Parts Catalog TGHAA Generator Set Printed in U.S.A. 9 00 (Spec A C) 9 Replaces 9 00 (Spec A) 97
To avoid errors or delay in filling your parts order, always give the MODEL, SPEC NO. and SERIAL NO. from the Onan nameplate. For handy reference, insert your nameplate information in the spaces below. MODEL AND SPEC NO. SERIAL NO. DIGITAL CONTROL SOFTWARE VERSION AND DATE (IF APPLICABLE) The following symbols are used in Onan manuals to alert users to the potentially dangerous conditions relating to maintenance of equipment and replacement of parts. Please read and observe. This symbol warns of immediate hazards which will result in severe personal injury or death. This symbol refers to a hazard or unsafe practice which can result in severe personal injury or death. This symbol refers to a hazard or unsafe practice which can result in severe personal injury or product or property damage. Service and repair of Onan equipment must be performed by trained, experienced personnel only. Improper service or repair may result in property damage, severe personal injury or death. Do not use this catalog as a guide to servicing your equipment. Read and follow the IMPORTANT SAFETY INSTRUC- TIONS in the Service Manual appropriate for the equipment you are working on. Contact with USED ENGINE OILS has been identified by a United States federal agency and some USA state agencies as causing CANCER or REPRODUCTIVE TOXICITY. When checking or changing engine oils take all necessary precautions not to ingest, breathe the fumes or contact the used oil. Contact with ASBESTOS has been identified by a United States federal agency and some USA state agencies as causing CANCER or REPRODUCTIVE TOXICITY. When handling engine gaskets take all necessary precautions not to ingest, breathe or contact the dust from the gaskets! Use adequate ventilation and wear protective gloves, masks and clothing! Contact with BENZINE and LEAD, found in gasoline, fuel additives and solvents has been identified by a United States federal agency and some USA state agencies as causing CANCER or REPRODUC- TIVE TOXICITY. When checking, draining or adding gasoline and fuel additives or using solvents take all necessary precautions not to ingest, breathe the fumes or contact the liquids. Use adequate ventilation and wear protective gloves, masks and protective clothing! PSP-
Introduction This manual applies to the standard Generator Set as listed in the Generator Set Data Table. Parts are arranged in groups of related items and each illustrated part is identified by a reference number corresponding to the same reference number in the parts list. Parts illustrations are typical. Using the model and specification number from your generator set nameplate, select parts that apply to your set. Right and left sides are determined by facing the engine end (front) of the set. Generator Set Data Table MODEL WIRING NUMBER DIAGRAM VOLTS HERTZ WIRE FUEL.TGHAA/* 7 0/0 0 Natural Gas.TGHAA/* 7 0 0 Natural Gas.TGHAA/* 7 0 0 LP Vapor.0TGHAA/* 7 0/0 0 LP Vapor.0TGHAA/* 7 0 0 LP Vapor * The diagonal line (/) in the model and specification number separates generator set characteristics from the specification number and letter. The specification number denotes customer requested options or deviations from a standard (A, B, etc.) model. The speci fication letter advances (A to B, B to C, etc.) with major manufacturing changes. NOTE: See Parts Book #9 00 for Transfer Switch Information.
