More time on the road Illustrated s List RTO-670C-AS November 0
Contents How To Use The Illustrated s List... 3 AFTERMARKET TRANSMISSIONS... 4 AUXILIARY DRIVE GEAR... 5 CASE (AUX)... 6 CASE (FRONT)... 8 CONTROLLER ECU & HARNESS... COUNTERSHAFT & BRGS(AUX)... 3 COUNTERSHAFT ASSY... 4 FILTER REGULATOR... 6 GEAR DISPLAY MODULE... 7 INPUT SHAFT & DRIVE GEAR... 8 INTEGRAL OIL PUMP... 9 KITS & ASSEMBLIES... MAINSHAFT & SYNCHRO(AUX)... 3 MAINSHAFT ASSY... 5 MISCELLANEOUS... 7 OIL COOLER... 8 RANGE CYLINDER... 30 REVERSE IDLER... 3 SHIFT BAR HOUSING... 34 SHIFT CONTROLS... 37 X-Y SHIFTER MODULE... 39
How To Use The Illustrated s List The information contained in this document is subject to frequent updates. Therefore, for the latest information available, please visit the interactive Electronic s Catalog at www.roadranger.com/epc. Model Designation or Nomenclature For information regarding Model Designation and Nomenclature, visit www.roadranger.com. Kits and Assemblies (K/A's) Kits and Assemblies contain groups of individual or assembled parts developed for optimal replacement or repair of a service problem. Kits and Assemblies are shown with applicable parts groupings in the parts listings. Identifying Kits and Assemblies A- numbers beginning with the letter 'A' are pre-assembled Production Assemblies K- numbers beginning with the letter 'K' are kits that are not assembled S- numbers beginning with the letter 'S' are pre-assembled Service Assemblies Note: Some Production Assemblies do not begin with a letter prefix (Midrange only). Illustrations Illustrations show parts in assembly groups. numbers on illustrations correspond with parts listings on pages adjacent to the illustration. Notes are included on illustrations where additional information is needed. s Listing s listings are defined by parts groupings and are broken down by service assemblies. s listings identify a part for servicing with the following categories Number - corresponding with numbers on illlustrations for part identification. - indentifies part as it is available for service. Description - specifies part name or description. Replaced - quantity quantity required for assembly. Quantity - defines unique characteristics or requirements. Notes - indicates Kits or Assemblies that contain a particular part. Kits/Assy's Where Used 3
