120 Mdel: TM-3 INSTALLATION AND OPERATION INSTRUCTIONS IF YOU CANNOT READ OR UNDERSTAND THESE INSTALLATION INSTRUCTIONS DO NOT ATTEMPT TO INSTALL OR OPERATE INTRODUCTION This Wired Wall Timer system was develped t prvide safe, reliable, and user-friendly remte cntrl system fr gas heating appliances. The timer is intended as a replacement fr manual ON/ switches that currently perate millivlt and electrnic ignitin appliances. WALL TIMER The wall timer perates n (2) 3V buttn cell batteries (included). Befre using the wall timer, install the tw (2) 3V buttn cell batteries. Fllw instructins belw. Indicatr Light 30 MIN 60 MIN 120 MIN The wall timer has 30 MIN, 60 MIN, 120 MIN, and buttns. 30 MIN: Appliance will burn fr 30 minutes then turn ff autmatically 60 MIN: Appliance will burn fr 60 minutes then turn ff autmatically 120 MIN: Appliance will burn fr 120 minutes then turn ff autmatically : Will manually turn appliance burner ff. When any f the buttns n the wall timer is pressed, an indicatr light n the wall timer s face illuminates t verify that a signal has been sent. If the signal light des nt illuminate, r becmes dim, check/replace the batteries. TO INSTALL BATTERIES 4. Remve face frm backing plate by inserting a small screwdriver int the small slt at the tp r bttm f the faceplate as shwn belw then snap ff. Lcate the (2) hlders fr the 3V buttn cell batteries. Place the buttn cell batteries int the battery hlders, inserting the tp edge f the battery underneath the metal clips, and snap int place. (Make sure that the batteries are installed with the (+) plus side as shwn t the right. After the batteries are installed replace the faceplate n the base. TO REMOVE THE BATTERIES Remve face frm backing plate by inserting a small screwdriver int the small slt n the side at the tp r bttm f the faceplate as shwn t the right then snap. Lcate the (2) hlders fr the 3V buttn cell batteries. Insert a small screwdriver int the slt at the buttn cell battery and pp the battery ut (Slts shwn in picture abve). Insert batteries int hlder and snap int hlder Insert small screwdriver int slt and pp ut batteries frm hlder 30 60 + Plus Side 30 MIN 60 MIN 120 MIN + Plus Side Insert small screwdriver int slt at the tp r bttm and pp cver ff REV 12-26-13 Page 1
INSTALLATION INSTRUCTIONS WARNING This remte cntrl system must be installed exactly as utlined in these instructins. Read all instructins cmpletely befre attempting installatin. Fllw instructins carefully during installatin. Any mdificatins f this remte cntrl r any f its cmpnents will vid the warranty and may pse a fire hazard. D nt cnnect any gas valve r electrnic mdule directly t 110-120VAC pwer. Cnsult gas appliance manufacturer s instructins and wiring schematics fr prper placement f all wires. All electrnic mdules are t be wired t manufacturer s specificatins. The fllwing wiring diagrams are fr illustratin purpse nly. Fllw instructins frm manufacturer f gas valve and/r electrnic mdule fr crrect wiring prcedures. Imprper installatin f electric cmpnents can cause damage t electrnic mdule, gas valve and remte receiver. WIRING INSTRUCTIONS A qualified electrician r a gas technician wh is familiar with the gas appliance and gas valves that will be perated by this cntrl shuld install the remte cntrl system. Incrrect wiring cnnectins WILL cause damage t the gas valve r electrnic mdule perating the gas appliance and may als damage the cntrl. Remval f Existing Wall Switch Lcate the manual ON/ wall switch that cntrls the gas appliance. Remve the screws hlding the cver plate ver the existing switch t expse the switch. Remve the screws that secure the existing switch t the junctin bx. Gently pull the existing switch ut f the junctin bx. Discnnect the tw wires frm the existing switch. Cnnecting the TM-3 Wall Switch NOTE: Strip all wires t be cnnected t the wall timer t a length f 0.25. T much expsed