AP00.20-U-1208LE SERVICE SHEET for Mercedes-Benz Maintenance System (USA) Model Year 2009 USA Model 230 Customer: Repair order number: Tire Rotation (non-staggered width wheel setup only) A 5,000-mile recommended tire rotation interval will likely necessitate tire rotation at least once in between each 10,000-mile maintenance service and at every 10,000-mile maintenance service. Tires rotated YES NO Note: For any condition found while performing the checks or inspections included in this maintenance sheet, determine the cause and perform the repair using a separate repair order. Current mileage reading: Oil grade/viscosity: Additional notes: Service work to be performed as advised by service advisor: Completion date: Confirm work has been performed by signing below: P-2374-230-09E (07/15) Dealer Workshop Services www.mbusa.com www.startekinfo.com Mercedes-Benz USA, LLC 1 Reproduction or translation in whole or in part is not permitted without written authorization from the publisher. 1-800-FOR-MERCedes
Required Service Work miles (thousands) 2 10 20 30 40 50 60 70 80 90 100 110 120 130 140 150 Reset maintenance service indicator in instrument cluster Engine - oil and filter change.954.981/983 Check catch, safety catch and hinges on engine hood for proper operation Clean water drain in air/water duct Check condition of poly-v-belt, 273 Replace brake fluid except CODE P99 (Special model "AMG Black CODE P99 (Special model "AMG Black Replace combination filter Check thickness of brake pads, front and rear Correct tire inflation pressure including spare () and enter in the table at the end of the service sheet Leakage - major components - check underbody and engine compartment for chafe marks, line routing, damaged components SL550, SL63 AMG SL600, SL65 AMG Visually inspect condition of front axle ball joints, rubber boots Visually inspect condition of driveshaft flexible discs Visually inspect condition of steering mechanical components, rubber boots Coolant - check fluid level and correct if necessary, 273; main and low temperature circuit (main circuit if not to be replaced (every 30k miles/3 yrs)) refer to AH20.00-P-1142-01V observe correct coolant composition Brake system - check fluid level and correct if necessary Power steering - check fluid level and correct if necessary the fluid level must always be on the maximum mark, corresponding to the oil temperature Windshield washer system - check fluid level and correct if necessary Active Body Control - check fluid level and correct if necessary CODE 487 (Active Body Control (ABC)) Parking brake (function test only) AP18.00-P-0101RMG AP18.00-P-0101SX AP18.00-P-0101SLA AP18.00-P-0101SZ AP88.40-P-8851R AP83.10-P-8353A AP13.22-P-1352RX AP13.22-P-1352L AP42.00-P-4280R AP42.00-P-4280RBS AP83.00-P-8384R AP40.15-P-4061A AP00.20-P-0053BA AP00.20-P-0053H AP33.20-P-3353BA AP41.10-P-4152Z AP46.00-P-4653F AP42.10-P-4210Z AP46.00-P-4612SLC AP82.35-P-8210N AP32.50-P-3213I AP42.00-P-4290BA 2
Required Service Work miles (thousands) 2 10 20 30 40 50 60 70 80 90 100 110 120 130 140 150 Audible warning system (Electro-hydraulic brake system) - function check except CODE P99 (Special model "AMG Black Reset maintenance service indicator in instrument cluster reminder - if not yet performed Required Additional Work miles (thousands) 2 10 20 30 40 50 60 70 80 90 100 110 120 130 140 150 Rear axle differential fluid replacement SL63 AMG, SL65 AMG with CODE P30 (AMG Performance Package) or with CODE 471 (Manual locking differential), SL65 AMG with CODE P99 (Special model "AMG Black except CODE P99 (Special model "AMG Black CODE P99 (Special model "AMG Black Parking brake, adjust cable slack Replace air filter except Replace air filter Automatic transmission - oil and filter