Group: AFTERMARKET TRANSMISSIONS Automated Transmission AFTMKT 09A- Generic Illustration - Not specific to part numbers listed below AFTERMARKET TRANSMISSIONS TB-F55- R TB-F55- RDS RTO-670C-AS REMAN TRANS RTO-670C-AS REMAN TRANS WITH INTERNAL PUMP DEALER STOCK - 4 DAY LEAD- TIME - WITH INTERNAL PUMP 4
Group: AUXILIARY DRIVE GEAR 5 7 4 3 6 0480-/9 Aux DG AUXILIARY DRIVE GEAR 6763 SNAP RING K-3486,K-3487 30 SNAP RING RETAINER K-3486,K-3487 3 668 SNAP RING 4 5566507- BOX BEARING 5566504,5566507 K-3486,K-3487 5 638 BEARING RETAINER 6 X-8-645 CAPSCREW X 8 6 6 3/8"-6X" 7 359 AUXILIARY DRIVE GEAR 3 5
Group: CASE (AUX) OEM supplied adjustable speedometer sensor (Threaded) OEM supplied non-adjustable speedometer sensor (Non-Threaded) 6 5 6 8 3 4 0 7 9 7 5 3 4 404-0-0 CASE (AUX) 4335 GASKET K-3485,S-96 900 REAR HOUSING 3 X-8L-60 CAPSCREW 6 3/8"-6X-/" 3 X-8L-64 CAPSCREW 3/8"-6X" 3 X-8L-66 CAPSCREW X 8 66 3/8"-6X-3/4" 4 364 GASKET K-6,K-3485,S- 99 5 S-99 REAR BRG COVER ASSY 430036 6 X-8C-409 CAPSCREW /4"-0X5/8" 7 X-8L-63 CAPSCREW X 8 63 6 3/8"-6X3-/" 8 44 -O- RING S-99,S-905 9 04 PLUG-MAGNETIC S-99,S-96 0 K-6 OIL SEAL W/SLINGER 909 0807 0808 "FOR MECHANICAL COVER" K-3486,K-3487 6
K-805 SHIM KIT 45 K - 06 K-3486,K-3487,S- 96 4305978 GASKET 43046 K-3485,S-96 3 43030 COVER 346 S-96 4 085 LIFTING EYE 705 5 X-8L-600 CAPSCREW 8 3/8"-6X" 6 K-33 SPEED SENSOR KIT A - 6398,A - 674 SINGLE PICK-UP ( PIN) 6 K-3455 SPEED SENSOR KIT, DUAL A - 7046,A - 758 DUAL PICK-UP (4 PIN) 7 430954 SENSOR SEAL S-99 7
Group: CASE (FRONT) 7 8 9 30 3 36 37 38 4 3 4 40 Latest Design 0 5 * 8 9 7 39 8 0 7 8 * 9 4 5 6 3 0305B-0-0 6 5 4 3 9 * Bushing quantity requirements: # Housing Upper bore use 4 #85 / Lower bore use #8677. # Housing Upper bore use #85 and #8677 / Lower bore use #8677. Note: Some part requirements are specific to # or # Aluminum or Iron Clutch Housings and Push or Pull type Clutch. CASE (FRONT) S-998 CASE ASSY 4308,4305765,S - 075 FOR USE W/INTEGRAL PUMP X--007 PIPE PLUG X 006 3 X--07 PIPE PLUG X 0,X 06 3/4" MAGNETIC 4 430530 GASKET 43080 K-3485 5 430809 PTO COVER 6596,430057 6 X-8-75 CAPSCREW X 8 74 8 7/6"-4X7/8" 7 4306584 CLUTCH HOUSING GASKET 430485,4305668 K-3485 8 A-373 CLUTCH HOUSING ASSY A - 3700 # PUSH-PULL IRON 8 A-373 CLUTCH HOUSING ASSY A - 37,A - 37 # PUSH-PULL IRON 8 A-477 CLUTCH HOUSING ASSY A - 4344,A - 477 # PUSH-PULL ALUM. 8
