BAYLIFT SERVICE MANUAL
|
|
- Roger Collin Bryant
- 5 years ago
- Views:
Transcription
1 -PRINT- MARCH TABLE OF CONTENTS- INTRODUCTION I. INTRODUCTION T he RICON BayLift Public Use wheelchair lift is intended to provide wheelchair access to public vehicles including buses, school buses, large multi-purpose passenger vehicles, and is DOT compliant. For proper operation, it is imperative that the lift operator be thoroughly familiar with the major components of the unit, the controls and their functions, operation of the unit, and the safety and warning features. This lift is for the physically challenged only and must be operated by trained personnel. The mechanical linkages provide smooth movement to the platform, which has a rated load capacity of 600 pounds (273 kilograms). Use of this lift for any other purpose is hazardous. NOTE: The lift is not to be used for lifting cargo or freight. To do so might overload the mechanism, making the system unsafe for passengers, and will instantly void the warranty. Five hydraulic cylinders are employed to move the lift components. Two cylinders are mounted within the scissors assembly to extend and retract the platform assembly. A third cylinder raises and lowers the inner barrier. The remaining two cylinders raise and lower the platform assembly. The movement of these cylinders is multiplied by a chain lift connected between the intermediate frame (rear portion of platform assembly) and the platform itself. As the cylinders lift the intermediate frame the chain lift doubles the movement of the platform assembly. The lift contains an electro-hydraulic pump with a built-in manual backup pump. If the lift loses electrical power, it can be raised or lowered manually. The cylinders are controlled by solenoid valves that are operated manually if there is an electrical failure. Platform movement is controlled with buttons on the hand held pendant. By using the buttons, the lift is extracted from the vehicles storage compartment and lowered to the ground level. The passenger boards the large non-skid platform and the operator uses the buttons to raise the platform to vehicles floor level. After the passenger departs, the platform is raised and retracted back into the vehicle. A similar procedure is used to exit. This manual contains installation instructions, maintenance and repair instructions; a troubleshooting guide, and parts and diagram lists. It is important to user safety that the lift is operated by trained personnel. Once the lift is installed, it is very important that the lift be properly maintained by following the Ricon recommended maintenance and inspection instructions provided. A. RICON PRODUCT SUPPORT If you have questions about this manual, or additional copies are needed, please contact Ricon Product Support at one of the following locations: Ricon Corporation 1135 Aviation Place San Fernando, CA (818) Outside (818) Area Code... (800) Website... Vapor Ricon Europe Ltd. Meadow Lane Loughborough, Leicestershire (9) LE 1HS United Kingdom Website
2 INTRODUCTION MARCH 2014 B. RICON BAYLIFT LIMITED WARRANTY RICON CORPORATION BAYLIFT PUBLIC WHEELCHAIR LIFT TWO-YEAR LIMITED WARRANTY Ricon Corporation (Ricon) warrants to the original purchaser of this product that Ricon will repair or replace, at its option, any part that fails due to defective material or workmanship as follows: Repair or replace parts for a period of two (2) years from the date of lift purchase. Labor costs for specified parts replaced under this warranty for a period of two (2) years from the date of lift purchase. A Ricon rate schedule determines parts covered and labor allowed. If you need to return a product: Return this product to Ricon, following the Ricon RMA procedure. Please give as much advance notice as possible, and allow a reasonable amount of time for repair. This warranty does not cover: Malfunction or damage to product parts caused by accident, misuse, lack of proper maintenance, neglect, improper adjustment, modification, alteration, the mechanical condition of the vehicle, road hazards, overloading, failure to follow operating instructions, or acts of nature (i.e., weather, lightning, flood). Note: Ricon recommends that this product be inspected by a Ricon dealer or qualified service technician at least once every six months, or sooner if necessary. Required maintenance should be performed at that time. WARNING THIS PRODUCT HAS BEEN DESIGNED AND MANUFACTURED TO EXACT SPECIFICATIONS. ANY MODIFICATION OF THIS PRODUCT IN ANY RESPECT CAN BE DANGEROUS. This warranty is void if: The product has been installed or maintained by someone other than a Ricon dealer or qualified service technician. The product has been modified or altered in any respect from its original design without written authorization by Ricon. Ricon disclaims liability for any personal injury or property damage that results from operation of a Ricon product that has been modified from the original Ricon design. No person or company is authorized to change the design of this Ricon product without written authorization by Ricon. Ricon's obligation under this warranty is exclusively limited to the repair or exchange of parts that fail within the applicable warranty period and the authorized labor to accomplish said repair. Ricon assumes no responsibility for expenses or damages, including incidental or consequential damages. Some states do not allow the exclusion or limitation of incidental or consequential damages, so the above limitation or exclusion may not apply. Important: The warranty registration card must be completed and returned to Ricon within 20 days after installation of this Ricon product for the warranty to be valid. The warranty is not transferable. The warranty gives specific legal rights. There may be other rights that vary in each state. 1-2