change transmission 722.9 transmission 722.6 Replace spark plugs Replace spark plugs except Replace fuel filter, 273 except CODE P99 (Special model "AMG Black.983 with CODE P99 (Special model "AMG Black Replace coolant main circuit Replace coolant except main circuit, 273 low temperature circuit AP54.30-P-5450A AP35.00-P-3501CMG AP35.00-P-3501RBS AP42.20-P-4262R AP09.10-P-0980RMG AP09.10-P-0980RX AP09.10-P-0980H AP27.00-P-2702W AP27.00-P-2702H AP15.10-P-1580L AP15.10-P-1580RMG AP15.10-P-1580RX AP47.20-P-0780RX AP47.20-P-0780DC AP47.20-P-0780RBS AP20.00-P-2080H AP20.00-P-2080RX AP20.00-P-2080H Recommended Service Work miles (thousands) 2 10 20 30 40 50 60 70 80 90 100 110 120 130 140 150 Main/starter battery - Check fluid level and correct if necessary except CODE P99 (Special model "AMG Black AP54.10-P-5410A Horn - Electrical system check 3
Recommended Service Work miles (thousands) 2 10 20 30 40 50 60 70 80 90 100 110 120 130 140 150 Warning/indicator lamps - Electrical system check Illumination and interior lighting - Electrical system check Exterior lighting, high beam flasher, hazard warning flasher, turn signals - Electrical system check Check trunk/cargo area lighting Check and correct headlamp setting Battery (Main/starter/auxiliary) check condition using Midtronics battery tester. Attach Midtronics test report print out here Check seat belts and buckles for signs ofexternal damage and proper function Check windshield washer and headlamp cleaning system Clean Vario roof seal and apply lubricant except CODE P99 (Special model "AMG Black Check bodywork for paintwork damage Tire rotation Inspect tires for damage, measure thread depth and enter table at the end of the service sheet Check TIREFIT tire sealant expiration date Activate Tire Pressure Monitoring System refer to vehicle Operator's Manual Visually check brake system components, lines, hoses, calipers Check thickness of brake pads and discs, front and rear wheels removed pads discs Check chassis and load-bearing body components for damage and corrosion AP54.30-P-5451SLC AP54.30-P-5453SLC AP82.10-P-8252EW AP82.10-P-8260R AP54.10-U-5453A AP91.40-P-9150M AP82.30-P-8252V AP77.30-P-7735R AP98.00-P-9850BA AP40.10-P-4051Z AP40.10-P-4054R AP42.10-P-4258R AP00.20-P-0090BA Replace wiper blades High Mileage Required Service Work at 160,000 miles or 16 years; then every 20,000 miles or 2 years Plus any applicable additional work listed at the end of the service sheet Reset maintenance service indicator in instrument cluster Engine - oil and filter change.954.981/983 Check catch, safety catch and hinges on engine hood for proper operation Clean water drain in air/water duct Check condition of poly-v-belt, 273 Not OK AP18.00-P-0101RMG AP18.00-P-0101SX AP18.00-P-0101SLA AP18.00-P-0101SZ AP88.40-P-8851R AP83.10-P-8353A AP13.22-P-1352RX AP13.22-P-1352L 4
Replace brake fluid except CODE P99 (Special model "AMG Black CODE P99 (Special model "AMG Black Replace combination filter Check thickness of brake pads, front and rear Correct tire inflation pressure including spare () and enter in the table at the end of the service sheet Leakage - major components - check underbody and engine compartment for chafe marks, line routing, damaged components SL550, SL63 AMG SL600, SL65 AMG Visually inspect condition of front axle ball joints, rubber boots Visually inspect condition of driveshaft flexible discs Visually inspect condition of steering mechanical components, rubber boots Coolant - check fluid level and correct if necessary, 273; main and low temperature circuit (main circuit if not to be replaced (every 30k miles/3 yrs)) refer to AH20.00-P-1142-01V observe correct coolant composition Brake system - check fluid level and correct if necessary Power steering - check