I N D I A N S T A T I S T I C A L I N S T I T U T E 8 th MILE POST, MYSORE ROAD, BANGALORE Tel : 080 28483002-28483006, Fax 080 22293517, E-mail : isib@isibang.ac.in TENDER DOCUMENT FINANCIAL BID (SUPPLY, INSTALLATION, TESTING AND COMMISSIONING OF ONE 10 PASSENGER ELEVATOR) 2 OF 2 AT THE RESEARCH SCHOLARS HOSTEL FOR INDIAN STATISTICAL INSTITUTE BANGALORE ARCHITECTS M/s. Alur & Associates No:3,14 th MainRoad, Vasanthnagar, Bangalore- 560 052. Ph:080-22356234 Fax No:080-41076707 E-mail:design@alurassociates.com ISSUED TO 1
COMMERCIAL BID TECHNICAL DATA SHEET for Main elevator -10 Pax: The brief minimum specifications required for the elevators have been given below. If any deviation from the minimum the Tenderer has to clearly mention the same. Note below quality specifications will not be considered. Higher quality specifications will be accepted but without additional cost. Basic Minimum Specifications Tick if Accepted Change in Specification (if Any) Below par specifications will not be accepted Main Specifications: No of Lifts: 1 Not Negotiable Type of Lift: Passenger Lift (Gearless MRL) Not Negotiable Capacity/ Load: 10 Pax / 680 Kgs 10 Pax Speed: At 1.0 Meter per Second Not Negotiable Control: A.C. Variable Voltage Variable Frequency (V3F) Operation: Simplex Full Collective (With / without Attendant) 2
Building Data: Floor designation: GF+01+02 (provision up to 08) G+2 Minimum Travel: 0 floor to 2 nd floor (with provision to Not Negotiable increase to 8th floor), rise 10.35 meters (provision for 27.6 mtrs) Stops & openings: Power supply: Machine: Car size: 3 stops 3 openings (all openings are on the same side) 415 volts + 5%-10%, 3 phases 50 hertz, alternating current, 230 V Single Phase AC Supply (MRL) Gearless placed in Lift Shaft Top Slab About 1350 mm wide x 1300 mm deep x 2300 mm high inside dimensions Not Negotiable Not Negotiable Hoist way: About 2000 mm wide x 2000 mm deep finished dimensions Starting Current: About 25-30 Amps Full Load Current: About 25-30 Amps Load on Pit: Load on Machine room floor: Cable 4 core / 16 sqmm Not Negotiable 3
Signals: Combined luminous hall buttons with direction arrows at all floors 2 LCD Digital hall position indicator at all floors; Hall Lantern & Gong Bell at all floors 3 Car Operating Panel with Braille Luminous Buttons and attendant key 4 L.C.D. digital Car Position Indicator in car. 5 Battery Operated Alarm Bell and Emergency Light; Overload warning indicator in car. 6 Electronically controlled card access system in car operating panel. 7 Floor announcement & music in car. 8 Infrared door detection system. 9 Intercom unit in Car, at Ground floor and in Machine Room. 10 In built voltage stabilizer for controller. 11 Automatic rescue device to bring the elevator to landing at nearest floor both in Power & Controller failure. 12 1 Hr. fire rated door of shaft & 1 hour fire rated door of cabin. 13 Fireman's switch at main lobby. 4
FIXTURES: Fixtures: Door Operation: Stainless steel fixtures in car and all landings Fully Automatic with ac door operator and electronic door protection system (infrared door detector) clear opening about 800mm W x 2000mm H Car Panels: Car Door: Full height Stainless steel finish with Braille luminous buttons and access card system Stainless steel 2 panel telescopic, side opening Auto doors Clear Opening: 1200mm W x 2000mm H Landing Door: Stainless steel 2 panel telescopic, side auto doors for vision panels. Clear Opening: 1200mm W x 2000mm H Car Door Protection: Flooring: Multiple beam Full height infra red detectors Granite stone colour as approved by client False ceiling: cd 35 (powder painted) Lighting: LED lighting with decorative design in false ceiling 5
Ventilation Duct fans in suitable nos to provide sufficient air circulation in lift car Handrail: SS /Bed Guard on three side of lift car. Provide 50 mm Dia. 35 mm Clear of the wall at height of 1000 mm from bottom side Faceplates: Rectangular Stainless steel in hairline Emergency Light & Alarm: As per standards Automatic Rescue System: As per standards Any other additional specification not mentioned: 6
The price/s quoted herein is/are inclusive of all taxes, as currently applicable, whether levied by the Central Government or the State Government or any Local Authority. Rate per Elevator Set in ( `) Abstract: Providing, Erecting & Commissioning Automatic MRL (Machine Room Less) Passenger & Service Elevators as per above IS codes including Certification from Chief Electrical Inspectorate, VAT @ 14%, One year free Maintenance, AMC (Annual Maintenance Contract) for 3 years excluding site related civil works, electrical and scaffolding works A Total Landed cost including spares, taxes, etc per machine: ` B For procuring certificates/permits/licenses from Statutory/ Regulatory Authorities, and pay all necessary fees for such certificates/ licenses/ permits and inspection fees. ` C Annual Maintenance Contract for 3 years ` (Rupees Signature and Seal of Contractor: Date: Place: Total cost ` 7