FieldIT TZIDC-110 Electro-Pneumatic Positioner

Similar documents
TZIM. Electropneumatic Analog Positioner 10/ EN

Field IT Actuators & Positioners Electro-Pneumatic Converters I/P Signal Converters Standard Model with Booster Stage

Actuators & Positioners Electro-Pneumatic Converters I/P Signal Converters - TEIP 11 Model without Booster Stage

FICHA TÉCNICA DE PRODUTO

Field instrumentation. Electropneumatic units. as I/P converters and positioners

ABB MEASUREMENT & ANALYTICS DATA SHEET. TEIP11 I/P signal converter for standard signals

Positioners Converters Limit Switches Position Transmitters Solenoid Valves Accessories. Selection and Application

V200 Positioner. V200 P Pneumatic Positioner. V200 E Electropneumatic Positioner. Housing Material: Cast aluminium with polyester coating

Series 3730 Electropneumatic Positioner Type

Type Electronic Limit Switch

PositionMaster EDP300 Electro-Pneumatic Positioner. Compact, well-proven, and flexible. High air capacity

Electrical Linear Actuator RSD10 / RSD20 (Contrac)

Electronic Limit Switch Type

EAS822 (Contrac) Power Electronic Unit

RSDE10 / RSDE20 (Contrac) Electrical Linear Actuator

ARCAPRO positioner. Positioner customized for specific tasks

SMART VALVE POSITIONER 4 to 20 ma + HART Digital Communication. smar B87

Type 3761 Pneumatic or Electropneumatic Positioner for Rotary Actuators. Fig. 1 Type 3761 Positioner. Mounting and Operating Instructions EB 8386 EN

Field IT Actuators & Positioners Rotary Actuators - Rated Torque 100 Nm (80 ft-lbs) PME 120-AI/AN. Rotary Actuators Rated Torque 100 NM (80 ft-lbs)

TECHNICAL BULLETIN. Logix 510si Series Digital Positioner. Experience In Motion FCD LGENTB /09

RSD100 (Contrac) Electrical Linear Actuator

POSITIONERS and Controls for Complete Valve Automation

Versions. Version with K VS Version with K VS 2.0. Fig. 1: Type 3967 Solenoid Valve

Contrac RSD 200. Electrical Linear Actuator for Continuous Control Rated Force 200 kn 10/ EN. Application. Positioning:

Limit Switch Type 4747

SP1 Smart Positioner Installation and Maintenance Instructions

4.3 MSK SWITCH BOX MSK (SIZE I) FEATURES ADVANTAGES

Solenoid Valves Type 3963

VAC D500 Electro-Pneumatic Positioner. Compact, well-proven, and. High air capacity. Approvals for explosion protection ATEX IECEx FM / CSA GOST

Solenoid Valve Island Type 3965

Model WEP Electro-pneumatic positioner. WEP positioner A valve control without compromise

System Electropneumatic Converters (Proportional Valves) Electronic Process Controllers Signal Converters

Intelligent Positioner

Pneumatic or Electropneumatic Positioner for Rotary Actuators Type Fig. 1 Type 3761 Positioner. Mounting and Operating Instructions EB 8386 EN

System 6000 Electropneumatic Converter for Direct Current Signals Type 6116 i/p Converter

Actuators & Positioners Pneumatic Actuators Series UP1/2/3/4/5/6

TECHNICAL BULLETIN. Logix 520MD Series Digital Positioner. Experience In Motion FCD LGENTB /09

JUMO dtrans p20. Process pressure transmitter. Type Brief description. Key features. Block diagram

FasTrak High Capacity Smart Positioner

AS-I

T 3965 EN Type 3965 Solenoid Valve Island To control pneumatic actuators

SMART VALVE POSITIONER 4 to 20 ma + HART Digital Communication. smar

PHOENIX CONTACT - 01/2008

TECHNICAL BULLETIN. Logix 505si Series Digital Positioner. Experience In Motion FCD LGENTB /13

Type 4746 Electric or Pneumatic Limit Switch

Type Installation, Operation and Maintenance Instructions. Ordering Information. Contents CA20 -

3/2-, 5/2- and 5/3-way Solenoid Valves for process pneumatics

Type 2511/12. Type Type 2030 Cable plug. ASI cable plug. Dosing control. General technical data Orifice Type 6518

Digital Positioner 8049

Mounting and Operating Instructions EB EN. Series 3730 Electropneumatic Positioner Type with HART communication and pressure sensors

3/2-, 5/2- and 5/3-way Solenoid Valves for process pneumatics

Digital Positioner 8049

+ = Angle-seat Valve System for continuous control. Type 8802/2300 electro-pneumatically operated angle-seat valve

