SCHEMATIC BATTERY SOLENOID A AMMETER (OPTIONAL) WHITE FUSE C G WHITE M STARTER BROWN B S M G A L A IGNITION SWITCH ORANGE F H B E A D PTO (DISENGAGED) WHITE CLUTCH / BRAKE (PEDAL UP) ELECTRIC CLUTCH SEAT SWITCH (NOT OCCUPIED) BLUE HOUR METER (OPTIONAL) GROUNDING CONNECTOR FUEL LINE IGNITION UNIT SPARK PLUGS GAP ( PLUGS ON TWIN CYL. ENGINES) FUEL SHUT-OFF SOLENOID CHARGING SYSTEM OUTPUT AMP DC @ 300 RPM REGULATOR VOLTS AC @ 300 RPM (REGULATOR DISCONNECTED) ALTERNATOR BROWN HEADLIGHTS IGNITION SWITCH POSITION CIRCUIT MAKE OFF M+G+A NONE ON + LIGHTS B+A L+A ON B+A NONE START B+S+A NONE WIRING INSULATED CLIPS NOTE: IF WIRING INSULATED CLIPS WERE REMOVED FOR SERVICING OF UNIT, THEY SHOULD BE REPLACED TO PROPERLY SECURE YOUR WIRING. 043 POSITION OFF ON REMOVABLE CONNECTIONS PTO SWITCH CIRCUIT C+G,B+H C+F,B+E,A+D NON-REMOVABLE CONNECTIONS H G F C E B D A PTO SWITCH CONNECTOR

REPAIR PARTS ELECTRICAL 9 4 4 4 43 40 30 5 0 D.C. AMPERES 45 50 9 4 9 34

ELECTRICAL 449 Battery 404 Bolt Hex Head /4-0 x 3/4 03J Tray, Bat tery 0 45 Bolt Btr Frt /4-0 x.5 zinc 5009 Holdown Battery Front Mount 459 Nut Push Nylon /4" 3 Switch Interlock Push-In 5 Harness Headlight w/bulbs 45J Bulb Light 4 544 Cable, Battery 5 449 Cable, Battery 04X Fuse 350400 Nut Keps Hex /4-0 unc 09 Cable, Ground 9 04 Switch, Plunger 30 55 Switch, Ign 4040 Key 40 03 Harness, Ignition 4 040 Screw /4-0 x / 4 353 Cover, Terminal Red 43 Solenoid 45 X Ammeter 4 935 Hourmeter Snap-In 50 45 Switch, PTO 9 54 Socket, Light Bulb 094X Relay Asm. 9 939 Bracket Snap-In NOTE: All component dimensions given in U.S. inches. inch = 5.4 mm. 35

CHASSIS AND ENCLOSURES 4 5 53 30 5 3 5 4 30 5 4 59 5 59 3 44 35 3 50 5 4 5 30 43 5 30 30 59 5 43 39 4 0 9 3 9 45 99 4 34 9 3 9 3 3 3 39 4 45 4 30 50 44 4 39 4 chassis-stealth II_ 3