8 A-6064 CLUTCH HOUSING ASSY A - 434,A - 4770,A - 606,A - 6063,A - 6065 # PUSH-PULL ALUM. 9 3964 SCREW X-8L-509 4 5/6-8X.8 QUANTITY DEPENDENT ON DESIGN 0 4506 HAND HOLE COVER # PUSH 0 4507 HAND HOLE COVER # PULL 0 430530 HAND HOLE COVER 453 # PULL 0 43053 HAND HOLE COVER 565 # PUSH 4306583 STUD 5966 6 X-0-005 WASHER X 3 000,X0 000,X0 004 6.3 X 6.60 3 X--0 HEX NUT 6.65-8 4 0550 FRONT BRG COVER " PULL K-468,K-45 5 X-8L-604 CAPSCREW 6 3/8"-6X-/4" 6 0549 FRONT BRG COVER " PUSH 7 43 GASKET K-3485 8 85 BUSHING FOR # HOUSING UPPER A-373,A-373,A- 477,A-6064,K-468 8 85 BUSHING 4 FOR # HOUSING UPPER A-373,A-373,A- 477,A-6064,K-468 8 8677 BUSHING FOR # HOUSING UPPER A-373,A-373,A- 477,A-6064 9 8677 BUSHING FOR # AND # HOUSING LOWER A-373,A-373,A- 477,A-6064 0 X-8C-830 HEX HEAD SCREW/WASHER ASSY 0 X-8C-83 HEX HEAD SCREW/WASHER ASSY X-8C-86 4.500-3 X.490, USE PCS FOR IRON HOUSING, USE 4 PCS FOR ALUMINUM HOUSING X-8C-8.500-3 X 3.460, FOR IRON HOUSING 430403 PLUG 4303747 -/6" MAGNETIC, O-RING INCLUDED S-998 X-8-686 CAPSCREW 6 3/8"-6X3/4" 3 4575 PTO COVER 43054 4 4305309 GASKET 684 K-3485 7 4373 MAGNET 3 S-998 8 88 PIN 9 X--0 HEX NUT.65-8 9
30 X-0-005 WASHER X 3 000,X0 000,X0 004.3 X 6.60 3 4554 STUD 63,6579 5/8" X -3/6" 36 304 PLUG 7 37 X-8-005 CAPSCREW 5/8"-X-/4" 38 084 SPACER 39 X--80 PIPE PLUG X 800 /" 40 X--07 PIPE PLUG X 0,X 06 3/4" MAGNETIC 4 69447 PIN S-998 0
Group: CONTROLLER ECU & HARNESS 0 9 Range Solenoid A Shift Bar Housing Speed Sensor B Shift Bar Housing Speed Sensor Splitter Solenoid (8 Speeds Only) Blank Rear Bearing Cover 3 5 3 4 3 4 8 7 3 6 039-03-0
CONTROLLER ECU & HARNESS 4307036 BRACKET 43030 3 5559348 TY-RAP 8 K-368,K-48 3 430367 MOUNTING PAD 4 4 430378 DOWEL PIN S-905 5 K-3443RX REMAN EXCHANGE TRANSMISSION CONTROLLER KIT K-3443, K-3443R 6 430369 SLEEVE 7 4304 WASHER 8 X-8-55 SCREW 5/6"-8X-/" 9 K-368 RANGE/SPLITTER VALVE KIT 55680,556804,K - 907 0 K-908 -O- RING KIT FOR SOLENOID VALVE X-8-64 HEX FLANGE HEAD SCREW X 8 59 4 #0-4 X /4 X-3-30 LOCKWASHER 4 #0 PLAIN 3 K-48 TRANSMISSION HARNESS KIT 69664,K-357
Group: COUNTERSHAFT & BRGS(AUX) 3 0440-/9 Aux CS Helical COUNTERSHAFT & BRGS(AUX) 430074- BOX BEARING 343,430074 4 K-3486,K-3487 A-6339 WELDED COUNTERSHAFT ASSY A - 6073 C/S 43009 - D/G 360 3 903 SPACER 3
Group: COUNTERSHAFT ASSY 3 5 5 4 9 8 7 0 6 5 4 3 034-/9 CS/RT COUNTERSHAFT ASSY 437 SNAP RING K-3486,K-3487 4366 BEARING K-3486,K-3487 3 K-94 CNTRSHFT-W/REV & ST 4304,4305 4 X-6-E KEY 5 65 ROLL PIN 4 6 4304840 KEY 9673 7 038 ND GEAR-CNTRSHFT 969,43003,43035 8 64 3RD GEAR-CNTRSHFT 963 9 43009 OD GEAR-CNTRSHFT 430507 0 5953 PTO GEAR - LOWER 0 0840 PTO GEAR - UPPER 595 4305665 DRIVE GEAR-CNTRSHFT 08,4305069 998 SNAP RING 3 4304599 BEARING 430677 4304598 K-3486,K-3487 4
