ILLUSTRATED PARTS BREAKDOWN PARTNER 1 HP, MOWER DECK LAWN TRACTOR MODEL NUMBER 1-9 (P1B) 94 1 00-9 1790 1..01 TR
SCHEMATIC RED BATTERY A AMMETER (OPTIONAL) RED FUSE RED M STARTER WHITE RED B S M G A1 L A CLUTCH / BRAKE (PEDAL UP) SOLENOID WHITE IGNITION SWITCH WHITE SEAT SWITCH (NOT OCCUPIED) BLUE HOUR METER (OPTIONAL) FUEL LINE ATT'MENT CLUTCH (CLUTCH OFF) IGNITION UNIT GROUNDING CONNECTOR SPARK PLUG GAP ( PLUGS ON TWIN CYL. ENGINES) CHARGING SYSTEM OUTPUT AMP DC @ 00 RPM 8 VOLTS AC MIN. @ 00 RPM (CHARGING SYSTEM DISCONNECTED) FUEL SHUT-OFF SOLENOID (IF SO EQUIPPED) ORANGE RED LIGHTING SYSTEM OUTPUT AMP AC @ 00 RPM DIODE ALTERNATOR IGNITION SWITCH POSITION CIRCUIT MAKE OFF M+G+A1 NONE RUN/LIGHT B+A1 A+L RUN B+A1 NONE START B + S + A1 NONE NOTE YOUR TRACTOR IS EQUIPPED WITH A SPECIAL ALTERNATOR SYSTEM. THE LIGHTS ARE NOT CONNECTED TO THE BATTERY, BUT HAVE THEIR OWN ELECTRICAL SOURCE. BECAUSE OF THIS, THE BRIGHTNESS OF THE LIGHTS WILL CHANGE WITH ENGINE SPEED. AT IDLE THE LIGHTS WILL DIM. AS THE ENGINE IS SPEEDED UP, THE LIGHTS WILL BECOME THEIR BRIGHTEST. 14 VOLTS AC MIN. @ 00 RPM (LIGHTS OFF) BROWN HEADLIGHTS NON-REMOVABLE CONNECTIONS REMOVABLE CONNECTIONS WIRING INSULATED CLIPS NOTE: IF WIRING INSULATED CLIPS WERE REMOVED FOR SERVICING OF UNIT, THEY SHOULD BE REPLACED TO PROPERLY SECURE YOUR WIRING.
ELECTRICAL 1 4 4 41 4 7 7 40 7 7 1 1 0 48 8 9 7 8 1
ELECTRICAL 1 1449 Battery 1 Volt AMP 8747041 Bolt Hex Hd 1/4-0unc X /4 8 1417 Case Battery Hng Mech W/lid 1 14 Switch Interlock Push-In 1 1181 Harness Asm Light W/41j 0041 Bulb Light #11 4 14780 Cable Battery Ga 11" Red 14147 Cable Battery Ga Red w/1 wir 1718 Fuse 7 8710400 Nut Keps Hex 1/4-0 Unc 8 1477 Cable Ground Ga 1" black 9 110 Switch Plunger Nc Gray 0 17 Switch Ign 140401 Key 40 17017 Harness Ing Cl Am Hm 41 871110408 Bolt Blk Fin Hex 1/4-0 x 1/ 4 11 Cover Terminal Red 4 17141 Solenoid 48 140844 Adapter Ammeter Rectangular 141940 Protection Wire Loop NOTE: All component dimensions given in U.S. inches. 1 inch =.4 mm.