CHASSIS AND ENCLOSURES 035 Rail, Frame RH 5 Drawbar, Gt 5 934X4 Dash 5 Dash Asm., Lower 040 Screw, Thd Cut /4-0 x / 4 Support, Battery 4 50X505 Hood Asm., Pnt 94X Cover, Access 000 Screw, 3/- x 3/4 59X4 Grille 9 9 Washer 3/3 x 3/ x Ga. 0 40 Bolt, Fin Hex 3/- x 30000 Nut, Lock Hex w/ins. 3/- unc 4 9X505 Footrest, RH 9X505 Footrest, LH 30 4505 Saddle, Hydro 995 3 49 Bracket, Supt -pc VGT Steering 3 3 Bracket, Pivot Chassis LH 3 Bracket, Pivot Chassis RH 34 0 Plate Asm. Engine Chassis 35 9 Washer /3 x / x Ga. 3 005 Screw 5/- x 3/4 3 50X505 Fender, Pnt. 39 5 Bracket, Axle Front 43 3939 Bracket, Spnsn Front Lh 44 3940 Bracket, Spnsn Front Rh 45 0 Bracket Asm., Susp Chassis 4 4900 Screw Thdrol 3/- x / TYT 50 54 Bracket, Chassis Front 5 359 Bracket Asm., Fender 49050 Screw, Thd 5/- x / 4 4 Upstop 400 Bolt, Fin Hex /-4 unc x -/4 Gr. 5 9 034 Rail, Frame Lh 99 43 Rod By Pass 44 Screw Hex Wshd - x / 30 5 Screw HWHD Hi-Lo #3- x 3/4 3 95X4 Cupholder YTGT 39 3 Bolt Shoulder 5/- TT 4 9 Bracket Dash RH 43 94X4 Skirt Grill RH 44 900 Bracket Dash LH 4 94X4 Skirt Grill LH 4 455 Extrusion Bumper 50 535 Duct Heat Hood 5 95 Shield Browning 53 9 Light Box Asm. w/lens 5 005 Screw 5/- x 3/4 5 40 Lens, Bar 5 00 Screw Thdrol 3/- x / 59 000 Screw 3/- x 3/4 9X4 Console Fuel Window 443 Screw /4-/ 5 3554 Bracket Support Tank 3000 Nut, Crownlock /-4 unc 4 Bushing Snap 9 59 Bracket Chassis Sway NOTE: All component dimensions given in U.S. inches inch = 5.4 mm 3

DRIVE 39 4 0 40 4 9 3 3 3 3 4 4 5 35 4 3 3 5 53 4 4 50 4 43 55 5 9 4 30 34 3 9 5 35 3 4 5 9 9 4 0 4 4 5 4 4 9 3 3 3 94 94 9 9 5 4 4 3 45 0 45 3 3 9 0 drive_-vgt 0 3

DRIVE - - - - - - - Transaxle Hydro Gear -3000 (Order Parts From Transaxle Manufacturer) 00E Key Sq. /4 x.5 3 53R Washer Thrust 004 Pin, Cotter 4050 Wheel, Hub Assembly 9 4000 Bolt, Hub 0 394000 Nut 035 Lever Asm Shift 3 4045 Knob 9 00 Brake, Rod 000053 Ring E 34 3 Cap, Parking Brake 35 34 Rod, Parking Brake 3 494 Spring, Drive Ground 3 49X Washer 5/3 x -/4 x Ga. 3 50035 Nyliner 39 430 Screw, Fin. #0-4 x 40 55 Actuator, Interlock Switch 4 393000 Nut Centerlock 0-4 unc 4 35X Cover, Pedal 4 450 Retainer, Spring 4 04 Bolt Carr. Shoulder 3/- x -3/4 Gr. 5 50 3494 Pulley, Idler, Flat 5 3 Pulley, Idler, Grooved 55 050X Bearing, Idler 5 59 V-Belt 5 404 Bolt Fin Hex /-4 x -/ 43995 Pulley, Transaxle 4 0 Shaft, Brake Pedal 5 93 Bolt, Shoulder 54H Pin, Roll 9 300X Washer 0 9X4 Console Shift 3 449054 Bolt Hex Flghd 5/- x 3 Gr. 5 4 443 Screw Hex Wsh. Hi-Lo /4-/ 40 Bolt Fin Hex /-4 x 9 3000 Nut Crownlock /-4 Unc 94 35 Fastener Christmas Tree 9 4004 Bracket Shift 0 49 O-Ring Asm Hydro Gear 0 5439 Line Fuel Hydro 5 VGT 0 49 Cap Asm Vent Hydro Gear 540 Spacer Shift Lever VGTH 55 Washer Nylon High Temp 4 300500 Nut Lock Hex W/Ins 5/- Unc 390000 Nut, Lock Flg. 3/- 5 Bracket Strap Torque 0050 Bolt 5/- x.50 3 354 Rod Shift 4 549 Bolt Shoulder 5/- x.5 5 49050 Screw 5/- x 5/ 00 Washer SRRTD 5/ ID x.0 x.5 3 Link Control Clutch 4 Spring Drive GRND 9 943 Bracket Asm Idler Tensioning 30 930 Washer 3/3 x 5/ x Ga. 3 003 Pin Cotter 3/3 x 3/4 3 54 Bracket Mtg Hydro 3500 LH VGT 54 Bracket Mtg Hydro 3500 RH VGT 35 34 Link Asm Control Hydro 3500 3 5H Nut Lock 5/- NC Thd. 3 30H Washer Thrust 5/ x.0 x /3 4 549 Strap Torque HG-3500 43 0005 Screw 5/- x 3/4 45 3 Washer Axle Flange HG-3000 4 404 Fan " Hydro 4 43 Washer 4 000 Bolt Hex /-4 x -/4 Gr. 5 5 4054 Bolt Fin Hex 5/- x / 5 05 Bolt Hex 5/- x 53 449H Spring Retainer NOTE: All component dimensions give in U.S. inches. inch = 5.4 mm 39