Index Actuator, Governor, Adapter, Air Cleaner, Adapter, Breather Tube, Adapter, Generator, Adapter, Oil Filter, 9 Backplate, Air Housing, 9 Base, Housing, 9 Base, Oil, 0 Bearing, Ball, Bearing, Camshaft, Bearing, Connecting Rod, Bearing, Crankshaft, Block, Brush, Block, Cylinder, Block, Generator Brush, Block, Terminal, Board, Control, Boot, Starter Harness, 7 Box, Battery, 9 Bracket, Battery Charger, Bracket, Control Mounting, Bracket, Housing Locking, 9 Bracket, Ignition Coil, Bracket, Ignition Control, Bracket, Regulator Mounting, Breaker, Circuit,, 7 Brush, Generator, Bushing, Piston Pin, Bushing, Regulator Reducer, Cable, Spark Plug, Camshaft, Cap, Fuel Fitting, Cap, Oil Fill, 0 Cap, Starter Solenoid, 7 Capacitor, Carburetor, Charger, Battery, Clip, Control Rod, Clip, Housing Circular, 9 Clip, Spark Plug Wire, 9 Clip, Wire, Coil, Ignition, Components, Starter, 7 Connector, Conduit, Control, Cover, Air Housing, 9 Cover, Breather, Cover, Brush Block Access, Cover, Control Box, Cover, Valve, Crankshaft, 7 Cup, Oil Pickup, 0 Drain, Oil Filter, 9 Elbow, Regulator Hose, Element, Air Cleaner, Fan, Blower Wheel, Fan, Generator, Filter, Breather, Filter, Oil, 9 Fuse, Engine Harness, 7 Fuse, Heater Harness, Gasket, Air Horn, Gasket, Bearing Plate, Gasket, Carburetor Mounting, Gasket, Cylinder Head, Gasket, Exhaust Manifold, Gasket, Gearcase, Gasket, Intake Manifold, Gasket, Muffler, Gasket, Oil Base, 0 Gasket, Oil Filter Adapter, 9 Gasket, Valve Cover, Gear, Camshaft, Gear, Crankshaft, 7 Gear, Fan/Ring, Gearcase, Generator, Governor, Grommet, Guide, Housing Base, 9 Guide, Valve, Harness, AC Output, Harness, Battery Charger, 7 Harness, Carburetor Heater, Harness, Engine, 7 Harness, Genset, Harness, Starter, 7 Head, Cylinder, Holder, Engine Harness Fuse, 7 Holder, Heater Harness Fuse, Hose, Regulator Fuel, Hose, Regulator Vent, Housing, Air, 9 Housing, Air Cleaner, Housing, Generator Stator, Housing, Set, 9 Hub, Blower Wheel, Insert, Blower Wheel Fan, Insulation, Exhaust Manifold, Isolator, Vibration, 0 Key, Blower Wheel, Key, Camshaft Woodruff, Key, Crankshaft Gear, 7 Kit, Gasket, 0 Kit, Oil Pump Gasket, 0 Kit, Piston Ring, Kit, Starter Brush, 7
Index Kit, Starter Bushing, 7 Kit, Starter Drive, 7 Kit, Starter Dust Seal, 7 Kit, Starter Hardware, 7 Kit, Starter Lever Shift, 7 Kit, Starter Solenoid, 7 Label, Circuit Breaker, Label, Switch, Label, Warning, Labels, 0 Lock, Valve Spring, Manifold, Exhaust, Manifold, Intake, Meter, Hour, Module, Ignition Control, Muffler, Nipple, Regulator Close, O Ring, Generator, O Ring, Oil Fill Cap, 0 Paint, 0 Pan, Breather, Pan, Drip, 0 Panel, Air Housing Front, 9 Panel, Control, Pin, Bearing Stop Drive, Pin, Gearcase Alignment,, Pin, Housing Snap, 9 Pin, Piston, Piston, Plate, Bearing, Plate, Cover, Plug, Camshaft Opening Welch, Plug, Core Hole, Plug, Gearcase Expansion, Plug, Regulator Countersunk Head, Plug, Spark, Plunger, Bypass Valve, Plunger, Camshaft, Pump, Oil, Reed, Breather Valve, Regulator, Natural Gas/LP, Relay, Heater Harness, Ring, Collector, Ring, Crankshaft Retaining, 7 Ring, Piston Pin Retaining, Rod, Connecting, Rod, Throttle Control, Rotocap, Exhaust, Rotor, Generator, Rotor, Ignition, Seal, Drip Pan Air Outlet, 0 Seal, Gearcase Oil, Seal, Muffler Support, Seal, Oil Filter Air, 9 Seal, Rear Crankshaft Oil, 7 Seal, Valve, Sealant, Thread, 0 Seat, Valve, Sensor, Engine Temperature, 9 Shim, Crankshaft, Spacer, Muffler Washer, Spring, Breather Valve, Spring, Bypass Valve, Spring, Camshaft