MATERIAL HANDLER Operating Weight: 76,49 lbs (8, kg) SAE Net Horsepower: with fan pump 49 HP (69 kw) without fan pump HP (97 kw) Swing Torque: 96,6 lbf-ft. (66. kn m) Engine Isuzu AH-6WGXYSS- Tier turbocharged diesel engine with electronic fuel control, 6-cylinder, water-cooled, EGR with cooler, air-to-air intercooler, fuel cooler, auto idle-start, neutral safety start, glow plugs, auto warm-up, EPF engine protection, dual stage fuel filtration, remote oil filter, green plug oil drain. SAE net horsepower... HP (97 kw) @,8 rpm Displacement....7 L Maximum torque...,66 lbf-ft (, N-m) @, rpm Starter... 4V-7.kW Alternator... amp Battery... amp hours Cab and Controls Pressurized cab with climate control a/c and heat with defroster, LCD monitor, illuminated soft-touch switches, low-effort controls pre-wired for auxiliary hydraulics, control pattern changer, sliding LEXAN MARGARD windows, safety glass front window with automatic locking system and vandal cover, intermittent windshield wiper with washer, emergency rear window exit, polycarbonate roof hatch with sunshade, shockless cab suspension with four fluid mountings, KAB reclining air-suspension seat, sliding 4-position tilting control consoles, AM/FM radio, digital clock, dome light, seat belt, coat hook, cup holder, storage compartments, floor mat, footrests, ashtray, 4-volt cigarette lighter, -volt outlet, travel alarm, handrail, mirrors. Four selectable working modes, anti-theft password protection system, on-board self-diagnostic system with memory, autoidling system, one-touch decelerator, auto power boost, gate lock safety shutoff. A/C output...8, BTU/hr Heater output..., BTU/hr Sound level (inside cab)... 69. db(a) Sound level (exterior)....8 db(a) Hydraulic System Open-center system, two variable displacement axial piston pumps and one gear pump for pilot controls, main control valve with one 4-spool valve and one -spool valve with auxiliary spool. Hydraulic Pumps Maximum flow... x gpm ( x l/min) Pilot pump maximum flow... 7. gpm (7 l/min) Relief Valve Settings Boom / Arm... 4, psi (4 bar) in Power-Boost Mode... 4,98 psi (4 bar) Swing circuit...,8 psi (6 bar) Travel circuit... 4,98 psi (4 bar) Hydraulic Cylinders Young -piece number of cylinders - bore x rod x stroke. Boom... - 8. x. x 68 ( mm x 7 mm x 77 mm) Arm... - 9. x 6. x 7 (9 mm x mm x 89 mm) Young -piece 68 number of cylinders bore x rod x stroke. Boom... - 8. x. x 68 ( mm x 7 mm x 77 mm) Arm... - 8. x 6. x 7 (6 mm x mm x 6 mm) Hydraulic Oil Filtration Return filter... 6 micron Pilot filter... 