DS ommercial - 5 Ton Packaged Air onditioner 4 SEE / Up to.0 EE ooling apacity: 5,000 58,000 BTU/h ontents Nomenclature... Product Specifications... 4 Expanded ooling Data... 7 Airflow Data... rankercase Heater... Heat Kit Electrical Data... Dimensions... 6 Wiring Diagrams... 0 for Models with DD ontrols... 5 Accessories... 4 Standard Features High-efficiency scroll compressor opper tube/aluminum fin coils High- and low-pressure switches ontactor with lugs High-capacity, steel-cased filter drier Heater kits with single-point entry 4-volt terminal strip onvertible airflow orientation Easy to service Built-in filter rack with standard " filters Bottom utility entry AHI ertified; ETL Listed -5 Tons with single speed blower motor units meet the performance specified in Table 6.8.- of ASHAE Standard 90.-0 abinet Features Heavy-gauge, galvanized-steel cabinet with UV-resistant powder-paint finish Full Perimeter ail Sloped drain pan * omplete warranty details available from your local distributor or manufacturer s representative or at www.daikincomfort.com. SS-DS www.daikinac.com 4/7 Supersedes /7
Nomenclature D S 060 00 B * * * A * 4,5,6 7,8,9 0 4 5 6 evision Levels Major & Minor Brand Factory-Installed Options D Daikin X No Options A Non-powered convenience outlet onfiguration B Powered convenience outlet Standard Efficiency (6-5 Tons) Low-ambient kit S Standard Efficiency ( - 5 Tons) D eturn air smoke detector T High Efficiency ( - 5 Tons) E Supply air smoke detector F Non-powered convenience outlet; Application Low-ambient kit ooling G Non-powered convenience outlet; G Gas Heat eturn air smoke detector H Heat Pump H Non-powered convenience outlet; Supply air smoke detector Nominal ooling apacity J Non-powered convenience outlet; 06 Tons 0 8½ Tons 00 5 Tons eturn & Supply air smoke detectors 048 4 Tons 0 0 Tons K Non-powered convenience outlet; 060 5 Tons 50 ½ tons Low-ambient kit; Supply air smoke detector 07 6 Tons 80 5 Tons L Non-powered convenience outlet; 090 7½ Tons 40 0 Tons Low-ambient kit eturn & Supply air smoke detectors Nominal Heating apacity M Powered convenience outlet; Gas/Electric A/ H/P Factory-Installed Electric Heat Low-ambient kit 045 45,000 BTU/h XXXNo Heat N Powered convenience outlet; 090 90,000 BTU/h 000 kw 00 0 kw eturn air smoke detector 5 5,000 BTU/h 055 kw 0 0 kw O Powered convenience outlet; 40 40,000 BTU/h 065 kw 045 45 kw eturn & Supply air smoke detectors 0 0,000 BTU/h 088 kw 046 45 kw P Powered convenience outlet; 50 50,000 BTU/h 000 kw 060 60 kw Supply air smoke detector 400 400,000 BTU/h 055 kw Q Powered convenience outlet; Low-ambient See product specifications for heat size(s) available for each capacity. kit; eturn air smoke detector Powered convenience outlet; Low-ambient Voltage kit; Supply air smoke detector 08-0//60 4 460//60 T Powered convenience outlet; Low-ambient 08-0//60 7 575//60 kit; eturn & Supply air smoke detectors U Non-powered convenience outlet; Supply Fan/Drive Type/Motor Low-ambient kit; eturn air smoke detector B Belt Drive (single speed) V Two-Speed Belt Drive (also designates 6-Ton V Low-ambient kit; eturn air smoke detector D Direct Drive (-5 Tons) with two-stage compressor) W Low-ambient kit; Supply air smoke detector H High Static (single-speed Belt Drive models only) Y Low-ambient kit; eturn & Supply Factory-Installed Options air smoke detectors A Ultra Low-Leak Downflow Economizer Ultra Low-Leak Downflow Economizer; Z eturn & Supply air smoke detectors B DD-BAnet protocol DD-BAnet protocol; F Ultra Low-Leak Downflow Economizer; Disconnect Switch (non-fused) DD-BAnet protocol V Low-Leak Downflow Economizer Factory-Installed Options H Disconnect Switch (non-fused) W Low-Leak Downflow Economizer X Standard Aluminized Heat Exchanger J Ultra Low-Leak Downflow Economizer; Disconnect Switch (non-fused) S Stainless-Steel Heat Exchanger Disconnect Switch (non-fused) X No Options D Hinged Panels M Disconnect Switch (non-fused); DD-BAnet protocol K Stainless-Steel Heat Exchanger; Hinged Panels Note: Not all options available for all products. B Phase Monitor X= No Options in character th J Stainless Steel Heat Exchanger; Phase Monitor M Hinged Panel; Phase Monitor L Stainless-Steel Heat Exchanger; Hinged Panels; Phase Monitor www.daikinac.com SS-DS
Factory-Installed Options Stainless-Steel Heat Exchanger (Gas units only): A tubular heat exchanger made of 409-type stainless steel is installed in the unit. Low-Ambient Kit: Allows for cooling operation at lower outdoor temperatures. On the - to 6-ton units, cooling operation is extended from 60 F ambient temperature to 5 F outside air temperature. On 7½ -0 ton units, cooling operation is extended from 5 F ambient temperature to 0 F outside air temperature. For 5 ton units, cooling operation is extended from 4 F ambient temperature to 0 F outside air temperature. Economizers (Downflow): Based on air conditions, can provide outside air to cool the space. Electric Heat Kits (A and heat pump units only): Available in all voltage options. Non-powered onvenience Outlet: A 0V, 5A, GFI outlet makes it easier for technicians to service the unit once an electrician runs power to the outlet. Powered onvenience Outlet: A 0V, 5A, GFI outlet powered with a transformer built into the unit. When a factory-installed powered convenience outlet is installed in the equipment, the unit MA (Min. ircuit Ampacity) will increase by 7.5A for 08/0V units, increase by.75a for 460V units, and by A for 575V units. The MOP (Max. Overcurrent Protection) device must be sized accordingly. Disconnect Switch (non-fused; -phase units only): A disconnect switch is installed in the unit and factory wiring will be complete from the switch to the unit. Please note that for air conditioning (DS units) and heat pump models (DSH units), the appropriate electric heat kit must be ordered to be factory-installed along with the disconnect switch (non-fused) when it is ordered. Please note that for models with a powered convenience outlet option and a disconnect switch (non-fused) option, the power to the powered convenience outlet will be shut off when the disconnect switch (non-fused) is in the off position. eturn Air and/or Supply Air Smoke Detectors: eturn air and/or supply air smoke detectors are installed in the unit. Hinged Access Panels: Allows access to unit s major components. ombined with latches for easy access to control box, compressor, filters and blower motor. Available on all units. Two-speed indoor fan blower models are available on 6, 7½, 8½, 0, ½, 5, 0 & 5 ton units. Section 6.4..0.b of ASHAE Standard 90.-00 and Section 6.5...a of ASHAE Standard 90.-0 require a minimum of two fan speeds. Section 40.4(m) of alifornia Energy ommission Title 4 0 contains a similar provision. When the units with the two-speed indoor fan blowers operate on a call for the first stage of cooling, the fan operates at low speed, which is 66% of full speed. When the units operate on a call for the second stage of cooling, the fan operates at full speed. In heating operation, the fan operates at full speed. During ventilation operation, the fan operates at low speed. Phase Monitor: Phase monitor ( phase only), available for - 5 ton DS, D and DT series models. Phase monitor shall provide protection for motors and compressors against problems caused by phase loss, phase reversal and phase unbalance. Phase monitor is equipped with an LED that provides an ON or FAULT indicator. DD ontroller: DD communicating controller, available for - 5 ton DS, D and DT series models with on-board BAnet communication interface. SS-DS www.daikinac.com