Plunger, Spring, Generator Brush, Spring, Housing Clip, 9 Spring, Housing Gas, 9 Spring, Throttle Rod, Spring, Valve, Starter, Stator, Generator, Strap, Ground, 0 Stud, Grounding, Support, Muffler, Switch, Actuator, 9 Switch, Low Oil Pressure, 9 Switch, Magnet, 9 Switch, Oil Level, 0 Switch, Rocker, Switchgear Housing Mounting Hardware, 9 System, Exhaust, System, Fuel, Tappet, Valve, Thermistor, 9 Tube, Breather, Tube, Cylinder Block Oil, Tube, Exhaust, Valve, Exhaust, Valve, Fuel Shut Off, Valve, Intake, Valve, Oil Filter Drain, 0 Volute, Air Housing, 9 Wheel, Blower,
Cylinder Block 9 0 9 9 0 0 0 7 7 9 7 0 7 9 7 0 7
Cylinder Block Block, Cylinder (See Shortblock Catalog #9 009) 0 00 Bearing, Camshaft (Precision) 7 007 Plug, Core Hole 0 Pin, Gearcase Alignment 00 0007 Screw, Hex Head Cap (/ 0 x ) 70 00 Washer, Flat (M) 7 0 09 Pump, Oil (Components Not Sold Separately) 007 Pin, Bearing Stop Drive 9 0 0 Tube, Cylinder Block Oil 0 00 Rod, Connecting (Includes Bolt and Bushing) 0 000 Bolt, Connecting Rod (Special) 00 Bushing, Piston Pin Bearing, Connecting Rod Half 0 Standard 0 0.00 Undersize 0 0.00 Undersize 0 0.00 Undersize 0 0.00 Undersize Piston (Includes Pin, Rings and Retaining Rings) 0 Standard 0 0.00 Oversize 0 0.00 Oversize 0 0.00 Oversize 0 0.00 Oversize 0 Pin, Piston 07 Ring, Retaining 7 Kit, Piston Ring 0 Standard 0 0.00 Oversize 0 0.00 Oversize 0 0.00 Oversize 0 0.00 Oversize 0 009 0 Nut, Hex (Special) (/ ) 9 009 Washer, Compression Lock (Special) (/ x / OD) 0 00 0 Washer, Flat (Special) (/ ) 0 9 Head, Cylinder 0 97 Gasket, Cylinder Head 0 7 Valve, Intake 0 79 Valve, Exhaust Seat, Exhaust Valve 0 Standard 0 0.00 Oversize 0 0.00 Oversize 0 0.00 Oversize 0 0.0 Oversize Seat, Intake Valve 0 Standard 0 0.00 Oversize 0 0.00 Oversize 0 0.00 Oversize 0.0 Oversize 7 Stud, Cylinder Head Mounting 0 099 / x 9/ (Install Bottom Holes RH, LH Heads) 0 07 / x / (Install Top Holes RH, LH Heads) 0 09 / x (Install Middle Holes RH, LH Heads) 00 Washer, Flat (.9 ) 9 00 00 0 Screw, Hex Head Cap (/ x / ) 0 0 09 Plate, Rear Bearing Bearing, Crankshaft (Includes Thrust Washer) 0 00 Standard 0 00 0.00 Undersize 0 00 0.00 Undersize 0 00 0.00 Undersize 0 00 0.00 Undersize 0 07 Washer, Thrust (Special) Shim, Crankshaft 0 077.00 0 077 0.00 Use as Required 0 009 Gasket, Bearing Plate 7 00 0 Plug, Camshaft Welch Opening ( / ) 0 00 Spring, Bypass Valve 7 00 Washer, Copper Flat (/ ) 0 000 Screw, Hex Head Cap psi (/ x 7/ ) 9 0 09 Plunger, Bypass Valve 0 0 090 Rotocap, Exhaust Guide, Valve 0 7 Exhaust 0 Intake 0 0 Seal, Intake Valve Stem Oil 0 09 Spring, Valve 0 09 Lock, Valve Spring 0 7 Gasket, Valve Cover Pan, Breather 7 7 Reed, Breather Valve 7 Spring, Breather Valve 9 Cover, Left Side Breather 0 00 Washer, Copper Flat (/ ) 00 00 Screw, Hex Head Cap (/ 0 x / ) 7 Filter, Breather 00 Washer, Flat (/ ) Tappet, Valve 000 Standard 000 0.00 Oversize 000 0.00 Oversize 0 0 Cover, Right Side Valve 00 00 Screw, Hex Head Cap (/ 0 x )
Camshaft 0 07 Camshaft 0 0 Gear (Includes Spacer and Plate) 0 0 Washer, Thrust 000 Key, Woodruff 0 00 Plunger, Camshaft 0 009 Spring, Plunger
Crankshaft 0 00 Gear, Crankshaft 0 00 Washer, Gear 0 7 Crankshaft 09 00 Seal, Rear Oil 000 Key, Gear 00 Ring, Retaining 7
Blower Wheel 7 9 Wheel, Blower (Includes Parts Marked *) 0 *Hub, Blower Wheel 0 09 *Fan *Insert, Fan 0 *Screw, Lock Flange 009 Key, Blower Wheel 7 0 Washer, Flat (7/ x / Thk) Special 007 Washer, Flat (7/ x / Thk) Special 9 0 070 Screw (Special) * Parts Included in Blower Wheel.
