WISCONSIN ROBIN WR-W-5VPM REV DATE: 0-9 Standard Specification 60000 and 60000 Introduction This catalog is designed to identify Wisconsin Robin parts. When ordering parts, it is always advisable to list the engine model, specification number and serial number. With this information, can we check your order for any incorrect part numbers. Use your Service Parts List to insure proper part number and nomenclature identification. TELEDYNE TOTAL POWER reserves the right to modify, alter and improve enginesand parts. Part numbers and the structure of parts may change from those shown this in catalog. Table of Contents Crankcase and Related Parts... " ". -..- Crankshaft, Connecting Rod and Pis ton...;... Muffler and Air Cleaner... Governor and Control Rod for engines up to and including Serial Number 09 for Specification 60000, and for engines up to and including Serial Number 079 for Specification 60000... 4 Governor and Control Rod for engines after Serial Number 065 for Specification 60000, and engines after Serial Number 059 for Specification 60000... 5 Air Shroud and Recoil Start... 6 Fuel Tank and Carburetor... 7 Flywheel, Ignition Coil and Brake for engines up to and including Serial Number 09 for Specification 60000... 8 Flywheel, Ignition Coil and Brake for engines after Serial Number 065 for Specification 60000... 9 Flywheel and Ignitional Coil for Specification 60000... 0
Crankcase and Related Parts ITEM NO. PART NO. DESCRIPTION Qm. EY57 050 4 5 6 7 8 9 0 4 5 6 7 8 9 0 EY57 040 0 EYOOl08 5 EYOOl086 5 EY000600 0 EY044 00800 0 EY044 000 00 EY044 050 80 EY060 0000 0 EY060 0500 0 EYOOl 406550 EYOOl 406400 EY57 500 EYOlO 5060 0 EYOlO 5060 40 EY57 5000 EY00 808000 EY00 008000 EY00 0080 00 EY57 00 EY57 500 EY0 00800 7 EYOOl 408 50 EY57 9900 07 Crankcase (w/flywheel brake, includes - ) spec 60000 Crankcase (no flywheel brake, includes - ) for spec 60000 Stud Stud Dowel pin Oil seal Oil seal Oil seal Ball bearing Ball bearing Bolt and washer assembly Bolt and washer assembly Cylinder (includes.. and 4) Stud Stud Gasket, cylinder Nut Lock washer Washer Cylinder head Gasket, head Bolt and washer assembly Bolt and washer assembly Engine gasket set (includes 5 and 0; includes,lo and from page 6).. 4 4 4 -- WISCONSIN ROBIN MODEL WTI-5V
I
Crankshaft, Connecting Rod and Piston ITEM NO. PART NO. DESCRIPTION QTY. EY57 090 00 EY57 080 00 EY005 900 60 EY57 45 0 Crankshaft assembly, spec 60000 Crankshaft assembly spec 60000 Spring pin Piston complete, standard 4 5 6 7 8 9 0 EY57 45 0 EY57 45 0 EY57 50 07 EY57 50 07 EY57 50 07 EY57 0 0 EY056 500 0 EY06000 0 EY00 70 00 EY00 00 00 EY005 04 0 EY57 500 0 EY57 500 0 Piston complete, oversize (0.5mm [.00 in.]) Piston complete, oversize (0.50mm [.00 in.]) Piston ring set, standard Piston ring set, oversize (0.5mm [.00 in.]). Piston ring set, oversize (0.50mm [.00 in.]) Piston pin Clip Needle bearing Nut Lock washer Woodruff key Shim (0.lmm [.009 in.]) Shim (0.mm [.08 in.]) -4- WISCONSIN ROBIN MODEL WT-5V
Muffler and Air Cleaner ITEM NO. PART NO. DESCRIPTION Qn. 6 7 8 9 0 EY57 00 0 EY57 50 0 EY00 9080 00 EY00 0080 00 EYOOll0860 EY57 606 00 - * EY57 640 0 - * EY57 60 0 EY7 600 EY57 90 0 EY57 500 0 EY57 70 08 Muffler Gasket, exhaust Nut Lock washer Bolt and washer assembly Air cleaner (includes 6-9,) Plate, air cleaner Guide plate Cover, air cleaner Cleaner element complete Gasket, air cleaner Insulator Gasket, insulator Warning label *Not serviced separately -6- WISCONSIN ROBIN MODEL WT-5V
? J
