ESSEX SUPER-SIX PARTS LIST JULY 9 " Serial 7 and Upward 9" Serial 0000 and Upward First Motor No 055 HUDSON MOTOR CAR COMPANY DETROIT, MICHIGAN, U. S. A. Printed in U. S. A.
ESSEX SUPER-SIX PARTS LIST IMPORTANT The use of genuine Essex parts will insure the satisfactory operation of your car. There are Hudson-Essex distributors and dealers in all principal cities and towns equipped to serve you. For your own protection, insist upon obtaining genuine Essex parts. JULY 9 HUDSON MOTOR CAR COMPANY DETROIT, MICHIGAN
WARRANTY "We warrant each new motor vehicle manufactured by us, whether passenger car or commercial vehicle, to be free from defects in material under normal use and service, our obligation under this warranty being limited to making good at our factory any parts or part thereof which shall within ninety (90) days after delivery of such vehicle to the original purchaser be returned to us with transportation charges prepaid, and which our examination shall disclose to our satisfaction to have been thus defective; this warranty being expressly in lieu of all other warranties, expressed or implied, and of all other obligations or liabilities on our part, and we neither assume nor authorize any other person to assume for us any other liability in connection with the sale of our vehicles. "This warranty will not apply to any vehicle which shall have been repaired or altered outside of our factory in any way so as, in our judgment, to affect its stability or reliability, nor which has been subject to misuse, negligence or accident, nor to any commercial vehicle made by us which shall have been operated at a speed exceeding the factory rated speed, or loaded beyond the factory rated load capacity. "We make no warranty whatsoever in regard to tires, rims, ignition apparatus, horns or other signaling devices, starting devices, generators, batteries, speedometers or other trade accessories, inasmuch as they are usually warranted separately by their respective manufacturers." HUDSON MOTOR CAR COMPANY Detroit, Michigan This warranty under which Essex motor cars are sold will be interpreted by the Distributor or Dealer from whom the car was purchased. If you are touring and require service, be sure to get in touch with your nearest Essex Distributor, Dealer, or Essex Service and Sales Station.
INSTRUCTIONS FOR ORDERING PARTS Order parts through the nearest Distributor or Dealer. Always give PART NUMBER and NAME of each part ordered. Mail and Parcel Post orders should be accompanied by an amount sufficient to cover POSTAGE. Specify how shipments are to be made. 5 Orders for parts should be written separately from correspondence pertaining to other matters. TELEGRAPH CODE To save expense, to expedite ordering and for your ccnvenience, we list below a brief General Code covering miscellaneous instructions, questions and answers relative to the shipment of parts: Sultex Ship to me (us) by express. Sulkline Ship by express to Sulkate Ship to me (us) by freight. Sulmost Ship to me (us) by parcel post. Sulwire When and how did you ship parts called for in my (our) telegram of Sultwich When and how will you ship parts called for in my (our) telegram of Sulteen When and how will you ship parts called for in my (our) letter of
ESSEX SUPER-SIX PARTS LIST INDEX Air Cleaner Axle Front Steering Spindle Tie Rod Wheel Bearings Axle Rear Differential and rier Drive Shaft Housing Pinion Housing Wheel Bearings Bonnet Brakes Front Brakes Rear Bumpers buretor buretor Choke Clutch Coil Controls Brake Control Hand Brake Pedals Throttle and Light Transmission Drag Link E Electrolock Engine Camshaft Connecting Rods Cylinder Distributor Mounting Exhaust Manifold Flywheel and Crankshaft Generator Drive Group Oil Pan Oil Pipes and Fittings Oil Pump and Check Valve Piston Timing Sprockets, Cover and Chain Valves Vibration Dampener Fan Fenders Frame Cross Members Free Wheeling A B C D F Page 7 7 7 7 9 0 9 0 5 7 5 5 7 7-9 5 5 9 9 5 5 5 5 7 G Gasoline Pipes and Connections Gasoline Tank and Straps Horn H I Instruments and Mounting Lamps Brackets and Tie Bar Head Side Tail and Stop Lighting Switch L M Muffler and Exhaust Pipes P Propeller Shaft and Universal Joints Radiator Core Shell Shutter and Controls Rim Demountable Running Board R S Shock Absorbers Splash Guards Engine, Radiator and Rear Running Board Springs Front Springs Rear Starter Button and Wire Starting Motor Steering Gear Tire rler Rear Tire rier Side Tools Transmission Trunk Rack Vacuum Tank Wheels Wire Wheels Wood Front Wheels Wood Rear Wiring T V W Page 5 5 5 5 5 5 5 9 5 7 5 7 5 5-5 7 7-7 9-50
ESSEX SUPER-SIX PARTS LIST 5 GROUP INDEX Axles and Brakes Bonnet Clutch Cooling System Engine Exhaust System Fenders, Running Boards and Splash Guards Frame Page 7 5 9 7 Fuel System Propeller Shaft and Universal Joints Springs Steering Gear Transmission Wheels Wiring Page 7 9 Axle Front Axle Rear Brake Control Clutch Assembly Engine End View Engine Side View Frame INDEX ILLUSTRATIONS Page 5 0 Free Wheeling Hand Brake Lever Assembly Propeller Shaft and Universal Joints Steering Gear Throttle and Light Control Transmission Wiring Diagram Page 0 0
ESSEX SUPER-SIX PARTS LIST 7 FRONT AXLE CX 507 CX 507 FRONT AXLE ASSEMBLY Axle center STEERING SPINDLE 5 7 7 9 0 5 7 9 0 5 BX 597 BX 59 BX 5 BX 70 BX 7 BX 00 BX 0 BX 99 BX 700 BX 75 BX 55 BX 509 BX 709 BX 50 BX 50 BX 50 BX 599 BX 505 BX 50 BX 507 BX 7099 BR BZ 709 BX 70 BX 00 BZ 7 BZ STEERING SPINDLE ASSEMBLY R.H. STEERING SPINDLE ASSEMBLY L.H. Bushing Welch plug Pivot pin Shim thin Shim thick Pivot pin lock Thrust bearing Thrust bearing dust shield Dust shield Wheel washer Wheel nut /"-x5/" GREASE WASHER RETAINER ASSEMBLY Retainer outer Washer Grease deflector Retainer inner Steering arm R.H. Steering arm L.H. Steering arm to backing plate bolt 7/"-0x-/" Steering arm to backing plate bolt nut 7/"-0 x 9/" Steering spindle to backing plate bolt 7/"-0 x -/" Steering arm stop bolt 5/"- x -/" Steering arm ball Steering arm ball nut /"-0 castle Steering arm stop bolt nut 5/"-x5/" FRONT WHEEL BEARINGS 7 9 0 70 700 70 70 Wheel bearing cup inner Timken 7 Serviced direct by Timken Roller Bearing Co., canton, Ohio. Wheel bearing cone and rolls inner Timken Serviced direct by Timken Roller Bearing Co., Canton, Ohio. Wheel bearing cup outer Timken 099 Serviced direct by Timken Roller Bearing Co., Canton, Ohio. Wheel bearing cone and rolls outer Timken 0907 Serviced direct by Timken Roller Bearing Co., Canton, Ohio. TIE ROD 5 7 CX 50 CX 55 BX 79 BX 79 BX 7050 BZ BX 7 BX 7 BZ 7 BX 99 TIE ROD ASSEMBLY Tie rod TIE ROD SOCKET ASSEMBLY R.H. TIE ROD SOCKET ASSEMBLY L.H. Clamp bolt Clamp bolt nut Dust cover Dust cover retainer Ball nut Tie rod sockets complete (right and left) /"-x-5/" /"-x/' 5/"-x5/" Service package FRONT BRAKES 9 0 BX BX BX 95 BX 9 FRONT BRAKE BACKING PLATE ASSEMBLY R.H. FRONT BRAKE BACKING PLATE ASSEMBLY L.H. Front brake crank lever R.H.. Front brake crank lever L.H.
