Illustrated Parts List 00-0 I0003 Ride Mower YTH 0 K 46 9604500040 0300 Illustrated Parts List
SCHEMATIC RED A AMMETER (OPTIONAL) FUSE BATTERY RED SOLENOID STARTER M WHITE WHITE B S M G L A A ATTACHMENT CLUTCH (CLUTCH OFF) CLUTCH/BRAKE (PEDAL UP) GRAY REVERSE SWITCH (NOT IN REVERSE) 3 SEAT SWITCH (NOT OCCUPIED) 6 GRAY /WHITE JUNCTION CONNECTOR CHASSIS HARNESS SHORTING CONNECTOR BLUE IGNITION UNIT (OPTIONAL) HOUR METER SPARK PLUGS GAP ( PLUGS ON TWIN CYL. ENGINES) BLUE FUEL LINE V POWER OUTLET (OPTIONAL) FUEL SHUT-OFF SOLENOID (IF SO EQUIPPED) RED CHARGING SYSTEM OUTPUT 9-6 AMP DC @ 3600 RPM REGULATOR STATOR ORANGE 8 VOLTS AC @ 3600 RPM (REGULATOR DISCONNECTED) BROWN LIGHT SWITCH HEADLIGHTS IGNITION SWITCH POSITION CIRCUIT MAKE OFF M+G+A RUN/OVERRIDE B+A RUN B+A L+A START B+S+A 030 3 CHASSIS HARNESS CONNECTOR (MATING SIDE) 6 5 4 6 3 5 4 DASH HARNESS CONNECTOR (MATING SIDE) WIRING INSULATED CLIPS NOTE: IF WIRING INSULATED CLIPS WERE REMOVED FOR SERVICING OF UNIT, THEY SHOULD BE REPLACED TO PROPERLY SECURE YOUR WIRING. NON-REMOVABLE CONNECTIONS REMOVABLE CONNECTIONS
ELECTRICAL 8 4 0 4 43 40 33 30 5 34 46 8 6 6 9 8 55 400449 8
ELECTRICAL 53 6 34-65 Battery 84 6 04- Bolt Hex Head /4-0 x 3/4 8 53 9 3-8 Box Battery 6 53 6-38 Switch Interlock Push-In 53 8 3-59 Harness Socket Light W/45J 53 00 4-5 Bulb Light 5 53 9 88-93 Cable Starter 6 53 5-58 Fuse 83 5 04-00 Nut Keps Hex /4-0 unc 8 53 9 88-85 Cable, Ground 9 53 40 5-45 Switch, Seat 30 53 9 33-50 Switch, Ign 33 53 4 04-0 Key, Ignition 34 53 0- Switch Light / Reset 40 53 40 04-49 Harness Ign. 4 8 04-08 Screw Thd Cut /4-0 x / 4 53 3 5-63 Cover, Terminal 43 53 9 5-0 Solenoid 46 53 40-63 Gauge Servicereminder Hrmtr 55 8 06 05- Screw Thdrol 5/6-8 x 3/4 TYTT 53 40 0-98 Harness Ign. Dash 8 53 9 8-0 Switch Interlock Clutch Cable 90 53 40 0-5 Cover Terminal 0 53 40 44-54 Harness Pigtail inch = 5.4 mm 9
CHASSIS 5 04 0 08 8 3 39 38 03 4 4 30 06 34 0 5 8 5 30 09 6 3 0 34 6 6 05 8 5 50 95 6 6 8 96 3 36 94 36 94 68 8 36 30 35 34 30 3 80 8 38 68 68 83 68 6 99 8 8 30 94 8 89 5 89 5 chassis-tex_6-gt-husq 30
CHASSIS 3 53 40 50- Logo 4 53 9 93-48 Logo 5 53 40 8-03 Dash 6 53 40 48-83 Clip 4 53 40 8-4 Hood 5 53 9 89-0 Lens LH 8 53 40 86-0 Grille/Lens Asm. 5 53 9 89-06 Lens RH 34 53 9 6-5 Plate Engine 36 8 06 05- Screw 5/6-8 x 3/4 3 53 40 4-94 Fender 5 83 68 05-00 Nut Lock 5/6-8 68 8 49 05-08 Screw Thdrol 5/6-8 x / 99 53 40 59-03 Rod Asm Bypass 30 53 9 6- Screw 0 x 3/4 Single