STEERING ASSEMBLY 5 9 3 45 44 4 0 9 3 0 5 4 4 5 4 3 5 3 3 4 4 5 34 3 4 9 3 4 3 3 53 4 9 4 49 4 50 5 4 35 steering_-vgt 40

STEERING ASSEMBLY 404X4 Wheel, Steering 55 Axle Asm., Front 3 3 Fitting, Grease 4 49 Spindle Asm, LH 5 4 Spindle Asm., RH H Bearing, Race Thrust Harden 4X Washer 5/3 x -5/ x Ga. 00009 Ring, Klip #T5304-5 9 3X Cap, Spindle 0 4044 Bolt, Fin Hex 5/- x -3/4 35 Spacer, Brg. Axle Front 390000 Nut, Lock Flange 5/- unc 3 49X Washer 5/3 x -/4 x Ga. 4 004000 Washer, Lock Hvy Hlcl Spr 3/ 5 354000 Nut Lock Center 3/-4 unf 4 Shaft Asm., Steering 99 Draglink, Ball Joint Solid Vgt 9 50 Support Asm., Steering Vgt 0 3X4 Boot Steering Stealth 59945 Adapter, Wheel Steering 5505 Bushing, Strg. 3 59 Screw 5994X4 Insert Cap Strg WH R Bearing, Col. Strg. 000 Screw Hexwsh thdr 3/- x 3/4 9 0439X Bearing, Flange 3 Bushing, Nyliner Snap 3 90 Washer /3 x x 0 Ga. 0040500 Washer, Lock Hvy Hlcl Spr 5/ 34 405 Bolt, Hex Hd 5/- x 3/4 35 039 Gear, Sector Steering 3 99 Tie Rod 4 554 Bracket Switch Interlock Vgt 9 4 49050 Screw Thdrol 5/- x / Tyt 44 035X4 Extension Steering 45 94 Washer 9/ x -/ x Ga. 4 930 Washer 3/3 x x 0 Ga. 4 94 Bracket Asm. Idler Stationary 4 000 Screw 3/- x.5 49 50 Pulley Idler Flat 50 390000 Nut Lock Flg. 3/- unc 5 394000 Nut Hex Jam Toplock /-0 unf 53 9 Washer Harden.93 x.3 x.00 NOTE: All component dimensions given in U.S. inches. inch = 5.4 mm. 4