wire can result in a shrt circuit that culd cause the appliance burner t turn ON accidentally. Insert the tw wires riginally cnnected t the manual ON/ switch int the blck terminals n the back f the wall timer. The wires must be inserted frm the bttm f the blck terminal. The rientatin f the wires des nt matter. Tighten the screw n the back f the terminal blck with a small screwdriver t secure the wires in the terminal blck. Gently pull n the wires t ensure they are secure in the terminal blck. Tighten screws t secure wire Insert wires frm bttm SYSTEM CHECK Millivlt Valves Light the gas appliance s pilt flame fllwing the lighting instructins that came with the appliance. Cnfirm that the pilt flame is n; it must be in peratin fr the main gas valve t perate. Press either the 30 MIN, 60 MIN, r 120 MIN buttns. The main gas flame (i.e., the fire) shuld ignite. Press the buttn. The flame shuld extinguish (the pilt flame will remain n). Electrnic Ignitin Systems Press either the 30 MIN, 60 MIN, r 120 MIN buttns. The spark electrde shuld begin sparking t ignite the pilt. After the pilt flame is lit, the main gas valve shuld pen and the main gas flame shuld ignite. Press the buttn. The main gas flame and pilt flame shuld BOTH extinguish. MOUNTING THE WALL TIMER 4. Remve face frm backing plate by insetting a small screwdriver int the small slt at the tp r bttm f the faceplate then snap. Lcate the (2) tw munting slts which align with the munting hles in a standard single-gang junctin bx. Use the (2) tw munting screws (supplied) t munt the base plate t the junctin bx in the wall as shwn. Snap the cver plate in-place ver the face f the wall timer. 30 60 120 3V 3V REV 12-26-13 Page 2
BATTERY LIFE Life expectancy f the alkaline batteries in the wall timer shuld be at least 12 mnths. Check and replace all batteries annually. When the indicatr light n the face f the wall timer becmes dim r des nt light when a buttn is pressed, r if the wall timer des nt functin at all, the batteries shuld be checked. The Wall Transmitter shuld perate with as little as 4 vlts f battery pwer, measuring each f the 3-vlt buttn cell batteries individually. The length f the wire between the remte receiver and gas valve directly affects the perating perfrmance f the remte system. The lnger the wire, the mre battery pwer is required t deliver signals between the remte receiver and the gas valve. Recmmended length is n lnger than 30 feet. TROUBLE SHOOTING If yu encunter prblems with yur fireplace system, the prblem may be with the fireplace itself r it culd be with the Wall timer. Review the fireplace manufacturer s peratin manual t make sure all cnnectins are prperly made. Then check the peratin f the wall timer in the fllwing manner: Make sure the batteries are crrectly installed. One reversed battery will keep cntrl frm perating prperly. Check if the batteries are fully charged. Replace the batteries if they measure less than 4 vlts (each battery individually). Make sure the wires cnnected t back f the wall timer have nt cme lse and are firmly cnnected. Make sure the wires cnnected t the back f the will timer are nt tuching each ther r anther bare metal surface, this will cause the appliance t turn ON. The wires shuld be stripped t a length f 0.25 t prevent this cnditin. SPECIFICATIONS BATTERIES: Tw 3V Buttn Cell Batteries (CR-2032) OUTPUT: Dry-Cntact fr up t 800mV DC r 24VAC FCC REQUIREMENTS NOTE: THE MANUFACTURER IS NOT RESPONSIBLE FOR ANY RADIO OR TV INTERFERENCE CAUSED BY UNAUTHORIZED MODI- FICATIONS TO THE EQUIPMENT. SUCH MODIFICATIONS COULD VOID THE USER S AUTHORITY TO OPERATE THE EQUIPMENT Fr Technical Service, call: U.S. INQUIRIES (855) 498-8324 r (260) 459-1703 CANADIAN INQUIRIES (877) 472-3923 Fr Sales: (888) 672-8929 Web site: www.skytechpg.cm MANUFACTURED EXCLUSIVELY FOR SKYTECH II, INC REV 12-26-13 Page 3
