TOP DRIVE OPERATIONS & MAINTENANCE MANUAL JULY 2007 HYBRID TECHNOLOGY UNIVERSAL LIFTING CEMENT HEAD. Det Norske Vertis Type Certificate D-2928

Similar documents
HYDRAULICS. TX420 & & lower. Hydraulic Tandem Pump Removal. 4. Remove the LH side panel (Fig. 0388).

SERVICE BULLETIN SB.DSL rev02

REPAIR PROCEDURES MANUAL

CAB TILT HYDRAULIC SYSTEM

WX980 Trailer Log Splitter Parts Manual

Drop-In Inside Blowout Preventer Valve

351GF-15. Hydrant Coupler INSTALLATION / OPERATION / MAINTENANCE MODEL

SERVICE MANUAL / PARTS LIST

MANUAL. TU Series. TU Series. Square Drive Hydraulic Torque Wrenches MODELS TU-2, TU-3, TU-5, TU-7, TU-11, TU-20, TU-27 & TU-60

MANUAL. TU Series. TU Series. Square Drive Hydraulic Torque Wrenches MODELS TU-2, TU-3, TU-5, TU-7, TU-11, TU-20, TU-27 & TU-60

Chief impulse - VHT PARTS MANUAL

M:\Logo.jpg SERVICE MANUAL / PARTS LIST APPLIANCE CLAMP SOFT TOUCH

METERING VALVE 2" STEM GUIDED

MODEL 456 SERIES HYDRA-LIFT ROTATOR

MOTION DECOUPLED HYDRAULIC DELIVERY SYSTEM (MDHDS) ASSEMBLY AND DEPLOYMENT PROCEDURES

1. Remove the parking brake assembly. 2. Remove the 4 bolts holding the yoke flange and drum. Remove the yoke flange and drive.

GH-BETTIS OPERATING & MAINTENANCE INSTRUCTIONS DISASSEMBLY & ASSEMBLY FOR THE T80X-M4-S DOUBLE ACTING SERIES HYDRAULIC ACTUATORS

Installation Manual. Model T675A Engine Brakes. For Mack 6 Cylinder, 2 valve Head ENDT-673, 675, 676 & E6 Series Engines.

SERVICE MANUAL / PARTS LIST

Convertible - Rated 3 4-Ton /2-Ton Nylon Strap Hoists Refer to any questions about the use, application, repair or testing of this hoist to:

LOW PRESSURE BALANCED VALVE DIAPHRAGM BALANCED

Maintenance Information

Return to Instruction Sheet index TCI Torqueflite Trans-Scat Kit

FRP Ball Valves INSTALLATION & MAINTENANCE MANUAL

DeZURIK " BAW AWWA BUTTERFLY VALVES WITH EPOXY-RETAINED SEAT

M:\Logo.jpg SERVICE MANUAL / PARTS LIST APPLIANCE CLAMP SOFT TOUCH

Sachs shock manual. ( ) 2 & 4 Stroke RR Enduro. ( ) RS Dual Sport

Escape Cylinder and Valve

HIGH PRESSURE CONTROL VALVE PISTON BALANCED

SERVICE MANUAL. PVR15-Manifold Series Pump. J Design Series INSTALLATION. Ordering Code PVR15 - _ RM - _ - - J

26LGC & 26LGC-L Trailer Log Splitter Parts Manual

OPERATION AND PARTS MANUAL

WX520 Trailer Log Splitter Parts Manual

Torqueflite Trans-Scat Kit

Service Manual for Hydraulic Cylinder

Maintenance Information

Fig Variable Speed Valve Parts

ASSEMBLY. Engine. Special Tool(s) Installer, Crankshaft Vibration Damper (T74P-6316-B) Special Tool(s)

Maintenance Information

WCI-20 Power-Pak Coldwork Hydraulic Power Supply Rev B

Installation Notes: #86000-R Race Series +3.5 L/T Kit

SERVICE GUIDE For WARN PULLZALL 120Vac P/N &

INSTRUCTION MANUAL AND PARTS LIST FOR SERIES 8L-630J AND 630M WARNING

Kimray reserves the right to modify or improve the designs or specifications of such products at any time without prior notice Kimray Inc.