Product Specifications Tons DS06 ***D***A* DS06 ***D***A* DS06 ***B***A* DS06 ***4B***A* DS06 ***7B***A* ooling apacity Total BTU/h 6,000 6,000 5,000 5,000 5,000 Sensible BTU/h 6,640 6,640 5,600 5,600 5,600 SEE / EE 4 / 4 / 4 / 4 / 4 / Decibels 78 78 78 78 78 AHI eference #s 99675 99678 995 9957 995 Evaporator Motor / oil Motor Type Direct Drive Direct Drive Belt Drive Belt Drive Belt Drive Indoor Nominal FM,50,50,00,00,00 Motor Speed Tap (ooling) Low Low --- --- --- Indoor Motor FLA (ooling).46.46.4.7. Horsepower - PM ⅓ - 90 ⅓ - 90.0-75.0-75.5-75 Piston Size (ooling) 0.070 0.070 0.070 0.070 0.070 Filter Size (") (4) 4" x 0" x " (4) 4" x 0" x " (4) 4" x 0" x " (4) 4" x 0" x " (4) 4" x 0" x " Drain Size (NPT) ¾" ¾" ¾" ¾" ¾" -40A efrigerant harge ir # (oz.) 05 05 05 05. 05 Evaporator oil Face Area (ft²) 7.0 7.0 7.0 7.0 7.0 ows Deep / Fins per Inch 4 / 6 4 / 6 4 / 6 4 / 6 4 / 6 Belt Drive Evap Fan Data # of Wheels (D x W) ----- ----- (" x 0") (" x 0") (" x 0") Motor Sheave ----- ----- VL4 X ⅝ VL4 X ⅝ VL4 X ⅝ Blower Sheave / Belt ----- ----- AK6 x / AX5 AK6 x / AX5 AK6 x / AX5 ondenser Fan / oil Quantity of ondenser Fan Motors Horsepower - PM ¼ /,075 ¼ /,075 ¼ /,075 ¼ /,050 ¼ /,050 Fan Diameter/ # Fan Blades / 4 / 4 / 4 / 4 / 4 Outdoor Nominal FM,800,800,800,800,800 Face Area (ft²) 7. 7. 7. 7. 7. ows Deep/ Fins per Inch / 4 / 4 / 4 / 4 / 4 ompressor Quantity / Type/ Stage / Scroll/Single / Scroll/Single / Scroll/Single / Scroll/Single / Scroll/Single ompressor LA / LA 6.7 / 79.0 0.4 / 7.0 0.4 / 7.0 5.8 / 8.0.8 / 6.5 Electrical Data Voltage-Phase-Frequency 08/0--60 08/0--60 08/0--60 460--60 575--60 Indoor Blower HP / FLA ⅓ /.46 ⅓ /.46 /.4 /.7.5 /. Max External Static 0.5" 0.5".0".0".0" Outdoor Fan HP / FLA ¼ /.4 ¼ /.4 ¼ /.4 ¼ / 0.70 ¼ / 0.55 Min. ircuit Ampacity¹ 5 7 8 9.7 8.0 Max. Overcurrent Protection (amps)² 40 5 5 5 5 Power Supply onduit Hole.5".5".5".5".5" Low-Voltage onduit Hole ½" ½" ½" ½" ½" Operating Weight (lbs) 565 565 565 565 565 Ship Weight (lbs) 590 590 590 590 590 ¹ Wire size should be determined in accordance with National Electrical odes. Extensive wire runs will require larger wire sizes. ² May use fuses or HA-type circuit breakers of the same size as noted. Notes Always check the S& plate for electrical data on the unit being installed. 4 www.daikinac.com SS-DS
Product Specifications 4 Tons DS048 ***D***A* DS048 ***D***A* DS048 ***B***A* DS048 ***4B***A* DS048 ***7B***A* ooling apacity Total BTU/h 48,000 48,000 47,000 47,000 47,000 Sensible BTU/h 5,50 5,50 5,000 5,000 5,000 SEE / EE 4 / 4 / 4 /.8 4 /.8 4 /.8 Decibels 78 78 78 78 78 AHI eference #s 99676 99679 995 9958 9954 Evaporator Motor / oil Motor Type Direct Drive Direct Drive Belt Drive Belt Drive Belt Drive Indoor Nominal FM,600,600,600,600,600 Motor Speed Tap (ooling) Low Low -- -- -- Indoor Motor FLA (ooling).80.80.4.7. Horsepower - PM ¾ -,05 ¾ -,05.0 -,75.0 -,75.5 -,75 Piston Size (ooling) 0.076 0.076 0.074 0.074 0.074 Filter Size (") (4) 4" x 0" x " (4) 4" x 0" x " (4) 4" x 0" x " (4) 4" x 0" x " (4) 4" x 0" x " Drain Size (NPT) ¾" ¾" ¾" ¾" ¾" -40A efrigerant harge ir # (oz.) 0 0 Evaporator oil Face Area (ft²) 7.8 7.8 7.8 7.8 7.8 ows Deep / Fins per Inch 4 / 6 4 / 6 4 / 6 4 / 6 4 / 6 Belt Drive Evap Fan Data # of Wheels (D x W) ----- ----- (" x 0") (" x 0") (" x 0") Motor Sheave ----- ----- VL40 X ⅝ VL40 X ⅝ VL40 X ⅝ Blower Sheave / Belt ----- ----- AK66 x / AX5 AK66 x / AX5 AK66 x / AX5 ondenser Fan / oil Quantity of ondenser Fan Motors Horsepower - PM ¼ -,075 ¼ -,075 ¼ -,075 ¼ -,050 ¼ -,050 Fan Diameter/ # Fan Blades / 4 / 4 / 4 / 4 / 4 Outdoor Nominal FM,800,800,800,800,800 Face Area (ft²).5.5.5.5.5 ows Deep/ Fins per Inch / 7 / 7 / 7 / 7 / 7 ompressor Quantity / Type/ Stage / Scroll/Single / Scroll/Single / Scroll/Single / Scroll/Single / Scroll/Single ompressor LA / LA 9.9 / 09./ 8../ 8. 6./ 4 4.4/ Electrical Data Voltage-Phase-Frequency 08/0--60 08/0--60 08/0--60 460--60 575--60 Indoor Blower HP / FLA ¾ /.8 ¾ /.8.0 /.4.0 /.7.5 /. Max External Static 0.5" 0.5".0".0".0" Outdoor Fan HP / FLA ¼ /.40 ¼ /.40 ¼ /.40 ¼ / 0.70 ¼ / 0.55 Min. ircuit Ampacity¹ 9. 0 8 Max. Overcurrent Protection (amps)² 45 0 0 5 5 Power Supply onduit Hole.5".5".5".5".5" Low-Voltage onduit Hole ½" ½" ½" ½" ½" Operating Weight (lbs) 565 565 570 570 570 Ship Weight (lbs) 590 590 595 595 595 ¹ Wire size should be determined in accordance with National Electrical odes. Extensive wire runs will require larger wire sizes. ² May use fuses or HA-type circuit breakers of the same size as noted. Notes Always check the S& plate for electrical data on the unit being installed. SS-DS www.daikinac.com 5
Product Specifications 5 Tons DS060 ***D***A* DS060 ***D***A* DS060 ***B***A* DS060 ***4B***A* DS060 ***7B***A* ooling apacity Total BTU/h 58,000 58,000 58,000 58,000 58,000 Sensible BTU/h 4,90 4,90 4,90 4,90 4,90 SEE / EE 4 /.6 4 /.6 4 /.6 4 /.6 4 /.6 Decibels 78 78 78 78 78 AHI eference #s 99677 99670 995 9959 9955 Evaporator Motor / oil Motor Type Direct Drive Direct Drive Belt Belt Belt Indoor Nominal FM,800,800,800,800,800 Motor Speed Tap (ooling) T T -- -- -- Indoor Motor FLA (ooling) 6.90 6.90.0.5. Horsepower - PM -,050 -,050-760 - 760-760 Piston Size (ooling) 0.086 0.086 0.086 0.086 0.086 Filter Size (") (4) 4" x 0" x " (4) 4" x 0" x " (4) 4 x 0 x (4) 4 x 0 x (4) 4 x 0 x Drain Size (NPT) ¾" ¾" ¾" ¾" ¾" -40A efrigerant harge ir # (oz.) 00 00 00 00 00 Evaporator oil Face Area (ft²) 7.8 7.8 7.8 7.8 7.8 ows Deep / Fins per Inch 4/6 4/6 4 / 6 4 / 6 4 / 6 Belt Drive Evap Fan Data # of Wheels (D x W) ----- ----- (" x 0") (" x 0") (" x 0") Motor Sheave ----- ----- VL40 x ⅞ VL40 x ⅞ VL40 x ⅞ Blower Sheave / Belt ----- ----- AK6 x / AX5 AK6 x / AX5 AK6 x / AX5 ondenser Fan / oil Quantity of ondenser Fan Motors Horsepower - PM ¼ /,075 ¼ /,075 ¼ /,075 ¼ /,075 ¼ /,075 Fan Diameter/ # Fan Blades / 4 / 4 / 4 / 4 / 4 Outdoor Nominal FM,800,800,800,800,800 Face Area (ft²).0.0.0 ows Deep/ Fins per Inch / 7 / 7 / 7 / 7 / 7 ompressor Quantity / Type/ Stage / Scroll/Single / Scroll/Single / Scroll/Single / Scroll/Single / Scroll/Single ompressor LA / LA 6.4 / 4.0 6.0 / 0.0 6 / 0 7.8 / 5 5.7 / 8.9 Electrical Data Voltage-Phase-Frequency 08/0--60 08/0--60 08/0--60 460--60 575--60 Indoor Blower HP / FLA.0 / 6.9.0 / 6.9.0 /.0.0 /.5.5 /. Max External Static 0.9" 0.9".0.0.0 Outdoor Fan HP / FLA ¼ /.40 ¼ /.40 ¼ /.40 ¼ / 0.70 ¼ / 0.55 Min. ircuit Ampacity¹ 4. 8 5 9 Max. Overcurrent Protection (amps)² 60 40 40 5 5 Power Supply onduit Hole.5".5".5".5".5" Low-Voltage onduit Hole ½" ½" ½" ½" ½" Operating Weight (lbs) 570 570 570 570 570 Ship Weight (lbs) 595 595 595 595 595 ¹ Wire size should be determined in accordance with National Electrical odes. Extensive wire runs will require larger wire sizes. ² May use fuses or HA-type circuit breakers of the same size as noted. Notes Always check the S& plate for electrical data on the unit being installed. 6 www.daikinac.com SS-DS
