Owner s Manual Liquid-cooled, Prepackaged Standby Generators Model Number 00030-0 (1kW) 00028-0 (kw) 00031-0 (2kW) This manual should remain with the unit. ONLY QUALIFIED ELECTRICIANS OR CONTRACTORS SHOULD ATTEMPT INSTALLATION!!
Mounting Base Drawing No. 0F0-B 38
Mounting Base Drawing No. 0F0-B 1 0F0 1 SUPPORT BATTERY TRAY 2 0E883 1 HOLD DOWN BATTERY 3 0E 1 ASSEMBLY BATTERY TRAY 0813 1 NUT HEX M X 1.0 G8 YEL CHR 02 WASHER LOCK M-1/ 0280 2 WASHER SHAKEPROOF EXT 1/ STL 01 1 LUG SLDLSS #2-#8 X / CU 8 0223 WASHER FLAT 1/-M ZINC 0 SCREW HHC M-1.0 X 1 G8.8 0280 NUT FLANGED HEX M-1. 0221 DAMPENER VIBRATION 0 BLUE 022 SPACER. X.2 X 1.8 PWDR/ZNC 13 0222 DAMPENER VIBRATION 1 022 WASHER FLAT M 1 0281 SCREW HHC M-1. X 80 G8.8 1 03221 1 ASSY WIRE #0.00" 00 1 SCREW HHTT M-1.0 X BP 083 REF BATT VDC -AH 2 (NOT SHOWN) 1 0F0 3 BRACKET CONTROL PANEL SUPPORT 0 3 WASHER SHAKEPROOF EXT /1 STL 21 001 1 SCREW SHC M-1.0 X 0 G. 22 02 1 WASHER LOCK M 23 022131 1 WASHER FLAT 3/8-M ZINC 2 02 1 EARTH STRAP 2 03880G 1 CABLE BATT BLK #1 X 1.0 2 00331 REF BATTERY POST COVER (BLACK) 2 00331A REF BATTERY POST COVER (RED) 28 03880J 1 CABLE BATT RED #1 X 0.0 2 01 REF NUT HEX M8-1.2 G8 YEL CHR 30 022 REF WASHER LOCK M8-/1 31 0282 1 WASHER SHAKEPROOF EXT /1 STL 32 03 1 BOOT BATTERY CABLE 33 0E8A 1 ASSY MTG BASE 2.L AL ENCL 3 0F0 3 SUPPORT CONTROL PANEL 2.L 3 0C2 33 SCREW THF M-1 X 1 N WA Z/JS 3 082 1 SPRING CLIP HOLDER.3-.2 3 0 1 SCREW HHTT M-0. X 8 BP
Enclosure Drawing No. 0F1-H 3 32 LATCH DETAIL 31 30 31 32 38 3 0 STATES FOAM IS ON NEAR SIDE STATES FOAM IS ON FAR SIDE 2 33 2 "B" 33 3 2 2 21 3 TYPICAL OF ROOF PANEL THAT REQUIRE INSULATION. SECURE AS SHOWN. 2 8 2 22 32 SEE LATCH DETAIL 13 8 3 1 1 21 "B" 2 3 28 1 1 3 23 2 0 2 2 1 TO "B" (2-PLCS) 0
Enclosure Drawing No. 0F1-H 1 0F083 1 DUCT INTAKE MID AL 2.L 2 0F081 1 DUCT DISCHARGE RH AL 2.L 3 0F080 1 DUCT DISCHARGE LH AL 2.L 0C2 3 SCREW TH-FRM M-1 X 1 N WA Z/JS 0F0 1 SUPPORT RADIATOR 2.L AL 0E002AB 1 AI INSULATION SIDE REAR CORNER POST RH 0E002AC 1 AI INSULATION INTAKE DUCT TOP PANEL 8 0E002AD 1 AI INSULATION LH SIDE REAR