W.S. DARLEY & CO. REPAIR SERVICE INSTRUCTIONS TYPE 2 1/2 AGE PORTABLE PUMP PUMP DISASSEMBLY FOR OVERHAUL Refer to Drawing DAC0600

STEERING SYSTEM 6 A POWER STEERING

W.S. DARLEY & CO. REPAIR SERVICE INSTRUCTIONS TYPE 1 1/2 AGE PORTABLE PUMP. PUMP DISASSEMBLY FOR OVERHAUL Refer to Drawing DAC0101/DAC0506

INSTALLATION INSTRUCTIONS South Highway 11 Westminster, SC Toll Free (888) (864) FAX (864)

Fast, Effective Blowout Protection

SERVICE INSTRUCTIONS ASSEMBLY & DISASSEMBLY T50X DOUBLE ACTING HYDRAULIC SERIES ACTUATORS

Maintenance Manual. Hydrant Coupler. F250 Series

Product Description. Product Numbers. Warning/Caution Notations. Required Tools. Wiring. Prerequisites

PARTS ORDERING INFORMATION

SW9TM, SW14.5TI, SW15TE

255 Cartridge Dual Seal

SERVICE MANUAL / PARTS LIST

MANUAL. TU Series. TU Series Hydraulic Torque Wrenches MODELS TU-2, TU-3, TU-7, TU-11, TU-20, TU-27 & TU-60 OPERATION AND MAINTENANCE

Rising Stem Instructions

Models & Inch & 4 Inch Digital Inline Pressure Control Valves SM64504

SUPPORT USA JOBS. Made in USA INSTALLATION MANUAL. 24,000 lbs GTWR, 6,000 lbs tongue

D-15/G-15 Maintenance

Product Manual. S&S V-100 Ball Valves 2 though 8 Inch Designs. Introduction: Installation:

Tidland Great Expansion Leaf Shaft

WX960 Trailer Log Splitter Parts Manual. S/N & After

FX140 & FX140R Skidding Winch Parts Manual

Installation and Service Manual Hydraulic Cab Tilt System

400 SERIES HYDRA-LIFT KARRIERS

Maintenance Manual Reduced Pressure Assembly Models 860 & 880V 2 1 /2" 10"

CP-1, CP-2, CP-2L & CPD-2 Series Overhaul

Mulching and Finishing Mowers MP and FP

SD Bendix E-10PR Retarder Control Brake Valve DESCRIPTION. OPERATION - Refer to Figure 2

JARVIS. Models USSS -1, USSS -2 and USSS -2A Pneumatic Stunners

High Lift Transmission Jack

Retractable System Operation & Maintenance Manual

HIGH PRESSURE CONTROL VALVE R2L ACTUATOR

STERNDRIVE UNIT 3 B GEAR HOUSINGS MR/ALPHA ONE/ALPHA ONE SS

Model 210HP Beadbreaker

225 CARTRIDGE DUAL SEAL

Maintenance Information

Firehawk Responder Second Stage Regulator

Tooling Assistance Center

SW9TM, SW14.5TI, SW15TE

Product Maintenance Information

Hydraulic Motors Repair Instructions

BRAKE SYSTEM Nissan 240SX DESCRIPTION BRAKE BLEEDING * PLEASE READ FIRST * BLEEDING PROCEDURES ADJUSTMENTS BRAKE PEDAL HEIGHT SPECS TABLE

Maintenance Manual. 3-Inch Internal Valve. F660 Series

DEMCO Model DM Gate Valves

TABLE OF CONTENTS. Cordless Drill & Driver / Cordless Hammer Drill & Driver. (Cordless Drill & Driver) (Cordless Hammer Drill & Driver)

Property of American Airlines

Maintenance Manual 3-INCH INTERNAL VALVE F660 SERIES

JARVIS. Model 30CL-1 AND 30CL-3 Hock Cutter and Dehorner. 30CL-1 Hock Cutter

Maintenance Information

SERVICE MANUAL 375 SERIES DIGGER MODELS

J Flow Controls Model Numbering

ENG-14, Balance Shaft Oil Seal Replacement

HFB Steering Gear Service Manual

AirHawk Gauge and Alarm Assembly

Power Steering Rack Leak from Right Side: Overhaul Procedure

Maverick American 3085 Bluff Street Boulder, CO Tel: Fax: ML7.0 SHOCK SERVICE MANUAL

PV4 - Compact Shut Off Style Pig Valve IOM - Installation, Operation & Maintenance

Transcription:

TOP DRIVE UNIVERSAL LIFTING CEMENT HEAD SUPER SUB SEA OPERATIONS & MAINTENANCE MANUAL JULY 2007 Det Norske Vertis Type Certificate D-2928 HYBRID TECHNOLOGY 1443 South Gage Street, San Bernardino, California 92408 (909) 799-8150 FAX (909) 799-5471

TABLE OF CONTENTS DNV Certification...1 Description...2 Operation...3 Service and Assembly...4-5 Seal List...6 Rated Capacities and Handling...7 Flow Areas and Diameters...8 Dimensions and Weights...9-10 Dimensional Drawings - Single & Double Dart...11-12 PARTS LIST Single Dart Body................................ Bulletin 589...13 Double Dart Body............................... Bulletin 590...14 Upper Swivel................................... Bulletin 588...15 Upper Swivel.................................. Bulletin 588e...16 Bottom Sub Sea................................. Bulletin 591...17 Lever / Lever Tattle Tale.......................... Bulletin 581...18 Lever Flag..................................... Bulletin 584...19 Single Dart Cage................................ Bulletin 592...20 Double Dart Cage............................... Bulletin 593...21 Pin Puller...................................... Bulletin 577...22 Ball Dropper.................................... Bulletin 560...23 Large Ball Dropper.............................. Bulletin 586...24 SUPER SUB SEA MANUAL TOC

DNV Certification Page 1 Rev 6/07

DESCRIPTION This Hybrid Technology Universal Top Drive Lifting Cement Head was designed from its inception for use in a top drive system. While it is relatively light and compact, it has the highest lift/pressure rating in the industry. Its optional subs add considerable versatility. The Top Drive Universal Lifting Cement Head allows the continuous and independent rotation, stroking (lifting) and high flow cementing simultaneously. Plugs can be loaded before the job and dropped by a manual or remote pin puller, without using a manifold. Slots in the Plug Cage allow the direct pressure on the bottom Plug from the flow passing the Cage to guarantee launch after the pin on the pin puller is retracted. The flow from circulation then cleans the Head from the cement. head is designed so that ample annular area exists around the largest size Cage to allow fluid flow at a reasonable velocity. The Plug cages use an adjustable length standoff/spring expeller to ensure the dart is pushed into the fluid flow for launch. A spring loaded, lever operated tattle tale releases a flag to indicate dart passage. It can be recocked without removal from the head. Both hook load and combined hook/pressure load capacities are increased by the one piece integral design. This no-weld construction contributes to the head s simplicity, compactness and lightness. The Sure Lock system has the ability to customize jobs with minimal inventory by changing the cage and the bottom sub only. The cement head uses a flow around design that keeps the plug out of the fluid path. Variable size Cages are available depending on which launching Plug is being used. The PAGE 2

OPERATION All standard operating procedures for flow rates and pump pressures apply when using the Hybrid Universal Lifting Cement Head. The Plug may be released without interruption of circulation flow. Please Note: the plug cannot freeze to the cage because it is naturally warmed by the flow of the circulation fluid temperature. Release of the Plug The Cage By cementing plug is released from the Cage by pin puller assembly. To release, unlock the safety and turn and the bonnet to the left (counterclockwise) approximately nine (9) turns. Right hand threads are used. The indicator pin will show in the bonnet at the end of the stroke. Inside the Plug cage, a captive expeller spring pushes the plug into the fluid flow. Tattle Tale The passage of the dart from its cage into the drill string is indicated by the Lever/Flag Tattle Tale. A lever extending into the head bore releases a spring-loaded arm to display a stored flag. The arm stroke is 3 in/76mm. The Tattle Tale assembly is recocked without removal from the head. To re-cock, push end of indicator arm in and hold. With a probe thru top hole, push indicator head into latch. Roll flag up, push between guard and arm. PAGE 3