fluid level and correct if necessary the fluid level must always be on the maximum mark, corresponding to the oil temperature Windshield washer system - check fluid level and correct if necessary Active Body Control - check fluid level and correct if necessary CODE 487 (Active Body Control (ABC)) Parking brake (function test only) Audible warning system (Electro-hydraulic brake system) - function check except CODE P99 (Special model "AMG Black Reset maintenance service indicator in instrument cluster reminder - if not yet performed High Mileage Recommended Service Work at 160,000 miles or 16 years; then every 20,000 miles or 2 years Plus any applicable additional work listed at the end of the service sheet Main/starter battery - Check fluid level and correct if necessary except CODE P99 (Special model "AMG Black Horn - Electrical system check Warning/indicator lamps - Electrical system check Illumination and interior lighting - Electrical system check Exterior lighting, high beam flasher, hazard warning flasher, turn signals - Electrical system check Check trunk/cargo area lighting Check and correct headlamp setting Battery (Main/starter/auxiliary) check condition using Midtronics battery tester. Attach Midtronics test report print out here Check seat belts and buckles for signs ofexternal damage and proper function Check windshield washer and headlamp cleaning system Clean Vario roof seal and apply lubricant except CODE P99 (Special model "AMG Black Check bodywork for paintwork damage Not OK AP42.00-P-4280R AP42.00-P-4280RBS AP83.00-P-8384R AP40.15-P-4061A AP00.20-P-0053BA AP00.20-P-0053H AP33.20-P-3353BA AP41.10-P-4152Z AP46.00-P-4653F AP42.10-P-4210Z AP46.00-P-4612SLC AP82.35-P-8210N AP32.50-P-3213I AP42.00-P-4290BA AP54.30-P-5450A AP54.10-P-5410A AP54.30-P-5451SLC AP54.30-P-5453SLC AP82.10-P-8252EW AP82.10-P-8260R AP54.10-U-5453A AP91.40-P-9150M AP82.30-P-8252V AP77.30-P-7735R AP98.00-P-9850BA 5
Tire rotation Inspect tires for damage, measure thread depth and enter table at the end of the service sheet Check TIREFIT tire sealant expiration date Activate Tire Pressure Monitoring System refer to vehicle Operator's Manual Visually check brake system components, lines, hoses, calipers Check thickness of brake pads and discs, front and rear wheels removed pads discs Check chassis and load-bearing body components for damage and corrosion Replace wiper blades High Mileage Required Service Work at 170,000 miles or 17 years; then every 20,000 miles or 2 years Plus any applicable additional work listed at the end of the service sheet Reset maintenance service indicator in instrument cluster Engine - oil and filter change.954.981/983 Check catch, safety catch and hinges on engine hood for proper operation Clean water drain in air/water duct Check thickness of brake pads, front and rear Correct tire inflation pressure including spare () and enter in the table at the end of the service sheet Coolant - check fluid level and correct if necessary, 273; main and low temperature circuit (main circuit if not to be replaced (every 30k miles/3 yrs)) refer to AH20.00-P-1142-01V observe correct coolant composition Brake system - check fluid level and correct if necessary Power steering - check fluid level and correct if necessary the fluid level must always be on the maximum mark, corresponding to the oil temperature Windshield washer system - check fluid level and correct if necessary Active Body Control - check fluid level and correct if necessary CODE 487 (Active Body Control (ABC)) Audible warning system (Electro-hydraulic brake system) - function check except CODE P99 (Special model "AMG Black Reset maintenance service indicator in instrument cluster reminder - if not yet performed 6 Not OK High Mileage Recommended