Replacement Parts List No. 057101700 Revision B 02/2017 McQuay Console Water Source Heat Pump CWC, CWG, CWH, CWJ, CWK 015-019 Vintage B Last Manufactured: 1994 To find your Daikin Applied parts distributor, call 1-800-377-2787 or visit www.daikinapplied.com
Contents Part List Revision History...3 Nomenclature Serial Number...4 Model Number...4-5 Refrigeration & Motor Section...6-7 Control Section...8-9 Cabinet Section...10-11 Subbase and Backwrap Assembly...12 Field Installed Accessories Electric Heat Assembly...13 Motorized Water Regulating Valve Assembly and Fused Disconnect Assembly...14-15 Motorized Damper Assembly...16 Hoses, Thermostats & Subbase...17 Thermostat Accessories, Control Accessories...18 Note: For parts information on MicroTech Loop Water Controller model LWC, refer to RPL 0552349. WSHP; CWC,CWG,CWH,CWJ,CWK 015-019 Vint. B Rev. B 02/17 RPL 571017 / Page 2
Parts List Revision History Revision Date Description New 2/93 New A 05/09 Add Revison History & Contents pages. Add unit description footer to all pages. Page 6 - Remove compressor vendor numbers. Page 6-18 - Convert all p/ns to current format. B 02/17 Rebrand to Daikin format. Page 4-5 Add code for Model Number. Pages 6-7 Change Ref numbers to N/S. Daikin Applied, 13600 Industrial Park Blvd., P.O. Box 1551, Minneapolis, MN 55440 (763) 553-5330 WSHP; CWC,CWG,CWH,CWJ,CWK 015-019 Vint. B Rev. B 02/17 RPL 571017 / Page 3
Nomenclature Serial Number 7 U A 00000 00 Plant Identification Number 7 = Auburn Year Manufactured S = 1987 T = 1988 U = 1989 Etc. Engineering Revision Serial Number (Building Sequence) Month Manufactured A = January B = February C = March D = April E = May F = June G = July H = August J = September K = October L = November M = December Model Number CMH 015 B M N L FB H ACC A NSB SRL R AR Code 01 02 03 04 05 06 07 08 09 10 11 12 13 14 Y RFD L M Y T M A A S F L YS Code 15 16 17 18 19 20 21 22 23 24 25 26 27 Code 01: Model Type CWC= Heat Pump, Chassis CWG= Cooling Only Unit CWH= Heat Pump Unit CWJ= Cooling Only Chassis CWK= Cabinet Only Code 02: Unit Size 60 Cycle 015= 15000 BtuH Nominal Cooling 019= 19000 BtuH Nominal Cooling 50 Cycle 013= 6000 BtuH Nominal Cooling 016= 8000 BtuH Nominal Cooling Code 03: Design/Vintage B= Vintage B Code 04: Control System E= Electromechanical Controls M= Mark IV Controls C= MicroTech Unit Controller Code 05: Voltage G= 208-230/60/1 wired for 208V J= 230/50/1 N= 265/60/1 V= 208-230/60/1 wired for 230V Code 06: Piping Hand L= Left Hand R= Right Hand Code 07: Discharge Grille/Cabinet Type FS= Flat Top- One Piece Steel Grille FB= Flat Top- Steel Bar Grille FM= Flat Top- Steel Modular Grille, 5" X 5" SB= Slope Top- Steel Bar Grille DC= Duct Collar SP= Slope