Grove GMK7550 Product Guide Features 450 t (550 USt) capacity. m (197 ft) five-section boom. 25 m - 79 m (82 ft - 259 ft) lattice luffing jib t (264,500 lb) counterweight with hydraulic installation/removal system
Features MEGATRAK The MEGATRAK suspension system is the best off-road driveline available on the market today. The system s versatility and performance allows the GMK7550 to operate as a true all-terrain crane. The MEGATRAK independent suspension and all-wheel steer system allows wheels to remain on the ground at all times so stresses and weight are not continually transferred between axles. MEGATRAK provides true ground clearance where others just raise the chassis. Other benefits of the MEGATRAK system are: A reliable suspension system Excellent job site maneuverability with all-wheel steering Commonality among almost all models A driveline that remains aligned at all times A steering linkage system that is protected against damage Constant tire contact for equal tire wear Reduced maintenance TWIN-LOCK Boom pinning mechanism automatically pins the sections in position using two horizontal pins. ECOS Electronic Crane Operating System - ECOS enables control of the entire crane's principle operations. Simple programming eases lift planning and a supply of essential information allows full concentration on the lift itself. EKS 5 The EKS 5 monitors the lifting conditions of the crane at all times and provides a full graphic display, rear lighting, graphic of boom telescoping percentage, and load charts.
Contents Specifications 4 Dimensions 7 Counterweight 10 Travel proposals 11 Working range/load charts main boom 13 Working range/load charts luffing jib 18 Working range/load charts fixed jib 39 Working range/load charts heavy duty jib 47 Symbols glossary 55
Specifications Superstructure Boom 16 m - m (53 ft - 197 ft) five section, full power boom with patented TWIN-LOCK boom pinning system. Maximum tip height: 63 m (7 ft). Boom elevation Two lift cylinders with safety valves provide boom angles from -1.2 to +82. *Lattice jib Luffing jib is a lattice design with lengths of 25 m - 79 m (82 ft -259 ft) in sections of 6,2 m ( ft) and 12,2 m ( ft). The luffing jib converts to a fixed offset lattice jib providing lengths of 12 m - m (39 ft - ft) offsettable at 3 and 25. Load moment and anti-two block system Graphic display load moment and anti-two block system with audio/visual warning and control lever lockout. These systems provide electronic display of boom angle, length, radius, tip height, relative load moment, maximum permissible load, load indication and warning of impending two-block condition. Cab All aluminum construction cab is tiltable (approximately ) and includes safety glass and adjustable operator s seat. Other features include engine independent hot water heater including 24 hour timer, air conditioning, armrest integrated crane controls, and ergonomically arranged instrumentation. Cab hydraulically stows to the rear of the superstructure for highway travel. Counterweight t (264,500 lb) consisting of various sections with hydraulic installation/removal system (see counterweight configuration on page 10). Engine Mercedes OM6LA, diesel, 6 cylinders, water cooled, turbocharged, 5 kw (279 hp) at 0 rpm. Max. torque: 0 Nm (811 ft/lb) at 1 rpm. Engine emission: EUROMOT/EPA/CARB (off highway). 300 L (79 gal). Fuel tank capacity Hydraulic system Five separate circuits, Three axial piston variable displacement pumps with electronic power limiting control, 1 axial piston variable displacement pump for slewing and 1 fixed displacement pump for auxiliary gears. Standard thermostatically controlled oil coolers keep oil at optimum operating temperature. Tank capacity: 15 L (415 gal) Control system Full electronic control of all crane movements is accomplished using electrical control levers with automatic reset to zero. Controls are integrated with the LMI and engine management system by CAN-BUS. Electrical system 24 V system with three-phase alternator 28 V/ A 2 batteries 12 V/ Ah. Swing Three axial piston fixed displacement motors provide swing speed of 0-1.1 RPM thru planetary gear box. Also provided is a spring applied, hydraulically released automatic swing brake with foot operated release for free swing. 4 *Denotes optional equipment
Specifications Superstructure continued Carrier Hoist Main and auxiliary hoist are powered by axial piston variable displacement motor with planetary gear and brake. Thumb-thumper hoist drum rotation indicator alerts operator of hoist movement. Line length Main Auxiliary 4 m (9 ft) Auxiliary 6 m (2264 ft) Rope diameter 24 mm 24 mm Line speed Line pull m/min (427 fpm) kn (24,729 lb) Hoist cameras and lights included. m/min (427 fpm) 104 kn (23,3 lb) Chassis Special seven-axle carrier, welded torsion resistant frame is fabricated from high-strength steel. Outrigger system Hydraulic two-stage outrigger beams are extended by a single hydraulic cylinder and two cables. Outriggers can adjust to two positions: Fully extended (%) - 8,9 m (2 ft) Partially extended (50%) - 6,1 m ( ft) Four 810 mm x 810 mm (32 in x 32 in), self stowing, steel outrigger pads provide rigid lifting base. Outrigger controls are located on both sides of the carrier. Electronic level indicators with automatic levelling system. Outrigger pad load indication through ECOS and carrier controls. *Optional equipment Second spotlight on superstructure cab Stereo/CD player Lift enhancement system (MegaWingLift) Additional t (88, lb) counterweight for MegaWingLift Worklights on boom base section Aircraft warning lights Hook blocks Adapter for heavy duty jib 3 positive swing lock Engine Mercedes, diesel, 8 cylinders, water-cooled, turbocharged, 4 kw (563 hp) at 0 rpm. Max. torque: Nm (1991 ft lb) at 0 rpm. Engine emission: EUROMOT/EPA/CARB (off-highway). 500 L (132 gal). Fuel tank capacity Transmission Allison automatic SP-R, seven forward and one reverse speed. Transfer case with two speeds and inter-axle differential lock. Hydraulic transmission retarder 14x6x14 Drive/steer Grove GMK7550 *Denotes optional equipment 5
Specifications Carrier continued Axles Seven axles. 1, 4 and 5 are drive/steer. Axles 2, 3, 6 and 7 are steer only. Suspension GMK7550 features the Grove exclusive MEGATRAK suspension. This revolutionary design features an independent hydroneumatic system with hydraulic lockout acting on all wheels. The suspension can be raised mm (6-1/2 in) or lowered mm 5 in) both longitudinally and transversely and features an automatic leveling system for on-highway travel. Tires 14 tires, 0 R25. Steering Dual circuit steering system is hydraulic power assisted with emergency steering pump. Axles 1, 2, 3, 6 and 7steer on highway. Separate steering of the 4th, 5th,6th and 7th axles for all wheel steer and crab-steer, controlled by an electric rocker switch. Brakes A dual circuit air system operates on all wheels with a spring-applied, air released parking brake acting on axles 2, 4, 5 and 7. An air dryer is fitted to remove moisture from the air system. Standard engine compression brake and transmission retarder. Electrical system 24 V system with three-phase alternator 28 V/ A, 2 batteries 12 V/ Ah. Maximum speed 85 km/h (53 mph) with.5 R25 tires. Gradeability (theoretical) 32% with.5 R25 tires (14x6x14) 50% with.5 R25 tires (14x8x14) Miscellaneous standard equipment Boom removal kit; trailing boom kit (less dolly), additional hydraulic oil cooler; removable rear outrigger box; tool kit; fire extinguisher; radio/cd player in carrier cab. *Optional equipment 14 x 8 x 14 (1,2,4 and 5 are drive/steer) Engine-independent hot water heater, with engine pre-heater 14 tires, 0 R25 (385/95 R25) 14 tires,.5 R25 (525/ R25). Vehicle width 3,1 m ( ft) Aluminum rims Auxiliary axle, pinned when rear outrigger box is removed Hinged bunk bed Working range limiter Reversing camera system Engine shutdown valves (for both engines) Cab Two-man, aluminum construction driver s cab includes the following features: safety glass; driver seat with pneumatic suspension, engine-dependent hot water heater and air conditioning. Complete instrumentation and driving controls. 6 *Denotes optional equipment
