SCHEMATIC SCH11 RED A AMMETER (OPTIONAL) FUSE BATTERY RED SOLENOID STARTER M WHITE WHITE B S M G L A1 A ATTACHMENT CLUTCH (CLUTCH OFF) CLUTCH/BRAKE (PEDAL UP) GRAY REVERSE SWITCH (NOT IN REVERSE) 3 1 SEAT SWITCH (NOT OCCUPIED) 6 GRAY NOTE YOUR TRACTOR IS EQUIPPED WITH A SPECIAL ALTERNATOR SYSTEM. THE LIGHTS ARE NOT CONNECTED TO THE BATTERY, BUT HAVE THEIR OWN ELECTRICAL SOURCE. BECAUSE OF THIS, THE BRIGHTNESS OF THE LIGHTS WILL CHANGE WITH ENGINE SPEED. AT IDLE THE LIGHTS WILL DIM. AS THE ENGINE IS SPEEDED UP, THE LIGHTS WILL BECOME THEIR BRIGHTEST. /WHITE BLUE BLUE FUEL LINE FUEL SHUT-OFF SOLENOID (IF SO EQUIPPED) RED LIGHT SWITCH IGNITION UNIT (OPTIONAL) HOUR METER ORANGE JUNCTION CONNECTOR CHASSIS HARNESS CHARGING SYSTEM OUTPUT 3AMPDC@3600RPM LIGHTING SYSTEM OUTPUT 5AMPAC@3600RPM SPARK PLUGS GAP ( PLUGS ON TWIN CYL. ENGINES) DIODE 1V POWER OUTLET (OPTIONAL) SHORTING CONNECTOR VOLTS AC MIN. @ 3600 RPM (CHARGING SYSTEM DISCONNECTED) ALTERNATOR 14 VOLTS AC MIN. @ 3600 RPM (LIGHTS OFF) BROWN IGNITION SWITCH HEADLIGHTS POSITION CIRCUIT OFF M+G+A1 RUN/OVERRIDE B+A1 RUN B+A1 START B+S+A1 MAKE L+A 3 1 CHASSIS HARNESS CONNECTOR (MATING SIDE) 6 5 4 6 3 5 4 1 DASH HARNESS CONNECTOR (MATING SIDE) WIRING INSULATED CLIPS NOTE: IF WIRING INSULATED CLIPS WERE REMOVED FOR SERVICING OF UNIT, THEY SHOULD BE RE-INSTALLED TO PROPERLY SECURE YOUR WIRING. NON-REMOVABLE CONNECTIONS REMOVABLE CONNECTIONS 3
ELECTRICAL T0S With 1V Outlet Option 103 9 1 30 33 59 With Service Minder Option 34 43 4 46 6 40 41 5 16 90 1 9 94 55 9 93 4
ELECTRICAL 1 163465 Battery 46041 Bolt Hex Hd 1/4-0 unc x 3/4 193 Box Battery 16 1613 Switch Interlock 1 1359 Harness Socket Light 415J Bulb, Light #1156 5 4194 Cable Battery 6 Ga. BL/Red 14.5 6 1515 Fuse 3510400 Nut Keps Hex 1/4-0 unc 195 Cable Ground 1" Rear Battery Blk 6 Ga. 9 401545 Switch Seat 30 193350 Switch Ign 33 411935 Key/Chain 34 1101X Switch Light/Reset 40 40109 Harness Ign 41 1040 Screw 1/4-0 unc x 1/ 4 131563 Cover Terminal Red 43 1950 Solenoid 55 106051 Screw 5/16-1 x 3/4 1 400449 Harness Ign. Chass. 9 154 Socket Asm. Bulb 190 Switch Interlock Clutch 90 4005 Cover Terminal 9 196615 Harness Pigtail Reverse Switch 93 19540 Screw Plastic 10-14 x.0 94 19134 Modual Reverse ROS 1 inch = 5.4 mm 5
CHASSIS 30 153 1 14 16 5 13 151 150 130 16 1 16 1 15 11 196 3 36 13 194 6 194 36 16 35 130 6 35 34 13 13 6 13 36 6 1 16 11 6 5 6 1 19 159 19 194 19 5 15 19 Chassis-tex_elite basic_5_r1 6 159
CHASSIS 5 193X4 Dash 14 13393X41 Hood 1 13399X4 Grille 34 19615 Plate Engine 36 106051 Screw 5/16-1 x 3/4 3 414X41 Fender 5 360500 Nut Lock 5/16-1 5 410 Drawbar Upper 6 149050 Screw Thdrol 5/16-1 x 1/ 130 41635 Screw #10 x 0.50 13 1491 Bumper Hood 13 1934X4 Cupholder 150 14461 Duct Heat Hood 151 400 Bracket Pivot 15 199535 Shield Browning 153 134X599 Lens Grille 159 100061 Screw Hexwsh Thdrol 3/-16 x 3/4 16 1443 Screw Hex Wsh Hi-Lo 1/4 x 1/ 15 19343 Crossmember 16 4006 Screw 10-4 x 5/ Wshd Qdrx 1 195 Bushing Steering 10 415063 Chassis 11 19310X4 Bushing Mtg. Fender Crgo. 1 19305 Dash Lower 13 4050 Bolt Fin Hex 5/16-1 x 1-1/4 19 100051 Screw 5/16-1 x 3/4 194 3900500 Nut Lock Hex Flange 5/16-1 196 41459 Console Asm. Deck Lift 13 46051 Bolt 5/16-1 x 3/4 1 40916 Rod Pivot Hood 1 196395 X-Piece Hood Step 195161 Stud Fastener 35 40619 Spacer Fender 36 3930500 Nut Center Lock 5/16-1 1600406 Screw 1/4-0 x 3/ 30 133 Insert Lens Reflective 1 inch = 5.4 mm