SERVICE AND ASSEMBLY General Wash, dry and oil all parts. Inspect for damage. Particularly inspect O-Rings and backups for nicks or cuts. Pre-grease grooves before installing O-Rings and backups (if gland is assembled dry, something else besides grease will fill the groove). Body and Plug Cage Plug Cage is held in place in the body by the lips on the front edges of the pin dropper. The cage can only be assembled in one position. Ensure that the plug puller and plug are in their proper position. Note their names are stamped their proper port on the body. Screw into body until the front lips catch the tube of the plug cage and the shoulders make up. Set lock nuts with moderate tap of a hammer. Upper Swivel Sub Disassembly after every job is not required, if no leaks were observed from the bleed holes during the previous job. Wash circular section thoroughly. Grease each fitting until grease appears at opposite bleed hole. Rotate several times and lightly regrease. Use finger to plug bleed hole while lightly regreasing to force grease through bearing and through seal. Be sure to grease O-Ring land above Sure-Lock. If leaks were observed during operation, swivel must be disassembled for seal replacement and to clean bearings of possible contamination. Be sure to install wiper ring on body before installing the flow ring. The split (2 piece) keeper ring is used on the bottom side of the flow ring. Reaction plate #8 may be assembled to top or bottom or swivel in any convenient position. On assembly, be sure seal lips face each other. Grooves and shoulder have been angled to allow easy assembly. However, on disassembly it is easy for the lower seal lip to catch the upper lock ring groove. Remove the upper bearing and cover the groove with tape or a metal shim to make sliding the seal easy. Install 1502 adapter with lock nut loose. Set the lock with hammer and chisel, medium tight. PAGE 4

Pin Puller Disassembly not required unless bonnet is stiff to turn or seals leak. 1. Retract Screw Pin #21 2. Grease 3. Extend 4. Grease lightly Sure Lock Body Adapter Lube O-ring and land, be sure camlocks are turned flush, and assemble. When box is fully down over pin Sure Lock, rotate 60 to the right. Secure the Sure Lock by turning the 3 camlocks one half turn to the right (clockwise) with a 5/16 allen wrench, as pictured below. Lever Tattle Tale Disassembly not required unless lever is stiff to operate or seals leak. Unlocked Locked PAGE 5

SEAL LIST Swivel Upper Sub and Lower Sub #5 34227 O-Ring and Backup...70 shore A Nitrile 568-227 and Nitrile 226 #12 62223 Wiper Ring...D9000 #13 62219 Retainer Ring...Smalley WS900 #14 62212 Bearing...Kaydon DF 090-CPO #15 62262 Backup Ring...Teflon MS 28774-447 #16 62221 Seal...Poly Pack 3750 9000 Upper Sub Pin Puller 34441 O-Ring...70 shore Nitrile 441 37440 Backup Ring...Nitrile 440 #8 18175 Bearing...KDD 205 #15 37325 Backup Ring...Nitrile 325 #16 34325 O-Ring...90 Shore A Nitrile 368-325 #17 37226 Backup Ring...Nitrile 226 #18 34227 O-Ring...70 shore A Nitrile 368-227 #19 18164 Wiper...CR 14810 Lever/Flag Tattle Tale (Bulletin 627) #12 37223 Backup Ring...Nitrile 226 #13 34224 O-Ring...70 Shore A Nitrile #14 37218 Backup Ring...Nitrile 218 #15 33218 O-Ring...70 Shore A Nitrile 568-218 Note: Seal material chemically compatible to N674-70 and N922-90 and PO642-70 PAGE 6

RATED CAPACITIES AND HANDLING (6 5/8 SIZE) Hook Load Lifting Capacity *1,2 Simultaneous Hook Load Lift & Pressure Working Pressure 10,000 PSI TEST Hydrostatic: 15,000 PSI Rated Capacities of Hook Load & Pressure - S.F. = 1.28 Working Pressure Pounds Load mt Lift 10,000...1,102,300...500 9,000...1,147,969...521 8,000...1,193,633...541 7,000...1,239,296...562 6,000...1,284,960...583 5,000...1,330,623...603 4,000...1,376,287...624 3,000...1,421,950...645 2,000...1,467,614...665 1,000...1,513,277...686-0-...1,558,941...707 Torque thru Sure Lock *3 Right hand rotation 70,000 Ft/lb = 11,300 Nm Left hand rotation 70,000 Ft/lb = 11,300 Nm CAUTION: Do not break tool joint thru head. Swivel Rotation Max speed 30 rpm Reaction plate must be secured to Rig to prevent twisting of cement lines. Minimum Operating Temperature 32 F / 0 C Handling Hoist Rings Hoist Rings on Body rated at 5,000 lbs. each. Hoist Rings on Lower Sub rated at 2,500 lbs each. Note #1: Head has a safety factor of 1.27 to 1 at test. Note #2: Actual lift capacity of tool is limited by the actual joint thread used. PAGE 7