CHASSIS AND ENCLOSURES 17 1 0 4 9 18 1 8 4 1 1 7 8 08 9 08 11 07 08 4 4 10 14 1 1 7 14 7 14 08 0 14 8 14 4
CHASSIS AND ENCLOSURES 1 17419 Chassis 174 Drawbar 817001 Screw /8-1 x.7 17 Bumper Hood Dash 9 1711 Dash 10 8714008 Bolt Rdhd Sqnk /8-1unc X 1 11 197 Panel Dash LH 1 140 Clip Tinnerman Grille P/L 1 170 Panel Dash RH 14 81749008 Screw Thdrol /8-1 x 1/ 17 108 Hood 18 198 Bumper Hood 4 8747801 Bolt Fin Hex /8-1unc X 1 Gr. 819111 Washer 1/ X 1/1 X 1 Ga. 8780000 Nut Lock Hex w/ins /8-1 Unc 8 14499 Grille Private Label 9 1814 Lens Grille Private Label 0 170 Fender 1 119 Bracket Fender Repl 10987x 19 Footrest Pnt LH 4 18 Footrest Pnt RH 871100 Bolt Rdhd Sht Sqnk /8-1 X/4 7 81749008 Screw Thdrol /1-18 x 1/ Tyt 8 1984 Bracket Asm Pivot Mower Rear 1 87800400 Nut Lock w/insert 1/4-0 81909141 Washer 9/ x 7/8 x 1 Ga. 14497 Bracket Grille LH 4 1144 Screw Hex Wshd 8-18 x 7/8 1449 Bracket Grille RH 7 87478041 Bolt Hex 1/4-0 x /4 8 1017 Air Duct Private Label 4 14798 Dash Lower STLT 14 187 Plate Reinforcement STLT 14 14 Rod Pivot Chassis/Hood 0 1701 Bolt Shoulder /1-18 07 8177008 Screw Thdrol /1-18 x 1/ 08 8177008 Screw Thdrol /8-1 x 1/ 1 19 Insert Lens REFLECT - - 00479 Plug Button Blk 9 Dia Choke NOTE: All component dimensions given in U.S. inches. 1 inch =.4 mm.
DRIVE 7 89 1 9 1 84 1 14 11 1 77 197 8 11 8 81 0 10 1 80 8 4 79 19 18 8 19 198 11 18 11 0 1 9 1 8 1 1 1 1 18 1 14 8 14 18 8 4 41 4 40 4 9 7 1 4 0 7 49 47 10 70 11 0 10 48 11 1 19 4 8 14 9 1 7 77 74 78 7 9 7
DRIVE 1 - - - - - - - - - Transaxle (Order Parts From Transaxle Manufactuer) Peerless 0-44C 148 Spring Return Brake T/a Zinc 1 Pulley Transaxle 18" tires 4 8100008 Ring Retainer # 100-110 Strap Torque 0 Degrees 817001 Screw Thdrol /1-18 x /4 TYT 8 119 Rod Shift Fender Adjust STLT 10 870041 Pin Cotter 1/8 x 1 Cad 11 10701 Washer Plate Shf 88 Sq Hole 1 874041 Bolt 1/4-8 Unf Gr 8 W/Patch 14 810040400 Washer Lock Hvy Helical 1/4 1 8780000 Nut Lock Hx W/Ins /1-18 Unc Pl 18 8747801 Bolt, Fin Hex /8-1 UNC x 1 Gr. 19 8780000 Nut Lock /8-1 Unc 1 109 Knob 10804 Rod Brake Blk Zinc 840 4 87000 Nut Hex Jam /8-1 Unc 10888 Spring Rod Brake 00 Zinc 819111 Washer 1/ x 1/1 x 1 Ga 7 870041 Pin Cotter 1/8 x /4 Cad 8 177 Rod Brake Parking LT/YT 9 0717 Cap Brake Parking Black 0 17497 Bracket Mtg Transaxle 1 177 Keeper Belt LH LT 14 Ga 874701 Bolt Hex Hd /1-18unc x /4 4 1778 Shaft Asm Pedal Foot 1018 Bearing Nylon Blk 9 Id 819111 Washer 1/ x 1 x 1 Ga 7 149 Pin Roll /1 x 1" 8 19 Pulley Composite Flat 9 8747048 Bolt Fin Hex /8-1 x 40 1741 Spacer Split 41 17 Keeper Belt Idler Flat 4 819111 Washer 1/ x 1/1 x 1 Ga 47 1778 Pulley Idler V Groove Plastic 48 14407 Bellcrank Clutch Grnd Drv Stl 49 10 Retainer Belt Style Spring 0 874704 Bolt Hex Hd /8-1unc x 1-1/ 1 878000 Nut Crownlock /8-1 Unc 878000 Nut Crownlock /1-18 Unc 10710 Link Clutch 10709 Spring Return Clutch 7 817001 Screw /8-1 x 1.0 7 18 