Service Work at 170,000 miles or 17 years; then every 20,000 miles or 2 years Plus any applicable additional work listed at the end of the service sheet Main/starter battery - Check fluid level and correct if necessary except CODE P99 (Special model "AMG Black Horn - Electrical system check Warning/indicator lamps - Electrical system check Not OK AP40.10-P-4051Z AP40.10-P-4054R AP42.10-P-4258R AP00.20-P-0090BA AP18.00-P-0101RMG AP18.00-P-0101SX AP18.00-P-0101SLA AP18.00-P-0101SZ AP88.40-P-8851R AP83.10-P-8353A AP40.15-P-4061A AP42.10-P-4210Z AP46.00-P-4612SLC AP82.35-P-8210N AP32.50-P-3213I AP54.30-P-5450A AP54.10-P-5410A AP54.30-P-5451SLC
Illumination and interior lighting - Electrical system check Exterior lighting, high beam flasher, hazard warning flasher, turn signals - Electrical system check Check trunk/cargo area lighting Battery (Main/starter/auxiliary) check condition using Midtronics battery tester. Attach Midtronics test report print out here Check windshield washer and headlamp cleaning system Clean Vario roof seal and apply lubricant except CODE P99 (Special model "AMG Black Tire rotation Inspect tires for damage, measure thread depth and enter table at the end of the service sheet Check TIREFIT tire sealant expiration date AP54.30-P-5453SLC AP82.10-P-8252EW AP54.10-U-5453A AP82.30-P-8252V AP77.30-P-7735R AP40.10-P-4051Z AP40.10-P-4054R Activate Tire Pressure Monitoring System refer to vehicle Operator's Manual Visually check brake system components, lines, hoses, calipers Check thickness of brake pads and discs, front and rear wheels removed pads discs AP42.10-P-4258R Replace wiper blades High Mileage Additional Work Rear axle differential fluid replacement SL63 AMG, SL65 AMG with CODE P30 (AMG Performance Package) or with CODE 471 (Manual locking differential), SL65 AMG with CODE P99 (Special model "AMG Black except CODE P99 (Special model "AMG Black CODE P99 (Special model "AMG Black Parking brake, adjust cable slack At 2,000 miles, then if more than 40,000 mi or 4 years since lastreplacement At 2,000 miles, then if more than 40,000 mi or 4 years since lastreplacement Once at 10,000 mi or 1 year AP35.00-P-3501CMG AP35.00-P-3501RBS AP42.20-P-4262R Replace air filter except If more than 40,000 mi or 4 years since last replacement AP09.10-P-0980RMG If more than 40,000 mi or 4 years since last replacement AP09.10-P-0980RX Replace air filter Automatic transmission - oil and filter change If more than 60,000 mi or 6 years since last replacement AP09.10-P-0980H transmission 722.9 If more than 40,000 mi or 4 years since last replacement AP27.00-P-2702W transmission 722.6 If more than 40,000 mi or 4 years since last replacement AP27.00-P-2702H Replace spark plugs Replace spark plugs except If more than 60,000 mi or 6 years since last replacement AP15.10-P-1580L If more than 80,000 mi or 8 years since last replacement AP15.10-P-1580RMG If more than 80,000 mi or 8 years since last replacement AP15.10-P-1580RX Replace fuel filter, 273 If more than 60,000 mi or 6 years since last replacement AP47.20-P-0780RX except CODE P99 (Special model "AMG Black.983 with CODE P99 (Special model "AMG Black Replace coolant main circuit If more than 60,000 mi or 6 years since last replacement If more than 60,000 mi or 6 years since last replacement If more than 30,000 mi or 3 years since last replacement AP47.20-P-0780DC AP47.20-P-0780RBS AP20.00-P-2080H 7
Replace coolant except main circuit observe correct coolant composition, 273 If more than 150,000 mi or 15 years since last replacement AP20.00-P-2080RX low temperature circuit If more than 150,000 mi or 15 years since last replacement AP20.00-P-2080H Tire inflation pressure (bar/psi) LF RF LR RR Spare Tire thread depth (mm) LF RF LR RR outside center inside 8