ENGINE 3 45 9 0 4 0 4 9 5 4 4 3 4 0 5 9 9 engine_els_-vgt 3 39 40 SPARK ARRESTER KIT - - - - - - - Engine Briggs, Model No. 44 (Order parts from engine manuf.) 493 Muffler Side 3X Pulley V-Idler 9 4 Keeper Asm. Belt Engine VGT 0 5 Bushing 95 Clutch Electric 4399 Pulley Engine VGT Elect Clutch 5 95 Tank Fuel Rear 5.0 94X4 Cap Asm. Fuel 0 543X4 Control Throttle 5 Screw HwHd Hi-Lo #3- x 3/4 X4 Control Choke 345J Bushing 39 Stem Tank Fuel 34R Fuel Line 9 30 Spark Arrester Kit 3 4500 Clip 3 34X Clamp Hose 39 4903 Screw TT 3/- x -/4 unc 40 4904 Screw TT 3/- x 4 unc 4 9X Washer -/ OD x 5/3 ID x.50 4 004000 Washer Lock / 43 9953 Bolt Hex /-0 x 3.5 Gr. 5 4 45 350400 Nut Keps Hex /4-0 4 5 Spacer 49 Shield Heat Muffler CV-Intek 9 539 Gasket 0 09 Tube Exhaust LH 00 Tube Exhaust RH 9 390 Screw Socket Head 5/- x 00 Tube Drain Oil Easy 99 Plug Oil Drain 3 Bolt 5/- Unc x -3/4 W/Sems 4 004 Screw Thdrol 3/- x -/ NOTE: All component dimensions given in U.S. inches inch = 5.4 mm For engine service and replacement parts, call the toll free number for your engine manufacturer listed below: Briggs & Stratton -00-- Kohler Co. -00-544-444 Tecumseh Products -00-55-540 Honda Engines -00-4-0 Kawasaki -949-40-5

SEAT 0 4 0 0 5 5 5 3 9 3 3 seat_-vgt 0 Seat 0 Bracket, Pivot Seat 3 405 Strap Asm. 5 4500 Clip, Push-In Hinged 30000 Nut, Crownlock 3/- 4X Spring, Seat Cprsn. Bolt 5/- unc x 3/4 w/sems 0 0 Pan, Seat 4X Bracket, Mounting Switch 3 4X Bushing, Snap 4 0504 Bolt, Carriage /4-0 x -/ 5 49X Spacer, Split 340X Spring, Cprsn. 39X Nut, Lock /4 Lg. Flg. Gr. 5 99 Washer /3 x -3/ x Ga. 9 39 Knob, Seat 0 43X Cap, Spring Seat Blk 5 Bolt 5/- unc-a 3 300500 Nut, Crownlock 5/- NOTE: All component dimensions given in U.S. inches inch = 5.4 mm 43

DECALS 9 5 5 3 4 0 3 9 3 4 3 59 Decal, Dash 0439 Decal, Engine 3 9045 Decal, Hood, RH 4 904 Decal, Hood, LH 5 9059 Decal, RRL 403 Decal, Brake Parking 90 Decal, Bypass 455 Decal, Deck Caution 9 9049 Decal 0 54 Decal, Danger 5 Decal, Footrest 9053 Decal, Chassis 3 45005 Decal, Battery 4 9 Decal, V-Belt Schematic 5 90430 Decal, Ins. Whl. Strg. 403 Decal, Saddle Brake Parking 9 45005 Decal, Battery 3 00X Reflector, Taillight - - 99X4 Pad, Footrest RH - - 9X4 Pad, Footrest LH - - 9055 Manual, Owner's (English) - - 905 Manual, Owner's (Spanish) WHEELS & TIRES 3 wheel_art_-vgt 4 0 5 9 599 Cap, Valve, Tire 539 Stem, Valve 3 0X4 Rim Assembly, Front 4 34H Tube, Front (Ser vice Item Only) 5 030X Tire, Front H Fitting, Grease (Front Wheel Only) 9040H Bearing, Flange (Front Wheel Only) 045X4 Cap, Axle (Front Wheel Only) 9 055X Tire, Rear 0 54J Tube, Rear (Service Item Only) 0X4 Rim Assembly, Rear 5M Fitting, Grease - - 444 Sealant, Tire (0 oz. Tube) NOTE: All component dimensions given in U.S. inches inch = 5.4 mm 44