3 MARCH 2014 INTRODUCTION C. SHIPMENT INFORMATION When the product is received, unpack the product and check for freight damage. Claims for damage should be made to the freight carrier immediately. Be sure the installation kit contains all items listed on the kit packing list. Please report any missing items immediately to Ricon Product Support. The warranty and owner registration cards must be completed and returned to Ricon within 20 days to validate the warranty. NOTE: The Sales or Service personnel must review the Warranty and this Operator Manual with the user to be certain that they understand how to safely operate the product and instruct the user to follow the operating instructions without exception. D. GENERAL SAFETY PRECAUTIONS The following general safety precautions must be followed during installation, operation, and maintenance: Under no circumstances should installation, maintenance, repair, and adjustments be attempted without the immediate presence of a person capable of rendering aid. An injury, no matter how slight, should always be attended. Always administer first aid or seek medical attention immediately. Protective eyeshields and appropriate clothing should be worn at all times. To avoid injury, always exercise caution when operating and be certain that hands, feet, legs, and clothing are not in the path of product movement. Batteries contain acid that can burn. If acid comes in contact with skin, flush affected area with water and wash with soap immediately. Always work in a properly ventilated area. Do not smoke or use an open flame near a battery. Do not lay anything metallic on top of a battery. Check under vehicle before drilling to avoid drilling into frame, subframe members, wiring, hydraulic lines, fuel lines, fuel tank, etc. Read and thoroughly understand the operating instructions before attempting to operate. Inspect the product before each use. If an unsafe condition is noted, such as unusual noises or movements, do not use lift until the problem is corrected. Never load or stand on the platform until installation is complete. Upon completion of installation, test load the lift to 100% of its rated load capacity. Stand clear of doors and platform and keep others clear during operation. The product requires regular periodic maintenance. Inspections are recommended at the intervals prescribed in chapter three. The product must be maintained at the highest level of performance. 1-3
4 INTRODUCTION MARCH 2014 E. MAJOR LIFT COMPONENTS The references used throughout this manual are illustrated in Figures 1-1, 1-2 and defined in the Tables 1-1, 1-2. Refer to Chapter IV Parts Diagrams and Lists for more details. CYCLE COUNTER ELECTRONIC CONTROLLER CYCLE COUNTER VIEWPORT INTERMEDIATE FRAME ACCESS PANEL HYDRAULIC CONTROLLER RESERVOIR DIPSTICK PLATFORM FRAME HANDRAIL MANUAL BACK-UP PUMP SAFETY BELT MANUAL PRESSURE RELEASE VALVE PENDANT HOLDERS SCISSORS ASSY PLATFORM LATCH MAINTENANCE SAFETY PIN BRIDGEPLATE HANDRAIL LATCH FRONT ROLLSTOP CONTROL PENDANT FRONT AND REAR PLATFORM SECTIONS FRONT ROLLSTOP LATCH ITW FIGURE 1-1: BAYLIFT PUBLIC USE WHEELCHAIR LIFT COMPONENTS RSM
5 MARCH 2014 INTRODUCTION TERM Left, right, front, rear Access panel Audible alarm Bridgeplate Control pendant Cycle counter viewport Electronic controller Front and rear platform sections Front rollstop Front rollstop latch Handrail Handrail latch Hydraulic controller Hydraulic pump and reservoir Intermediate frame Maintenance safety pin Manual backup pump handle Manual bypass knobs Manual pressure release valve Pendant holders Platform frame Platform latch Reservoir dipstick TABLE 1-1: BAYLIFT TERM DEFINITIONS DESCRIPTION Position references when installed lift is viewed from outside of vehicle. Provides easy access to components located behind intermediate frame. (not shown) Announces that something has passed through doorway threshold area and platform. Is 71 from vehicle floor level. Activated by threshold warning system (TWS). Refer to Threshold Warning System in Chapter II. Plate bridges gap between platform and vehicle floor when platform is at floor level. Acts as rear barrier during up and down platform motions to prevent wheelchair from rolling off of platform. Hand-held device controls platform motions. The counter can be seen here. It records number of times platform has moved from floor to ground and back to floor. Receives input signals from pendant and lift sensors and sends control signals to pump motor and hydraulic controller. Lift components where wheelchair and occupant are situated during UP and DOWN platform motions. Folds and stows into platform frame. Front barrier prevents the wheelchair from inadvertently rolling off platform during platform movement. Manually operated latch locks front rollstop in stowed position. Rollstop is locked in upright position by dropping into slots. (left and right) Provides a handhold for standing passenger (standee). (left and right) Manually operated latch locks handrail in outward or inward position. Push handrail downward to release latch. Electro-hydraulic, solenoid valve system controls distribution of hydraulic fluid