CORNER POST PANEL (BOTTOM) 0E 2 DOOR SIDE HSB AL 0F08 1 SUPPORT RH SIDE AL 2.L 081 2 FOAM STRIP 3/" WIDE X 3/1" THK (0" LG) 0A2 WASHER NYLON.2 13 0E002AE 1 AI NSULATION LH SIDE REAR CORNER POST PANEL (TOP) 1 0F01A 1 HINGE TYPE B W/STUDS, SOCKET 1 0F01 1 HINGE TYPE B W/STUDS, PIN 02 13 WASHER LOCK M-1/ 0223 13 WASHER FLAT 1/-M ZINC 1 0E0 2 GAS SPRING 0E1 BALL STUD GAS SPRING MOUNT 21 0001 NUT HEX /1- LOCK 22 0E2 SCREW WING M-1.00 X 2 23 0F01A 1 HINGE TYPE A W/STUDS, SOCKET 2 0F01 1 HINGE TYPE A W/STUDS, PIN 2 0D23 3 GASKET CLIP-ON SELF GRIPPING (8" LG) 2 08 8 WASHER SELF LOCKING DOME 2 0F2 1 KIT SAE FOAM 2.L QUIET SOURCE 28 0F088 1 ROOF 2.L FORD AL 2 0E82B 2 AI DOOR PANEL 30 0D303A 1 LATCH 1/ TURN NONLOCKING 31 0C81 2 PAWL DOOR HSB 32 0F08 1 SUPPORT LH SIDE AL 2.L 33 0E002Q 2 AI INSULATION RAD SUPPORT PANEL 3 0D303 1 LATCH QUARTER TURN LOCKING 3 0E002Y 1 AI INSULATION SIDE BRACE PANEL RH 3 0E002AF 1 AI INSULATION SIDE BRACE PANEL LH 3 0E002AA 1 AI INSULATION ROOF PANEL 38 0F082 1 DUCT DISCHARGE MID AL 2.L 0280 WASHER SHAKEPROOF EXT 1/ STL 0 0 2 ASSY WIRE 1AWG. #0 GRN/YEL 1 03 2 ASSY WIRE 1AWG. #0 GRN/YEL 2 0813 NUT HEX M X 1.0 G8 YEL CHR 3 0F08 1 CORNER POST REAR LH SIDE AL 0F08 1 CORNER POST REAR RH SIDE AL 0E8 1 BRACKET STIFFENER LH FRONT 0E883 1 DOOR BATTERY COMPARTMENT 0A33 1 SCREW BHSC M-1.0 X 1 SS 8 0E80 1 BRACKET STIFFENER RH FRONT * ALL ITEMS NOTATED WITH "AI" ARE COMPONENTS OF 0F2 1
Control Panel (1kW and kw) Drawing No. 0F22-D 2
Control Panel (1kW and kw) Drawing No. 0F22-D 1 0F00 1 TOP, CONTROL PANEL 2 0F08 1 BACK & BOTTOM, CONTROL PANEL 3 0F01 1 PANEL, FRONT 2.L CONTROL PNL 0E0 1 ASSY PCB HSB CONTROLLER 2.L 080 1 ASSY VOLTAGE REGULATOR 0HZ 0E8A 2 RELAY, VDC C FORM W/DIODE 0C 1 XFMR /1V 1VA&VA 8 088 1 CIRCT BRK 8 X 1 ETA -00-P 0D00A 1 ASSY PCB 2A V UL BATT CHRGR 003 1 JUNCTION BLOCK 3/8-1 00213 2 PCB SUPPORT SNAP-IN 1/" 0C22 SCREW PHTT M-0. X ZYC 13 023 1 DIO BRIDGE 2A 00V 1 0F03 1 BRACKET, CB SIEMENS BQ 1 0E80 1 BRKT CB MTG BACK 1 0D1* 1 CB 000A 2P V S BQ2 LL 0D** 1 CB 00A 2P V S BQ2 LL 0F 1 ADPTR,LH SIDE WICKMAN 8. 