Oil Filter 7 0 Adapter, Oil Filter (Includes Screws) 00 Screw, Hex Washer Head Thread Forming (#0 x / ) 00 Drain, Oil Filter 09 Filter, Oil 09 0 Switch, Low Oil Pressure (S) 00 00 0 Screw, Hex Head Cap (/ x ) 7 00 Washer, Copper Flat (/ ) 077 Gasket, Oil Filter Adapter 9
Oil Base 9 7 0 7 Gasket, Oil Base 0 7 0 Base, Oil Cup, Oil Pickup 09 Cap, Oil Fill 0 00 Valve, Shut Off 09 0 O Ring ( / ID) 7 0 Washer, Flat (/ ) 00 00 0 Screw, Hex Head Cap (/ x / ) 9 09 0 Switch, Oil Level (S) 0
Gearcase 9 7 0 0 Gearcase (Includes Oil Seal and Plugs) 09 000 Seal, Oil 7 09 Plug, Expansion 00 Plug, Gearcase 0 00 Gasket, Gearcase 0 Pin, Alignment 7 00 00 0 Screw, Hex Head Cap (/ x / ) 00 Washer, Flat (/ ) 9 00 0 Screw, Hex Head Cap ( / Lg.)
Governor 0 Rod, Throttle Control 0 Clip, Throttle Control Rod 0 Spring, Throttle Rod 070 Actuator, Governor (K) 07 0 Screw, Pan Head (0 x. Lg) 07 0 Screw, Pan Head (0 x. Lg)
Fuel System 0 0 9 9 7 0 7 7 9 7 07 Manifold, Intake 07 Screw, Hex Washer Head (Special) (/ x ) 9 Gasket, Intake Manifold 00 00 0 Screw, Hex Head Cap (/ x / ) 0 Washer, Flat (/ ) 0 Washer, Flat (/ ) 7 00 00 0 Screw, Hex Head Cap (/ x / ) 0 Clamp, Breather Tube Hose (.900 Diameter) 9 0 7 Clamp, Breather Tube Hose 0 09 Adapter, Breather Tube (Engine Breather End) 0 09 Clamp, Hose 09 Tube, Breather 09 Gasket, Carburetor Mounting 00 Nut, Hex (/ ) 0 0 Gasket, Air Horn 0 07 Clamp, Hose (Spec A B) 7 9 Cap, Fuel Fitting (Spec A B) 0 09 Connector, Hose (Spec A B) 9 Carburetor 07 Natural Gas 07 LP Vapor 0 097 Adapter, Breather Tube (Air Cleaner Adapter End) Adapter, Air Cleaner (Includes Heater) 0 09 00 Natural Gas (W/Fuel Hose Connection Hole) 0 09 0 LP Vapor (W/O Fuel Hose Connection Hole) 090 Screw, Hex Head Cap (Special) (0 x / ) 0 79 Element, Air Cleaner 0 9 Housing, Air Cleaner 00 Washer, Flat (/ ) 00 007 Screw, Hex Head Cap (/ 0 x / ) 7 00 Harness, Carburetor Heater (Includes Relay, Fuse Holder and Fuse) 07 Relay (K) 9 0 Holder, Fuse 0 007 0 Fuse (A) (F) 0 Screw, Hex Head Thread Cutting
Regulator 0 9 7 9 0 Bracket, Regulator Mounting 0 0 Hose, Regulator Vent 000 Screw, Lock Head Flange (/ 0 x / ) 0 0 Clamp, Hose 0 0 Elbow, 90 Hose 70 0 Nut, Self Lock (/ 0) 7 07 0 Valve, Fuel Shut Off 0 00 Nipple, Close (/ ) 9 0 0 Bushing, Reducer 0 0 07 Plug, Countersunk Head (/ ) 00 Regulator, Natural Gas/LP 000 Screw, Lock Head (0 x ) 0 0 Connector, Hose 0 0 Clamp, Hose 0 0 Hose, Fuel (/ x Lg)
Starter 9 99 09 Starter (See Separate Page for Components) (B) 70 00 Nut, Hex (M x.) 0 00 Washer, Lock (M) 00 00 Screw, Cap Hex Head (/ x ) 0 000 Washer, Lock (/ ) 000 Nut, Hex Spring (/ )
