INSTRUCTIONS: CARRYGOLF LEOPARD LEOPARD 1
CONTENTS 1. In The Box 2. Assembly Instructions 3. Control Panel Functions 4. Driving With Remote Control 5. How To Manage Without Remote Control 6. Battery 7. Electric Brake. "Brake System" 8. Driving Without Electric Motor 9. Maintenance 10. Transport 11. Technical Service 12. Warranty 2
INSTRUCTIONS: CARRYGOLF - LEOPARD Please read and follow these instructions carefully and your cart will be ready to run in minutes. 3
BOX CONTENTS A) Metal frame and motor. B) 2 wheels, rims and rear tires. C) 24 V Lithium battery with box. D) Battery Charger. E) three additional quick clamping gums. F) Remote control. G) Anti rollover tire. H) Wheels transport bag. I) Battery transport bag. J) Grass cleaning brush. K) Card holder. L) Support for umbrella. M) Silicone capss to protect the car. N) Towel to clean irons. 4
Figure 1 5
ASSEMBLY INSTRUCTIONS Unpack all components carefully and keep the package for a reasonable time. (Essential in case of refund) 1) Mount the wheels checking the tire tread and still points in the direction of travel. Take as reference the tire tread of the front wheel or follow the pattern of Figure 1 (p. 5). The wheels have left right position. Insert each wheel in axis, pressing the pivot located on the same wheel. The shaft has two lace. The exterior, is intended only for use with full manual cart, in case of a power failure, battery depletion or failure. The inner socket, is used to engage the four Allen screws inside the wheel, into the four holes that brings the motor, so the motor moves the wheels. 6
2) The anti rollover rear wheel has an anchoring(and safety) pin that shall be pressed, for insertion or removal of its position. 3) Position and fix the horizontal arm at the desired position. 7
4) Install the battery in the cart and plug the power cord into the power outlet of the motor, gently pressing the anchor pivot. (Remember that for removal one must also press the anchoring piece) To fit into the socket, press the pivot anchor 5) Fix the battery to the cart by a quick clamping rubber band (Photo B). The purpose of this fixing is to avoid unnecessary wear on the painting produced by continuous friction. At the same time, get the battery un moved in case we detach or dump the cart. Photo A Photo B All rubber clamps (photo A) has an adjustment function. To work properly tensioned, make a knot to the desired size.. 8
CONTROL PANEL FUNCTIONS 3.1 ON / OFF Press for two seconds, your Carrygolf is connected or disconnected. 3.2 LED power indicator. To verify that your car is on or off, the indicator light provided. Remains green as available battery charge. Red when the battery status is low. 3.3 TIMER, scheduled movement 10, 20 or 30 meters. Depending on the number of times the button (1, 2 or 3 times) is pressed, the preset distance Carrygolf advance 10, 20 0 30 m. 3.4 POTENCIOMETER, power regulator according to the terrain. A steeper, will require more power. 9
RIDING WITH REMOTE CONTROL The remote control is a command transmitter to the receiver installed on the golf cart. 2 AAA batteries (1.5 V) are necessary IMPORTANT: For a proper carriage driving with remote control, turn your Carrygolf on and hold down the potenciometer knob. Strange as it may seem, the button should remain in the stop position. The potentiometer is only used for driving without a remote control. You may need 2 or 3 games to master, driving with remote control 10
Basic functions of the remote control. 6 2 3 8 5 4 1 7 Button 1 - on or off button ON / OFF. Button 2 - Led - Witness Button 3 - Go Forward Button 4 Go BackWards Button 5 - Right Button 6 - Left. Button 7 - Move & scheduled stop at 10, 20 or 30 meters Button 8 - Emergency Stop The remote control is a command transmitter, receiving it the receiver installed on the golf cart. To better understand the operation have given a different number to each button. The functions performed by the command are: 11
Button 1 on/off - Your remote control has a button to start or end use. Button 2 - LED battery charge indicator or possible failure of command. Button 3 - Forward. This key and the following have more features than at first they may seem. A) Go ahead. Directs the cart in forward direction. B) Change of electrical gear. The G5R-T is equipped with an Electronic 5- speed gear box. Once the cart is started each time you press this key activates a higher gear and will be getting more speed. starting in 1st. Gear if every 3 to 4 seconds press this key to a total of 4 times, the cart will circulate with 5th gear. To slow intermittently have to click the Button 4 (Back) and it will go from 5th gear to 4th, 4th to 3rd and so on until the cart stops. When the cart is in 2nd gear you can press the emergency brake (Button 8) and stop smoothly without damaging the mechanism, because the abruptness is minimal. Button 4 - Back. It has 2 functions as with Button3 (forward). A) Back. With the car stopped, pressing this button runs the cart backwards. B) Change of electrical gear. When the cart is moving and want to be able to reduce your speed, you must press this button intermittently. Each press will reduce speed. To understand it better with a simple example will be enough. Imagine going in forward with 5th gear. The car is about to reach its destination. To stop the cart in the desired location you can use button 8 that is the emergency brake or reducing speed until it stops by itself, because it goes to P position like a car with automatic transmission. 12
