To: All Toyota Dealer Principals, Service Managers, and Parts Managers Subject: Safety Recall C0U Remedy Parts Available 2004 to Certain 2009 Model Year Prius Vehicles Hybrid Electric Water Pump As previously announced, in November, 2012, Toyota filed a Defect Information Report (DIR) with the National Highway Traffic Safety Administration (NHTSA) informing the agency of our intent to conduct a voluntary Safety Recall on 2004 to certain 2009 model year Prius vehicles. Toyota has completed parts preparation and will now begin mailing the remedy owner letter. Condition There is a possibility that the coil wire of the electric motor installed in the Water Pump for the Hybrid System may have been scratched during the coiling manufacturing process at the supplier. In this condition, the coil wire may corrode at the scratched portion and in some cases break. If this occurs, the water pump could stop, leading to the illumination of various warning lights in the instrument panel. There is also the potential that a short circuit can occur between adjacent coil wires, resulting in an open fuse for the electric power supply circuit. If the fuse is open, the hybrid system will stop while the vehicle is being driven, which may increase the risk of a crash. Remedy Toyota dealers will replace the Hybrid Electric Water Pump at NO CHARGE to the vehicle owner. For additional information on inspection and repair procedures, please refer to TIS. The following vital information is provided to inform you and your dealers of the remedy owner notification phase of this campaign and your degree of involvement. 1. Owner Letter Mailing Date Toyota has completed parts preparation and will begin to notify owners of the Remedy Phase in Mid- January, 2013. The owner notification will be mailed in quantities consistent with parts availability and repair capacity. Toyota tries very hard to obtain current customer name and address information when mailing owner letters. In the event your dealership receives a notice for a vehicle that was sold prior to the Safety Recall announcement, it is the dealership s responsibility to forward the owner letter to the customer who purchased the vehicle. Please note that only owners of the covered vehicles will be notified. If dealers are contacted by an owner who has not yet received a notification, please instruct them to verify eligibility by confirming through Dealer Daily/TIS prior to performing repairs. Dealers should perform the repair as outlined in the Technical Instructions found on TIS. 2. Used Vehicles in Dealership Inventory (In-Stock Vehicles and Toyota Rent-A-Car (TRAC)) Toyota requests dealers to conduct the remedy on any pre-owned vehicles currently in dealer inventory that are covered by this Safety Recall prior to delivery to the customer. 3. Dealer/Owner Lists Summary Reports, containing the number of covered vehicles in your dealership s primary marketing area, have been enclosed in the dealer package. (Please verify eligibility by confirming through Dealer Daily or TIS prior to performing repairs.)
Safety Recall C0U D Page 2 4. Number and Identification of Covered Vehicles There are approximately 350,000 Prius (2004 to certain 2009 model year) vehicles covered by this Safety Recall in the U.S. Model WMI MY VDS START FINISH Prius JTD 2004 2005 2006 KB20U 0001175 0116869 KB22U 0001260 0116749 KB20U KB22U KB20U KB22U 2007 KB20U 2008 KB20U 2009 KB20U 0116878 0133247 3000027 3128073 7004347 7057932 0116886 0132689 3000115 3128039 7004602 7057877 3099688 3202420 7057977 7545072 3128125 3202418 7056471 7544598 3202456 3296439 7083529 7694891 3291973 3462539 7690436 7818544 3458507 3546425 7815791 7894047 Please note that only owners of the covered vehicles will be notified. If a dealer is contacted by an owner who has not yet received the notification, please instruct the dealer to verify coverage by confirming through Dealer Daily/TIS. Dealers should perform the procedure as outlined in the Technical Instructions located on TIS. A UIO matrix by state is provided to inform your dealership of the number of covered vehicles in your state. STATE UIO STATE UIO STATE UIO STATE UIO STATE UIO AK 653 HI 1,660 MI 5,549 NV 2,585 UT 2,791 AL 2,546 IA 2,991 MN 6,954 NY 16,771 VA 11,653 AR 2,131 ID 1,536 MO 4,902 OH 8,727 VT 1,711 AZ 9,379 IL 12,393 MS 1,160 OK 2,320 WA 13,773 CA 81,500 IN 5,225 MT 1,137 OR 7,844 WI 6,452 CO 7,112 KS 2,558 NC 9,819 PA 11,439 WV 989 CT 5,582 KY 2,642 ND 357 RI 1,235 WY 473 DC 1,158 LA 1,895 NE 1,282 SC 3,132 DE 951 MA 10,788 NH 2,379 SD 581 FL 16,927 MD 8,324 NJ 8,244 TN 4,200 GA 6,372 ME 2,219 NM 2,269 TX 18,437 5. LSC A0N related update Please note that the LSC A0N is now superseded by Safety Recall C0U. Any non-completed vehicles covered by A0N are now loaded under C0U as not completed.
