MILITARY SPECIFICATION SHEET

MIL-c-39014/5E 16 Au~vt 1978 SUPERSEDING MIL-c-39014/5D 9 February 1977 MILITARY SPECIFICATION SHEET CAPACITORS, FIXEO, CERAMIC DIELECTRIC ~:: (GENEIiIILpuRPosE),.. ESTABLISHED RELIABILITY, STYLES CKR1l, CKR12, CK2i14, CKR15, ANO CKR16 This specifii.$tion is approved for use by all Departments and Agencies of the Department of Oefen se. The complete requirements for procuring the capacitors described herein shall consist of this document and the latest issue of Specification MI L-C-39014. FAILURE RATE LEvEL b,l,, IS INACTIVE FOR NEM OESIGN AFTER 31 OCTOBER 1975.....,,.. 1!N1.tit>.002.0.015.019.0.025.027.030.090.140.1,160.2.3.390.0.690 1.2 MM.05.25.38.48.51.64.69.76 2.29 3.56 3.B1 4.o6 6.35 8.89 9.91 12.70 17.53 31.75 FStyle CKRII CKR12.160i.0.25O*.O1O.090*.O1O.019+.002.090*.O1O.019+.002 CKRII CKR12 ECKR14 CKR15 CKR16.390*.O1O.140+.0.025i.002.0i.0.2f.015.690~. 030 =+=.3*.0.025+.002 I I I CKR15 CKR16 n APPROX ACTUAL SIZE NOTES: 1. Dimensions are in inches. 2. Metric equivalents are given for general information only and are based upon 1.00 inch = 25.4 mm. 3. Nonconductive material shal 1 not extend beyond.0 (.25 mm) from end of capacitor body. 4. Lead length may ba a minimum of one inch long for se in tape and reel automatic insertion equipment, when specified in the ordering data. FIGURE 1. Capacitors, styles CKRI1, CKR12, CKR14, CKR15, CKR16 and dimensions. ~de otes chmg,s Page 1 of FSC 59

MIL-C-3YO14/5E RECJUIREMENTS : Oime,jsions and configuration. See figure 1. Case type - Tubular, molded or preformed plastic encapsulatc!d. Capacitance value - See table 1. Capacitance tolerance - See table 1. 0per3ting temperature range - -55 c to +125 c. Voltdge rating - See table 1. Radiographic inspection (failure rate level S (0.001 percentll,000 hours only)) - In accordance with MIL-C-39014, Dissipation factor - Not more than 2.5 percent for BX; not more than 3.0 percent for BR. Dielectric withstanding voltage - Body insulation shall be able to withstand 0 Vdc between leads and case. Insulation resistance: ~t 25eC - Nat less than o,odo megohms or 1,000 me~ohm-microfarads whichever At 125 c - Not less than,000 megohms or 0 megohm-microfarads whichever is is less. less. Seal - Not applicable. Voltage-temperature?imits - In accordance with MIL-C-39014. Capacitance change with referent,? to 25 C Symbol Steps A through D Steps E through G of table V of table V Bias = O volts Bias = rated voltage BX +15 percent +15, -25 percent as applicable (see table 1) BR t15 percent +15, -40 Percent as applicable (see table 1) Inmrarsion - IR not less than percent of initial Z5 C requira!ent. Salt spray (corrosion) - Not applicable. Resistance to soldering heat - AC +, -O percent from initial measured value. L4fe: Rated conditions - 0 percent of dc rated voltage at 125 C. O through 3,000 hours: IR - At 25 c, not less than percent of initial 25 C requirement. At 12S C. not less than Dercent of initial 125 C requirement. Ac - 1 percent from initial measured value. Dissipation factor - Not greater than 2.S percent for BX; not more than 3.0 percent f, RR. 4,000 through 32,000 hours: IR - At 25 c, not less than 15 percent of initial 25 C requirement. At 125 c, not less than 15 percent of initial 125 C requirement. fic i percent from initial measured value. Dissipation factor - Not greater than 2.5 percent for BX; not more than 3.0 percent for BR. 2