REAR AXLE
ESSEX SUPER-SIX PARTS LIST 9 FRONT BRAKES (Continued) 5 7 9 50 5 5 5 5 55 5 57 5 59 0 5 7 9 70 BY 70 BR BX 507 BX 5075 BX 7 BX 9 BX 7 BX 70 BX 79 BX 07 BX BX 9 BX 977 BY 90 BX 977 BX 5 BX 9 BT 9 BX 09 BZ BX 7 BX 90 BX 975 BX 97 BX 97 BX BX 99 BX 5 BX 959 BX 07 Front brake crank lever bolt Front brake crank lever bolt nut Brake operating lever R.H. Brake operating lever L.H. Brake operating lever pivot pin Brake operating lever dust washer Brake operating lever dust washer Brake operating lever dust cover Brake operating lever dust cover spring Brake operating lever pivot pin taper pin Brake shoe spacer pin washer Brake shoe spacer pin spring Brake shoe spring small Brake shoe spring large Brake shoe steady rest pin washer BRAKE SHOE ASSEMBLY ( shoes) BRAKE REINFORCING PLATE AND ANCHOR PIN ASSEMBLY Brake anchor pin nut BRAKE ECCENTRIC ASSEMBLY Brake eccentric nut Brake adjusting screw Brake adjusting screw spring Brake adjusting screw pivot nut R.H. Brake adjusting screw pivot nut L.H. Brake adjusting screw cover BRAKE CAMSHAFT AND CRANK ASSEMBLY Brake camshaft dust shield BRAKE CAM PLATE AND BLOCK ASSEMBLY BRAKE CAM CARRIER BRACKET ASSEMBLY Brake cam carrier bracket bushing 5/"-xl-5/" 5/"-xl7/" Leather Felt x-/" /"-x5/" /"-x/" FRONT AXLE R.H.. DRIVE (All s for Right Hand Drive Axle Not Shown Here Are Same as Listed for Left Hand Drive) CX 507 BX 5090 BX 509 FRONT AXLE ASSEMBLY Steering arm R.H. Steering arm L.H. REAR AXLE CY 505 CY 500 CY 00 CY 500 CY 5007 CY 500 CY 0 CY 0 CY 07 REAR AXLE ASSEMBLY (from 7 to 509) 5-/0 to REAR AXLE ASSEMBLY (from 7 to 5057) 5-/0 to REAR AXLE ASSEMBLY (from 7 to 59) 5 9 to REAR AXLE ASSEMBLY (from 5095 to 7) 5-/0 to REAR AXLE ASSEMBLY (from 505 to 77) 5-/0 to REAR AXLE ASSEMBLY (from 59 to ) 5.9 to REAR AXLE ASSEMBLY (cars 7 and up) 5-l/0 to REAR AXLE ASSEMBLY (cars 77 and up) 5-/0 to REAR AXLE ASSEMBLY (cars 77 and up) 5.9 to HOUSING 5 CY 50 BY 50 BY 50 BY 5 BY 9 BY 55 BY 50 BY 5 BY 500 BZ 57 BM BM 0 REAR AXLE HOUSING ASSEMBLY (complete less brake shoes) Brake spider R.H. Brake spider L.H. Brake spider to housing rivet inner Brake spider to housing rivet outer /"x" Brake spider to backing plate rivet 5/"x" COVER ASSEMBLY Cover brace Cover gasket Cover bolt /"-x/" Cover drain plug /" Wheel bearing lubrication hole plug /"
0 ESSEX SUPER-SIX PARTS LIST DIFFERENTIAL AND CARRIER 7 7 7 9 0 5 7 9 0 5 7 CY 50 CY 50 CY 00 CY 0 CY 09 CY 0 BY 507 BY 50 BY 005 BY 50 BY 50 BY 00 BY 5 BY 557 BY 00 BY 05 BY 50 BY BY 705 BZ 705 BY 05 BY 05 BY 09 BZ BY 505 BY 0 BY 97 BY 059 BY 0 700 7 700 BY 505 BY 505 CY 505 BY 5 BR BY 700 BM 0 BR 0 BY 500 CARRIER AND GEAR SET ASSEMBLY (cars 7 to 7) 5-/0 to CARRIER AND GEAR SET ASSEMBLY (cars 7 to 77) 5-/0 to CARRIER AND GEAR SET ASSEMBLY (cars 7 to 775) 5.9 to CARRIER AND GEAR SET ASSEMBLY (cars 7 and up) 5-/0 to CARRIER AND GEAR SET ASSEMBLY (cars 77 and up) 5-/0 to CARRIER AND GEAR SET ASSEMBLY (cars 77 and up) 5.9 to Drive gear and pinion matched 5-/0 to Drive gear and pinion matched 5-/0 to Drive gear and pinion matched 5.9 to Drive gear 5-/0 to Drive gear 5-/0 to Drive gear 5.9 to Drive pinion 5-l/0 to Drive pinion 5-/0 to Drive pinion 5.9 to Drive gear bolt "-xl-7/" Drive gear bolt lock Drive gear bolt nut /"-x/" Drive pinion nut 7/"- castle Drive pinion washer DIFFERENTIAL CASE ASSEMBLY (includes cone) DIFFERENTIAL CASE ASSEMBLY (includes cone) (cars 77 up) Stud /"-x/"-x-/" Stud nut /"- castle Gear Gear (cars 77 up) Pinion Spider Spider (cars 77 up) DIFFERENTIAL BEARING ASSEMBLY Timken - Serviced direct by Timken Roller Bearing Co., Canton, Ohio Bearing cone Timken Serviced direct by Timken Roller Bearing Co., Canton, Ohio. Bearing cup Timken Serviced direct by Timken Roller Bearing Co., Canton, Ohio. Differential adjusting nut Differential adjusting nut lock DIFFERENTIAL CARRIER ASSEMBLY Differential adjusting nut bolt 7/"-0x-/" Differential adjusting nut lock bolt nut 7/"-0x9/" Pinion housing stud 7/"-x" Pinion housing stud nut 7/"-0x/" Housing bolt /"-x-/" Gasket PINION HOUSING 9 9 0 BY 5059 BY BY 50 BY 50 700 7009 700 7009 7009 7009 BY 50 BY 79 BY 5 PINION HOUSING ASSEMBLY (includes bearing cups) Oil baffle pinion housing Pinion housing shim thin Pinion housing shim thick PINION BEARING ASSEMBLY UPPER Timken - Serviced direct by Timken Roller Bearing Co., Canton, Ohio. Cone Timken Serviced direct by Timken Roller Bearing Co., Canton, Ohio Cup Timken Serviced direct by Timken Roller Bearing Co., Canton, Ohio. PINION BEARING ASSEMBLY LOWER Timken -0 Serviced direct by Timken Roller Bearing Co., Canton, Ohio. Cone Timken Serviced direct by Timken Roller Bearing Co., Canton, Ohio. Cup Timken 0 Serviced direct by Timken Roller Bearing Co., Canton, Ohio. Pinion bearing spacer Pinion bearing spacer shim thick Pinion bearing spacer shim medium 5 AS req. As req.
ESSEX SUPER-SIX PARTS LIST PINION HOUSING Continued 5 BY 0 BY 50 BY 50 BZ 507 Pinion bearing spacer shim thin PINION DUST WASHER ASSEMBLY Pinion dust collar Universal joint companion flange Leather As req. DRIVE SHAFT 7 9 0 CY 505 BY 09 BY 5 BY 570 BY 577 BY 57 BM 7 BY 57 CY 500 CY 0 CY 50 CY 705 CY 705 DRIVE SHAFT ASSEMBLY (from 7 to 5057) Thrust button (from 7 to 5057) Drive shaft key Drive shaft washer Drive shaft washer retainer inner Drive shaft washer retainer outer Drive shaft nut (from 7 to 5057) Drive shaft nut washer (from 7 to 5057) DRIVE SHAFT ASSEMBLY (from 505 to 77) DRIVE SHAFT ASSEMBLY (from 77 up) Drive shaft thrust button (from 505 up) Drive shaft nut (from 505 up) Drive shaft washer (from 505 up) Felt 5/"-x9/" castle REAR WHEEL BEARINGS 5 7 9 BY 50 7000 7005 700 BZ 9 BY 0 BY 097 BY 00 BY 09 BM 0 WHEEL BEARING ADJUSTING CAP ASSEMBLY (includes bearing cup) WHEEL BEARING ASSEMBLY Serviced direct by Timken Roller Bearing Co., Canton, Ohio Cone Timken Serviced direct by Timken Roller Bearing Co., Canton, Ohio Cup Timken 9 Serviced direct by Timken Roller Bearing Co., Canton, Ohio Wheel bearing adjusting cap bolt /"-x-/" Wheel bearing adjusting cap shim thick Wheel bearing adjusting cap shim medium Wheel bearing adjusting cap shim Wheel bearing adjusting cap felt washer Wheel bearing oil hole plug 0 REAR BRAKES 50 5 5 5 5 55 5 57 5 59 0 5 7 9 70 7 BY BY 5 BY 9 BY 97 BZ 70 BR BX BX 9 BX 977 BX 977 BX 90 BX 5 BX 9 BT 9 BX 09 BZ BX 7 BX 90 BX 975 BX 97 BX 97 BX BY 99 BY 9 BX 5 BX 959 BX 07 REAR BRAKE BACKING PLATE ASSEMBLY L.H. REAR BRAKE BACKING PLATE ASSEMBLY R.H.. Rear brake crank lever R.H.. Rear brake crank lever L.H. Rear brake crank lever bolt Rear brake crank lever bolt nut Brake shoe spacer pin washer Brake shoe spacer pin spring Brake shoe spacer steady rest pin washer Brake shoe spring small Brake shoe spring large BRAKE SHOE ASSEMBLY ( shoes) BRAKE REINFORCING PLATE AND ANCHOR PIN ASSEMBLY Brake anchor pin nut BRAKE ECCENTRIC ASSEMBLY Brake eccentric nut Brake adjusting screw Brake adjusting screw spring Brake adjusting screw pivot nut L.H.. Brake adjusting screw pivot nut R.H. Brake adjusting screw cover BRAKE CAMSHAFT AND CRANK ASSEMBLY Brake camshaft dust shield Brake camshaft retainer washer BRAKE CAM PLATE AND BLOCK ASSEMBLY BRAKE CAM CARRIER BRACKET ASSEMBLY Bushing 5/"-xl5/" 5/"-xl7/" 5/"-x5/" /"-x/"