Top- Plastic Grille NF= No Front Part Of cabinet- Flat Top NS= No Front Part Of cabinet- Slope Top Code 08: Cabinet Height H= High Sill- 25" High L= Low Sill- 22.5" High Code 09: Thermostat Control AAC= Auto Changeover- Continuous Fan MMC= Manual Changeover- Continuous Fan RMC= Remote Thermostat or Slave Unit Control ACF= Auto Changeover- Cycle Fan MCF= Manual Changeover- Cycle Fan MTC= MicroTech w/tenant Setpoint Adjustment MRT= MicroTech Remote Wall Sensor YY Code 10: Construction Type A= Standard E= Extra Quiet Continued on next page. WSHP; CWC,CWG,CWH,CWJ,CWK 015-019 Vint. B Rev. B 02/17 RPL 571017 / Page 4
Nomenclature Code 11: Night Control LLC= Low Limit Control NSB= Night Setback NWR= Night Setback with Override LNS= Low Limit & Night Setback LNR= Low Limit & Night Setback with Override NST= Night Setback & Thermostat LLT= Low Limit Thermostat NLT= NSB & LLC & Thermostat MTR= Tenant Override Button YY Code 12: Electromechanical Relays SRL= Shutdown Relay, 24V SRH= Shutdown Relay, 115V LSR= Load Shed Relay, 24V YY Code 13: Starting Relay R= Random Start/Anti Short Cycle Code 14: Additional Relays AR= Auxiliary Relay SR= Status Relay AS= Auxiliary & Status Relay MR= MicroTech Output Relay MS= Master Slave Relay Y Code 15: Power Connection J= Junction Box, 2 X 4 P= Plug Cord C= Conduit, 18 to Reach Box Code 16: Cabinet Electrical RYY= Box with Receptacle Only RFY= Box with Receptacle & Fuses RFD= Box with Receptacle/Fuses/Switches BDF= Box with Fuses & Disconnect BDY= Box with Disconnect JBC= Deep Junction Box, 2 X 4 X 2 ⅛ YY Code 17: Freeze Protection L= Leaving Water Temp Cutout Thermostat Code 19: Boilerless System A= 1.0 KW at or 0.62 KW at 208V B= 2.0 KW at or 1.23 KW at 208V C= 3.0 KW at or 1.85 KW at 208V D= 3.0 KW at 208V Code 20: Filter T= Throwaway C= Cleanable Code 21: Outside Air D= Manual M= Motorized Code 22: Access Door A= Standard K= Keylocked Access Door Code 23: Water Connection A= Sweat, ⅝ O.D. F = Female NPT Fitting, ½ Code 24: Coaxial Heat Exchanger S= Copper Inner Tube C= Cupro-Nickel Inner Tube Code 25: Finished Back Panel F= Finished Back Panel Code 26: Paint L= Standard Antique Ivory/Oxford Brown Code 27: Refrigerant Valve YS= Water Regulator Valve Y Code 28: Logo & Nameplate Designation Code 20: Agency Listing Code 21: Warranty Code 22: Packaging Code 23: Miscellaneous Code 18: Water Flow Control M= Motorized Valve, NC N= Motorized Valve, NO W= Water Regulating Valve WSHP; CWC,CWG,CWH,CWJ,CWK 015-019 Vint. B Rev. B 02/17 RPL 571017 / Page 5
