0365300B004 DESCRIPTION SINGLE PACKAGE COOLING UNITS DAPH08 THRU 060 / THRU 5 NOMINAL TONS AND 3 SEER These packaged cooling air conditioners are designed for outdoor installation. Only utility and duct connections are required at the point of installation. FEATURES / BENEFITS OPERATING EFFICIENCY All units provide high operating efficiencies and have a SEER up to 3. All efficiencies well exceed legislated minimum levels. ON SITE FLEXIBILITY All model sizes share a common, compact design cabinet with a single footprint. The installer has the flexibility of setting one curb and placing the proper tonnage unit on that curb after the internal load has been determined. Field convertible duct connections from side shot to down shot allows the installer to have greater flexibility and needs to carry less inventory. LOWER INSTALLATION COST Installation time and costs are reduced by easy power and control wiring connections. The small base dimension means less space is required on the ground or roof, plus, the installer can fit this unit between the wheel wells of full size pickup truck. All models are well under 500 pounds. All units are completely wired, charged with R and tested prior to shipment. Unique test stations using a new state of the art computerized process system are used to insure product quality. Refrigerant charge, and component part numbers are verified via computers at installation. Vital run test statistics such as system pressure, motor currents, air velocity and temperature, unit vibration are monitored and recorded by the system to insure unit performance. Equal size, side supply and return duct connections allows easy hookup of ducts to match low crawl spaces without transition pieces. UTILITY CONNECTIONS MADE EASY Electrical utility knockouts are provided through the bottom as well as the side of the unit. Utility connections can be made quickly and with a minimum amount of field labor. A field supplied and field installed electrical disconnect switch must be installed. CONVERTIBLE AIRFLOW DESIGN The bottom duct openings are covered when they leave the factory ready to be used for a side supply / side return application. If a bottom supply / bottom return application is desired, you simply remove the two panels from the bottom of the unit and place them in the side supply / side return duct openings. No panel cutting is required and no accessory panel is necessary. Convertible airflow design allows maximum field flexibility and minimum inventory. CONDENSATE PAN A noncorrosive, longlasting, watertight pan is positioned below the evaporator coil to collect and drain all condensate. Less collection of stagnate condensate will buildup. The condensate pan conforms to ASHRAE 689 standards (Ventilation for Acceptable Indoor Air Quality). FOR DISTRIBUTION USE ONLY NOT TO BE USED AT POINT OF RETAIL SALE
STANDARD FEATURES and BENEFITS continued CONDENSATE DRAIN The heavy duty,! inch NPTI copper connection is more tolerable during installation and is more durable over time. The connection is rigidly mounted to assure proper fit and leak tight seal. DURABLE FINISH With a heavy duty cabinet made of powderpainted, galvanized steel the neutral color blends into surrounding areas. The powered paint, provides a better paint to steel bond, which resists corrosion and rust creep. The special primer formulas and glossy earth tone finish insure less fading when exposed to sunlight and offers a more attractive on site appearance. This paint finish exceeds ASTMB7 standards for 000 hours salt spray rating, the highest in the industry. FULL PERIMETER BASE RAILS The easily removable base rails provide a solid foundation for the entire unit and protects the unit during shipment. The rails provide fork lift access from all sides, and rigging holes are also provided so that an overhead crane can be used to place the units on a roof. On applications when the unit is placed on a pad, the base will keep the unit off the pad to deter corrosion. On applications where height is limited, the! & inch high base rails may be removed on location. MORE ATTRACTIVE APPEARANCE A single piece Water Shed top cover containing a top discharge condenser fan arrangement requires less square footage on installation and provides a wider variety of installations. The one piece design adds greater water integrity. Rounded corners with water drip edges add to the attractive appearance. The cabinet panels have a nonfibrous insulation that does not add insulation fibers into conditioned area. TOP DISCHARGE The top discharge condenser fan does not disrupt neighboring areas and does not dryout vegetation surrounding the unit. The warm air from the top mounted fan is blown up away from the structure and any landscaping. This allows compact location on multiunit applications. CONDENSER COIL GRILLE A multipiece totally enclosed, rigidly mounted condenser coil grille provides protection from objects and personal after installation and provides protection during transit and installation. Description... Features and Benefits... & Product Nomenclature...3 Fieldinstalled Accessories...3 Physical Data...4 Ratings...4 Cooling Capacities DPH08...5 Cooling Capacities DPH04...6 Cooling Capacities DPH030...7 Cooling Capacities DPH036...8 Cooling Capacities DPH04...9 Cooling Capacities DPH048...0 Cooling Capacities DPH060...0 Side and Bottom Supply Air Blower Performance... Additional Static pressure Resistance... Field Wiring Diagram... TABLE OF CONTENTS 0365300B004 LOW OPERATING SOUND LEVEL The upward air flow carries the normal operating noise up and away from the living area. The rigid top panel effectively isolates any motor sound. Isolator mounted compressor and the rippled fins of the condenser coil muffle the normal fan motor and compressor operating sounds. The unique formed base pan also aids in sound alterations with it's SuperStructure design. This design strategically places embossments in the pan for optimum strength and rigidity. FAN SYSTEM All models operate over a wide range of design conditions with either a 3speed directdrive or electronically controlled (ECM) fan motor. These units easily match all types of applications and provides greater on site flexibility to match