Starter Components 7, 9 0 9 99 09 Starter 9 9 Kit, Hardware (Includes Two Solenoid Mounting Screws, Two Thru Bolts, Armature Shims, Pinion Stop Collar, Retaining Ring & Solenoid Terminal Nuts) 9 9 Kit, Bushing (Includes Rear Cap with Bushing & Front Bushing) 9 9 Kit, Brush (Includes Two Negative and Two Positive Brushes & Brush Holder) 9 9 Kit, Dust Seal (Includes ID & OD Pinion Seals) 9 9 Kit, Drive (Includes Pinion Gear & Drive Assy) 9 7 Kit, Lever Shift (Includes Lever, Wear Plate, Rubber Plug & Grease) 7 9 9 Kit, Solenoid (Includes Solenoid & Spring Plunger) 9 99 0 Solenoid 9 9 97 Cap, Solenoid 0 0 00 Washer, Lock (M) 70 00 Nut, Hex (M) 7
Air Housing 7 0 9 7
Air Housing 0 Backplate 0 Screw, Hex Washer Head Cap Thread Forming (/ 0 x / ) 000 Screw, Lock Head Flange (0 x / ) 9 0 Volute, Right Side 0 Volute, Left Side 00 Screw, Self Locking Hex Washer Head (/ x.7 ) 7 09 Seal, Oil Filter Air 0 Screw, Hex Washer Head (/ 0 x / ) 9 9 Cover, Right Side (Includes Indented Parts Listed Below) 79 0 Cover, Inner Cylinder Head 7 Insulation, Cylinder Head 7 Insulation, Muffler Box 0 Nut, Insulation Push On 0 Panel, Front (Includes Indented Parts Listed Below) 99 Insulation 77 0 Cover,Tailpipe Access 07 Clip, Access Cover (/ 0) 0 Screw, Torx Drive Access Cover (/ 0 x / ) -0 Nut, Insulation Push On 0 Clip, Spark Plug Wire 9 Cover, Left Side (Includes Indented Parts Listed Below) 790 0 Cover, Inner Cylinder Head 0 Nut, Insulation Push On 0 Screw, Torx Drive (/ 0 x / ) 07 Clip, Access Cover (/ 0) 77 0 Cover, Tailpipe Access 77 Insulation, Cylinder Head 79 Insulation, Muffler Box 0 0 Cover, Top (Includes Indented Parts Listed Below and Spark Plug Wire Clip) 9 Insulation 0 Insulation, Right Hand 0 Insulation, Left Hand 07 Insulation, Front 0 Nut, Insulation Push On 09 0 Sensor, Engine Temperature (Includes Parts Marked *) 0 097 Thermister 9 Terminal, Pin 7 0 Connector, Receptacle 0 Wedge, Receptacle * Parts Included in Engine Temperature Sensor. 9
Drip Pan 9 7 0 07 Screw, Hex Head Cap Thread Forming (/ x / ) 0 Washer, Flat (/) 000 Screw, Self Locking Hex Flange Head (/ 0 x / ) 0 0 Isolator, Vibration 0 Screw, Hex Head Thread Cutting (/ x / ) 000 Washer, EIT Lock (/ ) 7 7 Strap, Ground 00 Screw, Hex Head Cap Thread Forming (/ 0 x ) 9 000 Washer, EIT Lock (/ ) 0 0 0 Pan, Drip 7 Seal, Air Outlet 0
Exhaust System 7 9 0 0 9 7 77 Gasket, Exhaust Manifold 70 00 Washer, Flat (M) 70 Spacer, Washer 0 007 0 Screw, Socket Head (/ x ) 0 Manifold, Exhaust 9 0 Insulation, Exhaust Manifold 7 9 0 Insulation, Exhaust Manifold 70 00 Nut, Self Locking (/ x /) 9 0 Washer, Flat (Special) (/ ) 0 00 Bolt, Carriage (/ x / ) 00 Nut, Hex (/ ) Stainless Steel Tube, Exhaust 7 Gasket, Muffler (LP Use ) Muffler 07 Screw, Hex Washer Head Cap Thread Forming (/ 0 x / ) 00 Washer, Flat (/ ) 7 Support, Muffler Seal, Muffler Support 9 090 Screw, Hex Head Lock Flange Thread Form (/ x ) 0 00 070 Screw, Hex Head