..., :::,141L-c,-3901f/.5E 2,;}... @fi.,.,~,,.:.:, ;,, ~j;,.,,.l #,~~~l~~~td cmiftim,-::0 percerit~ofdc:katwv Alti96:at :l?~c7$ ~~----:.!-..-, --,,- ----------........._..., -_ O and 2 huurs: ;,.,,., lr.- At 25 c, not less than percent of initial 25 C requirement.. ~ At 125 c, mt less than percent of initial 1Z5 C r,wir~e~!:-:- AC + percent from initial measured value. ; ~,. Dissipation factor - Not greater, than 2.5 percent. for BX; not nmre :h~n. ~.O Percent,, for BR:.,,,.,....,:::,; ;. ~.., ~~ 1,000, 2,000 arid 4.Ooo h!urs: -,IR - At 25 C, ot less than 15 percent Of initial?5 C requi~~ent. At 125 C. not less than.15 percent of initial 12~C requir~ent. Ac *2o percent from initial measured value. : Olssi pation factor -.. Not greater than 2.5 percerit for 8X; not more than 3.0 Percent for BR,..~;.:.,.,. Part; number - M39014/05-(dash number from table 1)..: Narking - In accordance with MIL-C-39014, except that minimum marking as shown in the following example will be pemnitted for styles CKR1l and CKR12. Full markin9 shall be included on the package. CKRII and CKA12 J for JAN ~ Trademark 4, Capacitance.- --D17S6 ~~.. Ez: &-&<~!!l ~~~,(K. %, M = %)..,. Lot code ~~A ~C~o;On.. (1 xeek intervals)..,. @ TABLE 1.. Oash number and electrical characteristics. Oash number Oc Failure rate level Capacitance rated (%/1,000 hours).o(m) O.l(P) I 0.01 (R) I 0.001 (s).capacitance tolerance voltage Style CKR1l, voltage-temperature limits of *15% and +15; -25% ~ *percent ~ 21 0 22 13 0 23 12 0 24 15 i, 1 0 25 1s 0 26 18 0 27 22 0 28 22 0 22o9 27 0 22 33 0 2211 33 0 2212 39 0 2213 47 0 2214 47 0 2215 56 0 2216 68 0 2217 6B 0 221B 0 2219 1:: 0 22 0 0 2221 1 0 2222 1 0 2223 1 0 3.......

ii3l-12-39014i 5E ) TABLE I. Dash number and electrical : : z Dash number ~... Failure rate level (%/1, 000 hours) I.O(M) o.l(p) 0.01(R) o.001(s) : Giz%Gx 2624 2625 2626 2621 2626 2629 2630 2631 2632 263~ 2634 263$ 263 $ 2631 2638 263q 264d 2641 2642 26!3 264+ 26$s.2646 2647 26+ 26+!l 2659 241 26.f2 26f3 2654 2655 26% &yḷ Stvle CKR11,volage-temc :ature Iimi{ 2824 2825 2626 2827 2626 2629 2630 2631 2632 2633 2634 2835 2636 2637 2636 2839 2840 2841 2642 2843 2844 2645 2646 2647 2846 2649 28 2651 2652 2653 2854 2655 2656 :KR12, 24 25 26 27 28 29 30 31 32 33 34?,035. 36 37 38 39 40 41 42 43 44 45 46 47 46 49 51 52 53 54 55 56.tige-tenq 2224 2225 2226 2227 2226 2229 2230 2231 2232 2233 2234 2235 2236 2237. 2236 2239 2240 2241 2242 2243 2244 2245 2246 2247 2246 2249 22 2251 2252 2253 2254 2255 2256.ature limit: racleristics --.,. capacitance ~p 160 2 2 270 330 330 390 470 470 580 660 680 8 1,000 1,000 1,0 1,0 1, 0 1,600 2,0 2,0 2,700 3,300 3,300 3,900 4,700 4,700 5,600 6,600 6,600 6,0,000,000.,,...:...,,.,.,, 5,.,.,,:ḊC rated tolerance voltage. * percent volts?t 15% and 5. -25% ~ * percent 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 volt s 2651 2656 2659 2660 2661 2662 2663 2664 2665 2666 266 1 2666 2669 2857 2658 2859 2,860 2661 2862 2863 2664 2665 2666 2861 2866 2869 57 58 59 7.060 61 62 63 64 65 66 67 68 69 2257 2256 2259 2260 2261 2262 2263 2264 2265 2266 2267 2268 2269 J- 5,600 6,600 6,600 8,0,000 ;0>000 12,000 15,000 I5, 000 [6, 000 22,000 22,000?7, 000 -.. 0 0 0 0 0 0 4