Safety Recall C0U D Page 3 6. Super Long Life Coolant Chemical Part No. Chemical Name Qty/Unit 00272-SLLC2 Toyota Genuine 50/50 Pre-Diluted Super Long Life Coolant (SLLC) 1 Gal. Toyota Genuine 50/50 Pre-Diluted Super Long Life Coolant (SLLC) can be ordered through the Toyota Chemical Program and will be drop shipped from AMREP. 7. Parts Ordering Process (Dealer Ordering Solutions) Orders can be placed through your dealership s facing PDC. The parts have been placed on dealer ordering solutions; please refer to the Weekly Parts Allocation Report for additional details. All parts replaced for this Safety Recall are subject to Warranty Parts Recovery. Model Application Part No. Part Name Qty/Unit Prius 04000-32528 Hybrid Water Pump Kit 1 The kit above includes the following parts: G9020-47031 = Hybrid Water Pump = Quantity 1 90430-18008 = Hybrid Water Pump Gasket = Quantity 1 If additional quantities are required, please contact your facing PDC Customer Support Leader. Each dealership will receive specific dealer ordering criteria in an email from their facing PDC Manager based on Repair Order Volume * PDC Affected UIO. Therefore, it is vital that each dealership work with both Parts and Service to immediately file Safety Recall claims and coordinate appropriate kit orders. A sample of the Parts Allocation Report has been attached below for your reference. IMPORTANT PARTS ORDERING UPDATE All Safety Recall, Service Campaign (SSC/LSC) and Customer Support Program (CSP) parts will be eligible for the Monthly Parts Return Program. Please refer to PANT Bulletin 2011-087 for campaign parts that are currently returnable under the Monthly Parts Return Program and additional details. Note: Chemicals, such as Grease, are not eligible for the Monthly Parts Return Program.
Safety Recall C0U D Page 4 8. Remedy Procedures Please refer to TIS for Technical Instructions on inspection and repair. Conduct all applicable, non-completed Safety Recall and Service Campaigns on the vehicle during the time of appointment. 9. Warranty Reimbursement Procedure 2004 to Certain 2009 Model Year Prius Vehicles Op. Flat Rate Model Description Code Hour Prius 2508LA Replace the Hybrid Electric Water Pump 1.1 hr/vehicle Coolant Sublet: The cost of 50/50 Pre-Mix Super Long Life Coolant (00272-SLLC2) can be claimed as sublet type OF at a maximum of 2.8L ($15.05 per vehicle) under Op. Code 2508LA Towing Sublet: If the customer s vehicle required towing to the dealership, use TW sublet type under Op. Codes 2508LA for the total amount of the towing service. 0.1 hr/vehicle of administrative cost is covered under Safety Recall C0T because all vehicles covered by C0U are also covered by C0T. Campaign Designation Decoder Examples: A0D = Launched in 2010, Remedy Phase, 4 th Campaign Launched in 2010 B1M = Launched in 2011, Interim Phase, 13 th Campaign Launched in 2011 C0B = Launched in 2012, Remedy Phase, 2 nd Campaign Launched in 2012
Safety Recall C0U D Page 5 10. Repair Quality Confirmation The repair quality of covered vehicles is extremely important to Toyota. To help ensure that all vehicles have the repair performed correctly, please designate at least one associate (someone other than the individual who performed the repair) to verify the repair quality of every vehicle prior to customer delivery. 11. Media Contacts It is imperative that all media contacts (local and national) receive a consistent message. In this regard, all media contacts must be directed to Brian Lyons (310) 468-2552 in Toyota Corporate Communications. (Please do not provide this number to customers. Please provide this contact to only media associates.) 12. Customer Contacts A Q&A has been attached for your use in the event you receive a customer contact. If a customer has further questions, please direct the inquiry to the Toyota Customer Experience Center at 1-800-331-4331. Please review this entire package with your Service and Parts staff to familiarize them with the proper step-by-step procedures required to implement this Safety Recall. Thank you for your cooperation. TOYOTA MOTOR SALES, U.S.A., INC.