comfort requirement. SIMPLE CONTROL CIRCUIT A low voltage printed circuit board contains a low voltage terminal strip. The electrical control box is not located in the compressor compartment. All wiring internal to the unit is color/number coded. PROTECTED COMPRESSOR The compressor is internally protected against high pressure and temperature. This is accomplished by the simultaneous operation of high pressure relief valve and a temperature sensor which protect the compressor if undesirable operating conditions occur. EXCLUSIVE COIL DESIGN Grooved copper tubes and enhanced aluminum fin construction improves heat transfer for maximum efficiency and durability. LOW MAINTENANCE Long life, permanently lubricated condenser and evaporator fan motor bearings need no annual maintenance adding greater reliability to the unit. Blower assembly can be easily removed for cleaning by the unique Slip Track slideout blower assembly. SECURED SERVICE ACCESS PORTS Protected, externally mounted, reusable service access ports are provided on both the high and low lines for ease of evacuating and charging the system. No final field mounting required. EASY SERVICE ACCESS Alarge, single panel covers the electrical controls and makes servicing easy. The blower compartment has an additional large panel with a builtin handle tab. Removing this panel will allow the blower assembly to slideout for easy removal for maintenance and ease of trouble shooting. REPLACEMENT PARTS The installer has no need to carry an inventory of unique parts or needs special training to replace any of the components parts for these units. All are easily obtained from Source or other part houses. Electrical Data (basic unit)...3 Electrical Data (cooling / electric heat)...4 & 5 Unit Dimensions...6 Unit Weights and Center of Gravity...7 Clearances...7 Typical Applications...8 Roof Curb Dimensions...9 Roof Curb Application...9 Typical Wiring Diagram (08/3060) DPH08 04...0 Typical Wiring Diagram (08/3060) DPH048 & 060... Typical Wiring Diagram (08/30360) DPH08 04... Typical Wiring Diagram Notes... Typical Wiring Diagram Legend... Typical Wiring Diagram (08/30360) DPH048 & 060...3 Typical Wiring Diagram (460/575360) DPH08 04...4 Typical Wiring Diagram (460/575360) DPH048 & 060...5 Unitary Products Group
0365300B004 PRODUCT NOMENCLATURE PRODUCT CATEGORY D = Single Package Air Conditioner (Air Cooled) PRODUCT GENERATION P = NEW or Current Design PRODUCT IDENTIFIER PH = SEER Cooling Models D A PH F VOLTAGE CODE F = 08/3060 T = 08/30360 W = 460360 X = 575360 0 4 A FACTORY INSTALLED ELECTRIC HEAT A = No Electric Heat Installed NOMINAL COOLING CAPACITY () 08 = 8,000 BTUH 04 = 4,000 BTUH 04 = 4,000 BTUH 048 = 48,000 BTUH 030 = 30,000 BTUH 060 = 60,000 BTUH 036 = 36,000 BTUH FIELDINSTALLED ACCESSORIES ECONOMIZER DOWN DISCHARGE / SUPPLY KIT Modulating integrated economizer provides simultaneous operation between the mechanical cooling and economizer operation. Independent blade design insures proper control and less than % leak rate. Includes hood and mesh bird screen filter integrated into the hood, dry bulb sensor and relief damper. Separate field accessories of single enthalpy and dual enthalpy are also available. SINGLE ENTHALPY SENSOR Sensor replaces dry bulb sensor standard in economizer kit. Provides improved economizer operation by sensing the dry bulb temperature from outdoors plus the enthalpy content of the outdoor air. DUAL ENTHALPY SENSOR Additional sensor to single enthalpy sensor. Sensor senses both the return air temperature dry bulb and humidity in conjunction with the single enthalpy to determine the most economical mix. Single Enthalpy sensor also required. UPGRADE SAFETY PACKAGE Contains screw in type High pressure, Low Pressure/Loss of Charge switch, freeze protection switch and lockout relay. Switches are placed onto existing scharder ports located in the unit by furnished adapters. When abnormal conditions are sensed through the pressure switches, the unit will lock out preventing any further operation until reset or problem is corrected. Package agency approved. HAIL GUARD KIT Kit contains protected grilles made of expanded aluminum grilles with full perimeter inch frame. Sloped hoods are also included to assure maximum protection. ANTI SHORT CYCLE TIMER Automatically prevents the compressor from restarting for 5 minutes after cycled off. Not required if Thermostat ET077004 and ET047004 are used. FILTER / FRAME KIT (Single Phase only) Kit contains the necessary hardware to field install return air filters into the base unit. Precut filter racks and appropriate cleanable standard size filters are shipped in one kit. ( filter is supplied) This kit is available for single phase horizontal or vertical duct application only. Standard in all 3 Phase models. MOTORIZED FRESH AIR DAMPER Designed for duct mounted side supply/return and unit mounted down supply/return applications. Damper capable of providing 0% thru 50% of outdoor air (field supplied). Closes on power loss, includes hood and screen assembly. RECTANGLE TO ROUND ADAPTERS Kit includes one supply and one return air rectangle to round duct adapter. Adapters are preformed and designed to fit over current duct openings on the base unit. Transition is from5 square to 4 round. ROOF CURBS NRCA approved curbs provide proper fit to base unit for rooftop installations. Curbs are designed to be assembled through hinge pins in each corner. Kit also provides seal strip to assure a water tight seal. 8 and 4 inch high roof curbs are available. MANUAL OUTDOOR DAMPER Provides 0% thru 50% outdoor air capability (field adjustable). Designed for duct mounted side supply/return applications. Includes hood and screen assembly. WALL THERMOSTAT The units are designed to operate with 4volt electronic and electromechanical thermostats. All units can operate with single stage heat / single stage cool thermostats with or without the economizer. LOW AMBIENT KIT Kit provides necessary hardware to convert unit to operate in cooling cycle down to 0 F. Standard unit operation 45 F. TRANSFORMER KIT Kit provides necessary hardware to provide single phase models from factory furnished 40 VA transformer capability to 75 VA transformer capability. ELECTRIC HEATERS Each heater package provides easy installation of electric heat strips. Slide in design with plug in harness and agency approved. Heaters are available from 5.0 KW sizes and are designed for single point connection. Unitary Products Group 3