8 micron Suction screen... micron Swing Planetary reduction powered by axial piston motor. Internal ring gear with grease cavity for swing pinion. Swing bearing is single-row shear type ball bearing. Mechanical disc swing brake. Auto power swing. Swing speed... 6.4 rpm Tail swing... 4 (4. m) Swing torque... 96,6 lbf-ft. (66. kn m) Undercarriage X Pattern carbody with sealed and strutted track chain, sealed rollers and idlers, two-speed independent hydrostatic travel with compact planetary final drive, disc type brakes, adjustable track tension, swivel guard. Carrier rollers... per side Track rollers... 9 per side Track link pitch....4 (6 mm) Shoes... per side Shoe width... 9. (7 mm) Ground pressure.... psi (.4 bar) Lubricant and Coolant Capacity Fuel tank... 8. gal. (9 liters) Hydraulic tank... 8. gal. ( liters) Hydraulic system... 9. gal. (7 liters) Final drive (per side)....6 gal. (.8 liters) Swing drive....7 gal. (. liters) Engine oil....7 gal. ( liters) Cooling system... gal. ( liters) Travel System Two-speed independent hydrostatic travel with compact axial piston motors. Hydraulic motor powered output shaft coupled to a planetary reduction unit and track sprocket. All hydraulic components mounted within the width of side frame. Automatic downshift. Spring applied, hydraulically released disc parking brake built into each motor. Each travel motor equipped with counterbalance valve to prevent overspeeding down an incline. Max. travel speed....8 -.6 mph (.9-4. km/h) Drawbar pull... 7, lbf (6 kn) Gradeability... 7% ( ) Operating Weight Working weight with 9. (7 mm) shoes, (6.76 m) -piece attachment, / tank of fuel, 6 cab riser and 4, lbs. (,996 kg) of additional counterweight... 76,49 lbs (8, kg) Working weight with 9. (7 mm) shoes, (6.76 m) -piece attachment, / tank of fuel, 6 cab riser, widened undercarriage and 4, lbs. (,996 kg) of additional counterweight... 89,9 lbs (8,87 kg) Working weight with 9. (7 mm) shoes, 68 (.7 m) -piece attachment, / tank of fuel, 6 cab riser, widened undercarriage and 4, lbs. (,996 kg) of additional counterweight... 9,7 lbs (87,4 kg)
Working Ranges 7 Ft. 6 Ft. 6 6 6 6 6 - - - - - - - - - Ft. - - Ft. 8 X Material Handler with a Young ' (6.76 m) -piece attachment 8 X Material Handler with a Young 68' (.7 m) -piece attachment Transportation Specifications Boom (.9 m) 68 Boom (6.6 m) 4 (4.8 m) (.74 m) (4. m) (.47 m) (.74 m) (6.7 m) (6. m) 4 (4.6 m) (.96 m) (.96 m) 8 (.4 m) (.9 m) 4 ( m) (89 mm) 9 (.88 m) (. m) Riser 8 (.44 m) Riser 74 (.88 m) Riser 6 8 (.7 m) (6.6 m) 4 6 (7.46 m) ( mm) 9. (7 mm) 9 (.8 m) std. 4 (. m) extended 7 (.84 m) std. 4 8 (4.47 m) extended
