D-EAVZ Auila A210 / G500 3fly.at: +43 2252 77340 MTOW = 750 kg / 1.653 lb A/C-Size: W: 10,3 m H: 2,4 m L: 7,35 m F P L ( E X A M P L E ) 7 A/C ID D-EAVZ Tower LOAV +43 1 900729201 Mainten. LOAV +43 2252 790894 A I S +43 51703 3211 M E T +43 51703 3443 8 Flight Rules V Fuel F2 EN228 SUPER Type of Flight G Fuel (alternative)* AVGAS 100LL 9 Type of A/C A 210 Maximum Fuel 120 L / 31,7 gal Wake Turbul. Cat. L Unusable Fuel 10,4 L / 2,8 gal 10 Euipment S / S 13 Departure A/D LOAV Aero Shell SPORT PLUS 4 F2 Departure Time 0830 Minimum 15 Speed N0110 Maximum Flight Level VFR Route SOPRON Front Tire 29 psi / 2,0 bar 16 Destination A/D LHFM Main Tires 36 psi / 2,5 bar Total EET 0025 Alternate A/D LOAN VS0 (Stall- Flps max) 39 KIAS 18 Other Info EET/SOPRON0015 VG (best glide, Flps up) 78 KIAS 19 Endurance 0430 Max. Demo. X-Wind 15 knots Persons on Bord 2 Emerg. Euipm. A/C Colour Name PIC ELT WHITE NAME OPERATOR CONTACT F U E L TIRE O I L Motorflug Union - Wien A-2540 Bad Vöslau, Flugplatz *) If alternative Fuel used g Entry in A/C LOG SPEED COM FAIL DIFF = 0,45 L Clear to Land Do not Land Return to Landing Continue Circling A/D unsafe, don t Land Land at this A/D and proceed to Apron - wait for Clearance
1 D A I L Y I N S P E C T I O N 1. L e f t M a i n G e a r 1 Fuel Tank Sumps 2 x DRAIN 19 Wheel Fairng / Strut CHECK 2 Electr. Fuel Pump DRAIN 20 Tire Press /Slip Mkr. CHECK C A B I N C H E C K 3 A/C Documents CHECK 4 Ignition Key REMOVE B A T T E R Y 21 Tire / Wheel / Brake VIS INSP 22 Chocks REMOVE Master - GEN / BAT ON 23 Shell & Skid Plate VIS INSP Lights (GEN1, Fuel) ILLUMIN 24 Tail Tiedown DISCON Lights (GEN2, Volt) ILLUMIN Master - GEN OFF 3. E m p e n n a g e Eng. Instrument CHECK 25 Elevat. & Stabilizer VIS INSP Fuel Quantity CHECK 26 Rudder VIS INSP Light: Nav, Ldg, Instr CHECK 27 Fitting Bolt Connect. CHECK ACL, Stall Warning CHECK 28 Vertical Stabilizer VIS INSP Master - BAT OFF 14 ELT ARM 4. R i g h t M a i n G e a r 15 Foreign Objects REMOVE 29 Wheel Fairng / Strut CHECK 16 Baggage stowed SECURE 30 Tire Press /Slip Mkr. CHECK 17 Canopy clean NO DAMAGE 31 Tire / Wheel / Brake VIS INSP 18 Flashlights CHECK 32 Chocks REMOVE E X T E R I O R C H E C K 2. F u s e l a g e 5. R i g h t W i n g 33 Wing Surfaces VIS INSP 34 Fuel Vent - clear CHECK 35 Flap CHECK 36 Aileron/Insp. Wndw. VIS INSP 37 Wing Tip VIS INSP 38 Fuel Level- Dipstick CHECK 39 Fuel Filler Cap CLOSE 40 Wing Tiedown DISCON