0365300B004 DIRECT DRIVE CONDENSER FAN MOTOR BACK AND BOTTOM RETURN AIR AND SUPPLY AIR DUCT OPENING HIGHLY EFFICIENT ENHANCED COPPER TUBE/ALUMINUM FIN EVAPORATOR COIL HIGHLY EFFICIENT ENHANCED COPPER TUBE/ALUMINUM FIN CONDENSER COIL HIGH VOLTAGE TERMINAL BLOCK DECORATIVE PROTECTIVE COIL GUARD LOW VOLTAGE TERMINAL BLOCK LONG LASTING POWDER PAINT FINISH EARTH TONE COLOR PHYSICAL DATA EVAPORATOR BLOWER EVAPORATOR COIL CONDENSER FAN HIGH EFFICIENCY COMPRESSOR RIGIDLY MOUNTED 3SPEED DIRECT DRIVE BLOWER MOTOR WITH SLIDEOUT BLOWER ASSEMBLY HEAVY GAUGE REMOVABLE BASE RAILS MODELS DPH 08 04 030 036 04 048 060 CENTRIFUGAL BLOWER (Dia. x Wd. in.) 9 X 6 0 X 8 0 X 8 0 x 8 X 0 X 0 X 0 FAN MOTOR HP (Three Speed)!!! ROWS DEEP 3 3 3 3 FINS PER INCH 3 5 5 3 5 6 6 FACE AREA (Sq. Ft.) 4.38 4.38 4.38 4.38 4.38 5.63 5.63 PROPELLER DIA. (in.) FAN MOTOR HP NOM. TOTAL,800.800,800,800,400 3,000 3,000 ROWS DEEP CONDENSER COIL FINS PER INCH 0 0 0 0 0 0 0 FACE AREA (Sq. Ft.).9.9.9.9.9 6.4 6.4 CHARGE REFRIGERANT (lbs./oz.) 5 / 5 5 / 3 4 / 7 4 / 5 / 0 6 / 0 7 / FILTER FACE AREA (Sq. Ft. / Qty. / Size) 4.8 / / 4 x COMPRESSOR HERMETIC, Qty. =, (Type) Reciprocating Reciprocating Scroll Scroll Scroll Scroll Scroll = Electrically controlled motor used on 048 and 060 size units with 30 and 460 volt power supply. RATINGS ARI MODEL DPH COOLING CAPACITY 80 / 6795 F SOUND RATING (decibels) AVAILABLE ELECTRIC HEAT NOMINAL CAPACITY KW SEER SINGLE PHASE THREE PHASE 08 8.0.00 80 5.0, 7.5 N / A 04 4.0.00 80 5.0. 7.5. 0.0 N / A 030 9.8.00 77 5.0, 7.5, 0.0, 5.0 0.0, 5.0 036 36.0.00 75 5.0, 7.5, 0.0, 5.0 0.0, 5.0 04 4.0.00 79 5.0, 7.5, 0.0, 5.0 0.0, 5.0 048 (30 & 460 volt only) 46.5 3.00 8 0.0, 5.0, 0.0, 5.0 0.0, 5.0, 0.0, 5.0 060 (30 & 460 volt only) 55.5 3.00 8 0.0, 5.0, 0.0, 5.0 0.0, 5.0, 0.0, 5.0 048 (575 volt only) 46.5.00 8 N / A 0.0, 5.0, 0.0, 5.0 060 (575 volt only) 55.5.00 8 N / A 0.0, 5.0, 0.0, 5.0 SEER = Seasonal Energy Efficiency Ratio the total cooling output in BTU's during a normal annual usage period for cooling divided by the total electric power input in watthours during the same period. Certified in accordance with the Unitary Small Equipment certification program, which is based on ARI Standard 0/40. Rated in accordance with ARI Standard 70 4 Unitary Products Group
0365300B004 COOLING CAPACITIES / TON (DPH08) Temperature of Air on Outdoor Coil 85 F 95 F 05 F 5 F 5 F = These capacities are net capacities indoor fan heat deducted. ALL SENSIBLE CAPACITY Air On Indoor Coil 450 55 600 675 750 WB F WB F WB F WB F WB F 7 67 6 57 7 67 6 57 7 67 6 57 7 67 6 57 7 67 6 57 8.5 7.7 6.3 6.7 8.6 7.8 6.5 6.8 8.8 7.9 6.6 6.9 9.4 8.6 7. 7.5 0. 9. 7.8 8..47.46.45.44.5.5.49.48.56.55.54.5.59.58.57.56.6.6.60.59 86 0. 3. 5.9 6.7 0.8 4.0 6.3 6.8.5 4.8 6.6 6.9.3 5.7 7. 7.5 3. 6.7 7.8 8. 83 8.8.8 4.7 6.0 9.3.4 5.4 6.4 9.8 3.0 6.0 6.9 0.3 3.7 6.9 7.5 0.9 4.4 7.7 8. 80 7.5 0.6 3.4 4.7 7.8 0.9 3.8 5. 8.0.3 4.3 5.7 8.3.7 4.9 6.3 8.7. 5.5 7.0 77 6. 9.3. 3.4 6. 9.4.3 3.7 6.3 9.5.5 4.0 6.3 9.8.9 4.4 6.4 0.0 3. 4.8 74 4.9 8.0 0.8. 4.7 7.9 0.8. 4.5 7.8 0.8. 4.4 7.8 0.9.4 4. 7.7.0.5 7 6.7 9.5 0.9 6.4 9.3 0.7 6.0 9.0 0.5 5.8 8.9 0.4 5.5 8.8 0.3 68 5.4 8. 9.6 4.9 7.8 9. 4.3 7.3 8.7 3.8 6.9 8.4 3.3 6.5 8. 6.6 6.4 4.0 4.4 7.4 7. 4.7 5. 8. 8.0 5.3 5.8 8.4 8. 5.5 6.0 8.5 8.3 5.6 6..57.57.53.53.6.6.58.58.66.67.6.6.68.69.65.64.70.7.67.67 86 9..6 4.0 4.4 0. 4. 4.7 5..3 5.5 5.3 5.8.9 6. 5.5 6.0.5 6.8 5.6 6. 83 7.9.4 3. 3.6 8.7.6 4.3 4.7 9.6 3.8 5.3 5.8 9.9 4. 5.5 6.0 0.3 4.6 5.6 6. 80 6.6 0..9.3 7..0 3. 3.5 7.8.0 4.3 4.7 7.9. 4.4 4.9 8..3 4.6 5. 77 5.3 8.8 0.7. 5.7 9.5.6.0 6. 0.3.5 3.0 6.0 0..5.9 5.8 0..4.9 74 4.0 7.5 9.4 9.8 4. 8.0 0. 0.5 4.3 8.5 0.8. 4.0 8. 0.5 0.9 3.6 7.9 0. 0.7 7 6. 8. 8.5 6.5 8.6 9.0 6.8 9.0 9.5 6. 8.5 9.0 5.6 7.9 8.4 68 4.9 6.8 7. 5.0 7.0 7.5 5.0 7.3 7.7 4. 6.5 7.0 3.4 5.7 6. 5.6 4.9 3.0 3.5 6.3 5.6 3.6 4. 7.0 6. 4. 4.7 7.3 6.5 4.5 4.9 7.6 6.8 4.7 5..66.66.63.6.7.7.68.67.76.77.73.7.78.79.75.74.80.8.77.76 86 8.7.0 3.0 3.5 9.8 3.4 3.6 4. 0.9 4.9 4. 4.7.6 5.5 4.5 4.9.3 6. 4.7 5. 83 7.4 0.7.4.6 8.3.9 3.3 3.6 9. 3. 4. 4.7 9.6 3.7 4.5 4.9 0. 4. 4.7 5. 80 6. 9.4..3 6.8 0.4..5 7.4.4 3.4 3.6 7.6.7 3.7 4.0 7.8.0 4. 4.4 77 4.9 8. 9.8 0.0 5.3 8.9 0.7 0.9 5.7 9.7.6.9 5.6 9.7.8.0 5.6 9.8.9. 74 3.6 6.9 8.5 8.7 3.8 7.4 9. 9.4 3.9 7.9 9.9 0. 3.7 7.7 9.8 0.0 3.4 7.5 9.6 9.9 7 5.6 7. 7.4 5.9 7.7 7.9 6. 8. 8.4 5.7 7.8 8.0 5.3 7.4 7.6 68 4.3 5.9 6. 4.3 6. 6.4 4.4 6.4 6.6 3.7 5.8 6.0 3. 5. 5.4 4.6 3.4..5 5. 3.9.6 3.0 5.8 4.5 3. 3.5 6. 4.9 3.5 3.9 6.7 5.3 3.8 4.3.75.75.7.70.80.8.78.76.86.87.84.8.88.89.86.83.90.9.88.85 86 8.3.3..5 9.4.8.6 3.0 0.5 4.3 3. 3.5.3 4.8 3.5 3.9. 5.3 3.8 4.3 83 7.0 0..5.5 7.9.3.3.5 8.8.5 3. 3.5 9.3 3. 3.5 3.9 9.8 3.9 3.8 4.3 80 5.7 8.8 0. 0. 6.4 9.8.4.4 7.0 0.8.5.6 7.3. 3. 3. 7.6.7 3.6 3.6 77 4.4 7.5 8.9 8.9 4.9 8.3 9.9 9.9 5.3 9.0 0.8 0.8 5.3 9... 5.4 9.4.3.3 74 3. 6. 7.6 7.7 3.3 6.8 8.3 8.4 3.5 7.3 9.0 9. 3.3 7. 9. 9. 3. 7. 9. 9. 7 4.9 6.4 6.4 5. 6.8 6.8 5.5 7.3 7.3 5.3 7. 7. 5.0 6.9 6.9 68 3.6 5. 5. 3.7 5.3 5.3 3.8 5.5 5.6 3.3 5. 5..7 4.6 4.6 3.6.9..5 4..3.5.0 4.6.7.9.4 5. 3.3.4.9 5.8 3.8 3.0 3.4.8.8.8.8.9.9.9.8.0.0.9.9.0.0.0.9.0.0.0.9 86 7.9 0.7..5 9.0..5.0 0. 3.7.9.4.0 4..4.9.9 4.6 3.0 3.4 83 6.6 9.4 0.6 0.4 7.5 0.7.3.4 8.4.9.9.4 9.0.7.4.9 9.6 3.6 3.0 3.4 80 5.3 8. 9.3 9. 6.0 9. 0.5 0.3 6.6 0..7.5 7.0 0.8.4. 7.4.3 3.0.8 77 4.0 6.9 8. 7.9 4.5 7.6 9.0 8.8 4.9 8.4 9.9 9.7 5.0 8.8 0.4 0. 5. 9. 0.8 0.6 74.7 5.6 6.8 6.6.9 6. 7.5 7.3 3. 6.7 8. 8.0 3.0 6.8 8.4 8..9 6.9 8.6 8.3 7 4.3 5.5 5.3 4.6 6.0 5.8 4.9 6.4 6. 4.8 6.4 6. 4.6 6.3 6. 68 3.0 4. 4.0 3. 4.4 4. 3. 4.7 4.5.8 4.4 4..4 4. 3.9 Unitary Products Group 5