Expanded ooling Data Tons Outdoor Ambient Temperature 65 F 75 F 85 F 95 F 05 F 5 F Entering Indoor Wet Bulb Temperature IDB Airflow 59 6 67 7 59 6 67 7 59 6 67 7 59 6 67 7 59 6 67 7 59 6 67 7 70 50 00 050 MBh 6.7 8. 4.7-5.9 7. 40.8-5.0 6. 9.8-4. 5.4 8.8 -.5.7 6.9-0.. 4. - S/T 0.75 0.6 0.44-0.78 0.65 0.45-0.80 0.67 0.46-0.8 0.69 0.48-0.86 0.7 0.50-0.86 0.7 0.50 - Delta T 9 6-9 7-9 7-9 7-9 6-8 5 - KW.46.5.58 -.6.69.77 -.79.85.9 -.9.99.08 -.04.0.0 -.4.. - AMPS 7. 7.5 7.7-7.9 8.0 8. - 8.5 8.7 8.9-9.0 9. 9.5-9.6 9.8 0. - 0. 0. 0.6 - HI P 7 55 70-66 87 0-0 6 44-45 7 9-88 48 44-49 46 487 - LO P 9 0-8 5 7-0 4-9 7 49-5 4 57-9 48 6 - MBh 5.7 7.0 40.5-4.8 6. 9.6-4.0 5. 8.6 -. 4.4 7.7 -.5.7 5.8-9. 0.. - S/T 0.7 0.60 0.4-0.74 0.6 0.4-0.76 0.64 0.44-0.79 0.66 0.46-0.8 0.68 0.47-0.8 0.69 0.48 - Delta T 0 7-0 7-0 7-0 7-0 7-8 6 - KW.44.49.56 -.6.67.75 -.77.8.9 -.90.96.05 -.0.08.8 -..8.8 - AMPS 7. 7.4 7.7-7.8 8.0 8. - 8.4 8.6 8.9-9.0 9. 9.4-9.5 9.7 0.0-0.0 0. 0.6 - HI P 5 5 67-64 84 00-00 4-4 68 88-84 4 47-44 457 48 - LO P 0 8 8-7 4 6-9 4-7 6 48-4 4 55-8 47 60 - MBh.9 4. 7.4 -.. 6.5 -.4.5 5.7-0.6.7 4.8-9. 0..0-7.0 7.9 0.6 - S/T 0.69 0.58 0.40-0.7 0.60 0.4-0.74 0.6 0.4-0.76 0.6 0.44-0.79 0.66 0.46-0.80 0.66 0.46 - Delta T 0 7-0 7-0 8-0 8-0 7-9 6 - KW.9.4.50 -.56.6.68 -.70.76.84 -.84.89.98 -.95.0.0 -.04..0 - AMPS 7. 7. 7.5-7.6 7.8 8.0-8. 8.4 8.6-8.7 8.9 9. - 9. 9.4 9.7-9.7 0.0 0. - HI P 8 45 59-56 75 9-9 - 56 76-7 40 4-4 44 468 - LO P 07 4 4-0 - 8 5 7-4 44-0 8 50-4 4 56-75 50 00 050 MBh 7.4 8.5 4.6 44.7 6.5 7.6 40.7 4.7 5.6 6.7 9.7 4.6 4.8 5.8 8.7 4.6.0 4.0 6.8 9.5 0.6.5 4. 6.6 S/T 0.86 0.77 0.58 0.7 0.89 0.79 0.60 0.9 0.9 0.8 0.6 0.40 0.94 0.84 0.64 0.4 0.97 0.87 0.66 0.4 0.98 0.88 0.67 0.4 Delta T 0 6 0 7 0 7 0 7 0 7 0 9 5 KW.48.5.60.68.65.7.79.87.8.87.96.05.95.0.0.0.07....7..4.44 AMPS 7.4 7.6 7.8 8.0 7.9 8. 8.4 8.6 8.6 8.8 9.0 9. 9. 9. 9.6 9.9 9.6 9.9 0. 0.5 0. 0.4 0.7. HI P 40 58 7 84 69 89 06 9 06 9 48 6 48 75 96 4 9 4 445 465 4 466 49 5 LO P 0 9 9 7 8 47 4 44 5 0 8 5 6 6 45 58 69 4 50 64 74 MBh 6. 7.4 40.4 4.4 5.4 6.5 9.5 4.4 4.6 5.6 8.5 4.4.7 4.7 7.6 40.4..0 5.7 8. 9.7 0.6. 5.5 S/T 0.8 0.7 0.55 0.6 0.85 0.76 0.57 0.7 0.87 0.78 0.59 0.8 0.90 0.80 0.6 0.9 0.9 0.8 0.6 0.40 0.94 0.84 0.6 0.4 Delta T 7 7 7 7 7 0 6 KW.46.5.58.66.6.69.77.85.79.85.9.0.9.99.08.8.04..0.0.4...4 AMPS 7. 7.5 7.7 8.0 7.9 8. 8. 8.6 8.5 8.7 8.9 9. 9.0 9. 9.5 9.9 9.6 9.8 0. 0.4 0. 0. 0.6.0 HI P 7 55 70 8 66 87 0 6 0 6 44 59 45 7 9 409 88 48 44 460 49 46 487 508 LO P 9 0 8 8 5 7 46 0 4 5 9 7 49 59 5 44 57 67 40 48 6 7 MBh.5 4.5 7. 40.0.7.7 6.4 9..9.9 5.6 8... 4.7 7. 9.6 0.5.0 5.4 7.4 8. 0.5.8 S/T 0.79 0.70 0.5 0.4 0.8 0.7 0.55 0.6 0.84 0.75 0.57 0.6 0.86 0.77 0.58 0.8 0.90 0.80 0.6 0.9 0.90 0.8 0.6 0.9 Delta T 7 8 8 4 8 8 0 6 KW.4.45.5.60.58.6.70.79.7.78.86.95.86.9.0.0.97.0...07... AMPS 7. 7. 7.5 7.8 7.7 7.9 8. 8.4 8. 8.5 8.7 9.0 8.8 9.0 9. 9.6 9. 9.5 9.8 0. 9.8 0. 0.4 0.7 HI P 0 48 6 7 58 78 94 06 94 6 4 48 5 60 80 97 76 405 48 446 46 448 47 49 LO P 08 5 6 4 4 4 9 6 8 47 5 45 54 9 5 6 5 44 57 67 IDB = Entering Indoor Dry Bulb Temperature Shaded area reflects AA (TVA) conditions kw = Total system power High and low pressures are measured at the liquid and suction service ports. Amps: Unit amps (comp.+ evaporator + condenser fan motors) SS-DS www.daikinac.com 7
Expanded ooling Data Tons (cont.) Outdoor Ambient Temperature 65 F 75 F 85 F 95 F 05 F 5 F Entering Indoor Wet Bulb Temperature IDB Airflow 59 6 67 7 59 6 67 7 59 6 67 7 59 6 67 7 59 6 67 7 59 6 67 7 80 50 00 050 MBh 8.0 8.9 4.5 44.4 7. 8.0 40.6 4. 6. 7. 9.6 4. 5.4 6. 8.6 4..6 4. 6.7 9...8 4.0 6. S/T 0.94 0.88 0.7 0.54.00 0.9 0.74 0.56.00 0.94 0.76 0.57.00 0.97 0.79 0.59.00.00 0.8 0.6.00.00 0.8 0.6 Delta T 4 0 6 5 4 6 5 4 6 4 4 7 0 6 9 5 KW.50.55.6.70.67.7.8.90.8.89.98.07.97.0...09.5.5.6.9.6.6.47 AMPS 7.5 7.6 7.9 8. 8.0 8. 8.4 8.7 8.6 8.8 9. 9.4 9. 9.4 9.7 0.0 9.7 0.0 0. 0.6 0. 0.5 0.8. HI P 4 6 75 87 7 9 09 09 5 66 5 79 400 47 96 46 450 469 47 47 497 59 LO P 4 4 0 8 40 49 5 45 55 40 5 6 8 46 60 70 4 5 65 76 MBh 6.9 7.7 40. 4. 6. 6.9 9.4 4. 5. 6.0 8.4 4. 4. 5. 7.5 40..6. 5.6 8. 0. 0.9.0 5. S/T 0.90 0.84 0.68 0.5 0.9 0.87 0.7 0.5 0.95 0.89 0.7 0.54 0.98 0.9 0.75 0.56.00 0.96 0.78 0.58.00 0.96 0.78 0.59 Delta T 5 4 7 6 5 7 6 5 7 6 5 7 5 4 7 0 6 KW.48.5.60.68.65.7.79.87.8.87.96.05.95.0.0.0.07....7..4.44 AMPS 7.4 7.6 7.8 8.0 7.9 8. 8.4 8.6 8.6 8.8 9.0 9. 9. 9. 9.6 9.9 9.6 9.9 0. 0.5 0. 0.4 0.7. HI P 40 58 7 84 69 90 06 9 06 9 48 6 48 75 96 4 9 4 446 465 4 466 49 5 LO P 0 9 9 7 8 47 4 44 5 0 8 5 6 6 45 58 69 4 50 64 74 MBh 4. 4.8 7. 9.8. 4.0 6. 8.8.5. 5.5 7.9.7.4 4.6 7.0 0. 0.8.9 5. 7.9 8.5 0.5.6 S/T 0.86 0.8 0.66 0.49 0.90 0.84 0.68 0.5 0.9 0.86 0.70 0.5 0.95 0.89 0.7 0.54 0.98 0.9 0.75 0.56 0.99 0.9 0.76 0.57 Delta T 6 5 7 6 5 7 6 5 7 6 5 8 6 5 7 4 0 6 KW.4.47.54.6.59.65.7.8.75.80.89.98.88.94.0..99.06.5.5.09.6.6.6 AMPS 7. 7.4 7.6 7.9 7.7 7.9 8. 8.4 8.4 8.5 8.8 9. 8.9 9. 9.4 9.7 9.4 9.6 9.9 0. 9.9 0. 0.5 0.8 HI P 50 64 76 6 8 97 09 97 9 7 5 8 64 84 40 80 409 4 45 40 45 477 498 LO P 09 6 7 5 6 4 4 0 8 9 49 6 4 46 56 4 54 6 7 45 59 69 85 50 00 050 MBh 8.7 9.4 4. 44. 7.8 8.5 40. 4.0 6.9 7.6 9.4 4.0 6.0 6.7 8.4 4.0 4. 4.9 6.5 8.9.7..8 6. S/T 0.98 0.95 0.86 0.70.00 0.98 0.89 0.7.00.00 0.9 0.74.00.00 0.94 0.76.00.00 0.98 0.79.00.00 0.98 0.80 Delta T 6 6 4 6 6 4 5 6 4 5 5 5 4 4 0 KW.5.56.64.7.69.75.8.9.85.9.00.0.99.06.5.5..8.8.8..9.9.50 AMPS 7.5 7.7 7.9 8. 8. 8. 8.5 8.8 8.7 8.9 9. 9.5 9. 9.5 9.8 0. 9.8 0.0 0.4 0.7 0.4 0.6 0.9. HI P 45 6 78 90 74 95 5 6 55 70 55 8 404 4 400 40 454 474 44 476 50 54 LO P 5 4 4 9 4 50 6 4 47 56 4 54 64 9 48 6 7 44 5 67 78 MBh 7.6 8. 40. 4.8 6.7 7.4 9. 4.8 5.8 6.5 8. 40.8 4.9 5.6 7. 9.8..8 5.4 7.8 0.8..8 5.0 S/T 0.94 0.9 0.8 0.66 0.97 0.94 0.85 0.69.00 0.96 0.87 0.7.00 0.99 0.90 0.7.00.00 0.9 0.76.00.00 0.94 0.76 Delta T 7 7 5 7 7 5 7 7 5 7 7 6 5 6 5 4 4 4 0 KW.50.55.6.70.67.7.8.90.8.89.98.07.97.0...09.5.5.6.9.6.6.47 AMPS 7.5 7.6 7.9 8. 8.0 8. 8.4 8.7 8.6 8.8 9. 9.4 9. 9.4 9.7 0.0 9.7 0.0 0. 0.6 0. 0.5 0.8. HI P 4 6 75 87 7 9 09 09 5 66 5 79 400 47 96 46 450 469 47 47 497 59 LO P 4 4 0 8 40 49 5 45 55 40 5 6 8 46 60 70 4 5 65 76 MBh 4.7 5. 7.0 9.5.9 4.5 6. 8.6..7 5. 7.7..9 4.4 6.7 0.6..7 4.9 8.4 8.9 0.. S/T 0.9 0.87 0.79 0.64 0.94 0.9 0.8 0.66 0.96 0.9 0.84 0.68 0.99 0.96 0.86 0.70.00 0.99 0.90 0.7.00.00 0.9 0.7 Delta T 7 7 6 8 7 6 8 7 6 8 8 6 7 7 6 5 5 4 KW.44.49.56.64.6.67.75.8.77.8.9.00.90.96.05.5.0.08.8.8..8.8.9 AMPS 7. 7.4 7.7 7.9 7.8 8.0 8. 8.5 8.4 8.6 8.9 9. 9.0 9. 9.4 9.8 9.5 9.7 0.0 0. 0.0 0. 0.6 0.9 HI P 5 5 67 78 64 84 00 00 4 55 4 67 88 405 84 4 46 455 44 457 48 50 LO P 0 7 8 7 7 4 6 44 9 4 50 7 6 48 58 4 55 65 8 47 60 7 IDB = Entering Indoor Dry Bulb Temperature Shaded area reflects AHI atings conditions kw = Total system power High and low pressures are measured at the liquid and suction service ports. Amps: Unit amps (comp.+ evaporator + condenser fan motors) 8 www.daikinac.com SS-DS