VALVE CONTROLLERS Controllers for Dust Extr 2010 / 2011 action Technology

SS3 Linear / Rotary. Smart Valve Positioner. Smart performance with innovative and ever-strong coil drive even under harsh working environments

ABB ACTUATORS & POSITIONERS

Integrated Control modules

3/2 Way Pilot Valve 3/2 Way Solenoid Valve 1 /4" and 1 /2" 5/2 Way Solenoid Valve 1 /4" 6/2 Way Solenoid Valve 1 /4" 5/3 Way Solenoid Valve 1 /4"

SRD998 Intelligent Positioner with HART Communication

Pneumatic control unit for decentralized automation of ELEMENT process valves

Vortex Flowmeter FV4000 (TRIO-WIRL V) Swirl Flowmeter FS4000 (TRIO-WIRL S) For flow rate and volume measurement of liquids, gases and steam

Intelligent Positioner

Electropneumatic Positioner Type Fig. 1 Type Mounting and Operating Instructions EB EN

SS2 Linear / Rotary Smart Valve Positioner

2600T Series Pressure Transmitter

Level Measurement. Point level measurement Capacitance switches. Pointek CLS200 Standard. icenta Controls Ltd

TOP-QUALITY PNEUMATIC ACTUATOR

Limit Switch Type 3776

Pneumatic Positioner Type 3766 Electropneumatic Positioner Type 3767

SRD998 Intelligent Positioner (Version HART Basic Diagnostic)

Level Measurement Point level measurement - RF Capacitance switches

Level Measurement. Point level measurement Capacitance switches. Pointek CLS200 Standard. 4/18 Siemens FI Overview.

TopControl Continuous

Kämmer Actuators Series 4 Pneumatic and Electropneumatic

AS-I

Valve Accessories. Limit switches, solenoid valves, lock-up valves, supply pressure regulators, volume boosters, quick exhaust valves, applications

2/2-way Diaphragm Valve with stainless steel design, weld end or clamp connection, DN 8-25

Models UP1/2/3/4/5/6/7 Universal pneumatic rotary actuators. Measurement made easy. High performance actuators for precision damper control

Electropneumatic Converters i/p Converters Type 6111 Mounting and Operating Instructions EB 6111 EN

TECHNICAL BULLETIN. Logix 510si Series Digital Positioner. Experience In Motion FCD LGENTB /13

Intelligent Positioner

NAMUR FLANGE: With integrated exhaust air recirculation Ordering information

Electrical position indicators and combi switchboxes for linear and quarter turn valves

Level instruments. Continuous level measurement - Capacitance transmitters SITRANS LC300. 5/262 Siemens FI Overview.

Limit Switch Type 3776

Differential Pressure and Flow meters Accessories for the Media Series

Prism PI Intelligent features offer advanced performance

INLINE Flow sensor for hazardous area II 1 G/D - II 2 D - II 3 GD - I M1

Mounting and Operating Instructions EB EN ( ) Series 3730 Type Electropneumatic Positioner. with PROFIBUS-PA communication

We reserve the right to alter data according to improvements made. Previous documents become invalid with the issue of this document.

Series 430 Type 3430 Pneumatic Indicating Controller for Temperature with Capillary Sensor Type 3432 Controller Station Type 3436 Transmitter Module

FlowPak TM General Application Valve DN , PN 10 / 40

SMARTRONIC AS-i. Type Series Booklet

HART NEW. Digital Positioner PFLEX - Hart Protocol. Characteristics

Fisher i2p 100 Electro Pneumatic Transducer

Remote Process Actuation Control System AirLINE WAGO Remote I/Os and Fieldbusses

Double Acting & Spring Return. SERIES 92/93 Rack & Pinion PNEUMATIC ACTUATOR. The High Performance Company

Mounting and Operating Instructions EB EN

Valve Positioner. Product Guide. Field Devices for Measurement & Instrumentation.

Field IT Actuators & Positioners. Intelligent Electric Modulating Actuator. Contrac RHD Intelligent Electric Modulating Actuator

Transcription:

Data Sheet FieldIT TZIDC-110 Electro-Pneumatic Positioner Compact and efficient through well-proven technology and intelligence Communication based on PROFIBUS PA fieldbus connection to IEC 61158-2 current consumption 10.5 ma, 9...32 V DC Simple commissioning procedure, user-friendly fully automatic Autoadjust function adjustment via the built-in operator panel or remotely mechanical position indicator Complies with the EC directives for EMC and CE Explosion protection certificates, intrinsically safe Robust and environmentally ruggedized influence of shock and vibration < 1% aluminum case, IP 65 (NEMA 4X) Wide operating temperature range - 40 C to + 85 C (- 40 to + 185 F) Attachment to linear or rotary actuators P R O F I PROCESS FIELD BUS B U S Optional pressure gauge block and filter regulator Low operating cost air consumption of less than 0.03 kg/h Smart Compact and efficient