COOLING CAPACITIES TON (DPH04) Temperature of Air on Outdoor Coil 85 F 95 F 05 F 5 F 5 F = These capacities are net capacities indoor fan heat deducted. ALL SENSIBLE CAPACITY 0365300B004 Air On Indoor Coil 600 700 800 900 000 WB F WB F WB F WB F WB F 7 67 6 57 7 67 6 57 7 67 6 57 7 67 6 57 7 67 6 57 6. 4.0..5 7. 4.9.9.3 8. 5.8 3.7 3. 8. 5.9 3.8 3.3 8.4 6.0 4.0 3.4.00.0.97.93.05.06.0.98.0..07.03...7.4.3.33.8.4 86 4.8 8.5..5 6. 0..9.3 7.5.7 3.7 3. 8.6.9 3.8 3.3 9.7 4. 4.0 3.4 83 3. 6.8 0.7.3 4. 8... 5. 9.4 3.7 3. 6.0 0.3 3.8 3.3 6.7. 4.0 3.4 80.4 5. 9.0 9.6. 6. 0. 0.8.8 7.0.5. 3.3 7.6..8 3.7 8. 3.0 3.4 77 9.7 3.4 7.3 7.9 0. 4.0 8. 8.8 0.5 4.7 9. 9.8 0.6 5.0 9.5 0. 0.8 5. 0.0 0.4 74 8.0.7 5.6 6. 8..0 6. 6.8 8..4 6.8 7.4 8.0.3 6.9 7.4 7.8.3 7.0 7.4 7 0.0 3.9 4.5 0.0 4. 4.8 0.0 4.5 5. 9.7 4. 4.8 9.3 4.0 4.5 68 8...7 8.0..8 7.7..8 7.0.6. 6.3.0.5 4.8. 0.5.0 5.7 3...8 6.7 3.9.0.6 6.8 4.0..7 6.9 4...9.3..09.05.8.6.4.0.3..8.4.35.33.30.6.47.45.4.38 86 4. 7.6 0.5.0 5.7 9.3..8 7...0.6 8.3.4..7 9.4 3.7..9 83.5 5.9 9.5 9.4 3.7 7.3 0.7.0 4.8 8.7.0.6 5.6 9.7..7 6.5 0.7..9 80 0.8 4. 7.8 7.7.6 5.3 9. 9..5 6.4 0.5 0.5 3.0 7..3.3 3.5 7.7.. 77 9..5 6.0 6.0 9.6 3.3 7. 7. 0. 4. 8. 8. 0.3 4.4 8.7 8.6 0.5 4.7 9. 9. 74 7.4 0.8 4.3 4.3 7.6.3 5. 5.0 7.8.7 5.8 5.8 7.7.7 6.0 5.9 7.5.7 6. 6. 7 9..6.6 9. 3. 3.0 9.4 3.5 3.5 9. 3.4 3.3 8.8 3. 3. 68 7.4 0.9 0.9 7..0.0 7... 6.4 0.7 0.6 5.8 0. 0..4 9.8 8.6 8.6 3.4 0.7 9.5 9.4 4.4.6 0.3 0.3 4.5.7 0.4 0.3 4.6.8 0.5 0.4.4..8.5.9.7.3.0.34.3.8.5.46.43.40.37.58.55.5.48 86 3.4 6.7 8.6 8.6 4.9 8.4 9.5 9.4 6.3 0. 0.3 0.3 7.5 0.8 0.4 0.3 8.6.5 0.5 0.4 83.7 5.0 7.7 7.6.8 6.5 9.0 8.9 4.0 8.0 0.3 0.3 4.8 8.9 0.4 0.3 5.6 9.9 0.5 0.4 80 9.9 3.3 6.0 5.9 0.8 4.5 7.4 7.3.7 5.7 8.8 8.7. 6.3 9.5 9.4.6 6.9 0.3 0. 77 8..6 4.3 4. 8.8.5 5.4 5.3 9.3 3.3 6.5 6.4 9.5 3.6 6.9 6.7 9.6 3.9 7.3 7. 74 6.5 9.9.6.5 6.8 0.5 3.3 3.3 7.0.0 4. 4.0 6.8.0 4. 4. 6.7.0 4.3 4. 7 8. 0.9 0.8 8.4.3. 8.7.8.7 8.3.6.4 8.0.4. 68 6.5 9. 9. 6.4 9.3 9. 6.3 9.5 9.4 5.7 8.9 8.7 5.0 8.4 8. 0.0 7.4 6.8 6..0 8.3 7.7 7.0. 9. 8.6 7.9. 9.3 8.7 8.0.3 9.4 8.8 8.0.35.3.7.6.40.37.33.3.46.43.38.36.57.54.49.47.69.66.6.59 86.5 5.9 6.8 6. 4.0 7.5 7.7 7.0 5.5 9. 8.6 7.9 6.6 9.3 8.7 8.0 7.7 9.4 8.8 8.0 83 0.8 4. 5.9 5.8.0 5.7 7.3 6.8 3. 7. 8.6 7.9 4.0 8. 8.7 8.0 4.7 9. 8.8 8.0 80 9..4 4. 4. 0.0 3.7 5.6 5.5 0.9 4.9 7. 6.9.3 5.5 7.7 7.5.8 6. 8.4 8.0 77 7.4 0.7.5.4 8.0.7 3.6 3.5 8.5.6 4.7 4.6 8.7.9 5. 4.8 8.8 3. 5.5 5. 74 5.7 9.0 0.8 0.7 5.9 9.6.6.5 6. 0..4.3 6.0 0..4. 5.8 0..5. 7 7.3 9. 9.0 7.6 9.6 9.5 7.9 0. 9.9 7.6 9.8 9.5 7. 9.5 9. 68 5.6 7.4 7.3 5.6 7.6 7.4 5.6 7.7 7.6 4.9 7. 6.8 4. 6.5 6. 7.6 4.9 5.0 3.7 8.7 5.9 5.9 4.6 9.8 6.9 6.9 5.5 9.9 7.0 7.0 5.6 0.0 7.0 7. 5.6.5.4.4.4.5.5.4.4.6.5.5.5.7.6.6.6.8.8.7.7 86.6 5.0 5.0 3.7 3. 6.6 5.9 4.6 4.7 8.3 6.9 5.5 5.8 7.8 7.0 5.6 6.9 7.3 7. 5.6 83 9.9 3.3 4. 4.0. 4.9 5.5 4.8.4 6.5 6.9 5.5 3. 7.4 7.0 5.6 3.9 8.3 7. 5.6 80 8..6.5.3 9..9 3.9 3.7 0. 4. 5.3 5. 0.5 4.8 6.0 5.6 0.9 5.3 6.6 6.0 77 6.5 9.9 0.8 0.6 7. 0.8.9.7 7.7.8 3.0.8 7.8. 3.3.9 7.9.4 3.6 3.0 74 4.8 8. 9. 8.9 5. 8.8 9.9 9.7 5.4 9.5 0.7 0.5 5. 9.4 0.6 0.3 4.9 9.4 0.6 0. 7 6.4 7.3 7. 6.8 7.8 7.7 7. 8.3 8. 6.8 8.0 7.6 6.4 7.7 7. 68 4.7 5.6 5.5 4.8 5.8 5.7 4.8 6.0 5.8 4. 5.3 5.0 3.4 4.7 4. 6 Unitary Products Group
0365300B004 COOLING CAPACITIES / TON (DPH030) Temperature of Air on Outdoor Coil 85 F 95 F 05 F 5 F 5 F = These capacities are net capacities indoor fan heat deducted. ALL SENSIBLE CAPACITY Air On Indoor Coil 750 875 000 5 50 WB F WB F WB F WB F WB F 7 67 6 57 7 67 6 57 7 67 6 57 7 67 6 57 7 67 6 57 3.3 9.8 7.5 8. 3.6 30. 7.8 8.4 33.0 30.4 8. 8.7 33.5 30.9 8.4 9. 33.9 3.3 8.8 9.5.6.60.53.5.70.68.60.58.77.75.67.64.86.84.75.73.96.93.84.8 86 8. 3.6 7.5 8. 0. 5.8 7.8 8.4.9 8.0 8. 8.7 3.3 9.6 8.4 9. 4.8 3.3 8.8 9.5 83 6..4 5.5 6.3 7.5 3.3 6.8 7.5 9.0 5. 8. 8.7 0.0 6.4 8.4 9.. 7.7 8.8 9.5 80 4.0 9.3 3.3 4. 5.0 0.7 5. 5.9 6.0. 6.8 7.7 6.7 3. 7.8 8.6 7.3 4.0 8.8 9.5 77.8 7...0.5 8..5 3.4 3. 9.3 3.9 4.8 3.4 9.7 4.5 5.3 3.6 0. 5. 5.8 74 9.7 5.0 9. 9.9 0.0 5.7 0.0 0.9 0. 6.3.0.9 0. 6.4..0 9.9 6.5.4. 7.9 6.9 7.7 3. 7.5 8.3 3.4 8.0 9.0 3. 7.9 8.7.8 7.7 8.4 68 0.8 4.8 5.6 0.6 5.0 5.8 0.5 5. 6. 9.8 4.5 5.3 9. 3.9 4.6 9. 7.5 4.4 4.8 30. 8.6 5.3 5.7 3.3 9.7 6. 6.7 30.9 9.3 5.9 6.4 30.5 8.9 5.6 6.0.84.78.7.70.89.83.77.76.95.89.83.8 3.06 3.00.94.9 3.8 3. 3.05 3.03 86 7.5. 4.4 4.8 9.5 4.7 5.3 5.7.6 7. 6. 6.7 3. 8. 5.9 6.4 4.6 8.9 5.6 6.0 83 5.4 0. 4. 3.9 7.0. 5. 5.3 8.7 4.3 6. 6.7 9.8 5.7 5.9 6.4 0.9 7.0 5.6 6.0 80 3. 8.0.0.8 4.5 9.7 4. 3.8 5.8.4 6. 5.9 6.5.4 5.9 6.0 7. 3.3 5.6 6.0 77. 5.8 9.9 9.6.0 7..6.3.8 8.5 3.3 3.0 3. 9.0.6.6 3.4 9.6.8.3 74 9.0 3.7 7.7 7.5 9.4 4.6 9. 8.8 9.9 5.6 0.4 0. 9.8 5.7 9. 9.3 9.7 5.9 8. 8.6 7.6 5.6 5.3. 6.5 6.3.7 7.5 7..4 5.9 6.0. 4.4 4.8 68 9.4 3.5 3. 9.6 4.0 3.7 9.7 4.6 4.3 9..6.7 8.4 0.6. 6.7 4.8..3 7.8 5.8 3. 3. 8.9 6.8 4.0 4. 8.6 6.5 3.7 3.9 8.3 6.3 3.5 3.6 3.0.93.88.87 3.08.99.94.94 3.5 3.05 3.00 3.00 3.7 3.7 3. 3. 3.39 3.9 3.3 3.3 86 6.5.3..3 8.5 3.4 3. 3. 0.5 5.6 4.0 4..0 5.9 3.7 3.9 3.5 6.3 3.5 3.6 83 4.4 9..0.8 6.0. 3.0.9 7.6 3.3 4.0 4. 8.7 4.3 3.7 3.9 9.7 5.3 3.5 3.6 80.3 7.0 9.8 9.6 3.5 8.7.8.6 4.7 0.4 3.8 3.5 5.4.3 3.6 3.6 6.0. 3.5 3.6 77 0. 4.9 7.7 7.5 0.9 6. 9.3 9.0.8 7.5 0.9 0.6.0 8.0 0.3 0.3.3 8.5 9.8 9.9 74 8.0.7 5.6 5.3 8.4 3.7 6.8 6.5 8.9 4.6 7.9 7.7 8.7 4.7 7.0 6.9 8.6 4.8 6.0 6. 7 0.6 3.4 3.. 4. 4.0.7 5.0 4.8.4 3.7 3.6.0.3.5 68 8.5.3. 8.6.7.5 8.7..9 8.0 0.3 0.3 7.3 8.6 8.7 4.3.0 0.0 9.8 5.4.9 0.8 0.7 6.4 3.9.7.5 6. 3.7.6.4 6. 3.6.4.3 3.0 3.08 3.04 3.04 3.7 3.5 3. 3. 3.35 3. 3.8 3.8 3.47 3.34 3.30 3.30 3.60 3.46 3.4 3.4 86 5.6 0.3 0.0 9.8 7.5. 0.8 0.7 9.5 3.9.7.5 0.9 3.7.6.4.3 3.6.4.3 83 3.4 8. 9.8 9.6 5.0 0.3 0.7 0.6 6.5.3.7.5 7.6 3.0.6.4 8.6 3.6.4.3 80.3 6. 7.7 7.5.5 7.7 9.5 9.3 3.6 9.4.3. 4. 0.3.4. 4.9..4.3 77 9. 3.9 5.5 5.3 9.9 5. 7.0 6.8 0.7 6.5 8.4 8. 0.9 6.9 8. 7.9. 7.4 7.7 7.6 74 7.0.8 3.4 3. 7.4.7 4.4 4. 7.8 3.6 5.5 5.3 7.6 3.6 4.7 4.6 7.4 3.7 4.0 3.8 7 9.6.. 0..9.7 0.6.6.4 0.3.4. 0.0 0. 0. 68 7.5 9. 8.9 7.6 9.4 9. 7.7 9.7 9.5 7.0 8. 7.9 6. 6.5 6.4.9 9. 7.8 7.4.9 0. 8.6 8. 3.9.0 9.4 9.0 3.9.0 9.4 8.9 3.9 0.9 9.4 8.9 3.4 3. 3. 3. 3.5 3.3 3.3 3.3 3.5 3.4 3.4 3.4 3.7 3.5 3.5 3.5 3.8 3.6 3.6 3.6 86 4.6 9.4 7.8 7.4 6.5 0.8 8.6 8. 8.4. 9.4 9.0 9.8.6 9.4 8.9. 0.9 9.4 8.9 83.5 7. 7.6 7.5 4.0 9.3 8.5 8. 5.5.3 9.4 9.0 6.5.6 9.4 8.9 7.4.9 9.4 8.9 80 0.3 5. 5.5 5.3.4 6.7 7. 7.0.6 8.4 8.9 8.7 3. 9. 9. 8.8 3.7 0. 9.4 8.9 77 8. 3.0 3.3 3. 8.9 4. 4.7 4.5 9.6 5.5 6.0 5.8 9.8 5.9 5.8 5.5 0.0 6.3 5.6 5. 74 6.0 0.8.. 6.4.7..0 6.7.6 3..9 6.5.6.5. 6..3.6.9.5 7 8.7 9. 8.9 9. 9.6 9.4 9.6 0. 0.0 9.3 9. 8.9 8.9 8. 7.7 68 6.5 6.9 6.8 6.6 7. 6.9 6.7 7. 7.0 5.9 5.8 5.5 5. 4.5 4.0 Unitary Products Group 7