Expanded ooling Data 4 Tons Outdoor Ambient Temperature 65 F 75 F 85 F 95 F 05 F 5 F Entering Indoor Wet Bulb Temperature IDB Airflow 59 6 67 7 59 6 67 7 59 6 67 7 59 6 67 7 59 6 67 7 59 6 67 7 70 800 600 400 MBh 46.0 47.7 5. - 45.0 46.6 5. - 4.9 45.5 49.9-4.8 44.4 48.6-40.7 4. 46. - 7.7 9. 4.8 - S/T 0.77 0.64 0.45-0.80 0.67 0.46-0.8 0.68 0.47-0.84 0.70 0.49-0.88 0.7 0.5-0.88 0.74 0.5 - Delta T 8 6-8 6-8 6-8 6-8 6-7 5 - KW.0.7.6 -..40.50 -.5.60.7 -.7.78.90 -.86.94 4.06 -.99 4.07 4.0 - AMPS 8. 8. 8.6-8.7 8.9 9. - 9.4 9.7 0.0-0. 0. 0.6-0.7 0.9. -..5.9 - HI P 40 59 7-70 90 06-07 0 48-49 76 97-9 4 447-44 467 49 - LO P 9 0-8 6 8-4 - 9 8 50-5 44 57-40 49 6 - MBh 44.7 46. 50.8-4.7 45. 49.6-4.6 44. 48.4-4.6 4. 47. - 9.5 40.9 44.9-6.6 7.9 4.6 - S/T 0.7 0.6 0.4-0.76 0.64 0.44-0.78 0.65 0.45-0.80 0.67 0.47-0.84 0.70 0.48-0.84 0.70 0.49 - Delta T 9 6-9 7-9 7-9 7-9 6-8 5 - KW.08.4.4 -..7.48 -.50.58.69 -.68.75.87 -.8.9 4.0 -.95 4.04 4.7 - AMPS 8. 8. 8.5-8.7 8.9 9. - 9.4 9.6 9.9-0.0 0. 0.5-0.6 0.8. -..4.8 - HI P 8 56 70-67 87 0-04 7 45-46 7 9-89 49 44-40 46 488 - LO P 8 9-7 5 6-0 4-8 6 49-4 4 56-9 48 6 - MBh 4. 4.8 46.9-40. 4.8 45.8-9. 40.8 44.7-8.4 9.8 4.6-6.5 7.8 4.4 -.8 5.0 8.4 - S/T 0.7 0.59 0.4-0.7 0.6 0.4-0.75 0.6 0.44-0.78 0.65 0.45-0.8 0.67 0.47-0.8 0.68 0.47 - Delta T 9 7-9 7-9 7-0 7-9 7-8 6 - KW.0.07.6 -..0.9 -.4.49.60 -.59.67.78 -.7.8.9 -.86.94 4.07 - AMPS 7.9 8.0 8. - 8.5 8.6 8.9-9. 9. 9.6-9.7 9.9 0. - 0. 0.5 0.9-0.9..5 - HI P 48 6-59 79 94-95 7 5-5 6 8-77 406 49-47 449 474 - LO P 08 5 5-4 - 8 6 7-4 44-0 8 5-5 4 56-75 800 600 400 MBh 46.8 48. 5. 56.0 45.7 47. 5.0 54.7 44.6 46.0 49.8 5.4 4.6 44.8 48.5 5. 4.4 4.6 46. 49.5 8. 9.5 4.7 45.8 S/T 0.87 0.78 0.59 0.8 0.9 0.8 0.6 0.9 0.9 0.8 0.6 0.40 0.96 0.86 0.65 0.4.00 0.89 0.67 0.4.00 0.90 0.68 0.44 Delta T 9 6 9 6 0 6 0 6 9 6 0 8 5 0 KW..9.9.9.6.4.5.64.56.6.75.86.74.8.94 4.06.89.97 4.0 4. 4.0 4.0 4.4 4.7 AMPS 8. 8.4 8.6 8.9 8.8 9.0 9. 9.6 9.5 9.7 0.0 0.4 0. 0.4 0.7. 0.8.0.4.8.4.6.0.4 HI P 4 6 76 88 7 9 0 0 5 67 5 80 40 48 97 47 45 470 49 47 498 50 LO P 0 40 0 7 9 48 4 44 54 9 5 6 7 46 59 69 4 5 64 75 MBh 45.5 46.8 50.7 54.4 44.4 45.7 49.5 5. 4. 44.6 48. 5.8 4. 4.5 47. 50.6 40. 4.4 44.8 48. 7. 8. 4.5 44.5 S/T 0.8 0.75 0.56 0.6 0.86 0.77 0.59 0.8 0.89 0.79 0.60 0.9 0.9 0.8 0.6 0.40 0.95 0.85 0.64 0.4 0.96 0.86 0.65 0.4 Delta T 0 6 0 7 0 7 0 7 0 7 0 9 5 KW..7.6.6..40.50.6.5.60.7.8.7.79.90 4.0.86.94 4.06 4.0.99 4.07 4.0 4.4 AMPS 8. 8. 8.6 8.9 8.7 8.9 9. 9.5 9.4 9.7 0.0 0. 0. 0. 0.6.0 0.7 0.9..7..5.9. HI P 40 59 7 85 70 90 06 0 07 0 49 64 49 76 97 44 9 4 447 466 44 467 49 55 LO P 9 0 9 8 6 8 47 4 5 9 8 50 60 6 44 57 68 40 49 6 7 MBh 4.0 4. 46.8 50. 4.0 4. 45.7 49.0 40.0 4. 44.6 47.9 9.0 40. 4.5 46.7 7. 8. 4. 44.4 4. 5.4 8. 4. S/T 0.80 0.7 0.54 0.5 0.8 0.75 0.56 0.6 0.85 0.76 0.58 0.7 0.88 0.79 0.60 0.8 0.9 0.8 0.6 0.40 0.9 0.8 0.6 0.40 Delta T 0 7 7 7 7 7 9 6 KW.04.0.9.8.5..4.5.45.5.6.74.6.69.8.9.76.84.97 4.09.89.97 4.0 4. AMPS 7.9 8. 8.4 8.6 8.5 8.7 9.0 9. 9. 9.4 9.7 0.0 9.8 0.0 0. 0.7 0.4 0.6.0..0..6.0 HI P 5 65 76 6 8 97 0 98 0 8 5 9 65 85 40 8 40 4 45 4 45 479 499 LO P 09 6 6 5 5 4 9 7 9 48 5 46 55 40 5 6 6 45 58 68 IDB = Entering Indoor Dry Bulb Temperature Shaded area reflects AA (TVA) conditions kw = Total system power High and low pressures are measured at the liquid and suction service ports. Amps: Unit amps (comp.+ evaporator + condenser fan motors) SS-DS www.daikinac.com 9
Expanded ooling Data 4 Tons (cont.) Outdoor Ambient Temperature 65 F 75 F 85 F 95 F 05 F 5 F Entering Indoor Wet Bulb Temperature IDB Airflow 59 6 67 7 59 6 67 7 59 6 67 7 59 6 67 7 59 6 67 7 59 6 67 7 80 800 600 400 MBh 47.7 48.7 5.0 55.6 46.5 47.6 50.8 54. 45.4 46.4 49.6 5.0 44. 45. 48.4 5.7 4. 4.0 46.0 49. 9.0 9.9 4.6 45.5 S/T 0.96 0.90 0.7 0.55.00 0.9 0.76 0.57.00 0.96 0.78 0.58.00.00 0.80 0.60.00.00 0.8 0.6.00.00 0.84 0.6 Delta T 9 6 4 0 6 0 6 0 6 0 6 0 0 8 5 KW.5...4.8.45.56.67.59.66.78.90.77.85.97 4.0.9 4.00 4. 4.6 4.05 4.4 4.7 4.4 AMPS 8. 8.5 8.7 9.0 8.9 9. 9.4 9.7 9.6 9.8 0. 0.5 0. 0.5 0.8. 0.8..5.9.5.7..5 HI P 45 64 79 9 75 96 6 7 56 7 56 84 405 4 40 4 456 475 44 477 50 55 LO P 4 4 9 40 49 6 4 46 55 40 5 6 8 47 6 7 4 5 66 77 MBh 46. 47. 50.5 54.0 45. 46. 49. 5.7 44. 45. 48. 5.5 4.0 44.0 47.0 50. 40.9 4.8 44.6 47.7 7.9 8.7 4. 44. S/T 0.9 0.86 0.70 0.5 0.95 0.89 0.7 0.54 0.97 0.9 0.74 0.55.00 0.94 0.77 0.57.00 0.98 0.80 0.59.00 0.98 0.80 0.60 Delta T 4 0 6 5 4 6 5 4 6 5 4 7 0 6 9 5 KW..9.9.9.6.4.5.64.56.6.75.87.74.8.94 4.06.89.97 4.0 4. 4.0 4.0 4.4 4.8 AMPS 8. 8.4 8.6 8.9 8.8 9.0 9. 9.6 9.5 9.7 0.0 0.4 0. 0.4 0.7. 0.8.0.4.8.4.6.0.4 HI P 4 6 76 88 7 9 0 0 5 67 5 80 40 48 97 47 45 47 49 47 498 50 LO P 0 40 0 7 9 48 4 44 54 9 5 6 7 46 59 69 4 5 64 75 MBh 4.7 4.6 46.6 49.8 4.7 4.6 45.5 48.7 40.7 4.6 44.5 47.5 9.7 40.6 4.4 46.4 7.7 8.6 4. 44.0 5.0 5.7 8. 40.8 S/T 0.88 0.8 0.67 0.50 0.9 0.86 0.70 0.5 0.94 0.88 0.7 0.5 0.97 0.9 0.74 0.55.00 0.94 0.77 0.57.0 0.95 0.77 0.58 Delta T 5 4 6 5 4 7 5 4 7 5 4 7 5 4 7 9 5 KW.06....8.5.45.56.48.55.66.77.65.7.84.96.79.88 4.00 4..9 4.00 4. 4.7 AMPS 8.0 8. 8.4 8.7 8.6 8.8 9. 9.4 9. 9.5 9.8 0. 9.9 0. 0.4 0.8 0.5 0.7..4...7. HI P 5 5 68 79 64 84 00 0 4 56 4 68 89 406 85 44 48 456 45 458 48 504 LO P 0 7 8 6 6 5 44 8 40 49 7 5 47 57 4 54 64 7 46 60 70 85 800 600 400 MBh 48.5 49.4 5.8 55. 47.4 48. 50.6 5.9 46. 47. 49.4 5.7 45. 46.0 48. 5.4 4.8 4.7 45.7 48.8 9.7 40.5 4.4 45. S/T.00 0.97 0.88 0.7.00.00 0.9 0.74.00.00 0.9 0.76.00.00 0.96 0.78.00.00.00 0.8.00.00.00 0.8 Delta T 5 4 0 4 5 0 4 4 0 4 0 0 0 9 KW.8.4.4.44.4.48.59.70.6.69.8.9.80.88 4.00 4..95 4.04 4.6 4.0 4.08 4.7 4. 4.45 AMPS 8. 8.5 8.8 9. 9.0 9. 9.5 9.8 9.7 9.9 0. 0.6 0. 0.6 0.9. 0.9..6.0.6.8..6 HI P 48 67 8 94 78 99 6 9 6 40 59 75 60 87 409 47 405 46 460 480 447 48 508 50 LO P 6 4 4 0 4 5 7 5 47 57 4 55 65 40 49 6 7 44 54 68 79 MBh 47. 48.0 50. 5.6 46.0 46.9 49. 5.4 44.9 45.8 47.9 5. 4.8 44.6 46.8 49.9 4.6 4.4 44.4 47.4 8.5 9. 4. 4.9 S/T 0.96 0.9 0.84 0.68 0.99 0.96 0.87 0.70.00 0.98 0.89 0.7.00.00 0.9 0.74.00.00 0.95 0.77.00.00 0.96 0.78 Delta T 6 6 4 6 6 4 6 6 4 5 6 5 4 4 4 0 KW.5...4.8.45.56.67.59.66.78.90.77.85.97 4.0.9 4.00 4. 4.6 4.05 4.4 4.7 4.4 AMPS 8. 8.5 8.7 9.0 8.9 9. 9.4 9.7 9.6 9.8 0. 0.5 0. 0.5 0.8. 0.8..5.9.5.7..5 HI P 45 64 79 9 75 96 6 7 56 7 56 84 405 4 40 4 456 475 44 477 50 55 LO P 4 4 9 40 49 6 4 46 55 40 5 6 8 47 6 7 4 5 66 77 MBh 4.5 44. 46.4 49.5 4.4 4. 45. 48. 4.4 4. 44. 47. 40.4 4. 4. 46.0 8.4 9. 4.0 4.7 5.6 6. 8.0 40.5 S/T 0.9 0.89 0.8 0.65 0.96 0.9 0.8 0.68 0.98 0.95 0.86 0.69.00 0.98 0.88 0.7.00.00 0.9 0.74.00.00 0.9 0.75 Delta T 6 6 5 7 6 5 7 6 5 7 6 5 5 6 5 4 0 KW.08.4.4..0.7.48.58.50.58.69.80.68.75.87 4.00.8.9 4.0 4.6.95 4.04 4.7 4.0 AMPS 8. 8. 8.5 8.8 8.7 8.9 9. 9.5 9.4 9.6 9.9 0. 0.0 0. 0.5 0.9 0.6 0.8..5..4.8. HI P 8 56 70 8 67 87 0 6 04 7 45 60 46 7 9 40 89 49 44 46 40 46 488 509 LO P 8 9 7 7 5 6 45 0 4 5 8 6 49 58 4 4 56 66 9 48 6 7 IDB = Entering Indoor Dry Bulb Temperature Shaded area reflects AHI atings conditions kw = Total system power High and low pressures are measured at the liquid and suction service ports. Amps: Unit amps (comp.+ evaporator + condenser fan motors) 0 www.daikinac.com SS-DS