Concept The TZIDC-110 positioner is an intelligent and electronically configurable instrument with communication capabilities, mounting to pneumatic actuators. The TZIDC-110 stands out for a small and compact design, a modular construction, and an excellent cost-performance ratio. The functional heart of the TZIDC-110 positioner is its microprocessor-controlled CPU where the operating system is running. The position feedback signal is polled with a sampling rate of 20 ms and an A/D resolution of 16,000 steps. This ensures a rapid and high-precision signal processing for the input and the position feedback. The power for the CPU is derived from the bus. The operating program includes functions for fully automatic adjustment in the commissioning phase. These functions provide for optimal control of the position to minimize control deviation. The pneumatic actuator is driven by an I/P module with subsequent 3/3-way valve. The electrical positioning signal from the CPU is proportionally converted into a pneumatic signal which, in turn, adjusts the 3/3-way valve. The cross-sectional area of the valve air channels for filling the actuator with air or evacuating air from it is changed in proportion with the adjustment. When reaching the set point, the 3/3-way valve is closed in center position. The positioner has an operating panel consisting of a 2-line LCD and 4 push-buttons. The operating panel has the perfect design for optimal local configuration, commissioning, and operational monitoring. Alternatively, the TZIDC-110 can be configured, commissioned and monitored via the fieldbus, by using the appropriate configuration program. The modular design of the positioner allows you to add further functionality at a later time. Assembly kits for mechanical position indication for digital position feedback using proximity switches or 24 V microswitches are available. Additionally, the plug-in module for the shutdown function is available. Various TZIDC-110 features ensure safe valve operation on site: Compliance with the EMC Directive Robust aluminum case, protection IP 65 (NEMA 4X) High resistance to shock and vibration up to 10 g Operational reliability through permanent internal monitoring Message generation Operation at ambient temperatures of - 40 to + 85 C (- 40 to + 185 F) Options Microprocessor Bus connector Nonvolatile memory CPU Plug-in module for safety shutdown (forced decompression) 24 V DC Optocoupler (Shutdown function) Mechanical position indicator Air supply 1.4...6 bar Outgoing air I/P module with 3/3-way valve Position Position feedback Min. Max. or 24V microswitch min./max. position Fig.1: TZIDC-110 schematic diagram 2

Mounting To linear actuators in accordance with the standard Lateral attachment is in accordance with DIN/IEC 534 (lateral attachment to NAMUR). The required attachment kit is a complete set of attachment material, but does not include the screwed pipe connections and air pipes. To rotary actuators in accordance with the standard Attachment to rotary actuators is in accordance with VDI/VDE 3845. The attachment kit contains the adapter for coupling the positioner feedback shaft to the actuator shaft, and mounting brackets for mounting the positioner to the actuator. Screwed pipe connections and air pipes are not included in the kit and have to be provided by the customer. Integral mounting to control valves The TZIDC-110 positioner is ready for integral mounting. The appropriate threaded holes are available at the positioner s back. The benefit of this design is that the point for mechanical stroke measurement is inside the yoke and, thus, protected by it. No external tubing is required, since the air flow from the positioner to the actuator is guided through an internal channel bore. Special actuator-specific mounting In addition to the mounting methods described above, there are special actuator-specific attachments. Please contact us for details. Fig. 2: Mounting to linear actuators to DIN/IEC 534 Fig. 4: Mounting to rotary actuators to VDI/VDE 3845 Fig. 3: Integral mounting to control valves Fig. 5: Integral mounting to control valves by using an adapter panel 3