MfL-c-39014/5E @ TABLE 1: Dash number and electrical.&racteristics. -Continued _.-.. _ Dash number Failure rate level DC (%/1, 000 hours) Capacitance rated I. O(M) 9. l(p) O.O1(R) o. 001(s) Capacitance tolerance voltage X yle CKR12, voltage-temperature limits of + 15% and + 15, -25% -Continued 2675 267s 2677 267s 2679 26SO 26sl 2662 26s3 2684 2685 2686 2667 2688 2669 2690 2691 2692 2693 2694 2695 2696 2697 2698 2699 27OO 27o1 27o2 2703 2704 2705 Style CKR14, voltage-temperature fiinits of 15% and 2675 2s76 2877 2878 2879 2860 2661 2682 2883 2884 28S5 2886 2887 2666 28S9 2890 2891 2892 75 76 7~ 78 79 80 61 62 83 s4 65 86 87 86 89 90 91 92 2275 2276 2271 2278 2279 2280 2281 2282 2283 2284 2285 2286 2267 2288 2289 2290 2291 2292 @ 12,000 15,000 15,000 1s; 000 22,000 22,000 27.000 33; 000 33,000 39,000 47,000 47,000 56,000 68,000 66,000 S2, 000 0,000 0,000 Style CKR14, voltage-temperature limits of * 1570 and Style I 2893 2894 2695 2896 2897 2898 2699 2900 2901 2902 2903 2904 2905 93 94 95. 96 97 98 99 21 22 23 24 25 2293 2294 2295 2296 2297 2298 2299 2300 2301 2302 2303 2304 2305 KR15, voltage-temperature limit PF 56,000 68,000 68,000 82,000 0,000 0>000 1,000 1,000 1,000 160,000 2,000 2.000 270:000 @ 56,000 68,000 S8, 000 * percent volts 5, -25% * percent,. 5, -40% * percent,f +15 Yoand +15, -25% * -........ volts 0 0 0 0 0 0 0 0 0 0 0 0....-.. volts ~ 0 0 0 0 0 0 0 0 0 5

MIL-C-39014 5E @ TABLE 1. Dash number and electrical characteristic?. -Continued. ~.......... ~.... -. _... Dash number Failure rate level (%/1, 000 hours) 1.O(M) I o. I(P) O. O](R) I 0.001 (9 - Capacitance J=*. tolerance tyle CKff15, voltage-temperature limits of *15% and +15, -25% - Continued I I@ i~l~ -wmle131:::!fi~~ 0 000 StyleCKR15, voltage-temperature limits of + 15 % and + 15, -40% pf * percent volts 2712 2713 2?14 2715,2716 2717 2718 2719 27 2721 2722 2723 2724 2725 2726 Style CK 2912 2913 2914 2915 2916 2917 2918 2919 292o 2921 2922 2923 2924 2925 2926!,Voltag 2112 2113 2114 2115 2116 2117 2118 2119 21 2121 2122 2123 2124 2125 2126 temperah 2312 2313 2314 2315 2316 2317 2318 2319 23 2321 2322 2323 2324 2325 2326 : limits of 1,000 1,000 1, Ooc 180, Oocl 2, 00[1 2,000 270,000 330,000 330,000 470,000 470,000 660,000 680,000 1,000,000 ~, 000,000 ~0 and +1.5, ~ r - + percent 0 0 0 0 0 0 0 0 0 volts 2121 2728 2729 2730 2731 2732 2733 2734 2735 2736 2927 2928 2929 2930 2931 2932 2933 2934 2127 2126 2129 2130 2131 2132 2133 2134 2935 i135 2936 2136 2327 2326 2329 2330 2331 2332 2333 2334 2335 2336 470,000 470,000 680,000 680,000 1,000,000 1,000,000 2,0,000 220,000 3, 300, Oclo 3,300, Oclo 0 0 0 0 0 0 ;upersession data: See table If. 6

MIL-c-39014/5E TABLE II. Substititabilit y data. 1/ See fmtmte at end of table. 7 1

