COS-6 Combi Oven & BCS-6 STeamer REPLACEMENT PARTS LIST Effective june 11, 201 Superseding All Previous Parts Lists. The Company reserves the right to make substitution in the event that items specified are not available. ERRORS: Descriptive and/or typographic errors are subject to correction. BLODGETT OVEN COMPANY 44 Lakeside Avenue, Burlington, Vermont 0401 USA Telephone: (802) 68-6600 Fax: (802) 860-3732 www.blodgett.com P/N 192 Rev D
serial number location / KEY: IMPORTANT: When ordering parts, please provide the model, gas type, voltage and serial number of the oven. The identification plate is located on the left side of the control compartment. serial numbers CONTAINING: HK HR IM EXAMPLE: 021896HK023S TO OBTAIN LITERATURE: Email: literature@blodgett.com or visit www.blodgett.com june 11, 201 2 COS-6 & BCS-6
table of contents Doors Are Not Returnable cos standard control... Page 4 cos digital control... page 6 bcs control... page 8 exterior components... Page 9 door components... page 10 door handle components... page 12 harness & panel assembly... page 14 thermostats... page 17 convection motor components... Page 18 hot air elements, baffle & racks... page 20 steam generator components... page 21 plumbing components... page 22 accessories... page 24 body back & bottom options... page 26 june 11, 201 3 COS-6 & BCS-6
cos standard control 3 10 4 9 9 14 3 16 12 17 19 2 8 20 18 22 21 june 11, 201 4 COS-6 & BCS-6
cos standard control R181 Control panel, Std, 60hz w/out meat probe R814 Control panel, Std, 0hz w/out meat probe R247 Control panel, Std, 60hz w/meat probe R88 Harness, control (all panels listed above) R4872 Gasket, control panel 2 R183 Decal, control Std w/o meat probe R210 Decal, control Std w/meat probe 3 R4623 Switch, mode 4 position R81 Knob and shaft assy, mode switch 4 R6407 Controller, temperature 10-00 degrees P (s/n s HR) R1178 Thermostat, hot air P 200-00 degrees (s/n s HK) R6003 Probe, temp controller (item #4) R3992 Gasket, probe, temp controller (item #4) 8 R271 Switch, momentary Flush/Drain 9 R0226 Indicator light, clear 10 R1318 Indicator light, green Power On 12 16686 Knob, temp control & timer 14 R2666 Timer, 120 minute 60hz R3942 Timer, 120 minute 0hz & CE 16 R2792 Relay, SPST 240V ice cube R7689 Relay, SPDT, CE 17 M6899 Transformer, 208/240V-24V, CE 18 R242 Controller, meat probe R7692 Controller, meat probe, CE 19 R4622 Switch, meat probe on/off 20 R219 Panel jack 21 R31 Probe, meat plug-in type 22 R6988 Suppressor, arc assy R218 Harness, meat probe R32 Wire, thermocouple 20 awg R7717 Fuse, 24V, 2 amp, CE M3167 Holder, fuse, 24V CE R771 Bracket, fuse holder, CE june 11, 201 COS-6 & BCS-6
cos digital control 9 16 10 4 17 20 18 2 8 21 23 24 22 26 2 june 11, 201 6 COS-6 & BCS-6