Transportation Specifications Main Structure 9 (6.6 m) (6. m) 7 (.44 m) Weight with (76 mm) gauge widener, 74 (.88 m) cab riser, No Gen Set... 7, lbs. ( 899 kg) with Ohio Gen Set... 7, 67 lbs. ( kg) (. m) 9 (. m) 9 (. m) (. m) Riser with (76 mm) Gauge Widener 8 (.44 m) Riser with (76 mm) Gauge Widener 74 (.88 m) Riser with (76 mm) Gauge Widener Undercarriage Counterweight 9.8 ( mm) 9 (6.6 m) (.47 m) (88 mm) 4 7 (.9 m) 6 8 (.7 m) Shoe Width Weight (per side) 9. (7 mm)... 8,66 lbs. ( kg).4 (9 mm)... 9,64 lbs. ( 44 kg) Weight... 7, 6 lbs. ( 9 kg) -piece (6.76 m) Young attachment Length Weight 8, 6 bs. Boom with arm cylinder (9.8 m) (8 67 kg) Arm assembly Boom cylinder 6 (8. m) (.7 m) 7, 76 lbs. ( 46 kg),49 lbs. (677 kg) Boom with arm cylinder Arm assembly -piece 68 (.7 m) Young attachment Length Weight 8 4, 8 bs. Boom with arm cylinder (.68 m) (9 8 kg) Arm assembly Boom cylinder (9.7 m) (.7 m) 8, 66 lbs. ( 74 kg),49 lbs. (677 kg) Boom cylinder
Lifting Capacities Two-piece (6.76 m) Young Attachment with 4, lbs. ( 996 kg) Additional Counterweight Radius of Load - (6.m) - (7.6m) - (9.4mm) - (.67m) - (.9m) - (.7m) - (.4m) - (6.76m) End Side End Side End Side End Side End Side End Side End Side End Side + - lbs,8*,8* (6.76m) kg 9 888* 9 888* + - lbs 7,* 7,*,9*,9* (.4m) kg 9* 9* 9 94* 9 94* + - lbs 6,* 6,*,*,* (.7m) kg 794* 794* 9 99* 9 99* + - lbs 8,* 8,* 4,7* 4,7* 7,* 7,* (.9m) kg 746* 746* 4* 4* 7 89* 7 89* + - lbs 9,9* 9,9* 7,* 7,*,*, (.66m) kg 6* 6* 49* 49* 6* 6 + - lbs,8*,8* 9,* 8,,7*,9 7,7* 7,7* (9.4m) kg 4 44* 4 44* 6* 7 68* 87 8 9* 8 9* + - lbs 4,* 4,*,*,* 9,9* 7,6 7,*,7,6* 8,8 (7.6m) kg 8* 8* 4 969* 4 969* 6* 9 8* 97 9 798* 8 8 + - lbs 6,* 6,* 8,* 8,* 4,*,,* 7, 7,*, 4,* 8,6 (6.m) kg 6 466* 6 466* 7 464* 7 464* 468* 8* 47 49* * 8 47 + - lbs 4,* 4,* 47,6* 47,6*,*,*,*,,* 6, 7,6*,8 4,* 8, 4,* 4,* (4.7m) kg 9 64* 9 64* 9* 9* 8 * 8 * 967* 4 66 4 7* 884 9* 9 888 * 8 6 44* 6 44* + - lbs 6,6* 6,6*,6*,6* 4,* 8,9 6,*,,*, 7,6*, 4,* 8,,7*, (.m) kg 8 849* 8 849* 9* 9* 9 97* 7 6 6 7* 4 6 4 88* 9* 9 66 9* 8 6 7 * 6 98 + - lbs 66,8* 66,,* 48, 4,* 7, 6,* 9,9,* 4,7 7,*,8,* 7,7,6*, (.m) kg * 74 84* 88 9 * 6 874 6 6* 6 4 88* 4 8* 9 4 64* 8 9 7 76* 6 9 Ground lbs 8,9* 8,9*,6* 46, 4,*,8 6,* 8,9,9* 4, 6,*,,* 7, Line kg 7 6* 7 6* 89* 866 9 * 6 9 6 * 9 4 6* 886 * 9 8 7* 7 89 - - lbs,*,*,7* 44, 4,7* 4,7 4,9* 8, 9,*, 4,8*,,* 7, (.m) kg 4 66* 4 66* 998* 8 8 9* 7 8* 79 8* 66 49* 9 7 9 7* 7 847 - - lbs,7*,7* 46,7* 4,7 8,7* 4,,* 7,7 7,*,,* 9,8 6,* 6,* (.m) kg 4 8* 4 8* 8* 9 8 7 4* 468 4 697* 6 9* 4 * 8 98 7 94 7 94 - - lbs,9*,9*,6*,6* 4,*,8 8,* 7,,*, 7,8* 7,8* (4.7m) kg 6 84* 6 84* 8 46* 8 46* 4* 87* 474 4* 478 8 74* 8 74* Two-piece (6.76 m) Young Attachment with widened undercarriage and 4, lbs. ( 996 kg) Additional Counterweight Radius of Load - (6.m) - (7.6m) - (9.4mm) - (.67m) - (.9m) - (.7m) - (.4m) - (6.76m) End Side End Side End Side End Side End Side End Side End Side End Side + - lbs,*,* (6.76m) kg 6* 6* + - lbs 7,* 7,*,*,* (.4m) kg 8* 8* * * + - lbs 6,* 6,*,9*,9* (.7m) kg 884* 884* 9 48* 9 48* + - lbs 8,* 8,* 4,9* 4,9* 7,9* 7,9* (.9m) kg 87* 87* 94* 94* 8 9* 8 9* + - lbs,*,* 7,6* 7,6*,7*,7* (.66m) kg 68* 68* 9* 9* 97* 97* + - lbs,*,*,9*,9* 9,* 9,*,9*,9* 8,* 8,* (9.4m) kg 4 * 4 * 4 47* 4 47* 8* 8* 748* 748* 8 6* 8 6* + - lbs 4,* 4,*,*,* 9,9* 9,9* 7,* 7,*,8*,8* (7.6m) kg 649* 649* 4* 4* 6* 6* 8* 8* 9 888* 9 888* + - lbs 6,7* 6,7* 8,6* 8,6* 4,* 4,*,*,* 7,* 7,* 4,6* 4,6* (6.m) kg 6 647* 6 647* 7 9* 7 9* 468* 468* 8* 8* 474* 474* 8* 8* + - lbs,*,* 47,8* 47,8*,6*,6*,*,*,*,* 7,6* 7,6* 4,* 4, 4,* 4,* (4.7m) kg 7* 7* 68* 68* 8 46* 8 46* 966* 966* 4 7* 4 7* 9* 9* * 67 6 486* 6 486* + - lbs 6,9* 6,9*,8*,8* 4,* 4,* 6,* 6,*,*,* 7,6* 7,6* 4,* 4,*,8*,8* (.m) kg 8 98* 8 98* 4* 4* 9 4* 9 4* 6 7* 6 7* 4 88* 4 88* 9* 9* 9* 9* 7 67* 7 67* + - lbs 66,9* 66,9*,*,* 4,* 4,* 6,* 6,*,*,* 7,* 7,*,*,*,*,* (.m) kg * * 84* 84* 9 9* 9 9* 6 6* 6 6* 4 88* 4 88* 8* 8* 64* 64* 7 * 7 * Ground lbs 8,* 8,*,*,* 4,* 4,* 6,* 6,*,9*,9* 6,* 6,*,*,* Line kg 7 7* 7 7* 84* 84* 9 4* 9 4* 6 * 6 * 4 6* 4 6* 97* 97* 9 979* 9 979* - - lbs,*,*,*,* 4,6* 4,6* 4,8* 4,8* 9,* 9,* 4,7* 4,7* 9,8* 9,8* (.m) kg 4 6* 4 6* 96* 96* 8 869* 8 869* 78* 78* 6* 6* 4* 4* 8 98* 8 98* - - lbs,8*,8* 46,* 46,* 8,* 8,*,*,* 6,9* 6,9*,9*,9* 6,* 6,* (.m) kg 4 878* 4 878* 47* 47* 7 46* 7 46* 4 66* 4 66* * * 9 94* 9 94* 7 7* 7 7* - - lbs 6,* 6,*,*,*,6*,6* 8,* 8,*,8*,8* 7,* 7,* (4.7m) kg 6 7* 6 7* 8 44* 8 44* 4* 4* 7* 7* 4* 4* 7 89* 7 89*
Lifting Capacities Two-piece 68 (.7 m) Young Attachment with widened undercarriage and 4, lbs. ( 996 kg) Additional Counterweight Radius of Load - - - - - - - - 6-6 - (6. m) (7.6 m) (9.4 m) (.67 m) (.9 m) (.7 m) (.4 m) (6.76 m) (8.9 m) (9.8 m) End Side End Side End Side End Side End Side End Side End Side End Side End Side End Side +6 - lbs,8*,8 (9.8 m) kg 9 888* 9 888* +6 - lbs,*,*,*,* (8.9 m) kg 9 77* 9 77* 6 84* 6 84* + - lbs,8*,8*,6*,6* 4,* 4,* (6.76 m) kg 796* 796* 9 44* 9 44* 6 * 6 * + - lbs,*,*,*,* 9,* 9,* (.4 m) kg 8* 8* 4* 4* 8 74* 8 74* + - lbs,9*,9*,9*,9*,*,* 7,* 7,* (.7 m) kg 748* 748* 84* 84* 9 979* 9 979* 7 8* 7 8* + - lbs 6,* 6,*,9*,9*,*,*,*,*,*,* (.9 m) kg 79* 79* 84* 84* 9 979* 9 979* 9 8* 9 8* 987* 987* + - lbs 6,* 6,* 4,* 4,*,*,*,*,* 7,* 7,* (.66 m) kg 97* 97* 9* 9* 4* 4* 9 6* 9 6* 7 8* 7 8* + - lbs 9,7* 9,7* 6,8* 6,8* 4,* 4,*,*,*,*,* 8,* 8,* (9.4 m) kg 47* 47* 6* 6* * * 7* 7* 9 8* 9 8* 8 46* 8 46* + - lbs,7*,7* 7,* 7,* 4,7* 4,7*,*,*,*,* 8,* 8,* 4,* 4,* (7.6 m) kg 9* 9* 48* 48* 4* 4* 6* 6* 9 8* 