Refrigeration & Motor Section Components BUB. NO. DESCRIPTION FIELD REF. NO. PART NO. N/S COMPRESSOR 1 061043401 N/S COMPRESSOR 1 1 061043402 N/S COMPRESSOR 1 066540301 N/S COMPRESSOR 1 1 066540302 015 019 N/S OVERLOAD, COMPRESSOR 1 060993105 N/S OVERLOAD, COMPRESSOR 1 1 060993106 N/S OVERLOAD, COMPRESSOR 1 060993109 N/S OVERLOAD, COMPRESSOR 1 1 060993110 N/S CAPACITOR, COMPRESSOR 25MFD/370V 1 1 1 802007847 N/S CAPACITOR, COMPRESSOR 25MFD/440V 1 1 1 1 802007855 N/S BRACKET, CAPACITOR, COMPRESSOR 1 1 1 1 1 1 850010570 N/S NUT COMPRESSOR MOUNT 3 3 3 3 3 3 802012035 N/S GROMMET, COMPRESSOR MOUNT 3 3 3 3 3 3 060623301 N/S SLEEVE, COMPRESSOR MOUNT 3 3 3 3 3 3 060623403 N/S REVERSING VALVE 1 1 1 1 1 1 066533401 N/S SOLENOID COIL, REVERSING VALVE 1 1 1 1 1 1 066541901 N/S COAXIAL COIL (WATER TO REFRIGERANT) 1 1 1 061084801 N/S COAXIAL COIL (WATER TO REFRIGERANT) 1 1 1 061314801 N/S COAXIAL COIL (WATER TO REFRIGERANT) CU/NI 1 1 1 061084802 N/S COAXIAL COIL (WATER TO REFRIGERANT) CU/NI 1 1 1 061314802 N/S SUPPORT, FIN TUBULAR COIL, RIGHT SIDE 1 1 1 1 1 1 061311301 N/S SUPPORT, FIN TUBULAR COIL, LEFT SIDE 1 1 1 1 1 1 061311201 N/S CONDENSATE PAN 1 1 1 061312699 N/S CONDENSATE PAN 1 1 1 061312698 N/S FIN TUBULAR COIL (AIR TO REFRIGERANT) 1 1 1 061322901 N/S FIN TUBULAR COIL (AIR TO REFRIGERANT) 1 1 1 061323001 N/S CAPILLARY TUBE.0541.D x.106 OD x 22.00 2 2 2 060634711 N/S CAPILLARY TUBE 3 3 3 802001186 N/S STRAINER 1 1 1 060628802 N/S STRAINER/DISTRIBUTOR 1 1 1 060628807 N/S= Not Shown. WSHP; CWC,CWG,CWH,CWJ,CWK 015-019 Vint. B Rev. B 02/17 RPL 571017 / Page 6
Refrigeration & Motor Section Components, Continued BUB. NO. DESCRIPTION FIELD REF. NO. PART NO. N/S FUSIBLE PLUG 1 1 1 1 1 1 802025014 N/S FITTING, FUSIBLE PLUG 1 1 1 1 1 1 802025013 N/S VALVE SCHRADER 1 1 1 1 1 1 802026161 015 019 N/S SWITCH, HIGH PRESSURE 1 1 1 1 1 1 802005813 N/S THERMOSTAT, LOW TEMP. CUTOUT 1 1 1 1 1 1 802005724 N/S CLIP, THERMOSTAT 1 1 1 1 1 1 802017216 N/S FAN DECK 1 1 1 1 1 1 061312899 N/S FAN HOUSING, DISCHARGE HALF 2 2 2 2 2 2 022930900 N/S FAN HOUSING, ACCESS HALF 2 2 2 2 2 2 022931000 N/S WHEEL, BLOWER 2 2 2 2 2 2 061346601 N/S MOUNT, MOTOR 1 1 1 1 1 1 056312801 N/S CLIP, MOTOR MOUNT 2 2 2 2 2 2 060900501 N/S FAN MOTOR 1 1 066542001 N/S FAN MOTOR 1 1 1 1 066542002 N/S CAPACITOR, MOTOR 4MFD/370V 1 1 1 1 802007004 N/S CAPACITOR, MOTOR 5MFD/370V 1 1 802007046 N/S BRACKET, CAPACITOR, MOTOR 1 1 1 1 1 1 802009019 N/S CLIP, COMPRESSION RING 2 2 2 2 2 2 066534601 N/S= Not Shown. WSHP; CWC,CWG,CWH,CWJ,CWK 015-019 Vint. B Rev. B 02/17 RPL 571017 / Page 7