0F3 1 ADPTR,RH SIDE WICKMAN 8. 1 0F2 2 HOLDER, FUSE WICKMANN 8. 0E03A 1 FUSE ATO TYPE AMP (TAN) 21 0E03C 1 FUSE, ATO TYPE 1 AMP (BLUE) 22 0E21 1 FITTING CONDUIT STR 1-1/2" 23 0 2 SCREW PPHM M-0.8 X 30 ZINC 2 0238 WASHER FLAT # ZINC 2 022 2 WASHER LOCK # 2 01 2 NUT HEX M-0.8 G8 YEL CHR 2 0823 1 SWITCH ROC DPST V SPD 28 0E 1 SWITCH ROC DPDT ON-OFF-ON 2 0C1 REF. BLOCK TERM A 1 X X 00V 30 0C2 SCREW PHTT #-32 X 3/8 ZYC 31 0C22 1 SCREW PHTT M-0. X 1 ZYC 32 0 SCREW HHC M-1.0 X 1 G8.8 33 02 WASHER LOCK M-1/ 3 0223 WASHER FLAT 1/-M ZINC 3 0E38 SCREW PPPH HI-LO #-2 X 3/8 3 033 2 RES MTG BRACKET 3 0F08A 1 HARNESS, C-PNL 2.L QS 1&KW (NOT SHOWN) 38 0E881 REF SOCKET, RELAY 0832 1 RES R % 2W 0 0C2 1 DECAL AVR COVER 1 0C2 1 DECAL WARNING ELECTRICAL SHOCK 2 0F232 1 DECAL TERMINAL BLOCK 3 0F22 1 DECAL CONTROL HSB 0E13 1 DECAL, WARNINGS HSB 0F1 1 HANG TAG 2 WIRE START (NOT SHOWN) * 1KW ** KW 3
Control Panel (2kW) Drawing No. 0E1-C 32 2 28 33 3 2 3 1 21 3 30 38 23 2 1 2 3 0 13 31 2 2 2 2 1 8 1 32 33 3 1
Control Panel (2kW) Drawing No. 0E1-C 1 0F00 1 TOP, CONTROL PANEL 2 0F08 1 BACK & BOTTOM, CONTROL PANEL 3 0F01 1 PANEL, FRONT 2.L CONTROL PNL 0E0 1 ASSY PCB HSB CONTROLLER 2.L 080 1 ASSY VOLTAGE REGULATOR 0HZ 0E8A 2 RELAY, VDC C FORM W/DIODE 0C 1 XFMR /1V 1VA&VA 8 00 1 CIRCT BRK. X 1 ETA -00-P 0D00A 1 ASSY PCB 2A V UL BATT CHRGR 003 1 JUNCTION BLOCK 3/8-1 00213 2 PCB SUPPORT SNAP-IN 1/" 0C22 1 SCREW PHTT M-0. X ZYC 13 023 1 DIO BRIDGE 2A 00V 1 0F03 1 BRACKET, CB SIEMENS BQ 1 0E80 1 BRKT CB MTG BACK 1 0A 1 CB 0A 2P V S BQ2 LL 0F 1 ADPTR,LH SIDE WICKMAN 8. 0F3 1 ADPTR,RH SIDE WICKMAN 8. 1 0F2 2 HOLDER, FUSE WICKMANN 8. 0E03A 1 FUSE ATO TYPE AMP (TAN) 21 0E03C 1 FUSE, ATO TYPE 1 AMP (BLUE) 22 0E21 1 FITTING CONDUIT STR 1-1/2" 23 0 2 SCREW PPHM M-0.8 X 30 ZINC 2 0238 WASHER FLAT # ZINC 2 022 2 WASHER LOCK # 2 01 2 NUT HEX M-0.8 G8 YEL CHR 2 0823 1 SWITCH ROC DPST V SPD 28 0E 1 SWITCH ROC DPDT ON-OFF-ON 2 0C1 REF. BLOCK TERM A 1 X X 00V 30 0C2 SCREW PHTT #-32 X 3/8 ZYC 31 0C22 1 SCREW PHTT M-0. X 1 ZYC 32 0 SCREW HHC M-1.0 X 1 G8.8 33 02 WASHER LOCK M-1/ 3 0223 WASHER