9 8* 8 46* 8 46* 6 96* 6 96* + - lbs,*,*,6*,6*,8*,8* 8,* 8,*,*,*,6*,6*,*,* 8,* 8,* 6,*,7 (6. m) kg 4 * 4 * 6 48* 6 48* 4 44* 4 44* 746* 746* 8* 8* * * 9 8* 9 8* 8 * 8 * 7 7* 7 + - lbs 4,* 4,*,7*,7* 8,* 8,*,8*,8* 8,6* 8,6*,*,*,7*,7*,*,* 8,* 7,9*,7*,6 (4.7 m) kg 9 78* 9 78* 79* 79* 7 7* 7 7* 4 878* 4 878* 97* 97* * * 97* 97* 9 8* 9 8* 8 * 8 9* 7 * 7 76 + - lbs 6,9* 6,9* 47,9* 47,9* 9,* 9,*,*,* 9,* 9,*,*,*,6*,6*,*,* 7,7* 7,6*,*,* (. m) kg 7 64* 7 64* 77* 77* 7 87* 7 87* 9* 9* 4* 4* 67* 67* * * 9 7* 9 7* 8 9* 7 98* 6 89* 6 89* + - lbs,*,* 48,9* 48,9*,*,*,8*,8* 9,* 9,*,*,*,*,* 9,7* 9,7* 7,* 7,* 4,* 4,* (. m) kg 9 7* 9 7* 8* 8* 8 89* 8 89* * * * * * * 6* 6* 8 96* 8 96* 7 8* 7 8* 6 * 6 * Ground lbs 4,* 4,* 4,* 4,* 9,8* 9,8*,*,* 8,8* 8,8*,*,*,9*,9* 9,* 9,* 6,* 6,*,*,* Line kg 6 44* 6 44* 9 4* 9 4* 8 * 8 * 9* 9* 6* 6* * * 9 94* 9 94* 8 664* 8 664* 7 49* 7 49* 987* 987* - - lbs,7*,7*,6*,6* 8,6* 8,6*,6*,6* 7,9* 7,9* 4,* 4,*,*,* 8,* 8,*,*,*,*,* (. m) kg 6 4* 6 4* 88* 88* 7 9* 7 9* 4 787* 4 787* 6* 6* 977* 977* 9 * 9 * 8 * 8 * 6 89* 6 89* 6* 6* - - lbs,*,* 8,* 8,* 6,* 6,*,8*,8* 6,* 6,*,8*,8* 9,6* 9,6* 6,6* 6,6*,*,* (. m) kg 6 89* 6 89* 746* 746* 6 46* 6 46* 97* 97* 97* 97* 4* 4* 8 89* 8 89* 7 * 7 * 6 78* 6 78* - - lbs 7,* 7,* 8,6* 8,6*,9*,9* 8,* 8,* 4,* 4,*,7*,7* 7,6* 7,6* 4,* 4,*,8*,8* (4.7 m) kg 7 89* 7 89* 97* 97* 4 9* 4 9* 79* 79* 977* 977* 9 89* 9 89* 7 98* 7 98* 6 77* 6 77* 4 899* 4 899* - - lbs,*,*,6*,6* 8,* 8,* 4,6* 4,6*,*,* 7,9* 7,9* 4,8* 4,8*,*,* (6. m) kg 9 7* 9 7* 88* 88* 88* 88* 8* 8* 9 7* 9 7* 8 9* 8 9* 6 7* 6 7* 7* 7* - - lbs 9,9* 9,9* 7,* 7,* (7.6 m) kg 9 6* 9 6* 7 7* 7 7* Notes: Material Handler lifting capacities. Lifting capacities shown should not be exceeded. Weight of all lifting accessories must be deducted from the above lifting capacities.. Lifting capacities are based on machine standing on firm, uniform supporting surface. User must make allowances for job conditions such as soft or uneven ground.. Lifting capacities shown do not exceed 7% of minimum tipping loads or 87% of hydraulic capacities. Capacities marked with an asterisk (*) are limited by hydraulic capacities. 4. Least stable position is over the side.. Operator should be fully acquainted with the Operator s Manual & Operating Safety Booklet, furnished by LBX before operating the machine. 6. Capacities apply only to the machine as originally manufactured and normally equipped by LBX Company LLC. 7. Lift capacity ratings are based on SAE J97, Earthmoving Machinery - Hydraulic Excavators - Lift Capacity.