Lead-Hex 3 53 40 5-90 Bumper Dash 38 53 40 9-54 Cupholder 50 53 9 85-3 Air Duct 5 53 9 95-35 Shield Browning 6 53 4 4-3 Screw 5 53 9 63-04 Crossmember 6 53 40 0-6 Screw 0-4 x 5/8 53 9 5- Bushing Steering 8 53 9 9-8 Cargo Net Asm. 80 53 9 54-5 Chassis 8 53 40 30-5 Bushing Mtg. Fender Crgo 8 53 9 4-8 Dash Lower 83 84 8 05-0 Bolt Fin Hex 5/6-8 unc x -/4 89 8 00 05- Screw 5/6-8 x 3/4 94 83 90 05-00 Nut Lock Hex Flange 5/6-8 95 53 40 4-3 Plug Hole Dash Lower 96 53 40 8-43 Console Asm. Deck Lift 0 53 40 30-48 Vent Side Hood RH 03 53 40 30-6 Vent Side Hood LH 04 53 9 89-04 Vent Top Hood 05 53 40-09 Skirt Hood Side RH 06 53 40 - Skirt Hood Side LH 0 53 9-98 Bezel RH 08 53 9-99 Bezel LH 09 53 9 9-30 Insert Hex Top RH 0 53 9 9-3 Insert Hex Top Lh 53 9 9-3 Insert Hex Bottom RH 53 9 9-33 Insert Hex Bottom LH 3 84 6 05- Bolt 5/6-8 x 3/4 4 53 9 9-45 Clip Retainer Tinner 53 5 65-4 Rod Pivot 8 53 9 63-95 X-Piece Hood Stop 53 3-9 Screw Thdrol /4-0 x 5/8 8 53 9 5-6 Stud Fastner 30 53 0-65 Bolt Shoulder 5/6-8 34 53 40 4-4 Bumper Hood 35 53 40 6-9 Spacer Fender 36 83 93 05-00 Nut Lock 5/6-8 UNC 38 53 40 86-06 Trim 39 53 04-5 Nut, Push inch = 5.4 mm 3
DRIVE 56 3 9 09 5 06 6 0 43 6 6 4 84 35 5 80 5 5 5 85 64 60 6 60 88 0 6 3 5 5 86 89 49 8 50 59 6 53 08 5 4 0 5 90 5 5 5 9 59 63 5 66 33 83 6 6 5 5 53 05 30 6 69 30 05 33 drive-tex_36-husq TuffTorq wb 69 83 3
DRIVE 53405384 Transaxle, TUFFTORQ K46 (Order Parts from Transaxle Manufacturer) 53 35-83 Key Square 5 89 3 3-6 Washer 3/3 x 3/6 x 6 Ga. 53 4 36-8 Spring, Brake 6 53 9 96-9 Spring Return Cruise 9 53 40 38-06 Rod, Brake 33 8 00 00-0 Ring E 35 53 9 95-9 Rod, Brake, Park 4 53 48- Cover, Foot Pedal 49 8 06-4 Bolt 50 53 9 43- Pulley Idler Flat 5 83 90 06-00 Lock Nut 3/8-6 5 53 9 43-6 Idler V-Groove 90" Offset 56 53 3 09-69 V-Belt, Drive 64 53 9 8-65 Shaft Asm. Pedal Brake Control 80 53 4 00-4 Strap Torque 9 84 6 05-0 Bolt Fin Hex 5/6-8 unc x.5 6 83 90 05-00 Nut Lock Hex Flange 5/6-8 5 8 00 05- Screw 5/6-8 x 3/4 43 8 49 05-08 Screw 5/6-8 x / 53 53 4-88 Retainer Spring 59 86 0 04- Pin Cotter /8 x 3/4 60 53 6 94-84 Retainer Clip 6 53 9 54-03 Spring, Return, Clutch 6 53 9 5-85 Spacer Transaxle 63 53 40 0-34 Rod Pedal Control 66 53 9-90 Nut Push 6 53 40 5-5 Latch Brake Parking 69 84 49 05-60 Bolt Hex 5/6-8 x 3.5 0 53 9 43- Keeper Belt Centerspan 8 06-6 Bolt 83 53 3 0-5 Spacer Axle 84 53 9 95-5 Handle Parking Brake 85 8 06-0 Bolt 86 53 9 43- Spacer Retainer 8 89 3 3-0 Washer 88 53 