Generator Adapter 7 9 0 0 0 Adapter, Generator 0 0 Rotor, Ignition 00 07 0 Screw, Hex Flange Head Cap (/ x ) 7 07 Plug, Spark (E, E) Cable, Spark Plug 7 0 9 7 0 0770 Screw, Self Locking Hex Washer Head Thread Forming (#0 x / ) 7 0 Capacitor (C) Nut, Hex Flange 0770 M Positive Terminal 077 M Negative Terminal 9 077 Bracket, Ignition Coil 0 090 Screw, Self Locking Hex Washer Head Thread Forming (/ 0 x / ) 00 Coil, Ignition (T) 70 0 Nut, Self Locking (#0 ) 079 Bracket, Ignition Control 0 Module, Ignition Control (S) 9 Clip, Wire
Generator 9 0 7 9 0 7 7 0 9
Generator 000 Nut, Hex (/ ) 0 0 Rotor, Generator (Includes Parts Marked *) 0 0 *Fan, Generator (Includes Ring Gear) 0 0 *Ring, Collector 0 0099 *Bearing, Ball 0 0 Screw, Socket (7/ x 0 7/ ) 7 70 0 Nut, ET Hex (0 ) 0 Screw, Hex Head Slot (0 x / ) 9 0 07 Charger, Battery (VR) 0 0 09 0 Bracket, Battery Charger 0 07 Grommet 0 Connector, Conduit 000 Screw, Lock Head Flange (0 x / ) 09 Housing, Push On Connector 09 09 O Ring Stator, Generator 0 09 0Hz 0 0 0Hz 7 090 Screw, Countersunk Torx Drive Thread Forming (/ x ) 9 0 Clamp, Stator 9 0 000 Washer, Spring Lock (/ ) 0 Screw 00 00 Hex Head Cap (/ x / ) 090 Thread Cutting 0 0 Housing, Generator Stator Cover, Brush Block Access Stud, Grounding (/ x / ) 000 Washer, EIT Lock (.) 70 07 Nut, Self Lock (/ ) Block, Generator Brush (Includes Parts Marked #) 7 #Block, Brush 00 #Brush, Generator 9 7 0 #Spring, Generator Brush 0 07 Screw, Pan Head Torx (#0 x 7/ ) Harness, Genset (Includes Wedge and Housing) Wedge, Plug ( Pin) Housing, Plug ( Pin) * Parts Included in Generator Rotor. # Parts Included in Generator Brush Block.
Control 0 9 0 9 7 7 00 7 0 Panel, Control (Includes Parts Marked *) 09 77 *Label, Warning 9 0 0 *Cover, Control Box 70 *Nut, ET ( ) 00 90 *Board, Control 09 77 *Label, Switch 7 0 07 *Switch, Rocker (S) 0 Screw, Hex Washer Head (/ 0 x / ) 9 09 77 *Label, Circuit Breaker 0 0 00 *Meter, Hour (TT) 0 0 Breaker, Circuit (CB, CB) Harness, AC Output Spec A, B 77 Begin Spec C 0 Screw, Hex Head Slot (0 x / ) 9 0 0 Bracket, Top Control Mounting 00 0 Screw, ET Pan Head Cross Recessed ( x / ) 9 07 0 Bracket, Bottom Control Mounting 7 00 Screw, Lock Head Flange (/ 0 x / ) 00 Washer, Flat (/ ) 9 9 07 0 Plate, Cover 0 0009 Screw, Hex Washer Head (/ 0 x / ) Block, Terminal (TB) 9 0 Terminal 9 0 Terminal 09 0 Screw, Pan Head (0 x / ) * Parts Included in Control Panel.