MI L-C-39014;5E MIL-C-39014,1 M. 2457 2458 2459 2460 2461 2462 2463 2464 2465 2466 2461 2468 2469 2470 2471 2412 2473 2414 2475 2476 2477 2478 2479 2480 2481 2482 2483 2484 2485 2486 2487 2488 2489 2490 2491 2492 2493 2494 2485 2496 2497 2498 2499 20 21 25o2 25o3 24 25 26 2657 2658 2659 2660 2661 2662 2663 2664 2665 2866 2667 2868 2669 2670 2671 2672 2873 2674 2675 2676 2677 2678 2679 2680 2681 2662 2683 2684 2685 2686 2687 2686 2689 2690 2691 2692 2693 2694 2695 2686 2697 2698 2699 2700 2701 2702 27o3 2704 27o5 2706 TABLE II. Substitutability data. -Continued Dash no. in, ic, 5D P 2857 2858 2659 2860 2681 2862 2863 2884 2865 2866 2867 2666 2869 2870 2871 2872 2873 2874 2875 2876 2877 2678 2879 2680 2881 2862 2883 2864 2885 2686 2887 2888 2689 2890 2891 2892 2893 28s4 2695 2896 2697 2898 2899 29oO 29o1 2902 2903 2904 29o5 2906 27 2707 2907 28 2706 2908 29 2709 2909 25 27 29 Q 57 58 I 59 60 61 62 63 64 ~ 65 66 67 68 69 70 71 72 73 14 I 75! 76 77 78 79 80 81 82 s3 64 85 86 87 88 89 90 91 92 93 94 95 96 97 98 99 21 22 23 24 25 26 27 28 29 21 s 2257 2258 2259 2260 2261 2262 2263 2264 2265 2266 2267 2268 2269 2270 2271 2272 2273 2274 2275 2276 2277 2278 2279 2280 2261 2262 2283 2284 2285 2266 2261 2288 2289 2290 2291 2292 2293 2294 2295 2296 2297 2298 2299 23OO 23o1 2302 2303 2304 2305 2306 2307 2308 2309 23 L 0457 0458 0459 0460 0461 0462 0463 0464 0465 0466 0467 0466 0469 0470 0471 0472 0473 0474 0475 0476 0477 0478 0479 0480 0481 0482 0483 0464 0485 0486 0487 0486 0489 0490 0491 0492 0493 0494 0495 0496 0497 0498 0499 00 01 02 03 04 05 06 07 08 09 05 Substitutable fordash no. :MIL-c-39014/5B iv[ P R 0657 0857 0658 0658 0659 ~ 0859 0660 0860 0661! 0861 0862 : 0862 0663 ~ 0863 0664 I 0864 0665! 0S65 0668 / 0866 0667 ~ 0S67 06.66 0668 0t69 0670 0C;71 0872 0673 0874 0875 0676 0677 0676 0!879 0680 0,381 0,582 0683 0664 0685 0666 0687 0668 0689 0690 0691 0692 0693 0694 0695 0698 0697 c 898 c1699 C1700 (1701 0702 0703 0704 0705 0706 0707 0706 0709 07 0869 0870 0871 0672 0873 0874 0675 0876 0677 0878 0879 0880 0861 0862 0883 0884 0665 0886 0887 0688 0869 0890 0691 0892 0893 0894 0895 0896 0897 0896 0699 0800 0901 0902 0903 0904 0905 0906 0907 0908 0909 09 57, 56 59 60 61 62 63 64 65 66 67 68 89 70 71 72 73 74 75 76 77 78 79 80 81 62 83 84 85 86 67 86 89 90 91 92 93 io94 95 96 97 96 99 10 11 12 13 14 15 16 17 18 19 11 in s 1257 1258 1258 1260 1261 1262 1263 1264 1265 1266 1267 1266 1269 1270 1271 1272 1273 1274 1275 1276 1277 1276 1279 1280 1261 1282 1263 1284 1285 1286 1267 1288 1289 1290 1291 1292 1293 1294 1295 1296 1297 1296 1299 1300 1301 1302 1303 1304 1305 1306 1307 1308 1309 13 ~! SW footnote at end of table 6