4 4304605 RETAINER 9548 ROLL PIN NO LONGER REQUIRED 5 X-7-005 CAPSCREW 5/8"-8X-3/4" 5
Group: FILTER REGULATOR NSS -O- Ring/Element Kit 3 5 5 03--93 AFR/AS 5 4 NSS - Not Sold Separately FILTER REGULATOR K-70 FILTER REG KIT A - 5454 K-698 -O- RING/ELEMENT KIT FOR FILTER REGULATOR 3 X-8C-4 CAPSCREW X 8S 4 /4"-0X-/4" 4 54 -O- RING K-70,K-3365,K- 3484 5 X--08 PIPE PLUG 3 /8" NPT 6
Group: GEAR DISPLAY MODULE 3037-03-0 GEAR DISPLAY MODULE K-399 DRIVER DISPLAY MODULE 430640 7
Group: INPUT SHAFT & DRIVE GEAR 9 6 8 3 4 5 * * 0370-/9 IS * For Shipping Only -- Do Not Replace INPUT SHAFT & DRIVE GEAR 3559 SEAL NOT SOLD FOR SERVICE 6980 SNAP RING K-468,K-3486,K- 45 3 8504 BEARING K-468,K-3486,K- 3487,K-45 4 6463 SPACER 5 4750 SNAP RING K-468,K-3486,K- 3487,K-45 6 430590 MAIN DRIVE GEAR 430038, 4305068 8 S-659 INPUT SHAFT 0535 3566 43066 " PULL - USE W/FBC 0550 K-468,K-3486,K- 45 8 S-660 INPUT SHAFT 0536,3567 " PUSH - USE W/FBC 0549 9 6566 BUSHING K-3487,S-659,S- 660 8
Group: INTEGRAL OIL PUMP Indicates part of item 999 3 9 5 4 7 6 9 8 6 6 0 7 8 3 059--97 4 5 INTEGRAL OIL PUMP X-8C-409 CAPSCREW 5 /4"-0X5/8" K-40 COVER & SCREW KIT 053,430075 3 054 GASKET K-40 4 083 PLUG 5 4765 -O- RING K-3484 6 K-46 FASTENER KIT 084, X-8-448 KIT CONTAINS 3 FASTENERS AND 3 WASHERS K-3367 8 085 DOWEL PIN 9
9 4303773 RETAINER 0 K-3367 OIL PUMP KIT 43089,430948,4303776,430459,430457 A - 6963,A - 773 K-3367 OIL PUMP KIT 43089,430948,4303776,430459,430457 A - 6963,A - 773 0509 KEY 3 4853 SNAP RING 4 4303774 PUMP DRIVE GEAR 4304880 5 K-3367 OIL PUMP KIT 43089,430948,4303776,430459,430457 A - 6963,A - 773 6 X-4-700 STEEL BALL 7/6" 7 4303775 SPRING 8 430573 SUCTION TUBE 430468 O-RING INCLUDED ON SUCTION TUBE K-3367 9 430469 PLUG 6 X-8-447 SCREW 7 05 -O- RING 999 K-3367 OIL PUMP KIT 43089,430948,4303776,430459,430457 A - 6963,A - 773 0
KITS & ASSEMBLIES K-698 -O- RING/ELEMENT KIT FOR FILTER REGULATOR K-956 COOLER INSTLN KIT K-70 FILTER REG KIT A - 5454 K-6 OIL SEAL W/SLINGER 909 0807 0808 "FOR MECHANICAL COVER" K-3486,K-3487 K-40 COVER & SCREW KIT 053,430075 K-468 CLUTCH INSTALLATION KIT FOR USE WITH S-659 INPUT SHAFT ASSY AND 8504 INPUT SHAFT BEARING K-805 SHIM KIT 45 K - 06 K-3486,K-3487,S- 96 K-908 -O- RING KIT FOR SOLENOID VALVE K-94 COUNTERSHAFT