Wiring Harness 9 7 0 7 Harness, Engine (Includes Parts Marked *) Spec A, B 7 Begin Spec C 9 *Housing, Tab Terminal 07 *Relay *Connector, Plug ( Pin) *Wedge, Plug ( Pin) 0 9 0 *Breaker, Circuit (CB) 7 9 *Plug, Seal 09 *Housing, Receptacle 9 70 0 *Nut, ET Hex (#0 ) 0 0 *Holder, Fuse (Includes Fuse) 007 0 Fuse, 7.A (F, F) 0 *Connector, Plug ( Pin) 00 *Wedge, Plug ( Pin) 0 Harness, 7 Starter Harness, 7 Starter (Includes Boot) Boot 0 0 Spec A, B 0 Begin Spec C 7 Harness, Battery Charger (Includes Housing) Spec A, B 7 Begin Spec C 9 Housing * Parts Included in Engine Harness. 7
Housing 7 9 7 0 0 9 9
Housing 0 07 0 Base, Housing 0 09 0 Housing 0 Clip, Circular 00 07 0 Bolt, Hex Head Security (/ ) 0 0 0 Pin, Snap 0 0 0 Pin, Snap 7 0 07 0 Bracket, Locking 0 07 Spring, Clip 9 0 00 Spring, Gas 0 0 Box, Battery (Includes Hold Down Strap) 009 Washer, Flat (/ ) 00 00 Screw, Hex Head Cap (/ x.) 00 000 Screw, Hex Head Cap (/ x ) 0 000 Washer, Lock (/ ) 0 070 Guide, Base 00 0 Screw, Hex Head Sems 7 07 90 Switch, Actuator 07 907 Switch, Magnet Switchgear Housing Mounting Hardware: 9 009 Washer, Flat (/ ) 0 00 000 Screw, Hex Head Cap (/ x ) 0 000 Washer, Lock (/ ) 000 Nut (/ ) NOTE: See Parts Catalog 9 00 for Transfer Switch Information. 9
Labels, Paint, Thread Sealant, Kits 9 0 Label, Battery Negative 9 7 Label, Caution 9 9 Label, Caution 9 9 0 Label, Caution 9 70 Label, Caution (Unit Clearance) 9 7 Label, Caution (No Step) 9 7 Label, Caution (Lifting) 9 7 Label, Dual Fuel 9 770 Label, Stripe 9 9 0 Label, Warning 9 7 Label, Warning 9 90 Label, Warning 0 0 Kit, Oil Pump Gasket Kit, Gasket 090 Valve Grind 09 Engine 07 Loctite, Bottle (0cc) 09 Paint, Enamel Touch Up Black (Flat) oz. Pressurized Can 0 Sealant, Thread (0cc Bottle) 0
Numerical Index Part No. Page Part No. Page Part No. Page Part No. Page 09 90, 0 09 9 0, 0 09 9 0, 0 09 7, 0 09 0, 0 09 9, 0 09 70, 0 09 7, 0 09 7, 0 09 7, 0 09 770, 0 09 77, 09 77, 09 77, 0 00, 0 09, 0 00, 0 00 0, 0 00 0, 0 00 0, 0 00 0, 0 009, 0 7, 0 0 7 0, 0 0 00, 0 0, 0 00, 7 0 00, 7 0 009, 0 070, 0 07, 0 077, 0 077 0, 0 7, 7 0 00, 0 009, 0 0, 0 0, 0 07, 0 09, 0 09, 0 090, 0 0, 0 7, 0 79, 0 97, 0 