Operation General The intelligent microprocessor-controlled TZIDC-110 positioner is designed for achieving optimal results. Its stands out for quick and precise control until reaching the set point and for high operational reliability. The activation and adjustment of parameters necessary to achieve this goal is done automatically by the Autoadjust function. If required, the settings can be changed manually. The total range of parameters includes: Operating parameters Adjustment parameters Monitoring parameters Diagnosis parameters Operating parameters The following operating parameters can be activated and adjusted: Characteristic curve (travel = f {pos. signal}) linear, equal percentage 1:25 or 1:50 or 25:1 or 50:1, or user-configurable with 20 reference points Tolerance band When reaching the tolerance band the position is considered as having reached the setpoint. From this point on, the position is further slowly re-adjusted until the dead band is reached. The factory setting for this parameter is 0.3 %. Dead band (sensitivity) When reaching the dead band, the position is held. The factory setting for this parameter is 0.1 %. Both the tolerance band and the dead band are automatically determined during the positioner s self-optimization. Travel limiting The positioning travel, i.e. the stroke or angle of rotation, can be reduced as required within the full range of 0...100%, provided that a minimum value of 20% is observed. Shut-off function This function can be selected separately for each end position. When the respective configured limit value is exceeded, the shut-off function causes immediate travel of the actuator until reaching the set end position. Travel time prolongation With this function the max. travel time for full travel can be increased. This time parameter can be set separately for each direction Control in the end position Here you can define whether the pneumatic actuator shall be fully pressurized or the position shall be further controlled in the end position. This parameter can be set separately for each end position. Adjustment parameters The TZIDC-110 positioner has a special function (Autoadjust) for automatic adjustment of all relevant parameters. The Autoadjust function can be started by pressing the respective push-buttons on the device s front panel or by using the configuration program on a remote PC. The following parameters can be activated and adjusted: Control parameters To adapt the TZIDC-110 positioner to the control action of the valve, the control parameters can be adjusted individually to achieve optimal control until reaching the set point. Valve range 0...100 % Valve end positions, start of range "0 % and end of range "100 %". Effective direction of the actuator Adjustment to either of the two possible directions: Air to open/spring force to close or Air to close/spring force to open Display 0...100 % Adjusting the display (0...100 %) to the direction of action for opening or closing the valve. Monitoring parameters Various functions for permanent device monitoring are implemented in the operating program of the TZIDC-110 positioner: Internal output circuit monitoring Monitoring to check whether or not the position is out of the adjusted range (rotation angle) for position feedback. Monitoring for positioning time-out (adjustable time parameter) Monitoring of the stroke and travel counter to check if the limit value is exceeded (limits can be adjusted during diagnosis) While automatic commissioning is in progress, the current state is continuously indicated on the integrated LC display. All other messages can be called up for display via the graphical user interface. Extended monitoring is possible via the fieldbus. The most important process variables like the output signal (in %), the position (in %), the deviation (in %), and troubles occurring during operation are indicated as plain text in a special line. Diagnosis parameters The diagnosis parameters of the TZIDC-110 program inform the operator about the operating conditions of the valve. From this information the operator can derive which maintenance works are required, and when. Additionally, limit values can be defined for these parameters. When they are exceeded, an alarm is reported. The following values are e.g. determined: Number of control actions performed by the valve Total stroking distance The diagnosis parameters and limit values can be called up, set, and reset via the fieldbus, by using the special TZIDC-110 configuration program. 4

Operator panel The TZIDC-110 positioner s operator panel allows for monitoring manual control TZIDC-110 configuration fully automatic commissioning Operation The panel s four push buttons (see illustration) are used for selecting the individual operating levels, parameterizing the device, and saving the settings. In addition to the already known operating functions there is a special feature: a simplified autoadjustment routine can be started easily through only few operator actions, and without knowing parameterization details. When the positioner is changed over from a linear to a rotary actuator, the zero position of the display is changed automatically. As a result, 0% is indicated in the display for a valve that is closed by turning clockwise. Display The information indicated by the 2-digit LC display is permanently updated and adapted during operation, to inform the operator in an optimal way. In bus mode (REMOTE), the following TZIDC-110 data can be called up by pressing the push-buttons briefly: Enter Software revision Up arrow For cyclic communication: Setpoint (%) and setpoint state (decimal) For acyclic communication: communication state Down arrow Operating mode on the bus and address in the device conf C % ma ENTER MODE Fig. 6: TZIDC-110 operating elements Configuration program General The graphical user interface for the TZIDC-110 positioner is based on the FDT/DTM technology (FDT 0.98-1) and can be integrated in an open control system or loaded into a PC with the configuration program SMART VISION. With this you can use the same user interface in the commissioning phase, during operation, and for service tasks for monitoring the device, setting parameters, and uploading data. In all cases the communication is realized via the fieldbus connection. In accordance with the PROFIBUS conventions it is possible to read data during cyclic data exchange (AUT, MAN or RCAS mode) and write data in the O/S (Out of Service) mode. Newly set parameters are saved in the non-volatile memory directly upon the download into the device, and are immediately active. Fig. 7: Direct link to a PC/laptop 5