cos digital control R17 Control Panel, TNT w/o meat probe R246 Control Panel, TNT w/meat probe R4872 Gasket, control panel 2 R7426 Decal, control TNT w/o meat probe R784 Controller retrofit kit (from knob to all pads) R6928 Sensor, controller 8 R271 Switch, momentary Flush/Drain 9 R0226 Indicator light, clear 10 R1318 Indicator light, green Power On 14 M0199 Tie cable, w/adhesive (not shown) 1 9067 Tie, wire (not shown) 16 R4623 Switch, mode 4 position 17-18 R81 Knob and shaft assy, mode switch 20 R2792 Relay, SPST 240V ice cube R7689 Relay, SPDT, CE 21 M6899 Transformer, 208/240V-24V 22 R242 Controller, meat probe R7692 Controller, meat probe CE 23 R7198 Switch, meat probe on/off 24 R219 Panel jack 2 R31 Probe, meat plug-in type 26 R6988 Suppressor, arc assy R481 Nut, keps 4-40 s/s R218 Harness, meat probe R32 Wire, thermocouple 20 awg R7717 Fuse, 24V 2 amp, CE M3167 Holder, fuse 24 V, CE R771 Bracket, fuse holder, CE june 11, 201 7 COS-6 & BCS-6
BCS control 4 4 1 11 12 3 16 14 10 R7070 Control panel, Std, 60hz, w/out meat probe, OCB R7073 Harness, control, OCB R4872 Gasket, control panel 3 R707 Decal, control OCB 4 R4622 Switch, mode 4 position R7477 Switch, push button, green, OCB R7476 Contact block, push button switch, OCB 10 R271 Switch, momentary Flush/Drain 11 R0226 Indicator light, clear 12 R1318 Indicator light, green Power On 14 16686 Knob, timer 1 R2666 Timer, 120 minute 60hz R3942 Timer, 120 minute 0hz 16 318 Relay, DPST 204/240V 2amp, OCB june 11, 201 8 COS-6 & BCS-6
EXTERIOR COMPONENTS 9 10 4 7 8 6 4 R2909 Door assy, RH hinge w/glass R7069 Door assy, RH hinge solid R6313 Handle, door (after s/n 120198) R7833 Handle, door (before s/n 120198) 6 Various Control panel 7 R290 Drip pan, RH hinge ovens R3926 Drip pan, LH hinge ovens 8 R4873 Panel, access R487 Guide, access panel 9 R3012 Funnel assy, deliming 10 R289 Handle, deliming port R2998 Adapter, hose decalcifying R3011 Cap, decalifying adapter june 11, 201 9 COS-6 & BCS-6
door components 13 1 1 1 1 6 20 13 21 16 Oven 23 Door 22 24 26 2 28 27 29 june 11, 201 10 COS-6 & BCS-6
door components 1 R2909 Door assy, RH hinge w/glass R7069 Door assy, RH hinge solid R210 Gasket, window (per foot) 6 R799 Window, door 13 x 14 13 R079 Rivet, monobolt 1/8 dia. x 3/8 long s/s 14 R1278 Rivet, pop 1/8 dia. x 1/4 long s/s 16 R0391 Insert, 1/4-20 UNC 20 R7822 Fastener, 1/4-20 UNC rivnut s/s R2160 Nut, speed (not shown) 16469 Nameplate, Blodgett 7-3/4 (not shown) R1287 Bumper, rubber (not shown) R3013 Gasket, door perimeter (not shown) R3047 Plate, mounting gasket, horiz. R3048 Plate, mounting gasket, vert. R2292 Washer, door height adjustment 21 R2822 Bracket, hinge top 22 R2821 Bracket, hinge bottom R368 Hardware kit, door hinge (contains parts below) 23 R3397 Pin, hinge R0047 Spring, door hinge pin R236 Spacer, door screw R237 Washer, lock 1/4 1977 Screw, machine 10-24 x 3/4 s/s 24 R2818 Switch, micro door R238 Harness, door switch (not shown) 4068 Grommet, door switch 2 3148 Switch, door proximity, CE R773 Cup, magnet, door switch, CE (not shown) R7808 Magnet, door switch, CE (not shown) 26 R2844 Pin, door switch, RH hinge 27 R3717 Pin, door switch, LH hinge 28 R3089 Holder, door trough, RH hinge 29 R2080 Trough assy, door drip, RH hinge R367 Trough assy, door drip, LH hinge june 11, 201 11 COS-6 & BCS-6