Expanded ooling Data 5 Tons Outdoor Ambient Temperature 65 F 75 F 85 F 95 F 05 F 5 F Entering Indoor Wet Bulb Temperature IDB Airflow 59 6 67 7 59 6 67 7 59 6 67 7 59 6 67 7 59 6 67 7 59 6 67 7 70 050 800 550 MBh 57.6 59.7 65.4-56. 58. 6.9-54.9 56.9 6.4-5.6 55.6 60.9-50.9 5.8 57.8-47. 48.9 5.6 - S/T 0.74 0.6 0.4-0.77 0.64 0.44-0.78 0.66 0.45-0.8 0.68 0.47-0.84 0.70 0.49-0.85 0.7 0.49 - Delta T 9 7-9 7-9 7-9 7-9 7-8 6 - KW.95 4.04 4.7-4.6 4.5 4.49-4.5 4.6 4.78-4.77 4.87 5.04-4.97 5.08 5.5-5.5 5.6 5.44 - AMPS 0. 0.4 0.7 -.0..6 -.9..6 -.7.0.5 -.5.9 4. - 4. 4.7 5. - HI P 57 77 9-89 8-8 5 7-74 40 45-4 45 478-465 500 58 - LO P 07 4 4-0 - 7 5 6-4 - 9 7 50-4 4 55 - MBh 55.9 58.0 6.5-54.6 56.6 6.0-5. 55. 60.6-5.0 5.9 59. - 49.4 5. 56. - 45.8 47.5 5.0 - S/T 0.70 0.59 0.4-0.7 0.6 0.4-0.75 0.6 0.4-0.77 0.65 0.45-0.80 0.67 0.46-0.8 0.68 0.47 - Delta T 0 7-0 8-0 8-8 - 0 8-9 6 - KW.9 4.00 4. - 4. 4. 4.46-4.49 4.59 4.74-4.7 4.8 4.99-4.9 5.04 5. - 5.0 5. 5.9 - AMPS 0. 0. 0.6-0.9..5 -.8..5 -.6.9.4 -.4.7 4. - 4. 4.6 5. - HI P 55 74 90-86 08 5-5 50 70-70 99 4-47 448 474-460 495 5 - LO P 06-9 0-6 4 5-0 4-8 6 49-4 54 - MBh 5.6 5.5 58.6-50.4 5. 57. - 49. 5.0 55.9-48.0 49.8 54.5-45.6 47. 5.8-4. 4.8 48.0 - S/T 0.68 0.57 0.9-0.70 0.59 0.4-0.7 0.60 0.4-0.74 0.6 0.4-0.77 0.65 0.45-0.78 0.65 0.45 - Delta T 8 4-8 4-8 4-8 4-8 4-0 7 - KW.8.9 4.0-4. 4. 4.5-4.8 4.48 4.6-4.6 4.7 4.87-4.8 4.9 5.08-4.97 5.09 5.6 - AMPS 9.8 0.0 0.4-0.6 0.8. -.5.8. -..6.0 -..4.8 -.8 4. 4.6 - HI P 47 66 8-77 98 5-5 9 58-59 87 408-404 45 459-447 48 507 - LO P 0 09 9-08 5 6-0 - 8 6 7-4 44-8 6 49-75 050 800 550 MBh 58.6 60. 65. 70. 57. 58.9 6.8 68.5 55.9 57.5 6. 66.8 54.5 56. 60.7 65. 5.8 5. 57.7 6.9 48.0 49.4 5.5 57.4 S/T 0.84 0.75 0.57 0.7 0.87 0.78 0.59 0.8 0.89 0.80 0.60 0.9 0.9 0.8 0.6 0.40 0.96 0.85 0.65 0.4 0.96 0.86 0.65 0.4 Delta T 0 7 7 7 7 0 7 9 6 KW.98 4.07 4.0 4.4 4.9 4.9 4.5 4.68 4.57 4.67 4.8 4.98 4.8 4.9 5.08 5.5 5.0 5. 5.0 5.48 5.9 5. 5.49 5.68 AMPS 0. 0.5 0.8....7..0..7..8..6 4..7 4.0 4.5 5.0 4.5 4.8 5. 5.9 HI P 60 80 95 08 9 4 46 57 77 9 78 407 49 448 45 458 48 504 470 506 54 557 LO P 08 5 5 4 4 4 9 6 8 47 4 45 54 0 9 5 6 5 44 57 67 MBh 56.9 58.6 6.4 68.0 55.6 57. 6.9 66.5 54. 55.8 60.5 64.9 5.9 54.5 59.0 6. 50. 5.8 56.0 60. 46.6 47.9 5.9 55.7 S/T 0.80 0.7 0.54 0.5 0.8 0.74 0.56 0.6 0.85 0.76 0.58 0.7 0.88 0.79 0.59 0.8 0.9 0.8 0.6 0.40 0.9 0.8 0.6 0.40 Delta T 8 4 8 4 8 4 8 8 0 6 KW.95 4.04 4.7 4.0 4.6 4.5 4.49 4.64 4.5 4.6 4.78 4.94 4.77 4.88 5.04 5. 4.97 5.08 5.5 5.4 5.5 5.6 5.44 5.6 AMPS 0. 0.4 0.7..0..6.0.9..6..7.0.5 4.0.5.9 4. 4.9 4. 4.7 5. 5.8 HI P 57 77 9 05 89 8 4 9 54 7 89 74 40 45 44 4 45 478 499 465 50 59 55 LO P 07 4 4 0 40 7 5 6 45 4 5 9 7 50 60 4 4 55 65 MBh 5.5 54. 58.5 6.8 5. 5.8 57. 6. 50. 5.5 55.8 59.9 48.8 50. 54.4 58.4 46.4 47.8 5.7 55.5 4.0 44. 47.9 5.4 S/T 0.77 0.69 0.5 0.4 0.80 0.7 0.54 0.5 0.8 0.7 0.56 0.6 0.85 0.76 0.57 0.7 0.88 0.79 0.59 0.8 0.89 0.79 0.60 0.9 Delta T 4 8 4 8 4 8 5 9 4 8 7 KW.86.94 4.06 4.0 4.6 4.5 4.8 4.5 4.4 4.5 4.66 4.8 4.65 4.75 4.9 5.07 4.85 4.96 5. 5.9 5.0 5. 5.0 5.48 AMPS 9.9 0. 0.5 0.8 0.7 0.9..7.6.9..7.4.7..6..5.9 4.5 4.0 4. 4.8 5. HI P 50 69 84 96 80 0 8 9 4 6 78 6 9 4 40 408 49 464 484 45 486 5 55 LO P 04 0 0 8 0 7 7 5 4 4 0 7 9 48 5 46 55 0 8 5 60 IDB = Entering Indoor Dry Bulb Temperature Shaded area reflects AA (TVA) conditions kw = Total system power High and low pressures are measured at the liquid and suction service ports. Amps: Unit amps (comp.+ evaporator + condenser fan motors) SS-DS www.daikinac.com
Expanded ooling Data 5 Tons (cont.) Outdoor Ambient Temperature 65 F 75 F 85 F 95 F 05 F 5 F Entering Indoor Wet Bulb Temperature IDB Airflow 59 6 67 7 59 6 67 7 59 6 67 7 59 6 67 7 59 6 67 7 59 6 67 7 80 050 800 550 MBh 59.6 60.9 65. 69.6 58. 59.5 6.6 68.0 56.9 58. 6. 66.4 55.5 56.7 60.6 64.7 5.7 5.9 57.5 6.5 48.8 49.9 5. 57.0 S/T 0.9 0.86 0.70 0.5 0.95 0.89 0.7 0.54.00 0.9 0.75 0.56.00 0.95 0.77 0.58.00.00 0.80 0.60.00.00 0.8 0.60 Delta T 5 4 6 5 4 7 6 4 7 5 4 7 4 4 6 9 5 KW 4.0 4.0 4. 4.7 4. 4.4 4.57 4.7 4.6 4.7 4.86 5.0 4.85 4.96 5. 5.0 5.06 5.7 5.4 5.5 5.4 5.5 5.5 5.7 AMPS 0. 0.6 0.9...4.8...4.8..0..7 4..8 4. 4.6 5. 4.6 5.0 5.5 6. HI P 6 8 98 95 7 5 49 5 6 8 97 8 4 44 45 49 46 488 509 475 5 59 56 LO P 09 6 7 5 5 4 4 0 7 9 48 6 4 46 56 40 5 6 6 45 58 69 MBh 57.9 59. 6. 67.6 56.6 57.8 6.7 66.0 55. 56.4 60. 64.4 5.9 55.0 58.8 6.9 5. 5. 55.9 59.7 47.4 48.4 5.7 55. S/T 0.88 0.8 0.67 0.50 0.9 0.85 0.69 0.5 0.9 0.87 0.7 0.5 0.96 0.90 0.74 0.55.00 0.94 0.76 0.57.00 0.95 0.77 0.57 Delta T 6 5 7 6 5 7 6 5 8 6 5 8 6 5 7 4 0 6 KW.98 4.07 4.0 4.4 4.9 4.9 4.5 4.68 4.57 4.67 4.8 4.98 4.8 4.9 5.08 5.5 5.0 5. 5.0 5.48 5.9 5. 5.49 5.68 AMPS 0. 0.5 0.8....7..0..7..9..6 4..7 4.0 4.5 5.0 4.5 4.8 5. 5.9 HI P 60 80 95 08 9 4 46 57 77 9 78 407 40 448 45 458 48 504 470 506 54 557 LO P 08 5 5 4 4 4 9 6 8 47 5 45 54 0 9 5 6 5 44 57 67 MBh 5.4 54.6 58. 6.4 5. 5. 57.0 60.9 5.0 5. 55.6 59.5 49.7 50.8 54. 58.0 47. 48. 5.6 55. 4.7 44.7 47.8 5. S/T 0.85 0.79 0.65 0.48 0.88 0.8 0.67 0.50 0.90 0.84 0.69 0.5 0.9 0.87 0.7 0.5 0.96 0.90 0.74 0.55 0.97 0.9 0.74 0.55 Delta T 7 6 8 7 6 8 7 6 8 7 6 8 7 6 8 5 4 7 KW.89.97 4.0 4. 4.9 4.8 4.4 4.56 4.45 4.55 4.70 4.86 4.69 4.79 4.95 5. 4.89 5.00 5.6 5.4 5.06 5.7 5.5 5.5 AMPS 0.0 0. 0.5 0.9 0.8.0.4.8.7.0.4.8.5.8..7..6 4. 4.6 4. 4.4 4.9 5.5 HI P 5 7 87 99 8 05 5 46 66 8 67 95 47 45 4 444 469 489 456 490 58 540 LO P 05 0 8 8 7 5 4 4 8 40 49 7 5 47 57 9 5 6 85 050 800 550 MBh 60.7 6.9 64.8 69. 59. 60.4 6. 67.5 57.9 59.0 6.8 65.9 56.4 57.5 60. 64. 5.6 54.7 57. 6. 49.7 50.6 5.0 56.6 S/T 0.96 0.9 0.84 0.68.00 0.96 0.87 0.7.00 0.99 0.89 0.7.00.00 0.9 0.75.00.00 0.96 0.78.00.00 0.96 0.78 Delta T 6 6 4 7 6 5 6 6 5 5 6 5 4 5 5 0 KW 4.05 4.4 4.7 4.4 4.7 4.46 4.6 4.76 4.64 4.75 4.90 5.07 4.89 5.00 5.7 5.4 5.0 5. 5.9 5.57 5.8 5.40 5.58 5.77 AMPS 0.4 0.7.0.4..5.9.4..5.0.4..4.9 4.4.9 4. 4.7 5. 4.8 5. 5.6 6. HI P 65 85 0 4 98 0 8 5 9 64 85 40 86 45 48 457 44 467 49 54 479 56 545 568 LO P 0 7 8 6 6 4 5 44 9 40 50 7 5 48 57 4 55 65 8 46 60 70 MBh 58.9 60. 6.9 67. 57.5 58.7 6.4 65.5 56. 57. 60.0 64.0 54.8 55.9 58.5 6.4 5. 5. 55.6 59. 48. 49. 5.5 54.9 S/T 0.9 0.89 0.80 0.65 0.95 0.9 0.8 0.67 0.98 0.94 0.85 0.69.00 0.97 0.88 0.7.00.00 0.9 0.74.00.00 0.9 0.75 Delta T 8 7 6 8 8 6 8 8 6 8 8 6 7 7 6 5 5 4 KW 4.0 4.0 4. 4.7 4. 4.4 4.57 4.7 4.6 4.7 4.86 5.0 4.85 4.96 5. 5.0 5.06 5.7 5.4 5.5 5.4 5.5 5.5 5.7 AMPS 0. 0.6 0.9...4.8...4.8..0..7 4..8 4. 4.6 5. 4.6 5.0 5.5 6. HI P 6 8 98 95 7 5 49 5 6 8 97 8 4 44 45 49 46 488 509 475 5 59 56 LO P 09 6 7 5 5 4 4 0 7 9 48 6 4 46 56 40 5 6 6 45 58 69 MBh 54.4 55.4 58. 6.9 5. 54. 56.7 60.5 5.8 5.8 55.4 59. 50.6 5.6 54.0 57.6 48. 49.0 5. 54.7 44.5 45.4 47.5 50.7 S/T 0.89 0.86 0.77 0.6 0.9 0.89 0.80 0.65 0.94 0.9 0.8 0.67 0.97 0.94 0.85 0.69.00 0.97 0.88 0.7.00 0.98 0.89 0.7 Delta T 9 8 7 9 8 7 9 9 7 9 9 7 9 8 7 6 6 5 KW.9 4.00 4. 4.6 4. 4. 4.45 4.60 4.49 4.59 4.74 4.90 4.7 4.8 4.99 5.6 4.9 5.04 5. 5.8 5.0 5. 5.9 5.58 AMPS 0. 0. 0.6.0 0.9..5.9.8..5.0.6.9..8.4.7 4. 4.7 4. 4.6 5.0 5.6 HI P 55 74 89 0 86 08 5 9 5 50 69 85 70 98 4 49 47 448 47 494 460 495 5 546 LO P 06 9 0 8 6 4 5 44 0 4 5 8 6 48 58 4 54 64 IDB = Entering Indoor Dry Bulb Temperature Shaded area reflects AHI atings conditions kw = Total system power High and low pressures are measured at the liquid and suction service ports. Amps: Unit amps (comp.+ evaporator + condenser fan motors) www.daikinac.com SS-DS
Airflow Data Tons Direct Drive Horizontal Direct Drive Down Shot FM Static Amps Watts PM Speed Tap FM Static Amps Watts PM Speed Tap 80 0..54 60 755 70 0..5 55 760 5 0..5 45 800 05 0..5 50 80 45 0..46 5 80 Low 45 0..49 40 840 080 0.4.4 5 870 085 0.4.45 0 875 Low 005 0.5.7 0 895 05 0.5.4 0 900 485 0..98 460 840 460 0.6.96 450 850 40 0..9 440 870 80 0..89 40 885 5 0..86 45 900 75 0..8 405 95 55 0.4.8 40 90 Med 75 0..7 400 950 70 0.5.75 400 950 075 0.4.68 80 965 Med 075 0.6.68 80 980 005 0.5.6 70 000 945 0.7.6 60 005 95 0.6.59 60 05 445 0.. 505 940 445 0.. 500 950 65 0.4.4 490 960 40 0.4. 480 975 70 0.5.08 470 985 75 0.5.07 465 000 High 80 0.6.0 460 000 75 0.6.0 455 00 High 050 0.7.9 45 00 040 0.7.9 40 045 85 0.8.78 400 055 80 0.8.78 95 070 Notes: Assumes dry coil with filter in place SFM correction for wet coil = 4% SS-DS www.daikinac.com