FLAT 1/-M ZINC 3 0E38 SCREW PPPH HI-LO #-2 X 3/8 3 0F08 1 HARNESS CTRL PNL 2.L FORD AL (NOT SHOWN) 38 0E881 REF SOCKET, RELAY 0C2 1 DECAL AVR COVER 0 0C2 1 DECAL WARNING ELECTRICAL SHOCK 1 0F232 1 DECAL TERMINAL BLOCK 2 0F22 1 DECAL CONTROL HSB 3 0E13 1 DECAL, WARNINGS HSB 0F1 1 HANG TAG 2 WIRE START (NOT SHOWN)
0 2 30 2 1 1 30 1 38 28 0 2 1 1 38 2 0 2 13 31 22 1 HSG. 1 3 1 3 FOR HARNESS GROUND 3 8 33 3 0 1 1 1 22 1 1 "A" 3 1 STEPPER MOTOR UNITS ONLY 2 23 38 8 2 TO RADIATOR CAP 8 Engine Drawing No. 0E-F
Engine Drawing No. 0E-F 1 0E0 REF ENGINE 2.L FORD 2 0E 1 PULLEY, 2.L FORD WATER PUMP 3 081 8 SCREW HHC M-1. X 2 G8.8 0F0001 1 CLUTCH, COOLING FAN 2.L FORD 0D388B 1 SERPENTINE BELT - 0.8" LENGTH 0A88 1 SWITCH,OIL PRESSURE,PSI,2POL 0E01 1 ASSY WATER LEVEL SENSOR C/E PL 8 0A1 1 SW-TMP 2DEG 3/8NPT 03 1 BUSHING REDUCER 1/ TO 1/8 022 1 PLUG STD PIPE 3/8 STEEL SQ HD 0E 1 MANIFOLD, INTAKE (MACHINED) (STEPPER MOTOR) 0EA 1 MANIFOLD INTAKE MACH BOSCH32 (BOSCH GOV.) (NOT SHOWN) 0E81 1 GASKET, 2.L FORD INTAKE MAN. 13 023 SCREW HHC M8-1.2 X G8.8 1 02 SCREW SHC M-1.0 X 2 G. ZP 1 0221 8 WASHER FLAT /1-M8 ZINC 1 02 WASHER LOCK M-1/ 022 1 WASHER LOCK M8-/1 03 SCREW HHC M8-1.2 X 2 G8.8 1 022131 1 WASHER FLAT 3/8-M ZINC 02 22 WASHER LOCK M 21 022 2 SCREW SHC M-1. X 3 G. 22 0E08 2 ENGINE FOOT, 2.L FORD 23 0E38 1 DIPSTICK, 2.L FORD 2 0E2 1 BRACKET, DIPSTICK TUBE 2 0F0230 1 FAN 1" COOLING 2 0E83 1 HARNESS, 2.L FORD ENGINE (NOT SHOWN) 0E83A 1 HARNESS,2.L FORD (BOSCH GOV.) (NOT SHOWN) 2 0D SCREW HHC M-1.0 X 2 G. 28 0E08B 1 FLEXPLATE 2.L FORD 2 0E 1 ADAPT CASTING MACH 2.L FORD 30 0 SCREW SHC M-1. X 30 G. 31 001 2 SCREW SHC M-1.0 X 0 G. 32 0E80 1 SPACER FLEXPLATE HSB 33 0E80 1 GASKET, 2.L FORD EXHAUST MAN. 3 0E0 1 MANIFOLD, EXHAUST ( MACHINED) 3 0E30 1 HEAT SHIELD, EXHAUST MANIFOLD 3 0821 3 SCREW SHC M8-1.2 X 30 G. 3 0E 1 STARTER, VOLT 38 03 SCREW HHC M-1.0 X G8.8 0223 WASHER FLAT 1/-M ZINC 0 02 2 NUT HEX M-1. G8 YEL CHR 1 01 2 SCREW HHC M-1. X G8.8 2 0F022 1 SPRING BUSHING 3 0E88 1 ALTERNATOR, D.C 0F003 1 BRKT,D.C. ALTERNATOR(MACHINED) 02082 1 SCREW HHC 3/8-1 X 2-1/ G 0E28 1 TENSIONER, D.C. ALTERNATOR 0F0383 1 HOSE,2.L FORD COOLANT BY- PASS 8 0823 2 CLAMP HOSE #.