door handle components Oven Door 2 6 7 1 8 9 3 6 4 1 R6313 Handle assy, door (s/n s after 120198) R7833 Handle retrofit, door (s/n s before 120198) R6314 Screw, door handle (s/n s after 120198) R1286 Screw, door handle (s/n s before 120198) R7830 Plate, door handle (s/n s after 120198) R142 Plate, shim handle (s/n s before 120198) R2369 Reattachment kit, handle (s/n s before 120198) 2 R2296 Catch assy, door (comprised of parts below) 3 R2780 Latch, door s/s 4 R2781 Catch, door s/s M1820 Washer, flat #10 6 R0726 Washer, lock #10 7 R282 Screw, machine 10-32 x 3/8 s/s head 8 R0031 Screw, machine M x 8-16 s/s head (s/n s prior to 92) 9 1977 Screw, machine 10-24 x 3/4 s/s head (s/n s after 92) 16469 Name plate, Blodgett june 11, 201 12 COS-6 & BCS-6
incoming power components 1 4 6 3 1 R186 Block, terminal power 208/240V 1ph 0/60hz R186 Block, terminal power 208/240V 3ph 0/60hz R186 Block, terminal power 380/220/41/240V 3ph 0hz R7809 Harness, filter to terminal block CE 3 20043 Cable, strain relief R0048 Connector, electrical 4 R76 Fuse, 4 amp (s/n s HR) R0032 Fuse, 3 amp SC3 (s/n s HK) R0043 Fuse, 3 amp KTKR3 (Canada only) R774 Fuse, 2 amp FNQR2 (480V only) R773 Fuse, 1 amp FNQR1 (480V only) 20442 Holder, fuse 4 amp, KTKR3, FNQR2 & FNQR1 20163 Holder, fuse 3 amp SC3 1247 Screw, sdrill 10-16 x /8 ZNP fuse option Export M3167 Holder, 6.3 amp, CE type HTB-3 6M 1247 Screw, sdrill 10-16 x /8 ZNP CE june 11, 201 13 COS-6 & BCS-6
harness & panel assembly 22 20 21 23 19 1 Note: Mounted on the front of the bracket 14 16 Note: Mounted behind the timing board Note: Mounted underneath the bracket 14 Alternate for CE Ovens Only 18 10 9 7 10 12 13 11 june 11, 201 14 COS-6 & BCS-6
harness & panel assembly 7 R1443 Controller assy, steam P2 (comprised of parts below) Note: Mounted underneath the bracket below the relays 9 R1442 Bracket, mounting temp controller 10 18234 Potentiometer, remote 11 18268 Spacer, nylon 12 18744 Controller, 8 pot hold 13 R0022 Sensor, steam controller 14 R708 Board, level control R776 Retrofit kit, level sensing (from UE board w/ orange relays) 1 R2792 Relay, 220/240V ice cube Note: Mounted on the front of the bracket 16 R30 Timer, solid state (HK & HR s/n s only) Note: Mounted behind the Timing Board 389 Conversion kit, mercury to mechanical (208V 3ph) 18 R0038 Capacitor, suppressor, Contactor K3 19 R6402 Timing board R8338 Suppression kit, noise (update timing board) R7381 Standoff, male nylon R7382 Standoff, female nylon 20 R9498 Buzzer assy, w/resistor 21 R8724 Resistor only, buzzer assy 22 R186 Block, terminal, power 0hz only 23 R180 End stop, terminal block 0hz only june 11, 201 1 COS-6 & BCS-6
harness & panel assembly Components on units prior to 1996 only 1 2 4 7 1 1692 Contactor, motor 208V K1 2 2693 Contactor, motor 208/240V K1 4 R0261 Protector, motor PKZM F2 (s/n s HK) R2128 Protector, motor PKZM F2 480V 7 R281 Pin connector, 10 pin R2816 Pin connector, 11 pin june 11, 201 16 COS-6 & BCS-6
thermostats P7 2 P1 3 6 Alternate for CE ovens P3 4 P4 8 Pre 1996 Ovens F3 6 7 F6 2 R3662 Thermostat, cooling fan hi limit P7 (s/n s HR) R2039 Thermostat, cooling fan hi limit P7 (s/n s HK) 3 R2801 Themostat, Too hot to steam P1 4 R0118 Thermostat, Steam pre-heat prioity P3 R0122 Thermostat, quench P4 R37 Gasket, thermostat P4 6 R173 Thermostat, Cooking hi limit 670 degrees F3 R414 Grommet, thermostat 7 R2630 Thermostat, steam generator hi limit F6 8 R2040 Thermostat, stack hi limit F7 (s/n s before 1996) june 11, 201 17 COS-6 & BCS-6
