MCA 2014 33S11 EURO 5+ (F1A 2.3l) The information in this literature is intended to be of a general nature only. Iveco reserves the right to modify or change specification at any time Engineering Profile 1 07 Apr 2014
33S11 FDP: A25C MARKET: 1310 MOD: 33S11 List of linked VCB VCB Code Gearbox Wb Cabin Drive 8AAA1AA1 2835.6 DOD 3000 LSTS LHD 8AAA1BA1 2835.6 DOD 3450 LSTS LHD Engineering Profile 2 07 Apr 2014
33S11 - MCA 2014 EURO 5+ (F1A 2.3l) Weights & dimensions 3000 3450 Overall length (over RUP) (B) Max width over wings (cab) (E) Front axle to front of body (H) Frame height end of frame, unladen(l) Frame height front axle, unladen Frame height rear axle, unladen 5028 5913 2010 2010 1410 1410 702 702 599 599 710 710 Front overhang (C) 1008 1008 Rear overhang (D) 1020 1455 Minimum ground clearance (front) Minimum ground clearance (rear) Overall height to top of cab,unladen(k) Turning diameter kerb to kerb Turning diameter wall to wall 143 143 175 175 2196 2196 10546 11876 11200 12536 Front track (M) 1740 1740 Rear track (N) 1704 1704 Engineering Profile 3 07 Apr 2014
33S11 - MCA 2014 EURO 5+ (F1A 2.3l) 3000 3450 Weights & dimensions Approach angle ( ) 18.32 19.78 Departure angle ( ) 22.37 18.69 Ramp angle ( ) 20.3 12.83 Left hand drive vehicle drawing Total vehicle kerb weight 5801824100 5801824110 1750 1767 Kerbweight - F.A. 1307 1322 Kerbweight - R.A. 443 445 G.V.W. (EC) 3300 3300 Plated weight on F.A. (EC) Plated weight on rear axle (EC) Trailer weight (inertia brake) Max body & Payload (EC) Side members thickness Side members max height 1800 1800 2060 2060 3300 3300 1550 1533 3 3 144 144 Flange width 56 56 Frame width at rear 860 860 Engineering Profile 4 07 Apr 2014
FCP - MT - 2,8-3,4-2,8-3,49 ton. Weights (in general) GVW (kg) 3300 (2800-3490) GCW (kg) 6600 Notes: The weights are indicated more preciseley in the section: "Weight and dimensions". The values of GVW / GCW can vary according to the markets and the homologations. FCP - CA - 4X2-4x2 Configuration Axle Configuration 4 X 2 FCP - VE - CABINAT - Rigid Version Version CHASSIS CAB FCP - DR - SX - LH drive Drive Left FTP - EN - F1AFL411A - Motore F1A 106cv Euro5+ LD WG Engine Manufacturer Position Arrangement Cycle Aspiration type Injection type 4 Stroke / 2 Stroke cycle 4 No. of cylinders 4 Cylinders layout Bore (mm) 88 Stroke (mm) 94 FPT FRONT LONGITUDINAL DIESEL TC+AFTERCOOLER Unijet common rail - 16 valves IN-LINE Total displacement cm³ 2287 Exhaust gas treatment (Torque, generic ref. only. See: "EP") 270 Engine - Miscellaneous Injection system HIGH PRESSURE / COMMON RAIL Cold starting type Cooling Cooling system Fan type Air intake Filter type EGR THERMOSTARTER water electromagnetic DRY Engineering Profile 5 07 Apr 2014
FCP - EP - 106 EU5 - Motore F1A 106CV EURO 5 LD Engine Power kw 78 Power Hp 106 Rpm at Max Power 3600 Torque Nm 270 Rpm 1/min (min) 800 rpm (min. "Max Torque" eng. speed) 1500 Type of turbocharging FTP - GB - 2835.6 DOD - Cambio mecc. 6 vel. Doppio OD Gearbox Gearbox Type Installation Box material Dry weight Kg 48 Max input torque Nm 350 No. of gears (forward) 6 No. of reverse gears 1 No. of synchro gears 6 Gear ratios Gear ratio: 1st gear 5.004 Gear ratio: 2nd gear 2.635 Gear ratio: 3rd gear 1.503 Gear ratio: 4th gear 1 Gear ratio: 5th gear Gear ratio: 6th gear with waste gate valve SYNCRONIZED ENGINE FLANGED ALUMINIUM.812 OD Gear ratio: rev. 1st 4.506.701 DOD (double overdrive) Gear Ratio: Last Gear.701 Clutch Type Single dry plate Actuation Adjustment Outer diameter (inches) 10½ Release control Notes: Gearstick located on dashboard with a car type pattern shift. PTO: lower left side mount available. FTP - RA - NDA RS - NDA Ruote Singole (ex 450210) PULL TYPE AUTOMATIC HYDRAULIC Other features Axle Type RIGID Engineering Profile 6 07 Apr 2014