Technical data Communication Profiles Profibus PA Profile for Process Control Devices Electro-Pneumatic Actuators V3.0 Block types 1 AO Function Block, 1 Transducer Block, 1 Physical Block Physical layer Compliant to the standard IEC 61158-2 Communication speed 31.25 Kbit/s Operating voltage Bus-powered: 9.0 V DC - 32.0 V DC Max withstand voltage 35 V DC Current consumption 10.5 ma Fault current 15 ma (10.5 ma + 4.5 ma) Name value Physical device tag TZID-C110 PNO ID number 0x0639 Device ID 0X3200028xyz Device address Between 0 and 126, default node address 126 Output Range 0...6 bar (0...90 psi) Air capacity at supply pressure of 1.4 bar (20 psi): 5.0 kg/h = 3.9 Nm 3 /h = 2.3 scfm at supply pressure of 6 bar (90 psi) 13 kg/h = 10 Nm 3 /h = 6.0 scfm (Booster for increasing air capacity on request) Function for single or double acting actuators, air is vented from actuator or actuator is blocked in case of an electrical power failure Shut-off value When the setpoint exceeds or falls below the defined limit value, the actuator immediately moves to the 0% or 100 % position. Travel Angle of rotation Used range 25...120 (rotary actuators, optionally 270 ) 25...60 (linear actuators) Travel time prolongation Range 0...200 seconds, individually configurable for each direction Dead band time limit Range 0...200 seconds (monitoring parameter for control until the deviation is within the tolerance band) Stroke limiting Min. and max limits, freely configurable within 0...100% of total travel (> 20 %) Air supply Instrument air Free of oil, water and dust to DIN/ISO 8573-1 Pollution and oil contents according to Class 3 (purity: max. particle size 5 µm, max. particle density 5mg/m 3, oil contents: max. concentration 1 mg/m 3 ; dew point at least 10 C below operating temperature) Supply pressure 1.4...6 bar (20...90 psi) Caution: Do not exceed the max. operating pressure of the actuator! Air consumption < 0.03 kg/h (0.08 scfm) (independent of supply pressure) Transmission data and influences Action (output signal or pressure in the actuator) Direct: Increasing signal 0...100 ma Increas. pressure OUT1 in the actuator Reverse: Increasing signal 0...100 ma Decreas. pressure OUT1 in the actuator Characteristic curve (travel = f {signal}) Linear, equal percentage 1:25 or 1:50 or 25:1 or 50:1 and freely configurable with 20 reference points Characteristic deviation < 0.5 % Tolerance band 0.3...10 %, adjustable Dead band 0.1... 5 %, adjustable Resolution (A/D conversion) 16,000 steps Sample rate 20 milliseconds Influence of ambient temperature < 0.5 % for every 10 C change in temperature Influence of vibration +/-1 % up to 10 g and 80 Hz Seismic requirements Meets requirements of DIN/IEC 68-3-3 Class III for strong and strongest earthquakes Influence of mounting orientation No effect Meets the following requirements EMC Directive 89/336/EEC as of May 1989 EC Directive for the CE conformity marking 6

Environmental capabilities Ambient temperature -40 to +85 C (- 40 to + 185 F) for operation, storage and transport Relative humidity Operational (with closed housing and air supply switched on): 100 %, condensation permissible Transport and storage: 75 % (annual average), non-condensing Case Material/protection Aluminum, protection IP 65 (NEMA 4X) Surface/Color Electrostatic dipping varnish with expoxy resin, stove-enamelled Bottom part of case varnished black, RAL 9005, matt, Cover white aluminum, RAL 9006 Electrical connections Screw terminals max. 1.0 mm 2 for options, max. 2.5 mm 2 for bus connection Caution: Do not expose the terminals to strain! Cable entry 2 threads Pg. 13.5, 1/2-14 NPT or M20x1.5 for cable diameter 6...12 mm 1 with cable gland and 1 with pipe plug Pneumatic connections Threads G 1/4 or 1/4-18 NPT Weight 1.7 kg Mounting orientation any orientation allowed Dimensions see dimensional drawings Explosion protection FM/CSA (pending) ATEX II 2G EEx ia II C T6 Type examination certificate TÜV 02 ATEX 1831 X Type: Intrins. safe equipment Device class: II 2G (EEx ia IIC) Temperature class: T4, T5, T6 Permissible ambient temperature: T4: -40 C T amb 85 C T5: -40 C T amb 55 C T6: -40 C T amb 40 C ATEX II 3G EEx n A II T6 Type examination certificate TÜV 02 ATEX 1943 X Type: Explosion-proof equipment for zone 2 Device class: II 3G (EEx n A II) Temperature class: T4, T5, T6 Permissible ambient temperature: T4: -40 C T amb 85 C T5: -40 C T amb 65 C T6: -40 C T amb 50 C Signal current circuit for Profibus PA, only for connection to a certified intrinsically safe circuit (e.g. FISCO power unit or barrier) with the following max. values: FISCO ia/ib for group IIB/IIC FISCO ia/ib for group IIB/IIC Barrier or power supply unit ia/ib for group IIB/IIC Vi = 17.5 V Vi = 17.5 V Vi = 24 V Ii = 380 ma Ii = 360 ma Ii = 250 ma Pi = 5.32 W Pi = 2.52 W Pi = 1.2 W rectangular trapezoidal linear 7