Safety Recall C0U 2004 through Certain 2009 Model Year Prius Vehicles Hybrid Electric Water Pump Q&A Q1: What is the condition? A1: There is a possibility that the coil wire of the electric motor installed in the Water Pump for the Hybrid System may have been scratched during the coiling manufacturing process at the supplier. In this condition, the coil wire may corrode at the scratched portion and in some cases break. If this occurs, the water pump could stop, leading to the illumination of various warning lights in the instrument panel. There is also the potential that a short circuit can occur between adjacent coil wires, resulting in an open fuse for the electric power supply circuit. If the fuse is open, the hybrid system will stop while the vehicle is being driven, which may increase the risk of a crash. Q2: What is the Hybrid Electric Water Pump? A2: The Hybrid Electric Water Pump (HV Water Pump) is an electrically driven coolant pump that circulates coolant through the Hybrid System components to provide cooling. The HV Water Pump serves a different purpose than the engine water pump. Q3: Are there any warning that this condition exists? A3: There are no warnings prior to the condition occurring. However, if this condition has occurred on the vehicle, a Malfunction Indicator Light, Master Warning Light and/or Hybrid System Warning Light may be illuminated*. In limited cases, if the pump failure causes the power fuse to become open, the Malfunction Indicator Light will not illuminate. *Diagnostic code P0A93, with information code 346 will be recorded in the Hybrid Electronic Control Module (HV ECM). This code indicates the inverter coolant temperature became higher than the vehicle s HV ECM s expected value. Q3a: A3a: What if a customer has the Malfunction Indicator Light illuminated? If the customer experiences a check engine light ON condition, the vehicle will continue to operate. However, the customer should contact an authorized Toyota dealer for diagnosis and, if applicable, repair. If the customer is not able to immediately service the vehicle, he or she should confirm that there is sufficient coolant for the Hybrid System before operating the vehicle. The vehicle should be serviced as soon as possible. Q4: What is Toyota going to do? A4: Toyota mailed an interim owner notification in Mid-December 2012. The interim owner notification letter advised owners: (1) of this safety recall, (2) of the fact they will receive a future notice once the remedy is available. Owners of vehicles that are covered by this campaign will receive the second notification via first class mail starting in January, 2013. Any authorized Toyota dealer will replace the HV Water Pump assembly with an improved one at NO CHARGE to the vehicle owner. Q5: Which and how many vehicles are covered by this Safety Recall? A5: There are approximately 350,000 Prius (2004 through certain 2009 Model Year) vehicles covered by this Safety Recall. Model Name Model Year Production Period Number of Vehicles Early August, 2003 Approximately Toyota Prius 2004 through certain 2009 Through 350,000 units Late March, 2009 Q6: Are there any other Toyota, Lexus or Scion vehicles covered by this Safety Recall? A6: This condition only affects 2004 through certain 2009 model year Prius vehicles. However, Toyota will also be repairing a number of Fuel Cell Hybrid Vehicles that have been placed in operation in test fleets.
Q6a: A6a: Why aren t other HV models included in this campaign? Other models have a HV water pump manufactured using a different process. Q7: How long will the repair take? A7: The repair will take approximately 2.0 hours. However, depending upon the dealer s work schedule, it may be necessary for the owner to make the vehicle available for a longer period of time. Q8: What is the difference between this Safety Recall and Limited Service Campaign (LSC) A0N which was previously announced? A8: LSC A0N was to address concerns over potential errors during the inspection and maintenance of the vehicle's hybrid coolant system where air was introduced. That air may remain at the bearing of the HV Water Pump, causing actuation to be slow, resulting in higher coolant temperature and illumination of the Malfunction Indicator Light. This Safety Recall is to address a manufacturing concern with the vehicle's Hybrid Electric Water Pump assembly which could cause a short circuit, resulting in hybrid system stoppage. Q8a: A8a: If the customer had the remedy for LSC A0N performed, will he/she need to have the Hybrid Electric Water Pump replaced again? No. If the vehicle has had the remedy for LSC A0N performed, it will not require water pump replacement again, because the replacement water pumps used in the LSC do not have possible coil wire scratching. Q9: What if an owner has previously paid for repairs for this condition? A9: Owner reimbursement instructions will be provided in the remedy owner letter. Q10: What if an owner has additional questions or concerns? A10: Owners with questions or concerns are asked to please contact the Toyota Customer Experience Center at 1-888-270-9371 Monday through Friday, 5:00 am to 6:00 pm, or Saturday 7:00 am through 4:00 pm Pacific Time.