to cylinders. Receives input signals from electronic controller. Hydraulic pump is driven by electric motor and produces pressure to extend and raise platform and to raise bridgeplate. Includes manual backup components. Rigid structure suspended on outer ends of scissor assembly. Platform frame is attached to front face. (left and right) Maintenance item that is employed to lock platform in position on intermediate frame. Must be removed for normal operation. Use to operate manual backup pump when electrical power is not available. Four knobs are employed during manual operation to control distribution of hydraulic fluid to preferred lift cylinders. Opening valve bleeds pressure from hydraulic system, allowing platform or bridgeplate to lower. (up to three each, depending on application) Storage clips for pendant. One clip is attached to bottom of platform. Structure that platform and handrails attach to. Moves up and down on sliders fastened to intermediate frame. Magnetic catch that holds folded platform sections in upright position. Use to determine fluid level in reservoir. 1-5
6 INTRODUCTION MARCH 2014 TERM Safety belt Scissors assembly Visual alarm TABLE 1-1: BAYLIFT TERM DEFINITIONS DESCRIPTION Safety restraint belt that spans between handrails to confine passenger. (left and right) Telescoping components that support intermediate frame and platform, and allow horizontal movement. (not shown) Flashing red light makes it known that something has passed through doorway threshold area. Activated by threshold warning system (TWS). Refer to Threshold Warning System in Chapter II. END OF TABLE -BACK TO TOP NEXT CHAPTER-
The RICON S-Series Personal Use Wheelchair Lift provides wheelchair access to personal
I. INTRODUCTION The RICON S-Series Personal Use Wheelchair Lift provides wheelchair access to personal vans. The patented movement provides smooth, safe entry and exit and easily lifts up to 800 pounds
More informationRicon Corporation 7900 Nelson Road Panorama City, CA (818) Outside (818) Area Code...(800)
I. F9T INTRODUCTION S afe and easy access to mass-transit vehicles is provided by the RICON Mirage F9T Transit Use Wheelchair and Standee Lift. Refer to Figures 1-1 and 1-2. This manual covers both Dedicated
More informationInnovation in Mobility. R1208 Six-Way Power Seat Base. Operator Manual. 03/25/02 32DSB01.A RICON CORPORATION All Rights Reserved
Innovation in Mobility R1208 Six-Way Power Seat Base Operator Manual 03/25/02 32DSB01.A 92-2002 RICON CORPORATION All Rights Reserved Printed in the United States of America This RICON product must be
More informationRDO2900 Series Internal Power Swing Door Operator
Innovation in Mobility RDO2900 Series Internal Power Swing Door Operator Operator Manual 02/14/02 92-2002 RICON CORPORATION All Rights Reserved U.S. and foreign patents pending Printed in the United States
More informationOperator Manual riconcorp.com
TITANIUM LINE S-SERIES AND K-SERIES DOT PUBLIC USE LIFTS Operator Manual riconcorp.com 05/15/12 32DSKF01.A 2012 RICON CORPORATION All Rights Reserved U.S. Patent Nos: 4,534,450; 5,228,538; 5,308,215; 5,373,915;
More informationK-Series DOT Public Use Lift
K-Series DOT Public Use Lift OPERATOR MANUAL 10/10/11 32DSSK05.C 2011 RICON CORPORATION All Rights Reserved U.S. and Foreign Patents Pending Printed in the United States of America This RICON product must
More informationPhantom. Thin-Profile Commercial Wheelchair Lift. Innovation in Mobility OPERATOR MANUAL
Innovation in Mobility Phantom Thin-Profile Commercial Wheelchair Lift OPERATOR MANUAL 05/21/04 ª2004 RICON CORPORATION All Rights Reserved U.S. and Foreign Patents Pending Printed in the United States
More informationBAYLIFT DOT PUBLIC USE
BAYLIFT DOT PUBLIC USE SERVICE MANUAL -PRINT- 03/24/14 32DBLE04.C.1 -HOME- 2014 RICON CORPORATION All Rights Reserved U.S. and Foreign Patents Pending. Printed in the United States of America MARCH 2014
More informationK-Series DOT Private Use Lift
K-Series DOT Private Use Lift OPERATOR MANUAL -PRINT- 10/15/11 32DSSK03.C 2011 RICON CORPORATION All Rights Reserved U.S. and Foreign Patents Pending Printed in the United States of America -HOME- This
More informationCAUTION -TABLE OF CONTENTS- II. OPERATING INSTRUCTIONS
-PRINT- -TABLE OF CONTENTS- II. OPERATING INSTRUCTIONS his chapter contains safety precautions, daily safety check instructions, control and indicator descriptions, and operating instructions that apply
More informationS-SERIES PUBLIC USE OPERATING INSTRUCTIONS
-PRINT- II. T S-SERIES PUBLIC USE OPERATING INSTRUCTIONS -TABLE OF CONTENTS- his chapter contains safety precautions, daily safety check instructions, control and indicator descriptions and operating instructions
More informationS-Series Personal Use Lift
S-Series Personal Use Lift -PRINT- Operator Manual 10/15/11 -HOME- 2011 RICON CORPORATION All Rights Reserved U.S. Patent Nos: 4,534,450; 5,308,215; 5,445,488; 5,605,431; 5,944,473 Australian Patent No:
More informationK-SERIES PUBLIC USE LIFT OPERATING INSTRUCTIONS
-PRINT- II. T K-SERIES PUBLIC USE LIFT OPERATING INSTRUCTIONS -TABLE OF CONTENTS- his chapter contains safety precautions, daily safety check instructions, control and indicator descriptions, and operating
More informationS-Series Transit Use (ADA) Wheelchair and Standee Lift
INNOVATION IN MOBILITY S-Series Transit Use (ADA) Wheelchair and Standee Lift PRINT TM 05/16/01 Printed in the United States of America Operator Manual 92-02 RICON CORPORATION All Rights Reserved U.S.