ESSEX SUPER-SIX PARTS LIST WHEELS-WOOD FRONT CW 57 BZ 5 BZ 707 BZ 707 CW 590 BZ 50 BZ 79 BZ 705 BZ 50 BZ 7059 709 70 700 70 70 70 FRONT WHEEL ASSEMBLY HUB ASSEMBLY (includes bearing cups) Hub bolt Hub bolt nut Brake drum Oil throw Brake drum inspection cover Brake drum inspection cover screw Hub cap Valve hole grommet FRONT WHEEL BEARING ASSEMBLY INNER Serviced direct by Timken Roller Bearing Co., Canton, Ohio. Cup inner Serviced direct by Timken Roller Bearing Co., Canton, Ohio. Cone inner Serviced direct by Timken Roller Bearing Co., Canton, Ohio. FRONT WHEEL BEARING ASSEMBLY OUTER Serviced direct by Timken Roller Bearing Co., Canton, Ohio. Cup outer Serviced direct by Timken Roller Bearing Co., Canton, Ohio. Cone outer Serviced direct by Timken Roller Bearing Co., Canton, Ohio. WHEELS-WOOD REAR CW 59 BZ 59 BZ 707 BZ 707 CW 577 BZ 5 BZ 79 BZ 705 BZ 50 BZ 7059 REAR WHEEL ASSEMBLY Hub Hub bolt Hub bolt nut Brake drum Oil throw Brake drum inspection cover Brake drum inspection cover screw Rear wheel hub cap Valve hole grommet WHEELS-WIRE CW 5557 CW 55 BZ 55 BZ 555 BZ 55 CW 5570 BZ 557 CW 557 BZ 55 BZ 555 BZ 559 BZ 59 BZ 557 BZ 557 BZ 557 709 70 700 70 70 70 WIRE WHEEL ASSEMBLY FRONT HUB AND BRAKE DRUM ASSEMBLY- FRONT HUB AND BEARING CUPS ASSEMBLY Front hub bolt Front wheel oil throw Brake drum Brake drum rivet /"xl-/" REAR HUB AND BRAKE DRUM ASSEMBLY Rear hub Rear hub bolt 9/"-x-/" Rear wheel oil throw Hub cap inner (front wheels) Hub cap outer (front and rear wheels) Brake drum inspection hole cover Brake drum inspection hole cover screw /"-0xl7/" FRONT HUB BEARING ASSEMBLY INNER Timken 7- Serviced direct by Timken Roller Bearing Co., Canton, Ohio. Cup inner Timken 7 Serviced direct by Timken Roller Bearing Co., Canton, Ohio. Cone inner Timken Serviced direct by Timken Roller Bearing Co., Canton, Ohio. FRONT HUB BEARING ASSEMBLY OUTER Timken 099-0907 Serviced direct by Timken Roller Bearing Co., Canton, Ohio. Cup outer Timken 099 Serviced direct by Timken Roller Bearing Co., Canton, Ohio. Cone outer Timken 0907 Serviced direct by Timken Roller Bearing Co., Canton, Ohio. 5 0 0 0
ESSEX SUPER-SIX PARTS LIST WHEELS WIRE (SPECIAL SEDAN) CW 9 BZ BZ 97 BZ 5 BZ WIRE WHEEL ASSEMBLY Wire wheel snap-on spoke (short) R.H.. Wire wheel snap-on spoke short) L.H.. Wire wheel snap-on spoke (long) R.H.. Wire wheel snap-on spoke (long) L.H.. (All Wheel s Not Shown Here Are the Same as Shown in Previous Group) 5 50 50 50 50 DEMOUNTABLE RIM CW 59 BZ 0 BZ 05 BZ 075 DEMOUNTABLE RIM ASSEMBLY Rim clamp Rim bolt 7/"-x-/" Rim nut 7/"- 5 SIDE TIRE CARRIER BZ BZ 55 BY 705 BZ 575 BZ 575 BZ 709 BZ BZ 09 BZ 0 BZ 70 BZ 77 BZ 7 BZ 70 SPARE TIRE TO DASH BRACE ASSEMBLY (cars 7 to 505) SPARE TIRE TO DASH BRACE ASSEMBLY (cars 50 up) rier brace nut rier bracket R.H. rier bracket L.H. rier bracket bolt 5/"-x/" rier bracket bolt nut 5/"-x5/" CARRIER LOCK ASSEMBLY CLAMP ASSEMBLY (WOOD WHEELS) Strap Clamp bolt Clamp bolt nut "T" Cowl panel rubber ferrule CZ 555 BZ 557 BZ 55 BZ BZ BZ 7 BZ 0 BO 0 BZ BO 0 BZ 5597 BZ 0 BZ 7050 REAR TIRE CARRIER WOOD WHEELS TIRE CARRIER ASSEMBLY Tire carrier arm R.H. Tire carrier arm L.H. Tire carrier clamp TIRE LOCK ASSEMBLY Tire carrier stud Tire carrier stud nut Tire carrier arm to carrier bolt /"-x-/ Tire carrier arm to carrier bolt nut /"- Tire carrier arm to cross member bolt /"-x-/" Tire carrier brace lower Tire carrier brace lower to cross member bolt Tire carrier brace lower ferrule / REAR TIRE CARRIER WIRE WHEELS CZ 55 BZ 555 BZ 555 BZ 55 BZ 0 BZ 0 BZ BO 0 BY 0 BZ 555 BZ 55 BZ 559 TIRE CARRIER ASSEMBLY Tire carrier brace lower Tire carrier arm-r.h. Tire carrier arm L.H. Tire carrier flange lock stud Tire carrier flange lock stud nut Tire lock assembly Tire carrier arm to cross member bolt Tire carrier brace lower to cross member bolt Tire carrier hub bolt Tire carrier lock plate Tire carrier lock stud /"-x-/" REAR TIRE CARRIER R.H.D. WOOD WHEELS (All Tire rier s Not Shown Here Are Same as for Standard rier) CZ 55 BZ 55 TIRE CARRIER ASSEMBLY Tire carrier brace lower
ESSEX SUPER-SIX PARTS LIST SPRINGS FRONT CZ 550 CZ 577 CZ 77 CZ 5 CZ 5 CZ 5 CZ 5 CZ 09 CZ BZ 75 BM 0 BZ 75 BZ 7 BZ 0 BZ 0 BM 7 BZ 55 BZ 09 BZ 5 BZ 5 BZ 555 BZ BZ 57 BZ 07 BZ 5 BZ BZ 097 BZ 5550 BO 05 BZ 570 FRONT SPRING ASSEMBLY Leaf Leaf Leaf Leaf Leaf 5 Leaf Leaf 7 Leaf Front spring center bolt Front spring center bolt nut Front spring front bushing Front spring rear bushing Front spring front bolt Front spring front bolt sleeve Front spring front bolt nut Front spring rear bolt Front spring rear bolt nut Front spring shackle plain Front spring shackle tapped Front spring clip Front spring clip nut Front spring bumper Front spring bumper strap Front spring rebound clip small clinch type Front spring rebound clip large clinch type Front spring rebound clip bolted type Rebound clip bolt Rebound clip bolt nut Rebound clip rivet leaves " ctr. to ctr. " ctr. to front " ctr. to rear 7-/" ctr. to front 7" ctr. to rear 5-/" ctr. to front -/" ctr. to rear -/" ctr. to front -/" ctr. to rear 0-/" ctr. to front 0-/" ctr. to rear -/" ctr. to front -/ ctr. to rear " ctr. to front " ctr. to rear -/" ctr. to front -/" ctr. to rear /"-x-/" /"-x/" 5/"x7/"x-5/" plain 5/"X7/"x-5/" drilled 5/"-x-/" 5/"- castle 5/"-x-/" 5/"-x/" special "U" bolt /"-0x7/" 5/"-x-/" * CZ 55 CZ 557 CZ 559 CZ 55 CZ 559 CZ 50 CZ 59 CZ 5 CZ 57 CZ 57 CZ 575 CZ 57 CZ SPRINGS-REAR REAR SPRING ASSEMBLY (used on Coupe and Sport Roadster) 7 leaves 5-/" ctr. to ctr. REAR SPRING ASSEMBLY (used on Coach, Sedans and Chassis) leaves. 5-/" ctr. to ctr. REAR SPRING ASSEMBLY (used on 7-Pass. Sedan only) Leaf " ctr. to front -/" ctr. to rear Leaf 7-/" ctr. to front 5-/" ctr. to rear Leaf (for spring 55) -/" ctr. to front -/" ctr. to rear Leaf (for spring 557) -/" ctr. to front -/" ctr. to rear Leaf (for spring 55) -/" ctr. to front 7" ctr. to rear Leaf (for spring 557) -/" ctr. to front 7" ctr. to rear Leaf 5 (for spring 55) -/." ctr. to front " ctr. to rear Leaf 5 (for spring 557) -/" ctr. to front -/" ctr. to rear Leaf (for spring 55) 0-/ ctr. to front 9-/" ctr. to rear Leaf (for spring 557) -/'" ctr. to front 0-/" ctr. to rear
ESSEX SUPER-SIX PARTS LIST 5 SPRINGS REAR Continued CZ 57 CZ 57 CZ BZ 7 BZ 77 BZ 0 BZ 59 BZ 59 BZ 097 BZ 5 BZ 5 BZ 0 BZ 09 BZ 5 BZ BZ 0 BZ 57 BZ 5550 BO 05 BZ 570 Leaf 7(for spring 55) Leaf 7 (for spring 557) Leaf (for spring 557) REAR SPRING CENTER BOLT ASSEMBLY (for spring 55) REAR SPRING CENTER BOLT ASSEMBLY (for spring 557) Rear spring front bolt Rear spring rebound clip (clinch type) Rear spring rebound clip (bolted type) (for spring 55) Rear spring rebound clip (bolted type) (for spring 557) Rear spring shackle plain Rear spring shackle tapped Rear spring shackle bolt rear Rear spring bolt nut Rear spring clip Rear spring clip nut Rear spring clip strap Rear spring plate Rebound clip bolt Rebound clip bolt nut Rebound clip rivet -/" ctr. to front " ctr. to rear -/" ctr. to front " ctr. to rear 5-/" ctr. to front 5-/" ctr. to rear 5/"-x-/" special 5/"-x/" special "U" bolt /"-0x/" 5/"-x-/" * * SHOCK ABSORBERS (Serviced direct by Monroe Auto Equipment Co., Monroe, Mich.) 577 57 557 55 FRONT SHOCK ABSORBER ASSEMBLY R.H. FRONT SHOCK ABSORBER ASSEMBLY L.H. REAR SHOCK ABSORBER ASSEMBLY R.H. REAR SHOCK ABSORBER ASSEMBLY L.H. BUMPER FRONT CZ 550 BZ 575 BZ 77 CZ 5 CZ 57 BZ BZ 55 BZ 5 BZ 7057 CZ 5 CZ 59 BZ 5 BZ 707 BZ 559 BZ BZ 559 BZ 7 BZ 5 BZ 70 BZ FRONT BUMPER ASSEMBLY Frame bracket bolt 7/"-x" Frame clamp Outside bar upper Outside bar lower Finish plate Finish plate clamp Finish plate clamp bolt Finish plate clamp bolt nut Inside bar R.H. Inside bar L.H. Bar end bolt Bar end bolt nut "-0 Front license plate bracket Front license plate bracket (Special Sedan) Front license plate bracket clamp Front license plate bracket clamp (Special Sedan) Front license plate bracket clamp bolt 5/"-xl" Front license plate bracket clamp bolt (Special Sedan) Front license plate bracket clamp bolt nut 5/"-xl7/" CZ 550 BM 9 CZ 57 CZ 577 CZ 57 CZ 579 BZ 57 BZ 575 BUMPER--REAR REAR BUMPER ASSEMBLY (used with side tire carrier) Frame bolt long Outside bar upper Outside bar lower Inside bar R.H.. Inside bar L.H. Reinforcement bar R.H. Reinforcement bar L.H.. /"-x/"