Dimensions 19 622 (64' - 5") 297 (12") 284 (11") 710 (2' - 4") 0 (5' - 5" ) 10 (3' - 7") 14 Shown with 8th axle R 16 427 (53' - 11") R 14 548 (47' - 9") (9' - 2" ) R 63 (' - 11") 10' 2" (.5 tires) 9' - 10" ( tires) 39 13' - 1") 1893 (6' - 3") 2648 (8' - 8") 0 (5' - 5") 0 (5' - 5") 3000 (9' - 10") 15 788 (51' - 10") 0 (5' - 5" ) 17 (5' - 9") 0 (8' - 1") 2216 (7' - 3") 3085 (10' - 1" ) 82 (52' - 9" ) 3985 (13' - 1") 0 (5' - 9" ) 15788 (51' - 10" ) 87 (28' - 9" ) 39 (12' - 11") 5500 (18' - 1" ) 6 (') (29' - 2") Grove GMK7550 7
Dimensions Luffing jib combinations Without angle offset 79 m (259 ft) K I J A C E E G D F B B D H 73 m (2 ft) K I J A C E E G D F B D H I J 67 m ( ft) K A C E E G D F D H I J 61 m ( ft) K A C E E G D F B H I J K 55 m ( ft ) 49 m (161 ft) K A C E E G D F J A E E G D F H H A B Description Foot Section Short intermediate sections, small crosssection, each Length x width x height m (ft) 8. x 1. x 2.50 (28.87 x 5. x 8.) 6. x 1.50 x 1.500 (.34 x 4.91 x 4.91) Weight in kg (lb) 30 (8 0 (1985) 43 m (141 ft) K A C I E J E G F H C D Short intermediate sections, large crosssection, each Long intermediate sections, small crosssection, each 6. x 1. x 1. (.34 x 5. X 6.23) 12. x 1.50 x 1.50 (.03 x 4.91 x 4.91) 0 (5) 0 (3530) 37 m (121 ft) K A E I E G F H E F Long intermediate sections, large crosssection, each Angle piece 12. x 1. x 1. (.03 x 5. x 6.23) 102 ft (31 3. m) x 1.50 x 1. (12.14 x 4.91 x 5.) 0 (3530) 0 (3530) 31 m (102 ft) 25 m (82 ft) K K A A C E J I J E G F G F H H G H I J K Reducing piece Head piece Rear pendant link for short intermediate section Rear pendant link for long intermediate section Luffing control arm with fall-back guard strut 1. x 1. x 1. (3.94 x 5. x 6.23 ) 3. x 1.50 x 2.10 (10.50 x 4.91 x 6.89 ) 6. x 0. x 0. (.34 x 0. x 0.) 12. x 0. x 0. (.03 x 0. x 0. ) 12. x 2.10 x 1. (.03 x 6.89 x 5.) 500 (5) 1 (2650) (4) 0 (8) 3 (*55) 8 *Individual weight of rear pendant link: 3 kg (795 lb)
Dimensions Lattice boom extension combinations Without angle offset m ( ft) A C E E G F D D H 64 m ( ft ) A C E E G F B D H 58 m ( ft) A C E E G F D H 52 m ( ft) A C E E G F B H 46 m (151 ft) A C E E G F H 42 m (138 ft) A C E E G H 36 m (118 ft) A E E G H Description Length x width x height m (ft) Weight in kg (lb) 30 m (98 ft) A C E G H A B Foot Section Short intermediate sections, small crosssection, each 8. x 1. x 2.50 (28.87 x 5. x 8. ) 6. x 1.50 x 1.50 (.34 x 4.91 x 4.91) 30 (8) 0 (1985) 24 m (79 ft) A E G H C Short intermediate sections, large crosssection, each 6. x 1. x 1. (.34 x 5. X 6.23) 0 (5) 18 m (59 ft ) 12 m (39 ft ) A C G H A G H D E F Long intermediate sections, small crosssection, each Long intermediate sections, large crosssection, each Angle piece 12. x 1.50 x 1.50 (.03 x 4.91 x 4.91) 12. x 1. x 1. (.03 x 5. x 6.23) 3. x 1.50 x 1. (12.14 x 4.91 x 5.) 0 (3530) 0 (3530) 0 (3530) G Reducing piece 1. x 1. x 1. (3.94 x 5. x 6.23 ) 500 (5) H Head piece 3. x 1.50 x 2.10 (10.50 x 4.91 x 6.89 ) 1 (2650) Grove GMK7550 9
Counterweight 1 18'- 1" R18' 4" R18' 4" 8' 8' - 3" 6' - 9" 9' - 4" 2 3 R18' 4" 8' 8' - 11" 8' - 11" 8' - 11" 4 5 R18' 4" R18' 4" 8' - 11" 6' - 5" 6' - 5" 1 2 3 4 5 Thousand lb 22.0 22.0 22.0 22.0 x 88.1 x x x 132.2 x 2 x 2 x 176 x 3 x 3 x.4 x 4 x 4 x 264.5 x 4 x 4 x x x 308.6 x 4 x 4 x 2 x 2 x 352.7 x 4 x 4 x 3 x 3 x 10
Travel proposals Trailing boom dolly with 8th axle 26 356 (86' 6") 16 561 (54' 4" ) 12 500 (41') 5 (6' 3") 1 (5' 5") 1 (5' 5") 2997 (9' 10") 1 (5' 5") 2438 (8') 1 (5' 5") 1891 (6' 2") 4562 (15') 1384 1384 (54.5") (54.5") Boom in dolly over rear, rear outrigger box removed, 8th axle installed Axles 1-3 Axles 4-8 Dolly Total GVW kg (57,879 lb) 38 388 kg (84,631 lb) kg (59, lb 91 464 kg,64 lb Unit equipped with:.5 tires on aluminum rims - axles 1 through 8 Operator, 75 kg ( lb) Welded on MEGAWINGLIFT hardware Dolly weight: kg lb Allow % variation in weight due to manufacturing tolerances Boom removed, superstructure over rear 15 799 (51' 10") 19 761 (64' 10") 5 (6' 3") 1 (5' 5") 1 (5' 5") 2997 (9' 10") 1 (5' 5") 2438 (8') 1 (5' 5") 1092 (3' 7") 3962 (13') Boom removed, superstructure over rear Axles 1-3 Axles 4-7 Total GVW 16 717 kg (36,855 lb) 34 879 kg (76,895 lb) 51 597 kg (113,750 lb) Unit equipped with: Rear outrigger box removed.5 tires on aluminum rims Operator, 75 kg ( lb) Allow 3% variation in weight due to manufacturing tolerances Grove GMK7550 11
Travel proposals Boom over front 1 (5' 5") 1 (5' 5") 2997 (9' 10") 1 (5' 5") 2438 (8') 1 (5' 5") Boom over front, rear outrigger box removed Boom over front, rear outrigger box installed Boom over front, 8th axle installed Axles 1-3 Axles 4-7/8 Total GVW 37 724 kg (83,167 lb) 33 762 kg (74,431 lb) 43 562 kg (96,038 lb) 47 502 kg (104,722 lb) 58 193 kg (128,292 lb) 44 000 kg (97,003 lb) 85 226 kg (187,889 lb) 91 955 kg (2,723 lb) 87 563 kg (193,041 lb) Unit equipped with:.5 tires on aluminum rims Operator, 75 kg ( lb) Welded on MEGAWINGLIFT hardware Allow 3% variation in weight due to manufacturing tolerances Trailing boom (spread dolly) with axles 3 and 6 raised 26 356 (86' 6") 12 500 (41') 5 (6' 3") 1 (5' 5") 1 (5' 5") 2997 (9' 10") 1 (5' 5") 2438 (8') 1 (5' 5") 1891 (6' 2") 4242 (13' 11") 2 (67") 3797 (12' 6") Boom in dolly over rear, rear outrigger box removed, 8th axle installed, axles 3 and 6 raised Axles 1-2 Axles 4, 5, 7, 8 23 899 kg (52,689 lb) 743 kg (89,821 lb) Dolly 27 485 kg (,594 lb) Total GVW 92 127 kg (3,104 lb) Unit equipped with:.5 tires on aluminum rims - axles 1 through 8 Operator, 75 kg ( lb) Welded on MEGAWINGLIFT hardware 3 axle dolly ( 4563 kg (10,000 lb]) Allow 3% variation in weight due to manufacturing tolerances 12
Working range Main boom 197 ft main boom H [ft] 197' 179' 163' 148' 132' ' 116' ' 89' 84' 68' 53' Height from the ground in feet 50 30 82 MAX BOOM ANGLE 10 0 50 30 10 0 R[ft] Operating radius in feet from axis of rotation Hook heights shown in the working diagram do not consider loaded boom deflection. Grove GMK7550 13
Load charts Main boom 16,0 m - m (53 ft - 197 ft) 000 kg (264,500 lb) (%) 3 Feet 52.6 6 84.3 88.9.1.9.1 131.7 147.6 163.4 17 196.9 8 *0.0 10 6 624.0 15 538.0 536.0 496.0 300.0 438.0 442.0 438.0 300.0 410.0 3 284.0 25 3.0 3 3 300.0 3 3 2 2 30 3 3.0 3.0 298.0 3 3 232.0 228.0 4.0 1 35 276.0 2.0 2.0 2.0 2 2 6.0 7.0 186.0 1 1 242.0 2 2 238.0 2 2 187.0 186.0 1.0 141.0 1 45.0 2 21 2.0.0 1 142.0 131.0 11 50 194.0 196.0 1.0 193.0 1.0 141.0 131.0 122.0 1 55 176.0.0 1 1 143.0 1 12 121.0 1 105.0 1 1 1 1 132.0 136.0.0 111.0 106.0 98.0 65 1 136.0 1 142.0 121.0 128.0 111.0 104.0 98.0 92.0 131.0 122.0.0 127.0 111.0 11 102.0 97.0 92.0 86.0 75 10 1 1 104.0 113.0 96.0.0 87.0.0 106.0 104.0 95.0 107.0.0 83.0 76.0 85 97.0 94.0 86.0 98.0 84.0 87.0.0 71.0 67.0 95 84.0.0.0 64.0 76.0 66.0 64.0.0 105.0.0 66.0 43.4 41.4 43.4 41.2.6 38.6 37.6 38.2 36.0 35.8 33.6 33.8 31.4 31.6 29.4 27.6 25.8 24.2 Loads > 4,000 lb can only be lifted with additional equipment * Over rear, ft outrigger span, with special equipment 16,0 m - m (53 ft - 197 ft) 000 kg (,0 lb) (%) 3 Feet 52.6 6 84.3 88.9.1.9.1 131.7 147.6 163.4 17 196.9 8 *788.0 10 664.0 624.0 15 526.0 524.0 496.0 300.0 428.0 432.0 432.0 300.0 410.0 3 284.0 25 3.0 364.0 364.0 300.0 3 3 2 2 30 308.0 3 3 298.0 310.0 3 232.0 228.0 4.0 1 35 264.0 2 2 2 2 2.0 6.0 7.0 186.0 1 1 228.0 232.0 236.0 226.0 236.0 234.0 187.0 186.0 1.0 141.0 1 45 6.0 8.0 196.0 7.0 5.0.0.0 1 142.0 131.0 11 50.0 183.0 1 183.0.0 1.0 141.0 131.0 122.0 1 55 1.0 1.0 143.0 1 12 121.0 1 105.0 13.0 13 136.0 127.0 136.0.0 111.0 106.0 98.0 65 1.0 1.0 111.0 124.0 111.0 104.0 98.0 92.0.0 108.0 10 10 98.0 111.0 102.0 97.0 92.0 86.0 75 96.0 98.0 102.0 87.0 9 94.0.0 87.0.0 8 93.0.0.0 88.0 83.0 76.0 85 84.0 83.0 77.0.0 76.0 71.0 71.0 67.0 95 71.0 67.0 67.0.0 64.0 64.0.0 105 43.8 42.4.4.6 41.2 39.4 37.4 37.6 36.4 34.6 34.6 34.0 32.0 32.0 31.6 2 2 29.4 27.2 27.4 25.4 23.4 23.4 21.6.0 1 Loads > 4,000 lb can only be lifted with additional equipment * Over rear, ft outrigger span, with special equipment 14 THIS CHART IS ONLY A GUIDE AND SHOULD NOT BE USED TO OPERATE THE CRANE. The individual crane s load chart, operating instructions and other instructional plates must be read and understood prior to operating the crane