2 6. Nose Section / Cowling P R E F L I G H T 41 Ignition / ALT1/BAT CHECK OFF 1 Daily Inspection COMPL 42 Parking Brake SET 2 Tow Bar REMOVE 43 Crank Engine CHECK NOISE 3 Fuel Quant. Dipstk 2 x CHECK 44 Oil level / diff. 0,45L CHECK 4 Ignition & GEN/BAT CHECK OFF 45 Coolant Level CHECK 5 Parking Brake SET 46 Air+Cooler Intakes FREE 6 Crank Engine CHECK NOISE 47 Cowling Fasteners CHECK 7 Oil level / diff. 0,45L CHECK 48 Propeller / Spinner CHECK 8 Coolant Level CHECK 9 Tiedown Straps REMOVE 7. N o s e L d g G e a r 10 Baggage Door CLOSE/LOCK 49 Wheel Fairng / Strut CHECK 11 Pitot Cover REMOVE 50 Gear Strut Mount VIS INSP 12 Control Locks REMOVE 51 Tire Pressure CHECK 13 Seating Positions ADJUST/LOCK 52 Tire / Wheel VIS INSP 14 Carburetor Heat FREE - PUSH 53 Shock Absorber CHECK 15 Cabin Heat FREE - PUSH 54 Chocks / Tow Bar REMOVE 16 Choke free move AUTO RESET 8. L e f t W i n g 17 Throttle free move IDLE 18 Prop free move FULL FWD 55 Wing Surfaces VIS INSP 19 Mass & Balance IN LIMITS 56 Fuel Vent - clear CHECK 57 Pitot / Static Cover REMOVE 58 Pitot / stat Opening CLEAR B E F. E N G I N E S T A R T 59 Wing Tip VIS INSP 1 Preflight Check COMPL 60 Aileron Insp. Wndw. VIS INSP 2 Passenger Briefing COMPL 61 Fuel Level / Dipstick CHECK 3 Seats ADJUST 62 Fuel Filler Cap CLOSE 4 Seat Belts / Harn. FASTEN 63 Flap CHECK 5 Canopy Closed LOCK 64 Wing Tiedown DISCON 6 Canopy locked CHECK content: 3fly.at, layout & design: copyright 2016 ing. mag. less ayasch 7 Parking Brake SET 8 Controls movement CHECK
3 9 Fuel Selector FULLER TANK B E F O R E T A X I 10 Carburetor Heat PUSH (OFF) 1 Warmup max 1000rpm OIL MIN 50 C 11 Throttle IDLE 2 Avionics/Flight Instr. ON / SET 12 Prop FULL FWD 3 Engine Instruments CHECK 13 Avionic - Master OFF 4 Trim Sw. + Indicator CHECK 14 All CB's CHECK 5 Flap Sw. + Indicator CHECK + UP 15 Attitude Indicator CAGE 6 Landing Light ON 16 Master - GEN / BAT ON Master - GEN OFF 17 G500 AHRS Warnings CHECK Low Volt Warn Light CHECK F2 18 GEN1 / GEN2 Light ILLUMIN GEN2 CB PULL (OFF) 19 Fuel Warning Light ILLUMIN Low Volt Warn Light ILLUMIN 20 ACL ON Master - GEN ON Low Volt Warn Light CHECK F2 GEN2 CB PUSH (ON) Voltmeter in green CHECK All Switches AS REQ 1 Before Start Check COMPL 16 Parking Brake RELEASE 2 Fuel Pump ON Brakes CHECK 3 Fuel Warning Light OFF Steering CHECK HOT COLD E N G I N E S T A R T Throttle - when cold IDLE Flight Instruments CHECK Choke - when cold PULL / HOLD Throttle - when hot 1-2 cm OPEN Choke - when hot PUSH 6 Brakes Both Pedals PRESS 7 Prop Area CLEAR 8 Ignition START / BOTH 9 Oil Press < 10 sec. RISING 10 GEN1 Warn. Light OFF 11 GEN2 Warn. Light OFF 12 Fuel Pump OFF 13 Fuel Warning Light OFF G E N E R N A T O R T E S T T A X I