-1.0 0E3 1 LOWER HOSE ADAPTER,2.L FORD 0 0F03 1 O-RING 1-3/1 X 1-/1 X 1/8 1 0 2 SCREW HHC M-1.0 X 2 G8.8 2 080C 1 HOSE OIL DRAIN ASSY 21" 3 08031J REF HOSE CLAMP BAND /8" 0 1 BARBED STR 3/8NPT X 3/8 0 1 ADAPTER M-1. 3/8NPT 02 1 WASHER NYLON.0 X.8 X.0 0813 1 NUT HEX M X 1.0 G8 YEL CHR 8 0E38A 1 DIPSTICK TUBE, 2.L FORD 0F32 1 COVER, R/H SIDE ENGINE ADAPTOR 0 0F33 1 COVER, L/H SIDE ENGINE ADAPTOR 1* 03 8 SCREW SHC M-1.0 X 0 G. 2 0 1 TANK COOLANT RECOVERY 3 032 1 HOSE /32 ID ("LG) 0F133 1 BRACKET,2.L FORD WATER BOTTLE 0000 3 WASHER FLAT M SS 0000 3 WASHER LOCK M SS 08082 3 SCREW HHC M-1.0 X SS 8 01 1 NUT HEX M8-1.2 G8 YEL CHR 08031C 2 CLAMP HOSE BAND 1/ * NOTE: TORQUE TO FT/LBS.
Fuel System Drawing No. 0E80-D TO VALVE COVER 1 31 32 33 8 28 TO ENGINE 13 2 2 1 30 21 22 2 3 38 2 3 PORT "OUT 2" 1 0 3 L.P. VAPOR CONVERSION CARBURETOR ASSY. 0E28A (I/N 1) 2 1 1 2 0 3 PORT "OUT 1" 2 8
Fuel System Drawing No. 0E80-D 1 0E8 1 BRACKET FUEL REGULATOR 2 080 1 FLANGE FUEL INLET 3 0E 1 ASSY FUEL REG 2.L FRD N/G-L/P 023 SCREW HHC M8-1.2 X G8.8 0221 2 WASHER FLAT /1 ZINC 022 WASHER LOCK M8-/1 01 2 NUT HEX M8-1.2 G8 YEL CHR 8 * 0F 1 BODY CARBURETOR ASSEMBLY 0A3 1 BARBED EL 0 1/8 NPT X 3/8 0F REF. PCV VALVE 2.L FORD 0E 1 FUEL HOSE ASSM. NAT. GAS/L.P.V. 0F0 1 HOSE CRANKCASE BREATHER 13 0A 1 COVER AIR CLEANER 1 08031C 2 CLAMP HOSE BAND 1/ 1 0D 1 DECAL INLET PRESSURE 1 * 0E01 1 ADAPTER CARB. TO AIR CLNR 002 1 FILTER ELEMENT 031 1 NUT WING 1/- NYLK 1 0E28A 1 CARBURETOR ASSY. 2.L FORD 001 1 CARBURETOR GASKET 21 * 0 SCREW PPHM M-0.8 X ZNC 22 * 022 WASHER LOCK M 23 0230 1 ELBOW 0D STREET 3/ 2 0222 1 STUD TH 1/- X 3 G2 ZNC FULL 2 022 1 NUT HEX 1/- STEEL 2 0222 2 NUT HEX /1- STEEL 2 002 1 DECAL FUEL INLET NG 28 0A 2 STUD /1- X 1.2 F THR 2 0C2 3 SCREW TH-FRM M-1 X 1 N WA Z/JS 30* 0E0 1 GASKET, AIR CLEANER ADAPTER 31* 0E08 1 O-RING 2-028 1.38 X 1.0 X.0 32* 0E00A 1 VENTURI MM 33* 0C133 1 0-RING 2.82 X 2.2 3* 0E0 1 SCREW THROTTLE PIN STOP 3* 0E08 1 THROTTLE ARM REWORK 3* 033138 1 SCREW HHM #-32 X /8 3* 022 1 WASHER LOCK # 38* 0E0 1 LEVER,THROTTLE STOP * 033 1 BARBED EL 0 3/8 NPT X /8 0 01 1 HOSE /8 ID LPG & NG (2" LG) 1 0823 2 CLAMP HOSE #. - 1.0 2 0F0382 1 HOSE 3/8" 0 DEG 2.L PVC * INCLUDED IN ITEM 1 (CARBURETOR ASSY )