MOWER LIFT 40 43 3 35 3 34 39 3 3 30 9 0 4 0 3 4 5 5 4 9 3 0 9 3 5 4 4 5 4 0 4 5 3 00X Rod Asm., Lever 0045 Shaft Asm., Lift Vgt 3 599 Lever Asm., Lift Rh 4 0000 E-Ring Truarc #5-5 990 Washer 9/3 x -/4 x Ga. 04 Bolt, Fin Hex 3/- x -/ 53X Grip, Handle 45X Button, Plunger 9 34X Plunger, Lever Lift 0 394 Spring 0. OD x.5 535 Link Lift 355 Retainer, Spring 3 4939M Retainer, Spring 4 5000 Nut, Jam Hex /-3 unc 3000 Nut, Crownlock /-3 unc 9 50 Trunnion Inf. Height 30 00X Nut, Special 3 930 Washer 3/3 x 5/ x Ga. 3 350 Spring, Compression Inf Hgt 0030 Pin, Cotter 3/3 x / 34 3 Rod, Adj Lift 45 lift_rh_ 35 305 Knob, Inf 3/- unc 3 5509 Pointer, Height Indicator 39 3935X Plug, Hole 40 005 Screw 5/- x 3/4 4 5994 Nut, Lift Link /-0 4 940 Washer /3 x -/ x 0 Ga. 43 3934X Scale, Indicator Height 0 45 Nut, Hexfl ange Lock 045X Nut, Push Phos & Oil 3 5000 Nut Hex Jam 3/- unc 4 Arm Susp. Rear RH 5 505 Plate Asm Susp. Front 550 Pin Flange 05 Trunnion Susp. Arm 59 Trunnion Susp. Front 9 Arm Susp. Rear LH 5 903 Insert Wear 5 Bolt Shoulder NOTE: All component dimensions given in U.S. inches inch = 5.4 mm

MOWER DECK 4 90 95 4 34 3 0 94 54 / 4_nose_roller_ 3 4 4 4 49 5 0 9 90 4 43 9 9 50 49 3 39 30 5 5 5 3 3 9 5 3 35 3 5 59 50 9 5 0 5 4 5 3 mower_deck-54_ 4

MOWER DECK 95 Deck Weldment Mower 5 4939M Retainer Spring 9 Cover Mandrel LH Cover Mandrel RH 435 Bolt / Asm. Blade 54 Blade, Standard (For mulching mowers only) 3 9 Shaft Asm. w/lower Bearing 4 Housing, Mandrel 5 045X Bearing, Ball, Mandrel 40505 Bolt, Carriage 5/- x 5/ 30500 Nut, Crownlock 5/- unc 5 0 Spring, Torsion 045X Nut, Push 5X4 Deflector Shield 9 349 Rod, Hinge 30 394 Screw, Thdroll Washer Head 3 90 Washer, Spacer Mower Vented 3 5 Pulley, Mandrel 34 Nut, Flg. Top Lock Cntr. 9/ 34 3000 Nut 35 35 Pin Suspension Rear 3 5 Spring Compression 39 4 Pulley, Idler, Stationary 4 53 Spacer, Retainer 43 Arm, Idler 4 39 Screw, Thdroll. /4-0 x 5/ 4 93 V-Belt, Mower, Secondary 49 390000 Nut, Lock Flg. 3/- unc 50 0 Bolt, Carr. 3/- x 5 00 Bolt 5 40 Pulley Idler Clutching 5 559 Bar Pnt Adj. 5 594 Pin Head Rivet 5 34 Baffle Right 59 344 Baffle Left 0 0 Baffle Center 90 405 Bolt 5/- x 9 0535 Bracket Asm N Roller RH 94 0 Roller Nose 4" 95 0534 Bracket Asm N Roller LH 9 90 Washer Hardened 9 Spring Clutch Drive 3 050 Bolt Rdhd Sqnk 5/- x 3/4 4 55 Rod Tension Relief 49 Bolt, Shoulder 43 Gauge Wheel 393000 Nut, Centerlock 3/- unc 9 944 Washer 3/ x / x 4 Ga. 55 Bushing Tension Relief 0 300500 Nut 5/- 9 Rod Roller Nose Narrow 3 355 Retainer Spring - - 9 Mandrel Asm. Service (Includes Key Nos. 3-5 and ) - - Replacement Mower, Complete (Std. Deck-Order separately nose roller components key nos. 90, 9, 94, 95, 0,, 3) NOTE: All component dimensions given in U.S. inches inch = 5.4 mm 4