Options Module for the shutdown function Supply voltage V min = 20 V, V max = 30 V Safe pos. is activated when V < 5 V AK approval AK 4 to DIN V 19250 Test report No. 101/S01/148 Explosion protection EEx ia IIC In case of a 24 V DC power failure, the positioner can let the valve move to the safe position by depressurizing the actuator independently of the processor. To achieve this, the I/P module power supply is separated by an optocoupler. Both the communication and feedback are still active, since the positioner is powered via the bus line. The shutdown input is electrically isolated from the control signal. Due to the shutdown function no additional solenoid valves are required. It has a safety certificate from TÜV Rheinland in accordance with AK4. The plug-in module also has an Ex certificate for use in intrinsically safe current circuits. Mechanical position indicator Indicator disk Cover with transparent dome Symbol stickers Extension for the feedback shaft Digital position feedback with proximity switches* 2 proximity switches for min. and max. position (position adjustable within range of 0...100%) Current circuit to DIN 19234 Supply voltage 5...11 V DC Control current < 1 ma = switching state logical 0 Control current > 3 ma = switching state logical 1 (works independently of the software and the electronics of the positioner) Accessories Mounting material Attachment kit for linear actuators to DIN/IEC 534 (lateral attachment to NAMUR) Attachment kit for rotary actuators to VDI/VDE 3845 Attachment kit for integral mounting Attachment kit for actuator-specific attachment on request Pressure gauge block With pressure gauges for supply and output pressure, Pressure gauges with plastic case 28 mm, with connection block made of aluminum, varnished black inclusive of mounting material for attachment to TZIDC-110. Filter regulator All metal version, brass varnished black Bronze filter element, 40 µm, with condensate drain Max. pre-pressure 16 bar, output adjustable to 1.4...6 bar PC software for remote configuration and operation SMART VISION (standard) as CD-ROM DTM for operation in an FDT environment see data sheet 10/63-1.20 Adapter for bus communication see data sheet 10/63-6.41 Spare parts kit Direction of action (logical state) Proximity switch Position < Min. > Min. < Max. > Max. SJ2-SN (NC) 0 1 1 0 SJ2-S1N (NO) 1 0 0 1 Digital position feedback with 24 V microswitches* Two 24 V DC/AC microswitches for the min. and max. position. Switching points adjustable between 0 and 100 % Not approved for use in the hazardous area! Voltage max. 24 V AC / DC Current load max. 2 A Contact surface 10 µm Gold (AU) * The digital position feedback option is directly actuated by the rotating shaft of the positioner and can only be used together with the mechanical position indicator described above. 8

- TZIDC-110 Electro-Pneumatic Positioner Wiring diagrams 1. Not used 2. Service switch for the plug-in module with shutdown function 3. Terminals for the plug-in module for the shutdown function 4. Kit for digital position feedback, either proximity switches or 24 V microswitch (first connector) 5. Kit for digital position feedback, either proximity switches or 24 V microswitch (second connector) 6. Bus terminals 7. Enclosure ground 1 2 3 Off1 On Off2 +85-86 +41-42 +51-52 Limit 1 Limit 2 4 5 (11) (12) + - 6 7 Fig. 8: Electrical connections Kit for digital position feedback 24 V Microswitch 41 42 43 51 52 53 Limit 2 Limit 1 Input NO contact NC contact Input NO contact NC contact Kit for digital position feedback Pepperl & Fuchs proximity switches Plug-in module for shutdown function 24 V +85-86 +41-42 +51-52 Limit 2 Limit 1 Limit 2 Limit 1 Basic model + (11) (12) Bus terminals Grounding screw Fig. 9: Terminal assignment 9

Dimensional drawings (all dimensions in mm) 14.5 Output: 1 Positioner TZID-C Document 901047 II 2G EEx ib IIC T6 TÜV 98 ATEX 1370 X Ui, Ii, Pi, Ci, Li, Tamb see certificate CE 0032 Made in Germany TZID-C Typ 18345- Softw.-Rev. Serial no. Serien Nr. Supply press.: 1.4...6bar Zuluftdruck: 20...90psi Input: analog 4-20mA Eingang: CE Ausgang: single double einfachwirkend doppeltwirkend Loss of electr. supply: Stromlos: fail entlüftend fail blockierend Options: analog feedback electr. limit switch mech. limit switch FSK position indicator Fig.10: Top view 168.5 104.5 60 33.5 25 7 89.5 65 2 50 45 110.75 M5x0.5 Air outputs for direct attachment 23 58 50 Fig.11: Front view and rear view 92 10 18 2 14 14 28.5 28 M5 14 9 10 29 Fig. 12: Side view (from the left and from the right side) 10