Alternator Drawing No. 0E80-C 1 LOCKTIGHT 1 31 1 30 LEADS 2 21 8 3 13* LOCKTIGHT 1 1 0
Alternator Drawing No. 0E80-C 1 0F1A 1 ROTOR 0 1KW 1P DIRECT HSB (2.L FORD) 0F1A 1 ROTOR 0 KW 1P DIRECT HSB (2.L FORD) 0F1A 1 ROTOR 0 2KW 1P DIRECT HSB (2.L FORD) 0E03A 1 ROTOR 0 30KW 1P DIRECT HSB (3.0L FORD & 2.L FORD) 0E13A 1 ROTOR 0 0KW 1P DIRECT HSB (3.L CHRYSLER) 2 0F10A 1 STR 0 1AD HSB (382MM LONG)(2.L FORD) 0F18A 1 STR 0 AD HSB (382MM LONG)(2.L FORD) 0F1A 1 STR 0 2AD HSB (382MM LONG)(2.L FORD) 0E0A 1 STR 0 3AD1 HSB (382MM LONG)(3.0L FORD & 2.L FORD) 0EA 1 STR 0 0AD HSB (33MM LONG)(3.L CHRYSLER) 3 0E0 1 REAR BEARING CARRIER 0/DRCT 0E08 REF FLEXPLATE 3.0L FORD 0E08A REF FLEXPLATE 3.L HSB 0E08B REF FLEXPLATE 2.L FORD 0E8 1 FLYWHEEL ASSY 3.0L HSB LG GEAR 0E0 1 REVCOR FAN. X 2 W/PRESS DIS 02 8 WASHER LOCK M 8 0 SCREW HHC M-1. X 1 G8.8 00BK STUD M1-2.0 X 0 G ZINC (3.0L FORD & 2.L FORD) 00BF STUD M1-2.0 X 0 G ZINC (3.L CHRYSLER) 033 WASHER LOCK M1 0 NUT HEX M1-2.0 G8 YEL CHR 0E8 1 ASSY BRUSH HOLDER 0/HSB 13 0233 1 WASHER SHAKEPROOF INT #8 1 0C3 SCREW HHTT M-0. X 2 BP 1 0 SCREW SHC M-1. X 30 G. 1 0A202 1 WASHER FLAT.88 ID X 3.2 OD 028 1 KEY SQ 3/8 X 1 STEEL 0A201 1 SCREW HHC M1-2.0 X G8.8 1 0222 WASHER LOCK #8-M 038 WASHER FLAT #8 ZINC 21 003F 1 CONDUIT FLEX 1-1/" (30" LG - 3.0L FORD & 3.L CHRYSLER) 003F 1 CONDUIT FLEX 1-1/" (" LG - 2.L FORD) ROTOR REPLACEMENT PARTS 30 028 1 BALL BEARING- MM 31 0082 1 SLIP RING -MACHINED- 1
Muffler Drawing No. 0F230-C 1 2 1 3 13 1 1 1 1 8 2 21 22 23 1 0F2 1 PIPE MUFFLER OUT 2 0F28 1 PIPE EXHAUST 2.L FORD 3 0F2823 1 MUFFLER 2.L FORD 033 2 BOLT U /1- X 2.0 03 2 SADDLE 2 INCH 022 WASHER LOCK M8-/1 0222 NUT HEX /1- STEEL 8 0E00A 1 EXHAUST BLANKET 800MM 01 1 GASKET EXHAUST RING 0E881 1 EXHAUST FLANGE 2" PIPE 0F22 2 STRAP MUFFLER 0F22 1 BRACKET, MUFFLER 2 13 028 SCREW