Control Section Remote Control Mark IV Only Std. Mark IV Remote Electromechanical BUB. NO. DESCRIPTION FIELD REF. NO. PART NO. 362 PANEL, TOP, CONTROL BOX 2 MICROTECH 1 1 1 1 1 1 061468402 362 PANEL, TOP, CONTROL BOX 1 MICROTECH 1 1 1 1 1 1 061468502 362 PANEL, TOP, CONTROL BOX 1 STANDARD 1 1 1 1 1 1 061314702 362 PANEL, TOP, CONTROL BOX 2 STANDARD 1 1 1 1 1 1 061397002 015 019 366 MOUNTING PLATE, THERMOSTAT 1 1 1 1 1 1 1 061314601 367 PANEL, END, CONTROL BOX 1 1 1 1 1 1 1 061304099 367 PANEL, END, CONTROL BOX 2 1 1 1 1 061353399 370 TERMINAL BOARD 1 1 1 1 1 1 802007090 373 THERMOSTAT, ACO 1 1 1 1 802005302 373 THERMOSTAT, MCO 1 1 1 1 1 1 802005610 1 = Slope Top Units Only 2 = Flat Top Units Only WSHP; CWC,CWG,CWH,CWJ,CWK 015-019 Vint. B Rev. B 02/17 RPL 571017 / Page 8
Control Section Continued 015 019 BUB. NO. DESCRIPTION FIELD REF. NO. PART NO. 375 SWITCH, ROCKER 1 1 1 1 1 1 061321501 376 KNOB, THERMOSTAT 1 1 1 1 1 1 061334001 376 KNOB, THERMOSTAT, MICROTECH 1 1 1 1 1 1 066544601 377 CONTROL BOARD, MARK 4 1 1 1 1 1 1 060638805 377 CONTROL BOARD, ELECTROMECHANICAL 060679202 385 SWITCH, TAPTOUCH, 2 BUTTON 1 1 1 1 1 1 061348801 385 SWITCH, TAPTOUCH, 4 BUTTON 1 1 1 1 1 1 061317701 387 ESCUTCHEON PLATE, 2 BUTTTON, AUTO 1 1 1 1 1 1 061381601 387 ESCUTCHEON PLATE, 2 BUTTON, MANUAL 1 1 1 1 1 1 061356901 387 ESCUTCHEON PLATE, 4 BUTTON, AUTO W/OVERRIDE 1 1 1 1 1 1 061381801 387 ESCUTCHEON PLATE, 4 BUTTON, MANUAL W/OVERRIDE 1 1 1 1 1 1 061396705 387 ESCUTCHEON PLATE, 2 BUTTTON, REMOTE STAT 1 1 1 1 1 1 061381901 389 SWITCH, LOW TEMPERATURE 3 1 1 1 1 061400701 391 SWITCH, MOMENTARY 3 1 1 1 1 061377201 394 CIRCUIT BOARD, SHUTDOWN RELAY 803005072 415 RELAY, AUXILIARY 1 1 1 1 1 1 803005073 420 RELAY, BOILERLESS SYSTEM ELECTRIC HEAT 1 1 1 1 1 1 802005905 421 RELAY, HEATER 1 1 1 1 1 1 067180401 423 BRACKET 3 1 1 1 1 061397701 426 PLUG, 15 PIN 1 1 1 1 1 1 802007944 TERMINAL 802007742 429 BOTTOM, CONTROL BOX 1 1 1 1 1 1 061300299 430 SWITCH, STANDBY ELEC. HEAT, BOILERLESS SYSTEM 047357307 432 TERMINAL STRIP, MARK 4 & REMOTE T STAT ELEC. MECH 1 1 1 1 1 1 061365601 433 TERMINAL STRIP, REMOTE T STAT, MARK 4 ONLY 1 1 1 1 1 1 061414001 526 RELAY, MOTORIZED VALVE 1 1 1 1 1 1 061019401 526 RELAY, MOTORIZED VALVE 1 1 1 1 1 1 061019402 526 RELAY, MOTORIZED VALVE 1 1 1 1 1 1 061019404 550 TRANSFORMER - 24V 1 1 1 1 060614101 550 TRANSFORMER - 24V 1 1 060630701 1 = Slope Top Units Only 2 = Flat Top Units Only 3 = Night Setback Control Components WSHP; CWC,CWG,CWH,CWJ,CWK 015-019 Vint. B Rev. B 02/17 RPL 571017 / Page 9
Cabinet Section Diagrams Flat Top Cabinet Diagram Door frame oriented for left-hand piping unit. Door frame oriented for right-hand piping unit. Slope Top Cabinet Diagram Door frame oriented for left-hand piping unit. Door frame oriented for right-hand piping unit. WSHP; CWC,CWG,CWH,CWJ,CWK 015-019 Vint. B Rev. B 02/17 RPL 571017 / Page 10