2004 to certain 2009 Model Year Prius Vehicles C0U - Hybrid Electric Water Pump SAFETY RECALL NOTICE (Remedy Available) [VIN] Dear Toyota Customer: This notice is being sent to you in accordance with the requirements of the National Traffic and Motor Vehicle Safety Act. Toyota has decided that a defect, which relates to motor vehicle safety, exists in some 2004 to certain 2009 Model Year Prius vehicles. What is the condition? There is a possibility that the coil wire of the electric motor installed in the Water Pump for the Hybrid System may have been scratched during the coiling manufacturing process at the supplier. In this condition, the coil wire may corrode at the scratched portion and in some cases break. If this occurs, the water pump could stop, leading to the illumination of various warning lights in the instrument panel. There is also the potential that a short circuit can occur between adjacent coil wires, resulting in an open fuse for the electric power supply circuit. If the fuse is open, the hybrid system will stop while the vehicle is being driven, which may increase the risk of a crash. What will Toyota do? The remedy for your vehicle is available. Any authorized Toyota dealer will replace the Hybrid Electric Water Pump at NO CHARGE to you. What should you do? This is an important Safety Recall Please contact any authorized Toyota dealer and make an appointment to have the remedy performed as soon as possible. The replacement of the Hybrid Electric Water Pump will take approximately 1 hour. However, depending upon the dealer s work schedule, it may be necessary to make your vehicle available for a longer period of time. You do not need an owner letter to have this recall completed; however, to assist the dealer in confirming vehicle eligibility, we request that you present this notice at the time of your service appointment. If you would like to update your vehicle ownership or contact information, you may do so by registering at www.toyota.com/ownersupdate. You will need your full 17-digit Vehicle Identification Number (VIN) to input the new information. What if you have other questions? URGENT SAFETY RECALL This is an important Safety Recall. The remedy will be performed at NO CHARGE to you. SAMPLE Your local Toyota dealer will be more than happy to answer any of your questions and set up an appointment to perform the repair. You can find additional information and locate a Toyota dealer in your area by going online and visiting www.toyota.com/recall. Additional information is also available by contacting the Toyota Customer Experience Center at 1-888-270-9371 Monday through Friday, 5:00 am to 6:00 pm, or Saturday 7:00 am through 4:00 pm Pacific Time. If you believe that the dealer or Toyota has failed or is unable to remedy the defect within a reasonable time, you may submit a complaint to the Administrator, National Highway Traffic Safety Administration, 1200 New Jersey Avenue S.E., Washington, D.C. 20590, or call the toll free Vehicle Safety Hot Line at 1-888-327-4236 (TTY: 1-800-424-9153), or go to http://www.safercar.gov.
What if you have previously paid for repairs to your vehicle for this specific condition? If you have previously paid for repair to your vehicle for this specific condition prior to receiving this letter, please mail a copy of your repair order, proof-of-payment and proof-of-ownership to the following address for reimbursement consideration: Toyota Motor Sales, U.S.A., Inc Toyota Customer Experience, WC 10 19001 South Western Avenue Torrance, CA 90509 If you are a vehicle lessor, Federal law requires that any vehicle lessor receiving this recall notice must forward a copy of this notice to the lessee within ten days. We have sent this notice in the interest of your continued satisfaction with our products, and we sincerely regret any inconvenience this condition may have caused you. Thank you for driving a Toyota. Sincerely, TOYOTA MOTOR SALES, U.S.A., INC. SAMPLE