HN B G/US B G/US B G Compact direct acting, port solenoid valve air, water,, low vacuum (. x 0 Pa (abs)) CONTENTS Safety precautions port solenoid valve HNB NC (normally closed) type USB NC (normally closed) type 8 USB NC (normally closed) type 0 port solenoid valve HNG Universal type 6 USG Universal type USG Universal type Resin body type USB NC (normally closed) type 6 USB NC (normally closed) type 6 USG Universal type 6 USG Universal type 6 Electronic Catalog file list 0 Always read the precautions in the Introduction and page before starting use. K S/ NP/N PD/F/ Compact direct acting, port solenoid valve
Safety precautions Always read this section before starting use. Compact direct acting, port solenoid valve Working fluid () When using this valve for, the life can be shortened considerably due to wear. Use a valve for. () This valve cannot be used for maintaining the vacuum. Consult with CKD when the vacuum needs to be maintained. WARNG CAUTION Design & Selection Continuous energizing Consult with CKD when using the port valve in a continuously energized state. Fluid viscosity The fluid viscosity must be 0 mm /s. Malfunctions could occur if the viscosity is higher than 0 mm /s. Leakage current from other fluid control components When operating the solenoid valve with a programmable controller, etc., check that the output leakage current from the programmable controller is within the following specifications. Failure to observe this could lead to malfunctions. Triode AC switch Programmable controller side CR circuit C R Leakage current Solenoid valve Installation, Piping & Wiring CAUTION Piping Always hold the socket with a spanner, etc., if the NO side is a socket. CAUTION Maintenance USB/USG When disassembling or assembling, tighten the core assembly and socket with the following tightening torques. USB USG USB USG Core assembly tightening torque Socket tightening torque 0 to N m 0 to N m 8 to N m 8 to N m to 8 N m <<Precautions for each model>> USB/USG (resin body type) CAUTION Metal is wetted. (This is not a metal free valve.) Do not use a metal (M6) joint because it could damage the port. Use a PP or fluorine resin joint. Refer to the recommended torque below. Recommended tightening torque: 0. to 0. N m Voltage USB, USG HNB, HNG AC AC diode DC 00 V 00 V 00 V 00 V V V 0. ma 0. ma ma ma ma ma
MEMO K S/ NP/N PD/F/ Compact direct acting, port solenoid valve
HNB Series Compact direct acting port solenoid valve HNB Series NC (normally closed) type : JIS symbol NC (normally closed) type Specifications Item HNB Working fluid Air, water,, low vacuum (. x 0 Pa (abs)) Working pressure differential range MPa 0 to 0.7 Withstanding pressure (water) MPa.0 Fluid temperature C 0 to 0 (no freezing) Ambient temperature C 0 to 0 (no freezing) Valve seat leakage cm /min. 0 (water pressure) Mounting attitude Free Weight g Orifice mm.0 Cv flow factor 0.0 C [dm /(s bar)] 0. b 0. Electric specifications Rated voltage VDC (option: VDC ) Allowable voltage fluctuation ±0% Power consumption W. Leakage current ma Heat class B *: Effective sectional area S and sonic conductance C are converted as S.0 x C. How to HNB DCV A Rated voltage Symbol Descriptions A Rated voltage DCV VDC DCV VDC
HNB Series Internal structure and parts list HNB No. Parts name Core assembly Material PPS, STKM, SUS Plunger assembly SUS, NBR Spring O ring Body SUS0 NBR SUS0 (Page 0) Dimensions HNB Resin, stainless steel, nitrile rubber K S/ NP/N ø (00) PD/F/ depth M depth 6 0 ø Compact direct acting port solenoid valve
Compact direct acting port solenoid valve HNG Series Universal type : JIS symbol Universal type COM NCNO Specifications Item HNG Working fluid Air, water,, low vacuum (. x 0 Pa (abs)) Working pressure differential range MPa 0 to 0.7 (NO pressurization: 0 to 0.) Withstanding pressure (water) MPa.0 Fluid temperature C 0 to 0 (no freezing) Ambient temperature C 0 to 0 (no freezing) Valve seat leakage cm /min. 0 (water pressure) Mounting attitude Free Weight g 6 Orifice mm.0 Cv flow factor 0.0 C [dm /(s bar)] 0. b 0. Electric specifications Rated voltage VDC (option: VDC ) Allowable voltage fluctuation ±0% Power consumption W. Leakage current ma Heat class B *: Effective sectional area S and sonic conductance C are converted as S.0 x C. How to HNG DCV A Rated voltage Symbol Descriptions A Rated voltage DCV VDC DCV VDC