More informationThis chapter contains safety precautions, daily safety check instructions, control and indicator
III. OPERATING INSTRUCTIONS This chapter contains safety precautions, daily safety check instructions, control and indicator descriptions and operating instructions for the RICON S-Series Export Use Wheelchair
More informationS-SERIES ADA TRANSIT USE OPERATING INSTRUCTIONS
-PRINT- II. T S-SERIES ADA TRANSIT USE OPERATING INSTRUCTIONS -TABLE OF CONTENTS- his chapter contains safety precautions, daily safety check instructions, control and indicator descriptions, and operating
More informationII. W-SERIES WHEELCHAIR LIFT OPERATING INSTRUCTIONS T
II. W-SERIES WHEELCHAIR LIFT OPERATING INSTRUCTIONS T his chapter contains safety precautions, daily safety check instructions, control and indicator descriptions and operating instructions for the RICON
More informationS-Series Transit Use Wheelchair Lift
S-Series Transit Use Wheelchair Lift 10/10/11 Printed in the United States of America -PRINT- OPERATOR MANUAL -HOME- U.S. Patent Nos: 5,228,538; 5,308,215; 5,373,915; 5,445,488; 5,605,431; 5,944,473 Australian
More informationS-Series Transit Use (ADA) Wheelchair and Standee Lift
S-Series Transit Use (ADA) Wheelchair and Standee Lift 10/10/11 Printed in the United States of America -PRINT- Operator Manual 2011 RICON CORPORATION All Rights Reserved -HOME- U.S. Patent Nos: 5,228,538;
More informationOPERATING INSTRUCTIONS
II. T OPERATING INSTRUCTIONS his chapter contains safety precautions, a daily safety check, a description of lift functions, control and indicator descriptions, plus operating instructions for both the
More informationMirage F9B Series Personal Use Wheelchair Lift
Innovation in Mobility Mirage F9B Series Personal Use Wheelchair Lift Operator Manual 12/03/01 32DF9BP01.A 1999-2001 RICON CORPORATION U.S. Patent Nos. 5,228,538; 5,253,973; 5,373,915; 5,556,250; Australian
More informationS-SERIES AND K-SERIES EXPORT USE WHEELCHAIR AND STANDEE LIFT PRINT. Service Manual. 05/15/15 32DSKE02.C 2015 RICON CORPORATION All Rights Reserved
S-SERIES AND K-SERIES EXPORT USE WHEELCHAIR AND STANDEE LIFT S-Series K-Series PRINT Service Manual 05/15/15 2015 RICON CORPORATION All Rights Reserved HOME U.S. Patent Nos: 4,534,450; 5,228,538; 5,308,215;
More informationCustomer Name: Installing Dealer: Date Installed: Serial Number:
PRINT This VMI product must be installed and serviced by authorized VMI service technicians. The operator must refer to this manual for operating instructions, and retain it for future reference. DOT Private
More informationS-SERIES AND K-SERIES DOT PUBLIC USE LIFT
TITANIUM LINE S-SERIES AND K-SERIES DOT PUBLIC USE LIFT Service Manual -PRINT- 11/03/15 2015 RICON CORPORATION -HOME- All Rights Reserved U.S. Patent Nos: 4,534,450; 5,308,215; 5,445,488; 5,605,431; 5,944,473;
More informationMIRAGE F9TF DOT - PUBLIC USE LIFT
MIRAGE F9TF DOT - PUBLIC USE LIFT -Print- SERVICE MANUAL 04/18/16 -Home- 2016 RICON CORPORATION All Rights Reserved U.S and Foreign Patents Pending Printed in the United States of America APRIL 2016 TABLE
More informationMIRAGE F9TF DOT - PUBLIC USE LIFT
MIRAGE F9TF DOT - PUBLIC USE LIFT PRINT SERVICE MANUAL 03/09/05 1995-2005 RICON CORPORATION All Rights Reserved U.S and Foreign Patents Pending Printed in the United States of America This Ricon service
More informationMIRAGE F9TF DOT - PUBLIC USE LIFT
MIRAGE F9TF DOT - PUBLIC USE LIFT SERVICE MANUAL 08/31/15 2015 RICON CORPORATION All Rights Reserved U.S and Foreign Patents Pending Printed in the United States of America AUGUST 2015 TABLE OF CONTENTS
More informationThe RICON Eclipse F8000 (A) Series Export Use Wheelchair and Standee Lift is installed in a
II. INSTALLATION TABLE OF CONTENTS The RICON Eclipse F8000 (A) Series Export Use Wheelchair and Standee Lift is installed in a cassette mounted to the underside of the vehicle and behind the bottom step
More informationRaydot LLC 24 Actuator (115 VOLT)
Installation, Operation & Parts Manual Read carefully the information provided. Retain manual for future reference. Raydot LLC 24 Actuator (115 VOLT) 145 Jackson Ave. S. Cokato, MN 55321-USA (320) 286-2103
More informationK-SERIES SERVICE MANUAL
MARCH 2011 III. R MAINTENANCE AND REPAIR MAINTENANCE egular maintenance of the Ricon KlearVue Series platform wheelchair lift is required to help optimize its performance and reduce the need for repairs.
More informationService Bulletin No. 2905
MODEL TYPE SECTION/GROUP DATE E4500 / J4500 Series Coaches Service Information 22-Wheelchair Lift May 4, 2005 SUBJECT R ICON W HE E L CHAIR L IF T OPE R AT ION CONDITIONS Service Information Only Description:
More information24 Linear Actuator 115 Volts A.C. (Cat. # C430A)
Installation, Operation & Parts Manual Read carefully the information provided. Retain manual for future reference. 24 Linear Actuator 115 Volts A.C. (Cat. # C430A) Page 1 of 8 IS10007.doc 11/15/06 IMPORTANT!