FLOW AREAS AND DIAMETERS (6 5/8 BODY SIZE) Upper Sub Circulation Fittings Body Bore Size 4 1/4 inches = 14.19 in 2 Flow Slots 4 each total = 15.35 in 2 2 each 2 1502 (1.87 ID) = 4.81 in 2 Total Optional: 2 each 3 1502 (2.75 ID) = 11.88 in 2 Total Body (Around Cage inside 7.56 inch body bore) Plug Size Cage Annular Flow Areas 4 1/2 4.62 x 5.0 25.25 in 2 5 1/2 5.62 x 6.0 16.61 in 2 6 5/8 6.65 x 7.0 6.40 in 2 Lower Sub Thread Size Bore Flow Area 4 1/2 2.75 5.94 in 2 5 1/2 3.50 9.62 in 2 6 5/8 4.25 14.19 in 2 PAGE 8

Weights and Dimensions Swivel Upper Sub Assembly Complete with control swivel Part Number 62317 Weight - 545 lbs Length - 39.87 inches Single Plug Body Assembly Part Number 62306 Weight - 1005 lbs Length - 58.87 inches Ball Dropper Assy Bottom Adapter Part Number 62319 Weight: 405 lbs. Length: 39.87 PAGE 9

Weights and Dimensions Swivel Upper Sub Assembly Complete with control swivel Part Number 62317 Weight - 545 lbs Length - 39.87 inches Double Plug Body Assembly Part Number 62311 Weight - 1300 lbs Length - 83.69 inches Bottom Adapter Ball Dropper Assy Part Number 62319 Weight: 405 lbs. Length: 39.87 Page 10

Page 11

Page 12

1443 So. Gage St., San Bernardino, CA 92408 (909) 799-8150 Fax (909) 799-5471 LIFTING CEMENT HEAD ARROWHEAD SURE LOCK STYLE (9L34h34) COMPLETE SINGLE DART ASSEMBLY PART NUMBER 62306 4 ITEM QTY PART # PART NAME 1 1 16711 Body 2 6 16649 Cam Lock 2 1/4 Dia. 3 6 62214 Retainer Pin 4 2 14750 Lifting Eye & Bolts, 5000lbs 5 1 16642 Pin Puller, 4 1/2 in Stk 6 2 14702 Lock Nut 7 2 16624 Holding Bull Plug 8 2 34227 O-Ring 9 2 37226 Back Up Ring 10 1 62252 Ball Dropper 11 1 62180 Lock Nut 3 1/4 1 8 9 6 5 6 11 7 10 2 3 Bulletin 589 Page 13 Rev 6/07

LIFTING CEMENT HEAD ARROWHEAD SURE LOCK STYLE (9L34h34) COMPLETE DOUBLE DART ASSEMBLY PART NUMBER 62311-2 ITEM QTY PART # PART NAME 4 1 1 62312-2 Body 2 6 16649 Cam Lock 2 1/4 Dia. 3 6 62214 Retainer Pin 4 2 14750 Lifting Eye & Bolts, 5000lbs 5 1 16642 Pin Puller, 4 1/2 in Stk 6 3 14702 Lock Nut 7 1 16624 Holding Bull Plug 8 2 34227 O-Ring 9 2 37226 Back Up Ring 10 1 62252 Ball Dropper 11 1 62180 Lock Nut 3 1/4 1 8 9 6 5 6 2 11 7 10 3 Bulletin 590 Page 14 Rev 6/07