7, 0, 0, 0 0, 0 0, 0 0, 0 0, 0 9, 0 7, 0 0, 0, 0 0, 0 0, 0 0, 0, 0, 0 0, 0 0, 0 0, 0 0, 07, 0, 0, 0 0, 0 0, 0 0, 0 0, 00, 0, 0 0, 0 0, 0 0, 0 0, 00, 000, 000 0, 000 0, 0 00, 0 0, 0 0 09, 0 09, 0 0, 00, 9 09, 9 077, 9 0, 9 09, 9 7, 7,, 0,, 7, 09, 0 09, 097, 09,, 7, 0 7, 9 7, 9 79 00, 9 77 0, 9 77, 9 790 0, 9 79 0, 9 0, 9 0, 9 07, 9 9, 9 9, 9 9 0, 9 0, 9, 9 99, 9 0, 9 0, 9 9 0, 9 0, 0 0, 9, 9, 0 0, 0 79, 0 9, 0 09 00, 0 09 0, 09, 07, 07, 00, 0, 9, 0, 0, 0, 070, 9, 77, 7, 70, 0, 07,,,,, 077, 0770, 077, 079, 00, 0, 0 0,
Numerical Index Part No. Page Part No. Page Part No. Page Part No. Page 7 07, 7 0, 7 0, 090, 0 09, 0 9 7, 7 9 9, 7 9 97, 7 9 99 09,, 7 9 9, 7 9 9, 7 9 9, 7 9 9, 7 9 9, 7 0 0, 0 0, 0 0, 0 09, 7 0,,,, 00, 0 09, 0 0, 0 0, 0 0, 9 0, 00 7 0, 00 90, 0 00, 0 07, 0 09 0, 0 097, 9 07,, 7 07 0, 07 907, 9 07 90, 9 0 07, 09 0, 9 09 0, 0 09 0, 9 0, 9 0 0, 9 0 0, 9 07 0, 9 07 0, 0 0, 0 9 0, 7 007 0, 7 007 0, 0, 0, 7 9, 9 00, 7 0, 9 0, 7 0, 9,,, 7, 7 9, 7 0, 09,, 7 9, 7 9 0, 9 0, 9,, 7, 0, 7, 7, 7, 0, 7, 00, 77, 7, 7 7, 7 0 0, 0 0 07 0, 9 0 07, 9 0 070, 9 0 07 0, 9 0 0, 0 0 09 0, 9 0 00, 9 0 0 0, 9 0 0 0, 9 0 0, 7 0, 9 0, 7 0 0, 0 0, 0 09, 0 0, 0 09, 0 0, 0 07, 0, 0 7, 0 0, 0 0, 0 00, 0 0 00, 0 0, 0 07, 0 07, 09 000, 09 00, 7 09 09, 09 0, 0 0 0099, 000,, 7 009, 00, 007, 0,, 7 00 0, 7 007, 7 09, 00, 7 07, 0 0, 0 0, 9 07, 9 0, 9 0, 9 0 07, 0 09, 0 099, 09, 0 007, 00,,, 00, 009, 9 00, 00, 9, 00, 0,, 00, 0, 0, 0, 0 0, 00, 70 00, 70 00, 70 00,, 7 00 0007, 00 00, 00 00, 00 007, 00 00 0, 9 00 00 0, 00 00 0, 00 000, 9 00 00, 9 00 00 0,
Numerical Index Part No. Page Part No. Page Part No. Page Part No. Page 00 00, 00 00 0, 0 00 00, 00 00 0, 00 0, 00 07 0, 00 070, 00 07 0, 9 0 000, 0 007 0, 0 0, 0 000, 0, 0, 0 0, 9 090,, 07, 00, 9 00, 9 00 0, 07, 090, 00, 0 0, 07, 0 0, 09 0, 0770, 07 0, 07 0, 07, 0, 9, 090, 090, 00, 000, 9 000, 000, 0009, 000,, 0 00, 0, 00 0, 9 0 000,,, 9 0 00,, 7 009, 000, 0 000, 0, 000,,, 9 00, 00, 70 00, 70 0,, 7 70 0, 70 07, 70 0, 70, 9 7, 0
Onan Corporation 00 7rd Avenue N.E. Minneapolis, MN -00--ONAN -7-000 International Use Telex: 777 Fax: -7-07 Onan is a registered trademark of Onan Corporation