FRAME
ESSEX SUPER-SIX PARTS LIST 7 BUMPER REAR Continued BZ 5 BZ 707 BZ BZ 55 BZ 5 BZ 7057 Bar end bolt Bar end bolt nut /"-0 Finish plate Finish plate clamp Finish plate clamp bolt Finish plate clamp bolt nut BUMPERETTE REAR CZ 550 CZ 5505 BZ 7075 CZ 57 CZ 57 CZ 579 BZ 5 BZ 59 BZ 5 BZ 707 BZ BZ 55 BZ 5 BZ 7057 BUMPERETTE ASSEMBLY R.H. (used with rear tire carrier) BUMPERETTE ASSEMBLY L.H. (used with rear tire carrier) Frame bolt Outside bar Inside bar R.H. Inside bar L.H. Reinforcement bar R.H. Reinforcement bar L.H. Bar end bolt Bar end bolt nut Finish plate Finish plate clamp Finish plate clamp bolt Finish plate clamp bolt nut CZ 5 BZ 5 BZ 57 CO 795 BO 705 BO 707 BZ 707 BZ 70599 BZ 7007 BZ 707 BZ 7007 BZ 0 TRUNK RACK TRUNK RACK ASSEMBLY Support bracket rear (used on Coupes and Roadsters) Support bracket rear (used on all other models) Moulding Trunk rack moulding bolt Trunk rack moulding bolt nut Trunk rack support bolt Trunk rack sector bolt Trunk rack sector bolt nut Trunk rack sector to trunk rack bolt Trunk rack sector to trunk rack bolt nut Trunk rack support bracket to frame bolt /"-0x7/" /"-0x/" / "-x/" /"-x-/" /"-x/" /"-x/" /"-X/" /"-x-/" 5 7 9 0 C 70 C 500 C 50 C 507 C 75 C 7 BZ 59 BZ 50 BZ 9 BZ 70 BZ 5 BZ 55 BZ 55 BZ 5 BZ 5 BZ 9 BZ 55 BZ 5 BZ 55 BY 55 BZ 57 BZ 5 BZ 557 BZ 0 BZ BY 55 FRAME FRAME ASSEMBLY (7-Pass. Sedan only) FRAME ASSEMBLY SIDE MEMBER ASSEMBLY R.H. SIDE MEMBER ASSEMBLY L.H. SIDE MEMBER ASSEMBLY R.H. (7-Pass. Sedan only) SIDE MEMBER ASSEMBLY L.H. (7-Pass. Sedan only) Front spring front bracket R.H. Front spring front bracket L.H. Front spring front bracket rivet Front spring front bracket rivet long FRONT SPRING REAR BRACKET ASSEMBLY Front spring rear bracket bushing Front spring rear bracket rivet Rear spring front bracket R.H. Rear spring front bracket L.H. Rear spring front bracket rivet REAR SPRING REAR BRACKET ASSEMBLY R.H. REAR SPRING REAR BRACKET ASSEMBLY L.H. Rear spring rear bracket bushing Rear spring rear bracket rivet Engine support rear R.H.. (cars 7 to 5759) Engine support rear L.H.. (cars 7 to 5759) Engine support rear brace (cars 7 to 5759) Engine support rear brace bolt (cars 7 to 5759) Engine support rear brace bolt nut (cars 7 to 5759) Engine support rivet (cars 7 to 5759) 5/"x-/" 5/"x"" 5/"x" /'-x/"
ESSEX SUPER-SIX PARTS LIST FRONT AXLE 5 7 9 0 5 7 9 0 CZ 5 BZ 97 BZ BZ 5 BZ 5 BZ 59 BZ 50 BZ 5 BZ 9 BZ 55 BY 97 BY 55 BZ 5 CZ 5 BY 55 BZ 5 BZ BZ 55 BZ 5 BZ BZ 7 BZ BZ 590 BZ BZ BZ 579 BZ 50 BZ 70095 BZ BZ 55 BY 55 BZ 705 BM 0 BZ 0 BZ 97 BZ BZ 55 Engine support rear (cars 5759 up) Engine support rivet (cars 5759 up) Engine support rivet short (cars 5759 up) Engine support front R.H. Engine support front L.H. Body bolt bracket (first) Body bolt bracket (second) R.H. Body bolt bracket (second) L.H. Body bolt bracket (third and fourth) Body bolt bracket (fifth) Body bolt bracket rivet Body bolt bracket (second) rivet Stoplight switch bracket Running board bracket (front) Running board bracket (front) rivet Running board bracket (center) Running board bracket (center) rivet RUNNING BOARD BRACKET ASSEMBLY REAR R.H. RUNNING BOARD BRACKET ASSEMBLY REAR L.H. Running board bracket (rear) rivet Rear brake idler lever bracket Rear brake idler lever bracket rivet Frame rear axle bumper Frame rear axle bumper bolt Frame rear axle bumper bolt nut Fender well support bracket R.H. Fender well support bracket L.H. Fender well support bracket bolt Fender well support bracket bolt nut BATTERY TRAY ASSEMBLY Rivet Bracket bolt 5/"x7/" 5/"x" 5/"x" 5/"x7/" 5/"x7/" 5/"x7/" 5/"-x" 5/"-x5/" 5/"-x7/" 5/"-xl7/" 5/"x" /"-x-/" /"-x/" Bracket bolt nut Muffler bracket front Muffler bracket front rivet Muffler bracket rear (cars 57 and 00095 up) Muffler bracket rear rivet (cars 57 and 00095 up) 5/"x" 7 FRAME CROSS MEMBERS 5 7 9 0 C 5 BZ 97 BZ 5 BZ 55 BZ 9 C 55 BZ BZ 57 BZ 5 BZ 50 BZ 5 BZ 55 C 5 BZ 55 C 5 BZ 55 BZ 55 BZ 70 FIRST CROSS MEMBER ASSEMBLY Rivet Reinforcement Rivet Rivet SECOND CROSS MEMBER ASSEMBLY Rivet Gusset R.H. front Gusset L.H. front Gusset R.H. rear Gusset L.H. rear Rivet Third cross member Third cross member to frame rivet FOURTH CROSS MEMBER ASSEMBLY Rivet Fourth cross member bumper bolt clinch nut Fourth cross member tire carrier bolt clinch nut 5/"x7/" 5/"x" 5/"xl" 5/"x" 5/"xl" 9 FRAME R.H.DRIVE (All Frame s Not Shown Here Are the Same as for Standard Left Hand Drive) C 50 C 9 C 7 C 7 C 50 C 505 FRAME ASSEMBLY FRAME ASSEMBLY (7-Pass. Sedan only) SIDE MEMBER ASSEMBLY R.H.(7-Pass. Sedan only) SIDE MEMBER ASSEMBLY L.H.(7-Pass. Sedan only) SIDE MEMBER ASSEMBLY R.H. SIDE MEMBER ASSEMBLY L.H.
ESSEX SUPER-SIX PARTS LIST 9 ENGINE CM 505 BM 700 BM 50 BM 59 BM 597 BM 5070 BM 59 BM 599 BM 5990 BM 599 BM 0 BM 5070 ENGINE ASSEMBLY Engine mounting bolt Engine mounting bolt nut Engine mounting pad front outer Engine mounting pad front inner Engine front mounting shim Engine mounting pad backing plate front Engine mounting pad rear outer Engine mounting pad rear inner Engine mounting pad backing plate rear Engine rear support ground connection Engine front mounting shim /"-0x-9/" /"-0x/" As req. As req. CYLINDER 5 7 0 9 5 7 9 CM 57 BM BM 9 BM 5 BM 5 BM 95 BM 00 BM 70 BM 57 BM 55 BM 0 BM 57 BM BM 595 BM 59 BM 70 BM 50 BM 57 BM 0 BM 577 BM 5 BM BM 705 BM 705 BM BO BO 797 BO 7 BZ 799 BM 5 BM 009 BM 07 BM 705 BM 55 BZ BM 599 BM 5 CM 5 BM 5 BM 57 BM 007 BM BM 9 BM 0 BM 75 CM 5 BM 59 BM 07 BZ BM 59 BM 00 CYLINDER AND PISTONS ASSEMBLY Cylinder expansion plug " Cylinder expansion plug (camshaft) Cylinder water jacket cover Cylinder water jacket cover gasket Cylinder water jacket cover bolt 5/"-x5/" Cylinder water temperature indicator hole plug Cylinder water temperature indicator hole plug gasket CYLINDER SUPPORT PLATE ASSEMBLY FRONT Cylinder support plate (front) gasket Cylinder support plate (front) oil pressure tube baffle Cylinder support plate (front) bolt /"-x/" Cylinder support plate (front) bolt lock Cylinder support plate rear Cylinder support plate rear gasket Cylinder support plate rear to cylinder bolt /"-x-/" Cylinder support plate rear to cylinder dowel Cylinder support plate rear bolt /"-x/" BREATHER TUBE ASSEMBLY FRONT (from motor 055 to 50) BREATHER TUBE ASSEMBLY FRONT (from motor 5 up) Breather tube support Breather tube support gasket Breather tube support bolt 5/"-x-/" Breather tube support bolt gasket Breather tube clip Breather tube clip (front) bolt /"-0x/" Breather tube clip (front) bolt nut /"-0x5/" Breather tube clip clamping bolt 0-x5/" Breather tube clip clamping bolt nut 0-x5/" Cylinder water inlet (from motor 055 to 777) Cylinder water inlet gasket (from motor 055 to 777) Cylinder water inlet stud short 5/"-x-/" Cylinder water inlet stud medium Cylinder water inlet stud long Cylinder water inlet stud nut 5/"-x5/" Cylinder water inlet (from motor 77 up) Cylinder water inlet gasket (from motor 77 up) CYLINDER HEAD ASSEMBLY Cylinder head gasket Cylinder head stud long Cylinder head stud short Cylinder head stud medium /"-x-5/" Cylinder head stud nut (ignition cable tube) Cylinder head stud nut Cylinder head expansion plug 7/" CYLINDER HEAD WATER OUTLET ASSEMBLY Cylinder head water outlet flange gasket Cylinder head water outlet stud 5/"-x-/" Cylinder head water outlet stud nut Oil level gauge rod OIL FILLER ASSEMBLY COMPLETE 5/"-x5/" I 7 5 7 9
