Type: BALER RO Open Date: 03/23/13 Meter In: 21811 Promised: 04/30/13 001 REPAIR FOR RESALE D JERRY GILBRECT TRADE. D REPAIR FOR RESALE. F DID INSPECTION LIST & PARTS ESTIMATE PACKER WRAPPERS WORN THROUGH ON EDGES WRAPPERS WILL RUN AS PER TERRY REPLACED BROKEN & WORN TINES (26) REPLACED BOTH REEL BEARINGS (HAD TO USE PULLERS ON SPROCKETS) REPLACED BOTH CAM TRACKS MEASURED, CUT & REPLACED PICK UP CHAINS TOOK PACKER CRANK APART REPLACED PACKER FINGER BEARINGS ON #1, #2 & #3 PACKED BEARINGS W/WHEEL BEARING GREASE SET PRELOAD ON BEARINGS IT TOOK A LONG TIME TO GET IT OUT & APART REPLACED DOG BONE BEARINGS ON #1 & #2 DOG BONES REPLACED DOG BONE BEARINGS N PICKUP DOG BONE & IN THE PACKER CHAIN IDLER SPROCKET REPLACED LEFT PACKER CRANK BEARING (HAD TO CUT IT OFF) REPLACED PICKUP CLUTCH HUB, SPRINGS & PINS REPLACED PICKUP UP CLUTCH BEARING ADJUSTED PICKUP CLUTCH SHAFT REPLACED GEAR BOX OIL REPLACED GEAR BOX AUX SHAFT O RINGS, LEFT & RIGHT REPLACED GEAR BOX CRANK ARM SEALS & O RINGS ARMS WERE STUCK REPLACED FRONT RIGHT CONNECTING ROD BEARING HAD TO CUT BEARINGS OFF SHAFT & OUT OF HOUSING GREASED BEARING & DROVE IT ON RE-INSTALLED GEAR BOX CRANK ARMS REPLACED STRIPPED NUTS & JAM NUTS FOR CRANK ARM BOLTS UPDATED PACKER STRUT W/NEW SUPRT PIECES TRIED TO STRAIGHTEN STRUT CUT PIECES OF METAL USED CHAIN & BOOMER TRYING TO STRAIGHTEN STRUT GROUND OUT WELDS & RE-WELDED CARRIER BEARING HOUSING REPLACED WEAK HAY DOG SPRING & PIN REPLACED ALL 4 PLUNGER ROLLERS, BEARINGS & CAPS REPLACED STUFFER ASSIST CLEVIS & PINS page 1 of 5
REPLACED STUFFER DRIVE DOG PIN THAT HAD SPUN REINFORCED WIND GUARD CUT & WELDED PIECES REPLACED HOSE CLAMP & ADDED ONE MORE ON BIG HOSE COMING FROM HYD TANK REPLACED LEFT & RIGHT TWINE GUIDES IN BALER FRAME FREED UP UPPER & LOWER TENSIONERS REPLACED ALL ROLLERS REPLACED TWINE FINGER BUTTERFLY ROLLER PRE-HEATED, WELDED, GROUND KNOTTER DRIVE LOBE IN SPROCKET PRE-HEATED, WELDED, GROUND ALL 6 WIPER ARM LOBES ON KNOTTER GEARS REPLACED LUBE HARNESS & BROKEN FITTINGS FOR #1 KNOTTER REPLACED ALL 6 TWINE FINGER BEARINGS REPLACED #4 & #5 BILL HOOK TONGUES REPLACED #1 & #2 TWINE DISC CLEANERS CLEANED TWINE DISCS & HOLDERS WENT THROUGH KNOTTER ADJUSTMENTS ADJUSTED TUCKER ARMS ADJUSTED TWINE FINGER NEEDLE CLEARANCE ADJUSTED TWINE FINGER 90 S TIED KNOTS CHECKED HYD REPLACED SWITCH FOR LIGHTS CLEANED CONNECTORS ON OTHER LIGHTS RAN LUBBER FOR A LONG TIME TO FILL UP NEW HARNESS RE-INSTALLED WIND GUARD ADJUSTED STUFFER LINKAGE GREASED BALER REPLACED MISSING OPERATORS MANUAL LUBED & ADJUSTED CHAINS REPLACED TWINE FINGER ROD PINS & HAIR PINS SERVICE BY MITCHELL