COOLING CAPACITIES 3 TON (DPH036) Temperature of Air on Outdoor Coil 85 F 95 F 05 F 5 F 5 F = These capacities are net capacities indoor fan heat deducted. ALL SENSIBLE CAPACITY 0365300B004 Air On Indoor Coil 900 050 00 350 500 WB F WB F WB F WB F WB F 7 67 6 57 7 67 6 57 7 67 6 57 7 67 6 57 7 67 6 57 36.8 34.3 30. 30. 39. 36.4 3. 3.0 4.4 38.6 34.0 33.8 4.3 39.4 34.7 34.5 43. 40. 35.4 35.3 3.6 3.9 3.3 3.3 3.7 3.0 3.4 3.4 3.9 3. 3.5 3.5 3.35 3.7 3. 3. 3.4 3.33 3.7 3.7 86 9.7 5.4 9.3 30.. 8.5 3.7 3.0 4.6 3.5 34.0 33.8 6.3 33.5 34.7 34.5 8.0 35.5 35.4 35.3 83 7..9 6.7 8.5 9. 5.5 9.7 3.. 8.0 3.7 33.8.4 9.5 34. 34.5 3.6 3.0 35.4 35.3 80 4.6 0.3 4. 6.0 6..4 6.7 8.7 7.6 4.5 9. 3.4 8.4 5.6 30.4 3.7 9. 6.6 3.6 34.0 77.0 7.7.6 3.4 3. 9.4 3.7 5.6 4..0 5.7 7.9 4.4.6 6.4 8.7 4.6. 7. 9.5 74 9.5 5. 9. 0.8 0. 6.4 0.6.6 0.6 7.5. 4.4 0.4 7.6.5 4.7 0. 7.6.7 5.0 7.6 6.5 8.3 3.3 7.6 9.6 4. 8.7 0.9 3.6 8.5 0.7 3. 8. 0.6 68 0.0 3.9 5.7 0.3 4.6 6.5 0.6 5. 7.4 9.6 4.5 6.7 8.7 3.7 6. 34.4 3.3 9.5 8.4 36.4 34. 3. 30. 38.5 36.0 3.9 3.7 39.5 37.0 33.7 3.6 40.4 37.9 34.6 33.4 3.48 3.38 3.35 3.33 3.49 3.39 3.35 3.33 3.49 3.39 3.36 3.34 3.56 3.46 3.4 3.40 3.63 3.53 3.49 3.47 86 8.5 4.3 8.3 8.4.0 7.4 30.6 30. 3.4 30.5 3.9 3.7 4.8 3.0 33.7 3.6 6. 33.4 34.6 33.4 83 6.0.7 5.7 6.6 8.0 4.4 8.8 9. 9.9 7.0 3.9 3.7 0.8 8.0 33.0 3.6.6 9.0 34. 33.4 80 3.4 9. 3. 4.0 4.9.3 5.8 6.7 6.4 3.5 8.4 9.4 6.8 4.0 9.0 30.0 7. 4.5 9.6 30.7 77 0.8 6.6 0.6.4.9 8.3.8 3.7.9 0.0 4.9 5.9.8 0.0 5.0 6..7 0.0 5. 6. 74 8.3 4.0 8.0 8.9 8.9 5.3 9.7 0.6 9.4 6.5.4.4 8.8 6.0.0. 8. 5.5 0.7.7 7.5 5.5 6.3. 6.7 7.6 3.0 7.9 8.9.0 7. 8.. 6. 7.3 68 8.9.9 3.7 9. 3.7 4.6 9.5 4.4 5.4 8. 3. 4. 6.6.7.8 3.3 9. 6.5 5.9 33.3 3.0 8. 7.6 35.3 3.8 30.0 9.3 36. 33.7 30.7 30.0 37. 34.5 3.4 30.7 3.66 3.55 3.56 3.49 3.68 3.57 3.57 3.50 3.70 3.58 3.59 3.5 3.75 3.64 3.64 3.57 3.8 3.69 3.69 3.6 86 7.5 3.3 5.9 5.9 9.9 6.4 7.9 7.6.3 9.4 30.0 9.3 3.6 30.8 30.7 30.0 4.8 3. 3.4 30.7 83 5.0 0.7 4.0 4.3 6.9 3.3 6.7 6.8 8.8 5.9 9.5 9.3 9.6 6.8 30.3 30.0 0.3 7.6 3. 30.7 80.4 8..4.7 3.9 0.3 3.9 4.3 5.3.4 6.5 6.8 5.6.8 6.9 7.3 5.8 3. 7.3 7.7 77 9.8 5.6 8.8 9. 0.8 7.3 0.9..8 8.9 3.0 3.3.6 8.8.9 3.3.4 8.7.8 3. 74 7.3 3.0 6.3 6.6 7.8 4. 7.9 8. 8.3 5.4 9.5 9.8 7.6 4.8 8.9 9.3 6.9 4. 8.4 8.8 7 0.4 3.7 4.0. 4.8 5..9 6.0 6.3 0.8 4.9 5.3 9.7 3.9 4.3 68 7.9..4 8..8. 8.4.5.8 6.9 0.9.3 5.3 9.4 9.8 8. 5.9 3.6 3.4 30. 7.8 5.3 5. 3. 9.7 7.0 6.8 33.0 30.4 7.6 7.4 33.7 3. 8.3 8.0 3.85 3.7 3.76 3.65 3.88 3.74 3.79 3.67 3.90 3.77 3.8 3.70 3.94 3.8 3.86 3.74 3.99 3.85 3.90 3.78 86 6.5. 3.6 3.4 8.9 5.3 5.3 5.. 8.4 7.0 6.8.4 9.6 7.6 7.4 3.5 30.7 8.3 8.0 83 4.0 9.7..0 5.9.3 4.6 4.4 7.7 4.9 7.0 6.8 8.4 5.6 7.6 7.4 9.0 6.3 8.3 8.0 80.4 7. 9.6 9.4.8 9...8 4..4 4.5 4.3 4.4.6 4.8 4.5 4.5.8 5.0 4.7 77 8.8 4.5 7. 6.9 9.8 6. 9.0 8.8 0.7 7.9.0 0.8 0.4 7.6 0.8 0.5 0. 7.3 0.5 0.3 74 6.3.0 4.5 4.3 6.8 3. 6.0 5.8 7. 4.4 7.5 7.3 6.4 3.6 6.8 6.5 5.6.9 6. 5.8 7 9.4.9.7 0. 3.0.7 0.9 4.0 3.8 9.6.8.5 8.4.6.3 68 6.8 9.4 9. 7. 9.9 9.7 7.4 0.5 0.3 5.6 8.8 8.6 3.9 7. 6.9 4.9.7 0.6 0.8 7.0 4.6.3.6 9. 6.5 4. 4.3 9.7 7. 4.6 4.8 30.3 7.7 5. 5.4 4.0 3.9 4.0 3.8 4. 3.9 4.0 3.8 4. 4.0 4. 3.9 4. 4.0 4. 3.9 4. 4.0 4. 3.9 86 5.5.. 0.8 7.8 4.3.6.6 0. 7.3 4. 4.3. 8.4 4.6 4.8. 9.4 5. 5.4 83 3.0 8.6 0.4 9.7 4.8..5.0 6.6 3.8 4.6 4.3 7. 4.4 5.0 4.8 7.7 4.9 5.4 5.4 80 0.4 6. 7.9 7..8 8. 0. 9.4 3. 0.3.6.7 3. 0.4.6.7 3. 0.4.7.8 77 7.8 3.5 5.3 4.6 8.7 5. 7. 6.4 9.6 6.8 9. 8. 9. 6.4 8.7 7.7 8.8 6.0 8. 7.3 74 5.3 0.9.7.0 5.7. 4. 3.3 6. 3.3 5.6 4.7 5..4 4.7 3.8 4.3.5 3.8.8 7 8.4 0. 9.4 9.. 0.3 9.8.. 8.4 0.7 9.8 7.0 9.3 8.4 68 5.8 7.6 6.9 6. 8. 7.3 6.3 8.6 7.7 4.4 6.7 5.8.6 4.8 3.9 8 Unitary Products Group
0365300B004 COOLING CAPACITIES 3/ TON (DPH04) Temperature of Air on Outdoor Coil 85 F 95 F 05 F 5 F 5 F = These capacities are net capacities indoor fan heat deducted. ALL SENSIBLE CAPACITY Air On Indoor Coil 050 5 400 575 750 WB F WB F WB F WB F WB F 7 67 6 57 7 67 6 57 7 67 6 57 7 67 6 57 7 67 6 57 43.7 40.8 36.7 37. 46.3 43. 38.9 39. 48.8 45.6 4.0 4.4 49.5 46.3 4.6 4.0 50. 46.9 4. 4.6 3.7 3.65 3.59 3.60 3.77 3.70 3.64 3.65 3.8 3.75 3.69 3.70 3.95 3.88 3.8 3.8 4.07 4.00 3.94 3.95 86 5.3 3. 36.7 37. 8.4 36. 38.9 39. 3.6 40.0 4.0 4.4 34. 43. 4.6 4.0 36.7 46. 4. 4.6 83.3 9.3 35.8 36.9 4.9 3.6 38.4 39. 7.5 35.9 4.0 4.4 9.5 38.4 4.6 4.0 3.5 40.9 4. 4.6 80 9.3 6.3 3.8 33.9.3 9.0 36.3 37.5 3.4 3.8 39.8 4. 4.8 33.8 4.0 4.8 6.3 35.7 4. 4.6 77 6.3 3.3 9.8 30.9 7.8 5.5 3.8 34.0 9.3 7.7 35.7 37.0 0. 9. 36.4 37..0 30.5 37.0 37.4 74 3.3 0.3 6.8 7.9 4.3.0 9. 30.4 5. 3.7 3.6 3.9 5.5 4.5 3.7 3.6 5.8 5.3 3.8 3. 7 7.3 3.8 4.9 8.4 5.7 6.9 9.6 7.5 8.8 9.8 7. 7.9 0. 6.6 7.0 68 4.3 0.8.9 4.9. 3.3 5.5 3.4 4.8 5..4 3.3 4.9.4.7 4.8 39.0 34.8 34.8 44.5 4.6 37.0 37. 47. 44. 39. 39.3 47.6 44.5 39.6 39.7 48. 45.0 40.0 40. 4.04 4.0 3.9 3.93 4. 4.08 3.98 3.99 4.9 4.5 4.05 4.06 4.9 4.5 4.5 4.7 4.40 4.36 4.5 4.7 86 4.6 3.5 34.8 34.8 7.8 35.5 37.0 37. 3.0 39.5 39. 39.3 33.6 4. 39.6 39.7 36. 45.0 40.0 40. 83.6 8.6 34.7 34.8 4.3 3.0 37.0 37. 6.9 35.4 39. 39.3 8.9 37.9 39.6 39.7 30.9 40.5 40.0 40. 80 8.6 5.6 3.7 3.0 0.7 8.4 35. 35.5.8 3.3 38.8 39. 4.3 33.3 39.4 39.6 5.7 35.3 40.0 40. 77 5.6.6 8.7 9.0 7. 4.9 3.7 3.0 8.7 7. 34.7 35.0 9.6 8.6 34.8 35.0 0.5 30. 34.8 34.9 74.6 9.6 5.7 6.0 3.6.3 8. 8.5 4.6 3. 30.6 3.0 5.0 4.0 30. 30.3 5.3 4.8 9.6 9.7 7 6.6.7 3.0 7.8 4.6 4.9 9.0 6.5 6.9 9.3 5.5 5.7 9.6 4.4 4.5 68 3.6 9.7 0.0 4.3..4 5.0.5.8 4.7 0.8.0 4.4 9. 9.3 40.9 36.3 33.6 33.7 4.8 38. 35. 35.4 44.8 39.8 36.8 37.0 46.0 40.9 37.8 38.0 47. 4.9 38.7 38.9 4.49 4.43 4.36 4.40 4.56 4.49 4.4 4.46 4.6 4.55 4.48 4.53 4.75 4.67 4.6 4.65 4.87 4.80 4.73 4.77 86 4.4 30.5 33.6 33.7 7.4 34.0 35. 35.4 30.4 37.5 36.8 37.0 33.3 39.7 37.8 38.0 36.3 4.9 38.7 38.9 83.4 7.5 33.3 33.4 3.9 30.5 35.0 35. 6.3 33.6 36.8 37.0 8.7 36.6 37.8 38.0 3.0 39.5 38.7 38.9 80 8.4 4.5 30.3 30.5 0.3 7.0 33.4 33.7. 9.5 36.6 36.8 4.0 3.9 37.7 37.9 5.8 34.3 38.7 38.9 77 5.4.5 7.3 7.5 6.8 3.5 9.9 30. 8. 5.5 3.5 3.7 9.4 7.3 33.0 33. 0.6 9. 33.5 33.7 74.4 8.5 4.3 4.5 3.3 9.9 6.3 6.6 4..4 8.4 8.7 4.7.6 8.4 8.6 5.4 3.8 8.3 8.5 7 5.5.3.5 6.4.8 3.0 7.3 4.3 4.6 8.0 3.7 3.9 8.6 3. 3.3 68.5 8.3 8.5.9 9.3 9.5 3. 0. 0.5 3.3 9. 9.3 3.4 7.9 8. 40.0 33.5 3.4 3.6 4. 34.6 33.4 33.6 4.4 35.6 34.4 34.6 44.3 37. 35.9 36. 46. 38.8 37.5 37.8 4.94 4.84 4.8 4.88 5.00 4.90 4.87 4.93 5.05 4.95 4.9 4.99 5.0 5.0 5.06 5.3 5.35 5.4 5. 5.8 86 4. 9.4 3.4 3.6 7.0 3.5 33.4 33.6 9.8 35.6 34.4 34.6 33. 37. 35.9 36. 36.4 38.8 37.5 37.8 83. 