1443 So. Gage St., San Bernardino, CA 92408 (909) 799-8150 Fax (909) 799-5471 LIFTING CEMENT HEAD ARROWHEAD SURE LOCK STYLE (9L34h 075) SWIVEL UPPER SUB ASSEMBLY PART NUMBER 62317 1 13 ITEM QTY PART # PART NAME 18 1 1 Body (PN Listed Below) 2 1 62199 Keeper Ring 2a 1 62199-3 Drive Retainer Ring 3 1 62198 Flow Ring 4 2 14703 Adapter 2 3/4-8 x 2 1502 5 2 34227 O-Ring 5a 2 37226 Back Up Ring 6 2 19251 Seal Ring 7 2 62231 Lock Nut 8 1 62220 Reaction Plate 9 2 14750 Lifting Eye & Bolts 10 12 62216 12 PCS 3/8-16 x 1 1/4 12 2 62223 Wiper Ring 13 2 62219 Retainer Ring 14 2 62212 Bearing 15 2 62262 Back Up Ring 16 2 62221 Seal 17 2 16451 Grease Fitting 18 12 62217 12 PCS 3/8-16 x 1 3/4 19 2 62215 Clevis 20 1 62303 Stop Button 21 1 11031 SHCS 3/8-24x.5 22 1 37440 Back Up Ring 23 1 34441 O-Ring 24 1 16613 Parts Kit 35 Note 35 is a bleed hole and should not be blocked. 19 20 21 22 23 35 14 2 17 3 16 15 12 10 2a Torque 3/8-16 Bolts to 33 ft lbs. Torque 1/2-13 Bolts to 80 ft lbs. Use any bearing grease that suits your particular temperature conditions. Thread Swivel Body PN 6 5/8 FH 62318 API NC-61 62413 5 1/2 FH 62323 XT-57 62408 NC-50 4 1/2 IF 62332 XT-55-375 62403 9 Bulletin 588 Page 15 Rev 6/07

1443 So. Gage St., San Bernardino, CA 92408 (909) 799-8150 Fax (909) 799-5471 LIFTING CEMENT HEAD SWIVEL UPPER SUB ASSEMBLY PART NUMBER: 62317 1 ITEM QTY PART # PART NAME 18 12 1 1 62323-4 Body 2 1 62199 Keeper Ring 2a 1 62199-3 Drive Retainer Ring 3 1 62198 Flow Ring 4 2 14703 Adapter 2 3/4-8 x 2 1502 5 2 34227 O-Ring 5a 2 37336 Back Up Ring 6 2 19251 Seal Ring 7 2 62231 Lock Nut 8 1 6220 Reaction Plate 9 2 14750 Lifting Eye & Bolts 10 12 62216 12 PCS 3/8-16 x 1 1/4 12 2 62223 Wiper Ring 13 2 62219 Retainer Ring 14 2 62212 Bearing 15 2 62262 Back Up Ring 16 2 62221 Seal 17 2 16451 Grease Fitting 18 12 62217 12 PCS 3/8-16 x 1 3/4 35 Note 35 is a bleed hole and should not be blocked 8 13 2 17 3 16 15 14 2a 12 13 10 Bulletin 706e Page 16 Rev 6/07

SUPER SUB SEA CEMENT HEAD LOWER ADAPTOR ASSEMBLY (9L 34h 134) PART NO THREAD STYLE 62319 6 5/8 FH 62414 API NC-61 62334 5 1/2 FH 62409 XT-57 62324 NC-50 4 1/2 IF 62404 XT-55-375 2 3 1 11 10 7 ITEM QTY PART # PART NAME 5 9 1 1 ---- Bottom Adaptor 2 1 34441 O-Ring 3 1 37440 Back Up Ring 4 2 14747 Lifting Eye and Bolts, 2500 lbs 5 1 14691 Bolt On Housing 6 1 14609 Lock Nut 7 4 14694 Soc Hd Cap Scr 7/16-20x1 3/8 8 1 14690 Lock Nut 2 1/2-8 Acme 9 1 14694 Bolt on Lever Tattle Tale 10 1 62303 Button 11 1 11031 SHCS 3/8-24x1/2 4 6 BULLETIN 591 PAGE 17 REV 6/07

LIFT FLOW AROUND CEMENT HEAD BOLT-ON LEVER LEVER TATTLE TALE 2 1/2-8 ACME x 2.00 SEAL ASSY 16694 2 ITEM QTY PART # PART NAME 1 1 1 14692 Body 2 1 14682 Lever Ball Assy 5 3 1 37223 Back Up Ring 4 1 34224 O-Ring-90 5 1 14669 Bearing Gland 6 1 37218 Back Up Ring 7 1 33218 O-Ring-70 8 1 14688 Retainer Gland 2.5-8 3 4 9 6 7 8 9 1 14696 Retainer Ring Smalley WH150 12 10 1 14691 Bolt On Housing 11 4 14695 Soc Hd Cap Scr 7/16-20x1 3/8 12 1 14690 Lock Nut 2 1/2-8 ACME 10 11 13 -- 14680 Seal Kit Note: Torque 7/16-20 SHCS to 58 ft lb Caution: Assemble TT Body to Bottom Sub before torqueing SHCS Caution: Turn TT Body with Arrow Pointing Up Before setting lock nut #14690. BULLETIN 581 PAGE 18 REV 6/07