V-Belt Ground Drive 9 8 1774 Keeper Belt RH LT Pnt/zinc 1g 9 1991 Keeper Belt Span Ctr 1 817001 Screw /8-1 x /4 1487 Cover Pedal Round 17410 Engine Pulley 4 87117074 Bolt Hex 810040700 Washer Lock Hvy Hlcl Spr 7/1 14778 Keeper Belt Engine Foolproof 9 144 Screw Hex Wsh Hi-Lo 1/4-1/ 70 148 Guide Belt Mower Drive RH 74 1707 Spacer Axle 7 11749 Washer / x 1 1/4 x 1 Ga 7 81000001 E-ring #1-7 77 18 Key Square 0 x 184/ 18 78 11748 Washer / x 1-/8 x 1 Ga 79 109 Key Woodruff #9 /1 x /4 80 1148 Arm Shift 81 194 Shaft Asm Cross Tapered DA/PR 18" 8 178 Spring Torsion T/a 8 8191711 Washer 17/ x /4 x 1 Ga 84 18 Transaxle Link 8 100 Nut Lock Center 1/4-8 FNTHD 89 17774 Console Shift STLT 9 14788 Retainer Spring 1" 11 81909110 Washer 9/ x /4 x 10 Ga. 11 178 Strap Torque LT 11 8714008 Bolt Rdhd Sq Neck /8-1 x 1 10 8790000 Nut Lock Flg /8-1 14 87449040 Bolt Hex Flg Hd /1-18 Gr 10 174 Spacer Retainer 11 819110 Washer 1/ x x 10 Ga. 1 100 Washer Srrted /1ID x 1.1 18 189 Bracket Shift Mount 19 1494 Hub Tapered Flange Shift Lt 11 8714040 Bolt Rdhd Sqnk 1/4-0 x /4 Gr 1 8780400 Nut Crownlock 1/4-0 Unc 1 87478041 Bolt Hex Fin 1/4-0 Unc x 1 Gr 14 819091010 Washer /8 x.81 x 10 Ga 1 1 Bracket Pivot Lever 1 1880 Screw /1-18 x /8 18 149 Bolt Shoulder /1-18 x.1 19 180 Plate Fastening STLT/CRD 197 191 Nyliner Snap-In /8" ID 198 199 Washer Nyl 7/8 Id x.10" Hyd 0 8711014 Bolt Carr Sh /8-1 x 1-/4 1 141 Nut Hexflange Lock NOTE: All component dimensions given in U.S. inches 1 inch =.4 mm
STEERING ASSEMBLY 8 11 9 1 41 4 7 7 44 1 4 91 88 4 71 9 9 17 4 8 9 47 1 8 7 7 7 8 4 8 7 8 9 9 47 7 9 8 8 11 9 4 1 40 4 1 1 9 10 8 0 4 8
STEERING ASSEMBLY 1 1978 Wheel Steering Opp. Sears Blk 1447 Axle Asm Fr 19840 Spindle Asm LH 4 1989 Spindle Asm RH 1491 Bearing Race Thrust Harden 11748 Washer / x 1-/8 x 1 Ga 7 819701 Washer 7/ x 1-1/4 x 1 Ga 8 8100009 Ring Klip #t04-7 9 1497 Bearing Col Strg Blk 10 1711 Link Drag 11 81004000 Washer Lock Hvy Hlcl Spr /8 1 118 Spacer Brace Axle 1 141 Nut Hexflange Lock 17 17787 Shaft Asm Strg 1847 Bushing Link Drag Blk LR 8 8191141 Washer 1/ x 7/8 x 1 Ga 9 817001 Screw /8-1 x.7 0 870041 Pin Cotter 1/8 x /4 Cad 104 Rod Tie Wire Form 19 7 Mech 1099 Bushing Strg Nat./.18Id 7 197 Screw TT #10- x x /8 Flange 8 14017 Cap Wheel Steer P/L 9 819181 Washer 1/ x -/8 x 1 Ga 40 14701 Nut Lock Center /8-4unf 41 100711 Adaptor Wheel Strg 4 19 Boot Shaft Steering 4 11749 Washer / X 1 1/4 X 1 Ga 44 170 Extension Steering 4 11 Cap Spindle Fr Top Blk 47 148 Fitting Grease 1 8780000 Nut Lock Hx w/ins /1-18 Unc 4 8747800 Bolt Fin Hex /1-18 Unc x 1-1/4 8747801 Bolt Fin Hex /8-1 UNC Gr. 107 Spacer Brace Axle 7 8714018 Bolt RDHD SQ /8-1 UNC x -1/4 8 1987 Brace Axle 71 1714 Steering Asm 8 198 Bracket Susp. Chassis Front 8 18 Fastener Christmas Tree 88 17118 Bolt Shoulder 7/1-0 91 17 Cup Steering NOTE: All component dimensions given in U.S. inches. 1 inch =.4 mm.
