NTRIUL LTRONI PUMPS K OUL-IMPLLR OUL-IMPLLR NTRIUL LTRI PUMPS WIT M/P INVRTR TNIL T Operating range: from 2 to 3 m 3 /h with head of up to 95 metres. Liquid temperature range: from -1 to +5 : for K 35/4, K 45/5, K 55/1, from -15 to +8 : for K 55/5, K 66/1, K 9/1, K 7/3, K 8/3, K 7/4, K 8/4. Pumped liquid: clean, free of solids and abrasives, non-viscous, nonaggressive, non-crystallised and chemically neutral, with properties similar to water. Maximum ambient temperature: +4. Maximum operating pressure: K 35/4: 6 bar (6 kpa) K 45/5, K 55/5: 8 bar (8 kpa) K 55/1, K 66/1: 1 bar (1 kpa) K 9/1, K 7/3, K 8/3 K 7/4, K 8/4: 12 bar (12 kpa). Protection class at the terminal board: IP 55. Protection class: IP 44 Insulation class: Installation: normally in horizontal or vertical position, provided that the motor is always above the pump. PPLITIONS ouble-impeller centrifugal pump designed for the realisation of pressurization units in water systems and filling of pressure vessels. Suitable for sprinkler systems and other general water supply uses. ONSTRUTION TURS O T PUMP Pump body and motor support in cast iron. Opposite technopolymer impellers. arbon/ceramic mechanical seal. ONSTRUTION TURS O T MOTOR losed asynchronous type, external ventilation cooling. Rotor running on permanently lubricated ball bearings, oversized to ensure low noise and durability. onstruction according to I 2-3. ontrolled by M inverter. Standard single-phase voltage: 1x23 V / 5-6 z Special version on request: three-phase 3x4 V / 5 z, or three-phase 3x46 V / 6 z Standard three-phase voltage: 3x4 V / 5 z Special version on request: 3x46 V / 6 z PUMPS reserves the right to make modifications without notice. 16
K OUL-IMPLLR OUL-IMPLLR NTRIUL LTRI PUMPS WIT M/P INVRTR M/P INVRTR M-P ONSTRUTION TURS O T LTRONIS: M/P INVRTR The inverter continuously adjusts the rotation speed of the electric pump, keeping the pressure constant, even when the flow rate varies. The other electric pumps, also with variable speed, are activated in cascade after the first one has reached maximum speed. Through modulation, they compensate the pressure fluctuations of the system. or every operating cycle, it is possible to switch the restart to a different pump, therefore ensuring even use of all electric pumps. It is possible to set operation times for each individual pump, switching to another pump after such set times. The "SP" pressure can be adjusted by the user using the "+" and "-" keys found on the M/P (as a rule, all the pumps are set to the same pressure value). With the new M/P, it is sufficient to set the data on one of the devices, and it will be automatically propagated to the other pumps of the system. NTRIUL LTRONI