DRIVE 0 56 15 143 4 14 16 1 15 0 15 4 35 11 159 16 160 15 114 1 159 15 1 9 16 1 64 14 165 161 51 166 10 31 49 16 19 1 1 33 50 116 15 3 166 153 3 153 190 5 51 51 9 116 3 99 1 3 05 3 13 05 33 drive-tex_t_fender_0
DRIVE 1 - - - - - - Transaxle, Hydro Gear T-AABC-1X1A-1GX1 (See Transaxle Breakdown) 1353X Key Square 15 19131316 Washer 13/3 x 13/16 x 16 Ga. 1 1996 Spring, Brake 19660 Rod Shift 3 14045 Knob 9 4339 Rod, Brake 33 1000001 Ring E 35 19 Rod, Brake, Park 3 1149X Washer 5/3 x 1-1/4 x 16 Ga. 4 3R Cover, Foot Pedal 49 110614 Bolt 50 1943 Pulley Idler Flat 51 3900600 Lock Nut 3/-16 5 19436 Idler V-Groove 910" Offset 56 1590X V-Belt, Drive 64 19600 Shaft Asm. Pedal Brake Control 0 1930X4 Console 3 4490544 Bolt Hex 5/16-1 Gr. 5 4 1443 Screw 1/4 x 1/ 0 40393 Strap Torque 99 4041 Rod Spring Bypass 114 300500 Nut Lock 5/16-1 unc 116 3900500 Nut Lock Hex Flange 5/16-1 11 15611 Bracket Strap Torque 1 01050 Bolt 5/16-1 x.50 15 100051 Screw 5/16-1 x 3/4 143 149050 Screw 5/16-1 x 1/ 153 449H Retainer Spring 1" 159 60041 Pin Cotter 1/ x 3/4 160 16944 Retainer Clip 161 10509X Spring, Return, Clutch 165 1961 Bushing 166 4305 Nut Push.65 16 4055 Latch Brake Parking 10 413430 Keeper V-Idler 14 199 Nut Push 15 40539 Shaft Asm Shift 16 19614 Arm Clevis Rod Shift 1 19456 Spring Shift 13 1569 Spacer Axle 14 19403X505 Handle Parking Brake 15 1106 Bolt 16 19431 Spacer Retainer 1 1913310 Washer 1 19433 Link Clutch Ground Drive 19 19431 Bellcrank Ground Drive 190 19431 Keeper Bellcrank Ground Drive 05 114X Washer 5/3 x 1-5/ x 16 Ga. 16 196131 Bracket Pulley Idler 1 4031 Retainer Spring Clip Handle 31 40 Idler V-Groove 1.6" Offset 3 4016 Bolt /16-14 x 1 Gr 5 33 40596 Washer Serrated 9 44155 Link Shift 1 inch = 5.4 mm 9
ENGINE 1 1 0 45 4 9 1 1 15 1 69 3 4 9 90 5 9 OPTIONAL EQUIPMENT Spark Arrester 10
ENGINE 1 - - - - - - Engine B&S Model No. 31P6-004-B1 1335 Muffler 9 194319 Keeper Belt Engine 1 40195 Pulley Engine 15 40545 Tank Fuel 1.50 1 4516 Cap Fuel 0 10545 Control Throttle/Choke 1 41635 Screw #10 x 0.50 40113 Fuel Line 9 1310 Spark Arrester Kit 3 134X Clamp Hose 4 1004000 Washer Lock /16 45 3510400 Nut Keps Hex 1/4-0 unc 69 16591 Gasket 9 19334 Screw Socket Hd 5/16-1 x.5 1 14456 Tube Drain Oil Easy 4 Valve Drain Oil 4 106060 Screw 3/-16 x 1-1/4 5 1393 Bolt Hex /16-0 x 4 x Gr. 5-1.5 90 1000616 Screw 3/-16 x 1.0 96 19091416 Washer 9/3 x / x 16 Ga. 9 16041 Screw 1/4-0 x 3/4 1 inch = 5.4 mm Engine Power Rating Information The gross power rating for individual gas engine models is labeled in accordance with SAE (Society of Automotive Engineers) code J11940 (Small Engine Power & Torque Rating Procedure), and rating performance has been obtained and corrected in accordance with SAE J1995 (Revision 