30 / 53 75 45-75 25 B* A* *) Dimensions A and B depend on rotary actuator size Fig. 13: Mounting to linear actuators to DIN/IEC 534 Fig. 14: Mounting to rotary actuators to VDI/VDE 3845 40 120 TZID-C 97 Fig.15: Positioner TZIDC-110 with pressure gauge block and filter regulator 11

Ordering information Catalog No EUR Deliv. time TZIDC-110 Intelligent Positioner V18346-0 0 electro-pneumatic, configurable with indicator and operator panel Case/Mounting Case made of aluminium, varnished, protection IP 65 (NEMA 4X) For mounting to linear actuators acc. to DIN/IEC 534 or to rotary actuators acc. to VDI/VDE 3845, also ready for integral mounting 1 902,00 4 wks. As above, but with mechanical position indicator 2 928,00 4 wks. For mounting to rotary actuators acc. to VDI/VDE 3845 with extended rotation angle up to 270 5 980,00 As above, but with mechanical position indicator 6 1006,00 Note: Special mounting material as specified under "Accessories" is required Input/communication port Profibus PA 3 - Explosion protection without 0 - ATEX EEx ia IIC T6 1 47,00 FM/CSA 2 47,00 ATEX EEx n A II T6 4 Explosion protection certificate upon special agreement (on request) Output/safe position (in case of an electrical power failure) Single acting, fail safe 1 - fail freeze 2 - Double acting, fail safe 4 95,00 fail freeze 5 95,00 Connections Cable: Thread Pg. 13.5 Air pipe: Thread G 1/4 1 - Cable: Thread 1/2-14 NPT Air pipe: Thread 1/4-18 NPT 2 - Cable: Thread Pg 13.5 Air pipe: Thread 1/4-18 NPT 3 - Cable: Thread M20 x 1,5 Air pipe: Thread M12 x 1 4 - Cable: Thread M20 x 1,5 Air pipe: Thread 1/4-18 NPT 5 - Cable: Thread M20 x 1,5 Air pipe: Thread G 1/4 6 - Option modules for analog or digital position feedback Without 0 - Plug-in module for shutdown module (temperature: -30 +60 ) 4 90,00 Mechanical Kit for digital position feedback (option) Without 0 - Mechanical kit for digital feedback of minimum and maximum position 1) With proximity switches SJ2-SN (NC or logical 1) 1 216,00 With proximity switches SJ2-S1N (NO or logical 0) 3 216,00 With 24 V DC/AC microswitches (change-over contacts) 5 103,00 1) only for model with mechanical position indicator Continued on the next page 12

Ordering information (continued) Catalog No EUR Deliv. time TZIDC-110 Intelligent Positioner V18346- electro-pneumatic, configurable with indicator and operator panel Design (varnish/coding) Standard 1 - Special version chemistry (details on request) E - As specified (on request) Device identification label incudes lettering (plain text, max. 16 letters) stainless steel 11.5 x 60 mm on requ. sticker 41 x 32 mm on requ. sticker 11 x 25 mm on requ. Note: The kit for digital position feedback (proximity switches) is identical for positioners with or without explosion protection. The 24V microswitches must not be used in hazardous areas. Accessories Catalog No EUR Deliv. time Mounting material and cost Attachment kit for linear actuators (lateral attachment to DIN/IEC 534 or Namur) Stroke 10... 35 mm 18391-7959125 58,00 1 wk. Stroke 20... 100 mm 18391-7959126 58,00 1 wk. Attachment kit for integral mounting to 23/24 and 23/25 cont. valve DN 15 up to DN 100, stroke 10...35 mm 18391-7959106 42,00 1 wk. DN 125 up to DN 150, stroke 25...65 mm 18391-7959107 42,00 1 wk. 23/26 control valve DN 25 up to DN 100, stroke 10...35 mm 18391-7959108 84,00 1 wk. DN 125 up to DN 162, stroke 25...65 mm 18391-7959109 84,00 1 wk. Attachment kit for rotary actuators (mounting to VDI/VDE 3845), consisting of a) Adapter (shaft coupler) 18391-7959110 37,00 1 wk. b) Mounting bracket, dimensions A/B = 80/20 mm 18391-0319603 63,00 1 wk. A/B = 80/30 mm 18391-0319604 63,00 1 wk. A/B = 130/30 mm 18391-0319605 63,00 1 wk. A/B = 130/50 mm 18391-0319606 63,00 2 wks. Mounting cost, material and adjustment for mounting to linear actuators to DIN/IEC 534 or to rotary actuators to VDI/VDE 3845 External tubing with Plastic tube 18391-0319628 58,00 2 wks. Copper pipe 18391-0319629 79,00 2 wks. Stainless steel pipe 18391-0319630 147,00 2 wks. for integral mounting to 23/24, 23/25 or 23/26 control valves Internal tubing 18391-0319627 48,00 2 wks. External tubing 1) with Copper pipe 18391-7959015 79,00 2 wks. Stainless steel pipe 18391-7959016 147,00 2 wks. 1) External tubing only for 23/24 and 23/25 control valves with "air to close/spring to open" action, otherwise internal tubing only. 13