LIVELY, CLYDE HARMS & NATHAN HAMMONS UL L USED INTERNAL 93.37 83.00 7749.71 P 79017754 PAINT GREY 2.00 11.85 11.85 23.70 P 700728401 DOUBLE TIN 26.00 6.30 6.30 163.80 P Z711770 BEARING-15 8.00 15.00 15.00 120.00 P 700141886 CAMTRACK, 1.00 108.00 108.00 108.00 P 700141885 CAMTRACK, 1.00 108.00 108.00 108.00 P 71309128 BEARING-1-2.00 29.40 29.40 58.80 P Z51417 BEARING FL 6.00 3.28 3.28 19.68 P 91499 ANTISIEZE 1.00 19.50 19.50 P 700724471 CAPSCREW-3 20.00 1.42 1.42 28.40 P 3/8SFW FLATWASHER 16.00 0.06 0.06 0.96 P Y704734 NUT/LOCK 19.00 0.46 0.46 8.74 P DX1233010 CHAIN/60 1 3.00 84.08 84.08 252.24 page 2 of 5
P DC4233CL08 LINK,CHAIN 1.00 2.72 2.72 2.72 P DC7233P LINK,CHAIN 2.00 7.12 7.12 14.24 P 761213 KEY 2.00 5.23 5.23 10.46 P 700710545 BEARING CO 6.00 51.90 51.90 311.40 P 700142211 TAB/LOCK 4.00 13.00 13.00 52.00 P 700710544 BEARING CU 6.00 32.40 32.40 194.40 P 700109753 BEARING-2" 1.00 173.00 173.00 173.00 P Z51318 BEARING-44 1.00 42.90 42.90 42.90 P 71130258 FLANGE,BEA 2.00 6.66 6.66 13.32 P 79014730 GREASE CAR 1.00 2.94 2.94 2.94 P SHOPSOLV SOLVENT 4.00 6.18 6.18 24.72 P 1/2X1-1/4USS BOLT 8.00 0.60 0.60 4.80 P 700142215 SPACER 1.00 12.70 12.70 12.70 P 700188198 GUSSET 2.00 31.10 31.10 62.20 P 1/2X4USS BOLT 4.00 1.38 1.38 5.52 P 1/2LFW FLATWASHER 4.00 0.22 0.22 0.88 P Y704742 NUT,LOCK/H 8.00 1.07 1.07 8.56 P 9/16RER E RING 8.00 0.15 0.15 1.20 P 5/8FLN FLN.LK.NUT 12.00 0.99 0.99 11.88 P 1109055 BALL BEARI 7.00 9.81 9.81 68.67 P BR20L BUSHING 4.00 0.35 0.35 1.40 P 5/8LFW FLATWASHER 2.00 0.42 0.42 0.84 P 70923530 SETSCREW-3 2.00 1.10 1.10 2.20 P 700720548 COMPRESS. 2.00 2.06 2.06 4.12 P 70937154 PIN/DOWEL 2.00 4.54 4.54 9.08 P 700161210 HUB 1.00 178.00 178.00 178.00 P 70920469 SETSCREW-3 1.00 2.15 2.15 2.15 P 700711134 FLANGE HEA 1.00 1.17 1.17 1.17 P 700734704 LIP SEAL-1 2.00 18.10 18.10 36.20 P 359119X1 O RING-148 2.00 3.71 3.71 7.42 P 700723678 LIP SEAL 2.00 178.00 178.00 356.00 P 700723677 O-RING-8.2 2.00 6.90 6.90 13.80 P 8799280 BREATHER V 1.00 22.20 22.20 22.20 P Z61770 KEY PARALL 1.00 1.42 1.42 1.42 P 3/8X1CB CARR BOLT 6.00 0.52 0.52 3.12 P FRT FREIGHT 1.00 14.00 14.00 14.00 P 700731940 BEARING 1.00 49.60 49.60 49.60 P Y740068 BUSHING 1.00 1.47 1.47 1.47 P 79021647 GASKET SEA 2.00 14.10 14.10 28.20 P 242BLUE LOCTITE 1.00 8.85 8.85 8.85 P 700728925 OIL SEAL-1 2.00 13.90 13.90 27.80 P 700724470 BEARING-75 1.00 266.00 266.00 266.00 P ROYAL98 GREASE 2.00 2.08 2.08 4.16 P 6523500 BUSH 1.00 2.42 2.42 2.42 page 3 of 5