Load charts Main boom 16,0 m - m (53 ft - 197 ft) 000 kg (176,300 lb) (%) 3 Feet 52.6 6 84.3 88.9.1.9.1 131.7 147.6 163.4 17 196.9 8 10 6 624.0 15 5 5 496.0 300.0 4 4.0 4.0 300.0 410.0 3 284.0 25 3 3 3 300.0 3 3 2 2 30 294.0 298.0 298.0 2.0 300.0 296.0 232.0 228.0 4.0 1 35 2 2 2 2 2 242.0 6.0 7.0 186.0 1 1 3.0 213.0 2 6.0.0 3.0 187.0 186.0 1.0 141.0 1 45 176.0.0.0 1 1.0 1 1 142.0 131.0 11 50 1 1 143.0 1 1 138.0.0 13 131.0 122.0 1 55 131.0 12 131.0 133.0 11 131.0 121.0 11 1 105.0.0 1 1 1 107.0.0 1 105.0 105.0 98.0 65 103.0 98.0.0 105.0 98.0 102.0 102.0 96.0 94.0 92.0 91.0 91.0 94.0 93.0 87.0.0 92.0 8 83.0 75 83.0 84.0 84.0 77.0 76.0.0 77.0 73.0.0 85 66.0.0 95 105 43.4 43.6 43.2 41.4 39.4 41.0 37.8 36.0 36.2 36.4 34.6 32.8 33.0 33.6 31.8 30.0 31.0 2 27.2 27.4 26.8 24.8 25.0 24.6.4.6.8 11.0 9.8 Loads > 4,000 lb can only be lifted with additional equipment 16,0 m - m (53 ft - 197 ft) 000 kg (132, lb) (%) 3 Feet 52.6 6 84.3 88.9.1.9.1 131.7 147.6 163.4 17 196.9 10 634.0 624.0 15 500.0 500.0 496.0 300.0 6.0 410.0 410.0 300.0 8.0 3 284.0 25 336.0 3.0 3.0 300.0 338.0 3 2 2 30 2 276.0 2 2 2 2 226.0 228.0 4.0 1 35 5.0.0 21 8.0 2 19 1 194.0 1 1 1 1 171.0 1 1 1.0 1 1.0 143.0 141.0 1 45 141.0 1 142.0 1 1.0 136.0 133.0 127.0 121.0 1 50 1 124.0 11 126.0.0.0 11 1.0 104.0 101.0 55 106.0 107.0 10 108.0.0 106.0 101.0 96.0 91.0 88.0 92.0 93.0 95.0 94.0 88.0 94.0 8.0 65 83.0 84.0 83.0 71.0 71.0 71.0 67.0 75 64.0 66.0 66.0 67.0 66.0 64.0.0.0 85 41.0.0 95 43.6 43.2 41.8.0 37.0 36.2.2 3 37.8 36.0 33.4 32.6 105 35.6 34.2 32.4 30.2 29.4 33.2 32.2 30.8 2 27.2 26.6 2 27.8 26.0 24.2 24.0 23.4 21.6 21.6 22.8 21.0 1 1.6 14.8 13.0 13.4 11.2 11.4 11.8 9.8 9.8 8.2 7.0 7.0 5.8 4.6 3.6 Loads > 4,000 lb can only be lifted with additional equipment 16,0 m - 45 m (53 ft - 148 ft) 0 kg (0 lb) (%) 3 Feet 10 15 25 30 35 45 50 55 65 75 52.6 6 84.3 88.9.1.9.1 131.7 147.6 586.0 4.0 19 1 34.0 584.0 366.0.0 111.0 38.6 28.2.6 302.0 1 106.0.6 30.8 23.4 13.0 6.0 2 1 104.0 73.0 41.0 31.4 24.0 9.8 6.8 4.0 1 9 71.0.4 31.4 7.6 5.0.0.0 66.0 38.2 10.0 7.0 4.4 124.0 87.0 64.0 37.6 29.4 7.2 4.8.0 34.8 27.0.8 11.8 5.6.2 23.4 13.0 6.0 Grove GMK7550 THIS CHART IS ONLY A GUIDE AND SHOULD NOT BE USED TO OPERATE THE CRANE. The individual crane s load chart, operating instructions and other instructional plates must be read and understood prior to operating the crane 15
Working range With MegaWingLift 197 ft main boom 196.9' 17' 163.4' 147.6' Height from the ground in feet 131.7'.1'.9' 9 0 0 Operating radius in feet from axis of rotation Hook heights shown in the working diagram do not consider loaded boom deflection. 16
Load charts With MegaWingLift 35,3 m - m (116 ft - 197 ft) 000 kg (352,0 lb) (%) 3 Feet.9.1 131.7 147.6 163.4 17 196.9 25 30 35 45 50 55 65 75 85 95 105 3 324.0 298.0 2 242.0 222.0.0 1 166.0 1.0 12.0 111.0 104.0 97.0 2.0 2 242.0.0 21.0.0 167.0 1 141.0.0.0 1 104.0 97.0 91.0 86.0 73.0 330.0 310.0 2.0 2 2.0 21 197.0 1 166.0 1.0 12.0 111.0 104.0 97.0 91.0.0 71.0 298.0 2 2 226.0 2 193.0 1 1 1 13 128.0 11.0 103.0 96.0.0 84.0.0 67.0 222.0 211.0.0.0 1 1 1 1 138.0 127.0 1 10 102.0 95.0 8 83.0 73.0 213.0.0 186.0 1 164.0 1 1 138.0.0 124.0 1 108.0.0 93.0 87.0 77.0.0 43.6 3 167.0 1 1 142.0 134.0 127.0 121.0.0.0 104.0.0 96.0 91.0 87.0 77.0 64.0.0 41.4 3 36.8 33.8 35,3 m - m (116 ft - 197 ft) 000 kg (264,500 lb) (%) 3 Feet.9.1 131.7 147.6 163.4 17 196.9 25 30 35 45 50 55 65 75 85 95 105 3 324.0 298.0 2.0 236.0 8.0 1 167.0 1 137.0.0.0 104.0 94.0 86.0 2.0 2 242.0.0 21 4.0 186.0 167.0 1 138.0 126.0.0 105.0 95.0 87.0.0 330.0 310.0 2.0 2 232.0 6.0 186.0 167.0 1 138.0.0.0 104.0 95.0 86.0 73.0 67.0 298.0 2 2 226.0 2.0 1 166.0.0 137.0 124.0 1 103.0 93.0 66.0 222.0 211.0.0.0.0.0 1 136.0 1 1 102.0 92.0 84.0 77.0 71.0.0 41.4 38.6 213.0.0 186.0 1 164.0 1 1 134.0 122.0 111.0.0.0 42.8 36.8 34.2 31.8 2 27.6 167.0 1 1 142.0 134.0 127.0 121.0.0.0.0 91.0 83.0 76.0 64.0 43.0.0 37.2 34.4 32.0 27.6 25.8 22.2 Grove GMK7550 THIS CHART IS ONLY A GUIDE AND SHOULD NOT BE USED TO OPERATE THE CRANE. The individual crane s load chart, operating instructions and other instructional plates must be read and understood prior to operating the crane 17
Working range 82 ft - 2 ft luffing jib - 81 main boom 4 4 22 0 219.8' 0.1' 3.5' 3.8' 3 141.1' 239.5' 3 121.4' Height from the ground in feet 300 2 2 2 101.7' ' 17' 9.5' 9 0 300 2 2 2 0 Operating radius in feet from axis of rotation Hook heights shown in the working diagram do not consider loaded boom deflection. 18
Load charts 81 16,0 m + 2,9 m (52.6 ft + 9.5 ft) 25 m - 73 m (82 ft - 2 ft) 000 kg (264,500 lb) (%) 3 Feet 101.7 121.4 141.1.8.5.1 219.8 239.5 45 50 55 65 75 85 95 105 5 1.0 1 142.0 134.0 128.0 1 102.0 86.0.0 1.0 136.0 132.0 12.0 122.0 1 108.0 96.0 86.0 1 111.0 10 106.0 104.0 102.0 9 96.0 93.0 88.0.0 73.0 92.0 91.0 8 88.0 86.0 84.0 83.0.0 76.0 71.0 73.0.0 67.0 64.0 43.2 36.2 43.6 42.6 41.6.6 38.8 38.0 37.0 36.2 35.0 33.4 31.8 2 42.6 41.4.4 3 38.2 37.2 36.2 35.2 34.4 33.4 32.6 31.8 31.0 30.2 29.4 2 27.6 26.6 25.8 24.8 23.2 22.8 22.2 21.6 32.6 31.6 30.8 2 28.0 27.0 26.2 24.2 23.2 22.0 21.4.8.2 1 16.4 15.6 14.8 23.4 22.8 22.0 21.4.6.0 11.2 11.0 9.8 8.6 81 25,7 m + 2,9 m (84.3 ft + 9.5 ft) 25 m - 73 m (82 ft - 2 ft) 000 kg (264,500 lb) (%) 3 Grove GMK7550 Feet 101.7 121.4 141.1.8.5.1 219.8 239.5 45 50 55 65 75 85 95 105 5 1 1 137.0 12 122.0 1 1 107.0.0.0 1.0 1 1 113.0 111.0 10 105.0 98.0 87.0.0 9 98.0 97.0 95.0 93.0 92.0.0 8 88.0 87.0 67.0 77.0 76.0 73.0 71.0.0 64.0.0 43.6 42.2.6 THIS CHART IS ONLY A GUIDE AND SHOULD NOT BE USED TO OPERATE THE CRANE. The individual crane s load chart, operating instructions and other instructional plates must be read and understood prior to operating the crane. 19 43.2 42.2 41.4.6 39.8 3 38.0 37.4 35.8 35.2 34.4 33.6 33.0 32.4 31.8 3 37.6 36.8 36.0 35.0 34.2 33.6 32.8 32.0 31.2 2 27.8 27.2 26.4 25.8 25.0 24.2 23.4 22.8 22.4 22.0 21.4 21.0 2 27.8 26.8 26.0 25.0 23.2 22.0 21.4 21.0.4.0 1 21.0.4.0 14.8 11.2 9.8 8.6
Load charts 81 35,3 m + 2,9 m (.9 ft + 9.5 ft) 25 m - 73 m (82 ft - 2 ft) 000 kg (264,500 lb) (%) 3 Feet 101.7 121.4 141.1.8.5.1 219.8 239.5 45 50 55 65 75 85 95 105 5 2 1 113.0 107.0 102.0 97.0 93.0 8 9 9 95.0 92.0 88.0 84.0.0 77.0 67.0 64.0.0.0.0 77.0.0 67.0.0 64.0 64.0.0 43.6 43.0 42.4 41.8 41.2.6.2.4 39.8 3 38.8 38.2 37.6 37.2 36.0 35.6 35.0 34.4 33.8 33.4 32.8 32.4 31.8 31.2 30.8 30.2 2 28.8 32.0 31.6 31.2 30.2 2 2 28.2 27.6 27.2 26.6 26.0 24.6 24.0 23.6 22.2 21.8 21.4 21.0.6.2 19.8 23.4 22.2 21.6 21.2.8.4.0 1 16.4 15.6 14.8 1 12.2 11.8 11.4 11.2 9.8 8.8 8.2 81 45,0 m + 2,9 m (147.6 ft + 9.5 ft) 25 m - 73 m (82 ft - 2 ft) 000 kg (264,500 lb) (%) 3 Feet 101.7 121.4 141.1.8.5.1 219.8 239.5 55 65 75 85 95 105 5 2 86.0 83.0 71.0.0 67.0.0 43.0 41.8.4 42.6 41.2.0 38.8 37.6 36.4 35.4 34.4 37.2 37.2 37.2 37.0 36.8 36.4 36.2 36.0 35.8 35.4 35.2 35.0 34.6 33.8 33.2 32.4 31.8 31.0 30.2 2 29.4 2 2 28.8 28.2 28.0 27.8 27.6 27.2 27.0 26.8 26.4 26.0 25.6 25.4 25.0 24.6 24.0 23.2 23.2 23.2 22.8 22.4 22.2 22.0 21.6 21.4 21.2.8.6.4.0 19.8 1 1 1 16.4 15.6 14.8 13.0 12.2 11.8 13.4 13.0 12.2 11.8 11.4 11.0 10.4 10.0 9.8 9.4 8.6 8.2 8.0 7.8 7.6 7.4 THIS CHART IS ONLY A GUIDE AND SHOULD NOT BE USED TO OPERATE THE CRANE. The individual crane s load chart, operating instructions and other instructional plates must be read and understood prior to operating the crane.