Airflow Data Tons ESP ( W..) Standard Belt Drive Down Shot Turns Open 0 4 5 FM BHP FM BHP FM BHP FM BHP FM BHP FM BHP 0. --- --- --- --- --- --- --- --- 58 0. 0 0.4 0. --- --- --- --- --- --- --- --- 0 0.9 044 0. 0. --- --- --- --- --- --- 09 0.4 044 0.7 854 0. 0.4 --- --- --- --- 0 0.4 050 0. 86 0.4 665 0.0 0.5 --- --- 7 0.7 4 0. 86 0.9 --- --- --- --- 0.6 --- --- 54 0.4 90 0.8 675 0.5 --- --- --- --- 0.7 70 0.4 99 0. 685 0.5 --- --- --- --- --- --- 0.8 09 0.7 807 0.8 --- --- --- --- --- --- --- --- 0.9 905 0.4 6 0.5 --- --- --- --- --- --- --- ---.0 660 0.9 --- --- --- --- --- --- --- --- --- --- ESP ( W..) High-Static Belt Drive Down Shot Turns Open 0 4 5 FM BHP FM BHP FM BHP FM BHP FM BHP FM BHP 0.6 --- --- --- --- --- --- --- --- --- --- --- --- 0.7 --- --- --- --- --- --- --- --- --- --- --- --- 0.8 --- --- --- --- --- --- --- --- --- --- 40 0.44 0.9 --- --- --- --- --- --- --- --- --- --- 4 0.4.0 --- --- --- --- --- --- --- --- 5 0.48 965 0.9. --- --- --- --- --- --- 80 0.55 06 0.44 804 0.7. --- --- --- --- --- --- 4 0.5 867 0.40 --- ---. --- --- --- --- 68 0.59 96 0.48 65 0.6 --- ---.4 --- --- 47 0.69 7 0.55 766 0.4 --- --- --- ---.5 --- --- 0.65 986 0.5 --- --- --- --- --- ---.6 90 0.7 04 0.59 8 0.48 --- --- --- --- --- ---.7 5 0.69 87 0.55 --- --- --- --- --- --- --- ---.8 06 0.66 --- --- --- --- --- --- --- --- --- --- 4 www.daikinac.com SS-DS
Airflow Data Tons (cont.) ESP ( W..) Standard Belt Drive Horizontal Turns Open 0 4 5 FM BHP FM BHP FM BHP FM BHP FM BHP FM BHP 0. --- --- --- --- --- --- --- --- --- --- 75 0.8 0. --- --- --- --- --- --- --- --- 67 0. 86 0.7 0. --- --- --- --- --- --- 74 0.9 86 0. 97 0.5 0.4 --- --- --- --- --- --- 9 0.6 95 0.8 756 0. 0.5 --- --- --- --- 77 0.6 980 0.4 78 0.6 --- --- 0.6 --- --- 0.9 056 0. 767 0. --- --- --- --- 0.7 --- --- 6 0.6 779 0.9 --- --- --- --- --- --- 0.8 40 0.4 97 0. --- --- --- --- --- --- --- --- 0.9 09 0.9 708 0.0 --- --- --- --- --- --- --- ---.0 749 0.4 --- --- --- --- --- --- --- --- --- --- ESP ( W..) High-Static Belt Drive Horizontal Turns Open 0 4 5 FM BHP FM BHP FM BHP FM BHP FM BHP FM BHP 0.6 --- --- --- --- --- --- --- --- --- --- --- --- 0.7 --- --- --- --- --- --- --- --- --- --- --- --- 0.8 --- --- --- --- --- --- --- --- --- --- 459 0.5 0.9 --- --- --- --- --- --- --- --- --- --- 0.50.0 --- --- --- --- --- --- --- --- 9 0.55 6 0.46. --- --- --- --- --- --- 455 0.6 08 0.5 947 0.4. --- --- --- --- --- --- 99 0.60 985 0.46 78 0.40. --- --- --- --- 409 0.65 094 0.54 740 0.4 --- ---.4 --- --- 480 0.76 5 0.6 870 0.49 --- --- --- ---.5 --- --- 0.7 095 0.57 --- --- --- --- --- ---.6 48 0.80 6 0.65 95 0.5 --- --- --- --- --- ---.7 66 0.75 90 0.60 --- --- --- --- --- --- --- ---.8 68 0.7 --- --- --- --- --- --- --- --- --- --- SS-DS www.daikinac.com 5
Airflow Data 4 Tons Standard Direct Drive Horizontal Standard Direct Drive Down Shot FM Static Amps Watts PM Speed Tap FM Static Amps Watts PM Speed Tap 570 0..09 490 905 548 0..0 480 90 50 0..06 480 90 500 0. 470 945 445 0..95 460 945 Low 45 0..89 450 970 Low 75 0.4.89 440 970 5 0.4.8 40 995 95 0.5.8 45 995 7 0.5 75 45 00 75 0..9 560 975 660 0.. 540 00 655 0.. 545 985 65 0..5 50 05 580 0..4 55 005 565 0..9 55 040 500 0.4.6 505 00 Med 485 0.4. 505 050 Med 405 0.5.09 490 05 405 0.5. 500 055 05 0.6.00 465 050 85 0.6.98 465 060 00 0.7.9 440 065 00 0.7.9 440 070 89 0..77 650 00 85 0..65 60 045 770 0..70 60 040 745 0..55 600 060 696 0..6 60 050 670 0..5 590 065 High 6 0.4.5 590 060 585 0.4.46 575 070 High 50 0.5.44 560 070 480 0.5.7 550 080 48 0.6.6 540 085 405 0.6. 55 090 Notes: Assumes dry coil with filter in place SFM correction for wet coil = 4% 6 www.daikinac.com SS-DS
Airflow Data 4 Tons (cont.) Standard Belt Drive Down Shot ESP (" W..) 0 Turns Turn Turns Turns 4 Turns 5 Turns FM BHP FM BHP FM BHP FM BHP FM BHP FM BHP 0. --- --- --- --- --- --- --- --- 7 0.4 588 0.4 0. --- --- --- --- --- --- 756 0.47 58 0.9 449 0. 0. --- --- --- --- 76 0.5 604 0.44 47 0.7 8 0. 0.4 --- --- 765 0.54 60 0.49 45 0.4 86 0.4 09 0.8 0.5 80 0.5 65 0.5 458 0.46 06 0.8 4 0. --- --- 0.6 70 0.56 55 0.48 4 0.4 5 0.6 --- --- --- --- 0.7 59 0.54 406 0.46 60 0.40 956 0. --- --- --- --- 0.8 446 0.5 47 0.4 98 0.6 --- --- --- --- --- --- 0.9 7 0.48 07 0.9 --- --- --- --- --- --- --- ---.0 45 0.44 987 0.9 --- --- --- --- --- --- --- ---. 059 0.44 --- --- --- --- --- --- --- --- --- --- High-Static Belt Drive Down Shot ESP (" W..) 0 Turns Turn Turns Turns 4 Turns 5 Turns FM BHP FM BHP FM BHP FM BHP FM BHP FM BHP 0.6 --- --- --- --- --- --- --- --- --- --- 64 0.5 0.7 --- --- --- --- --- --- --- --- 705 0.59 50 0.49 0.8 --- --- --- --- --- --- 75 0.64 576 0.56 78 0.47 0.9 --- --- --- --- --- --- 644 0.6 447 0.5 7 0.4.0 --- --- --- --- 77 0.69 55 0.58 94 0.49 070 0.40. --- --- --- --- 605 0.66 9 0.54 44 0.45 --- ---. --- --- 745 0.76 48 0.6 0.50 974 0.4 --- ---. 78 0.87 586 0.7 0.58 068 0.46 --- --- --- ---.4 658 0.8 47 0.66 77 0.5 --- --- --- --- --- ---.5 5 0.78 96 0.6 09 0.50 --- --- --- --- --- ---.6 87 0.7 0.57 --- --- --- --- --- --- --- ---.7 6 0.68 --- --- --- --- --- --- --- --- --- ---.8 096 0.65 --- --- --- --- --- --- --- --- --- --- SS-DS www.daikinac.com 7
Airflow Data 4 Tons (cont.) Standard Belt Drive Horizontal ESP (" W..) 0 Turns Turn Turns Turns 4 Turns 5 Turns FM BHP FM BHP FM BHP FM BHP FM BHP FM BHP 0. --- --- --- --- --- --- --- --- --- --- 76 0.7 0. --- --- --- --- --- --- --- --- 70 0.4 575 0.6 0. --- --- --- --- 888 0.57 744 0.48 56 0.4 98 0.4 0.4 --- --- --- --- 740 0.54 579 0.45 98 0.8 7 0. 0.5 --- --- 797 0.56 586 0.5 40 0.4 6 0.6 004 0.8 0.6 849 0.6 658 0.5 49 0.48 5 0.40 997 0. --- --- 0.7 7 0.59 58 0.5 66 0.45 09 0.6 --- --- --- --- 0.8 57 0.55 55 0.47 068 0.4 --- --- --- --- --- --- 0.9 4 0.5 7 0.4 --- --- --- --- --- --- --- ---.0 45 0.48 987 0.9 --- --- --- --- --- --- --- ---. 059 0.44 --- --- --- --- --- --- --- --- --- --- High-Static Belt Drive Horizontal ESP (" W..) 0 Turns Turn Turns Turns 4 Turns 5 Turns FM BHP FM BHP FM BHP FM BHP FM BHP FM BHP 0.6 --- --- --- --- --- --- --- --- --- --- 776 0.57 0.7 --- --- --- --- --- --- --- --- --- --- 65 0.54 0.8 --- --- --- --- --- --- --- --- --- --- 498 0.5 0.9 --- --- --- --- --- --- --- --- 7 0.6 45 0.47.0 --- --- --- --- --- --- 787 0.67 57 0.57 6 0.44. --- --- --- --- 745 0.7 668 0.6 407 0.5 960 0.40. --- --- --- --- 6 0.68 5 0.59 4 0.49 --- ---. --- --- 74 0.78 447 0.6 9 0.54 059 0.46 --- ---.4 80 0.90 55 0.7 79 0.58 6 0.50 --- --- --- ---.5 667 0.85 409 0.67 08 0.54 --- --- --- --- --- ---.6 508 0.80 0.6 --- --- --- --- --- --- --- ---.7 4 0.74 005 0.56 --- --- --- --- --- --- --- ---.8 9 0.70 --- --- --- --- --- --- --- --- --- --- 8 www.daikinac.com SS-DS