6.4 3.9 3.0 3.5 9. 33. 33.3 5.7 3.9 34.4 34.6 8.5 35. 35.9 36. 3. 38.5 37.5 37.8 80 8. 3.4 8.9 9.0 9.9 5.6 3.6 3.8.7 7.8 34.3 34.5 3.8 30.5 35.9 36. 5.9 33.3 37.5 37.8 77 5. 0.4 5.9 6.0 6.4.0 8. 8. 7.6 3.7 30. 30.4 9. 5.9 3. 3.5 0.7 8.0 3. 3.5 74. 7.4.9 3.0.9 8.5 4.5 4.7 3.5 9.6 6. 6.3 4.5. 6.6 6.8 5.5.8 7.0 7.3 7 4.4 9.9 0. 5.0.0. 5.5..3 6.6.9. 7.6.8. 68.4 6.9 7..4 7.5 7.6.5 8.0 8..9 7.3 7.5.4 6.6 6.9 39.0 30.8 3. 3.5 39.5 3.0 3.5 3.9 40.0 3.3 3.9 3.3 4.7 33.5 34.0 34.4 45.3 35.7 36. 36.6 5.4 5.3 5.3 5.4 5.4 5.3 5.3 5.4 5.5 5.4 5.4 5.4 5.7 5.5 5.5 5.6 5.8 5.7 5.7 5.8 86 4.0 8.3 3. 3.5 6.6 3.0 3.5 3.9 9.3 33.6 3.9 3.3 3.9 34.7 34.0 34.4 36.5 35.7 36. 36.6 83.0 5.3 30.5 30.6 3. 7.7 3. 3.5 5. 30. 3.9 3.3 8. 33.8 34.0 34.4 3.3 37.5 36. 36.6 80 8.0.3 7.5 7.6 9.6 4. 9.8 9.9. 6.0 3. 3. 3.6 9. 34. 34.4 6.0 3.3 36. 36.6 77 5.0 9.3 4.5 4.6 6.0 0.6 6.3 6.3 7.0.9 8.0 8. 8.9 4.5 9.5 9.7 0.8 7.0 30.9 3.4 74.0 6.3.5.6.5 7..7.8.9 7.9 3.9 4.0 4.3 9.8 4.8 5. 5.6.8 5.7 6. 7 3.3 8.5 8.6 3.5 9. 9.3 3.8 9.8 9.9 5. 0. 0.4 6.6 0.5 0.9 68 0.3 5.5 5.6 0.0 5.6 5.7 9.7 5.8 5.9 0.5 5.5 5.8.4 5.3 5.7 Unitary Products Group 9
COOLING CAPACITIES 4 TON (DPH048) AND 5 TON (DPH060) Temperature of Air on Outdoor Coil 85 F 95 F 05 F 5 F 5 F 0365300B004 DPH048 DPH060 Air On Indoor Coil Air On Indoor Coil 00 600 Temperature of Air on 500 000 WB F WB F Outdoor Coil WB F WB F 7 67 6 57 7 67 6 57 7 67 6 57 7 67 6 57 49.7 45.5 4.6 4.5 54.6 49.9 45.6 45.6 6.5 57. 53. 46.4 64.4 59.9 55.7 48.6 3.85 3.79 3.78 3.77 4.00 3.94 3.93 3.9 4.40 4.38 4.36 4.3 4.85 4.83 4.80 4.75 86 9.7 36.9 4.6 4.5 36.9 45.5 45.6 45.6 86 37.3 46.9 53. 46.4 45.3 56.6 55.7 48.6 83 6.3 33.5 40.0 4. 3. 40.9 45.6 45.6 85 F 83 33.0 4.6 5.3 45.7 39.5 50.7 55.7 48.6 80.9 30. 36.6 37.7 7.6 36. 44. 45.4 80 8.7 38.3 47.0 4.4 33.7 44.9 55. 48.6 77 9.5 6.7 33. 34.3.9 3.5 39.4 40.7 77 4.5 34.0 4.7 37. 7.8 39. 49.3 4.7 74 6. 3. 9.8 30.9 8. 6.9 34.8 36. 74 0. 9.8 38.5 3.9.0 33. 43.4 36.9 7 9.8 6.4 7.4. 30. 3.4 7 5.5 34. 8.6 7.4 37.6 3. 68 6.4.9 4.0 7.5 5.4 6.7 68. 9.9 4.3.6 3.8 5. 48.0 43.4 39. 39.7 5.3 47. 4.5 43. 60. 54.8 50.5 44.3 6.4 56.8 5.4 46.0 4.0 4.4 4. 4.3 4.36 4.30 4.8 4.9 4.85 4.87 4.73 4.70 5.36 5.38 5.3 5.9 86 3.7 36. 39. 39.7 39. 44.4 4.5 43. 86 36. 46. 50.5 44.3 44.0 55.7 5.4 46.0 83 8.3 3.7 38.7 39. 34.4 39.7 4.5 43. 95 F 83 3.8 4.8 49.0 43.5 38. 49.8 5.4 46.0 80 4.8 9.3 35. 35.8 9.8 35. 4. 4.8 80 7.5 37.5 44.7 39. 3.3 44.0 5.4 46.0 77.4 5.8 3.8 3.3 5. 30.4 37.6 38. 77 3.3 33. 40.4 34.9 6.5 38. 46.6 40. 74 8.0.4 8.4 8.9 0.4 5.7 3.9 33.5 74 9.0 9.0 36. 30.6 0.6 3.3 40.8 34.3 7 9.0 5.0 5.5. 8. 8.9 7 4.7 3.9 6.4 6.5 34.6 8.5 68 5.6.6. 6.4 3.6 4. 68 0.4 7.6. 0.7 9..6 45.3 40.0 36.6 37.0 49. 43.5 39.7 40. 56.0 5.4 48.0 44. 57.4 5.7 49. 45. 4.6 4.57 4.55 4.58 4.80 4.75 4.73 4.76 5.45 5.4 5.3 5.7 5.9 5.89 5.77 5.7 86 9. 34.8 36.6 37.0 36. 4. 39.7 40. 86 34.4 44.5 48.0 44. 4.9 5. 49. 45. 83 5.8 3.4 36.3 36.6 3.5 38. 39.7 40. 05 F 83 30. 40. 46.4 4.9 36. 47.8 49. 45. 80.4 8.0 3.9 33. 6.8 33.5 39.4 39.8 80 5.9 35.9 4. 38.6 30. 4.0 49. 45. 77 8.9 4.5 9.5 9.8. 8.9 34.8 35. 77.6 3.7 37.9 34.4 4.4 36. 43.4 39.3 74 5.5. 6.0 6.4 7.5 4. 30. 30.5 74 7.3 7.4 33.6 30. 8.6 30.3 37.5 33.5 7 7.7.6.9 9.5 5.5 5.8 7 3. 9.3 5.8 4.5 3.7 7.6 68 4.3 9. 9.5 4.9 0.8. 68 8.8 5.0.5 8.7 5.9.8 4.5 36.7 34.0 34. 46.0 39.7 36.8 37.0 5.8 48. 45.5 43.8 5.4 48.6 46.0 44.3 5.03 4.99 4.97 5.0 5.4 5.0 5.8 5.3 6.05 5.97 5.90 5.85 6.47 6.39 6.3 6.6 86 6.7 33.5 34.0 34. 33. 39.7 36.8 37.0 86 3.8 4.9 45.5 43.8 39.8 48.6 46.0 44.3 83 3.3 30. 34.0 34. 8.5 36.7 36.8 37.0 5 F 83 8.5 38.7 43.8 4.4 34.0 45.8 46.0 44.3 80 9.9 6.7 30.5 30.6 3.9 3.0 36.7 36.8 80 4. 34.4 39.5 38. 8. 40.0 46.0 44.3 77 6.4 3.3 7. 7. 9. 7.4 3.0 3. 77 9.9 30. 35.3 33.8.3 34. 40. 38.5 74 3.0 9.8 3.7 3.8 4.5.7 7.3 7.5 74 5.7 5.8 3.0 9.5 6.5 8.3 34.3 3.6 7 6.4 0.3 0.4 8.0.7.8 7.5 6.7 5.3.5 8.5 6.8 68 3.0 6.9 7.0 3.4 8.0 8. 68 7.3.4.0 6.8.7.0 39.7 33.4 3.5 3.4 4.8 36.0 33.9 33.8 47.7 44.7 43.9 43.6 47.4 44.4 43.7 43.4 5.5 5.4 5.4 5.5 5.7 5.6 5.6 5.7 6.6 6.5 6.5 6.4 7.0 6.9 6.9 6.8 86 4. 3. 3.5 3.4 30. 36.0 33.9 33.8 86 3. 4.4 43.9 43.6 37.8 44.4 43.7 43.4 83 0.8 8.8 3.5 3.4 5.6 35. 33.9 33.8 5 F 83 6.8 37. 4. 4.8 3.9 43.8 43.7 43.4 80 7.4 5.4 8. 8. 0.9 30.5 33.9 33.8 80.6 3.8 37.8 37.5 6. 38.0 43..7 43.4 77 40.0 4.8 4.7 6. 5.8 9. 9. 77 8.3 8.5 33.4 33.3 0.3 3. 37.7 37.6 74 0.5 8.5.3..6. 4.5 4.4 74 4.0 4.3 9.0 9.0 4.4 6.3 3.8 3.8 7 5. 7.9 7.8 6.5 9.9 9.8 7 0.0 4.7 4.7 0.5 5.8 5.9 68.7 4.5 4.4.8 5. 5. 68 5.7 0.3 0.4 4.6 9.9 0. = These capacities are net capacities indoor fan heat deducted. ALL SENSIBLE CAPACITY 0 Unitary Products Group
0365300B004 Unitary Products Group MODEL NO. MOTOR SPEED EXTERNAL STATIC PRESSURE IWG.0.0.30.40.50.60.70.80.90.00.0 DPH08 HI MED LOW 74 6 686 63 98 690 577 3 85 689 659 453 374 0 65 593 487 36 88 497 347 DPH04 HI MED LOW 80 6 765 50 96 70 33 38 90 675 3 7 84 67 305 78 90 990 70 468 74 888 660 456 57 786 444 684 43 DPH030 HI MED LOW 080 80 35 6 0 765 34 40 96 33 90 3 7 84 504 305 080 78 486 90 990 468 888 456 786 444 DPH036 HI MED LOW 465 36 53 473 395 60 5 455 440 35 04 605 49 438 36 55 48 58 473 40 73 67 069 555 446 396 85 079 990 530 49 37 097 99 9 504 39 348 004 480 9 456 DPH04 HI MED LOW 579 567 674 5 64 546 78 590 444 75 590 55 633 506 377 697 567 504 57 400 8 666 535 476 4 95 88 635 50 447 37 90 093 605 470 48 05 063 576 48 094 547 DPH048 TBA TBB 500 600 360 405 500 600 380 460 500 600 400 55 500 600 40 570 500 600 455 600 500 600 489 69 500 600 55 660 500 56 DPH060 TBA TBB 500 000 58 590 500 000 347 648 50 000 376 707 500 000 476 765 500 000 495 83 500 000 554 88 500 64 500 673 500 73 NOTE: Above data includes allowances for a dry evaporator coil and no filters. For additional pressure drops, refer to the Additional Static Pressure Resistance table. * TBA Factory set TBB Field option 08 volts SIDE AND BOTTOM SUPPLY AIR BLOWER PERFORMANCE 30/460/575 volts MODEL NO. MOTOR SPEED EXTERNAL STATIC PRESSURE IWG.0.0.30.40.50.60.70.80.90.00.0 DPH08 HI MED LOW 70 0 64 05 654 536 33 83 659 54 40 09 55 386 DPH04 HI MED LOW 900 90 850 77 800 65 750 5 935 697 339 35 867 643 3 8 800 304 987 733 507 86 873 867 493 68 760 480 DPH030 HI MED LOW 00 900 390 90 34 850 397 67 068 800 368 43 00 357 935 339 00 867 540 3 00 800 50 304 987 507 873 493 760 480 DPH036 