Load charts 81 49,8 m + 2,9 m (163.4 ft + 9.5 ft) 25 m - 73 m (82 ft - 2 ft) 000 kg (264,500 lb) (%) 3 Feet 101.7 121.4 141.1.8.5.1 219.8 239.5 65 75 85 95 105 5 2 255 67.0 64.0 43.4 43.2 41.8.6 3 38.0 36.8 35.8 37.0 37.0 37.0 37.0 37.0 37.0 37.0 37.0 35.8 34.8 34.0 33.0 32.0 31.0 30.0 2 2 2 2 2 2 2 2 2 2 2 28.8 28.2 27.8 27.4 27.0 26.2 25.4 24.8 23.6 23.6 23.4 23.2 23.2 22.8 22.4 22.2 22.0 21.8 21.8 21.6 21.4 21.2 21.0.6.4 1 1 1 1 1 16.4 15.6 13.4 13.0 12.2 11.8 11.4 11.4 11.2 11.0 10.4 10.4 10.0 9.8 9.4 9.4 8.8 8.6 8.2 8.0 7.8 7.6 7.4 7.2 7.0 7.0 6.8 6.6 6.4 6.2 81 54,6 m + 2,9 m (17 ft + 9.5 ft) 25 m - 73 m (82 ft - 2 ft) 000 kg (264,500 lb) (%) 3 Feet 101.7 121.4 141.1.8.5.1 219.8 239.5 75 85 95 105 5 2 255 2 43.2 41.8.4 3 37.8 36.4 36.2 35.2 34.0 33.0 32.0 31.0 30.0 2 2 27.4 26.6 25.8 THIS CHART IS ONLY A GUIDE AND SHOULD NOT BE USED TO OPERATE THE CRANE. Grove GMK7550 The individual crane s load chart, operating instructions and other instructional plates must be read and understood prior to operating the crane. 21 23.6 23.4 23.2 22.4 21.8 21.2.4 1 1 1 1 1 1 14.8 14.8 13.4 13.4 13.0 13.0 11.4 11.4 11.2 11.2 11.0 11.0 10.4 10.4 10.0 10.0 9.8 9.4 8.8 8.2 8.2 8.0 8.0 7.8 7.8 7.6 7.6 7.4 7.4 7.2 7.2 7.0 6.8 6.8 6.6 6.6 6.4 6.2 6.2 6.0 5.8 5.8 5.6 5.6 5.4 5.2
Working range 82 ft - 2 ft luffing jib - main boom Height from the ground in feet 4 0 3 3 3 3 300 2 2 2 22 0 219.8'.1'.5'.8' 141.1' 121.4' 101.7' ' 239.5' 17' 9.5' 0 300 2 2 2 0 Operating radius in feet from axis of rotation Hook heights shown in the working diagram do not consider loaded boom deflection. 22
Load charts 16,0 m + 2.9 m (52.6 ft + 9.5 ft) 25 m - 73 m (82 ft - 2 ft) 000 kg (264,500 lb) (%) 3 Feet 101.7 121.4 141.1.8.5.1 219.8 239.5 65 75 85 95 105 5 2 1 142.0 134.0 128.0.0 1 104.0.0 11 1 105.0 98.0 92.0 86.0.0 97.0 91.0.0 76.0.0 77.0 71.0 67.0 64.0 64.0 43.2.0 43.6 42.6 41.6.6 38.8 38.0 37.0 36.2 35.4 34.6 34.0 33.0 31.4 34.4 33.4 32.6 31.8 31.0 30.2 29.4 28.8 28.0 27.2 26.4 25.6 24.8 24.0 23.2 22.2 21.6 25.4 23.4 22.0 21.4.8.2 19.8 1 16.4 15.6 15.6 11.2 9.8 8.6 75,7 m + 2,9 m (84.3 ft + 9.5 ft) 25 m - 73 m (82 ft - 2 ft) 000 kg (264,500 lb) (%) 3 Feet 101.7 121.4 141.1.8.5.1 219.8 239.5 75 85 95 105 5 2 255 1.0 104.0 97.0.0 96.0 8 84.0.0 66.0 8 83.0 73.0 64.0 43.6 43.2 41.4 38.0 36.4 42.4 41.6.8 39.8 3 38.2 37.6 36.8 36.0 35.2 34.6 33.8 33.2 32.6 31.8 30.4 31.4 30.8 30.0 29.4 28.0 27.2 26.4 25.6 24.8 24.0 23.6 22.4 22.0 21.6 21.0.6 22.8 22.2 21.6 21.0.4.0 1 14.8 11.2 11.0 10.0 9.4 8.8 Grove GMK7550 THIS CHART IS ONLY A GUIDE AND SHOULD NOT BE USED TO OPERATE THE CRANE. The individual crane s load chart, operating instructions and other instructional plates must be read and understood prior to operating the crane. 23
Load charts 35,3 m + 2,9 m (.9 ft + 9.5 ft) 25 m - 73 m (82 ft - 2 ft) 000 kg (264,500 lb) (%) 3 Feet 101.7 121.4 141.1.8.5.1 219.8 239.5 85 95 105 5 2 255 2 265 66.0 64.0 42.8 41.6 43.0 41.6.4 3 38.0 37.0 36.0 35.0 43.0 41.6.4 3 37.8 36.8 35.6 34.6 33.6 32.8 31.6 30.4 2 36.8 36.8 35.8 34.8 34.0 33.0 32.0 31.2 30.2 29.4 27.8 27.0 26.0 25.0 24.0 27.8 27.4 26.8 26.2 25.6 25.0 24.2 23.6 23.2 22.8 22.4 22.0 21.6 21.0.6.2 19.8 1.2 1 1 16.4 13.4 14.8 13.4 13.0 12.2 11.2 11.0 10.4 10.0 9.8 9.4 8.8 8.6 8.0 45,0 m + 2,9 m (147.6 ft + 9.5 ft) 25 m - 73 m (82 ft - 2 ft) 000 kg (264,500 lb) (%) 3 Feet 101.7 121.4 141.1.8.5.1 219.8 239.5 95 105 5 2 255 2 265 2 275 2 42.0.2 42.0.4 3 37.6 36.4 35.2 34.0 33.0 36.8 35.6 34.4 33.2 32.0 31.0 30.0 2 28.2 27.4 32.0 30.8 28.8 27.8 27.0 26.0 25.4 24.8 24.0 23.4 22.8 28.8 27.8 26.8 25.8 25.0 22.4 21.6 21.0.4 19.8 24.6 24.2 23.4 21.8 21.0.4 1 1 21.4 21.2.8.2 1 1 15.6 16.4 15.6 14.8 13.4 13.0 12.2 11.8 11.4 11.2 11.8 11.8 11.4 11.2 11.0 10.0 9.8 9.4 8.8 8.6 8.2 8.0 7.8 7.6 7.2 7.0 24 THIS CHART IS ONLY A GUIDE AND SHOULD NOT BE USED TO OPERATE THE CRANE. The individual crane s load chart, operating instructions and other instructional plates must be read and understood prior to operating the crane.