ENGINE SIDE VIEW
ENGINE SIDE VIEW
ESSEX SUPER-SIX PARTS LIST CYLINDER Continued 0 BM 595 BM 079 BM 9 OIL FILLER ASSEMBLY Cover spring Oil filler attaching screw /"-0x7/" EXHAUST MANIFOLD 5 CM 5 BM 7 BM BM 705 BM 59 BM 59 BM 55 BM 70577 Exhaust manifold Exhaust manifold stud Exhaust manifold stud Exhaust manifold stud nut Exhaust manifold gasket end Exhaust manifold gasket center Exhaust damper valve cover gasket Exhaust damper valve cover bolt /"-x/" 5/"-x7/" 7.. 9 0 5 7 9 0 CM 59 CM 97 BM 70 BM BM 55 BM 55 BM 00 BM CM 570 BM 57 BM 577 BM 0 BM BM 555 BM 57 BM 579 BM BM 9 BM 555 BM 507 BM 5 BM 5 BM BM BM 555 BM 5 BM 55 BM 5 BM BM 5 BM 59 BM 00 BM 00 BM 507 BM 0 BM 50 BM 5 BM 59 BM 599 BM 70 FLYWHEEL AND CRANKSHAFT FLYWHEEL ASSEMBLY (from motor 055 to 05) FLYWHEEL ASSEMBLY (from motor 059 up) Flywheel drain plug /" Flywheel starter gear Flywheel cover (from motor 0 up) Flywheel cover screw (from motor 0 up) Flywheel bolt Flywheel bolt nut /"-x/' CRANKSHAFT ASSEMBLY Counterweight bolt 7/"-0x-/' Counterweight bolt lock Crankshaft starting jaw Crankshaft starting jaw spring washer CRANKSHAFT BEARING CAP ASSEMBLY FRONT Crankshaft bearing upper front Crankshaft bearing lower front Crankshaft bearing shim thin front Crankshaft bearing shim thick front CRANKSHAFT BEARING CAP ASSEMBLY CENTER (from motor 055 to 5) CRANKSHAFT BEARING CAP ASSEMBLY CENTER (from motor 5 up) Crankshaft bearing upper center Crankshaft bearing lower center Crankshaft bearing shim thick center Crankshaft bearing shim thin center CRANKSHAFT BEARING CAP ASSEMBLY REAR Crankshaft bearing upper rear Crankshaft bearing lower rear Crankshaft bearing shim thick rear Crankshaft bearing shim thin rear Crankshaft fan pulley see vibration dampener. Crankshaft bearing screw /"-0x/" Crankshaft bearing cap packing CrankThaft bearing cap stud long Crankshaft bearing cap stud short (from motor 055 to 5) Crankshaft bearing cap stud short (from motor 5 up) Crankshaft bearing cap stud nut / -0 CRANKSHAFT OIL THROW ASSEMBLY UPPER Crankshaft oil throw lower Crankshaft oil throw gasket upper Crankshaft oil throw gasket lower Crankshaft oil throw bolt 7 CAMSHAFT 5 7 9 50 CM 59 BM 00 BM 00 BM 00 BM 07 BM 97 BM BM Camshaft Camshaft bearing Camshaft bearing Camshaft bearing Camshaft bearing anchor plug Camshaft bearing anchor plug seal Camshaft thrust button Camshaft thrust button spring
ESSEX SUPER-SIX PARTS LIST CAMSHAFT Continued 5 5 5 BM 570 BM 57 BM 5 BM 97 BM 070 Camshaft thrust button guide Camshaft thrust button guide plate Camshaft thrust plate Camshaft thrust plate rivet Camshaft thrust washer /"x5/" CONNECTING RODS 5 55 5 5 5 57 5 BM 505 BM 50 BM 59 BM 0 BM BM 5 BM 50 Connecting rod complete R. H Cylinders l, and Connecting rod complete L.H. Cylinders, 5 and Connecting rod shim thick Connecting rod shim medium Connecting rod shim thin Connecting rod bolt /"-x-5/" Connecting rod bolt nut /"- castle VALVES 59 0 5 7 9 70 7 7 7 7 75 7 BM 70 BM 95 BM 9 BM 00 BM 97 BM 5 BM 009 BM 0099 BM 0 BZ 90 BM 797 BM 97 BM 0 BM 77 BM 59 BM 00 BM 55 BM BM 7 BM 0 BM 0 BO 9 BM 5 VALVE TAPPET AND GUIDE ASSEMBLY Tappet Roller Pin Guide Adjusting screw Adjusting screw nut Plate Clamp Clamp bolt Valve exhaust Valve inlet Valve stem guide Valve spring Valve spring seat Valve spring seat retainer VALVE CHAMBER COVER ASSEMBLY COMPLETE Stud Stud nut Leather Stiffener Stiffener rivet Valve chamber cover gasket 5/"-x7/" /"-0x/" PISTON 77 7 79 0 0 BM 505 BM 5009 BM 50 BM 50 BM 50 BM BM 00 Piston (see reference sheet for correct size). Piston pin (furnished in std.,.00",.005" and.00" oversize) Piston ring compression (furnished in.005",.00",.00" and.00" oversize) Piston ring oil upper (furnished in.005",.00",.00" and.00" oversize) Piston ring oil lower (furnished in.005",.00",.00" and.00" oversize) Piston pin bushing Piston pin lock ring 5 7 50 BM 7 BZ 7909 BM BM 70 BM 79 BM 5 BM 55 BM 5 BM 57 BM GENERATOR DRIVE GROUP GENERATOR ASSEMBLY Serviced direct by Electric Auto-Lite Corp., Toledo, Ohio. Generator bracket Generator bracket bolt Generator bracket clamp Generator bracket clamp bolt /"-x-7/" Generator bracket clamp bolt nut /"-x7/" Generator drive shaft Generator drive shaft bearing Generator drive shaft eccentric Generator drive shaft eccentric gasket Generator coupling stationary
ESSEX SUPER-SIX PARTS LIST GENERATOR DRIVE GROUP Continued 9 90 9 9 9 9 95 9 BM 9 BZ 5 BM 7 BM 59 BM BM 5 BM 797 BM 570 BM 70 BM 095 Generator coupling floating Generator drive shaft stationary coupling key Generator drive shaft stationary coupling pin Generator drive shaft coupling Generator drive shaft coupling clamp Generator drive shaft coupling clamp bolt /"-0x-5/" Generator drive shaft coupling clamp bolt nut /"-0x5/" Generator gear thrust washer Generator gear thrust washer spring Generator gear thrust washer dowel pin /x5/" 97 9 99 00 0 0 0 0 05 0 597 BT 95 BZ 0 BM 5 BM 0 BM 70 BM 705 BM 5 BZ BM 5 BM 05 BM 0 BM 0 BM 5 BM BS 995 BS 9957 BM DISTRIBUTOR MOUNTING DISTRIBUTOR ASSEMBLY (not supplied) Distributor bolt Distributor bolt plain washer DISTRIBUTOR SUPPORT ASSEMBLY Distributor priming plug Distributor support bolt long Distributor support bolt short Distributor support bolt lock Distributor support bolt nut Distributor support bolt spacer Distributor drive shaft Distributor drive shaft bushing upper Distributor drive shaft bushing lower Distributor drive shaft bushing lower pin Distributor drive shaft nut Distributor drive shaft plug Distributor drive shaft plug gasket Distributor drive gear 5/"-x-/" 5/"-x-/" 5/"-x5/" 5/"-xl7/" 07 0 09 0 5 CM 597 BM 9 BZ BM 05 BM 0900 BM 9 BM BM 705 BM 9 BM 5 CM 50 BM BO 7 BZ 799 OIL PAN OIL PAN ASSEMBLY Oil pan bolt 5/"-x/" Oil pan drain plug /" Oil pan oil return pipe assembly (from motor up) Oil pan gauge flange cover OIL PAN GAUGE ASSEMBLY Oil pan gauge gasket Oil pan gauge fastening screw Oil pan gauge wire screw -x/" brass Oil pan gasket OIL PAN TRAY ASSEMBLY OIL PAN SCREEN ASSEMBLY Oil pan screen screw 0-x5/" Oil pan screen screw nut 0-x/" 5 j 7 9 0 BM 77 BM 7 BM 0 BM BM BM BM BM 9 BM 797 BM 79 BM 7 BM BM 5 BM 990 BM 79 BM 7 BM 57 OIL PUMP AND CHECK VALVE OIL PUMP ASSEMBLY Oil pump body Oil pump body plug Oil pump body plug gasket Oil pump plunger Oil pump shaft Oil pump shaft retaining screw Oil pump outlet elbow rear Oil pump union Oil pump body gasket Oil pump body bolt OIL CHECK VALVE ASSEMBLY Oil check valve body Oil check valve plug Oil check valve plug gasket Oil check valve plunger Oil check valve plunger spring /"-x/" special /"x/"-0 /"x/"-0 5/"-x-/" I