PUMPS MOS O OPRTION P kpa Q US gpm Q IMP gpm m ft P kpa Q US gpm Q IMP gpm m ft PRORMN URVS WITOUT INVRTR Q m 3 /h PRORMN URVS WIT INVRTR Q m 3 /h The inverter is capable of maintaining a constant pressure even when the flow rate varies. The operating pressure can be adjusted by the user. good pressure set-point is between 1/3 and 2/3 of the maximum head of the electric pump. In this way, high efficient of the pump is maintained, together with maximum saving. In addition, the M/P does not block the pump if the pressure is not reached, but the flow is present. This prevents service interruptions in case of high flows. or more information refer to the technical appendix. PUMPS reserves the right to make modifications without notice. 17
NTRIUL LTRONI PUMPS MTRILS N. PRTS MTRILS MOLS 1 PUMP OY ST IRON 2 UNI ISO 185 3 SUPPORT ST IRON 2 UNI ISO 185 K OUL-IMPLLR OUL-IMPLLR NTRIUL LTRI PUMPS WIT M/P INVRTR 4 IMPLLR TNOPOLYMR K 35/4; K 45/5; K 55/1 TNOPOLYMR K 55/5; K 66/1; K 9/1; K 7/3; K 8/3; K 7/4; K 8/4 ISI 416 STINLSS STL X12RS13 UNI 69/71 K 35/4 7 ST WIT ROTOR ISI 33 STINLSS STL X1RNIS 189 UNI 69/71 K 45/5; K 55/5; K 55/1; K66/1; K 9/1 ISI 34 STINLSS STL X5 NI 181 UNI 69/71 K 7/3; K 8/3; K 7/4; K 8/4 16 MNIL SL RON / RMI 28 SKT NR RUR K 35/4; K 45/5; K 55/5; K 55/1 34 INTRMIT IS ST IRON 2 UNI ISO 185 K 35/4; K 45/5; K 55/5; K 55/1; K 66/1; K 9/1; K 7/3; K 7/4; K 8/3; K 8/4 * In contact with the liquid K 35/4 1 28 3 16 K 45/5 - K 55/5 1 28 3 16 4 34 7 4 34 7 K 55/1 - K 66/1 - K 9/1 - K 7/3 - K 8/3 - K 7/4 - K 8/4 28 1 16 4 34 3 7 SLTION TL - K OUL-PROPLLR MOL Q=m 3 /h 1,2 1,8 2,4 3,6 4,8 6 7,2 9 9,6 1,8 12 15 18 24 3 Q=l/min 2 3 4 6 8 1 12 15 16 18 2 25 3 4 5 K 35/4 M M11/P 43,5 41,5 4 38 33 23,5 K 45/5 M M15/P 51 49 47,5 46 42 37 3 K 55/5 M M15/P 62 6 58 57 52 45 34 K 55/1 T M3/P 62 59,5 57 54,5 51 47 39 36 K 66/1 T M3/P 73 7 67,5 64 6,5 57 49 47 K 9/1 T M55/P (m) 83,5 82 79,5 76,5 72,5 68 61 58 K 7/3 T M55/P 76 74 73 72 71,5 7 69 65 6,5 43,5 K 8/3 T M11/P 95 93 92,2 91 9,5 9 89,5 87 82 68 K 7/4 T M11/P 86 84 83,2 82,5 82 79 76 65 47 K 8/4 T M11/P 97 95 94,5 94 92 89 8 64 PUMPS reserves the right to make modifications without notice. 18
K 35/4 - OUL-IMPLLR NTRIUL LTRI PUMPS WIT M/P INVRTR, OR WTR SUPPLY IN OMSTI, IVIL, N INUSTRIL NVIRONMNTS Pumped liquid temperature range: from -1 to +5 - Maximum ambient temperature: +4 2 1 N NM NTRIUL LTRONI PUMPS NM 1 mm 2 /s and density equal to 1 /m 3. urve tolerance according to ISO 996. MOL POWR INPUT 5 z P1 MX LTRIL T P2 NOMINL K 35/4 M M11/P 1 x 23 V 1,3,75 1, 1,3 2838 P In MOL I 1 2 N NM PKIN IMNSIONS VOLUM L/ L/ WIT K 35/4 M M11/P 563 2 76 148 72 15 148 9,5 271 1 135 1 1 826 43 426,151 2,5 PUMPS reserves the right to make modifications without notice. 19