Limited Lifetime Warranty SKYTECH warrants the SKYTECH REMOTE CONTROL SYSTEM fr a Limited Lifetime f the riginal wner f this system. This warranty is nt transferable t anther persn it is fr the riginal purchaser f the prduct. Shuld any part fail because f defective wrkmanship r material frm the riginal date f purchase. SKYTECH will repair r, at SKYTECH ptin, replace the defective parts. Replacement parts will be available at n charge fr the first (5) five years f this warranty, and will be available at market cst fr the Lifetime f the prduct t that riginal wner. If SKYTECH des nt have the parts fr an individual mdel, then a replacement SYSTEM will be prvided. At n charge fr the first (5) five years and sld at market cst fr the Lifetime f that prduct t the riginal wner. The Owner must prvide a bill f sale, cancelled check, r payment recrd shuld be kept t verify purchase date and establish warranty perid. Travel, diagnstic cst, service labr t repair the defective SYSTEM, and freight charges n warranty parts t and frm the factry will be the respnsibility f the wner. SKYTECH will nt be respnsible fr labr charges and/r damage incurred in installatin, repair, replacement, r fr incidental r cnsequential damages. Batteries and any damage caused by them are nt cvered by them are nt cvered by this warranty. This warranty des nt cver claims, which d nt invlve defective wrkmanship r materials. Damage t the SYSTEM caused by accident, misuse, abuse, r installatin errr, whether perfrmed by a cntractr, Service Cmpany, r wner, is nt cvered by this warranty. Mdificatin f the SKYTECH prduct will vid this warranty. IN NO EVENT SHALL SKYTECH BE LIABLE FOR INCIDENTAL AND CONSEQUENTIAL INCLUDING THE IMPLIED WARRANTIES OF MERCHANTABILITY AND FITNESS, ARE LIMITED TO THE DURATION OF THIS WRITTEN WARRANTY. THIS WARRANTY SUPERSEDES ALL OTHER ORAL OR WRITTEN WARRANTIES. Sme States d nt allw the exclusin r limitatin f incidental and cnsequential damages r limitatin n hw lng an implied warranty lasts, s the abve limitatin may nt apply t yu. This warranty gives yu specific rights and yu may have ther rights, which vary frm state, prvince, and natin. Hw t Obtain Service: Cntact SKYTECH r yur SKYTECH Dealer direct with the fllwing infrmatin: Name, Address, Telephne Number f Owner Date f Purchase, Prf f Purchase Mdel Name, Date Cde f Prduct and any relevant infrmatin r circumstances, cncerning installatin, mde f peratin and/r when defect was nted Warranty claim prcess will start with all f this infrmatin. SKYTECH will reserve the right t physically inspect the prduct fr defects, by authrized representatives. Print infrmatin and detach at dtted line fr return t: Skytech, 9230 Cnservatin Way, Frt Wayne, IN 46809 Telephne: (888) 672-8929 Warranty Infrmatin Purchase Date: Mdel: Date Cde: Purchased Frm: Custmer Name: Phne: Sample date cde is 1311 Address: City: State/Prv. Zip/Pstal Cde: Please send a Prf f Purchase (riginal receipt) cpy alng with yur warranty frm.
Santa s Helper Exclusive ffer t Skytech Remte Cntrl Owners This special ffer is nly prvided t custmers f Skytech that have purchased a remte cntrl fr their Hearth Prduct. This remte cntrl system can be used fr any 120VAC appliance, but perfect yur Christmas Tree Lights r any ther appliance that is difficult t reach r plug in. Simply plug the receiver int yur wall utlet and yur appliance int the receiver, push the ON buttn n the transmitter and yu are in business. It s that easy! The list price f $48.00 fr the Santa s Helper has been cut almst in half t $20.00 USD fr this exclusive ffer. Shipping and handling f $5.00 $USD shuld be added. Send us yur check, mney rder r call us with yur credit card number, alng with the warranty infrmatin frm yur remte cntrl f yur Hearth Prduct. Yu can als send it via mail, fax, r e-mail. Skytech Prducts Grup 9230 Cnservatin Way Frt Wayne, IN 46809 1-(888) 672-8929 1-(888) 672-8024 Fax E-mail : rder@skytechpg.cm