More informationFIGURE 2-1: LIFT (LEFT-SIDE) MOUNTING HOLES
II. INSTALLATION T he RICON Mirage F9A Series Transit Use Wheelchair and Standee Lift is installed in a cassette mounted to the underside of the vehicle and behind the bottom step riser. Due to the wide
More information20A Solar Charge Controller
Item no. 2511 20A Solar Charge Controller User s Manual 20A Solar Charge Controller by Wagan Tech Thank you for purchasing the 20A Solar Charge Controller by Wagan Tech. With normal care and proper treatment
More informationMODEL A96 SERIES. 130Vdc Switchmode Utility Rectifier / Battery Charger. Used with LaMarche Power Cage ECN/DATE
MODEL A96 SERIES 130Vdc Switchmode Utility Rectifier / Battery Charger Used with LaMarche Power Cage CPN112138 ECN/DATE ISSUE DATE: ECN 17010-12/05 106 BRADROCK DRIVE DES PLAINES, IL. 60018-1967 (847)
More informationMODEL A97 SERIES. Switchmode Utility Rectifier/Battery Charger ECN/DATE
MODEL A97 SERIES Switchmode Utility Rectifier/Battery Charger CPN108172 ISSUE DATE: 16071 7/03 ECN/DATE 106 BRADROCK DRIVE DES PLAINES, IL. 60018-1967 (847) 299-1188 FAX: (847)299-3061 Page 1 of 7 INSTRUCTION
More informationSAFETY GUIDELINES. Please fill out the following information for quick reference: Pride Provider: Address: Phone Number:
Caddy SAFETY GUIDELINES The symbols below are used throughout this owner's manual and on the product to identify warnings and important information. It is very important for you to read them and understand
More informationRegular maintenance of the RICON S-Series Transit Use Wheelchair Lift will help optimize its
IV. MAINTENANCE AND REPAIR Regular maintenance of the RICON S-Series Transit Use Wheelchair Lift will help optimize its performance and reduce the need for repairs. This chapter contains cleaning and lubrication
More informationA48 / A48B (base plate) BATTERY CHARGER
A48 / A48B (base plate) BATTERY CHARGER CPN41054 ISSUE DATE: 12315-8/98 ECN/DATE 106 BRADROCK DRIVE DES PLAINES, IL. 60018-1967 (847) 299-1188 FAX: (847)299-3061 15349-07-07/02 16041 6/03 14575-2/01 INSTRUCTION
More informationWARNING WARNING CAUTION
IV. REPAIR T his chapter provides instructions for the major systems adjustment, repair, and replacement of the RICON Mirage F9A Series Transit Use Wheelchair and Standee Lift. A. GENERAL SAFETY PRECAUTIONS
More informationWARNING! THIS PRODUCT MUST BE INSTALLED BY A TRAINED, AUTHORIZED RICON SERVICE TECHNICIAN.
II. INSTALLATION T he chapter provides instructions for installing the RICON RDO2900 Series Internal Power Swing Door Operator into full-size 1992 and later Ford vans, 1990 and later Chevrolet & GMC vans,
More information2000 lb Adjustable Gantry Crane
2000 lb Adjustable Gantry Crane Owner s Manual WARNING: Read carefully and understand all ASSEMBLY AND OPERATION INSTRUCTIONS before operating. Failure to follow the safety rules and other basic safety
More informationLumina 28 Traction Drive Model: Battery Burnisher M28036TDQP OPERATION SERVICE PARTS CARE
Lumina 28 Traction Drive Model: Battery Burnisher M28036TDQP OPERATION SERVICE PARTS CARE Table of Contents IMPORTANT SAFETY INSTRUCTIONS...1 OPERATING INSTRUCTIONS...2 INSPECTION...2 ELECTRICAL...2 BATTERIES...2
More informationHydraulic Drum Transporter
Hydraulic Drum Transporter Owner s Manual WARNING: Read carefully and understand all ASSEMBLY AND OPERATION INSTRUCTIONS before operating. Failure to follow the safety rules and other basic safety precautions
More informationAmerican Crescent Elevator's Lula Lift
's Lula Lift American Crescent Elevator Mfg., Corp. 310 Stephens Street Picayune, Ms. 39466 Phone (800) 748-9711 or Fax (601) 798-9392 Introduction Congratulations... we welcome you as a new American Crescent
More informationWheelchair Trailer Lift Operations & Parts Manual Maintenance Schedule
Wheelchair Trailer Lift Operations & Parts Manual Maintenance Schedule Keith Consolidated Industries www.kcigse.com 541-830-8678 1718 Antelope Rd. White City, OR 97502 Table of Contents Overview 2 Operations
More information1000 lb. Adjustable Gantry Crane
1000 lb. Adjustable Gantry Crane Owner s Manual WARNING: Read carefully and understand all ASSEMBLY AND OPERATION INSTRUCTIONS before operating. Failure to follow the safety rules and other basic safety
More informationInnovation in Mobility
R Innovation in Mobility FOLDOVER RAMP Low-Floor Vehicle Access Ramp for GILLIG PRINT SERVICE MANUAL 09/23/02 ª95-2001 RICON CORPORATION All Rights Reserved U.S and Foreign Patents Pending Printed in the
More informationV. SPACEPRO SPARE PARTS
V. SPACEPRO SPARE PARTS T his chapter contains parts illustrations and parts lists for the RICON SpacePro (HC-L series) Motor Coach Wheelchair and Standee Lift. Each exploded view of a major lift assembly
More informationBAYLIFT MODEL AND KIT NUMBERS
-PRINT- MARCH 2014 - TABLE OF CONTENTS- SPARE PARTS IV. SPARE PARTS T his chapter contains parts illustrations and lists for the Ricon BayLift Public use wheelchair lift. Each exploded view of a major
More informationLESTRONIC II BATTERY CHARGER BUILT-IN OR PORTABLE CHARGERS
LESTRONIC II BATTERY CHARGER BUILT-IN OR PORTABLE CHARGERS PLEASE SAVE THESE IMPORTANT SAFETY AND OPERATING INSTRUCTIONS For correct operation of the equipment, it is important to read and be familiar
More informationSawhorse with Chainsaw Holder
Sawhorse with Chainsaw Holder Owner s Manual Chainsaw not included. WARNING: Read carefully and understand all ASSEMBLY AND OPERATION INSTRUCTIONS before operating. Failure to follow the safety rules and
More informationHL5-7K PLATFORM LIFT INSTRUCTIONS
HL5-7K PLATFORM LIFT INSTRUCTIONS REIMANN & GEORGER CORPORATION MARINE PRODUCTS BUFFALO, NY P/N 6114205 10/16/14 TABLE OF CONTENTS CHAPTER TITLE PAGE 1 SAFETY... 1 1.1 Introduction... 1 1.2 Safety Definitions...