00-5). Actual gross engine power will be lower and is affected by, among other things, ambient operating conditions and engine-to-engine variability. Given both the wide array of products on which engines are placed and the variety of environmental issues applicable to operating the equipment, the gas engine will not develop the rated gross power when used in a given piece of power equipment (actual on-site or net horsepower). This difference is due to a variety of factors including, but not limited to, accessories (air cleaner, exhaust, charging, cooling, carburetor, fuel pump, etc.), application limitations, ambient operating conditions (temperature, humidity, altitude), and engine-to-engine variability. Due to manufacturing and capacity limitations, Briggs & Stratton may substitute an engine of higher rated power for this Series engine. 11
STEERING 6 33 45 1 0 1 1 16 13 64 63 60 5 9 19 59 5 63 6 66 9 35 6 5 6 61 4 69 14 15 6 14 6 5 13 6 0 15 13 steering-tex_stdhrr_5 53 1
STEERING 1 41451X41 Wheel, Steering 19596 Axle Asm., Front 4 4030 Spindle Asm., LH 5 4030 Spindle Asm., RH 6 666H Washer Thrust 0.5 x 1.3 114X Washer 5/3 x 1-5/ x 16 Ga. 100009 Ring, Clip #T5304-5 9 113X Cap, Spindle 13 1149X Washer 5/3 x 1-1/4 x 16 Ga. 14 10040600 Washer Lock 3/ 15 3540600 Nut, Crown Lock 3/-4 unf 16 400 Shaft Steering 19 1949 Plate Steering 0 1935X4 Boot, Steering 1 163 Adapter, Wheel Steering 4053 Strg. Supt. Lower 6 41454X4 Insert, Wheel Steering 100061 Screw 3/-16 x 3/4 33 10040500 Washer Lock 5/16 35 1943 Gear, Sector Plate 45 191131 Washer 11/3 x -3/ x 1 Ga. 53 196 Washer Hardened.93 x 1.63 x.060 5 40465 Bracket Upstop 5 1944 Bolt Shoulder Sector Pivot CFM 59 1944 Washer Thrust Sector Steering 60 391000 Nut Flange Lock 5/-11 61 19440 Draglink, LH 6 19441 Draglink, RH 63 100051 Screw 5/16-1 x 3/4 64 19949 Retainer Clip Spring Steering 66 1004 Bolt Hex Fghd /16-14 x 3 Serr 6 1943 Bushing PM Front Axle 6 390000 Nut Lock Flange /16-14 Gr. 5 69 19916 Washer 1.5 x.505 x.11 0 19619 Bracket Deck Susp. Front 1 19605 Shaft Ext. Steering 4050 Bolt 5/16-1 x 5 Gr. 5 1 inch = 5.4 mm 13
MOWER DECK 0 6 15 3 14
MOWER DECK 1 196495 Mower Housing 6 19516 Arm Suspension 41635 Screw #10 x 0.50 BOS Thread 193003 Bolt/Washer Asm /16-0 unf 11 1391 Blade, 4" Hi-Lift (For bagging or discharge) - - 1395 Blade, 4" Mulching Premium (For better wear when mulching) - - 134149 Blade, 4" Mulching Std (For mulching mowers only) - - 445 Blade 4SP" 3N1 - - 419 Blade 4SP" Premium 13 19 Shaft Assembly, Mandrel 14 11 Housing, Mandrel 15 11045X Bearing, Ball, Mandrel 19 196539 Bolt, Shoulder 0 1590 Baffle, Vortex 1 360500 Nut, Crownlock 5/16-1 unc 3 1955 Bracket, Deflector 4 105304X Cap, Sleeve 5 1906 Spring, Torsion, Deflector 6 11045X Nut, Push 19310X4 Shield, Deflector 9 131491 Rod, Hinge 30 1394 Screw Thdrol Rolling Wsh Hd 31 1690 Washer, Spacer 3 1943 Pulley, Mandrel 33 40034 Nut, Toplock, Flanged 34 11061 Bolt Carr Sh. 3/-16 x 1-1/ Gr. 5 36 1939 Pulley, Idler 4.50 RAW 3 19131316 Washer 13/3 x 13/16 x 16 Ga. 3 19919 Keeper Belt LH Mandrel 40 