REPL KIT 4304,4305 K-33 SPEED SENSOR KIT A - 6398,A - 674 SINGLE PICK-UP ( PIN) K-3365 RANGE CYL COVER KIT 6944 K-3367 OIL PUMP KIT 43089,430948,4303776,430459,430457 A - 6963,A - 773 K-3436 XY SHIFTER KIT 6938,A - 7034 K-3438 POSITION SENSOR KIT 6955,6996 K-3443RX REMAN EXCHANGE TRANSMISSION CONTROLLER KIT K-3443, K-3443R K-3455 SPEED SENSOR KIT, DUAL A - 7046,A - 758 DUAL PICK-UP (4 PIN) K-3484 O-RING KIT - RANGE K-3486,K-3487 K-3485 GASKET KIT K-3486,K-3487 K-3486 BASIC OVERHAUL KIT K-3487 BASIC REBUILD KIT K-349 SYNCHRONIZER KIT K - 446 K-3494 SYNCHRONIZER REPLACEMENT KIT K - 448 SLIDING CLUTCH INCLUDED IN KIT K-365 OIL SEAL TOOL KIT K-368 RANGE/SPLITTER VALVE KIT 55680,556804,K - 907
K-3979 SPACER KIT INCLUDES (4) SPACER MOUNTING SCREWS K-3980 COBRA SHIFT LEVER KIT (RHO) K-3997 COBRA SHIFT LEVER KIT (RHO) W/MACK SWING ARM K-48 TRANSMISSION HARNESS KIT K-45 CLUTCH INSTALLATION KIT (RT), HYDRAULIC RELEASE K-3680 (LEFT HAND DRIVE), ALSO KNOWN AS (RHO) RIGHT HAND OPERATION A - 78,K-3680 (LEFT HAND DRIVE), ALSO KNOWN AS (RHO) RIGHT HAND OPERATION - FOR UNITS USING THE MACK 0MY559M SWING ARM BRACKET 69664,K-357 STANDARD RT INPUT SHAFT AND YOKE FOR HYDRAULIC CLUTCH RELEASE S-404 OIL FILTER 738 S-659 INPUT SHAFT 0535 3566 43066 " PULL - USE W/FBC 0550 K-468,K-3486,K- 45 S-660 INPUT SHAFT 0536,3567 " PUSH - USE W/FBC 0549 S-99 REAR BRG COVER ASSY 430036 S-688 MAINSHAFT ASSY 4303404,430393 S-905 SHIFT BAR HOUSING ASSY S-95 SHIFT BAR HOUSING ASSY 6953 COMPLETE 6953 HOUSING ONLY (DOES NOT INCLUDE SPEED SENSORS) S-96 RANGE SECTION ASSY "C" RATIO S-989RX S-990RX PUSHBUTTON ASSY, REMAN PUSHBUTTON ASSY, REMAN S - 985,S-989 S-990 FOR USE WITH REMOTE LEVER S-998 CASE ASSY 4308,4305765,S - 075 FOR USE W/INTEGRAL PUMP
Group: MAINSHAFT & SYNCHRO(AUX) 8 7 3 4 5 4 Universal Joint Yoke 3 0 04--93 MAINSHAFT & SYNCHRO(AUX) 4897 SPRING 3 K-3486,K-3487,K- 349,K-3494 A-733 SYNCHRONIZER ASSY 4304396 4304397 A - 597 HI RANGE K-349,K-3494 3 033 SLIDING CLUTCH K-3494 4 A-754 SYNCHRONIZER ASSEMBLY A - 4937 A - 5876 LO RANGE K-349,K-3494 5 43003 AUXILIARY MAINSHAFT 970 7 899 WASHER 8 430090 REDUCTION GEAR 4307 0 898 SPACER 356- BOX BEARING 356 K-3486,K-3487 969 SPACER 3
3 09 ROTOR 4 54 NUT 956 S-96 4