Cabinet Section Components BUB. NO. DESCRIPTION FIELD REF. NO. PART NO. 601 PANEL, FRONT 1 1 1 1 1 1 1 061312198 601 PANEL, FRONT 2 1 1 1 1 061327699 015 019 602 PANEL, LEFT END 1 1 1 1 1 1 1 061355101 602 PANEL, LEFT END 2 1 1 1 1 061327902 603 PANEL, RIGHT END 1 1 1 1 1 1 1 061355001 603 PANEL, RIGHT END 2 1 1 1 1 061328002 604 PANEL, TIE PIECE 1 1 1 1 1 1 1 061312099 604 PANEL, TIE PIECE 2 1 1 1 1 061328299 651 GRILLE, PLASTIC 1 5 5 5 5 5 5 061356401 651 GRILLE, STAMPED, ONE PIECE STEEL 2 1 1 1 1 1 1 061301202 651 GRILLE, MODULAR 2 5x5 8 8 8 8 8 8 061365101 651 GRILLE, STEEL BAR 2 41 1 1 1 1 1 1 061336002 FRAME, MODULAR GRILLE 2 1 1 1 1 1 1 061456902 652 FRAME, DOOR, PLASTIC 1 1 1 1 1 1 1 061356601 652 FRAME, DOOR, STEEL 2 1 1 1 1 1 1 061301402 653 DOOR, PLASTIC 1 1 1 1 1 1 1 061356701 653 DOOR, STEEL 2 1 1 1 1 1 1 061301302 N/S DOOR, LOCKING (STEEL BAR) 2 1 1 1 1 1 1 061352802 N/S DOOR, STANDARD (STEEL BAR) 2 1 1 1 1 1 1 061301302 N/S LOCK & KEY 1 1 1 1 1 1 1 802018114 N/S LOCK & KEY 1 1 1 1 1 1 061334501 656 END CAP, -1" 1 1 1 1 1 1 1 061356501 N/S PANEL, GRILLE FILLER (MODULAR) 2 1 1 1 1 1 1 061457102 662 PANEL, LOCKING ACCESS DOOR 1 1 1 1 1 1 1 055145308 663 PANEL, BLOCKOFF 1 (LEFT HAND ONLY) 1 1 1 1 1 1 061302302 663 PANEL, BLOCKOFF 2 (LEFT HAND ONLY) 1 1 1 1 061363802 N/S= Not Shown. 1 = Slope Top Units Only 2 = Flat Top Units Only WSHP; CWC,CWG,CWH,CWJ,CWK 015-019 Vint. B Rev. B 02/17 RPL 571017 / Page 11
Subbase & Backwrap Assembly Subbase frame shown in left-hand piping position. Subbase frame shown in right-hand piping position. BUB. NO. DESCRIPTION FIELD REF. NO. PART NO. 605 PANEL, BACKRAP ASSEMBLY (EQU Unit) 1 1 1 1 1 1 061328899 605 PANEL, BACKRAP ASSEMBLY (Standard Unit) 1 1 1 1 061328802 015 019 711 FRAME, SUBBASE (HIGH SILL) 1 1 1 1 1 1 061312402 711 PANEL, SUBBASE (LOW SILL, RIGHT HAND PIPING) 061376602 711 PANEL, SUBBASE (LOW SILL, LEFT HAND PIPING) 061328502 712 PANEL, SUBBASE (HIGH SILL) 1 1 1 1 1 1 061312502 771 BACK PANEL, FINISHED (HIGH SILL) 061400402 771 BACK PANEL, FINISHED (LOW SILL) 061400602 N/S AIR FILTER, THROWAWAY (HIGH SILL) 31.75 x 9.75 x.44 1 1 1 1 1 1 061302502 N/S AIR FILTER, THROWAWAY (LOW SILL) 31.75 x 6.75 x.44 1 1 1 1 1 1 061302504 N/S AIR FILTER, CLEANABLE (HIGH SILL) 31.75 x 9.75 x.50 1 1 1 1 1 1 061364402 N/S AIR FILTER, CLEANABLE (LOW SILL) 1 1 1 1 1 1 061364404 N/S= Not Shown. WSHP; CWC,CWG,CWH,CWJ,CWK 015-019 Vint. B Rev. B 02/17 RPL 571017 / Page 12
Field Installed Accessories Control Box Electric Heat Assembly Key Description Part Number Heater, Dual Element, 1.0KW 061409801 345 Heater, Dual Element, 2.0KW 061409802 Heater, Dual Element, 3.0KW 061409803 Heater, Dual Element, 3.0KW 208V 061409804 346 Switch, Limit 061402903 348 Plug, 2-Pin 802007746 349 Receptacle, 2-Pin 802007747 WSHP; CWC,CWG,CWH,CWJ,CWK 015-019 Vint. B Rev. B 02/17 RPL 571017 / Page 13
