Lamborghini Gallardo GT3 GT3-004 2008
Spares List Lamborghini Gallardo GT3 - Spares List Qty Part Notes 4 OZ wheels in anthracite Mounted on car with new slicks 4 OZ wheels in red Bare, 1 damaged 4 OZ wheels in anthracite New Dunlop wets 2 OZ wheels in anthracite Bare 7 Braid wheels in anthracite Boxed, new 1 Selection of coolant pipes & hoses New 1 Selection of chassis brackets and engine mounts Used 2 Car set springs Used 4 Wheel nuts Used 1 Engine aux belt New 1 Heat shield Used 1 Car set brake pads New 1 Selection of brake pads Part worn 1 RH front wing Used, damaged repairable 1 LH front wing New 1 Wing main plane Used 1 Rear lamp assembly RH, inc bulb holder and loom Used - small crack 1 Rear lamp assembly LH, inc bulb holder and loom Used 1 Front bumper in grey met New 1 Bumper mesh set Used 1 RH door New 1 Car set of floors New
Total Inc Net VAT 31-4-Nov Simon Bellenger / John Neate 40 2400 2400 2880 Remove engine and Gearbox Strip engine bay Strip front chassis Remove corners Measure Chassis and pick up points. Left Rear requires repair 09-Nov-11 John Neate 8 480 480 576 Strip oil tank remove sight tube to be replaced Remove Airjacks to be sent for rebuild 11-Nov-11 Mark Rule Full clean engine bay Full clean interior Check dash wiring Re Route some wiring under dash ReFit Dash Remove plate under tunnel-check water and oil pipes Remove heat wrap on lines and cables to check -Require replacing with new Consumables 9 540 5 545 654 10-Nov ship sight tube to Think 0 7.95 7.95 9.54 15-Nov sight tube-oil tank 0 29.95 29.95 35.94 18-Nov Mark Rule Strip clean and check all 4 corners LH D Shaft bolt incorrect Strip dampers ready to be shipped for rebuild 25-Nov Simon Bellenger Sort through Parts, Make List, Clean/Paint, Chassis Sort through Engine Parts, Strip Engine Aux parts 26-Nov Payment 10,000inc vat. 8333.33 net -10000 25-Nov Uprated engine mount set 0 628 628 753.6 22-Nov ship wheel to braid spain 0 25 25 30
1-2-Dec Mark Rule Cut out suspension pick up strip out fuel tank and parts prep car for paint Remove tank foam and spacer balls strip panels ready for paint Cut rear arches out ready for Dunlops 20 1200 1200 1440 02-Dec Simon Bellenger 4 240 240 288 prep, jig and weld suspension pick up 09-Dec Mark Rule Build up corners Fit engine mounts Sort brake lines Sort through new wheels 10-Dec 10K paid by PW = 8333.33net 0 0-10000 13-Dec Prep Reiter order and parts list 2 120 120 144 15-Dec water hoses. 07L121508.( 99.52)07L121510( 84.16) 0 183.68 183.68 220.416 Total Net Inc VAT 5-17 Dec SD Engine strip and prep Remove ancilleries Strip engine Dummy build & check clearances on Arrow rods and standard pistons Organise block repair (Liners) Rods to Arrow for check Piston design Check compression (Deck heights) Engine parts list 54 3240 3240 3888 15-Dec SB on brake lines & refit 4 hours 4 240 240 288 15-Dec Mark Rule 9 hours Fit radiators assemble ducting and fabricate mounts 16-Dec Mark Rule 9 hours Build front end 13-Dec wiring parts rs components 0 125 125 150 12-Dec 2x Bosch Fuel pump @ 224 each 0 448 448 537.6 14-Dec In tank foam and in tank fuel pump ATL 0 175 175 210
