DI158 DIAGNOSTIC TROUBLE CODE CHART HINT: ENGINE (2JZGTE) Parameters listed in the chart may not be exactly the same as your reading due to the type of instrument or other factors. If a malfunction code is displayed during the DTC check in check mode, check the circuit for that code listed in the table below. For details of each code, turn to the page reffered to under the See page for the respective in the DTC chart. DI4SI01 P0100 (DI170) P0101 (DI174) P0110 (DI175) P0115 (DI179) P0116 (DI183) P0120 (DI184) P0121 (DI189) P0125 (DI190) Mass Air Flow Circuit Mass Air Flow Circuit Intake Air Temp. Circuit Engine Coolant Temp. Circuit Engine Coolant Temp. Circuit Throttle / Pedal Position Sensor / Switch A Circuit Throttle /Pedal Position Sensor / Switch A Circuit Range / Peformance Problem Insufficient Coolant Temp. for Closed Loop Fuel Control Open or short in mass air flow meter circuit Open or short in intake air temp. sensor circuit Intake air temp. sensor Open or short in engine coolant temp. sensor circuit Engine coolant temp. sensor Engine coolant temp. sensor Cooling system Open or short in throttle position sensor circuit Throttle position sensor Throttle position sensor Open or short in heated oxygen sensor circuit Heated oxygen sensor Heated Oxygen Sendor Circuit P130 (DI193) Heated Oxygen Sensor Circuit P0133 Slow Response (DI196) *:... MIL lights up Heated oxygen sensor Fuel trim malfunction Heated oxygen sensor Author: Date: 386
DI159 ENGINE (2JZGTE) P0135 (DI197) Heated Oxygen Sensor Heater Circuit Open or short in heater circuit of heated oxygen sensor Heated oxygen sensor heater P0136 (DI199) P0141 (DI197) Heated Oxygen Sensor Circuit (Bank 1 Sensor 2) Heated Oxygen Sensor Heater Circuit (Bank 1 Sensor 2) Heated oxygen sensor Same as P0135 Air Intake (hose loose) Fuel line pressure P0171 (DI201) System too Lean (Fuel Trim) Injector blockage Heated oxygen sensor malfunction Engine coolant temp. sensor Fuel line pressure P0172 (DI201) System too Rich (Fuel Trim) Injector blockage, leak Heated oxygen sensor malfunction Engine coolant temp. sensor P0300 (DI204) Random / Multiple Cylinder Misfire Detected Ignition system Injector P0301 P0302 P0303 P0304 P0305 P0306 (DI204) Misfire Detected Cylinder 1 Cylinder 2 Cylinder 3 Cylinder 4 Cylinder 5 Cylinder 6 Fuel line pressure EGR Compression pressure Valve clearance not to specification Valve timing Engine coolant temp. sensor P0325 (DI209) Knock Sensor 1 Circuit Open or short in knock sensor 1 circuit Knock sensor 1 (looseness) P0330 (DI209) Knock Sensor 2 Circuit Open or short in knock sensor 2 circuit Knock sensor 2 (looseness) Open or short in crankshaft position sensor circuit for NE sig- P0335 (DI212) Crankshaft Position Sensor A Circuit nal Crankshaft position sensor for NE signal Starter *:... MIL lights up Author: Date: 387
DI160 ENGINE (2JZGTE) Open or short in camshaft position sensor circuit Camshaft position sensor P0340 (DI215) Camshaft Position Sensor Circuit Open or short in crankshaft position sensor circuit for NE2 signal Crankshaft position sensor for NE2 signal Starter EGR valve stuck closed P0401 (DI217) Exhaust Gas Recirculation Flow Insufficient Detected Short in VSV circuit for EGR Open in EGR gas temp. sensor circuit EGR hose disconnected EGR valve stuck open P0402 (DI227) Exhaust Gas Recirculation Flow Excessive Detected EGR VSV open malfunction Open in VSV circuit for EGR Short in EGR gas temp. sensor circuit P0420 (DI231) Catalyst System Efficiency Below Threshold Threeway catalytic converter Open or short in heated oxygen sensor circuit Heated oxygen sensor Open or short in VSV circuit for EVAP P0441 (DI234) Evaporative Emission Control System Incorrect Purge Flow VSV for EVAP Vacuum hose blocked or disconnected Charcoal canister Open or short in vehicle speed sensor circuit P0500 (DI238) Vehicle Speed Sensor Vehicle speed sensor Combination meter IAC valve is stuck or closed P0505 (DI240) Idle Control System Open or short in IAC valve circuit Open or short in A/C signal circuit Air intake (hose loose) P0510 (DI243) Closed Throttle Position Switch Open in closed throttle position switch circuit Closed throttle position switch *:... MIL lights up Author: Date: 388
DI161 ENGINE (2JZGTE) DTC CHART (Manufacture Controlled) P1100 (DI247) Barometric Pressure Sensor Circuit MAlfunction Open or short in fuel pump ECU circuit P1200 (DI248) Fuel Pump Relay / ECU Circuit Fuel pump ECU power source circuit Fuel pump P1300 (DI252) Igniter Circuit Open or short in IGF or IGT circuit from igniter to ECM Igniter Open or short in crankshaft position sensor circuit for NE sig- P1335 (DI257) Crankshaft Position Sensor Circuit (during engine running) nal Crankshaft position sensor for NE signal Starter P1400 (DI258) Sub Throttle Position Sensor Open or short in sub throttle position sensor circuit Sub throttle position sensor P1401 (DI261) Sub Throttle Position Sensor Sub throttle position sensor P1405 (DI262) Turbo Pressure Sensor Circuit Open or short in turbo pressure sensor circuit Turbo pressure sensor P1406 (DI265) Turbo Pressure Sensor Circuit Turbo pressure sensor Air intake (leakage or clogging) Actuator (for waste gate valve, IACV control valve, exhaust P1511 (DI266) Boost Pressure Low bypass valve and exhaust gas control valve) Short in VSV for waste gate valve, IACV control valve, exhaust bypass valve and exhaust gas control valve circuit Actuator (for waste gate valve and exhaust bypass valve) P1512 (DI274) Boost Pressure High Short in VSV for waste gate valve and exhaust bypass valve circuit P1520 (DI279) Stop Light Switch Signal Short in stop light switch signal circuit Stop light switch P1600 (DI282) ECM BATT Open in back up power source circuit *:... MIL dose not light up... MIL lights up Author: Date: 389
DI162 ENGINE (2JZGTE) P1605 (DI284) Knock Control CPU Open or short in ETC+ or ETC circuit P1630 (DI285) Traction Control System Open or short in EFI+ or EFI circuit Throttle control ECU P1652 (DI287) IACV Control CIrcuit Open or short in VSV circuit for IACV VSV for IACV P1658 (DI291) Waste Gate Valve Control CIrcuit Open or short in VSV circuit for waste gate valve VSV for waste gate valve P1661 (DI294) Exhaust Gate Valve Control CIrcuit Open or short in VSV circuit for exhaust gate control valve VSV for exhaust gate control valve P1662 (DI297) Exhaust Bypass Valve Control CIrcuit Open or short in VSV circuit for exhaust bypass valve VSV for exhaust bypass valve P1780 (DI300) Park / Neutral Position Switch Short in park / neutral position switch circuit Park / neutral position switch *:... MIL dose not light up... MIL lights up Author: Date: 390