Field Installed Accessories Continued Motorized Valve Assembly Diagram Water Flow Use Upper K.O. Fuse Disconnect Assembly Diagram Wire Diagram (On Inside of Access Cover) WSHP; CWC,CWG,CWH,CWJ,CWK 015-019 Vint. B Rev. B 02/17 RPL 571017 / Page 14
Field Installed Accessories Continued Motorized Valve Assy and Fuse Disconnect Assy Key Description Part Number Water Regulating Valve Valve, Motorized, N.C., 120V 802026062 Valve, Motorized, N.C., 277V 802026066 511 Valve, Motorized, N.C., 061381001 Valve, Motorized, N.O., 120V 802026063 Valve, Motorized, N.O., 277V 802026067 Valve, Motorized, N.O., 061380901 524 Tube, Water Extension 061340305 525 Tube, Adapter 802025026 N/S Pressure Actuated Dual Acting Regulating Valve 802026194 Fuse Disconnect Switch Assembly 691 Box, Fuse Disconnect 061360901 692 Bracket, Fuse Disconnect Box 061361201 693 Panel, Cover 061361101 694 Panel, Fuse & Switch 061361001 698 Holder, Fuse- 20A 802007660 Holder, Fuse- 15A 802007553 699 Fuse- 20A 049128307 Fuse- 15A 049128306 700 Receptacle, 20A, 802007514 Receptacle, 20A, 250A 802007511 702 Switch, On-Off Disconnect Rocker 061350601 WSHP; CWC,CWG,CWH,CWJ,CWK 015-019 Vint. B Rev. B 02/17 RPL 571017 / Page 15
Field Installed Accessories Continued Motorized Damper Assembly Key Description Part Number 803 Damper Box 061453102 806 Box, Wire 061443002 808 Door Assembly 061442999 Motor, 115V 802024036 810 Motor, 230V 802024037 Motor, 277V 802024016 813 Operating Arm 820000128 814 Spring Hook 850006704 817 Spring, Extension 802017209 822 Bushing 802007568 825 Switch, Override Toggle 802005045 829 Door Link 802023021 WSHP; CWC,CWG,CWH,CWJ,CWK 015-019 Vint. B Rev. B 02/17 RPL 571017 / Page 16
Field Installed Accessories Continued Supply & Return Hoses. Includes 1/2" fitting, 2 per unit. Ball Valve. 1/2" FPT, 2 per unit. Cleanable Permanent Type Replacement Filters Description Unit Size Part Number 8" All 061268804 Rubber 12" All 061268807 18" All 061268808 9" All 061269011 Fire Rated 12" All 061269007 18" All 061269008 All 802025097 High Sill Low Sill All All 061364402 061364404 Thermostats & Subbases. For Electromechanical Control Units. Code 03 Must Be E. Description Standard Manual Changeover Thermostat & Subbase. Honeywell T834C with no LED. Mounts vertically. System "Heat-Off-Cool" switch and fan. "On-Auto" switch. Standard Automatic Changeover Thermostat & Subbase. Honeywell T874/Q674. LED for "Service." Mounts horizontal. System Off-Auto" switch & fan "On-Auto" switch. Honeywell Chronotherm III Programmable Thermostat & Subbase (1 Stage Heat, 1 Stage Cool) Thermostat Subbase Part Number 066804401 (Includes Subbase) 066804402 060687401 067114201 Thermostats & Subbases. For Mark IV Control Units. Code 03 Must Be M. Description Standard Manual Changeover Thermostat & Subbase. Honeywell