Load charts 49,8 m + 2,9 m (163.4 ft + 9.5 ft) 25 m - 73 m (82 ft - 2 ft) 000 kg (264,500 lb) (%) 3 Feet 101.7 121.4 141.1.8.5.1 219.8 239.5 5 2 255 2 265 2 275 2 285 3 37.6 36.2 35.0 33.8 35.2 33.8 32.6 31.6 30.4 29.4 2 27.6 2 27.6 26.6 25.8 25.0 23.6 25.4 24.6 24.0 23.2 22.4 21.6 21.0.2 1 1 22.2 21.4.6.0 1 15.6 13.4 13.0 15.6 13.4 13.0 12.2 11.2 10.4 10.0 9.8 9.4 13.4 11.2 10.4 10.0 9.4 8.6 8.2 8.0 7.6 7.4 7.0 9.4 8.8 8.6 8.2 8.0 7.8 7.6 7.2 7.0 6.8 6.6 6.2 6.0 5.8 5.4 54,6 m + 2,9 m (17 ft + 9.5 ft) 25 m - 73 m (82 ft - 2 ft) 000 kg (264,500 lb) (%) 3 Feet 101.7 121.4 141.1.8.5.1 219.8 239.5 5 2 255 2 265 2 275 2 35.0 33.6 32.4 31.2 30.2 28.8 27.6 26.8 25.8 23.6 25.0 23.4 21.8 21.2.4 19.8 1.6 19.8 1 1 15.6 15.6 13.0 12.2 14.8 12.2 11.2 10.4 10.0 8.8 11.4 11.0 10.0 8.6 8.2 7.8 7.4 7.2 6.8 6.6 9.8 9.4 8.6 8.0 7.6 7.2 7.0 6.6 6.2 6.0 5.6 5.4 5.2 4.8 4.6 7.6 7.6 7.4 7.4 7.2 7.0 6.6 6.4 6.0 5.8 5.4 5.2 4.8 4.6 4.4 4.0 3.8 3.6 THIS CHART IS ONLY A GUIDE AND SHOULD NOT BE USED TO OPERATE THE CRANE. Grove GMK7550 The individual crane s load chart, operating instructions and other instructional plates must be read and understood prior to operating the crane. 25
Working range 82 ft - 2 ft luffing jib - main boom Height from the ground in feet 3 3 300 2 2 2 22 0 219.8'.1'.5'.8' 141.1' 121.4' 101.7' ' 239.5' 147.6' 9.5' 30 0 3 300 2 2 2 0 Operating radius in feet from axis of rotation Hook heights shown in the working diagram do not consider loaded boom deflection. 26
Load charts 16,0 m + 2,9 m (52.6 ft + 9.5 ft) 25 m - 73 m (82 ft - 2 ft) 000 kg (264,500 lb) (%) 3 Feet 101.7 121.4 141.1.8.5.1 219.8 239.5 95 105 5 2 255.0 94.0 88.0 93.0 87.0 77.0 73.0 76.0 64.0 67.0.0 43.2 41.4 39.8 41.6.6 38.8 37.8 37.0 36.2 35.4 34.6 33.8 33.2 30.2 29.4 28.0 27.2 26.4 25.4 23.2 22.0 21.6.8.2 1 16.4 14.8 11.2 9.8 8.6 25,7 m + 2,9 m (84.3 ft + 9.5 ft) 25 m - 73 m (82 ft - 2 ft) 000 kg (264,500 lb) (%) 3 Feet 101.7 121.4 141.1.8.5.1 219.8 239.5 95 105 5 2 255 2 265 2 275 77.0 64.0.0 43.4 41.6 42.4.4 38.6 37.0 35.4 34.0 37.8 36.2 34.6 33.2 31.8 29.4 28.2 37.0 35.4 33.8 32.4 31.0 27.4 26.2 24.2 23.4 28.0 27.4 26.8 26.0 25.4 24.8 22.4 21.8 21.0.2 1 1 11.2 11.0 10.0 8.8 8.2 Grove GMK7550 THIS CHART IS ONLY A GUIDE AND SHOULD NOT BE USED TO OPERATE THE CRANE. The individual crane s load chart, operating instructions and other instructional plates must be read and understood prior to operating the crane. 27
Load charts 35,3 m + 2,9 m (.9 ft + 9.5 ft) 25 m - 73 m (82 ft - 2 ft) 000 kg (264,500 lb) (%) 3 Feet 101.7 121.4 141.1.8.5.1 219.8 239.5 5 2 255 2 265 2 275 2 285 43.6 42.2.6 38.8 36.8 38.6 37.4 36.2 34.4 33.0 31.6 30.2 33.2 31.8 30.4 2 27.8 26.6 25.6 28.2 27.0 25.8 24.8 22.8 21.8 21.0.0 25.0 22.8 21.8 21.0.2 1 1 22.0 21.2.2 16.4 15.6 16.4 12.2 12.2 11.2 11.0 10.4 10.0 9.8 9.4 8.8 8.6 8.0 45,0 m + 2,9 m (147.6 ft + 9.5 ft) 25 m - 73 m (82 ft - 2 ft) 000 kg (264,500 lb) (%) 3 Feet 101.7 121.4 141.1.8.5.1 219.8 239.5 5 2 255 2 265 2 275 2 285 2 295 300 305 33.4 31.6 30.0 26.0 24.6 22.2 21.4.8.2 16.4 13.4 13.0 12.2 11.2 10.4 10.0 9.8 9.4 8.6 8.2 7.8 7.6 7.2 8.8 8.2 7.8 7.4 7.0 6.8 6.4 6.2 5.8 5.6 5.4 8.2 7.8 7.6 7.2 7.0 6.6 6.4 6.0 5.6 5.2 4.8 4.4 4.0 3.6 28 THIS CHART IS ONLY A GUIDE AND SHOULD NOT BE USED TO OPERATE THE CRANE. The individual crane s load chart, operating instructions and other instructional plates must be read and understood prior to operating the crane.
Load charts 49,8 m + 2,9 m (163.4 ft + 9.5 ft) 25 m - 61 m (82 ft - ft) 000 kg 264,500 lb (%) 3 Feet 101.7 121.4 141.1.8.5.1 5 2 255 2 265 2 275 2 25.4 24.8 24.0 23.2 21.2.6 19.8 1 16.4 14.8 13.4 13.0 11.2 11.4 11.0 9.8 9.4 8.6 8.8 8.0 7.6 7.2 6.8 6.6 6.2 6.0 5.6 7.6 7.2 6.8 6.4 6.0 5.8 5.4 5.2 4.8 4.6 4.2 4.0 3.8 54,6 m + 2,9 m (17 ft + 9.5 ft) 31 m - 49 m (102 ft - 161 ft) 000 kg (264,500 lb) (%) 3 Feet 101.7 121.4 141.1.8 5 2 14.8 11.8 11.4 10.0 8.8 8.0 7.4 7.0 6.6 6.4 6.0 5.8 THIS CHART IS ONLY A GUIDE AND SHOULD NOT BE USED TO OPERATE THE CRANE. Grove GMK7550 The individual crane s load chart, operating instructions and other instructional plates must be read and understood prior to operating the crane. 29
Working range With MegaWingLift 82 ft - 259 ft luffing jib - 81 main boom with MegaWingLift 0 4 4 0 3 3 22 239.5' 219.8'.1'.5'.8' Height from the ground in feet 3 3 300 2 2 2 141.1' 121.4' 101.7' ' 25' 17' 9.5' 9 0 300 2 2 2 0 Operating radius in feet from axis of rotation Hook heights shown in the working diagram do not consider loaded boom deflection. 30
Load charts With MegaWingLift 81 35,3 m + 2,9 m (,9 ft + 9.5 ft) 25 m - 79 m (82 ft - 259 ft) 000 kg (352,0 lb) (%) 3 Feet 101.7 121.4 141.1.8.5.1 219.8 239.5 25 50 55 65 75 85 95 105 5 2 255 2 141.0 136.0 12 122.0.0 10 105.0.0 97.0 107.0 107.0 107.0 107.0 107.0 107.0 107.0 105.0 102.0 98.0 93.0 84.0.0.8 41.4 37.6 33.2 37.0 34.0 30.8 33.0 33.0 33.0 33.0 33.0 33.0 33.0 33.0 33.0 33.0 33.0 33.0 32.8 32.2 31.6 2 28.0 27.2 26.8 26.2 25.8 25.4 24.8 24.6 26.2 26.2 26.2 26.2 26.2 26.2 26.2 26.2 25.8 25.4 24.8 23.2 22.8 22.2 21.8 21.4.8.4 19.8 1 1.6.6.6.6.6.6.6.6.4.0 1 16.4 15.6 13.0 12.2 81 45,0 m + 2,9 m (147.6 ft + 9.5 ft) 25 m - 79 m (82 ft - 259 ft) 000 kg (352,0 lb) (%) 3 Feet 65 75 85 95 105 5 2 255 2 265 11 113.0 10 106.0 103.0 102.0.0 98.0 93.0 101.7 101.0 98.0 94.0 91.0 8 87.0 84.0 121.4 76.0 71.0.0 64.0 141.1.0.8.5 43.8 43.6 43.2 42.6 42.2 41.6 41.0 37.0 THIS CHART IS ONLY A GUIDE AND SHOULD NOT BE USED TO OPERATE THE CRANE. The individual crane s load chart, operating instructions and other instructional plates must be read and understood prior to operating the crane. Grove GMK7550 31.1 36.4 33.6 30.2 219.8 30.4 2 28.8 28.0 27.4 26.6 26.2 25.8 25.4 25.0 24.6 239.5 24.2 23.4 22.0 21.6 21.2.8.4 19.8 1 1 25 1 1 1 1 1 1 1 1 1 1 1 16.4 15.6 13.4 12.2
Load charts With MegaWingLift 81 49,8 m + 2,9 m (163.4 ft + 9.5 ft) 25 m - 79 m (82 ft - 259 ft) 000 kg (352,0 lb) (%) 3 Feet 101.7 121.4 141.1.8.5.1 219.8 239.5 25 75 85 95 105 5 2 255 2 265 98.0 95.0 93.0 91.0 8 86.0 83.0 76.0 71.0 73.0.0 67.0 66.0 64.0.0.0.0.0.0 43.0 43.0 41.6.2 38.8 41.2 41.2 41.2 41.2 41.2 41.2 41.2 41.2 41.2 41.2 41.2 41.2 41.2.6 39.8 3 3 37.2 36.2 35.0 34.0 34.2 34.2 34.2 34.2 34.2 34.2 34.2 34.2 34.2 34.2 34.2 34.2 34.2 34.2 34.2 34.2 34.2 33.8 32.8 32.0 31.0 2 27.0 2 28.0 27.4 26.8 26.2 25.8 25.4 25.0 24.6 24.2 23.6 22.4 22.0 21.6 21.2.8.4.0 1 1 16.4 14.8 13.4 13.0 12.2 81 54,6 m + 2,9 m (17 ft + 9.5 ft) 25 m - 79 m (82 ft - 259 ft) 000 kg (352,0 lb) (%) 3 Feet 101.7 121.4 141.1.8.5.1 219.8 239.5 25 32 75 85 95 105 5 2 255 2 265 2 275.0 76.0 73.0 66.0.0 71.0.0 64.0 43.2 41.4 37.8 43.0 41.4 39.8 38.2 35.2 33.8 43.4 42.0.6 3 38.0 36.8 35.4 34.2 33.0 31.8 THIS CHART IS ONLY A GUIDE AND SHOULD NOT BE USED TO OPERATE THE CRANE. The individual crane s load chart, operating instructions and other instructional plates must be read and understood prior to operating the crane. 38.0 38.0 38.0 38.0 38.0 38.0 38.0 38.0 37.4 36.4 35.4 34.6 33.4 31.8 30.4 2 27.4 26.6 25.6 24.6 31.6 31.6 31.6 31.6 31.6 31.6 31.6 31.6 31.6 31.2 30.0 28.8 27.6 26.4 24.0 23.2 22.4 21.6.8.0 25.0 22.4 21.8 21.0.4 19.8 1 1.8.8.8.8.8.8.8.8.8.8.8.8.8.8.8.6.2 19.8 1 14.8 14.8 13.4 11.8
Working range With MegaWingLift 82 ft - 259 ft luffing jib - main boom with MegaWingLift 3 3 3 3 22 0 239.5' 219.8'.1'.5' 300.8' 25' Height from the ground in feet 2 2 2 141.1' 121.4' 101.7' ' 9.5' 131.7' 0 300 2 2 2 0 Operating radius in feet from axis of rotation Hook heights shown in the working diagram do not consider loaded boom deflection. Grove GMK7550 33
Load charts With MegaWingLift 34,3 m + 2,9 m (.9 ft + 9.5 ft) 25 m - 79 m (82 ft - 259 ft) 000 kg (352,0 lb) (%) 3 Feet 101.7 121.4 141.1.8.5.1 219.8 239.5 25 95 105 5 2 255 2 265 2 275 2 98.0 93.0 88.0 84.0.0 91.0 87.0 83.0 66.0 71.0.0 71.0.0 67.0 64.0.0.0 43.2 41.6 43.6 42.2.8 3 37.8.4.4.4.4.4.4.4.4.4 39.8 3 37.0 35.8 34.6 33.4 32.2 31.2 33.4 33.2 32.8 32.4 32.0 31.6 31.2 30.8 2 28.0 27.2 26.6 26.0 25.6 24.8 24.8 23.4 22.4 22.0 21.4 21.0.6.2 19.8 1 1 1 14.8 13.4 12.2 45,0 m + 2,9 m (147.6 ft + 9.5 ft) 25 m - 79 m (82 ft - 259 ft) 000 kg (352,0 lb) (%) 3 Feet 101.7 121.4 141.1.8.5.1 219.8 239.5 25 105 5 2 255 2 265 2 275 2 285 2 295 83.0 71.0 43.8 42.2 42.8 41.2 39.8 3 37.0 35.6 34.4 3 37.0 35.6 34.4 33.0 32.0 30.8 37.0 37.0 37.0 37.0 36.2 35.6 34.8 33.4 32.2 31.2 30.0 2 28.0 27.0 26.0 24.2 31.2 31.2 31.0 30.8 30.4 30.0 2 38.2 27.4 26.4 25.4 24.6 22.2 21.4 24.0 23.6 23.4 22.2 21.8 21.4 21.0.6.2 19.8 1 14.8 13.4 34 THIS CHART IS ONLY A GUIDE AND SHOULD NOT BE USED TO OPERATE THE CRANE. The individual crane s load chart, operating instructions and other instructional plates must be read and understood prior to operating the crane.