9 43-3 Link Clutch Ground Drive 89 53 9 43- Bellcrank Ground Drive 90 53 9 43-8 Keeper Bellcrank Ground Drive 05 53-48 Washer 5/3 x -5/8 6 Ga. 06 53 9 8-6 Bracket Mount Latch Cruise 0 53 9 8-68 Latch Control Cruise 08 53 9 8-69 Gear Sector Control Cruise 09 53 9 95-9 Rod Control Cruise 0 53 40 09-80 Rockr Asm. Pedal Control 53 0-83 Bearing Nylon 3 53 40 3-9 Knob control Cruise 4 53 40 - Pad Pedal Forward 5 53 40-3 Pad Pedal Reverse 6 53 9 6-3 Bracket Pulley Idler 53 40 3-8 Retainer Spring Clip 89 0-0 Washer /3 x -/4 0 Ga. 5 53 40 33-9 Keeper Belt Transaxle 6 53 40 5-64 Bracket Mount Torque 30 53 8 89-6 Washer Hardened 3 53 40-8 Idler V-Groove.688" OFFSET inch = 5.4 mm 33
ENGINE 9 96 - - - - - - - - - Engine Kohler Model No. SV60 53 8 86-55 Muffler 9 53 9 43-0 Keeper Belt Engine 53 40 54- Pulley Engine 5 53 40 4-89 Tank Fuel 8 53 9-5 Cap Asm 0 53 40 5-08 Control Throttle 53 9 6- Screw 0 x 3/4 Single Lead Hex 8 53 40-3 Fuel Line 9 53 3-80 Spark Arrester Kit 3 53 34-8 Clamp Hose 4 80 04 0-00 Washer Lock /6 45 83 5 04-00 Nut Keps Hex /4-0 unc 69 53 8 59-09 Gasket 9 53 9 3-34 Screw Socket Head 5/6-8 x.5 8 53 4 84-56 Tube Drain Oil Easy 8 53 8 6-54 Plug Drain Oil 83 53 8- Bolt 5/6-8 UNC x 3/4 w/sems 85 53 39-3 Bolt Hex /6-0 x 4 x Gr. 5-.5 Thr 90 8 00 06-6 Screw 3/8-6 x 9 8 06-6 Screw 3/8-6 x 94 53 8 86-54 Tube Exhaust 96 89 09 4-6 Washer 9/3 x /8 x 6 Ga. 9 8 6 04- Screw /4-0 x 3/4 inch = 5.4 mm For engine service and replacement parts, call the toll free number for your engine manufacturer listed below: Kohler Co. -800-544-444 34
STEERING ASSEMBLY 6 5 45 63 6 9 60 5 63 6 8 9 6 66 59 6 9 8 64 8 35 58 4 6 6 3 69 68 5 0 4 6 4 5 5 3 53 8 steering-tex_4-husq 3 53 9 39-43 Wheel, Steering 53 9 59-68 Axle Asm., Front 4 53 40 30-8 Spindle Asm., LH 5 53 40 30-88 Spindle Asm., RH 6 53 49-3 Bearing, Race Thrust Harden 53-48 Washer 5/3 x -5/8 x 6 Ga. 8 8 00 00-9 Ring, Klip #T5304-5 9 53-3 Cap, Spindle 3 53-49 Washer 5/3 x -/4 x 6 Ga. 4 80 04 06-00 Washer, Lock Hvy Hlcl Spr 3/8 5 83 54 06-00 Nut, Crown Lock 3/8-4 unf 6 53 40 8-9 Shaft Steering 9 53 9 4-9 Plate Steering 53 8 6-3 Adapter, Wheel Steering 53 9 48-45 Bushing, Strg. Blk 6 53 9 36-5 Insert, Wheel Steering 8 8 00 06- Screw 3/8-6 x 3/4 35 53 9 4-3 Gear, Sector Plate 45 89 8 38- Washer 9/6 ID x -3/8 OD Ga. 5 83 94 08-00 Nut Hex Jam Toplock /-0 unf 53 53 8 89-6 Washer Hardened.93 x.63 x.060 5 53 40 4-65 Bracket Upstop 58 53 9 4-4 Bolt Shoulder Sector Pivot CFM 