More informationHL4K PONTOON LIFT INSTRUCTIONS
HL4K PONTOON LIFT INSTRUCTIONS REIMANN & GEORGER CORPORATION MARINE PRODUCTS P/N 6114179 5/02/14 BUFFALO, NY TABLE OF CONTENTS CHAPTER TITLE PAGE 1 SAFETY... 1 1.1 Introduction... 1 1.2 Safety Definitions...
More informationLESTRONIC II BATTERY CHARGER MODEL 19740
*01679* LESTRONIC II BATTERY CHARGER MODEL 19740 PLEASE SAVE THESE IMPORTANT SAFETY AND OPERATING INSTRUCTIONS For correct operation of the equipment, it is important to read and be familiar with this
More informationCAUTION CAUTION MAINTENANCE AND REPAIR A. LUBRICATION
III. R MAINTENANCE AND REPAIR egular maintenance of the Ricon KlearVue Series platform wheelchair lift is required to help optimize its performance and reduce the need for repairs. This chapter contains
More informationHL4K PLATFORM LIFT INSTRUCTIONS
HL4K PLATFORM LIFT INSTRUCTIONS REIMANN & GEORGER CORPORATION MARINE PRODUCTS P/N 6114--- 6/19/15 BUFFALO, NY TABLE OF CONTENTS CHAPTER TITLE PAGE 1 SAFETY... 1 1.1 Introduction... 1 1.2 Safety Definitions...
More informationAngle Grinder Holder
Angle Grinder Holder Owner s Manual WARNING: Read carefully and understand all ASSEMBLY AND OPERATION INSTRUCTIONS before operating. Failure to follow the safety rules and other basic safety precautions
More information4-LED Solar-Powered Pendant Shed Light
4-LED Solar-Powered Pendant Shed Light Owner s Manual WARNING: Read carefully and understand all ASSEMBLY AND OPERATION INSTRUCTIONS before operating. Failure to follow the safety rules and other basic
More informationKlearVue K-Series Folding Platform DOT Private Use Lift
KlearVue K-Series Folding Platform DOT Private Use Lift PRINT SERVICE MANUAL 09/20/05 95 2005 RICON CORPORATION All Rights Reserved U.S. and foreign patents pending Printed in the United States of America
More informationOwner s Manual & Safety Instructions
Owner s Manual & Safety Instructions Save This Manual Keep this manual for the safety warnings and precautions, assembly, operating, inspection, maintenance and cleaning procedures. Write the product s
More informationINSTRUCTION MANUAL FOR PC63 CAGE
INSTRUCTION MANUAL FOR PC63 CAGE CPN106833 ISSUE DATE: 15689-12/02 ECN/DATE 106 BRADROCK DRIVE DES PLAINES, IL. 60018 (847) 299-1188 FAX: (847) 299-3061 16816-6/05 INSTRUCTION DRAWING NUMBER: P25-LPC63-1
More informationInstallation Guide Document N Cleanroom Mirrors Copyright 2016 Terra Universal Inc. All rights reserved. Revised November 2016
Document N0. 1800-09 Copyright 2016 Terra Universal Inc. All rights reserved. Revised November 2016 Terra Universal, Inc. TerraUniversal.com 800 S. Raymond Ave. Fullerton, CA 92831 TEL: (714) 578-6000
More informationAdjustable Steel Welding Table
Adjustable Steel Welding Table Owner s Manual WARNING: Read carefully and understand all ASSEMBLY AND OPERATION INSTRUCTIONS before operating. Failure to follow the safety rules and other basic safety
More information1000-lb Hydraulic Truck Crane
1000-lb Hydraulic Truck Crane Owner s Manual WARNING: Read carefully and understand all ASSEMBLY AND OPERATION INSTRUCTIONS before operating. Failure to follow the safety rules and other basic safety precautions
More informationSlide-Away Personal Wheelchair Lift DOT - Private Use Lift -PRINT-
Slide-Away Personal Wheelchair Lift DOT - Private Use Lift -PRINT- This VMI product must be installed and serviced by VMI authorized dealers. The owner must refer to this manual for operating instructions,
More informationG500REC Manual Covering System for Containers
10 Boulder Parkway N. Oxford, MA 01537 866-353-5826 pioneersales@wastequip.com www.pioneercoverall.com G500REC Manual Covering System for Containers Installation Manual WARNING: In order to prevent damage,
More informationWP-400 Series Electric Work Platforms Instruction Manual
VESTIL MANUFACTURING CORP. 2999 North Wayne Street, P.O. Box 507, Angola, IN 46703 Telephone: (260) 665-7586 -or- Toll Free (800) 348-0868 Fax: (260) 665-1339 www.vestilmfg.com e-mail: sales@vestil.com
More informationHydraulic Bead Breaker Kit
Hydraulic Bead Breaker Kit Owner s Manual WARNING: Read carefully and understand all ASSEMBLY AND OPERATION INSTRUCTIONS before operating. Failure to follow the safety rules and other basic safety precautions