, 1 D F?d2L-C-390 L M 2511 2711 2512 2712 2513 2713 2514 2714 2515 2715 2516 2716 2517 2717 2518 2718 2519 2719 25 27 TABLE II. Ino. in./ f5c, 51 - P R s 2911 2912 2913 2914 2915 2916 2917 2918 2919 29 2921 2922 2923 2924 2925 2926 2927 2926 2929 2930 2931 2932 2933 2934 2935 2936 2111 2112 2113 2114 2115 2116 2117 2116 2119 21 2121 2122 2123 2124 2125 2126 2127 2128 2129 2130 2131 2132 2133 2134 2135 2136 Substihdabilityd ata. -Contbmed 2311 2312 2313 2314 2315 2316 2317 2318 2319 23 2321 2322 2323 2324 2325 2326 2327 2328 2329 2330 2331 2332 2333 2334 2335 2336 L 0511 0512 0513 0514 0515 0516 0517 0516 0519 05 0521 0522 0523 0524 0525 0526 0527 0528 0529 0530 0531 0532 0533 0534 0535 0536.MII-c-39014/5E Substitutable fordasbno.in M 0711 0712 0713 0714 0715 0716 0717 0718 0719 07 0721 0722 0723 0724 0725 0726 0727 0728 0729 0730 0731 0732 0733 0734 0735 0736 MIL-c-39014/5B.: P R.s 0911 1111! 1311 0912 1112 1312 0913 1113 1313 0914. 1114 1314 0915 1115 1315 0916 1118 1316 0917 1117 1317 0918 1118 1318 0919 1119 1319 09 11 13 0921 1121 1321 0922 1122 13~2 0923 1123 1323 0924 1124 1324 0925. 1125 1:25 0926 1126 1326 0927 1127 13:?7., 0928 1126 1328 0929 1129 1329 0930 1130 1330 0931 1131 1331 0932 1132 1332 0933 1133 1333 0934 1134 1334 0935 1135 1335 0936 1136 1336 J. 1/ Dae.h numbers in lower FR level Columns aresubstitutaple higher FR level columns. r dash number: all NOrE: As indicated intable II, CKR12 items previously covered by MIL-C-39014/5A and MIl,-C-39014/5 arenowredlaced bvdhvsicallv smaller CKR1l items. It isalsoto be noted that units of 6,600- and,ooo-pf ~apacitan~e vahies rated at 0voltsdcat 85QC (5Opercent deratkg for125" C)mereplaced with uitsrated atvolt6at both 85a Cadl25"C. EXAMPLE: MIL-c-39014/5A MIL-c-39014/5B,~;;c;3p;E5c z~: ~ Since all previous FRlevel testing was accomplished at 125 C, no FRlevel was ever established for tbe 85 Crating. The newer items in regard to FRlevel testing more closely resemble the items they supersede., 9

MIL-c-39014/5E Packaging: Capacitors will be furnished in tape and reel packaging when so specified in the ordering data. Application notes: @Glass.asesshall "olonger resupplied tothisspecificatlo,l sheet. Ifaglass cased part is desired, MIL-C-39014 /13 should be specified. @ substitutability for failure rate levels shall be as follows: Failure rate level s R P M Will replace failure rate level R. P. M, L P, M, L M, L L ~ Substitutability for capacitance tolerance shall be as follows: Cap tolerance K Will replace cap to~le M ~Equivalent NATO styles. Theequivalen~ NATO styles per NATO-NEPR No. 14 shall be as follows: m Military st Ie CKR11 CKR12 CKR14 CKR15 NATO st le NCC75 Ncc70 NCC72 I Ncc73 Custodians: Army - EL Navy EC Air Force - 11 NASA - NA Review activities: Army - MI, AR Navy - EC Air Force - 17, 85 DLA - ES Preparing activity: Army - EL Agent: OLA - ES (Project 59-1240) User activities: Army - AT, AV, ME Navy - MC Air Force - 19

!; STANDARDIZATION DOCUilENT IMPROVEMENT PROPOSAL ~ (See Instpctions - Reverse Side) DOCUMENT NUMBER 2, DOCUMENT TITLE s NfiwEOF 5u0MIT71NG. ORGANIZATION 4. TYPE OF ORGAN IZATl ON(M,wkono) ADDRESS (Sheet. City, St.ate,. ZIP Code)..,,, VENDOR 1 u,,. /q MANUFACTURER.,-, PR08LEM AREAS a Parwraph Number and Wording: other(speci,y,., i...:,..,. b. R%omnm ded Wo-dine: c. Reeton/Rationale for Recommendation, REMARKs NAME OF submitter (Lat, Fir. t, MI) -OPtiOnaI b. WORK TELEPHoNE NUMBER (lnclud, Are. code) Oc.,rmlal b4a#ll NeADDFlESS (Street, City State, ZIP Cc.ie) -optional 8. DATE OF SU8MISSN fyvmmdd).a.-... --- JU.&T&1425 PnEvl Ous EDITIoN IS OBSOLETE