5 Series. Tractor Walk Around

Transcription

1 5 Series Tractor Walk Around

2 Tractor Walk Around To do list Before a Customer gets to the dealership make sure you do the following; 1. Have a Deutz Fahr key 2. Clean tractor 3. Check fuel level 4. Check all tractors functions work 5. Adjust seat and steering to a comfortable positon 6. Set steering angle at full lock

3 Tractor Walk Around START Over the next slides this booklet will give you an overview on the key selling points. To start the Walk Around start at the rear of the tractor and move in an anti clock-wise direction to finish up with the customer inside the tractor. Be confident in selling the product and good luck!

4 Tractor Walk Around REAR Remotes Mechanical sets of remotes as std 2. Float, Detent, and Kick out 3. Flow control on 1 set l/min Hyd flow at rear remotes Remotes Electro-Hyd 5130 FS/TTV 1. 3 sets of remotes as STD 2. Open centre Load Sensing 3. Flow control on 3 sets 4. Timer control on l/min at 1600rpm 6. Power beyond and load sensing Valve std

5 Tractor Walk Around REAR Three Point Linkage and Drawbar 1. Quick hitch ends kg lift capacity 3. Easy to use turnbuckle drop arms, one each side 4. Easy to use mechanical stabilisers with greasing points 5. Lower Link Draft sensing 6. Linkage Dampening when hitch is raised above 65% and travelling over 8km/h 7. Rear swinging heavy duty drawbar with multiple length settings to adjust for different PTO shafts

6 Tractor Walk Around REAR Rear Buttons on Guard 1. Green buttons are hitch Up and Down 2. Hold both Up & Down for 5 seconds to unlock hitch then linkage will raise and lower 3. Yellow button is PTO start and stop

7 Tractor Walk Around REAR Cab Suspension 1. Mechanically controlled maintenance free system 2. Operated by shocker and spring 3. Built in sway mechanism to give the operator a smooth ride

8 Tractor Walk Around REAR Easy to use maintenance 1. Easy view level Hydraulic/Transmission oil sight glass 2. Easy to fill Hydraulic oil located on top of lift cover 3. Located on rear left fender is the water reservoir for wipers

9 Tractor Walk Around SIDE Battery and Isolator switch 1. Easy to get to Battery, located under the step. 2. Isolator switch is a standard feature

10 Tractor Walk Around SIDE Cabin Air filter 1. Located at the top, 2 filters in total, one each side Easy to remove Side Pillar Exhaust 1. Located on the side giving clear view from cabin and also mounted with special shock system to allow movement with cabin.

11 Tractor Walk Around SIDE Engine Lift the hood up, you will need the key to activate button at front of the bonnet. Once the bonnet is lifted remove side panel. Key Features German Built Deutz Tier 4, 3.6 lt engine Maintenance free system with No Ad blue and No Diesel particulate filter Common Rail fuel system Horsepower hp

12 Tractor Walk Around SIDE Engine Maintenance 1. All maintenance inspection for engine on one side; Dipstick Oil filler Engine oil filter Two fuel filters Fuel Primer Coolant Reservoir

13 Tractor Walk Around SIDE Engine Key Features 1. Common Rail fuel injection Explodes the fuel at higher pressure. The engine burns the fuel more efficiently giving the operator a fuel saving 2. Poly vee self tension Fanbelt, longer life and less maintenance 3. Separate belt around Air Cond compressor - this is a benefit as a lot of competitors have one belt going around all pulleys. If Air Cond compressor seizes you can still operate tractor 4. Viscous Fan on radiator, will use less power than a normal fan and makes engine more fuel efficient

14 Tractor Walk Around SIDE Engine Easy to clean radiators 1. Slide out Radiator screens Easy to clean. DEMONSTRATE Radiator Pack Consists of; 1. Radiator 2. Transmission Cooler 3. Intercooler 4. Diesel fuel Cooler 5. Air Cond Condenser

15 Tractor Walk Around Front Engine Air Filter 1. Donaldson Dual Air filter element 2. Powercore filtration system to expel the dust Works like a Dyson Vacuum cleaner 3. Easy to clean and check

16 Tractor Walk Around Front Front Axle 1. Heavy Duty Front axle with 3600kg load rating degree turning tight turning circle 3. Twin power steering rams - operated by separate steering hydraulic pump 4. 4 wheel wet disc brakes gives proper stopping power, not operated by 4wd shaft. 5. Front and Rear Diff lock Gives true pulling, competition has a limited slip diff or none.