convection motor components for ovens manufactured before 7/13/9 1 R0092 Motor, 208/240V, 3ph R0079 Motor, 240V, 1ph R302 Heat slinger, motor 3 R0037 Nut, hex motor mounting R0714 Nut, hex motor mounting 4 R0039 Washer, toothed lock 832 Washer, toothed lock R0231 Washer 6 R2328 Packing, motor shaft 8 R0232 Washer, blower wheel 9 R0233 Washer, toothed lock, blower wheel 10 R0034 Screw, hex, blower wheel 13 R3699 Blower wheel R242 Capacitor, motor start 6mfd R2012 Cover, capacitor R2010 Bracket 1882 Nut, 1/4-20 126 Washer, lock R3647 Hardware kit, motor mounting june 11, 201 18 COS-6 & BCS-6
convection motor components for ovens manufactured AFTER 7/13/9 17 19 21 23 16 18 20 24 28 30 14 1 26 2 29 1 2 27 16 17 18 23 28 29 20 LINERSIDE 14 R4227 Motor, 1/3hp 11/230V 1ph R4920 Motor, 480V 3ph 1 R190 Spacer, motor 16 R0714 Nut, hex /16-18 s/s 17 1798 Washer, lock /16 18 R2292 Washer, flat 3/8 s/s 19 R2349 Plate, motor mount 20 M0229 Washer, split lock 3/8 s/s 21 R4417 Plate assy, stud mounting 23 209 Bolt, 3/8-16 x 3/4 hex 24 R4482 Insulation, duraboard. 2 R9648 Washer, seal, 1/4" I.D. 26 R4244 Seal, motor shaft 27 R3471 Plate, shaft seal mounting 28 M0417 Washer, lock 1/4 split 29 R2006 Nut, hex jam 1/4-20 x /32 30 R082 Wheel, blower small R2122 Insulation, motor june 11, 201 19 COS-6 & BCS-6
hot air elements, baffle & racks 1 2 3 4 6 1 R362 Element assy, hot air 208V (6 ring assy) R363 Element assy, hot air 240V (6 ring assy) 2 R77 Pan holder, PH- R7868 Pan holder, PH-6 R1971 Spacer, rack guide 3 R1012 Wire rack 4 R3760 Grease filter R2099 Baffle assy 6 R7320 Baffle assy, OCB only R8130 Retrofit kit, baffle and grease filter june 11, 201 20 COS-6 & BCS-6
steam generator components 6 7 12 8 9 10 11 9 4 1 14 2 1 3 1 R244 Steam generator assy R24 Insulation, steam generator 2 R2467 Boot, rubber drain R2487 Clamp, drain boot large 3 R2726 Pump, drain 60hz R763 Pump, drain 0hz R6870 O ring, drain pump R2927 Hose, pump outlet 7/8 ID (per foot) R024 Clamp, hose plumbing 7/8 4 R2814 Hose, steam transfer 1-1/4 ID (per foot) R0082 Clamp, plumbing 1-1/4 R2812 Hose, pharmed, 3/8 ID (per foot) R0080 Clamp, hose plumbing 3/8 6 R696 Probe assy, dual level sensing (used w/warrick Board) 7 R361 Probe only, level sensing 8 R343 Plate, level sensing 9 R1491 Gasket, switch level 10 R3141 Probe, level sensing, J hook, 3 wire (used w/ue Board) 11 R2926 Plate, J hook probe 12 R2843 Probe only, J hook 14 R7180 Element assy, steam 208V 60hz w/thermocouple R7181 Element assy, steam 208V 0hz w/thermocouple R7182 Element assy, steam 240V 60hz w/thermocouple R7183 Element assy, steam 240V 0hz w/thermocouple R7184 Element assy, steam 480V 60hz w/thermocouple 1 R2769 Element assy, steam 208V 60hz R2768 Element assy, steam 208V 0hz R2772 Element assy, steam 240V 60hz R2771 Element assy, steam 240V 0hz R7187 Element assy, steam 380/220V 0hz R7723 Element assy, steam 400/230V 0hz CE R4432 Element assy, steam 480V 60hz june 11, 201 21 COS-6 & BCS-6
plumbing components 2 1 28 30 3 4 6 2 7 8 9 10 12 17 18 21 24 19 24 26 23 31 24 20 22 june 11, 201 22 COS-6 & BCS-6