If you stop the car with button 8, this is going to stop abruptly, but the mechanisms that get stop the cart, suffer a "punch" that as time goes by, will cause one or more faults. If you drive with a slow gear, sharply this is much softer and the mechanisms absorb well this order by button 8. Therefore in this case you can safely use button 8 called "emergency stop". When the car runs with fast speeds, you should use button 4 and shifting down. Check that the cart gently and quickly stops to reaches the P position. Button 5 - Right. Press this button to move the cart to the right. Button 6 - Left. Directs the cart to the left. Button 7 Move & stop scheduled in 10, 20 or 30 meters. This button allows us (sometimes that is not often) move a distance of 10, 20 or 30 meters. Any press is 10 meters long, two and three times moves 20 and 30 meters. It is an option that is rarely used. Button 8 - Emergency stop. Pressing this button stops the cart at one. Used to stop the cart when going at a slow gear or in an emergency, such as a possible hit to another player or a possible entry into a lake. PRECAUTIONS Never store the remote control in pants pocket without prior use of the disconnect button. It is extremely easy to activate the cart and move it to the right or left by pressing a key without you knowing it. It is obviously dangerous to the safety of persons and the maintenance of equipment. 13
VERY IMPORTANT The cable that serves as the handle of the control, is also the transmitting antenna. NEVER CUT THE ANTENNA. The distance of control coverage is determined by the remaining power in the battery, the terrain and the deployment of the antenna. Keep yourself relatively close to the cart when scroll the field. YES NO D) Recommendations On winding roads or pavements with solid materials (concrete, asphalt, tiles), feeder lines and difficult terrain, it is advisable to drive your cart manually. INSTRUCTIONS TO RUN WITHOUT REMOTE CONTROL Active start button (p. 9 ref. 3.1) and manually turn the Potenciometer (page 9, ref. 3.4) adjusting it to your liking. Stop your cart turning the potentiometer to its initial position of inactivity. 14
Use the TIMER button (p. 9 ref. 3.3) on the control panel for a scheduled progress of 10, 20 or 30 meters. Depending on the number of times the button (1, 2 or 3 times) is pressed will move the desired 10, 20 or 30 meters. BATTERY Your Carry golf has LITHIUM battery 24 Volt 10 Amp (24V / 10 Ah). In an optimal and fully charged state, allows to run a distance of approximately 36 holes, depending on the terrain and route field. Our recommendation is to charge the battery every 18 holes to playing golf with complete disregard for the state of charge of the battery. If you wish playing 27 or 36 holes in a row, the battery is ready to supply the necessary energy. No memory effect, allowing you to charge the battery without having to wait until it is in a low state of charge. Conventional lead-acid battery HAS memory effect. - Lifetime. Approximately 800 cycles or charges. A comparison that serves to understand how these batteries work, is to think that a "smart phone", is also equipped with a lithium battery. A golf course with steep slopes is comparable to a phone that makes a number of phone calls. More calls mean more battery consumption and steeper courts more battery consumption. Know your battery Lithium batteries require no special maintenance, just charge it every three months to keep it in optimum condition. 15
Charge your battery using the supplied charger. Most chargers are 12 V or 24 V, if you by mistake or distraction use a 24 V charger for a 12 V battery, will damage the battery. The waiting time for full charge is 4-5 hours. Admits the possibility of connection in any state of charge. The charger will end its function, once the maximum load detected. Remember to keep your battery charged before starting the tour with golf cart. In case of running out of battery power, change the position of the wheels to manual position. (See page 6). Recommendations: a) Recharge the battery before it runs out b) After the recharge, disconnect the battery charger. ELECTRIC BRAKE. "BRAKE SYSTEM". This mechanism makes us to be apart from most manufacturers. we are sure, you will be pleasantly surprised, as soon as you test our cart! Carrygolf incorporates in all its electric carts, a smart engine brake that automatically detects and reduces inertia generated when descending a slope, maintaining a gentle walking pace. Smart electric brake of your Carrygolf adjusts the speed drops and therefore the player will not need to keep the momentum of the cart. 16