SEAT ASSEMBLY 1 8 9 8 14 10 7 9 7 1 4 1 1 1 17 1 4 1 14011 Seat 1401 Bracket Pivot Seat 8 70 8711101 Bolt Fin Hex /8-1unc x 1 4 8191110 Washer 1/ x 1 x 10 Ga 1400 Clip Push-In 8780000 Nut Lock Hex w/wsh /8-1 Unc 7 14181 Spring Seat Cprsn 0 Blk Zi 8 8170001 Screw /8-1 x 1. 9 8191114 Washer 1/ x 1 x 14 Ga. 10 174894 Pan Seat 1 114 Bracket Mounting Switch 1 1148 Bushing Snap Blk Nyl 0 Id 14 870041 Bolt Rdhd Sht Nk 1/4-0 x 1-1/ 1 1400 Spacer Split 8 x 9 Yel Zinc 1 110 Spring Cprsn 1 7 Blk Pnt 17 197 Nut Lock 1/4 Lge Flg Gr Zinc 1 1718 Bolt Shoulder /1-18 Unc -A 8780000 Nut Lock Hex W/Insert /1-18 UNC 871110814 Bolt Hex 4 81917191 Washer 17/ x 1-/1 x 1 Ga. 17018 Bolt Shoulder /1-18 x 810040800 Washer Lock Hvy HLCLSPR 1/ NOTE: All component dimensions given in U.S. inches. 1 inch =.4 mm
DECALS 8 1 7 4 9 14 11 1 10 10 1 19 1 1 1447 Decal Europe Stand CE 1400 Decal Bat Dan/Poi P/L Symbols 179 Decal Hood LH 4 1794 Decal Hood RH 1708 Decal Engine 1788 Decal Chas. Turbo Collection 7 14087 Decal Saddle Brake Parking 8 140987 Decal Fender Logo 9 14498 Decal Read Owners Manual Syms 10 197 Decal Chassis Hot Muffler 11 14494 Decal Mower Cut finger Symbol 1 1187 Decal 100 Dba 1 14998 Decal Strg Wheel Cap 14 14098 Decal Logo Grille 1 1977 Decal Brake/Clutch 19 18 Decal V-Belt Sch - - 198 Decal Drawbar Load Limit - - 1811 Decal Lift Handle (Lift Handle) - - 174 Manual Operator's Euro - - 174 Manual Operator's Scan WHEELS & TIRES 1,8 7 4,10,9 11 1 0919 Cap Valve Tire 019 Stem Valve 10 Tire F Ts 1 X 0 - Service 4 09904 Tube Front (Service Item Only) 111 Rim Asm " front Yellow Service 1497 Fitting Grease (Front Wheel Only) 7 1499 Bearing Flange (Front Wheel Only) 8 11 Rim Asm 8" rear Yellow Service 9 14 Tire R Ts 18 x 8.-8 C. Service 10 149 Tube Rear (Service Item Only) 11 1709 Cap Axle Blk 1 0 X 1 00 NOTE: All component dimensions given in U.S. inches 1 inch =.4 mm
ENGINE 1 7 81 1 4 78 8 44 1 14 78 4 4 1 7 40 9 OPTIONAL EQUIPMENT Spark Arrester
ENGINE 1 1708 Control Th/ch Flag Eec 81770410 Screw Hex Thd Cut 1/4-0 x /8 T - - - - - - - - - Engine B&S Model No. 89707 (Order parts from engine manufacturer) 4 1748 Muffler LT B&S 1/1 HP 1 191 Gasket Eng 14 1484 Tube Drain Oil Easy 1 8110000 Washer Lock Ext Tooth /8 1987 Shield Brn/Dbr Guard 9 17180 Kit Spark Arrecter 1 1090 Tank Fuel Front 1. 1407 Cap Asm Fuel W/sym Vented 1487 Clamp Hose Blk 7 17040 Line Fuel 0" 8 1481 Plug Oil Drain Easy 40 1408 Bushing Snap Nyl Blk Fuel Line 44 8177041 Screw Hexwsh Thdrol 1/4-0 x /4 4 8170001 Screw Hexwsh Thdrol /8-1 x /4 4 81909141 Washer 9/ x 7/8 x 1 Ga. 81004000 Washer Lock Hvy Hlcl Spr /1 1791 Stop Throt 000 Rpm 7 8710701 Screw Hexhd Cap /1-18 x /4 78 817000 Screw /8-1 x 1-1/4 81 8710400 Nut Keps Hex 1/4-0 UNC NOTE: All component dimensions given in U.S. inches 1 inch =.4 mm