59 53 9 4-48 Washer Thrust Sector Steering 60 83 9 0-00 Nut Flange Lock 5/8-6 53 9 4-40 Draglink LH 6 53 9 4-4 Draglink, RH 63 8 00 05- Screw 5/6-8 x 3/4 64 53 9 98-49 Retainer Clip Spring Steering 66 8 0 0-48 Bolt Hex Fghd /6-4 x 3 Serr 6 53 9 4-3 Bushing PM Front Axle 68 83 90 0-00 Nut Lock Flange /6-4 Gr. 5 69 53 9 9-6 Washer.5 x.505 x.8 0 53 9 6-9 Bracket Deck Susp. Front inch = 5.4 mm 35
SEAT ASSEMBLY 8 8 4 40 0 6 3 44 43 3 3 seat-tex_-vgt 53 9 5-8 Seat 53 8 0-66 Bracket Pivot Fender 3 53 4 06-5 Strap, Asm Fender 6 83 80 06-00 Nut, Lock W/Ins. 3/8-6 unc 53 4-8 Spring, Seat Cprsn 8 53 8- Bolt 5/6-8 uncx 3/4 w/sems 0 53 9 69- Pan, Seat 53 8-5 Bolt, Shoulder 5/6-8 3 83 80 05-00 Nut, Lock 5/6-8 unc 40 53 9 6-6 Handle Slide Seat 4 53 9 8-00 Spring Latch Seat 43 84 6 06- Bolt Fin Hex 3/8-6 unc x 3/4 44 89 3 38- Washer 3/3 x -3/8 x Ga. inch = 5.4 mm 36
DECALS 4 8 5 6 9 3 0 53 40 5-8 Decal, Operators 53 40 8-3 Decal, Hood 3 53 4 0-08 Decal, Hood Panel SD 4 53 40-8 Decal, Hood Top Insert 5 53 8 09-4 Decal, Customer Respons. 6 53 4 03- Decal, Replacement 53 40 44-84 Decal, Steering Wheel 8 53 9 5-54 Decal, Fender 9 53 4 50-05 Decal, Battery Dnge/Poi 0 53 4 53-8 Decal, Engine HP 53 4 53-8 Decal, Engine 53 6 03-96 Decal, Mower V-Belt Schematic - - 53 6 69-60 Decal, Bypass - - 53 4 08-05 Pad, Footrest, LH - - 53 4 08-06 Pad, Footrest, RH WHEELS AND TIRES 6 3 4 0 5 9 8 53 05 9-9 Cap Valve Tire 53 06 5-39 Stem Valve 3 53 3 83-36 Rim Front Service 4 53 05 99-04 Tube Front (Service Item Only) 5 53 0 6- Tire Front 5 x 6.0-6 Service 6 53 49-5 Fitting Grease (Front Wheel Only) 53 49-59 Bearing Flange (Front Wheel Only) 8 53 50-39 Cap Axle Blk 50 x 00 9 53 0 6-68 Tire R T 8 x 9.5-8 Service 0 53 49-6 Tube Rear (Service Item Only) 53 3 83-3 Rim Asm 8" rear Service - - 53 4 43-34 Sealant, Tire (0 oz. Tube) inch = 5.4 mm wheel_art_-tex 3
MOWER DECK 46 5 94 5 6 8 0 3 86 30 86 5 5 3 38 93 6 9 8 5 4 43 56 60 64 6 9 36 4 44 3 40 45 59 5 56 38 55 46 63 4 34 30 30 95 68 33 3 3 8 9 46 6 3 95 96 98 9 6 88 89 6 40 89 88 5 69 69 69 9 3 69 4 5 6 9 4 99 69 3 69 46_tex_lt_pred_3_r 8 38