17 Tractor Walk Around Front Work lights and styling 1. Sloping and side angled bonnet to give clear view 2. Big Air intake 3. Plenty of work lights 4. Led drive lights like on car

18 Tractor Walk Around SIDE Front Axle Suspension - ONLY FS and TTV 1. Two rams that use Hydraulics and Nitrogen accumulator 2. Can turn On and Off 3. Low maintenance of suspension unit 4. Gives the operator a smoother ride in cabin

19 Tractor Walk Around SIDE Engine What is that Galvanised thing? Diesel Oxidation Catalyst (DOC) This is like a cars catalytic convertor - it is for the Tier 4 emissions and is a maintenance free system NO Ad blue or Diesel Particulate filter

20 Tractor Walk Around SIDE Fuel Tank 1. Large 165 Lt Capacity 2. Easy to fill with low nozzle level and big fill neck

21 Tractor Walk Around SIDE Adjustable Mirrors 1. These can be adjusted in and out and also have a safety hinge mechanism in case object hits mirror

22 Tractor Walk Around SIDE Cabin 1. Large non slip steps 2. Wide door entry for easy access 3. Double skin glass front quarter panels Reduces noise in Cabin

23 Tractor Walk Around Cabin Cabin Get customer to enter the cabin and sit in drivers seat, adjust steering wheel and start tractor. When in cabin start from the Powershuttle lever and work clock wise. First thing to do is explain the coloured controls ORANGE Driving YELLOW PTO BLUE Auxiliary Hydraulics GREEN Three point linkage

24 Tractor Walk Around Cabin Power Shuttle Forward /Reverse Power Shuttle Modulation control with 5 settings DEMONSTRATE All power shuttle info is displayed on A pillar monitor

25 Tractor Walk Around Cabin DASH 1. Easy to read dash work display 2. Analogue readout; Engine Speed Fuel gauge Operating temperature 3. Digital readout ; Hours of tractor Ground Speed PTO Speed Time

26 Tractor Walk Around Cabin STOP & GO SDD Steering (OPT) Front axle suspension (Profiline/TTV)

27 Tractor Walk Around Cabin A pillar display Shows direction of travel 2. Show the powershift speed selected 3. Shows the PTO Speed selected A pillar WORK Display - TTV This coloured work display shows the operator 1. Direction of travel 2. Powershift speed selected 3. PTO Speed selected 4. Ground speed 5. PTO speed 6. Headland management 7. Engine cruise control settings 1&2 8. Auxiliary Remotes with flow control and activation 9. Performance monitor to select this touch the ESC black button and rotate to black dial and touch to select (these buttons are located next to the engine throttle)

28 Tractor Walk Around Cabin RIGHT HAND CONSOLE Unlock of linkage and headland raise and lower Auxiliary Remotes 4WD and Diff lock buttons Gear stick 3 speed powershift and declutch button Three point linkage control unit Engine Throttle with 2 engine speed programmes PTO engagement & Auto PTO Gear Range lever

29 Tractor Walk Around Cabin Headland Management RIGHT HAND CONSOLE Profiline/TTV WORK display buttons Auxiliary Remotes Auxiliary Remotes Unlock Unlock of linkage and headland raise and lower ECO-Power Dial (TTV) 4WD, Diff lock & ASM Buttons Three point linkage control unit PTO engagement & Auto PTO Engine Throttle with 2 engine speed programmes

30 Tractor Walk Around Cabin GEAR STICK Powershift Models 1. 3 Speed Powershift 2. De clutch button On the go shifting 3. Auto Powershift (Profiline Models Only) De Clutch Button Powershift Buttons Auto Powershift Button

31 Tractor Walk Around Cabin Rapid Speed increaser Speed Increase/Decrease Joystick TTV Joystick Speed Cruise Control The TTV Joystick is easy to use! When showing and changing modes look at work display as information will be changing to correspond to the work mode Mode Button Manual PTO Auto

32 Tractor Walk Around Cabin Back Right Hand Corner of Cabin 1. Easy to get to sealed Fuse box 2. Euro 3 pin plug 3. ISO 7 pin plug to give implements ground speed 4. Easy access for cables and leads through to the cabin 5. Rear Inching 3 point linkage button

33 Tractor Walk Around Cabin Opening Rear window and rear quarter panel window 1. Plenty of view from Drivers seat to Drawbar 2. Rear window can partially open or open all the way 3. Rear quarter window opens to allow fresh air in

34 Tractor Walk Around Cabin PTO Speed Selector - Powershift 4 Speeds Normal & Economy 540 & 1000 PTO Speed Selector TTV 3 Speeds Ground Speed (optional) 540,750 & 1000

35 Tractor Walk Around Cabin Storage Compartments Plenty of storage compartments with a cooler box and drink holders

36 Tractor Walk Around Cabin Seating Padded trainee seat with adjustable backrest and seatbelt Deluxe Comfortable Air suspended seat

37 Tractor Walk Around Driving Cabin Roof Lining Hi Visibility Glass Roof Hi capacity Air-conditioning with 17 Vents Side and front glass demister vents Cab work light switches Interior worklight Front and Rear wipers/washers CD/Radio player with 4 speakers Two internal mirrors Front sunshade

38 Tractor Walk Around Cabin Key Points to show when Driving 1. Tight turning Circle 2. Visibility inside cabin 3. Quiet noise level 4. Engine Speed Programming 5. STOP & GO (Powershift models) 6. Power shuttle modulation 7. Smooth forward/reverse shuttle TTV TRANSMISSION 1. 3 modes Auto, PTO, Manual 2. Power Zero Control (Auto & PTO mode) Stays stopped without your feet on pedals and in forward or reverse 3. Power dial when in Auto mode Change parameters when driving to see engine revs change but speed stays the same 4. Setting the Speed Cruise control