Airflow Data 5 Tons Standard Direct Drive Motor Horizontal Standard Direct Drive Motor Down Shot FM Static Amps Watts PM Speed Tap FM Static Amps Watts PM 5 0..4 65 60 05 0..47 80 65 50 0..46 75 645 50 0..54 85 675 085 0..54 80 690 065 0..59 85 70 T 00 0.4.64 95 75 980 0.4.68 95 760 900 0.5.74 05 780 860 0.5.79 00 80 840 0.6.77 5 80 800 0.6.8 0 840 95 0..86 0 670 75 0..94 5 690 5 0..95 40 705 00 0..0 45 70 60 0..0 50 75 0 0..05 55 750 0 0.4.0 60 770 80 0.4.5 65 790 5 0.5.6 65 80 T 00 0.5. 75 80 040 0.6.8 80 860 005 0.6. 85 890 970 0.7.8 90 885 970 0.7.4 95 900 90 0.8.46 00 95 95 0.8.5 0 940 840 0.9.5 0 955 845 0.9.57 5 980 790 0..4 45 80 755 0..4 85 850 75 0..7 45 80 700 0..47 95 865 670 0..45 450 865 665 0..56 40 895 60 0.4.55 465 890 580 0.4.68 45 90 560 0.5.60 475 90 T 545 0.5.7 45 955 50 0.6.70 490 945 505 0.6.80 50 990 470 0.7.80 500 970 40 0.7.9 50 00 40 0.8.94 50 995 70 0.8 4.08 55 040 45 0.9.98 50 05 00 0.9 4. 570 070 005 0. 4.0 575 880 945 0. 4.46 600 90 965 0. 4.4 590 900 90 0. 4.57 60 940 895 0. 4.5 60 90 850 0. 4.66 65 965 85 0.4 4.6 60 955 795 0.4 4.78 655 990 790 0.5 4.75 65 980 T4 760 0.5 4.84 670 00 745 0.6 4.84 650 005 70 0.6 4.96 685 045 695 0.7 4.9 660 00 640 0.7 5.06 675 065 650 0.8 5.0 675 055 60 0.8 5.9 690 090 600 0.9 5.0 675 080 560 0.9 5. 700 5 0 0. 5.0 690 90 090 0. 5.5 70 970 075 0. 5.5 70 950 040 0. 5.8 740 990 05 0. 5. 70 975 985 0. 5.70 755 05 975 0.4 5.5 75 995 95 0.4 5.44 760 05 90 0.5 5.46 750 00 T5 900 0.5 5.8 780 050 875 0.6 5.59 770 040 855 0.6 5.7 800 075 85 0.7 5.64 780 065 80 0.7 5.69 80 090 795 0.8 5.7 790 090 750 0.8 5.8 85 0 75 0.9 5.8 805 0 680 0.9 5.94 840 45 Speed Tap T T T T4 T5 Notes Assumes dry coil with filter in place; SFM correction for wet coil = 4% Five-ton models are shipped from the factory with speed tap set on T4. SS-DS www.daikinac.com 9
Airflow Data 5 Tons (cont.) Standard Belt Drive Down Shot ESP (" W..) 0 Turns Turn Turns Turns 4 Turns 5 Turns FM BHP FM BHP FM BHP FM BHP FM BHP FM BHP 0. --- --- --- --- --- --- 040 0.5 87.00 0.4 70 0.5 0. --- --- --- --- 046 0.58 90 0.50 758.00 0.4 586 0.4 0. --- --- 0 0.65 98 0.55 78 0.46 67.00 0.8 45 0. 0.4 090 0.74 08 0.6 80 0.5 65 0.4 49.00 0.5 90 0.8 0.5 005 0.7 897 0.59 698 0.49 505 0.40 48.00 0. --- --- 0.6 95 0.68 776 0.55 576 0.45 76 0.7 74.00 0.9 --- --- 0.7 85 0.64 657 0.5 44 0.4 7 0. --- --- --- --- 0.8 7 0.60 59 0.48 00 0.9 --- --- --- --- --- --- 0.9 587 0.56 97 0.44 --- --- --- --- --- --- --- ---.0 460 0.5 0 0.40 --- --- --- --- --- --- --- ---. 4 0.50 --- --- --- --- --- --- --- --- --- --- High-Static Belt Drive Down Shot ESP (" W..) 0 Turns Turn Turns Turns 4 Turns 5 Turns FM BHP FM BHP FM BHP FM BHP FM BHP FM BHP 0.6 --- --- --- --- --- --- --- --- --- --- 7 0.77 0.7 --- --- --- --- --- --- --- --- 8 0.87 048 0.74 0.8 --- --- --- --- --- --- --- --- 9 0.84 99 0.7 0.9 --- --- --- --- --- --- 58 0.9 97 0.80 78 0.66.0 --- --- --- --- 9.04 0.9 796 0.76 576 0.6. --- --- --- --- 49.00 99 0.84 66 0.7 4 0.58. --- --- 8.8 06 0.96 84 0.8 4 0.66 --- ---. 8.0 86. 874 0.9 650 0.76 --- --- --- ---.4 80.6 048.07 674 0.87 456 0.70 --- --- --- ---.5 4. 874.0 49 0.79 --- --- --- --- --- ---.6 009.7 75 0.96 --- --- --- --- --- --- --- ---.7 8.0 4 0.85 --- --- --- --- --- --- --- ---.8 474 0.98 --- --- --- --- --- --- --- --- --- --- 0 www.daikinac.com SS-DS
Airflow Data 5 Tons (cont.) ESP (" W..) Standard Belt Drive Horizontal 0 Turns Turn Turns Turns 4 Turns 5 Turns FM BHP FM BHP FM BHP FM BHP FM BHP FM BHP 0. --- --- --- --- --- --- --- --- 05 0.49 940 0.40 0. --- --- --- --- --- --- 47 0.57 975 0.47 78 0.9 0. --- --- --- --- 78 0.6 00 0.5 88 0.4 6 0.6 0.4 --- --- --- --- 057 0.60 855 0.50 678 0.4 450 0. 0.5 --- --- 0.68 90 0.57 69 0.47 55 0.8 5 0.9 0.6 5 0.78 995 0.64 77 0.5 546 0.44 0 0.4 --- --- 0.7 05 0.74 86 0.6 60 0.49 79 0.40 --- --- --- --- 0.8 9 0.70 78 0.57 46 0.46 0 0.7 --- --- --- --- 0.9 784 0.66 570 0.5 96 0.4 --- --- --- --- --- ---.0 64 0.6 7 0.48 --- --- --- --- --- --- --- ---. 477 0.58 00 0.44 --- --- --- --- --- --- --- ---. 9 0.5 --- --- ESP (" W..) High-Static Belt Drive Horizontal 0 Turns Turn Turns Turns 4 Turns 5 Turns FM BHP FM BHP FM BHP FM BHP FM BHP FM BHP 0.6 --- --- --- --- --- --- --- --- 94 0.94 04 0.8 0.7 --- --- --- --- --- --- 66.05 70 0.90 969 0.77 0.8 --- --- --- --- --- --- 0.0 060 0.87 89 0.74 0.9 --- --- --- ---.6 5 0.97 98 0.84 699 0.7.0 --- --- --- ---. 04 0.95 788 0.80 495 0.66. --- --- 6.6 5.09 880 0.9 66 0.75 --- ---. --- --- 7. 988.05 7 0.86 4 0.70 --- ---. 06.6 075.7 844.00 57 0.8 --- --- --- ---.4 96. 946. 68 0.94 86 0.76 --- --- --- ---.5 06.7 786.06 486 0.88 --- --- --- --- --- ---.6 95. 60.00 --- --- --- --- --- --- --- ---.7 785.6 44 0.94 --- --- --- --- --- --- --- ---.8 6.09 --- --- --- --- --- --- --- --- --- --- SS-DS www.daikinac.com
rankcase Heater, High Efficiency MEV Air Filter Option High Efficiency MEV Air Filter Option 0.50 Flanders Pre Pleat M Air Velocity vs esistance (Test Size: 4" x 4" x " High apacity) 0.45 0.40 " Deep esistance (in. w.g.) 0.5 0.0 0.5 0.0 0.5 0.0 0.05 0.00 0 00 00 00 400 500 600 700 Air Velocity (FPM) Tonnage: Filter Nominal Size: Part Number: Order QTY: 4 x 4 x 060L000 4 4 x 0 x 060L0004 4 5, 6, 7.5 6 x 0 x 060L0005 4 7.5(HP), 8.5, 0 6 X 4 X 060L0006 4.5 0 x 5 x 060L000 4 5, 0 0 x 5 x 060L000 6 5 0 X 0 X 060L000 8 rankcase Heater Selection Table ompressor Voltage rankcase ZP/ZPS ompressor Diameter 0V 460V 575V Heater Watts 6-5.5" 060000S 06000S 06000S 40 9-8 6.58/7." 00L0007S 00L0008S 00L0009S 70 0-7 9.4 00L0000S 00L000S 00L000S 90 D*,DT* & DS* Tonnage ompressor Voltage 0V 460V 575V rankcase Heater Watts Ton 060000S 06000S 06000S 40 4 Ton-.5 Ton 00L0007S 00L0008S 00L0009S 70 5-0 Ton** 00L0007S 00L0008S 00L0009S 70 5 Ton 00L0000S 00L000S 00L000S 90 *Includes,G&H models. **If ompressor Diameter is 9.4 then use 5 Ton rankcase heaters. www.daikinac.com SS-DS
Heat Kit Electrical Data (Blower Only, Heat Mode) Tons Model and Heat Kit Usage MA¹ at 08 / 40V MOP² (amps) at 08 / 40V Actual kw & BTU at 40V ecommended Airflow ange DS06***D*** 5 40 --- --- EHK0-0 56 60 0 50-50 FM EHK0-5 8 90 5 400-440 FM DS06***D*** 7 5 --- --- EHK-0 9 / 0 / 5 0 50-50 FM EHK-5 4 / 48 45 / 50 5 400-440 FM DS06***B*** 8 5 --- --- EHK-0 0 / 5 / 5 0 50-50 FM EHK-5 4 / 48 45 / 50 5 400-440 FM Model and Heat Kit Usage MA¹ at 480V MOP² (amps) at 480V Actual kw & BTU at 480V ecommended Airflow ange DS06***4B*** 0 5 --- --- EHK4-0 7 0 0 50-50 FM EHK4-5 5 5 5 400-440 FM Model and Heat Kit Usage MA¹ at 575V MOP² (amps) at 575V Actual kw & BTU at 575V ecommended Airflow ange DS06***7B*** 8 5 --- --- EHK7-0 5 0 0 50-50 FM EHK7-5 5 5 400-440 FM ¹ Minimum ircuit Ampacity ² Maximum Overcurrent Protection device kw orrection Factor kw orrection Factor for - & -Phase Units Supply Voltage 40 0 0 0 08 orrection Factor 0.9 0.8 0.78 0.76 Multiply rated kw by correction factor to get actual kw kw orrection Factor for 480V Units Actual Voltage 460 440 40 orrection Factor 0.9 0.84 0.8 For other voltage use voltage / 480 kw orrection Factor for 575V Units Supply Voltage 560 550 540 orrection Factor 0.95 0.9 0.88 Multiply rated kw by correction factor to get actual kw SS-DS www.daikinac.com
Heat Kit Electrical Data (Blower Only, Heat Mode) 4 Tons Model and Heat Kit Usage MA¹ at 08 / 40V MOP² (amps) at 08 / 40V Actual kw & BTU at 40V ecommended Airflow ange DS048***D*** 9 45 --- --- EHK-0 56 60 0 400-800 FM EHK-5 8 90 5 575-800 FM EHK-8 98 00 8 575-800 FM DS048***D*** 0 --- --- EHK-0 9 / 4 5 / 5 0 400-800 FM EHK-5 4 / 49 45 / 50 5 575-800 FM EHK-8 50 / 58 60 / 60 8 575-800 FM DS048***B*** 0 --- --- EHK-0 0 / 5 5 / 5 0 400-800 FM EHK-5 4 / 50 45 / 50 5 575-800 FM EHK-8 5 / 59 60 / 60 8 575-800 FM Model and Heat Kit Usage MA¹ at 480V MOP² (amps) at 480V Actual kw & BTU at 480V ecommended Airflow ange DS048***4B*** 0 5 --- --- EHK4-0 7 0 0 400-800 FM EHK4-5 5 5 5 575-800 FM EHK4-8 9 0 8 575-800 FM Model and Heat Kit Usage MA¹ at 575V MOP² (amps) at 575V Actual kw & BTU at 575V ecommended Airflow ange DS048***7B*** 8 5 --- --- EHK7-0 5 0 0 400-800 FM EHK7-5 5 5 575-800 FM EHK7-8 5 0 8 575-800 FM ¹ Minimum ircuit Ampacity ² Maximum Overcurrent Protection device kw orrection Factor kw orrection Factor for - & -Phase Units Supply Voltage 40 0 0 0 08 orrection Factor 0.9 0.8 0.78 0.76 Multiply rated kw by correction factor to get actual kw kw orrection Factor for 480V Units Actual Voltage 460 440 40 orrection Factor 0.9 0.84 0.8 For other voltage use voltage² / 480² kw orrection Factor for 575V Units Supply Voltage 560 550 540 orrection Factor 0.95 0.9 0.88 Multiply rated kw by correction factor to get actual kw. 4 www.daikinac.com SS-DS