plumbing components 1 R31 Valve assy, decalicifying (comprised of parts below) 2 R1928 Elbow, street 1/2 NPT 3 R1142 Valve, ball 4 R1198 Fitting, barb 3/8 x 1/2 R2998 Adapter, hose decalcifying R3079 Gasket, decalcifying inlet R289 Handle, decalicifying valve R132 Cover, drain handle R3011 Cap, decalicifying valve R2812 Hose, decalicifying 3/8 ID (per foot) 6 R4891 Overpressure assy, steam (comprised of parts below) 7 R781 Outlet assy, steam 8 R77 Spring, pressure relief 9 R267 Gasket, pressure relief 10 R770 Cover, pressure relief R7732 Nut, 1/4-20 thin w/nylon 11 R2437 Stack, quench R2812 Hose, quench stack, 3/8 ID (per foot) R0080 Clamp, plumbing 3/8 12 R3643 Nozzle assy, quench (comprised of parts below) 13 R1198 Fitting, barb 3/8 x 1/2 18 R2868 Gasket, cavity drain 19 R2202 Boot, drain, gray silicone 2 20 R2207 Clamp, drain boot 21 R079 Solenoid valve assy, triple 208/240V R077 Valve body, solenoid triple R07 Coil, solenoid valve 208/240V R071 Fitting, barbed 3/8 22 R078 Solenoid valve assy, single 208/240V CE R222 Solenoid valve assy, dual 208/240V CE 23 R7978 Fitting, 3/4 hose, male 24 R770 Washer, garden hose 26 R7813 Coupling, 3/4G x 3/4G brass 28 R700 Venturi assy (comprised of parts listed below) 30 R0640 Fitting, straight 1-3/32 31 R11210 Pressure reducer R0729 Washer, flat 13/16 R861 Hose, steam transfer, green, 7/8 ID (per foot) june 11, 201 23 COS-6 & BCS-6
accessories 1 4 7 6 3 8 2 10 Pressure Regulator R11210 9 11 12 1 13 20 2 23 22 26 28 29 24 30 31 30 31 27 june 11, 201 24 COS-6 & BCS-6
accessories 1 R0006 Bottle, pressure spray R6332 Repair kit, spray bottle (nozzle repair only) 2 R3109 Leg set, 4 s/s w/feet 3 R3110 Leg set, 6 s/s w/feet 33196 Leg set, 6 s/s, seizmic 4 R2899 Leg set, 2 s/s w/feet R4 Leg set, stands R46 Leg set, stands, seizmic R3112 Caster kit, 2 locking/2 non-locking R8161 Caster kit, stands ACS-12 R44 Caster kit, stands ACS-18 & ACS-31 6 R9064 Installation kit, start up (comprised of parts below) 7 R2207 Clamp, hose 8 R6884 Tee, copper 9 R688 Reducer, 2 x 1. R6886 Adapter, copper 1-1/2 R1033 Vent, drain R10899 Hose, spray and nozzle assy 8 (comprised of parts below) 11 3639 Nozzle, spray 12 R0376 Y fitting 13 R10889 Hose, 8 w/fittings 1 R392 Hook, hose 20 R7648 Stand, ACS-12 (s/n s IM) 22 R449 Stand, ACS-31 23 R3012 Funnel assy, deliming (comprised of parts below) 24 R2999 Fitting, swivel decalcifying 2 R3000 Funnel, decalcifying 26 R7886 Tube, 3/8 ID 27 R9601 Deliming bottle assembly (comprised of parts below) 28 R8860 Hand pump assy 29 R8861 Bottle, deliming 30 R887 Clamp, hose 31 R8084 Fitting, male hose, barbed R3128 Stacking kit, Combi on DFG R3074 Vent kit, stacking (on another 6 series oven) R3077 Vent kit, stacking (with other models) R816 Vent kit, stacking, copper (OCB) R9047 Side shield, SS-6 w/hardware june 11, 201 2 COS-6 & BCS-6
body back & bottom options 2 1 3 7 8 6 1 R764 Body bottom, single, top or bottom section 2 R763 Panel, access body bottom 3 R23 Body back, ALCT 1247 Screw, sdrill 10-16 x /8 ZNP, body back mounting R7660 Panel, access body back s/s R3161 Cover, thermostat access panel, ALCT R36 Cover, thermostat access panel, s/s 6 R312 Shield, fan ALCT R384 Shield, fan s/s 7 23034 Fan, 4 axial, 230V 8 M071 Guard, 4 axial fan june 11, 201 26 COS-6 & BCS-6