T834C with no LED. Mounts vertically. System "Heat-Off-Auto" switch & fan. "On-Auto" switch. Standard Automatic Changeover Thermostat & Subbase. Honeywell T874/Q674. LED for "Service." Mounts horizontal. System "Off-Auto" switch & fan "On-Auto" switch. Standard Manual Thermostat & Subbase. Honeywell T874/Q674. LED for "Service." Mounts horizontal. System "Off-Heat-Auto-Cool" switch & fan "On-Auto" switch. Deluxe Automatic Changeover Thermostat & Subbase with Night Setback & Override. Honeywell T874/Q674. LED for "Service." Mounts horizontal. Requires grounding of unit "U" terminal. Night setback bulb set 12 F below day heat setpoint. System "Off-Auto" switch & fan "On-Auto-Override" switch. Standard Automatic Changeover Thermostat & Subbase for Operating Two Units. Honeywell T874/Q674. LED for "Service."Mounts horizontal. R System "Off-Auto" switch. Honeywell Chronotherm III Programmable Thermostat & Subbase.(1 Stage Heat, 1 Stage Cool) Thermostat Subbase Thermostat Subbase Thermostat Subbase Thermostat Subbase Part Number 066804401 (Includes Subbase) 066804404 060684801 066804404 060684901 066804405 061202601 066804406 060684701 067114201 WSHP; CWC,CWG,CWH,CWJ,CWK 015-019 Vint. B Rev. B 02/17 RPL 571017 / Page 17
Thermostat Accessories Field Installed Accessories Continued Description Part Number Universal Thermostat Guard. Honeywell TG512A. Clear plastic with ring base, lock and keys. 066406602 Programmable Thermostat Guard. Honeywell TG511A. Clear plastic with ring base, lock and keys. 066406702 Locking Control Access Cover. 055145201 Adapter Plate for T874/Q674 Thermostats. Allows for horizontal thermostat to be mounted on a vertical junction box. 802007673 7-Day Time Clock. (Not available for 50 cycle power) Includes spring carryover 802005716 Override Timer 1 Hour 802005717 Override Timer 6 Hour 802005718 Control Accessories Description Shutdown Relay Kit For Electromechanical Control Units. For shutdown of the unit from an external 24 volt AC power source. Relay mounts at control box. Code 04 must be E. Relay is SPDT. Consumes 1.2 VA. Auxiliary Relay. 24 volt DC relay to be wired to low voltage terminal block to allow a set of SPDT pilot duty contacts to operate miscellaneous devices when the fan or compressor operate. Contact rating is 3 amp at 24 volts. Multiple Unit Control Panel. Master and one slave. Allows master unit to be controlled by thermostat. Slave units "follow" with paralleled operation. Not recommended with Boilerless System. Do not use when Mark IV night setback, load shed, override or emergency shutdown logic is being used. Part Number 859004311 803005073 803005159 WSHP; CWC,CWG,CWH,CWJ,CWK 015-019 Vint. B Rev. B 02/17 RPL 571017 / Page 18