K 45/5 - OUL-IMPLLR NTRIUL LTRI PUMPS WIT M/P INVRTR, OR WTR SUPPLY IN OMSTI, IVIL, N INUSTRIL NVIRONMNTS Pumped liquid temperature range: from -1 to +5 - Maximum ambient temperature: +4 NTRIUL LTRONI PUMPS NM 2 1 N NM P kpa 5 4 3 4 8 12 16 2 24 4 8 12 16 2 m 5 4 3 Q US gpm Q IMP gpm ft 7 2 2 NPS m NPS 3 ft 7 2 2 5 1 15 1 3 1 1 5 1 1 2 3 4 5 6 Q m 3 /h P P η η% 2 3 6 5 4 2 1,5 1 1,5 P 1 2 3 4 5 6,5 1 1,5 2 4 6 8 1 2 1 Q m 3 /h Q l/s Q l/min 1 mm 2 /s and density equal to 1 /m 3. urve tolerance according to ISO 996. MOL POWR INPUT 5 z P1 MX LTRIL T P2 NOMINL K 45/5 M M15/P 1 x 23 V 2 1,6 2,2 14,7 2866 P In MOL I 1 2 N NM PKIN IMNSIONS VOLUM L/ L/ WIT K 45/5 M M15/P 57 21 75 144 69 15 165 11,5 289 118 15 1 ¼ 1 826 43 426,151 27,7 PUMPS reserves the right to make modifications without notice. 2
K 55/5 - OUL-IMPLLR NTRIUL LTRI PUMPS WIT M/P INVRTR, OR WTR SUPPLY IN OMSTI, IVIL, N INUSTRIL NVIRONMNTS Pumped liquid temperature range: from -15 to +8 - Maximum ambient temperature: +4 2 1 N NM NTRIUL LTRONI PUMPS NM 1 mm 2 /s and density equal to 1 /m 3. urve tolerance according to ISO 996. MOL POWR INPUT 5 z P1 MX LTRIL T P2 NOMINL K 55/5 M M15/P 1 x 23 V 2,53 1,6 2,2 18,1 2828 P In MOL I 1 2 N NM PKIN IMNSIONS VOLUM L/ L/ WIT K 55/5 M M15/P 57 21 75 144 69 15 165 11,5 289 118 15 1 ¼ 1 826 43 426,151 28,2 PUMPS reserves the right to make modifications without notice. 21
K 55/1 - OUL-IMPLLR NTRIUL LTRI PUMPS WIT M/P INVRTR OR WTR SUPPLY IN OMSTI, IVIL, N INUSTRIL NVIRONMNTS Pumped liquid temperature range: from -1 to +5 - Maximum ambient temperature: +4 NTRIUL LTRONI PUMPS 2 1 N NM NM 1 mm 2 /s and density equal to 1 /m 3. urve tolerance according to ISO 996. MOL POWR INPUT 5 z P1 MX LTRIL T P2 NOMINL K 55/1 T M3/P 3 x 4 V 3,66 2,2 3, 8,93 2929 P In MOL I 1 2 N NM PKIN IMNSIONS VOLUM L/ L/ WIT K 55/1 T M3/P 65 267 88 16 72 18 2 14 362 14 172,5 1 ½ 1 826 43 426,151 44,9 PUMPS reserves the right to make modifications without notice. 22
K 66/1 - OUL-IMPLLR NTRIUL LTRI PUMPS WIT M/P INVRTR, OR WTR SUPPLY IN OMSTI, IVIL, N INUSTRIL NVIRONMNTS Pumped liquid temperature range: from -15 to +8 - Maximum ambient temperature: +4 2 1 N NM NTRIUL LTRONI PUMPS NM 1 mm 2 /s and density equal to 1 /m 3. urve tolerance according to ISO 996. MOL POWR INPUT 5 z P1 MX LTRIL T P2 NOMINL K 66/1 T M3/P 3 x 4 V 4,32 3, 4, 9,64 2878 P In MOL I 1 2 N NM PKIN IMNSIONS VOLUM L/ L/ WIT K 66/1 T M3/P 65 267 88 16 72 18 2 14 362 14 172,5 1 ½ 1 826 43 426,151 47,5 PUMPS reserves the right to make modifications without notice. 23