Group: MAINSHAFT ASSY 4 9 5 4 7 4 0 9 8 4 7 3 6 5 4 3 0337B-0-96 MAINSHAFT ASSY S-688 MAINSHAFT ASSY 4303404,430393 6504 ROLL PIN S-688 3 430464 3-SIDED KEY 4300890 4 4750 SNAP RING K-468,K-3486,K- 3487,K-45 5 430 REVERSE GEAR- MAINSHAFT 6 4749 SPACER 7 4305997 SLIDING CLUTCH 430407 8 4303497 ST GEAR-MAINSHAFT 4303498 9 4303603 WASHER 430397 0 430350 ND GEAR-MAINSHAFT 430396 3RD GEAR-MAINSHAFT 430393 OD GEAR-MAINSHAFT 4305070 5
3 4300830 WASHER.44-BLUE 4 430398 WASHER 4 5 4305996 SLIDING CLUTCH 699 K-3486 6
MISCELLANEOUS 558660 SHIFT DIAGRAM LABEL 703 SILICONE LUBE 8 OZ (36.59 CC)-FLEET SIZE 704 ADHESIVE SEALANT 0.5 CC (SINGLE APPLICATION SIZE) 705 SEALANT CC (SINGLE APPLICATION SIZE) K-3486 706 SILICONE LUBE 4 CC (SINGLE APPLICATION SIZE) K-3484 7
Group: OIL COOLER 6 7 Flow 7 6 3 4 5 8 9 3 7 6 Oil Return 6 7 0 3 Oil Pump Outlet *3 *6 Outlet *4 Fuller 737 *6 Inlet *5 Return Outlet 055-4/9 Cooler *Adding Oil Filter and parts as shown is optional. Return / Outlet Location OIL COOLER 805 OIL COOLER K-956 944 HOSE 5 FEET K-956 3 X-8-535 CAPSCREW 5/6"-6X-/" 4 X-3-506 LOCKWASHER 5/6" 5 8 BRACKET 4 K-956 6 949 CONNECTOR 6 K-956,S-404 7 945 SWIVEL 4 K-956 8 X-0-50 WASHER 5/6" 9 809 PLUG-RUBBER MOUNT K-956 0 790 STRAP 8 K-956 943 CLAMP 5 K-956 80 NUT K-956 8
3 94 ELBOW 4 K-956 4 S-404 OIL FILTER 738 5 737 FILTER ELEMENT S-404 9
Group: RANGE CYLINDER Solenoid Valve 6 8 7 3 4 5 6 7 8 5 0 3 5 9 5 0539-03-0 RANGE CYLINDER A-5474 SHIFT YOKE ASSY 4347 GASKET K-3484,K-3485 3 69348 RANGE CYLINDER 4 4765 -O- RING K-3484 5 434 PISTON 3353 6 4345 -O- RING K-3484 7 4344 -O- RING K-3484 8 X--00 NUT 5/8"-8 9 69955 GASKET 69440 K-3365,K-3484,K- 3485 0 K-3365 RANGE CYL COVER KIT 6944 X-8-647 CAPSCREW 3/8"-6X4-3/4" X-8L-605 CAPSCREW 3/8"-6X3" 3 X-3-600 LOCKWASHER 3/8" 30
5 X--08 PIPE PLUG 3 /8" NPT 6 K-908 -O- RING KIT FOR SOLENOID VALVE 7 X-8-64 HEX FLANGE HEAD SCREW X 8 59 4 #0-4 X /4 8 K-368 RANGE/SPLITTER VALVE KIT 55680,556804,K - 907 3
Group: REVERSE IDLER 5 3 9 8 3 4 8 Latest Design 5 3 6 7 3 4 38-3-97 RI REVERSE IDLER X-7-008 CAPSCREW 5/8"-8X-/4 483 WASHER 3 43098 WASHER 48 4 K-309,S-998 4 487 BEARING 430500 K-3486,K-3487 5 4309 REVERSE IDLER GEAR 6 K-309 IDLER SHAFT REPL KIT 6405,43098,430553 7 4303336 RETAINING RING K-309 8 4303336 RETAINING RING 4 K-309 9 430553 IDLER SHAFT K-309 3
33
Group: SHIFT BAR HOUSING 34 3 4 9 0 9 0 37 8 38 7 36 34 35 6 5 5 6 7 35 36 8 7 4 5 8 0 6 999 3 33 6 4 5 6 3 7 4 8 6 3 6 30 6 9 035-03-0 SHIFT BAR HOUSING 34