Axle weight without susp. and tyres (Kg) 134 Reduction type single Brakes Brakes according to standards EC Brake type FTP - FS - AMB017N - Ind. wheel transverse spring 17 q Suspensions Springs material Front Axle Suspension Type Shock absorbers Shock absorbers type Shock absorbers no. (front) 2 Features of the brakes (front wheels) : 29L / 35S : 2 calipers, diameter 48 mm - disc: diameter 300 mm, thickness: 28 mm FTP - RS - PMA022N - Leaf springs 22 q. Shock absorbers Shock absorbers type Shock absorbers no. (rear) 2 Note: Disc STEEL Models 35C../ 70C.. chassis cab, crew cab are equipped with single acting semielliptic springs. Models 35C.../ 70C... vans,combi,chassis cowl are equipped with dual-leaf parabolic springs. Independent wheels, transversal leaf HYDRAULIC TELESCOPIC HYDRAULIC TELESCOPIC Models 29L.. / 35S.. chassis cab,vans, combi,crew cab, chassis cowl (only 35S ) are equipped with single leaf parabolic springs. FTP - FR - AA04710R1 - Chassis 144 x 53 x 3 Chassis (mm) Frame section Chassis / W.B. Section shape Side members material FTP - FR - AA05605R1 - Chassis 144 x 53 x 3 Chassis (mm) Frame section Chassis / W.B. Section shape Side members material FCS - M0000-04488 - SISTEMA ESP 9 Braking system Features _ PARALLEL "C" STEEL PARALLEL "C" STEEL Engineering Profile 7 07 Apr 2014
Braking system: Dual circuit configuration; cross split on 29L - 35S / independent from 35C up to 70C. Hydraulically operated with vacuum servo assistance. Full disc brakes with floating calipers with auto wear adjustment. Mechanically controlled parking brake: 29L / 35S / 35C (brake calipers) 40C / 45 / 50C / 60C / 65C / 70C (drum) Brake fluid level indicator-front / rear pad wear indicator. Asbestos free pads. EASY interface. Notes: On Daily 2014 the ESP 9 system is standard for all the range. It is the latest evolution among the Electronic vehicle stability controls and is an advanced system for active and preventive safety in all weather and road conditions. Prevents the loss of vehicle control caused by: High speed Wrong evaluation of the road lay-out Sudden vehicle skid Trying to avoid an obstacle Sudden vehicle steering ------------------------------------------ ESP9 includes ABS (Antilock Braking System), EBD (Electronic Brake force Distribution), ASR (Anti Slip Regulator), MSR (Motor Schleppmoment Regelung that acts on engine speed to reduce the braking torque in release), Hill Holder (Assited uphill departure), HBA (Hydraulic Brake Assist), LAC (Load Adaptive Control), TSM (Trailer sway mitigation. It detects the presence of a trailer and adapts the electronic stability control strategy in order not to negatively influence the dynamics of the vehicle-trailer system), RMI (Roll Movement Intervention. It mitigates dangerous roll-over situations during highly dynamic driving like e.g. evasive manoeuvre), ROM (Roll Over Mitigation. It mitigates dangerous roll-over situations during almost stationary manoeuvres like circular driving with steadily increasing steering wheel angle). FTP - CL - LSTS - Light Cab LH Cab Manufacturer Cab type Material IVECO Steps no. 1 Roof Roof type LOW Dimensions Front Area 3.8 Air Penetration Coefficient.7 Doors Front doors no. 2 Front doors type Front doors opening angle 64 SEMI-ADVANCED FIRM STEEL PLATE WINDOW SASH Window operation MANUAL ON RIGHT - MANUAL ON LEFT Rear view mirrors Rear view mirr no 2 Mirrors control MANUAL Heating Fan speed no. 4 Heating control MANUAL Windscreen wiper No. of windscreen wiper speeds 3 No. of windscreen wipers 2 Seats No. of places 3 No. of seats 2 Driver seat adjustme IN HEIGHT, LENGTH AND BACK INCLINATION Engineering Profile 8 07 Apr 2014
Passenger seat type Miscellaneous Safety belts points Sun visors no. 2 Ceiling no. 1 Lighter CB pre-wiring Chassis cab Doorway lever Glove compartment Cab floor Monolithic execution Plastic covering TWO SEATS BENCH COVERED WITH SYNTHETIC MATERIAL Engineering Profile 9 07 Apr 2014