More informationINSTALLATION INSTRUCTIONS AND OWNER S MANUAL
INSTALLATION INSTRUCTIONS AND OWNER S MANUAL Thank you for purchasing the AlloyCover from WeatherTech. Manufactured with pride using superior quality materials and workmanship. With proper care, your cover
More informationHeavy-Duty Drywall Dolly Cart
Heavy-Duty Drywall Dolly Cart Owner s Manual WARNING: Read carefully and understand all ASSEMBLY AND OPERATION INSTRUCTIONS before operating. Failure to follow the safety rules and other basic safety precautions
More informationHydraulic Transmission Jacks
Hydraulic Transmission Jacks Operating Instructions & Parts Manual Model Number Atd-7435 Atd-7436 Atd-7437 Capacity 1100 Lb. 2000 Lb. 3000 Lb. Model Atd-7435 Model Atd-7436 Model Atd-7437 Atd Tools Inc.
More informationPOWER GEAR SLIDE-OUT MANUAL
POWER GEAR SLIDE-OUT MANUAL Operation Guide FLUSH FLOOR SLIDE-OUT SYSTEM FOR AMERICAN COACH PRODUCTS 82-S0220-01 Rev. 1 AMERICAN COACH SLIDE-OUT MANUAL FLUSH FLOOR SYSTEM TABLE OF CONTENTS SECTION PAGE
More informationCanopy Frame Assembly Instructions
Canopy Frame Assembly Instructions 14 Foot // 22 Foot // 24 Foot // 26 Foot // 28 Foot // 30 Foot // 32 Foot INTRODUCTION The Starr line of Boat Lift Canopy Frames by Great Lakes Entry Systems has been
More informationDeluxe Hitch 3-Bike Rack Instructions for Part # BC-3581
General Guidelines Deluxe Hitch 3-Bike Rack Instructions for Part # BC-3581 It is the user s responsibility to read and follow all instructions. Keep these instructions with the product at all times and
More informationHeavy Duty Engine Cranes
Heavy Duty Engine Cranes Operating Instructions & Parts Manual Model Number Atd-7484 Atd-7485 (Foldable Legs) Capacity 2 Ton 2 Ton Model Atd-7484 Model Atd-7485 Atd Tools Inc. 160 Enterprise Drive, Wentzville,
More informationOwners Manual. LifeGuard Power Lift Model # Rev. 2/1/13
Owners Manual LifeGuard Power Lift Model #100287 Rev. 2/1/13 Table of Contents 1. ASSEMBLY INSTRUCTIONS 3-5 A. Lift Assembly 3 B. Setup 3 1. Clinch Pin Location Drawings 4 2. Down Tube and Seat Assembly
More information2000-lb Hand Winch Truck Crane
2000-lb Hand Winch Truck Crane Owner s Manual WARNING: Read carefully and understand all ASSEMBLY AND OPERATION INSTRUCTIONS before operating. Failure to follow the safety rules and other basic safety
More informationSAVE THESE INSTRUCTIONS
12 Volt High-V Volume Air Inflator Owner s Manual WARNING: Read carefully and understand all ASSEMBLY AND A OPERATION INSTRUCTIONS before operating. Failure to follow the safety rules and other basic safety
More informationMOTORIZED FOLDING CAMPER WINCH
OWNER'S MANUAL MOTORIZED FOLDING CAMPER WINCH With 1200lb Lift Capacity The 12 Volt Motorized Folding Camper Winch is used to raise and lower folding campers with the touch of the switch, eliminating hand
More information3-Pt. Quick Hitch. Owner s Manual
3-Pt. Quick Hitch Owner s Manual WARNING: Read carefully and understand all ASSEMBLY AND OPERATION INSTRUCTIONS before operating. Failure to follow the safety rules and other basic safety precautions may
More informationWARNING TABLE 3-1: DAILY SAFETY CHECK
III. T PSL-10 MAINTENANCE his chapter contains maintenance information for the Ricon PSL-10. The information consists of a maintenance schedule, component descriptions, electrical diagrams, fuse locations,
More informationS-Series DOT - Private Use Lift
Innovation in Mobility S-Series DOT - Private Use Lift Shortcut to WINWORD.EXE.lnk -PRINT- SERVICE MANUAL 04/09/15 U.S. Patent Nos: 4,534,450; 5,308,215; 5,445,488; 5,605,431; 5,944,473; Australia Patent
More informationINSTRUCTIONS FOR USE. Rx Only
INSTRUCTIONS FOR USE - HOSE ASSEMBLY Rx Only Basic matrix shown. Consult the Ohio Medical website for full matrix or contact your Ohio Medical representative. The product package label contains your product
More informationReach ins, Freeezers & Refrigerators Installation & Operation Manual
Reach ins, Freeezers & Refrigerators Installation & Operation Manual BSR23 BSF23 BSR49 BSF49 BSR72 BSF72 IMPORTANT SAFETY INSTRUCTIONS (SAVE THESE INSTRUCTIONS) Visit us on the web at www.blueairinc.com