ESSEX SUPER-SIX PARTS LIST 5 OIL PIPES AND FITTINGS 5 BM 9 BM 559 BM 557 BM BM BM 5 BM 5 BO 57 BM 799 BM 9 BM 599 BM 9 BM 9 BM 797 BM 55 BM 9 BM BM 797 BM 57 BM 555 Outlet pipe union rear /" pipe x/"-0 Oil check valve to pressure gauge pipe and wire loom OIL CHECK VALVE TO GAUGE PIPE ASSEMBLY COMPLETE Oil check valve to gauge pipe union /" pipe x7/"-0 Oil check valve to gauge pipe nut / OIL PUMP TO CHECK VALVE PIPE ASSEMBLY Oil pump to check valve pipe clip Oil pump to check valve pipe clip screw 0-x7/" Oil pump to check valve pipe clip screw nut 0-x/" Oil pump suction pipe union elbow /" pipe x/"-0 OIL PUMP TO FRONT SUPPORT PIPE ASSEMBLY Oil pump to front support pipe elbow (90 ) (from motor 9 up) Oil pump to front support pipe elbow (5 ) (from motor 9 up) Oil pump to front support pipe elbow (from motor 055 to 95) OIL PUMP SUCTION PIPE ASSEMBLY Oil pump suction pipe elbow /" pipe x/"-0 Oil pump suction pipe union cylinder end Oil pump suction union pump end /"-0 Oil pan suction pipe Oil pump to reservoir suction pipe wedge TIMING SPROCKETS, COVER AND CHAIN 5 7 9 0 BM 09 BM 5 BM 009 BM 57 BM 9 BM BM 5 BM 799 BM 00 BM 59 CM 55 BM 9 BZ BM 55 BM 00 Timing chain (from motor 055 to 5) Morse Timing chain (from motor up) Camshaft sprocket (from motor 055 to 5) teeth Camshaft sprocket (from motor up).. Camshaft sprocket bolt %"-x.%"" Crankshaft sprocket (from motor 055 to 5) Special 9 teeth Crankshaft sprocket (from motor up) Crankshaft sprocket key Woodruff "A" Generator sprocket (from motor 055 to 5) teeth Generator sprocket (from motor up) TIMING GEAR COVER ASSEMBLY Timing gear cover bolt 5/"-x/" Timing gear cover bolt nut 5/"-x5/" Timing gear cover gasket Timing gear cover felt washer Felt I I 5 VIBRATION DAMPENER (From Motor 055 to 90) 5 7 9 50 5 5 BM 59 BM 59 BM 59 BM 9 BM 59 BM 59 BM 50 BM 597 BM 599 BM 59 BM 599 BM 70 BM 0 BM 799 VIBRATION DAMPENER ASSEMBLY FAN PULLEY ASSEMBLY Fan pulley HUB ASSEMBLY Hub dowel Hub dowel retainer Spring Spring retainer Facing Rivet COVER PLATE ASSEMBLY Cover plate screw Cover plate gasket Dampener hub key /"x9/" "-0x/" Woodruff "A" BM 55 BM 5 BM 509 BM 559 BM 557 BM 55 BM 55 (From Motor 9 up) VIBRATION DAMPENER ASSEMBLY Fan pulley HUB ASSEMBLY Hub dowel Spring retainer Facing Cover plate
ESSEX SUPER-SIX PARTS LIST CLUTCH-L.H.. DRIVE 5 7 9 0 5 7 9 0 BR 50 BR 5 BR 59 BR 99 BR 50 BR 50 BR 50 BM 9 BR 50 BR 57 BR 507 BR 500 BR 0 BR BR 9 BR BR BR 50 BZ 977 BR 5097 BR 057 BY 05 BR 50 BR 707 CLUTCH ASSEMBLY DRIVING PLATE ASSEMBLY COMPLETE Driving plate cork Pressure plate Throwout finger Throwout finger pin Throwout finger lock plate Throwout finger lock plate lock 5/"-x/" Throwout finger lock plate bolt lock Engaging spring Cover THROWOUT BEARING RETAINER ASSEMBLY (from motor 055 to 0). THROWOUT BEARING RETAINER ASSEMBLY (from motor 05 up) Throwout bearing Throwout bearing oil retainer (from motor 055 to 0) Throwout bearing oil retainer (from motor 05 up) Throwout bearing oil retainer gasket (from motor 05 up) COLLAR ASSEMBLY Collar plug / headless CLUTCH SHIFTER YOKE ASSEMBLY Clutch shifter yoke bushing Clutch shifter yoke clevis pin 7/"x-/" Clutch cover gasket Clutch cover bolt CLUTCH-R.H. DRIVE BR 5 BR 59 CLUTCH COLLAR ASSEMBLY CLUTCH SHIFTER YOKE ASSEMBLY
ESSEX SUPER-SIX PARTS LIST 7 5 7 9 0 5 7 9 0 5 7 9 0 5 7 7 9 0 5 7 9 50 5 CT 500 CT 50 CT 0 BT 05 BT 050 BT BT 5 BT 00 BT 00 CT 5 BT BM 7 BZ BT 5 BZ 705 BT 7050 BT 5 BT 55 BZ 75 BT 5 BT 5 BT 7005 BR 70 BT 5 BT BT 5 BT 0 BT 59 BT 50 BT 5 BT 5 BM BT 00 BT 000 BT 99 BT BT 5 BM BT 00 BT 57 BT 0 BT 5 BT 50 BZ 75 BT 05 BT 05 BT BT BT 095 BT 7 BT 75 BT 05 BT 055 BT 5 BT 5 BT 57 BT 5 BT 0 BT 0 BT 00 BT 007 BT 5 BT 0 BT BT 00 TRANSMISSION (From Motor 055 to 0) TRANSMISSION ASSEMBLY 5-/0 to TRANSMISSION ASSEMBLY 5-/0 to TRANSMISSION ASSEMBLY 5.9 to Speedometer pinion 5-l/0 to Speedometer gear 5-l/0 to Speedometer pinion 5-/0 to Speedometer gear 5-/0 to Speedometer pinion 5.9 to Speedometer gear 5.9 to Transmission case Transmission case drain plug Transmission case drain plug gasket Transmission case filler plug Transmission case to rear motor plate bolt Transmission case to rear motor plate bolt nut /"-0 Transmission case to cylinder bolt Front bearing cap Front bearing cap gasket Front bearing cap bolt MAIN DRIVE GEAR ASSEMBLY Main drive gear bushing MAIN DRIVE GEAR BEARING ASSEMBLY LARGE N. D. 07 MAIN DRIVE GEAR BEARING ASSEMBLY SMALL Main shaft MAIN SHAFT BEARING ASSEMBLY Hyatt N. C. 0 Main shaft bearing retainer Main shaft bearing inner sleeve Main shaft second and high gear Main shaft low and reverse gear Main shaft thrust ball Countershaft Countershaft expansion plug Countershaft lock screw COUNTERSHAFT DRIVE AND INTERMEDIATE GEAR ASSEMBLY COUNTERSHAFT LOW AND REVERSE GEAR ASSEMBLY Countershaft gear bushing REVERSE IDLER SHAFT ASSEMBLY Reverse idler shaft expansion plug Reverse idler lock screw REVERSE IDLER GEAR ASSEMBLY Reverse idler gear bushing Speedometer gear housing gasket Speedometer gear housing Speedometer gear housing bolt /"-x-7/" Speedometer gear housing shim thick Speedometer gear housing shim thin Speedometer gear housing thrust washer Steel Speedometer gear housing thrust washer Bronze Speedometer gear housing thrust washer pin Speedometer pinion sleeve Speedometer pinion sleeve shim Gear shift fork Gear shift fork screw 5/"-x-/" special Second and high shifting rail Low and reverse shifting rail. Gear shift rail interlock Gear shift rail lock ball /" Gear shift rail lock ball spring Gear shift rail lock cap R. H Gear shift rail lock cap L.H.. Gear shift rail lock plunger Gear shift rail lock strap Gear shift rail lock strap spring Gear shift rail lock strap spring retainer Gear shift rail lock strap guide As req.
TRANSMISSION
ESSEX SUPER-SIX PARTS LIST 9 TRANSMISSION Continued (From Motor 055 to 0 Continued) BT 55 BM 7 BM 955 BR 5097 BR 057 BM 05 Companion flange Companion flange nut Companion flange washer CLUTCH YOKE ASSEMBLY Clutch yoke bushing Clevis pin 5 7 9 0 5 7 9 0 5 7 9 0 5 5 7 7 9 0 CT 550 CT 557 CT 5 BT 05 BT 050 BT BT 5 BT 0 BT 0 CT 57 CT 0 BT BM 77 BZ BT 5 BZ 705 BT 7050 BT 5 BT 55 BZ 75 BT 57 BT 5 BT 7005 BR 70 BT 5 BT BT 5 BT 0 BT 50 BT 5 BT 5 BT 590 BT 5 BM 9 BT 00 BT 5 BT 5 BT 55 BT 5 BM BT 00 BT 5 BT 0 BT 50 BT 5 BO 75 BT 09 BT BT 707 BT 75 BT 70 BT 05 BT 05 BT BT BT 095 BT 7 (From Motor up) TRANSMISSION ASSEMBLY 5-l/0 to TRANSMISSION ASSEMBLY 5-/0 to TRANSMISSION ASSEMBLY 5.9 to Speedometer pinion Speedometer Gears 5-/0 to Speedometer gear and Pinions for 5-/0 to Speedometer pinion Free Wheeling Are 5-/0 to Speedometer gear Listed in Free 5- /0 to Speedometer pinion Wheeling 5.9 to Speedometer gear Group 5.9 to Transmission case Transmission case Transmission case drain plug Transmission case drain plug gasket Transmission case filler plug Transmission case to rear motor plate bolt /"-0x-/" Transmission case to rear motor plate bolt nut /"-0 Transmission case to cylinder bolt /"-x,' Front bearing cap Front bearing cap gasket Front bearing cap bolt 5/"-xl" MAIN DRIVE GEAR ASSEMBLY Main drive gear bushing MAIN DRIVE GEAR BEARING ASSEMBLY LARGE MAIN DRIVE GEAR BEARING ASSEMBLY SMALL MAIN SHAFT ASSEMBLY MAIN SHAFT BEARING ASSEMBLY Main shaft bearing retainer Main shaft bearing inner sleeve Main shaft second and high gear Main shaft low and reverse gear Main shaft thrust ball Main shaft thrust ball seat Countershaft Countershaft expansion plug, Countershaft lock screw COUNTERSHAFT DRIVE AND INTERMEDIATE GEAR ASSEMBLY COUNTERSHAFT LOW AND REVERSE GEAR ASSEMBLY Countershaft gear bushing REVERSE IDLER SHAFT ASSEMBLY Reverse idler shaft expansion plug Reverse idler lock screw REVERSE IDLER GEAR ASSEMBLY Reverse idler gear bushing Speedometer gear housing Speedometer gear housing gasket Speedometer gear housing bolt /"-x-/" Speedometer gear housing Speedometer gear housing gasket Speedometer gear housing bolt upper /"-x-5/" Speedometer gear housing bolt lower /"-x-/" Speedometer gear housing bolt (shoulder type) /"-x-5/" Speedometer gear housing shim thick Speedometer gear housing shim thin Speedometer gear housing thrust washer steel Speedometer gear housing thrust washer bronze Speedometer gear housing thrust washer pin Speedometer pinion sleeve