Remarks: Anti-corrosion protection includes full cataphoretic dipping with galvanized boxed sections and strategic use of zinc plated panels in vulnerable areas. Protective under seal for all under body cabin area, wheel housing and engine area. Interior equipment: Storage compartments with bottle holder, pool cup for mobile phone, arm rests on the doors, shelves in overhead console, shelves at floor level below seats, interior lights, 2 spotlights, 4 loud-speakers, gearshift lever on dashboard. Passenger's seat: Fixed, 2 seats bench with drawer under seat. Floor: Covered with rubber mats. Central console: Storage compartments, glove box compartments on the top of the dashboard, central panel, adjustable air vents, ash-trays, lighter, heating control, cooled compartment (with opt. air conditioning). Exterior equipment: Close proximity mirror on passenger's side, steps on both sides, front bumper, mudguard, fog lights. Handles on both sides, handle on A-pillar (with opt), rear underrun protection, rear lights crossbar. New battery position under driver step. In cab equipment (it can vary according to the markets / homologations; for a complete list of Daily options please contact local Iveco distributor) : Indicator lamps, on cluster: - Parking brake - Brakes failure - Directions indicators - Generic failure - Seat belts not fastened - Fog lights - High beams - Wing lights - External lights failure - Rear fog light(s) - Open doors - Fuel gauge - Tachograph failure - Coolant temperature - EOBD - Engine preheating - Water in fuel filter - Clogged air filter - Clogged fuel filter Multifunction stalks: (Left) direction - Wing / Highbeam / Lowerbeam - Headlamp flash - Horn - Front fog lights (right). New Daily 2014 is equipped with DRL (Daytime Running Lights). For more security "side light / parking light" switch on automatically at every Key ON, so that the vehicle is more visible by daytime, too. The driver cannot byany means switch them off. Windscreen wiper with intermittent wipe. Steering wheel with secure and comfortable grip (ø 390 mm / inclination 42 ). FCS - D7000-02307 - STEEL WHEELS Wheels Rim type Rim material FCS - I0000-20193 - PNEUMATICI 215/65 R16 DISC STEEL RUOTE IN ACCIAIO Tyres Rolling circumference m. 2.324 Dinamic Radius m.37 Rolling resistance Coefficient.008 Engineering Profile 10 07 Apr 2014
Tyre repair kit availability is : - STANDARD from 29L to 35C - OPTIONAL from 40C to 70C and it is positioned inside the cab : - for Van / Cab : beside the driver's seat. - for Crew Cab : inside the compartment of rear bench. - for Combi : beside the rear passengers bench. FCS - D0000-00003 - REAR AXLE RATIO 4.44 Rear Axle Ratios Rear axle ratio 4.44 FCS - D0000-00004 - REAR AXLE RATIO 4.88 Rear Axle Ratios Rear axle ratio 4.889 FCS - D0000-06056 - 4.22:1 REAR AXLE RATIO Rear Axle Ratios Rear axle ratio 4.22 FCS - D0000-08648 - RAPPORTO AL PONTE 3.73 Rear Axle Ratios Rear axle ratio 3.73 FCS - MPN00-00567 - 110 AH BATTERIES Electrics Batteries capacity V/Ah 12 V / 110 Ah Engineering Profile 11 07 Apr 2014
Calculations Tyres : 20193 - PNEUMATICI 215/65R16 Rear Axle Ratio : 3 - R. AXLE RATIO 4.44 Efficiency : 0.93 No Transfer Box VCB Code Ratios Speed Max Gradeability 8AAA1AA1 2835.6 DOD NDA RS Km/h Total Weights (solo vehicle) (Kg) Total Weights (vehicle+trailer) (Kg) 3300 6600 1 5.004 22.59 51.44 23.06 4.44 L..701 161.28 3.94 1.57 Tyres : 20193 - PNEUMATICI 215/65R16 Rear Axle Ratio : 4 - R. AXLE RATIO 4.88 Efficiency : 0.93 No Transfer Box VCB Code Ratios Speed Max Gradeability 8AAA1AA1 2835.6 DOD NDA RS Km/h Total Weights (solo vehicle) (Kg) Total Weights (vehicle+trailer) (Kg) 3300 6600 1 5.004 20.52 58.44 25.63 4.889 L..701 146.47 4.91 2.05 Tyres : 20193 - PNEUMATICI 215/65R16 Rear Axle Ratio : 6056-4.22 REAR AXLE RATIO Efficiency : 0.93 No Transfer Box VCB Code Ratios Speed Max Gradeability 8AAA1AA1 2835.6 DOD NDA RS Km/h Total Weights (solo vehicle) (Kg) Total Weights (vehicle+trailer) (Kg) 3300 6600 1 5.004 23.77 48.21 21.82 4.22 L..701 169.69 3.42 1.31 Tyres : 20193 - PNEUMATICI 215/65R16 Rear Axle Ratio : 8171-5.14 REAR AXLE RATIO Efficiency : 0.93 No Transfer Box VCB Code Ratios Speed Max Gradeability 8AAA1AA1 2835.6 DOD NDA RS Km/h Total Weights (solo vehicle) (Kg) Total Weights (vehicle+trailer) (Kg) 3300 6600 1 5.004 19.52 62.65 27.09 5.14 L..701 139.32 5.43 2.31 Tyres : 20193 - PNEUMATICI 215/65R16 Rear Axle Ratio : 8648 - RAPPORTO PONTE 3.73 Efficiency : 0.93 No Transfer Box VCB Code Ratios Speed Max Gradeability 8AAA1AA1 2835.6 DOD NDA RS Km/h Total Weights (solo vehicle) (Kg) Total Weights (vehicle+trailer) (Kg) 3300 6600 1 5.004 26.89 41.43 19.08 3.73 L..701 191.98 2.15.67 Engineering Profile 12 07 Apr 2014