3900600 Nut, Lock Flg. 3/-16 unc 4 19410 Spring Torsion Brake 43 1956 Spring Torsion Retainer 46 139 Screw Thd Roll 1/4-0 x 5/ 4 1950 Bracket Clutch Cable 55 1949 Arm, Idler 56 19909 Spacer, Retainer 5 1000616 Screw Hexwsh Thd 3/-16 x 1 59 141043 Guard, Tuv Idler (94) 60 1961 Arm Brake Mower 6 110616 Bolt Rdhd Sqnk 3/-16 unc x 63 1994 Arm Brake Mower 64 19990 Linkage Brake 6 1939X41 Handle, Clutch Cable 6 49636 V-Belt 69 140505 Bolt Rdhd Sqnk 5/16-1 x 5/ 0 1933 Clutch Asm. Manual 113 1000510 Screw 5/16-1 116 49H Bolt Shoulder "A".41 "B" 1.66 11 1606 Wheel Gage 11 3930600 Nut Centerlock 3/-16 unc 119 1911414 Washer 3/ x / x 14 Ga. 1 195 Keeper Belt Eng. LH 13 1959 Keeper Belt Eng. RH 144 19904 Keeper Belt 145 19319 Pulley Idler Primary 14 40191 Spring Return 15 4014 Cable Clutch Manual w/spr. 1 195161 Stud Fastener 19 3900500 Nut Lock Hex Flange 19 1960 Bracket Brake Stand LH 195 100061 Screw Hexwsh Thdr 3/-16 x 3/4 0 16060 Screw THDROL 3/-16 x 1/ - - 190 Mandrel Assembly (Includes housing, shaft assembly, and bearing only - pulley/nut/washer and blade bolt/washers not included) - - 19960 Replacement Mower, Complete 1 inch = 5.4 mm 15
MOWER LIFT 90 9 10 9 3 9 100 9 91 101* 9 lift-tex_ *Key 91 may be substituted for Key 101 40 Shaft Asm., Cross Lift 3 19531 Lever Asm., Lift RH 19649X4 Grip, Lever 10 196314 Spring Torsion 19409 Pin Cotter /16 Bow Tie Lock 41010 Spring Lift Assist 9 1919191 Washer Clear Zinc 90 1940 Pin Cotter 5/16 Bow Tie Lock 91 19511 Link Lift Susp Mower Rear 9 100061 Screw 3/-16 x.5 Smgml Tap/R.Z 9 1950 Link Lift Susp. Front Mower 100 3930600 Nut Centerlock 3/ -16 unc 101 40003 Link Asm. Lift Fixed 1 inch = 5.4 mm 16
SEAT 1 41 40 10 1 6 3 44 43 3 1 3 seat-tex_6.5sl_ 1 19514 Seat 10166 Bracket Pivot Fender 3 14065 Strap, Asm Fender 6 300600 Nut, Lock w/ins. 3/-16 unc 1411X Spring, Seat Cprsn 11 Bolt 5/16-1 unc x 3/4 w/sems 10 1969 Pan, Seat 1 115 Bolt, Shoulder 5/16-1 3 300500 Nut, Lock 5/16-1 unc 40 19661 Handle Slide 41 1900 Spring Latch 43 46061 Bolt 3/-16 unc x 3/4 44 191331 Washer 13/3 x 3/ x 1 Ga. 1 inch = 5.4 mm 1
11 3 4 4 3 0 9 6 1 1 14 4034 Decal Eng. H.P. 3 430113 Decal Hood 4 430335 Decal Side Panel Logo 6 10563 Decal Warning, Keep Hand Away 41169 Decal Replacement Parts 41165 Decal Fender Warn S/F 9 43011 Decal Fender Logo 11 430111 Decal Ins Strg Whl 1 43055 Decal Fend SD 14 160396 Decal V-Belt Schematic 0 145005 Decal Bat Dan/Psn - - 166960 Decal Bypass - - 1936X4 Pad Footrest LH - - 193X4 Pad Footrest RH - - 430094 Manual Operator's (English/French) - - 43049 Manual Operator's (Spanish) - - 430095 Manual Parts (English/French) WHEELS AND TIRES 1 11 3 6 4 10 5 9 1 5919 Cap Valve Tire 65139 Stem Valve 3 1063 Rim Asm 6" Front 4 59904 Tube Front (Service Item Only) 5 106X Tire F T 15 x 6 0-6 6 H Fitting Grease (Front Wheel Only) 9040H Bearing Flange (Front Wheel nly) 1045X4 Cap Axle Blk 1 50 x 1 00 9 40531 Tire R T 1 x 9.5-C Turf Saver LT 10 15J Tube Rear (Service Item Only) 11 10610X Rim Asm " Rear Service - - 144334 Sealant, Tire (10 oz. Tube) wheel_art_1-tex 1 inch = 5.4 mm 1