4 1 Transponder CHECK 1 Before T/O Check COMPL 2 Brakes APPLY 2 Landing Light AS REQ 3 Parking Brake SET 3 Approach Sector CLEAR 4 Compass / Gyro CHECK / SET 4 Runway Heading CONFIRM 5 Fuel Selector FULLER TANK 5 Throt / Prop / Carb FULL FWD 6 Fuel Warng Light OFF F2 6 RPM Max 2260 CHECK 7 Engine Instruments IN GREEN 7 T/O Power Values CORRECT 8 Throttle 1700 rpm 8 Elevator NEUTRAL MAGNETOS L - B - R - B SWITCH 9 Rudder DIRECTION Drop max.120 rpm CHECK 10 Rotate (VR) 50 KIAS Diff L/R max 50 rpm CHECK 11 Climb Initialy 57 KIAS Ignition Switch Both CONFIRM 12 Short T/O (VX) 52 KIAS 13 Carburetor pull (on) DROP 20-50 rpm 14 Carburetor PUSH (OFF) GOVERNOR B E F O R E T A K E O F F Prop 3 x to start / cruise end stops A Drop 200 +/- 50 rpm C L I M B A Oil Press CONSTANT 1 Throttle FULL A Manifold Press CHANGE 2 Prop Max 2260 rpm CHECK 19 Throttle IDLE 3 Engine Instruments IN GREEN 20 Fuel Pump ON 4 Climb Speed (VY) 65 KIAS 21 Flaps T/O 5 min. 400 ft AGL - Check Safe Spd 22 Trim SET START 6 Flaps UP 23 All CB's CHECK 7 Trim AS REQ 24 Contr. Movement FREE 8 Landing Light OFF 25 Lap Belt TIGHTEN 9 Fuel Pump OFF 26 Canopy g closed LOCK 10 Fuel Warning Light CHECK 27 Departure Briefing COMPL 28 T/O Briefing COMPL 29 Parking Brake RELEASE L I N E U P / T A K E O F F
5 C R U I S E 8 Flaps F2 LDG 1 Throttle F2 AS REQ 9 Fin. Appr. Spd. F2 60 KIAS 2 Prop 1650-2260 rpm 10 Prop FULL FWD 3 Flaps CHECK UP Throttle FULL FWD 4 Trim AS REQ Prop FULL FWD 5 Engine Instruments IN GREEN Carburetor Heat PUSH (OFF) 6 Manvr. Speed (VA) 112 KIAS Flaps T/O 7 Turbulent Air (VNO) MAX 130 KIAS Climb Airspeed 65 KIAS G O A R O U N D F2 Full Throttle: g Prop min. 2140 rpm F2 CAUTION: Strong cross/head winds may reuire less flaps / higher airspeeds A F T E R L A N D I N G D E S C E N T 1 Throttle AS REQ 1 Throttle AS REQ 2 Flaps UP 2 Prop MIN 2000 rpm 3 P/S Heat OFF 3 Carburetor Heat AS REQ 4 Carburetor Heat PUSH (OFF) RAPID DESCENT Throttle IDLE 5 Fuel Pump OFF Prop FULL FWD 6 Landing Light OFF Carburetor Heat PULL (ON) 7 XPDR GND Mode CHECK Flaps UP Airspeed MAX 130 KIAS Engine Instruments IN GREEN 1 Throttle IDLE L A N D I N G 2 Parking Brake SET 3 Flaps LDG 1 Lap Belt TIGHTEN 4 ELT (121,5 MHz) CHECK 2 Fuel Pump ON 5 Avionic Master OFF 3 Landing Light AS REQ 6 Ignition OFF 4 Carburetor Heat PULL (ON) 7 Electr. Euipment OFF 5 Throttle AS REQ 8 Instrument Lights OFF 5 Airspeed (VFE) MAX 90 KIAS 9 Master - ALT1 / BAT OFF S H U T D O W N 6 Flaps T/O OR LDG 10 Seats Pos. (L & R) FULL AFT 7 Trim AS REQ 11 Chocks / Tiedowns AS REQ.
6
7 Airspeeds for Normal Operations T A K E O F F Climb Flaps T/O 57 KIAS VX Flaps T/O 52 KIAS VY Flaps UP 65 KIAS F2 L A N D I N G Final APP Flaps LDG 60 KIAS Balked Ldg Flaps LDG 60 KIAS Max. demo X Wind 15 KIAS VFE max, Flaps LDG 90 KIAS C R U I S E VA Maneuvering 112 KIAS VNO Max turbul. Air 130 KIAS VNE Max Airspeed 165 KIAS Airspeeds for Emergency Operations VA Maneuvering Best Glide Flaps UP Best Glide Flaps T/O Precaut. Flaps LDG No Engine Power Flaps T/O Flaps UP 112 KIAS 78 KIAS 73 KIAS 60 KIAS 65 KIAS 70 KIAS