S-95 SHIFT BAR HOUSING ASSY 6953 HOUSING ONLY (DOES NOT INCLUDE SPEED SENSORS) 430676 GASKET 498 K-3485,S-905,S- 95 4 0070 OIL TROUGH S-905 5 033 AIR VALVE SHAFT 777 S-905 6 X-8-43 CAPSCREW /4"-0X/" 7 X--603 PIPE PLUG X 60 3/8" NPT 8 430378 DOWEL PIN S-905 0 966 PLUNGER 43037 SPRING 779 GASKET S-905,S-95 3 4303655 PLUG 778 S-905,S-95 4 94 NEUTRAL LIGHT SWITCH 639 SWITCH NORMALLY CLOSED 5 085 LIFTING EYE 705 6 X-8L-60 CAPSCREW 3/8"-6X-/" 6 X-8L-604 CAPSCREW 6 3/8"-6X-/4"- OR USE 4 PCS OF X-8L-604 WITH PCS OF X-8L-60 7 5899 PIN 8 5900 GASKET S-905,S-95 9 940 REVERSE LIGHT SWITCH 6830 SWITCH NORMALLY OPEN 0 4303656 PLUG 597 S-905,S-95 6966 COMPRESSION SPRING 3 S-905 X-4-800 STEEL BALL 3 /" 3 697 SHIFT YOKE 430376 REVERSE/ST S-905 4 X-4-00 STEEL BALL 3/4" 5 4658 SHIFT BLOCK ND/3RD S-905 6 30 LOCKSCREW 5 S-905 7 634 INTERLOCK PIN S-905 8 4659 SHIFT BLOCK 4TH/5TH S-905 9 6960 SHIFT YOKE 430 4TH/5TH S-905 30 430366 YOKE BAR 4TH/5TH S-905 3 69600 SHIFT YOKE 430994 ND/3RD S-905 35
3 430365 YOKE BAR ND/3RD S-905 33 430364 YOKE BAR REVERSE/ST S-905 34 K-33 SPEED SENSOR KIT A - 6398,A - 674 SINGLE PICK-UP ( PIN) 35 44 -O- RING S-99,S-905 36 X-8C-409 CAPSCREW /4"-0X5/8" 37 4303656 PLUG 597 3 S-905,S-95 38 5900 GASKET 3 S-905,S-95 999 S-905 SHIFT BAR HOUSING ASSY 6953 COMPLETE 36
Group: SHIFT CONTROLS VOLUME CONTROL R 3 5 N SERVICE D 4 MANUAL SHIFT LOW EATON FULLER TRANSMISSIONS PUSHBUTTON ASSEMBLY COBRA LEVER - only for use with 0MY559M Mack Swing Arm Bracket 7 6 Indicates part of 5 009-06-09 COBRA LEVER - Latest Design - for all applications with the exception of units using the 0MY559M Mack Swing Arm Bracket (see illustration to the left) SHIFT CONTROLS S-989RX PUSHBUTTON ASSY, REMAN S-990RX PUSHBUTTON ASSY, REMAN K-3997 COBRA SHIFT LEVER KIT (RHO) W/MACK SWING ARM 3 5505 SHIFT LEVER KNOB DECAL 4 55050 SHIFT LEVER POSITION STRIP 5 K-3980 COBRA SHIFT LEVER KIT (RHO) S - 985,S-989 S-990 FOR USE WITH REMOTE LEVER 4305447,K-3680 (LEFT HAND DRIVE), ALSO KNOWN AS (RHO) RIGHT HAND OPERATION - FOR UNITS USING THE MACK 0MY559M SWING ARM BRACKET K-3680 (LEFT HAND DRIVE), ALSO KNOWN AS (RHO) RIGHT HAND 37
OPERATION 6 A-798 JUMPER HARNESS ASSY 7 K-3979 SPACER KIT INCLUDES (4) SPACER MOUNTING SCREWS 38
Group: X-Y SHIFTER MODULE s not included in 999 3 999 4 5 6 XY Shifter Repair Kit 09-03-0 X-Y SHIFTER MODULE 430545 GASKET 430958 K-3436,K-4009 X-8C-65 CAPSCREW 4 3 430460 BREATHER 3605 /4" NPT 4 5559348 TY-RAP K-368,K-48 5 K-3438 POSITION SENSOR KIT 6955,6996 6 K-4009 XY SHIFTER REPAIR KIT 999 K-3436 XY SHIFTER KIT 6938,A - 7034 39
40
4