Governor, Control Rod for Engines Up To and Including Serial No.09 for Spec 60000, and for Engines Up To and Including Serial No. 079 for Spec 60000 ITEM NO. PART NO. DESCRIPTION Qm. 4 5 6 7 8 9 0 4 5 EY57 470 0 EY57 490 0 EY57 40 0 EY57 40 0 EY004 5040 60 * EY06 440 0 EY00 7060 00 EY00 0060 00 EY004 6040 80 EY57 450 0 EY57 480 0 EY4 470 0 EY06 40 0 * Governor plate complete Governor sleeve Governor yoke Governor shaft Screw and washer assembly Governor lever Adjusting plate Nut Lock Washer Screw and washer assembly Governor spring Rod spring Governor rod Rod spring Speed control complete 6 7 8 9 0 EY57 4500 0 EY57 460 0 EYOOl650660 EY57 48 0 EY57 450 0 EYOllOO600 0 EY004 04 60 EY57 4900 0 EY 57 400 07 Cover Washer Bo t Choke lever complete Choke rod Flange bolt Screw Spring, adjuster Governor lever kit (includes 6-0) **EY57 40 07 Speed control lever kit (includes 5-8, and ) *Not serviced separately. **Upon depletion of stock, speed control lever kit EY57 40 07 will no longer be available. For service use EY57 4 07. -8- WISCONSIN ROBIN MODEL WTl-5V
Governor, Control Rod for Engines After Serial No. 065 for Spec 60000, and for Engines After Serial No. 059 for Spec 60000 ITEM NO. PART NO. DESCRIPTION Q=* 4 5 6 7 8 9 0 4 5 6 7 8 9 0 4 5 6 7 - - EY57 470 0 Governor plate EY57 490 0 sleeve Governor EY57 40 yoke 0 EY57 40 shaft 0 Governor Governor EY004 504060 Screw and washer assembly - " * lever Governor EY57 4400 plate EY00 7060 00 EY00 0060 washer 00 EY004 604080 EY57 4505 0 EY57 480 0 EY4 470 0 EY57 480 0 Adjusting Nut Spring Screw and washer Governor spring Rod spring Governor rod Rod spring assembly EY57 4 0 lever control Speed EY57 4500 EY57 4600 EYOOl6506 60 EY57 lever 480 EY57 4500 EYOllOO600 0 EY004 04 60 Cover Washer Bolt Choke Choke rod Flange bo t Screw EY57 4900 adjuster 0 Spring, EY57 44 lever EY57 4700 0 EY57 470 0 EY00 7060 00 EY57 40 07 Control Tension spring Set bo t Nut Governor lever kit (includes 6-0) EY57 407 Speed control lever kit (includes,5,6, 8, 9,, - 7) *Not serviced separately. -0- WISCONSIN RQBIN MODEL WTI-5V
Air Shroud and Recoil Start ITEM NO. PART NO. DESCRIPTION QTY. EY57 550 0 Air shroud (w/flywheel EY57 55 0 brake) spec 60000 Air shroud (w/blade brake) 4 5 6 7 8 9 0 EY07 00 0 EY57 560 0 EYOll 00600 0 EY57 5040 00 EY6 50 08 - " * - " * EY5 5055 08 - " * - " * spec 60000 Warning label Cylinder baffle Flange bolt Recoil starter assembly (includes 5-7,0) Reel Ratchet Ratchet pin Spiral spring Friction spring Thrust washer Friction plate 6 4 5 6 7 8 9 0 - EY00 8060 00 EY6 5008 08 - " * - " * EY57 50445 08 EY05 0600 70 EYOOl 006 0 EY5 50550 08 EY57 50400 07 Flange nut Starting rope (includes 5,6) Starting knob Knob cap Starting pulley Tapping screw Bolt and washer assembly Bushing Hardware kit (includes 7,8, 0 - ) 7 *Not serviced separately -- WLSCONSIN ROBIN MODEL WT-5V
\ I \ 4 \\ 5 *? \ \ \ '\I Q"6 I 8 9 DETA I L "A"
Fuel Tank and Carburetor ITEM NO. PART NO. DESCRIPTION QTY. 8 9 0 4 5 6 7 8 9 0 4 5 6 7 8 9 0 ** *M EY57 6000 Fuel tank (includes - 6/> A* EY57 6000 Fuel tank (includes - 6/) EY04 0440 0 Cap, fuel tank (includes - 6) " " * cap Inner - " * Sponge EY00600 Gasket, tank cap - " * plate Partition EY064 00440 Fuel strainer assembly (includes 8 and 9) - " * Sleeve - " * Clamp EY064 400 0 Fuel filter EY57 660 Bracket, tank (w/flywheel EY57 660 brake) spec 60000 Bracket, tank (w/blade brake) EY57 65000 spec 60000 Tank strap EY57 650 0 band Tank (rubber) EYO 00600 0 Flange bo t EYOOl 08 60 Bolt and washer assembly EY5 490 0 Clamp EY004 605 60 Screw and washer assembly *M EY085 040 hose 40 Rubber A** EY085 044 hose 40 Rubber * AA EY056 0800 0 Hose clamp EY085 00070 Rubber hose EY57 6000 assembly Carburetor EY06 656 valve 08 Throttle EY50 656 08 Screw EY7 64508 Screw EY57 valve 65 08 Choke EY8 640 08 Pilot jet EY09 6508 Screw EY0 68 08 Spring EY57 605 assembly 08 Needle EY4 65508 Pin EY6 6506 08 Float EY57 656 08 Throttle shaft assembly EY 57655 08 Seal -4- (Continued on page 6) WISCONSIN ROBIN MODEL WT-5V