FREE WHEELING UNIT
ESSEX SUPER-SIX PARTS LIST TRANSMISSION Continued (From Motor 055 up Continued) 5 7 9 50 5 BT 75 BT 05 BT 055 BT 5 BT 5 BT 57 BT 5 BT 0 BT 0 BT 00 BT 007 BT 5 BT 0 BT BT 00 BT 55 BM 7 BM 955 BT BM 7 BM 955 BR 5097 BR 057 BM 05 Speedometer pinion sleeve shim Gear shift fork Gear shift fork screw 5/"-x/" special Second and high shift rail Low and reverse shift rail Gear shift rail interlock Gear shift rail lock ball /" Gear shift rail lock ball spring Gear shift rail lock cap R.H. Gear shift rail lock cap L.H. Gear shift rail lock plunger Gear shift rail lock strap Gear shift rail lock strap spring Gear shift rail lock strap spring retainer Gear shift rail lock strap guide Companion flange (from motor to 5) Companion flange nut (from motor to 5) Companion flange washer (from motor to 5) Transmission modulator assembly (motor up) Transmission modulator nut (motor up) Transmission modulator nut washer (motor up) (Modulator for Use with Free Wheeling Listed in Free Wheeling Group) CLUTCH YOKE ASSEMBLY Clutch yoke bushing Clevis pin As Req. TRANSMISSION R.H. DRIVE (All Transmission s Not Shown Here Are Same as for Standard Left Hand Drive) CT 07 Transmission case FREE WHEELING SPECIAL EQUIPMENT 5 7 9 0 5 7 9 0 BT 00 BT BT 5 BT BT 700 BT 70 BT 70 BT 5 BT 5 BT 55 BM 0 BT 77 BT 5 BM 7 BM 955 BT 57 BT 5 BT 05 BT 0 BT BT BT BT 5 BT BT 7 BT BT 9 BT 70 BT 7 FREE WHEELING UNIT ASSEMBLY Free wheeling housing gasket Free wheeling rear bearing retainer shim thick Free wheeling rear bearing retainer shim thin Free wheeling housing bolt upper. Free wheeling housing bolt upper Free wheeling housing bolt lower Free wheeling rear bearing retainer Free wheeling rear bearing Free wheeling rear bearing snap ring Free wheeling rear bearing retainer bolt FREE WHEELING MAIN SHAFT ASSEMBLY Free wheeling main shaft Free wheeling main shaft nut Free wheeling main shaft washer Free wheeling transmission main shaft nut Free wheeling transmission main shaft washer Free wheeling transmission main shaft bearing shim Free wheeling main shaft packing Free wheeling main shaft packing retainer Free wheeling main shaft packing retainer washer Free wheeling speedometer pinion bushing Free wheeling drive sleeve Free wheeling drive sleeve positive drive gear Free wheeling drive sleeve positive drive gear poppet ring Free wheeling drive roller spider Free wheeling drive roller retainer spring Free wheeling drive roller Free wheeling drive roller retaining washer /"-x-5/" /"-x-5/" with / shoulder /"-x-l/ /"-xl" 5/"-x9/" castle * *
ESSEX SUPER-SIX PARTS LIST FREE WHEELING Continued 5 7 9 0 5 5 5 BT 7 BT 7 BT 7 BT 77 BT 7 BT BT BT 970 BT 77 BT BT 59 BT 9 BT 90 BT 777 BT 70 BO BT 79 BT 779 BT 797 BT 707 BT BT 7 BT BT 9 BT 0 BT 5 BT Free wheeling drive roller shoe Free wheeling drive roller spider cap Free wheeling drive roller retaining snap ring FREE WHEELING HOUSING ASSEMBLY Free wheeling housing plug Free wheeling reverse shaft plunger FREE WHEELING CONTROL LEVER ASSEMBLY Free wheeling control lever ball Free wheeling control lever ball (Special Sedan) Free wheeling control lever fulcrum pin Free wheeling control lever fulcrum pin retainer Free wheeling control lever oil seal Free wheeling control lever oil seal cap Free wheeling control lever locating pin spring bracket Free wheeling control lever locating pin spring tapping plate Free wheeling control lever locating pin spring screw /"-0x5/" Free wheeling control lever locating pin spring Free wheeling control lever locating pin Free wheeling control lever locating pin spring reinforcement Free wheeling control lever locating pin spring screw /"-0x5/" FREE WHEELING MODULATOR ASSEMBLY Free wheeling speedometer gear 5-/0 to Free wheeling speedometer pinion 5-/0 to Free wheeling speedometer gear 5-/0 to Free wheeling speedometer pinion 5-/0 to Free wheeling speedometer gear 5.9 to Free wheeling speedometer pinion 5.9 to PROPELLER SHAFT AND UNIVERSAL JOINTS PROPELLER SHAFT AND UNIVERSAL JOINTS 5 7 CZ 5 CZ 9 CZ CZ 7 CZ BZ 55 BZ BZ 5 BZ 05 BZ 700 BZ 700 BZ 5575 BZ 57 BZ 57 BZ 575 PROPELLER SHAFT ASSEMBLY (less flanges) (cars 7 to 95) PROPELLER SHAFT ASSEMBLY (less flanges) (cars 957 up) PROPELLER SHAFT ASSEMBLY (less flanges) (7-Pass. Sedan) PROPELLER SHAFT ASSEMBLY (less flanges) (free wheeling) PROPELLER SHAFT ASSEMBLY (less flanges) (free wheeling) PROPELLER SHAFT FRONT END ASSEMBLY (cars 7 to 95) PROPELLER SHAFT FRONT END ASSEMBLY (cars 957 up) Propeller shaft front end yoke (cars 7 to 55) Propeller shaft front end yoke (cars 55 up) Propeller shaft bolt Propeller shaft bolt nut Propeller shaft bolt nut lock Propeller shaft front yoke dust cap Propeller shaft front yoke dust cap washer Propeller shaft front yoke dust cap washer retainer /"-x7/" /"-x7/"
ESSEX SUPER-SIX PARTS LIST PROPELLER SHAFT AND UNIVERSAL JOINTS Continued 9 0 0 5 7 9 0 BZ 9 BZ 09 BZ 59 BZ 599 BZ 977 BZ BZ 0 BZ 05 BZ 09 BZ 7059 BZ 5 BZ 55 BZ 5 BZ 559 BZ 0 BZ 079 BZ 075 BZ 5 BZ 05 BZ 055 PROPELLER SHAFT AND REAR JOINT ASSEMBLY (cars 7 to 95) PROPELLER SHAFT AND REAR JOINT ASSEMBLY (0000 to 00) (7-pass.) PROPELLER SHAFT AND REAR JOINT ASSEMBLY (cars 957 up) PROPELLER SHAFT AND REAR JOINT ASSEMBLY (cars 005 up) (7-pass.) Propeller shaft filler plug Propeller shaft flange yoke Propeller shaft inner casing (cars 7 to 55) Propeller shaft inner casing (cars 55 up) Propeller shaft inner casing gasket Propeller shaft inner casing screw 0-x/" PROPELLER SHAFT OUTER CASING ASSEMBLY (front end) PROPELLER SHAFT OUTER CASING ASSEMBLY (rear end) Propeller shaft outer casing spring (front end) Propeller shaft outer casing spring (rear end) Propeller shaft outer casing packing Propeller shaft journal Propeller shaft journal bushing Propeller shaft journal bushing ring Propeller shaft baffle cup Propeller shaft baffle cup spring STEERING GEAR 5 7 9 0 5 7 9 0 5 CZ 550 CZ 570 BZ 57 BZ BZ 577 BZ BZ BZ 59 BZ 0 BZ 97 BZ 707 BZ 579 CZ 570 BZ 570 BZ 57 BZ 0 BZ BZ 9 BZ 7059 BZ 9 BZ 9 CZ 57 BZ 09 BZ 7055 BZ 705 BZ 07 BY 70 BZ 7090 BZ 709 BZ 570 BZ 59 BZ 5 BY BZ 70 BZ 5995 BZ BZ STEERING GEAR ASSEMBLY COMPLETE STEERING GEAR ASSEMBLY (less jacket tube and controls) Ball arm (cars 7 to 75) Ball arm (cars 7 up) Shaft (cars 7 to 75) Shaft (cars 7 up) Shaft nut Shaft washer Shaft bushing Shaft adjusting screw Shaft adjusting screw nut Shaft thrust washer Main column tube Worm Worm adjusting nut Worm adjusting nut screw Worm adjusting nut screw nut WORM BEARING ASSEMBLY Lower control bracket bolt /"-0x/" Lower housing washer Lower housing oil seal CONTROL ASSEMBLY Jacket tube clamp Jacket tube clamp bolt 5/"-x" Jacket tube clamp bolt nut 5/"-x7/" FRICTION BAND ASSEMBLY Friction band reinforcement Friction band clamp bolt -x/" Friction band clamp bolt nut -x/" STEERING GEAR HOUSING ASSEMBLY STEERING GEAR HOUSING ASSEMBLY Steering gear housing gasket Grease plug Clamp bolt /"-x-5/" Steering gear housing clamp bolt Clamp bolt nut /"-x/" Adjusting stud I
STEERING GEAR