MOWER DECK 53 4 08-63 Mower Housing 53 40 55-06 Cover Mandrel RH 3 53 40 55-0 Cover Mandrel LH 5 53 46-0 Retainer Spring 6 53 9 5-86 Arm Suspension 53 9 6- Screw 0 x 3/4 Single Hex 8 53 9 30-03 Bolt/Washer asm /6-0 unf 53 40 53-80 Blade Mower 3 53 9 8- Shaft Assembly, Mandrel 4 53 8-8 Housing, Mandrel 5 53 04-85 Bearing, Ball, Mandrel 9 53 9 65-39 Bolt, Shoulder 83 68 05-00 Nut 3 53 9 5-5 Bracket, Deflector 4 53 0 53-04 Cap, Sleeve 5 53 9 0-6 Spring, Torsion, Deflector 6 53 04-5 Nut, Push 53 40 53-5 Shield, Deflector 9 53 3 4-9 Rod, Hinge 30 53 39-84 Screw Thdrol Rolling Wsh Hd 3 53 8 6-90 Washer, Spacer 3 53 9 59-45 Pulley, Mandrel 33 53 40 0-34 Nut, Toplock, Flanged 34 8 06- Bolt Carr Sh. 3/8-6 x -/ Gr. 5 36 53 9 6-06 Pulley, Idler, Flat 3 89 3 3-6 Washer 3/3 x 3/6 x 6 Ga. 38 53 9 9-89 Keeper Belt LH Mandrel 40 83 90 06-00 Nut, Lock Flg. 3/8-6 unc 4 53 9 84-0 Spring Trosion Brake 43 53 9-56 Spring Torsion Retainer 46 53 3-9 Screw 4 53 9-50 Bracket Clutch Cable 55 53 9-49 Arm, Idler 56 53 9 90-9 Spacer, Retainer 5 8 00 06-6 Screw Hexwsh Thd 3/8-6 x 59 53 4 0-43 Guard, Tuv Idler (94) 60 53 40 0-3 Arm Brake Mower LH 6 84 5 06-36 Bolt 3/8-6 UNC x -/4 Gr. 5 63 53 9 94-8 Arm Brake Mower 64 53 40 5-39 Linkage Brake 6 53 40 30- Handle, Clutch Cable 68 53 40 5-43 V-Belt 69 8 4 05-05 Bolt 0 53 40 65-63 Clutch Asm. Cable 86 53 9-98 Pin Attachment Cable 3 8 00 05-0 Screw 5/6-8 6 53 9 34-06 Bolt, Shoulder 53 48-3 Wheel, Gauge 9 89 3 0- Washer 3/3 x -/4 x Ga. 53 9-58 Keeper Belt Eng. LH 3 53 9-59 Keeper Belt Eng. RH 44 53 9 9-04 Keeper Belt 45 53 9-68 Pulley Idler 4 53 40 8- Spring Return 49 53 6 58-98 Retainer Spring Yellow 5 53 40 65-60 Bracket Mount 5 53 40 83-9 Cable Clutch Manual w/spr. 86 53 9-99 Arm Acutator CL Cable 8 53 40 65-6 Lever Control CL Cable 88 53 9 5-6 Stud Fastener 89 83 90 05-00 Nut Lock Hex Flange 93 53 9 8-0 Spring Plunger Actuator 94 53 9-9 Bearing Control Lever Clutch 95 8 00 06- Screw 3/8-6 x 3/4 96 53 4 35-4 Washer 3/3 x x / Ga. 9 89 3 3- Washer 3/3 x 3/6 x Ga. 98 53 40 3-49 Baffle Center Front 99 53 40 3-50 Baffle Front RH - - 53 9 8-0 Mandrel Assembly (Includes housing, shaft assembly, and bearing only - pulley/nut/washer and blade bolt/washers not included) - - 53 40 84-8 Replacement Mower, Complete inch = 5.4 mm 39
MOWER LIFT 8 8 90 98 3 0 9 88 89 00 9 9 89 8 lift-tex_5 53 9 5-3 Shaft Asm., Lift 3 53 9 5-3 Lever Asm., Lift Rh 53 9 64-9 Grip, Lever 0 53 9 63-4 Spring Torsion 8 53 9 4-09 Pin Cotter /6 Bow Tie Lock 88 53 9 53-03 Spring Lift Assist 89 89 9 9- Washer Clear Zinc 90 53 9 4-08 Pin Cotter 5/6 Bow Tie Lock 9 53 9 5-8 Link Lift Susp Mower Rear 9 8 06 06- Screw 3/8-6 x.5 Smgml Tap/R.Z 98 53 9 5-0 Link Lift Susp. Front Mower 00 83 93 06-00 Nut Center Lock 3/8-6 UNC inch = 5.4 mm 40
53 4 53-86 0..0 CL Printed in the U.S.A.