Load charts With MegaWingLift 49,8 m + 2,9 m (163.4 ft + 9.5 ft) 25 m - 79 m (82 ft - 259 ft) 000 kg (352,0 lb) (%) 3 Feet 101.7 121.4 141.1.8.5.1 219.8 239.5 25 5 2 255 2 265 2 275 2 285 2 295 300.0 67.0 64.0.0 43.6 42.0 43.2 42.2 41.2 39.8 3 37.2 35.8 42.2 41.6.8.8 3 38.0 35.4 34.0 32.8 31.6 35.2 35.2 35.2 35.2 35.0 34.6 34.0 33.6 32.8 31.6 30.4 29.4 2 27.4 32.0 31.6 31.2 30.4 30.0 2 2 2 27.4 26.4 25.4 24.6 22.8 22.0 21.2 2 28.2 27.8 27.4 27.0 26.6 26.4 26.0 25.6 25.0 23.2 22.4 21.6.8.0 22.4 22.2 22.0 21.6 21.4 21.0.8.4.0 1 1 16.4 16.4 14.8 13.4 13.0 12.2 54,6 m + 2,9 m (17 ft + 9.5 ft) 25 m - 79 m (82 ft - 259 ft) 000 kg (352,0 lb) (%) 3 Feet 101.7 121.4 141.1.8.5.1 219.8 239.5 25 5 2 255 2 265 2 275 2 285 2 295 300 305 310 43.8 42.2.6 3 37.4 41.4 39.8 3 37.0 35.6 34.4 33.0 31.8 37.2 36.0 34.6 33.4 32.2 31.0 2 28.0 26.2 25.0 24.0 34.6 33.6 32.6 31.4 2 27.8 26.6 25.8 25.0 24.2 23.4 21.8 28.0 26.6 25.8 25.0 24.2 23.4 22.8 22.0 21.4.6.0 1 22.4 21.6 21.0.4 19.8 1 15.6 22.4 21.8 21.2.6.0 15.6 1 15.6 11.2 11.2 9.8 9.4 8.6 Grove GMK7550 THIS CHART IS ONLY A GUIDE AND SHOULD NOT BE USED TO OPERATE THE CRANE. The individual crane s load chart, operating instructions and other instructional plates must be read and understood prior to operating the crane. 35
Working range With MegaWingLift 82 ft - 259 ft luffing jib - main boom with MegaWingLift 3 300 2 2 22 0 239.5' 219.8'.1'.5'.8' 25' 2 141.1' Height from the ground in feet 121.4' 101.7' '.9' 9.5' 30 0 300 2 2 2 0 Operating radius in feet from axis of rotation Hook heights shown in the working diagram do not consider loaded boom deflection. 36
Load charts With MegaWingLift 35,3 m + 2,9 m (.9 ft + 9.5 ft) 25 m - 79 m (82 ft - 259 ft) 000 kg (352,0 lb) (%) 3 Feet 101.7 121.4 141.1.8.5.1 219.8 239.5 25 5 2 255 2 265 2 275 2 285 2 295 300.0 43.4 41.6 43.6 42.0.4 38.8 37.4 36.0 39.4 37.8 36.4 35.0 33.8 32.6 31.4 35.0 33.6 32.4 31.2 30.0 2 27.8 26.8 26.0 30.2 2 28.0 27.0 26.0 25.0 24.2 23.4 22.4 21.6 27.2 26.2 25.4 23.6 21.8 21.0.4 1 21.4.8.4.0 1 1 13.4 13.0 45,0 m + 2,9 m (147.6 ft + 9.5 ft) 25 m - 79 m (82 ft - 259 ft) 000 kg (352,0 lb) (%) 3 Feet 101.7 121.4 141.1.8.5.1 219.8 239.5 25 5 2 255 2 265 2 275 2 285 2 295 300 305 310 315 3 42.6.8 3 37.6 38.2 35.2 34.0 32.6 31.4 35.0 33.6 32.4 31.2 30.0 28.8 27.8 2 27.8 26.8 25.8 24.8 24.0 25.6 24.8 22.8 22.0 21.2.4 22.0 21.0.2 14.8 13.4 11.8 11.4 10.4 13.0 11.8 11.4 10.4 9.8 9.4 8.6 8.0 7.6 Grove GMK7550 THIS CHART IS ONLY A GUIDE AND SHOULD NOT BE USED TO OPERATE THE CRANE. The individual crane s load chart, operating instructions and other instructional plates must be read and understood prior to operating the crane. 37
Load charts With MegaWingLift 49,8 m + 2,9 m (163.4 ft + 9.5 ft) 25 m - 79 m (82 ft - 259 ft) 000 kg (352,0 lb) (%) 3 Feet 101.7 121.4 141.1.8.5.1 219.8 239.5 25 5 2 255 2 265 2 275 2 285 2 295 300 305 310 315 3 325 330 43.6 41.8.4 38.8 37.2 35.6 34.2 34.6 33.2 32.0 30.8 2 2 30.2 2 28.0 27.0 26.0 25.0 24.0 26.4 25.4 23.6 21.8 21.0.2 22.8 22.0 21.2.2 1 16.4 13.4 12.2 15.6 12.2 11.0 12.2 11.0 8.8 8.2 7.8 10.0 8.6 8.2 7.8 7.2 6.8 6.4 6.2 5.8 5.4 54,6 m + 2,9 m (17 ft + 9.5 ft) 25 m - 79 m (82 ft - 259 ft) 000 kg (352,0 lb) (%) 3 38 Feet 5 2 255 2 265 2 275 2 285 2 295 300 305 310 315 3 325 330 335 3 38.0 36.4 34.8 101.7 33.4 32.2 31.0 121.4 2 27.8 25.8 24.6 23.6 141.1 23.2 22.4 21.6 21.0.2.8 21.8.8.0 THIS CHART IS ONLY A GUIDE AND SHOULD NOT BE USED TO OPERATE THE CRANE. The individual crane s load chart, operating instructions and other instructional plates must be read and understood prior to operating the crane..5 16.4.1 13.4 11.8 11.2 219.8 11.0 10.0 8.6 8.2 7.8 239.5 9.8 8.8 8.0 7.6 7.0 6.6 6.2 6.0 5.6 25 7.8 7.8 7.6 7.2 6.8 6.4 6.0 5.6 5.2 4.8 4.6 4.2 3.8 3.6 3.2
Working range 39 ft - ft boom extension H [ft] 430 4 410 0 25 3 ' ' 3 3 ' 3 3 171' 350 3 330 151' 138' 3 310 118' Height from the ground in feet 300 2 2 2 2 2 98' 79' 59' 39' 179' 163' 148' 132' 116' ' 84' 68' 53' 50 30 81 10 0 2 2 2 2 2 50 30 10 0 Operating radius in feet from axis of rotation R[ft] Hook heights shown in the working diagram do not consider loaded boom deflection. Grove GMK7550 39
Load chart 49,8 m (163.4 ft) 12 m - m (39 ft - ft) 000 kg (264,500 lb) (%) 3 Feet 163.4 Feet 39.4 59.1 78.7 9 118.1 137.8.9.6.3.0 229.7 3 3 3 3 3 3 3 25 3 25 3 25 3 25 3 25 45 105.0 50.0 87.0 55 96.0.0 83.0.0 66.0 65 77.0 41.6 75 85.0 66.0 64.0 43.6 42.0.4.0 38.6 37.2 35.8 33.8 32.6 31.4 28.2 27.0 26.0 24.8 25.6 23.6 23.4 21.6 1 95 105 5 2 255 2 265 2 275 2 285 43.6 41.0 38.6 34.6 32.6 26.6 25.0 21.2 16.4 41.8 39.8 38.0 36.0 34.2 32.4 2 27.4 26.0 22.8 21.2 16.4 43.0 41.4 37.8 36.0 34.2 32.6 30.8 2 27.4 25.6 23.4 22.4 21.4.2 1 11.8 3 37.8 35.2 34.0 32.8 31.6 30.4 2 28.0 26.8 25.8 25.0 24.0 23.2 22.2 21.2.4 10.4 9.4 34.4 33.4 32.2 31.2 30.0 28.8 27.6 26.4 24.2 23.6 22.4 21.6 21.0.4 19.8 1 1 11.4 10.4 9.4 7.4 6.6 5.8 2 26.8 25.8 25.0 24.2 23.4 22.4 21.8 21.2.4 19.8 1 13.4 12.2 8.6 7.8 7.0 6.0 5.2 4.4 3.8 3.0 22.0 21.2.4 16.4 14.8 13.4 11.4 11.0 10.0 8.6 7.6 6.8 5.8 5.0 4.0 3.2 2.6 21.8 21.0.2 15.6 11.2 11.0 10.0 8.8 8.0 7.2 6.2 5.2 4.4 3.6 2.8.8 19.8 1 1 15.6 13.4 13.0 11.2 10.4 10.0 8.6 8.0 7.8 7.4 7.2 6.8 6.6 6.2 5.6 4.8 4.0 3.2 2.4 16.4 12.2 11.8 11.4 11.0 9.8 8.8 8.6 8.2 8.0 7.8 7.4 7.2 7.0 6.8 6.4 6.2 6.0 5.8 5.4 4.8 4.0 3.2 2.4 14.8 13.0 11.0 9.8 9.4 8.6 8.0 7.8 7.4 7.2 6.8 6.6 6.2 6.0 5.8 5.6 5.4 5.2 4.8 4.6 4.4 3.8 3.0 2.2 12.2 11.8 11.2 10.4 10.0 8.8 8.6 8.2 8.0 7.6 7.2 7.0 6.8 6.6 6.2 6.0 5.8 5.6 5.4 5.2 5.0 4.8 4.6 4.4 4.2 3.8 3.6 3.4 3.2 2.6 14.8 11.0 8.8 8.0 7.8 7.4 7.0 6.8 6.4 6.0 5.8 5.6 5.4 5.0 4.8 4.6 4.2 4.0 3.8 3.6 3.4 3.4 3.2 3.0 2.8 2.4 10.4 10.0 8.6 8.0 7.6 7.2 7.0 6.6 6.4 6.0 5.8 5.6 5.2 5.0 4.8 4.6 4.4 4.2 4.0 3.8 3.6 3.4 3.2 3.0 2.8 2.6 2.6 13.0 11.4 11.0 8.8 8.2 7.8 7.4 7.0 6.6 6.4 6.0 5.6 5.4 5.2 4.8 4.6 4.2 4.0 3.8 3.6 3.4 3.2 3.0 2.8 7.4 7.0 6.6 6.4 6.0 5.8 5.4 5.2 4.8 4.6 4.4 4.0 3.8 3.6 3.4 3.2 3.0 2.8 2.6 THIS CHART IS ONLY A GUIDE AND SHOULD NOT BE USED TO OPERATE THE CRANE. The individual crane s load chart, operating instructions and other instructional plates must be read and understood prior to operating the crane.