MOWER LIFT 7 8 11 1 4 1 1 4 1 19 1 0 1 0 1 17 18 0 1 1 1 19 0 1
MOWER LIFT 1 1940 Wire Asm Inner W/Plunger 19471 Shaft Asm Lift 1077 Pin Groove 4 8100000 E Ring #1-819111 Washer PLTD 1/ x 1 x 1Ga 1018 Bearing Nylon Blk 9 Id 7 10941 Grip Handle Bicycle Matte Blk 8 14 Button Plunger Black 11 198 Link Lift LH 1 198 Link Lift RH 1 1470 Retainer Spring 1 1788 Link Front 1 870800 Nut Jam Hex 1/-1 Unc 17 10171 Trunnion Blk Zinc 18 87800800 Nut Lock W/Wsh 1/-1 Unc 19 1988 Arm Suspension Rear 0 1 Retainer Spring 1 198 Bearing Pvt Lift 874000 Nut Crownlock /8-4 NOTE: All component dimensions given in U.S. inches 1 inch =.4 mm
8 4 REPAIR PARTS MOWER 18 17 7 1 89 107 40 4 10 40 108 8 11 1 1 89 1 1 14 9 148 14 4 1 14 0 1 1 4 11 0 1 17 171 170 7 0 1 7 1 1 19 4 19 1 18 149 4 1 1 14 1 1 1 8 9 11 1 7 10 8 9
MOWER 1 1749 Mower Deck Assembly 871400 Bolt 18017 Bracket Assembly,Sway Bar 4 174 Bracket Sway Bar 1470 Retainer Spring 108 Arm, Suspension, Rear 7 14008 Keeper Belt 8 8087 Bolt, Hex /8-4 x 1. Gr. 8 9 8100000 Washer, Lock Hvy Hlcl /8 10 1409 Washer, Hardened 11 1849 Blade, Mower 1 174 Shaft Assembly, Mandrel, Vented (Includes Key #1) 14 18774 Housing, Mandrel, Vented 1 11048 Bearing, Ball, Mandrel 1 17449 Stripper, Mower Deck 19 187 Bolt, Shoulder 1 878000 Nut Crownlock /1-18 11 Bracket, Mower Deflector 4 1004 Cap, Sleeve 171 Spring, Torsion, Deflector 1104 Nut, Push 7 171 Shield, Deflector 8 81911101 Washer 11/ x /8 x 1 Ga. 9 11980 Rod, Hinge 0 177 Screw Thdrol Washer Head 1 199 Washer, Spacer 11 Pulley, Mandrel 17 Nut, Toplock, Flanged 4 8711014 Bolt Rdhd /8-1 x 1-/4 11494 Pulley, Idler, Flat 40 878000 Nut Crownlock /8-1 4 14788 Retainer, Spring 10840 Brake Assembly 4 194 Washer, Hardened 1840 Idler Arm Assembly 17 Spacer, Retainer 7 109 Knob RD /8-1 Plstc Thd 8 174978 Belt 9 87001 Pin, Cotter / x /4 89 819111 Washer 1/ x 1 x 1 Ga 107 10 Spacer, Retainer 108 10 Stiffener, Idler Arm 11 81749008 Screw Thdrol /1-18 x 1/ 1 1740 Rod, Brake, LH 1 17404 Rod, Brake, RH 14 1891 Bolt Carriage Idler 148 190 Spring Return Idler 149 1898 Retainer Spring Yellow Zinc 10 8190911 Washer 9/ x /4 x 1 Ga. 11 1970 Bracket Clutch 1 17079 Cable Clutch 1 1974 Washer Flat /8 Type B 14 197 Spring Retainer 1 1971 Spring Retention Lever 1 197 Spacer 17 199 Rod Clutch 18 81770410 Screw Hex Thd Cut 1/4-0x/8 14 17497 Bracket Asm Idler Support 18 1777 Bracket Deck Cable 19 174977 Bracket Asm Suspension 170 179 Bracket Suspension RF 171 17 Brace Support Susp. Frt 17 17 Bracket Suspension LF - - 10794 Mandrel Assembly (Includes Key Numbers 1-1, 17-19, 1 and ) - - 174 Mower Deck, Complete NOTE: All component dimensions given in U.S. inches 1 inch =.4 mm