HI MED LOW 46 55 400 506 47 337 547 486 394 75 56 467 44 97 87 67 495 440 37 99 00 588 465 44 9 0 0 560 435 387 6 985 533 397 03 507 90 480 DPH04 HI MED LOW 680 607 605 584 673 530 630 560 697 556 45 740 594 58 580 439 30 706 558 496 463 3 4 67 5 464 339 8 050 640 476 40 6 608 09 576 DPH048 TBA TBB 500 600 390 450 500 600 400 490 500 600 40 530 500 600 40 570 500 600 460 606 500 600 499 643 500 600 540 680 500 600 585 76 DPH060 TBA TBB 500 000 58 590 500 000 37 648 500 000 376 707 500 000 436 765 500 000 495 83 500 000 564 88 50 000 0 64 940 500 000 673 998 500 73 500 79 DPH048 (575 V ONLY) HI MED LOW 876 544 79 60 89 508 77 60 783 47 753 600 847 736 436 88 733 590 867 668 375 857 706 573 786 599 33 83 680 557 706 53 5 807 653 540 637 434 78 6 569 337 757 59 500 40 73 560 DPH060 (575 V ONLY) HI MED LOW 4 090 454 0 63 053 387 6 7 07 499 30 0 90 070 980 39 9 04 33 03 97 83 37 96 77 977 873 75 046 883 0 930 80 067 950 797 080 887 787 958 854 7 040 843 753 850 758 65 000 800 70 NOTE: Above data includes allowances for a dry evaporator coil and no filters. For additional pressure drops, refer to the Additional Static Pressure Resistance table. * TBA Factory set TBB Field option
ADDITIONAL STATIC PRESSURE RESISTANCE 0365300B004 RESISTANCE, IWG MODEL DPH DESCRIPTION 500 600 700 800 900,000,00,00,300,400,500,600 Wet Evaporator coil 0.0 0.0 0.0 0.0 0.0 0.03 0.03 0.04 0.04 0.04 0.04 0.04 Economizer 0.00 0.00 0.00 0.0 0.0 0.0 0.0 0.0 0.03 0.04 0.05 0.06 Filter/Frame Kit 0.0 0.0 0.0 0.0 0.0 0.0 0.03 0.03 0.03 0.03 0.04 0.05 Electric Heat 0.0 0.03 0.03 0.03 0.04 0.04 0.05 0.06 0.07 0.08 0.09 0.0 NOTE:. Deduct these resistance values from the available external static pressure shown in the respective Blower Performance Table.. The pressure thru the economizer is greater for 00% outdoor air then for 00% return air. If the resistance of the return air duct system is less then 0.5 IWG, the unit will deliver less during full economizer operation. FIELD WIRING DIAGRAM ** = Minimum wire size of 8 AWG wire should be used for all field installed 4 volt wire. THERMOSTAT 4 / ** UNIT TERMINAL STRIP 4 / NOTE: HEAT ANTICIPATOR SHOULD BE SET AT 0.5 AMPS FOR ALL MODELS. PROGRAMMABLE THERMOSTAT ONLY * = Only required on units with supplemental electric heat. ; 9 * 9 9 ; 9 + + * 4 VOLT TRANSFORMER CAUTION: Label all wires prior to disconnection when servicing controls. Wiring errors can cause improper and dangerous operation. Verify proper operation after servicing. CONTROL WIRING REFER TO ELECTRICAL DATA TABLES TO SIZE THE DIS CONNECT REFER TO ELECTRICAL DATA TABLES TO SIZE THE DIS CONNECT POWER WIRING Unitary Products Group
0365300B004 ELECTRICAL DATA (BASIC UNIT) MODEL POWER SUP DPH PLY VOLTAGE LIMITATIONS COMPRESSOR MIN. MAX. RLA LRA COND. FAN MOTOR, FLA SUPPLY AIR BLOWER MOTOR, FLA MINIMUM CIRCUIT AMPACITY MAX. FUSE SIZE, AMPS MAX. HACR BREAKER SIZE, AMPS UNIT POWER FACTOR TRANSFORMER SIZE (VA) 08 08/3060 87 53 7. 48.0..6.5 5 5.96 40 04 08/3060 87 53 9.3 57.0..6 5.3 0 0.96 40 030 08/3060 87 53 5.0 7.5..6.5 30 30.96 40 036 08/3060 87 53 7. 88.0. 3.5 6. 35 35.96 40 04 08/3060 87 53 0.0 04.0. 3.5 9.6 40 40.96 40 048 08/3060 87 53 0.5 5.3 7.3 34.7 45 45.96 40 060 08/3060 87 53 8.8 69.3 9.4 46.8 60 60.96 40 030 08/30360 87 53 0.0 63.0..6 6. 5 5.96 75 036 08/30360 87 53.4 77.0. 3.5 8.9 5 5.96 75 04 08/30360 87 53 3.9 88.0. 3.5.0 30 30.96 75 048 08/30360 87 53 4. 90.0.3 7.3 6. 35 35.96 75 060 08/30360 87 53 9.3 3.0.3 9.4 34.8 45 45.96 75 030 460360 44 504 5.0 3.0 0.6.4 8.3 5 5.96 75 036 460360 44 504 5.7 39.0 0.6.8 9.5 5 5.96 75 04 460360 44 504 6.4 44.0 0.6.8 0.4 5 5.96 75 048 460360 44 504 7. 45.0 0.7 7.3 3. 0 0.96 75 060 460360 44 504 7.5 49.5 0.7 9.4 4.8 0 0.96 75 036 575360 58 630 4.7 3.0 0.4.5 7.8 5 5.96 75 04 575360 58 630 5.4 34.0 0.4.5 8.7 5 5.96 75 048 575360 58 630 5.8 36.0 0.6.0 9.8 5 5.96 75 060 575360 58 630 6.4 40.0 0.6.8.4 5 5.96 75 = Rated in accordance with ARI Standard 0, utilization range A. = Dual element, time delay type. Unitary Products Group 3
0365300B004 ELECTRICAL DATA (COOLING / ELECTRIC HEAT) Continued on page 5 DPH MODEL POWER SUPPLY COMPRESSOR COND. FAN MOTOR FLA SUPPLY AIR BLOWER MOTOR, RLA LRA FLA MODEL NO. ELECTRIC HEAT ACCESSORY STAGE KW TOTAL AMPS MINIMUM CIRCUIT AMPACITY MAX. FUSE SIZE, AMPS MAX. HACR BREAKER SIZE 08 08/3060 9.0 48.0..6 04 08/3060. 60.0..6 030 08/3060.0 73.0..6 036 08/3060 7.3 94.0. 3.5 04 08/3060 0.5 0.0. 3.5 048 08/3060 0.5 5.0.3 7.3 060 08/3060 8.8 69.0.3 9.4 030 08/30360 0.0 63.0..6 036 08/30360 0.9 78.0. 3.5 04 08/30360 4. 0.0. 3.5 048 08/30360 4. 90.0.3 7.3 060 08/30360 9.3 3.0.3 9.4 030 460360 5.0 3.0 0.6.4 036 460360 5.8 40.0 0.6.8 04 460360 7. 54.0 0.6.8 048 460360 7. 45.0 0.7 7.3 060 460360 7.5 49.5 0.7 9.4 = Dual element, time delay type. = Standard circuit breakers may be used in Canada and on applications over 60 amps where the heaters are separately fused. NH04500506 NH04500706 NH04500506 NH04500706 NH0450006 NH04500506 NH04500706 NH0450006 NH0450506 NH04500506 NH04500706 NH0450006 NH0450506 NH04500506 NH04500706 NH0450006 NH0450506 NH0450006 NH0450506 NH0450006 NH0450506 NH0450006 NH0450506 NH0450006 NH0450506 NH045005 NH045055 NH045005 NH045055 NH045005 NH045055 NH045005 NH045055 NH045005 NH045055 NH045005 NH045055 NH045005 NH045055 NH0450046 NH0450546 NH0450046 NH0450546 NH0450046 NH0450546 NH0450046 NH0450546 NH0450046 NH0450546 NH0450046 NH0450546 NH0450046 NH0450546 3.8/5.0 * 5.6/7.5 * 3.8/5.0 * 5.6/7.5 * 7.5/0.0 * 3.8/5.0 * 5.6/7.5 * 7.5/0.0 *.3/5.0 * 3.8/5.0 * 5.6/7.5 * 7.5/0.0 *.3/5.0 * 3.8/5.0 * 5.6/7.5 * 7.5/0.0 *.3/5.0 * 7.5/0.0 *.3/5.0 * 5.0/0.0 * 8.8/5.0 * 7.5/0.0 *.3/5.0 * 5.0/0.0 * 8.8/5.0 * 7.5/0.0 *.3/5.0 * 7.5/0.0 *.3/5.0 * 7.5/0.0 *.3/5.0 * 7.5/0.0 *.3/5.0 * 5.0/0.0 * 8.8/5.0 * 7.5/0.0 *.3/5.0 * 5.0/0.0 * 8.8/5.0 * 0.0 ** 5.0 ** 0.0 ** 5.0 ** 0.0 ** 5.0 ** 0.0 ** 5.0 ** 0.0 ** 5.0 ** 0.0 ** 5.0 ** 0.0 ** 5.0 ** 8./0.8 7./3.3 8./0.8 7./3.3 36./4.7 8./0.8 7.3/3.3 36./4.7 54./6.5 8./0.8 7./3.3 36./4.7 54./6.5 8./0.8 7./3.3 36./4.7 54./6.5 36./4.7 54./6.5 7./83.3 90.3/04. 36./4.7 54./6.5 7./83.3 90.3/04. 0.8/4. 3.3/36. 0.8/4. 3.3/36. 0.8/4. 3.3/36. 0.8/4. 3.3/36. 4.7/48. 5./60. 0.8/4. 3.3/36. 4.7/48. 5./60..0 8.0.0 8.0.0 8.0.0 8.0 4. 30..0 8.0 4. 30. 