HNG Series Internal structure and parts list HNG NO COM NC No. Parts name Core assembly Plunger assembly Spring O ring Body Material PPS, STKM, SUS SUS, NBR SUS0 NBR SUS0 Resin, stainless steel, nitrile rubber K Dimensions HNG (Page 0) S/ NP/N NO ø (00) PD/F/ depth COM M depth 6 NC 0 ø Compact direct acting port solenoid valve
USB Series Compact direct acting port solenoid valve USB Series NC (normally closed) type : JIS symbol NC (normally closed) type Specifications Item USB USB Working fluid Air, water,, low vacuum (. x 0 Pa (abs)) Working pressure differential range MPa 0 to 0.7 0 to 0. Withstanding pressure (water) MPa. Fluid temperature C 0 to 60 (no freezing) Ambient temperature C 0 to 0 Valve seat leakage cm /min. 0. (pneumatic pressure) Mounting attitude Free Weight kg 0.07 Orifice Cv flow factor C [dm /(s bar)] b mm 0.0 0. 0.7. 0.06 0.8 0.6 Electric specifications Rated voltage VDC, VDC (option: 00 VAC 0/60 Hz, 00 VAC 0/60 Hz) Allowable voltage fluctuation ±0% Power consumption W DC AC Heat class B *: use with water when the solenoid valve is not used for a long time, the high corrosion resistant solenoid valve HB Series (page 807) is recommended. *: Effective sectional area S and sonic conductance C are converted as S.0 x C. How to USB 0 DCV A Orifice B Body/ sealant combination Symbol Descriptions A Orifice ø.0 ø. B Body/sealant combination Body Sealant Blank L 0 Brass Treatment Oil free C Voltage C Voltage DCV DCV AC00V AC00V Std. Option VDC VDC 00 VAC 0/60 Hz 00 VAC 0/60 Hz
USB Series Internal structure and parts list USB 9 0 Dimensions USB (Page 0) 6 7 8 No. Parts name Clip Bonnet Sub core Core assembly Coil assembly 6 Plunger assembly 7 Waving washer 8 Core B 9 O ring 0 Plunger spring Body ( ) shows option. Material PBT SPC SPC SUS0 or equivalent, SUS6L SUS0 or equivalent, SUS0, NBR S6CM SUM NBR SUS0 SUS0 (C60) PBT, nitrile rubber Free cutting steel (brass) K S/ NP/N ø0. (00) PD/F/ 7 M depth 6 8 depth ø0 (0) 0 Lead wire Rectification stack The alternating current (AC) type has a rectification stack assembled into the lead wire. Compact direct acting port solenoid valve
USB Series Compact direct acting port solenoid valve USB Series NC (normally closed) type : Rc/8 JIS symbol NC (normally closed) type Specifications Item USB6 USB6 USB6 Working fluid Air, water,, low vacuum (. x 0 Pa (abs)) Working pressure differential range MPa 0 to 0.9 0 to 0. 0 to 0. Withstanding pressure (water) MPa Fluid temperature C 0 to 60 (no freezing) Ambient temperature C 0 to 0 Valve seat leakage cm /min. 0. (pneumatic pressure) Mounting attitude Free Weight kg 0. Rc/8 Rc/8 Rc/8 Orifice mm.6.. Cv flow factor 0.09 0.8 0. C [dm /(s bar)] 0. 0.6. b 0.6 0. 0.8 Electric specifications Rated voltage VDC, VDC (option: 00 VAC 0/60 Hz, 00 VAC 0/60 Hz) Allowable voltage fluctuation ±0% Power consumption W DC AC Heat class E (molded coil: B) *: use with water when the solenoid valve is not used for a long time, the high corrosion resistant solenoid valve HB Series (page 807) is recommended. *: Effective sectional area S and sonic conductance C are converted as S.0 x C. How to USB 6 B DCV A Orifice Symbol A Orifice ø.6 ø. ø. Descriptions Rc/8 B Body/sealant/coil combination B Body/sealant/coil combination Body Sealant Std. Brass Fluoro rubber Stainless steel Fluoro rubber Blank B V D E W H J L M Option Brass Stainless steel Fluoro rubber Fluoro rubber Coil Taped Molded coil Taped Molded coil Treatment Vacuum inspection * Vacuum inspection * Oil free C Voltage C Voltage DCV DCV AC00V AC00V Std. Option VDC VDC 00 VAC 0/60 Hz 00 VAC 0/60 Hz *: option symbols V and W, vacuum is inspected at "leakage amount:. x 0 6 Pa m /s ".
USB Series Internal structure and parts list USB6 9 0 Dimensions USB6 (Page 0) 6 7 8 No. Parts name Material 6 7 8 9 0 Clip Bonnet Bonnet piece Core assembly Plunger assembly Coil assembly Waving washer Core B O ring Plunger spring Body PBT SPC SPC SUS6, SUS0 or equivalent SUS0 or equivalent, NBR (FKM) S6CM SUM NBR (FKM) SUS0 C60 (SUS0) ( ) shows option. PBT, nitrile rubber (fluoro rubber) Free cutting steel (fluoro rubber) Brass (stainless steel) K S/ NP/N ø (00) PD/F/ ø 8 8 Rc/8 M depth 6 Lead wire 0 (00) Rectification stack The alternating current (AC) type has a rectification stack assembled into the lead wire. Compact direct acting port solenoid valve