LIFT FLOW AROUND CEMENT HEAD BOLT ON LEVER FLAG TATTLE TALE THREAD x SEAL: 2 1/2-8 ACME x 2.00 SEAL PART NUMBER: 14697 ITEM QTY PART # PART NAME 1 1 14689 Body 2 1 14661 Spring 3 1 14674 Indicator 2 Stroke 4 1 14675 Cover/Guard 2 Stroke *5 1 14664 Ring *6 1 14665 Flag 7 1 16685 Lever/Ball Assy *8 1 14696 Retainer Ring Smalley WH-150 *9 1 14688 Retainer Gland 2.5-8 *10 1 14669 Bearing Gland *11 1 14670 Set Screw 1/2-28 x 1/4 *12 1 37223 Back Up Ring *13 1 34224 O-Ring 90 *14 1 37218 Back Up Ring *15 1 33218 O-Ring 70 16 1 14680 Seal & Parts Kit 4 C 6 5 D Note: Torque 7/16-20 SHCS to 58 ft lb 3 2 CAUTION: Assemble Lever/Flag Tattle Tale to Cement Head with Arrows Pointing UP. Arrange Guard so that the Flag can hang freely down. 1 14 15 10 RE-COCKING: 1) Push indicator pin a A (with hammer handle) and hold 2) Push indicator head 3 into latch with probe through hole C 3) Look through hold D to see indicator head in latch 4) roll flag up and push between pin and guard 12 13 7 9 8 BULLETIN 584 PAGE 19 REV 6/07

SUPER SUB SEA CEMENT HEAD SINGLE DART CAGE SIZES: 6 5/8 5 1/2 4 1/2 ITEM PART NAME SIZE PART NO. 0 Assy 6 5/8 62285-1 5 1/2 62285-2 4 1/2 62285-3 1 Cap 6 5/8 62187 5 1/2 16671 4 1/2 16672 2 Cage 6 5/8 62227 5 1/2 62225 4 1/2 62224 3 Guide Tube 62254 4 Spring (3 ea) 62255 5 Top Collar 62259 6 Cap Screw (2 ea) 5/16x2.25 GR8 62267 7 Lock Nut (2 ea) 5/16 62268 8 Top Spring 62270 9 Bottom Collar 62260 5 6 7 8 1 2 3 4 Notes: 1) The cage can be assembled from top or the bottom of the body of the cement head in vertical or horizontal positons. 6 7 9 2) Assemble Cage into Head Body. Install Pin Puller and Blanking Plug. Center port of the head with port of the cage. Their lips will hold cage in place. 3) Cement Plugs can be loaded from the top or the bottom of the head. Bulletin 592 Page 20 Rev 6/07

1443 So. Gage St., San Bernardino, CA 92408 (909) 799-8150 Fax (909) 799-5471 SUPER SUB SEA CEMENT HEAD DOUBLE DART CAGE SIZES: 6 5/8 5 1/2 4 1/2 ITEM PART NAME SIZE PART NO. 0 Assy 6 5/8 62350-1 5 1/2 62350-2 4 1/2 62350-3 1 Cap 6 5/8 62187 5 1/2 16671 4 1/2 16672 2 Cage 6 5/8 62351 5 1/2 62352 4 1/2 62353 3 Guide Tube 62254 4 Spring (3 ea) 62255 5 Top Collar 62259 6 Cap Screw (2 ea) 5/16x2.25 GR8 62267 7 Lock Nut (2 ea) 5/16 62268 8 Top Spring 62270 9 Bottom Collar 62260 6 7 9 5 6 7 8 1 2 3 4 Notes: 1) The cage can be assembled from top or the bottom of the body of the cement head in vertical or horizontal positons. 2) Assemble Cage into Head Body. Install Pin Puller and Blanking Plug. Center port of the head with port of the cage. Their lips will hold cage in place. 3) Cement Plugs can be loaded from the top or the bottom of the head. Bulletin 593 Page 21 Rev 6/07