ESSEX SUPER-SIX PARTS LIST 5 STEERING GEAR Continued 7 9 0 5 7 9 0 5 7 9 9 50 5 5 5 5 55 5 57 BZ BZ 0 BZ 0 BZ 570 BZ 57 BZ 05 BZ BZ 57 CZ 5775 BZ 00 BZ 0 CZ 5500 BZ 705 BZ 7050 BZ 50 BZ 709 BZ 597 BZ 00 BZ 70 BM 7 BZ 0 BZ 57 BZ 575 BZ 70 BM 7 BZ 05 CZ 57 BZ 0 BZ 57 BZ 570 CZ 57 BZ 05 BZ 55 BZ 577 BZ 09 BZ 5 BO BO 0 Adjusting stud nut Eccentric adjusting sleeve Eccentric adjusting sleeve lock ring Eccentric rivet STEERING GEAR HOUSING COVER ASSEMBLY Stud Stud nut Gasket STEERING GEAR JACKET TUBE ASSEMBLY Bushing Oil hole cover Steering wheel Steering wheel key Steering wheel key nut Steering gear frame bracket bolt 7/"-0x-/" Steering gear frame bracket bolt nut 7/"-0 Steering gear lower control bracket LOWER THROTTLE LEVER ASSEMBLY Clamp bolt /"-0x" Clamp bolt nut /"-0x/" Lower throttle lever stop plate LOWER SWITCH LEVER ASSEMBLY Lower switch lever clamp washer Lower switch lever clamp screw "-0x" Lower switch lever clamp screw nut /"-0x/" Lower control bracket spacer Throttle tube Throttle silencer lower Throttle silencer upper Switch lever Switch tube Switch tube silencer Switch lever driving plate screw Horn button Horn button spring HORN WIRE ASSEMBLY Terminal (horn end) Terminal (button end) 5 59 0 CZ 550 CZ 57 BZ 595 BZ 5995 BZ 5959 BZ BZ 57 BZ 57 BZ 7 CZ 579 BZ 579 CZ 5777 CZ 577 CZ 57 BZ 57 STEERING GEAR-R.H. DRIVE STEERING GEAR ASSEMBLY COMPLETE STEERING GEAR ASSEMBLY (less jacket tube and controls) STEERING GEAR HOUSING ASSEMBLY Steering gear housing clamp bolt Steering gear ball arm (cars 7 to 7) Steering gear ball arm (cars 7 up) STEERING GEAR HOUSING COVER ASSEMBLY Steering gear shaft (cars 7 to 7) Steering gear shaft (cars 7 up) Steering gear main column tube Steering gear worm STEERING GEAR JACKET TUBE ASSEMBLY STEERING GEAR CONTROL ASSEMBLY Throttle tube HORN WIRE ASSEMBLY CZ 50 CZ 555 BZ 59 BZ 709 BZ 05 BZ 05 BZ 05 BZ 570 DRAG LINK ASSEMBLY Drag link Spring rear Spring retainer rear Ball seat front Ball seat spring front Plug Socket DRAG LINK
BRAKE CONTROL
ESSEX SUPER-SIX PARTS LIST 7 DRAG LINK Continued.. BZ 57 BZ 0 BZ BZ 59 BZ 59 BZ 700 BZ 97 BZ 9 BZ 50 Socket clamp Socket clamp bolt Socket clamp bolt nut Dust cover inner Dust cover outer Dust cover bolt Dust cover bolt nut BOOT ASSEMBLY FRONT Ball seat rear DRAG LINK R.H. DRIVE (All Drag Link s Not Shown Here Are Same as for Standard Left Hand Drive) CZ 500 CZ 55 BZ 57 BZ 7 DRAG LINK ASSEMBLY Drag link Socket BOOT ASSEMBLY FRONT BRAKE CONTROL L.H. DRIVE BZ 509 BZ 57 BZ 0 BZ 59 BZ 0 BZ 9 BM 0 BZ 05 BZ BZ 5 BZ 7 BZ 0 BZ 05 BZ 0 BZ 5 BZ 5 BO BZ BZ 55 BZ 0 BZ 55 BZ 0 BZ 75 BM 0 BZ 07 BZ 075 BZ 07 BZ 07 BZ 700 BZ BZ 7 BZ 59 BY 05 BZ 50 CZ 5 BZ 5777 BO BZ 55 BZ 5 BZ 700 BZ BZ 55 BZ BZ 57 BZ 5 BZ BZ 5 Brake cross shaft BRAKE CROSS SHAFT CENTER BEARING ASSEMBLY Roller Roller rivet (center bearing) Roller rivet (frame) Brake cross shaft center bearing bolt Brake cross shaft center bearing bolt nut /"-x/" Brake cross shaft eccentric Brake cross shaft eccentric nut Brake cross shaft end lever Brake cross shaft end lever pin Brake cross shaft end lever key Brake cross shaft end lever return spring Brake cross shaft end lever return spring clip Brake pedal rod Brake pedal rod play link Brake pedal rod play link nut 5/"-x7/" Brake pedal rod clevis pin Brake pedal rod return spring Brake pedal rod return spring clip Brake pedal rod lever Brake pedal rod lever key Brake pedal rod lever clamp bolt Brake pedal rod lever clamp bolt nut /"-x/" Rear brake rod front L.H. Rear brake rod front L.H. (Family Sedan only) Rear brake rod front R.H. Rear brake rod front R.H. (Family Sedan only) Rear brake rod (front) clevis pin Rear brake rod (front) clevis pin Rear brake rod idler lever outer Rear brake rod idler lever inner Rear brake rod idler lever pin Rear brake rod ldler lever pin spring End brake rod End brake rod clevis 5/" End brake rod clevis nut 5/"-x7/" End brake rod spring End brake rod spring retainer End brake rod clevis pin (rear rod) End brake rod clevis pin (front rod) Front brake rod rear Front brake rod (rear) clevis pin Front brake rod idler lever Front brake rod idler lever pivot Front brake rod idler lever pivot nut Front brake rod idler lever spring
ESSEX SUPER-SIX PARTS LIST HAND BRAKE LEVER ASSEMBLY BRAKE CONTROL-R.H. DRIVE BZ 5 BZ 5 BZ 07 BZ 07 BZ 07 BZ 075 BRAKE CROSS SHAFT CENTER BEARING ASSEMBLY Pedal rod Rear brake rod front L.H.. Rear brake rod front L.H.. (Family Sedan only) Rear brake rod front R.H. Rear brake rod front R.H. (Family Sedan only) 5 7 9 0 5 7 BS 0 BS BS 05 BS 0 BO BS 5 BR 0 BM 0 BS 07 BZ 0 BZ BS BS BS BS 75 BS 7 BS BM 0 BZ BS 9 BS 0 BS BS 7095 HAND BRAKE LEVER ASSEMBLY COMPLETE HAND BRAKE Bushing Hand brake lever return spring Hand brake lever return spring stud Hand brake lever return spring stud nut Hand brake lever bracket Hand brake lever bracket bolt Hand brake lever bracket bolt nut Hand brake lever to cross shaft lever link Hand brake lever to cross shaft link clevis pin washer Hand brake lever clevis pin 5/" Hand brake lever latch rod Hand brake lever latch grip Hand brake lever latch grip screw Hand brake lever latch grip screw nut Hand brake lever latch inside Hand brake lever latch outside Hand brake lever latch clevis pin short Hand brake lever latch clevis pin long Hand brake lever latch spring Hand brake lever latch spring hook Hand brake lever shaft Hand brake lever shaft pin 5/"-x7/" /"-xl/" /"-x/" 0-x/" 0-x/" /"x59/" 5/"x/"
ESSEX SUPER-SIX PARTS LIST 9 HAND BRAKE Continued 9 0 BS BS 57 BZ 705 BM 0 BS 9 BS 0 BS BS Hand brake lever shaft spring Hand brake lever ratchet Hand brake lever ratchet bolt Hand brake lever ratchet bolt nut Hand brake lever ratchet spacer Hand brake lever ratchet frame spacer short Hand brake lever ratchet frame spacer long Hand brake lever latch rod /"-x/" /"-x/" HAND BRAKE (SEVEN-PASSENGER SEDAN) 5 7 9 0 BS 5 BS BS BS BS 7 BS BS 9 BS 0 BS 05 BS 0 BO BS 5 BR 0 BM 0 BS 07 BZ 0 BZ BS 5 BS 7095 BS BS 57 BZ 705 BM 0 BS 5 BS 59 HAND BRAKE LEVER ASSEMBLY COMPLETE Bushing Hand brake lever pawl Hand brake lever pawl pin Hand brake lever pawl rod Hand brake lever pawl rod spring Hand brake lever pawl rod button Hand brake lever pawl rod button pin Hand brake lever return spring Hand brake lever return spring stud Hand brake lever return spring stud nut Hand brake lever bracket Hand brake lever bracket bolt Hand brake lever bracket bolt nut Hand brake lever to cross shaft lever link Hand brake lever to cross shaft link clevis pin washer Hand brake lever clevis pin 5/" Hand brake lever shaft Hand brake lever shaft pin Hand brake lever shaft spring Hand brake lever ratchet Hand brake lever ratchet bolt Hand brake lever ratchet bolt nut Hand brake lever ratchet frame spacer short Hand brake lever ratchet frame spacer long 5/"-x7/" /"-x-/" /"-x/" /"-x-/" /"-x/" I HAND BRAKE R.H. DRIVE BS 55 BS BS BS BS 7 BS BS 9 BS 0 BS 05 BS 0 BO BS 5 BR 0 BM 0 BS 07 BZ 0 BZ BS 5 BS 7095 BS BS 57 BZ 705 BM 0 BS 5 BS 59 HAND BRAKE LEVER ASSEMBLY COMPLETE Bushing Hand brake lever pawl Hand brake lever pawl pin Hand brake lever pawl rod Hand brake lever pawl rod spring Hand brake lever pawl rod button Hand brake lever pawl rod button pin Hand brake lever return spring Hand brake lever return spring stud Hand brake lever return spring stud nut Hand brake lever bracket Hand brake lever bracket bolt Hand brake lever bracket bolt nut Hand brake lever to cross shaft lever link Hand brake lever to cross shaft link clevis pin washer Hand brake lever clevis pin 5/" Hand brake lever shaft Hand brake lever shaft pin Hand brake lever shaft spring Hand brake lever ratchet Hand brake lever ratchet bolt Hand brake lever ratchet bolt nut Hand brake lever ratchet frame spacer short Hand brake lever ratchet frame spacer long 5/"-xl7/" /"-x-/" /"-x/" /"-x-/" /"-x/"
THROTTLE AND LIGHT CONTROL R.H. DRIVE THROTTLE AND LIGHT CONTROL L.H.. DRIVE