HHC M-1.0 X G8.8 1 02 WASHER LOCK M-1/ 1 0223 8 WASHER FLAT 1/-M ZINC 1 0813 NUT HEX M X 1.0 G8 YEL CHR 023 2 SCREW HHC M8-1.2 X G8.8 01 2 NUT HEX M8-1.2 G8 YEL CHR 1 0A0 1 SCREW HHC M8-1.2 X 0 G8.8 FT 0221 WASHER FLAT /1-M8 ZINC 21 022131 2 WASHER FLAT 3/8-M ZINC 22 08 2 WASHER LOCK 3/8 SS 23 0D2 2 SCREW HHC 3/8-1 X 1-3/ SS 2 0288 1 NUT TOP LOCK FL M8-1.2
Stepper Motor Drawing No. 0E-C 3 2 ITEM (13) NEOPRENE COATING 1 1 WIRE HARNESS 1 SECURE WIRE HARNESS WITH TIE WRAP AS SHOWN. "A" 1 TO "A" CARBURETOR ARM (REF.) INTAKE MANIFOLD (REF.) 1 08 1 ASM MOTOR STEPPER 2 081A 1 HOUSING GOVERNOR CONNECTOR 3 0F0 REF HARN GOV 2.L FORD 082A 1 COVER CONNECTOR HOUSING 0822 2 SCREW PFHST #2 X /8 031 3 SCREW HHC M-1.0 X G8.8 02 WASHER LOCK M-1/ 8 0E38 REF SCREW PPPH HI-LO #-2 X 3/8 0883 1 LEVER STEPPER MOTOR 038 2 NUT LOCK HEX #-32 NYL INS 0E132 1 ASSY. CARBURETOR LINKAGE ROD 0A 1 BRACKET STEPPER MOTOR 13 0031 AR LIQUID NEOPRENE 1 02333A 1 TIE WRAP."X.1" BLK UL 1 02 2 SCREW HHC 1/- X 1/2 G 1 0223 2 WASHER FLAT 1/ ZINC 02 1 SCREW TAP HWH #-2 X 3/8 ZINC 0E1 1 SPRING,ANTI LASH 3
1 Rotating fan Can cause severe injury or death. 002 Radiator Drawing No. 0E-F 1 2 1 2 2 8 TO THERMOSTAT ADAPTER TO BASE OF WATER INLET TUBE (ON BLOCK) 1 1 2 3 2 21 WARNING 8 2 2 1 0E REF SUPPORT RADIATOR 2.L FORD 0F0 REF SUPPORT RADIATOR 2.L AL 0EA REF SUPPORT RADIATOR 2.L FORD ALM 2 0E83 1 RADIATOR 2.L FORD 3 0F03 1 VENTURI 1" FAN 2.L FORD 0F01 1 GUARD FAN 2.L FORD 002 CLAMP HOSE #2 B1.0-2.00 0C2 REF. SCREW THF M-1 X 1 N WA Z/JS 02 2 TAPE FOAM 1 X 1(21" LG) 8 02 8 WASHER LOCK M-1/ 0223 WASHER FLAT 1/ ZINC 022 8 NUT HEX 1/- STEEL 02 1 CAP RADIATOR 0003 SPACER.1 X. X.8 ST/ZNC 1 0F0 1 HOSE, UPPER RADIATOR MM TAL 1 0E833 1 HOSE, 2.L FORD LOWER RADIATOR 1 031 1 BARBED STR 1/ NPT X 3/8 080C 1 HOSE OIL DRAIN ASSY 21" 0A2 FOAM 1. X 1 ADHESIVE BACKING (21." LG) 1 031 BOLT CARR 1/- X 1-3/ JS00 082 1 SPRING CLIP HOLDER.3-.2 21 0A21 1 SCREW SWAGE -32 X /1 Z/YC 2 0C2 SCREW TH-FRM M-1 X 1 N WA Z/JS 2 02228 SCREW HHC 1/- X 3/ G 2 02 REF NUT HEX LOCK M-1.0 SS NY INS 2 002 2 DECAL WARNING-FAN