Load chart 54,6 m (17 ft) 12 m - m (39 ft - ft) 000 kg (264,500 lb) (%) 3 Feet Feet 17 39.4 59.1 78.7 9 118.1 137.8.9.6.3.0 229.7 3 3 3 3 3 3 3 25 3 25 3 25 3 25 3 25 45 50 87.0 55 83.0.0.0 65 76.0 75 38.6 37.4 31.4 25.8 24.6 85 43.0 36.2 25.0 41.6 35.0 28.2 24.2 22.8.8 95.2 34.0 27.0 23.2 22.0.0 43.4 38.8 32.8 26.2 22.4 21.2 105 41.6 37.4 31.4 25.4 21.6.6 13.4 11.2 43.0 39.8 35.8 30.2 24.6.8 19.8 15.6 13.4 13.0 41.0 38.0 34.6 28.8 24.0.2 1 15.6 13.0 10.4 41.8 3 36.4 33.2 27.6 23.2 10.0 39.8 37.2 35.0 31.8 26.6 9.8 37.8 35.4 33.6 25.8 21.8 13.4 11.2 9.4 35.8 33.6 32.2 2 25.0 21.2 13.0 11.2 8.8 34.0 31.8 27.8 24.2.6 13.0 10.4 8.6 6.8 32.0 30.0 2 26.6 23.4.0 16.4 15.6 10.4 10.0 8.2 8.2 6.4 30.4 28.2 28.0 13.4 12.2 11.4 10.0 7.8 7.8 6.2 28.8 26.4 26.6 21.8 14.8 13.0 11.8 11.0 7.6 7.4 6.0 27.2 25.0 21.0 14.8 11.4 8.8 7.2 7.2 5.6 25.6 24.0 21.6.2 11.0 7.0 6.8 5.4 24.0 22.8 22.4.8 13.4 9.8 8.6 8.2 6.6 6.6 5.0 22.2 21.8 21.2.0 13.4 13.0 11.2 8.2 7.8 6.4 6.2 4.8 21.0.8.4 1 13.0 10.0 8.0 7.4 6.0 6.0 4.6 1 1 12.2 10.4 8.8 7.6 7.2 5.8 5.8 4.4 14.8 11.8 9.4 7.4 6.8 5.6 5.4 4.2 11.4 9.8 8.2 7.2 6.6 5.4 5.2 3.8 14.8 11.2 11.0 9.4 8.8 7.8 6.8 6.2 5.2 5.0 3.6 5 7.6 6.6 6.0 4.8 4.6 3.4 8.8 8.2 7.4 6.4 5.6 4.6 4.4 3.2 13.4 12.2 9.8 9.8 7.8 7.0 6.2 5.4 4.4 4.2 3.0 12.2 13.0 8.2 7.6 6.8 6.0 5.2 4.2 4.0 2.8 11.2 12.2 11.2 8.8 8.8 7.8 7.4 6.6 5.8 5.0 4.0 3.6 2.8 10.0 7.4 7.0 6.2 5.4 4.8 3.8 3.4 9.8 7.8 8.0 7.0 6.8 6.0 5.2 4.6 3.6 3.2 2 8.2 8.8 7.4 7.6 6.6 6.4 5.6 5.0 4.2 3.4 3.0 7.8 8.6 8.8 6.8 7.2 6.2 6.2 5.4 4.8 4.0 3.2 2.8 7.0 7.8 7.8 5.8 6.2 5.8 5.8 5.0 4.6 3.8 3.2 2.6 255 6.0 6.8 7.0 5.0 5.4 5.4 5.6 4.8 4.6 3.6 3.0 2.4 2 5.2 6.0 6.2 4.2 4.4 4.8 5.2 4.4 4.4 3.2 2.8 265 5.2 5.4 3.4 3.6 4.0 4.8 4.0 4.2 3.0 2.6 2 4.4 4.6 2.6 2.8 3.2 4.0 3.6 3.8 2.8 2.6 275 3.8 3.8 2.4 3.2 2.8 3.6 2.6 2.4 2 3.0 3.2 2.4 3.2 285 2.4 2.6 Grove GMK7550 THIS CHART IS ONLY A GUIDE AND SHOULD NOT BE USED TO OPERATE THE CRANE. The individual crane s load chart, operating instructions and other instructional plates must be read and understood prior to operating the crane. 41
Working range 53 ft - 131 ft boom extension H [ft] 350 3 330 3 310 300 25 3 131' 112' 2 2 92' 2 2 72' 53' Height from the ground in feet 2 179' 50 9 30 10 0 2 2 2 2 2 50 30 10 0 R [ft] Operating radius in feet from axis of rotation Hook heights shown in the working diagram do not consider loaded boom deflection. 42
Load chart 49,8 m (163.4 ft) 16 m - m (53 ft - 131 ft) 000 kg (264,500 lb) (%) 3 Feet 163.4 Feet 52.5 72.2 91.9 1 131.2 3 25 3 25 3 25 3 25 3 25 45 50 55 65 75 85 95 105 5 2 255 2 265 2 97.0 94.0 88.0 73.0 43.2 41.2 3 37.0 35.0 32.8 31.2 29.4 27.8 26.0.6 15.6 77.0 71.0 67.0 64.0.0 43.4 41.2 3 37.2 35.2 33.4 31.4 28.0 26.4 24.8 23.2 21.2 71.0 66.0 43.4 41.4 39.4 37.4 35.4 33.4 31.6 2 27.8 26.0 23.4 22.2 21.2.0 1 13.0 11.8 9.4 43.8 42.8 41.6.4 3 37.8 36.4 35.2 33.6 31.8 30.0 28.2 26.4 25.0 22.8 21.6.4 43.4 42.0.6 3 38.0 35.4 34.2 33.0 31.8 2 27.6 26.2 24.8 23.2 21.8.8 19.8 1 9.8 8.8 7.8 6.8 36.4 35.4 34.4 33.4 32.6 31.6 29.4 28.2 27.0 26.6 26.0 25.4 24.8 24.2 23.6 22.4 21.8 21.2.4 12.2 43.2 41.6.0 3 37.0 35.6 34.4 33.2 32.2 31.0 27.4 26.2 22.4 21.8 21.2.6 19.8 1 16.4 11.0 9.8 8.8 7.8 6.8 6.0 5.0 4.2 25.0 23.2 22.0 21.4 21.0.4.0 1 1 16.4 15.6 14.8 10.4 34.6 33.2 32.0 2 27.4 26.0 23.6 22.8 22.2 21.4.8.2 1 11.8 9.8 8.8 7.8 6.8 6.0 5.2 4.4 3.6 19.8 1 14.8 13.4 13.0 12.2 11.4 11.2 11.0 7.8 6.8 THIS CHART IS ONLY A GUIDE AND SHOULD NOT BE USED TO OPERATE THE CRANE. The individual crane s load chart, operating instructions and other instructional plates must be read and understood prior to operating the crane. 43
Load chart 54,6 m (17 ft) 16 m - m (53 ft - 131 ft) 000 kg (264,500 lb) (%) 3 Feet 17 Feet 52.5 72.2 91.9 1 131.2 3 25 3 25 3 25 3 25 3 25 45 50 55 65 75 85 95 105 5 2 255 2 265 2 275 77.0 73.0.0 66.0 43.0.8 38.8 34.6 32.8 30.8 28.8 27.0 24.0 22.8 21.8.6 16.4 12.2 11.0 9.8 71.0 67.0 64.0 42.6.6 38.6 36.8 34.8 32.8 31.0 2 27.2 25.4 24.2 23.2 22.0.8 1 67.0 43.6 41.6 38.0 36.4 34.8 33.0 31.4 2 26.8 25.4 22.4 21.2.2 1 16.4 11.2 10.0 7.8 6.8 43.0 41.6.0 3 36.8 35.2 33.4 31.6 28.2 27.0 25.8 24.8 23.6 21.6.6 12.2 42.6 41.2 38.0 36.4 34.8 33.2 31.8 30.2 27.2 25.6 23.4 22.4 21.4.6 10.4 9.4 7.4 6.4 5.4 4.6 36.0 35.0 34.2 33.2 32.4 31.6 30.8 30.0 2 28.0 27.0 26.0 23.6 22.2 21.4.6 19.8 11.8 9.4 8.2.4 3 37.8 35.6 34.4 33.4 32.4 31.6 29.4 28.2 26.8 25.6 24.2 23.2 22.4 21.6.8 19.8 1 1 11.2 10.0 8.0 7.2 6.2 5.4 4.6 3.8 25.6 25.0 23.2 22.8 22.2 21.8 21.4.8.4.0 19.8 1 15.6 11.4 9.8 8.6 7.6 6.6 32.2 30.8 2 27.6 26.6 25.8 25.0 24.2 23.4 22.8 22.0 21.4.8.4 19.8 1 15.6 11.4 10.4 9.8 8.8 7.8 7.0 6.0 5.2 4.4 3.6 1 15.6 14.8 13.0 12.2 11.8 11.4 11.0 10.4 10.0 9.4 7.4 6.4 5.4 4.4 44 THIS CHART IS ONLY A GUIDE AND SHOULD NOT BE USED TO OPERATE THE CRANE. The individual crane s load chart, operating instructions and other instructional plates must be read and understood prior to operating the crane.