P 6523542 SHIM-57MM 1.00 2.29 2.29 2.29 P 6523534 SHIM 1.00 2.88 2.88 2.88 P 700108820 FRICTION D 1.00 136.00 136.00 136.00 P 1LFW FLATWASHER 4.00 0.82 0.82 3.28 P 1USS NUT 4.00 1.32 1.32 5.28 P 1USSJN 1" JAM NUT 4.00 1.00 1.00 4.00 P 271RED LOCTITE 1.00 8.95 8.95 8.95 P 85W1405 GEAR OIL 5 1.00 63.00 63.00 63.00 P 8701377 CAPSCREW/H 3.00 1.03 1.03 3.09 P Y703132 SCREW/HEX 6.00 0.64 0.64 3.84 P 70931277 NUT/FLANGE 9.00 0.44 0.44 3.96 P 7/64X1CP COTTER PIN 2.00 0.09 0.09 0.18 P 5/16X3/4CB CARR BOLT 4.00 0.27 0.27 1.08 P 852314 KNOB 3.00 4.56 4.56 13.68 P 700706124 BEARING SE 4.00 61.40 61.40 245.60 P 700113170 ROLLER 4.00 97.00 97.00 388.00 P 700706125 TONGUED WA 4.00 10.00 10.00 40.00 P 700113171 NUT/STAKE 4.00 11.30 11.30 45.20 P Y766113 CLEVIS 4.00 13.40 13.40 53.60 P 700137816 TWINE GUID 6.00 5.39 5.39 32.34 P 700144747 HARN REPAI 1.00 20.10 20.10 20.10 P 8050866 BEARING/CA 1.00 49.40 49.40 49.40 P 70930680 FITTING/LU 1.00 1.32 1.32 1.32 P 700707402 BEARING,BA 6.00 7.07 7.07 42.42 P 700734489 KNOTTER BI 2.00 44.90 44.90 89.80 P 863738 DOWEL/PIN3 2.00 0.53 0.53 1.06 P 70922598 PIN 5.00 0.93 0.93 4.65 P 6523807 KNOTTER CL 2.00 16.30 16.30 32.60 P 700737442 BEARING 30.00 6.42 6.42 192.60 P 700738585 SOCKET HEA 18.00 1.43 1.43 25.74 P 8701476 CAPSCREW/H 18.00 0.39 0.39 7.02 P #24 HOSE CLAMP 2.00 0.55 0.55 1.10 P Z26922 CAP 4.00 3.17 3.17 12.68 P 1/4USSLN TOPLOCKNUT 1.00 0.10 0.10 0.10 P 700727924 FITTING-1/ 6.00 13.20 13.20 79.20 P 700137246 SHAFT/CLUT 1.00 20.60 20.60 20.60 P 1/2X1-1/2USS BOLT 3.00 0.65 0.65 1.95 P 700711132 HEX FLG HD 1.00 0.69 0.69 0.69 P 700706376 TORSION SP 1.00 9.90 9.90 9.90 P 700706685 PIN/CLEVIS 1.00 4.76 4.76 4.76 P HP6 HAIR PIN 6.00 0.14 0.14 0.84 P Z63586 CLEVIS PIN 6.00 0.71 0.71 4.26 P 6TIE PLASTICTIE 6.00 0.23 0.23 1.38 P 6553275 SHIM-.018" 8.00 0.97 0.97 7.76 page 4 of 5
P 7852163 MACHINRY B 6.00 0.20 0.20 1.20 P 7852593 BUSH 2.00 0.88 0.88 1.76 P 70927728 RING,RETAI 1.00 0.81 0.81 0.81 P 702700040 PINION 1.00 36.60 36.60 36.60 P ROYAL98 GREASE 3.00 2.08 2.08 6.24 P 700706398 INDUCTIVE 1.00 32.30 32.30 32.30 P IRONMAN CHAIN LUBE 1.00 7.09 7.09 7.09 P BLACKTAPE ELECTRICAL 1.00 1.85 1.85 1.85 P 700723268 BUSHING KI 1.00 43.40 43.40 43.40 P 70923219 GREASE FIT 2.00 1.14 1.14 2.28 P 700727154 ROCKER SWI 1.00 11.10 11.10 11.10 P 700736943E 2100 SERIE 1.00 65.25 65.25 65.25 Subtotal charges this section 12599.72 M SHOP SUPPLIES 30.00 PLEASE SEND IN UPDATED COPY OF FARM TAX NUMBER YOU MAY FAX TO 405.224.0547 THANK YOU Allocation control # account # 13101C 12629.72 Signature: livingstonc-servicepg2.template DESC LABOR PARTS SUBLET MISC OTHER SUBTOTAL TAX TOTAL Copyright (c) 2015 HBS Systems TOTALS 7749.71 4850.01 30.00 12629.72 12629.72 page 5 of 5