Standard Equipment KAB 8 sliding/reclining air-suspension seat with adjustable 4-inch armrests, lumbar support and retractable seat belt Safety glass front window with auto lock, windshield wiper and washer with intermittent speeds, Lexan side and rear tinted windows 4-position tilting consoles with memory position and hydraulic lock-out Auto climate control a/c and heat AM/FM stereo with mute button, horn, interior light, digital clock, hour meter, floor mat, cup holder, sun shade, storage, LH and RH rear view mirrors Travel alarm with cancel switch Vandal guarding with bolt-on FOG capability EPA Tier III Isuzu diesel engine Common rail fuel injection Turbocharger with intercooler Neutral safety start Idle start Glow plug pre-heat Auto engine warm-up Reversible cooling fan Auto idling system One-touch idle Dual remote fuel filters with water separation Double element air filter with in-cab restriction indicator Reversible fan External fuel gauge Remote, full-flow engine oil filter Green plug engine oil drain EPF Engine Protection Emergency engine stop Open-center hydraulic system Four selectable work modes including attachment mode Auto power boost Auto swing priority Pre-set auxiliary pump settings - Auxiliary valve Stackable main control valve Auxiliary pipe brackets Control levers pre-wired for auxiliary Control pattern changer Long undercarriage Sealed and lubricated track chain Two-speed with auto shift and straight travel Planetary drive Spring-applied, hydraulic release brake Hydraulic track adjust Swivel guard belly pan Track guides Vandal locks with common key 7,6 lb (, kg) counterweight with lifting eyes Hand rail Tool box Catwa ks Attachment cushion valve Arm and boom speed assistance Arm and boom regeneration Arm and boom holding valves Cylinder cushion Centralized lube bank Illuminated LCD service monitor On-board diagnostic system Anti-theft device -volt accessory outlet 7-watt work lights on boom and upper Options Tracks 9.-in (7 mm) -bar grouser.4-in (9 mm) -bar grouser 74 (.88 m), 8 (.44 m), or (. m) risers are available, manual tilt cab, includes ladder and platform -piece (6.76 m) Young attachment -piece 68 (.7 m) Young attachment Load holding valves for boom & arm cylinders Grapple rotation circuit -in (76 mm) gauge widened undercarriage 4, lbs. ( 996 kg) of additional counterweight kw Baldor generator and Hubbell controller includes volt meter and amp meter Free swing FOPS level cab guard Front guard - mesh or bars LBX Company is the proud maker of quality Link-Belt excavators and is located in Lexington, KY. www.lbxco.com Litho in USA 8/ #LBX9 LBX and Link-Belt are registered trademarks. Copyright. All rights reserved. We are constantly improving our products and therefore reserve the right to change designs and specifications.