Heat Kit Electrical Data (Blower Only, Heat Mode) 5 Tons Model and Heat Kit Usage MA¹ at 08 / 40V MOP² (amps) at 08 / 40V Actual kw & BTU at 40V ecommended Airflow ange DS060***D*** 4 60 --- --- EHK-0 6 70 0 750-50 FM EHK-5 87 90 5 750-50 FM EHK-0 5 0 850-50 FM DS060***D*** 9 45 --- --- EHK-0 4 / 40 5 / 45 0 750-50 FM EHK-5 47 / 55 50 / 60 5 750-50 FM EHK-0 60 / 70 70 / 70 0 850-50 FM DS060***B*** 5 40 --- --- EHK-0 0 / 5 5 / 40 0 750-50 FM EHK-5 4 / 50 45 / 50 5 750-50 FM EHK-0 56 / 65 60 / 70 0 850-50 FM Model and Heat Kit Usage MA¹ at 480V MOP² (amps) at 480V Actual kw & BTU at 480V ecommended Airflow ange DS060***4B*** 0 --- --- EHK4-0 9 0 0 750-50 FM EHK4-5 5 5 5 750-50 FM EHK4-0 5 5 0 850-50 FM Model and Heat Kit Usage MA¹ at 575V MOP² (amps) at 575V Actual kw & BTU at 575V ecommended Airflow ange DS060***7B*** 0 5 --- --- EHK7-0 5 0 0 750-50 FM EHK7-5 5 5 750-50 FM EHK7-0 8 0 0 850-50 FM EHK7-5 4 5 5 --- ¹ Minimum ircuit Ampacity ² Maximum Overcurrent Protection Device kw orrection Factor kw orrection Factor for - & -Phase Units Supply Voltage 40 0 0 0 08 orrection Factor 0.9 0.8 0.78 0.76 Multiply rated kw by correction factor to get actual kw kw orrection Factor for 480V Units Actual Voltage 460 440 40 orrection Factor 0.9 0.84 0.8 For other voltage use voltage / 480 kw orrection Factor for 575V Units Supply Voltage 560 550 540 orrection Factor 0.95 0.9 0.88 SS-DS www.daikinac.com 5
Dimensions TOP VIEW.65.805 FLUE/VENT OUTLET OMBUSTION AI INLET (GAS UNITS) GAS LINE ENTANE 7.945 FONT VIEW ALL DIMENSIONS GIVEN AE IN INHES ALL DIMENSIONS AND SPEIFIATIONS AE SUBJET TO HANGE WITHOUT NOTIE SUPPLY AI DUT.000 4.475 0.060 6.96 DS06-060 THU 5 TON OMMEIAL.540.000 7.65 7.000 ONDENSATE DAIN OUTLET LIFTING SHAKLE HOLES BOTH SIDES AND ENDS 48.96 FOK HOLES BOTH SIDES AND BOTH ENDS 0.85 IGHT END VIEW ETUN AI DUT 6 www.daikinac.com SS-DS
Dimensions (cont.) 9.470 5.04.000 ONDENSATE DAIN BOTTOM EXIT SUPPLY AI DUT 7.000 48..44.000 0.905 6.9 5.558 5.000 ETUN AI DUT 74.06 BASE PAN VIEW (VIEWED FOM TOP) ONDENSATE MODEL TONNAGES "A" "B" "" TON OMMEIAL GAS, HT MP, AI ONDITIONE 8.840 6.555 6.055 4 TON OMMEIAL GAS, HT MP, AI ONDITIONE 8.840 6.555 6.055 5 TON OMMEIAL GAS, AI ONDITIONE 8.840 6.555 6.055 BOTTOM EXIT 7.984 LINE WIE ENTANE "A" "" "B" 8.555 TSTAT WIE ENTANE 5.87 0.7 LEFT END VIEW SS-DS www.daikinac.com 7
Unit learances Maintain an adequate clearance around the unit for safety, service, maintenance, and proper unit operation. Leave a total clearance of 75 on the main control panel side of the unit for possible removal of fan shaft, coil, electric heat, and gas furnace. Leave a clearance of 48 on all other sides of the unit for possible compressor removal or service access, and to ensure proper ventilation and condenser airflow. Do not install the unit Beneath any obstruction. Install the unit away from all building exhausts to inhibit ingestion of exhaust air into the unit s fresh-air intake. Electrical Entrance Locations High-Voltage Entrance (emove Plug) ⅜ 0¼ Low-Voltage Entrance Low-Voltage Entrance ½ Dia. Power Thru the urb 47½ 7½ 8 www.daikinac.com SS-DS
oof urb Installation igging Provisions for forks have been included in the unit base frame. No other fork locations are approved. Unit must be lifted by the four lifting holes located at the base frame corners. Lifting cables should be attached to the unit with shackles. The distance between the crane hook and the top of the unit must not be less than 60. Two spreader bars must span over the unit to prevent damage to the cabinet by the lift cables. Spreader bars must be of sufficient length so that cables do not come in contact with the unit during transport. emove wood struts mounted beneath unit base frame before setting unit on roof curb. These struts are intended to protect unit base frame from fork lift damage. To remove the struts, extract the sheet metal retainers and pull the struts through the base of the unit. efer to rigging label on the unit. Important: If using bottom discharge with roof curb, duct-work should be attached to the curb prior to installing the unit. Duct-work dimensions are shown in oof urb Installation Instructions Manual. efer to the oof urb Installation Instructions for proper curb installation. urbing must be installed in compliance with the National oofing ontractors Association Manual. Lower unit carefully onto roof mounting curb. While rigging the unit, the center of gravity will cause the condenser end to be lower than the supply air end. Bring condenser end of unit into alignment with the curb. With condenser end of the unit resting on curb member and using curb as a fulcrum, lower opposite end of the unit until entire unit is seated on the curb. When a rectangular cantilever curb is used, take care to center the unit. heck for proper alignment and orientation of supply and return openings with duct. To assist in determining rigging requirements, unit weights are shown below. orner & enter-of-gravity Locations Unit Weights -Ton Weights 4-Ton Weights 5-Ton Weights 0 ondenser oil eturn Evaporator oil orner Weight (A) orner Weight (B) 67 68 68 orner Weight () 7 8 8 orner Weight (D) 50 5 5 Unit Shipping Weight 565 570 570 Unit Operating Weight 590 595 595 Supply ompressor Note: Weights are calculated without accessories installed. 7 urb installations must comply with local codes and should follow the established guidelines of the National oofing ontractors Association. Proper unit installation requires that the roof curb be firmly and permanently attached to the roof structure. heck for adequate fastening method prior to setting the unit on the curb. Full perimeter roof curbs are available from the factory and are shipped unassembled. The installing contractor is responsible for field assembly, squaring, leveling, and mounting on the roof structure. All required hardware necessary for the assembly of the sheet metal curb is included in the curb accessory package. Determine sufficient structural support before locating and mounting the curb and package unit. Duct-work must be constructed using industry guidelines. The duct-work must be placed into the roof curb before mounting the package unit. Our full perimeter curbs include duct connection frames to be assembled with the curb. antilevered-type curbs are not available from the factory. ontractor furnishes curb insulation, cant strips, flashing, and general roofing material. Support curbs on parallel sides with roof members. To prevent damage to the unit, the roof members cannot penetrate supply and return duct openings. Note: The unit and curb accessories are designed to allow Down Shot duct installation before unit placement. Duct installation after unit placement is not recommended. See the manual shipped with the roof curb for assembly and installation instructions. SS-DS www.daikinac.com 9