Accessories Catalog No EUR Deliv. time Pressure gauge block Pressure gauge block, including attachment material for single acting TZIDC-110, with 2 pressure gauges Ø 28 mm (1 x for air supply and 1 x for output pressure) G 1/4 connections Supply pressure range 0...10 bar/ 0...140 psi Output pressure range 0...4 bar/ 0...60 psi 18381-7959111 74,00 1 wk. Output pressure range 0...10 bar/ 0...140 psi 18381-7959112 74,00 1 wk. 1/4-18 NPT connections Supply pressure range 0...10 bar/ 0...140 psi Output pressure range 0...4 bar/ 0...60 psi 18381-7959113 74,00 1 wk. Output pressure range 0...10 bar/ 0...140 psi 18381-7959114 74,00 1 wk. for double acting TZIDC-110, with 3 pressure gauges Ø 28 mm (1 x for air supply and 2 x for output pressure) G 1/4 connections Supply pressure range 0...10 bar/ 0...140 psi Output pressure range 0...4 bar/ 0...60 psi 18381-7959115 84,00 1 wk. Output pressure range 0...10 bar/ 0...140 psi 18381-7959116 84,00 1 wk. 1/4-18 NPT connections Supply pressure range 0...10 bar/ 0...140 psi Output pressure range 0...4 bar/ 0...60 psi 18381-7959117 84,00 1 wk. Output pressure range 0...10 bar/ 0...140 psi 18381-7959118 84,00 1 wk. (Pressure gauge blocks are delivered as separate units for mounting by the customer) Filter regulator Brass filter regulator, incl. material for mounting to pressure gauge block Connections Thread G 1/4 18381-7959119 152,00 1 wk. Thread 1/4-18 NPT 18381-7959120 152,00 1 wk. (Filter regulators are delivered as separate units for mounting by the customer) PC software for digital communication SMART VISION as CD-ROM s. Data Sheet 63-1.20 DTM for use under SMART VISION and in FDT environment s. Data Sheet 63-1.20 Option Modules (can be added later) Plug-in module for shutdown function 18391-7959199 113,00 Kit for Mechanical position indicator 18391-7959130 83,00 1 wk. (including front cover with glass) Kit for Digital feedback of minmum and maximum position (including front cover with mechanical position indicator) with 24 V DC/AC microswitches (change-over contacts) 18391-7959191 211,00 with proximity switches SJ2 - SN (NC or logical 1) 18391-7959131 324,00 SJ2 - S1N (NO or logical 0) 18391-7959132 324,00 Kit for digital feedback of minimum and maximum position 1) with 24 V DC/AC microswitches (change-over contacts) 18391-7959190 129,00 with proximity switches SJ2 - SN (NC or logical 1) 18391-7959133 247,00 SJ2 - S1N (NO or logical 0) 18391-7959134 247,00 Spare parts Spare parts kit 18391-7959198 170,00 I/P-Module (single acting, fail safe) (explosion-proof model, only) 18391-7958510 370,00 I/P-Module (single acting, fail freeze) (explosion-proof model, only) 18391-7958511 370,00 I/P-Module (double acting, fail safe) (explosion-proof model, only) 18391-7958512 440,00 I/P-Module (double acting, fail freeze) (explosion-proof model, only) 18391-7958513 440,00 1) Only fits for basic model with mechanical position indicator 14

Your notes 15

The Industrial IT wordmark and all mentioned product names in the form XXXXXX IT are registered or pending trademarks of ABB. The Company s policy is one of continuous product improvement and the right is reserved to modify the information contained herein without notice. ABB has Sales & Customer Support expertise in over 100 countries worldwide. www.abb.com Printed in the Fed. Rep. of Germany (03.03) ABB 2003 Rev. A ABB Ltd. Salterbeck Trading Estate Workington, Cumbria CA14 5DS UK Tel: +44 (0) 1946 830 611 Fax: +44 (0) 1946 832 661 ABB Inc. 125 E. County Line Road Warminster, PA 18974 USA Tel: +1 215 674 6000 Fax: +1 215 674 7183 ABB Automation Products GmbH Schillerstr. 72 32425 Minden Germany Tel: +49 571 830-1494 Fax: +49 571 830-1860