Fuel Tank and Carburetor (cont.) 4 5 6 7 8 9 40 4 4 4 44 45 46 47 48 49 50 5 5 5 54 - EY57 654 08 Spring EY57 lever 65 08 Choke EY6 655008 Ring EY57 656 08 Ring EY4 6540 08 Packing EY4 655 08 chamber Float body EY57 nozzle 644 08 Main EY4 645 08 Bolt EY4 645008 Packing EY7 64008 Main jet EY6 670008 Cap EY57 64 08 Air jet jet EY57 64 08 Air EY6 67008 Hose EY06 69 08 Seal EY6 670 08 Clip EY00 706000 Nut EY00 006000 Lock washer Am EYOOl 006 0 Bolt and washer assembly Am EY056 6000 70 Clamp A. EYOOl6508 0 Bo t EY57 600 7 Carburetor kit repair (includes,4,9,0,,8, 4,48 and 49) *Not serviced separately. **Upon depletion of stock, fuel tank EY57 600 0 will no longer be available. For service use EY57 600 0 with the following parts:. EY085 044 40 EY056 0000 EY056 6000 70 EYOOl6508 0 Rubber hose Hose clamp Clamp Bo t *For engines up to serial no. 09 for spec 60000. MFor engines up to serial no. 079 for spec 60000. AFor engines after serial no. 065 for spec 60000..For engines after serial no. 059 for spec no. 60000. -6- WISCONSIN RORIN MODEL WTl-5V
Flywheel, Ignition Coil and Brake for Engines Up To and Including Serial No. 09 for Spec 60000 ITEM NO. PART NO. DESCRIPTION QW. 4 5 6 7 8 9 0 4 5 6 7 8 9 0 4 5 EY57 797 08 EY57 7947 08 EYOOl 606 00 EY57 7500 0 EY57 7500 0 EY6 7705 0 EY00 0040 00 EY004 504 0 EY065 0404 60 EY0 750 EY065 5000 00 EY4 79006 0 EY57 7600 0 EYOOl 6508 0 EY57 8600 00 EY57 860 0 EY6 86006 0 EY00 060 00 EY57 8640 0 EY57 860 0 EY57 860 EY6 8605 0 EYOOl 06 60 EY00 060 00 EYOOl660660 EY0 00600 0 Flywheel Ignition coil Bolt and washer as ;sembly Grommet Grommet Stop switch Washer Screw and washer assembly Spark plug Spark plug cap Clip Clamp complete Plug guard Bo t Brake assembly (includes 5-0) Brake holder complete (includes 6 and 7) Brake shoe Clip Spacer Control lever Return spring Brake spring Bolt and washer assembly Washer Bo t Spacer. -8- WISCONSXN ROBIN MODEL WT-5V
0
Flywheel, Ignition Coil and Brake for Engines After Serial No. 065 for Spec 60000 ITEM NO. PART NO. DESCRIPTION Qm. 4 5 6 7 8 9 0 4 5 6 7 8 9 0 4 5 6 7 EY57 797 08 EY57'7947 08 EYOOl 006 00 EY57 7500 0 EY57 7500 0 EY6 7705 0 EY00 040 00 EY004 504 0 EY065 0404 60 EY0 750 EY065 5000 00 EY4 79006 0 EY57 7600 0 EYOOl6508 0 EY57 8600 00 EY57 8660 0 EY00 060 00 EY57 8640 0 EY57 860 0 EY57 860 EY6 8605 0 EYOOl 06 60 EY00 060 00 EYOOl 6606 60 EY0 00600 0 EY57 8670 0 EY57 8680 0 Flywheel Ignition coil Bolt and washer assembly Grommet Grommet Stop switch Washer Screw and washer assembly Spark plug Spark plug cap Spark plug cap Clamp Plug guard Bolt Brake assembly (includes 6-0) Brake shoe Clip Spacer Control lever Return spring Brake spring Bolt and washer assembly Washer Bo t Spacer Pivot bolt Bracket, brake -0- WISCONSIN ROBIN MODEL WTI-5V
9
Flywheel and Ignition Coil for Spec 60000 ITEM NO. PART NO. DESCRIPTION Qn. 4 5 6 7 8 9 0 4 5.. EY57 79708 EY57 7947508 EYOOl 00600 EY57 7500 0 EY57 7500 0 EY6 7705 0 EY00 0040 00 EY004 504 0 EY065 0404 60 EY0 750 EY065 5000 00 EY4 79006 0 EY57 7600 0 EYOOl6508 0 ".. EY056 60500 0 Flywheel Ignition coil Bolt and washer assembly Grommet Grommet Stop switch Washer Screw and washer assembly Spark plug Spark plug cap Clip Clamp Plug guard Bo t Clamp -- WISCONSIN ROBIN MODEL WTl- 577