More informationAutomatic Battery Charger Switching mode with Micro-controlled Input: Vac / Output: 12Volt DC
Automatic Battery Charger Switching mode with Micro-controlled Input:220-260Vac / Output: 12Volt DC User s Manual and Important Safety Information Model: OC-SW121080 / OC-SW121160 / OC-SW121210 FEATURES
More information24 VOLT AUTOMATIC BATTERY CHARGER PART NO
24 VOLT AUTOMATIC BATTERY CHARGER PART NO. 957732 AC Input: DC Output: Battery Type: Specifications 230 volts, 50 hertz, 3.5 amps, single-phase 24 volts, 20 amps initially tapering to 6 amps 24 volt, 12
More informationSAFETY PRECAUTIONS SAFETY FIRST!... 1 ABOUT THE CODE READER CONTROLS AND INDICATORS... 3 DISPLAY FUNCTIONS... 4
Table of Contents SAFETY PRECAUTIONS SAFETY FIRST!... 1 ABOUT THE CODE READER CONTROLS AND INDICATORS... 3 DISPLAY FUNCTIONS... 4 USING THE CODE READER CODE RETRIEVAL PROCEDURE... 7 VIEWING ABS DTCs...
More informationPVI 60KW, PVI 82KW, PVI 95KW
PVI 60KW PVI 82KW PVI 95KW WARRANTY MANUAL Commercial, Grid-Tied Photovoltaic Inverters 2008, Solectria Renewables LLC Subject to Change DOC-020099 rev 024 1 1 Product Warranty & RMA Policy Warranty Policy
More informationAir Curtain. Installation, Operating and Maintenance Instructions
Installation, Operating and Maintenance Instructions Save this manual for future reference. Air Curtain Model Numbers: ES026, ES036, ES042, ES048, ES060, ES072 READ THIS OWNER S MANUAL CAREFULLY BEFORE
More information16 Inch Hanging Pendant Barn Light
16 Inch Hanging Pendant Barn Light Owner s Manual WARNING: Read carefully and understand all ASSEMBLY AND OPERATION INSTRUCTIONS before operating. Failure to follow the safety rules and other basic safety
More informationHP190SL Series Slimline Radon Fans
Installation and Operation Manual Item #: 412843 Rev Date: 070113 HP190SL Series Slimline Radon Fans United States 10048 Industrial Blvd., Lenexa, KS, 66215 Tel.: 800.747.1762 Fax: 800.487.9915 Canada
More informationStrut Spring Compressor
Strut Spring Compressor Operating Instruction & Parts Manual Model Number Atd-7553 Model Atd-7553 Atd Tools Inc. 114 I-70 Trade Center Drive, St. Peters, MO 63376 Printed in Taiwan Save these instructions.
More information60 Watt Industrial LED Low Bay Light
60 Watt Industrial LED Low Bay Light Owner s Manual WARNING: Read carefully and understand all ASSEMBLY AND OPERATION INSTRUCTIONS before operating. Failure to follow the safety rules and other basic safety
More informationHydraulic Wheel Dolly
Hydraulic Wheel Dolly Operating Instructions & Parts Manual Model Number HW93766 Capacity 3/4 Ton Made in the U.S.A. This is the safety alert symbol. It is used to alert you to potential personal injury
More information1. Contents 1. CONTENTS INTRODUCTION SAFETY WARNINGS POWER TILT STANDARD OPERATING INSTRUCTIONS... 5.
1. Contents 1. CONTENTS..... 2. INTRODUCTION..... 3. SAFETY WARNINGS..... 4. POWER TILT STANDARD OPERATING INSTRUCTIONS....... 5. POWER SEAT LIFT STANDARD OPERATING INSTRUCTIONS...... 6. POWER TILT / SEAT
More informationLifeGuardLift. LifeGuard Power Lift Model #100287A OWNERS MANUAL. Rev: 2/14/11
LifeGuardLift OWNERS MANUAL LifeGuard Power Lift Model #100287A Rev: 2/14/11 Table of Contents 1. ASSEMBLY INSTRUCTIONS A. Lift Assembly B. Setup C. Disassembly 2. CONTROL SYSTEM A. Batteries B. Battery
More informationOperating and Installation Instructions
Model Number 20902 Fabricator's Power Module Kit - Aluminum Operating and Installation Instructions CAUTION! This product is to be installed only by persons knowledgeable in the repair and modification
More informationHeavy-Duty Welding Fabrication Table
Heavy-Duty Welding Fabrication Table with Fix-Up Kit Owner s Manual WARNING: Read carefully and understand all ASSEMBLY AND OPERATION INSTRUCTIONS before operating. Failure to follow the safety rules and
More informationOPERATIONS MANUAL LEVER CHAIN HOIST
OPERATIONS MANUAL LEVER CHAIN HOIST IMPORTANT SAFETY INFORMATION Please read, understand and follow all safety information contained in these instructions prior to the use of this hoist. Retain these instructions
More information