5.8/9.3 37./4.3 5.8/9.3 37./4.3 48.4/55.3 5.8/9.3 37./4.3 48.4/55.3 7.0/8.4 6.9/30.4 38./43.4 49.5/56.5 7./8.5 30./30.4 38./43.4 49.5/56.5 7./8.5 54.3/6. 76.8/87.3 99.4/3.3.0/39.3 56.9/63.8 79.5/89.9 0.0/5.9 4.6/4.0 9.3/33.3 4.3/48.4 30.4/34.4 43.5/49.5 30.4/34.4 43.5/49.5 35./39. 48./54. 6./69.3 74.3/84.3 37.8/4.8 50.8/56.9 63.9/7.9 76.9/86.9 6.8 4.3 7.3 4.8 7.3 4.8 9.6 7. 34.6 4. 0.9 8.4 35.9 43.5 30/30 40/45 30/30 40/45 50/60 30/30 40/45 50/60 80/90 35/40 40/45 50/60 80/90 40/40 50/50 50/60 80/90 60/70 80/90 00/5 5/50 70/70 80/90 0/5 5/50 30/35 45/50 35/35 45/50 35/35 45/50 40/40 50/60 70/70 80/90 50/50 60/60 70/80 80/90 0 5 0 5 0 5 0 30 35 45 5 30 40 45 * = KW listed is for 40 volts, use this table for 08 or 30 volts. ** = KW listed is for 480 volts, use this table for 460 volts. ELECTRIC HEAT CORRECTION FACTORS NOMINAL VOLTAGE 40 VOLTAGE 08 30 30/30 40/45 30/30 40/45 50/60 30/30 40/45 50/60 80/90 35/40 40/45 50/60 80/90 40/40 50/50 50/60 80/90 60/70 80/90 00/5 5/50 70/70 80/90 0/5 5/50 30/35 45/50 35/35 45/50 35/35 45/50 40/40 50/60 70/70 80/90 50/50 60/60 70/80 80/90 0 5 0 5 0 5 0 30 35 45 5 30 40 45 KW CAP. MULTI PLIER.75.9 480 460.9 4 Unitary Products Group
0365300B004 ELECTRICAL DATA (COOLING / ELECTRIC HEAT) Continued from page 4 DPH MODEL POWER SUPPLY COMPRESSOR COND. FAN MOTOR FLA SUPPLY AIR BLOWER MOTOR, RLA LRA FLA MODEL NO. ELECTRIC HEAT ACCESSORY STAGE KW TOTAL AMPS MINIMUM CIRCUIT AMPACITY MAX. FUSE SIZE, AMPS MAX. HACR BREAKER SIZE 036 575360 4.5 3.0 0.4.5 04 575360 5.8 44.0 0.4.5 048 575360 5.8 36.0 0.6.0 060 575360 6.4 40.0 0.6.8 = Dual element, time delay type. = Standard circuit breakers may be used in Canada and on applications over 60 amps where the heaters are separately fused. NH0450058 NH0450558 NH0450058 NH0450558 NH0450058 NH0450558 NH0450058 NH0450558 NH0450058 NH0450558 NH0450058 NH0450558 0.0 *** 5.0 *** 9.6 4.4 3.9 9.9 5 0 0.0 *** 9.6 3.9 5 5.0 *** 4.4 9.9 0 0.0 *** 9.6 4.5 5 5.0 *** 4.4 0.5 5 0.0 *** 9. 6.6 30 5.0 *** 4. 3.6 35 0.0 *** 9.6 5.5 0 5.0 *** 4.4.5 5 0.0 *** 9. 7.6 30 5.0 *** 4. 33.6 35 *** = KW listed is for 600 volts, use this table for 575 volts. ELECTRIC HEAT CORRECTION FACTORS 5 0 5 0 5 5 30 35 0 5 30 35 NOMINAL VOLTAGE VOLTAGE KW CAP. MULTI PLIER 600 575.9 Unitary Products Group 5
0365300B004 UNIT DIMENSIONS HIGH VOLTAGE CONN.!! DIA. KNOCKOUT LOW VOLTAGE CONN. % & DIA. KNOCKOUT SIDE SUPPLY AIR OPENING SIDE RETURN AIR OPENING HIGH VOLTAGE CONN. % & DIA. KNOCKOUT FRONT! & A (OVERALL) COMPRESSOR SERVICE ACCESS COMPARTMENT PANEL UNIT SIZE DIMENSION A 08 04!! 048 060 REFRIGERANT CONNECTIONS ELECTRICAL/FILTER SERVICE ACCESS COMPARTMENT PANEL ' & (OVERALL) & % % & % (OVERALL) HIGH VOLTAGE CONN.! $ DIA. KNOCKOUT!! LOW VOLTAGE CONN. % & DIA. KNOCKOUT UNIT CONDENSATE CONNECTION! NPTI (TRAP REQUIRED) FRONT All dimensions are in inches. They are subject to change without notice. Certified dimensions will be provided upon request. HIGH VOLTAGE CONN.!! x % & DIA. KNOCKOUT SIDE SUPPLY AIR OPENING! $! &! & 6 BACK CONDENSER COIL CONDENSATE DRAIN! NPTI!! & SIDE RETURN AIR OPENING BOTTOM SUPPLY AIR OPENING! &! 5 5 4! 5! & ' $! BOTTOM RETURN AIR OPENING! 6 Unitary Products Group
0365300B004 UNIT WEIGHTS AND CENTER OF GRAVITY UNIT SIZE SHIPPING WEIGHT OPERATING WEIGHT CORNER WEIGHTS A B C D 08 330 35 89 78 76 86 04 338 333 9 80 78 88 030 340 335 86 83 83 87 036 34 336 9 8 79 89 04 348 343 94 83 80 9 048 376 37 94 89 94 99 060 456 45 7 0 06 D ECONOMIZER (lbs.) 40 CENTER OF GRAVITY ROOF CURB (lbs.) 8 70 4 75 FRONT OF UNIT A B C ' & 6! % CLEARANCES UNIT CLEARANCES (Minimum) Front Back 0 Left Side (Filter Access) 4 Right Side 4 Below Unit 0 Above Unit 36 (For Condenser Air Discharge) MINIMUM CLEARANCE OF ALL SIDES FOR THE FIRST 3' OF DUCT FOR 0 & 5 kw. ZERO IN CHES THEREAFTER, FOR A LL OTHER HEATERS, ZERO IN CH CLEARANCE ALL SIDES FOR ENTIRE LENGTH OF DUCT. Units may be installed on combustible floors made from wood or class A, B or C roof covering material. Units must be installed outdoors. Overhanging structures or shrubs should not obstruct outdoor air discharge outlet. NOTE: FOR UNITS APPLIED WITH A ROOF CURB, THE MINIMUM CLEARANCE MAY BE REDUCED FROM INCH TO / INCH BETWEEN COMBUSTIBLE ROOF CURB MATERIAL AND THE SUPPLY DUCT. FLEXIBLE DUCT COLLAR 3' Unitary Products Group 7
TYPICAL APPLICATIONS TYPICAL SLAB ON GROUND INSTALLATION SUPPLY AIR DUCT 0365300B004 RETURN AIR DUCT FIELD SUPPLIED DISCONNECT SWITCH LOCATED TO REAR OF UNIT TO POWER SUPPLY CONTROL WIRING TO INDOOR THERMOSTAT TYPICAL ROOF CURB INSTALLATION FIELD SUPPLIED DISCONNECT SWITCH MOUNTED ON UNIT TO POWER SUPPLY ROOF CURB INSTALLATION REAR DUCT CONTROL WIRING TO INDOOR THERMOSTAT ROOF CURB INSTALLATION BOTTOM DUCT RETURN AIR DUCT SUPPLY AIR DUCT SLAB ON GROUND INSTALLATION 8 Unitary Products Group
0365300B004 ROOF CURB DIMENSIONS (8 roof curb also available)!! % # & #! OPENING FOR RETURN AIR DUCT % 4! OPENING FOR SUPPLY AIR DUCT 4 FRONT WOOD NAILER INSULATED PANELS RECOMMENDED DUCT SIZE SUPPLY AIR DUCT % & x RETURN AIR DUCT % & x $! ROOF CURB APPLICATION! x WIDE GASKETING FOR CURB FRAME AND ALL DUCT SUPPORT SURFACES UNIT BASE RAIL UNIT BASE WOOD NAILER 8 MIN. ABOVE FINISHED ROOF 4 COUNTERFLASHING CANT STRIP INSULATION AND ROOFING MATERIAL CURB FRAME INSULATION ROOF DECK AND ROOFING MATERIAL Unitary Products Group 9
0365300B004 TYPICAL WIRING DIAGRAM (08/3060 POWER SUPPLY) DPH08 THRU 04 MODELS OPTIONAL CCH S / P CONFIGURATION CCH BLK L BLK T SEE DETAIL A D / P CONFIGURATION CCH BLK L BLK L M T L DETAIL A 5695BASH030 0 Unitary Products Group
0365300B004 TYPICAL WIRING DIAGRAM (08/3060 POWER SUPPLY) DPH048 AND 060 MODELS SEE DETAIL OPTIONAL CCH A S / P CONFIGURATION CCH BLK BLK L T D / P CONFIGURATION CCH BLK BLK L L 5556BBSH030 Unitary Products Group
0365300B004 TYPICAL WIRING DIAGRAM (08/30360 POWER SUPPLY) DPH08 THRU 04 MODELS TYPICAL WIRING DIAGRAM NOTES TYPICAL WIRING DIAGRAM LEGEND F9 6 (NOT USED) M3, 30V COIL Unitary Products Group
0365300B004 TYPICAL WIRING DIAGRAM (08/30360 POWER SUPPLY) DPH048 060 MODELS Unitary Products Group 3
0365300B004 TYPICAL WIRING DIAGRAM (460360 AND 575360 POWER SUPPLY) DPH08 060 MODELS 4 Unitary Products Group
0365300B004 TYPICAL WIRING DIAGRAM (460360 POWER SUPPLY) DPH048 AND 060 MODELS Unitary Products Group 5
0365300B004 6 Unitary Products Group