DRIVING WITHOUT ELECTRICAL MOTOR. If you need to use your car without using the motor, move the wheels to the outer anchorage axis position (see p. 7). MAINTENANCE Your Carrygolf has a minimal maintenance. Here we detail various aspects to consider: 1) Cleaning To keep clean your cart, remove the battery and use a cloth dampened with water. Carefully dry the delicate parts. Do not use water or other liquids around control panel in the upper handle, the outer compartment of the motor as well as motor and battery connections. Do not use cleaning machines or pressure water hoses, as irretrievably damage electronic components, bearings, axles, engine and rear wheel clutches. Moisture in electronic parts can cause malfunctions and short circuits. 2) Grease Grease periodically spraying the front wheel bearing, both rear axles where the wheels are placed. (Remember to keep the left / right position of the rear wheels, as they are not interchangeable). 17
3) Adjust, front wheel alignment. It is an easy task, although it seems not. The front wheel alignment is important to ensure that the car is traveling in a straight line. If necessary, adjust the direction using two wrenches number 14. Loosen the nut opposite to the direction you want to correct. For example, if our cart is going to the right, with the help of the two wrenches, loosen the left nut. Then with the help of a nylon hammer move the axis forward with small hits onto it. Repeat if you have not got a perfect alignment. 4) Various Tighten periodically visible bolts around the cart. Keeping your tires in good condition will give greater grip on the field. When worn, you can find parts in our store and website. 18
TRANSPORT THE CART Carrying your golf cart is convenient and easy. The folding system reduces the size of LEOPARD for you to carry it in any small space in your vehicle. 3 rubber grommets are provided to stop the car, once folded, unfold while carrying by hand or in your car. Adjust to the desired size for rubber, with a simple knot. Your Carrygolf, brings two caps for axes. Their functions are: - Prevent grease stains inside of your vehicle or your golf cloths as we proceed to place or remove the wheels. - Prevent the shaft ends, tear any fabric during transport. We strongly recommend you to use them. 19
OFFICIAL TECHNICAL SERVICE: CARRYGOLF, SL Crtra. Sils C-63, Km 23 Santa Coloma de Farners 17430 Tel 972 843 084 WARRANTY Conditions and terms These products are warranted for CARRYGOLF, SL. the legal guarantee covered by Royal Legislative Decree 1/2007 November 16, revised text of the General Law for the Defence of Consumers and Users and other complementary laws. To access the security is essential to prove the purchase of the product by presenting of a bill or proof of purchase, and this warranty certificate. The warranty is extended to all countries where the product is distributed by Carrygolf SL.. This warranty is subject to the laws in force in Spain. Warranty Coverage 1 -. The warranty is for a period of 2 years from the time of delivery, except for the battery, that is for a period of 1 YEAR. 20
2.-conformity of the product according to the use for which it is intended guaranteed. 3 - Within the period of warranty, we will repair, free of charge, any malfunction of the device due to its manufacturing, either by repairing, replacing parts or the whole cart, provided that the chosen option is economically feasible and in accordance with our criterion. To qualify for repairing, the owner must send the cart to our authorized service point. 4 -. Repairing period will suspend the warranty period referred to in paragraph 1 above. The suspension period will start from the moment we receive the cart, until we deliver it to the buyer. Consequently, the warranty will be extended, during repairing time. Invalidation of warranty This warranty is void in cases of: misuse, improper use, tempting to repair it by unauthorized person, by the deterioration of the product due to external agents such as lime or other harmful, chemical, or obstructive corrosive due to inadequate maintenance, lack of cleaning or the use of non-original spare parts for the brand. Also not covered under this warranty any damage or failure caused by operating voltages and incorrect electrical installations. This warranty does not include: plastic or aesthetic pieces that are claimed by break after the first use. Also does not cover normal wear and tear or maintenance or replacement of parts such as wheels and tires. This product has been designed to sole and exclusive personal use and therefore the warranty does not cover professional use such as, rent, or use for unintended functionality. 21
This warranty does not affect the rights available to the operator pursuant to the provisions of Royal Decree 1/2007 of November 16, which approves the revised text of the General Law for the Defence of Consumers and Users For any questions or need assistance in the maintenance and / or operation of your Carrygolf, visit our website or contact us. 22
Dimensions, 23
Carrygolf, SL. c / Camprodon, 35 baixos CP 17430 Santa Coloma de Farners SPAIN Tel 972 843 084 info@ - www. 24