Working range With MegaWingLift 39 ft - 79 ft boom extension with MegaWingLift 2 2 3 78.7' 59.1' 2 39.4' 17' Height from the ground in feet 9 0 2 0 Operating radius in feet from axis of rotation Hook heights shown in the working diagram do not consider loaded boom deflection. Grove GMK7550 45
Load chart With MegaWingLift 49,8 m - 54,6 m (163.4 ft - 17 ft) 12 m - 24 m (39 ft - 79 ft) 000 kg (352,0 lb) (%) 3 Feet 163.4 17 Feet 39.4 59.1 78.7 39.4 59.1 78.7 3 3 3 3 3 3 45 50 55 65 75 85 95 105 5 1 107.0.0 95.0.0 77.0 73.0 67.0 64.0 43.4.8 38.2 35.6 33.4 31.2 2 86.0 77.0 73.0 43.4 41.8.2 3 37.8 35.4 34.2 33.2 32.4 31.4 28.8 28.0 27.0 25.4 23.6 66.0 43.2 41.4 39.4 38.0 36.8 35.4 34.2 32.8 31.4 30.4 2 28.0 27.0 25.8 24.6 23.2 22.0 21.4.8.2 19.8 1 1.0 94.0 88.0 83.0 71.0 43.0 41.6.2 38.8 37.8 36.8 35.8 34.4 32.2 30.2 28.2 26.4 24.6 43.8 42.2.8 39.4 37.8 36.4 35.0 33.8 32.4 31.2 27.4 26.6 26.0 24.6 23.2 22.8 22.2 21.2 19.8 43.2 41.4 39.8 38.2 35.0 33.6 32.2 30.8 29.4 28.0 26.6 25.8 25.0 24.2 23.6 22.8 22.0 21.4.8.2 1 16.4 46 THIS CHART IS ONLY A GUIDE AND SHOULD NOT BE USED TO OPERATE THE CRANE. The individual crane s load chart, operating instructions and other instructional plates must be read and understood prior to operating the crane.
Working range 13 ft heavy duty jib H [ft] 13.1' 197' 179' 163' 148' Height from the ground in feet 132' 116' ' 84' 68' 53' 50 9 30 10 0 50 30 10 0 R[ft] Operating radius in feet from axis of rotation Hook heights shown in the working diagram do not consider loaded boom deflection. Grove GMK7550 47
Load chart 16,0 m - m (53 ft - 197 ft) 4 m (13.1 ft) 000 kg (264,500 lb) (%) 3 Feet 52.6 6 84.3.1.9 131.7 147.6 163.4 17 196.9 25 30 35 45 50 55 65 75 85 95 105.0.0.0.0.0.0.0.0.0.0.0.0.0.0 171.0 1 138.0.0.0.0.0.0.0 187.0 1 1.0.0 107.0 96.0 86.0.0.0.0.0 1.0 1 143.0 132.0 121.0 108.0 97.0 88.0.0.0 1 164.0 1 138.0 128.0 11.0 103.0 97.0 88.0.0 73.0 66.0.0.0 1 167.0 1.0 12 1 10 102.0 95.0 88.0 83.0 166.0 1.0.0.0.0 102.0 95.0 88.0 77.0 73.0 64.0 42.2 3 36.0 138.0 12 121.0 113.0 105.0 98.0 91.0.0 66.0 41.2 38.2 35.4 32.8 30.4.0 1 10 102.0 96.0 91.0.0 71.0 67.0.0 43.4 41.4 39.4 37.4 34.8 32.4 30.2 28.0 26.2 104.0 9 94.0 8 84.0 71.0 67.0.0 42.6.4 38.2 36.2 34.4 32.8 31.0 2 27.4 25.6 21.0 13' - 3" 48 THIS CHART IS ONLY A GUIDE AND SHOULD NOT BE USED TO OPERATE THE CRANE. The individual crane s load chart, operating instructions and other instructional plates must be read and understood prior to operating the crane.
Working range 25 ft heavy duty jib H [ft] 2 42 25' 197' 179' 163' Height from the ground in feet 148' 132' 116' ' 84' 68' 50 9 53' 30 10 0 50 30 10 0 R[ft] Operating radius in feet from axis of rotation Hook heights shown in the working diagram do not consider loaded boom deflection. Grove GMK7550 49
5' - 3" 5' - 3" Load chart 16,0 m - m (53 ft - 197 ft) 7,5 m (24.6 ft) 000 kg (264,500 lb) (%) 3 Feet 25 30 35 45 50 55 65 75 85 95 105 52.6 6 84.3.1.9 131.7 147.6 163.4 17 196.9 42 42 42 42 42 42 42 42 42 42 1 107.0.0 93.0 88.0 84.0 76.0 94.0 8 77.0 122.0 113.0 106.0.0 94.0 8 76.0 97.0 93.0 8 83.0.0 77.0 76.0 1.0 104.0 9 95.0 91.0 87.0 83.0 76.0 95.0 91.0 88.0 83.0 77.0 76.0 1 108.0 103.0 9 95.0 91.0 88.0.0 76.0 73.0 96.0 93.0.0 88.0 83.0.0 77.0 76.0 76.0.0.0 105.0 101.0 98.0 94.0 91.0 88.0 86.0 83.0.0 94.0 91.0 8 87.0 83.0.0 77.0 73.0 71.0 111.0 107.0 103.0.0 96.0 93.0 91.0 88.0 77.0 73.0 41.4 38.0 92.0.0 88.0 86.0 84.0.0 77.0 66.0 106.0 103.0.0 97.0 94.0 92.0 87.0 73.0 42.8 39.4 36.4 33.4 92.0.0 87.0 86.0 84.0 83.0.0 73.0 104.0 101.0 9 95.0 91.0 87.0 83.0.0 66.0 42.2.2 38.0 35.4 32.8 30.2 27.8 87.0 83.0.0.0 66.0.0 42.4.2 97.0 95.0 91.0 87.0 83.0 73.0 66.0 42.8.4 3 36.4 34.4 32.4 30.4 2 27.0 23.4 21.6 84.0 83.0.0 76.0 43.0.8 3 37.2 88.0 84.0.0 76.0 42.0.0 38.2 36.2 34.4 32.6 30.8 2 27.6 26.2 24.6 21.4 19.8 42.4.4 38.6 34.8 32.8 31.0 29.4 24' - 9" 50 THIS CHART IS ONLY A GUIDE AND SHOULD NOT BE USED TO OPERATE THE CRANE. The individual crane s load chart, operating instructions and other instructional plates must be read and understood prior to operating the crane.
Working range With MegaWingLift 13 ft heavy duty jib with MegaWingLift + 13.1 ' 196.9' 17 ' 163.4 ' 147.6 ' Height from the ground in feet 131.7 '.9 ' 9 0 0 Operating radius in feet from axis of rotation Hook heights shown in the working diagram do not consider loaded boom deflection. Grove GMK7550 51
Load chart With MegaWingLift 35,3 m - m (116 ft - 197 ft) 4 m (13.1 ft) 000 kg (352,0 lb) (%) 3 Feet.9 131.7 147.6 163.4 17 196.9 30 35 45 50 55 65 75 85 95 105.0.0.0.0 187.0 173.0 1 143.0 131.0.0.0 102.0 94.0 88.0 76.0.0.0.0.0 186.0 1 1 1 133.0 1 113.0 104.0 97.0.0 84.0 73.0.0.0.0 188.0 1.0.0 1 134.0 1 113.0 104.0 97.0.0 84.0 73.0 171.0 1 1 1.0 134.0 128.0 122.0.0 106.0 9 92.0 86.0.0.0 66.0 1 13 132.0.0 11 113.0 108.0 103.0 9 95.0 91.0 87.0 84.0 76.0 67.0 43.0.6 38.2 35.2 128.0 121.0.0 10 104.0 9 95.0 91.0 88.0 84.0 76.0 73.0.0 43.2.6 38.2 36.0 33.8 31.8 52 THIS CHART IS ONLY A GUIDE AND SHOULD NOT BE USED TO OPERATE THE CRANE. The individual crane s load chart, operating instructions and other instructional plates must be read and understood prior to operating the crane.
Working range With MegaWingLift 25 ft heavy duty jib with MegaWingLift 42 + 24.6' 196.9' 17 ' 163.4 ' 147.6 ' Height from the ground in feet 131.7 '.9 ' 9 0 0 Operating radius in feet from axis of rotation Hook heights shown in the working diagram do not consider loaded boom deflection. Grove GMK7550 53
Load chart With MegaWingLift 35,3 m -,0 m (116 ft - 197 ft) 7,5 m (24.6 ft) 000 kg (352,0 lb) (%) 3 Feet 30 35 45 50 55 65 75 85 95 105.9 131.7 147.6 163.4 17 196.9 42 42 42 42 42 42 1.0 133.0 126.0.0.0.0 106.0 102.0 98.0 95.0 92.0 8 86.0 77.0 71.0 66.0 1.0 106.0 102.0 9 96.0 93.0 91.0 88.0 86.0 84.0 83.0.0 1.0 132.0 126.0.0.0.0 106.0 102.0 98.0 95.0 92.0 8 86.0 84.0 64.0 10 105.0 101.0 98.0 95.0 93.0.0 88.0 86.0 84.0.0 77.0 138.0 131.0.0 11 1.0 105.0 101.0 97.0 94.0 91.0 88.0 86.0 83.0 64.0 41.8 107.0 104.0.0 97.0 94.0 91.0 8 86.0 84.0.0 76.0.0.0 1 1 111.0 106.0 101.0 97.0 94.0.0 86.0 84.0 73.0 71.0 66.0 43.6.8 38.0.0 96.0 93.0 8 86.0 84.0 76.0.0 67.0 66.0 64.0 113.0 108.0 102.0 97.0 93.0 8 67.0.0 42.4 39.8 37.2 35.0 32.8.0 87.0 83.0.0 77.0 67.0.0 43.0 95.0 91.0 86.0 83.0.0 67.0.0 42.6.0 37.4 35.0 32.8 30.8 28.8 27.0 84.0 67.0 43.0.4 37.8 35.4 54 THIS CHART IS ONLY A GUIDE AND SHOULD NOT BE USED TO OPERATE THE CRANE. The individual crane s load chart, operating instructions and other instructional plates must be read and understood prior to operating the crane.
Symbols glossary Axles Counterweight Grade Gear Boom Drive Heavy duty jib Radius Boom elevation Electrical system Hoist Rotation Boom extension Engine H Hookblock Speed Boom length Extension Hydraulic system Steering Boom nose Frame Lights Suspension Brakes Fuel tank capacity Oil Swing Cab Outriggers Outrigger controls Tires Transmission Grove GMK7550 55