K 9/1 - OUL-IMPLLR NTRIUL LTRI PUMPS WIT M/P INVRTR, OR WTR SUPPLY IN OMSTI, IVIL, N INUSTRIL NVIRONMNTS Pumped liquid temperature range: from -15 to +8 - Maximum ambient temperature: +4 NTRIUL LTRONI PUMPS 2 1 N NM NM 1 mm 2 /s and density equal to 1 /m 3. urve tolerance according to ISO 996. MOL POWR INPUT 5 z P1 MX LTRIL T P2 NOMINL K 9/1 T M55/P 3 x 4 V 5,23 3, 4, 1,8 2871 P In MOL I 1 2 N NM PKIN IMNSIONS VOLUM L/ L/ WIT K 9/1 T M55/P 65 267 88 16 72 18 2 14 362 14 172,5 1 ½ 1 826 43 426,151 5,8 PUMPS reserves the right to make modifications without notice. 24
K 7/3 - OUL-IMPLLR NTRIUL LTRI PUMPS WIT M/P INVRTR, OR WTR SUPPLY IN OMSTI, IVIL, N INUSTRIL NVIRONMNTS Pumped liquid temperature range: from -15 to +8 - Maximum ambient temperature: +4 2 1 N NM NTRIUL LTRONI PUMPS NM 1 mm 2 /s and density equal to 1 /m 3. urve tolerance according to ISO 996. MOL POWR INPUT 5 z P1 MX LTRIL T P2 NOMINL K 7/3 T M55/P 3 x 4 V 6,73 5,5 7,5 14,1 2934 P In MOL I 1 2 N NM PKIN IMNSIONS VOLUM L/ L/ WIT K 7/3 T M55/P 83 27 122 182 6 2 21 14 382 16 18 2 1 ¼ 126 53 546,297 79,8 PUMPS reserves the right to make modifications without notice. 25
K 8/3 - OUL-IMPLLR NTRIUL LTRI PUMPS WIT M/P INVRTR OR WTR SUPPLY IN OMSTI, IVIL, N INUSTRIL NVIRONMNTS Pumped liquid temperature range: from -15 to +8 - Maximum ambient temperature: +4 NTRIUL LTRONI PUMPS 2 1 N NM NM 1 mm 2 /s and density equal to 1 /m 3. urve tolerance according to ISO 996. MOL POWR INPUT 5 z P1 MX LTRIL T P2 NOMINL K 8/3 T M11/P 3 x 4 V 9,83 7,5 1, 19,4 2926 P In MOL I 1 2 N NM PKIN IMNSIONS VOLUM L/ L/ WIT K 8/3 T M11/P 853 341 122 182 6 2 21 14 382 16 18 2 1 ¼ 126 53 546,297 86,6 PUMPS reserves the right to make modifications without notice. 26
K 7/4 - OUL-IMPLLR NTRIUL LTRI PUMPS WIT M/P INVRTR, OR WTR SUPPLY IN OMSTI, IVIL, N INUSTRIL NVIRONMNTS Pumped liquid temperature range: from -15 to +8 - Maximum ambient temperature: +4 2 1 N NM NTRIUL LTRONI PUMPS NM 1 mm 2 /s and density equal to 1 /m 3. urve tolerance according to ISO 996. MOL POWR INPUT 5 z P1 MX LTRIL T P2 NOMINL K 7/4 T M11/P 3 x 4 V 9,57 9,2 12,5 2,4 2948 P In MOL I 1 2 N NM PKIN IMNSIONS VOLUM L/ L/ WIT K 7/4 T M11/P 893 341 122 182 6 2 21 14 382 16 18 2 1 ¼ 126 53 546,297 86,9 PUMPS reserves the right to make modifications without notice. 27
K 8/4 - OUL-IMPLLR NTRIUL LTRI PUMPS WIT M/P INVRTR, OR WTR SUPPLY IN OMSTI, IVIL, N INUSTRIL NVIRONMNTS Pumped liquid temperature range: from -15 to +8 - Maximum ambient temperature: +4 NTRIUL LTRONI PUMPS 2 1 N NM NM 1 mm 2 /s and density equal to 1 /m 3. urve tolerance according to ISO 996. MOL POWR INPUT 5 z P1 MX LTRIL T P2 NOMINL K 8/4 T M11/P 3 x 4 V 11,2 11, 15, 22,7 2953 P In MOL I 1 2 N NM PKIN IMNSIONS VOLUM L/ L/ WIT K 8/4 T M11/P 893 341 122 182 6 2 21 14 382 16 18 2 1 ¼ 126 53 546,297 9,9 PUMPS reserves the right to make modifications without notice. 28