14-Dec In tank foam and in tank fuel pump ATL 0 175 175 210 12-Dec Fuel cooler 16 row 0 115 115 138 20-Dec Trident foam sheet 0 20 20 24 20-Dec 4x wets 4x slicks dunlops at 150 ea 0 1200 1200 1440 20-Dec Tyre fit and balance x8 at 10 ea 0 80 80 96 20-Dec remove 12 tyres for refurb at 8 ea 0 96 96 115.2 20-Dec 16 wheels(6 scrap) 10 refurb at 95 0 950 950 1140 20-Dec brembo piston seals 0 180 180 216 22-Dec atl fuel tank gaskets 0 36 36 43.2 20-Dec reflect a cool - heat reflective sheet 0 81.58 81.58 97.896 12-Dec Paint shell and body parts (Some parts not done yet) 0 2250 2250 2700 Total Net Inc VAT 06-Jan Mark Rule 8 hours Preparing corners Refitting interior trim 28-Dec Engine parts Lamborghini (7676) 5x Water seal 2x oil seal 5x water seal 2x Oil pipe 6x o ring Shim 20x seal ring 40x spring valve 5x screw 40x N/Stk connector rod 12x Drive shaft bu Engine gasket 24x N/STK Cylinder head 2x o ring 0 1577.33 1577.33 1892.796 03-Jan 10x new connecting rods -new design 0 2950 2950 3540 21-Dec Crank polish (Automotive Services) 0 48 48 57.6 22-Dec Air lance repair (Think 7705) 0 86.04 86.04 103.248 16-Dec FEV extinguisher service (7711) 0 125 125 150 09-Jan Mark Rule 9 hours Fit low pressure pumps and new collector still lh lp pump to do New hoses for in tank required 100mm longer-parts ordered Fabricate and fit studs for fuel tank top plate note: missing R/H door latch
Total Inc Net VAT 10-Jan payment by bacs 0 0-10000 13-15-jan Simon Bellenger 13 hours Strip G Box 13 780 780 936 06-Jan engine parts washer and jets 0 73.2 73.2 87.84 09-Jan Air jack 1 replace 2 repair (7735) 0 693.75 693.75 832.5 06-Jan Catch tank and fuel tank topand inlet (7748) 0 415 415 498 20-Jan Payment by BACS 0 0-9600 17-Jan m8x160 cap heads (7813) 0 24 24 28.8 19-Jan Air ducts Lamborghini (7831) 0 842.99 842.99 1011.588 20-21-Jan Mark Rule 12 hours Fabricate and fit water hoses front and through tunnel Routing power cables (modified) Trim front bumper bar/paint Fit bridges, fire nozzles, heat wrap engine bay heat reflector bulkhead 12 720 720 864 26-Jan CP BDM Piston Set of 10 0 2650 2650 3180 26-Jan Steve Davey 8 hour wiring and loom 8 480 480 576 27-Jan KW damper service inc. Replace 1x comp unit (7834) 0 1113.75 1113.75 1336.5 27-Jan Mark Rule 9 hours Air lines jacks and mounts 17-Jan LM bumper bar and brackets (7864) 0 1235.72 1235.72 1482.864 01-Feb SD 8 hours 8 8 9.6 Wiring for twin fuel pump system & AIM sensors 09-Jan Nuts and bolts (7886) 0 25 25 30 11-Jan snor washers (7887) 0 20 20 24 07-Feb (7788-7795) Fuel lines, wiring, filters etc 0 200 200 240 02-Feb (7916) Hydraulic lines 0 195 195 234 30-Jan Wurth Repair glue (7918) 0 89 89 106.8 09-Feb bushes, connectors, heat shrink (7944-46) 0 60 60 72 26-Jan tapered spacers, w/bone studs,cam blocks (7947&48) 0 447 447 536.4 07-Feb Mark rule 9 hours Fuel tank LH low pressure pump new feed and return hoses Fit collector and tank foam Seal tank and surround 17-Jan Silicone hose (7960) 0 25.06 25.06 30.072 17-Feb Machine engine block and fit 10x liners (8003) 0 1080 1080 1296
14-17-Feb Mark Rule 4 days at 9 hours New fire nozzle mounts Bulkhead plate for fuel lines Tank to bulkhead fuel line Heat matting on fuel tank Paint fuel pump bracket Assemble fuel pumps Bulkhead fuel pump lines Fit vacuum reservoir bracket for fuel cooler Fuel pipe bulkhead to fuel cooler Route vacuum lines Fit header tank Rear hubs and dampers Replace wishbone studs Trim and fit new Reiter radiator duct Move ecu position Fit tunnel gusset Fuel cooler grill Total Net Inc VAT 36 2160 2160 2592 14-Feb Fuel, Coolant & Vacuum parts, hoses & Fittings (8009-8018) 0 275 275 330 14-17-Feb SD Vacuum, water and fuel lines assembly 10 600 600 720 24.2.12 Payment by BACS 0 0-7200 TOTAL -54