LIFT FLOW AROUND SUB SEA DART PIN PULLER THREAD x SEAL: 2 3/4-8 ACME x 2.37 PART NUMBER: 16642 ITEM QTY PART # PART NAME 1 1 18182 Pin 2 1 18181 Spring 3 1 18180 Lock Lever 4 1 18179 Lock Pin 5 1 18178 Jam Nut 6 1 18177 Bonnet Assembly 7 1 18176 Key 8 1 18175 Bearing 9 1 62244 Drive Shaft 10 1 18172 Cap *11 2 18171 Set Screw (1/4-28 x 1/4 ) 12 1 16451 Grease Fitting 13 1 62241 Body 14 1 16643 Sub ACME *15 1 37325 Back Up Ring *16 1 34325 O-Ring 90 *17 1 37226 Back Up Ring *18 1 34227 O-Ring 90 19 1 18164 Wiper 20 1 16645 Indicator Rod 21 1 16644 Screw Pin 22 1 16611 Seal & Parts Kit 1 2 3 4 5 6 7 9 10 11 13 14 15 8 12 35 A B LENGTHS AND WEIGHTS Part No. A B C Lbs 16642 4.5 3.37 8.12 12.0 16 17 18 GREASE PROCEDURE 1. Retract Screw Pin #21 2. Grease heavily 3. Extend Screw Pin; extra grease will bleed at hold #35 4. Grease lightly. Next use will force grease to drive shaft. 19 20 21 STROKE A Note: Hole #35 is a bleed hole, and should not be plugged Bulletin 577 Page 22 Rev 6/07

LIFT FLOW AROUND SUB SEA BALL DROPPER THREAD x SEAL: 3 1/4 ACME x 3.03 PART NUMBER: 62252 4 ITEM QTY PART # PART NAME 1 1 18182 Pin 2 1 18181 Spring 3 1 18180 Lock Lever 4 1 18179 Lock Pin 5 1 18178 Jam Nut 6 1 18177 Bonnet Assembly 7 1 18176 Key 8 1 18175 Bearing 9 1 62205 Drive Shaft 10 1 18172 Cap *11 2 18171 Set Screw (1/4-28 x 1/4 ) 12 1 16451 Grease Fitting 13 1 62239 Body 14 1 62237 Sub ACME *15 1 37325 Back Up Ring *16 1 34325 O-Ring 90 *17 1 37231 Back Up Ring *18 1 34232 O-Ring 90 19 1 18164 Wiper 20 1 62210 Indicator Rod 21 1 62238 Screw Pin 22 1 Seal & Parts Kit BALL CAGE PN 2.25 62175 1/75 Haliburton 62176 Note: Ball Cage Not Included in Assy PN GREASE PROCEDURE 1. Retract Screw Pin #21 2. Grease heavily 3. Extend Screw Pin; extra grease will bleed at hold #35 4. Grease lightly. Next use will force grease to drive shaft. Note: Hole #35 is a bleed hole, and should not be plugged 3 5 6 1 2 7 9 15 16 17 18 8 11 12 13 14 20 21 19 Bulletin 560 Page 23 Rev 6/07

LIFT FLOW AROUND SUB SEA LARGE BALL DROPPER THREAD x SEAL: 3 7/8 ACME x 3.625 PART NUMBER: 62360 ITEM QTY PART # PART NAME 1 1 18182 Pin 2 1 18181 Spring 3 1 18180 Lock Lever 4 1 18179 Lock Pin 5 1 18178 Jam Nut 6 1 18177 Bonnet Assembly 7 1 18176 Key 8 1 18175 Bearing 9 1 18173 Drive Shaft 10 1 18172 Cap *11 2 18171 Set Screw (1/4-28 x 1/4 ) 12 1 16451 Grease Fitting 13 1 18189 Body 14 1 62362 Sub ACME *15 1 37325 Back Up Ring *16 1 34325 O-Ring 90 *17 1 37252 Back Up Ring *18 1 34253 O-Ring 90 19 1 18164 Wiper 20 1 18162-5 Indicator Rod 21 1 16644 Screw Pin 22 1 16611 Seal & Parts Kit BALL CAGE PN 2.875 62361 GREASE PROCEDURE 1. Retract Screw Pin #21 2. Grease heavily 3. Extend Screw Pin; extra grease will bleed at hold #35 4. Grease lightly. Next use will force grease to drive shaft. Note: Hole #35 is a bleed hole, and should not be plugged 1 2 4 3 5 6 7 9 11 15 16 17 18 20 8 10 21 12 13 35 14 19 Bulletin 586 Page 24 Rev 6/07