P E11500VD2C-02A PARTS LIST RUBBER CRAWLER CARRIER MST-1500VD. Serial No and up М О П О О К Д

Transcription

1 P E11500VD2C-02A PARTS LIST RUBBER CRAWLER CARRIER MST-1500VD Serial No and up М О П О О К Д

2 PARTS LIST RUBBER CRAWLER CARRIER MST-1500VD Serial No and up A -1

3 FOREWORD Thank you for purchasing this Morooka Rubber Crawler Carrier. When ordering a part, please specify the model serial number, the engine serial number and the reading of the hourmeter. READING FOR PARTS LIST For complete understanding, the parts list is written as follows. Fig. Number Figure numbers are not continuous. Description is put in front of the name of an assembly component and the item is entered next to the assembly. If part marked with is an assembly, its component is part marked with. Quantity The number of pieces per set used for assembly is specified. For assembly or part group components, the number of pieces per specified. assembly is Serial number The engine or machine serial number in which the part is used. Codes The codes and part number specified in the Part No. and Part name columns represent the following: The part specified in the line above is applicable instead of this part. Supplied as a set rather than singly. A-2

4 CONTENTS ITEM FIG. No. PAGE FORWARD A-2 CONTENTS 0-1 ENGINE RELATED PARTS (ENGINE MOUNTING PARTS AND RADIATOR) ENGINE RELATED PARTS (MAIN PUMP AND MOUNTING PARTS) ENGINE RELATED PARTS (AIR INTAKE SYSTEM) ENGINE RELATED PARTS (EXHAUST SYSTEM) FUEL TANK AND FUEL PIPING FRAME RELATED PARTS (1/4) (RADIATOR COVER AND FRONT GRILL) FRAME RELATED PARTS (2/4) (UNDER COVER AND STEP) FRAME RELATED PARTS (3/4) (ENGINE BONNET) FRAME RELATED PARTS (4/4) (BATTERY BOX) CAB CAB MOUNTING PARTS CAB (1/3) CAB (2/3) CAB (3/3) OPERATOR S SEAT AND FLOOR ASS Y CAB ELECTRICAL SYSTEM (1/2) CAB ELECTRICAL SYSTEM (2/2) PANEL ASS Y IN CAB (1/2) PANEL ASS Y IN CAB (2/2) FUSE BOX AND FUSE CAB AUDIO ASS Y AIR CONDITIONER SYSTEM (1/2) AIR CONDITIONER SYSTEM (2/2) AIR CONDITIONER RELATED PARTS (AIR COMPRESSOR AND MOUNTING) AIR CONDITIONER RELATED PARTS (A/С CONDENSER AND MOUNTING) AIR CONDITIONER RELATED PARTS (AIR CONDITIONER PIPING) AIR CONDITIONER RELATED PARTS (HEATER PIPING) UNDER CARRIAGE RELATED PARTS (TRAVEL MOTOR AND IDLER) UNDER CARRIAGE RELATED PARTS (CARRIER ROLLER) UNDER CARRIAGE RELATED PARTS (TRACK ROLLER) STEERING CONTROL SYSTEM DUMP CONTROL SYSTEM HYDRAULIC PIPING (CONTROL VALVE AND DUMP CYLINDER LINE) HYDRAULIC PIPING (MAIN PUMP CHARGE LINE) HYDRAULIC PIPING (HST MAIN LINE) HYDRAULIC PIPING (PARKING BRAKE AND H-L SPEED VALVE LINE)

5 ITEM FIG. No. PAGE HYDRAULIC PIPING (OIL COOLER AND DRAIN LINE) HYDRAULIC PIPING (MAIN PUMP DRAIN LINE) HYDRAULIC OIL TANK HYDRAULIC OIL FILTER OIL COOLER RERATED PARTS DUMP BODY RELATED PARTS ( 3-WAY OPENABLE TYPE) DUMP BODY RELATED PARTS (EARTH-MOVING TYPE) ELECTRICAL SYSTEM (1/4) (CHASSIS WIRING HARNESS AND LAMPS) ELECTRICAL SYSTEM (2/4) (CHASSIS WIRING DIAGRAM) ELECTRICAL SYSTEM (3/4) (BATTERY AND BATTERY RELAY ) ELECTRICAL SYSTEM (4/4) (BATTERY WIRING DIAGRAM) MARKS AND PLATES (JAPANESE) MARKS AND PLATES (ENGLISH) TOOLS NUMERICAL INDEX

6 MST-1500VD 1-1

7 FIG.101 ENGINE RELATED PARTS (ENGINE MOUNTING PARTS AND RADIATOR) 4

8 FIG.101 INDEX PART NO. DESCRIPTION Q TY SERIAL NO ENGINE ASS Y (CAT 6.6) ~ REAR LEFT SIDE BRACKET ~ REAR RIGHT SIDE BRACKET ~ BOLT (M16X40) ~ SPRING WASHER (M16) ~ CUSHION (FQ2531) ~ BOLT (M12X35) ~ NUT (M12) ~ SPRING WASHER (M12) ~ HARD WASHER (M12) ~ NUT (M12) ~ SPRING WASHER (M12) ~ HARD WASHER (M12) ~ CUSHION (FQ3529) ~ BOLT (M12X35) ~ NUT (M12) ~ SPRING WASHER (M12) ~ HARD WASHER (M12) ~ NUT (M12) ~ SPRING WASHER (M12) ~ HARD WASHER (M12) ~ 1-3

9 FIG.105 ENGINE RELATED PARTS (MAIN PUMP AND MOUNTING PARTS ) PV

10 FIG.105 INDEX PART NO. DESCRIPTION Q'TY SERIAL NO MAIN PUMP ASS Y (PV075075) ~ GEAR PUMP ASS Y ~ COUPLING ~ O-RING ~ BOLT (UNC7/16X35) ~ SPRING WASHER (M12) ~ PLANE WASHER (M12) ~ COUPLING ~ BOLT ~ BOSS ~ CENTER PLATE ~ BOLT ~ BOLT (UNC7/16X30) ~ SPRING WASHER (M12) ~ COVER ~ BOLT (M10X30) ~ SPRING WASHER (M10) ~ BOLT (M14X35) ~ SPRING WASHER (M14) ~ PLANE WASHER (M14) ~ 1-5

11 FIG.111 ENGINE RELATED PARTS (AIR INTAKE SYSTEM) PV

12 FIG.111 INDEX PART NO. DESCRIPTION Q TY SERIAL NO ELEMENT ASS Y ~ 1 ( ) INNER ELEMENT ~ OUTER ELEMENT ~ DUST PAN ~ VALVE ~ CAP ~ DUST INDICATOR ~ 1-7

13 FIG.115 ENGINE RELATED PARTS (EXHAUST SYSTEM) 1-8

14 FIG.115 INDEX PART NO. DESCRIPTION Q'TY SERIAL NO EXHAUST MUFFLER ~ GASKET ~ BOLT (M10X35) ~ NUT (M10) ~ SPRING WASHER (M10) ~ FRONT PIPE ~ GASKET ~ TAIL PIPE ~ CLAMP ~ BOLT (M10X35) ~ NUT (M10) ~ SPRING WASHER (M10) ~ CLAMP ~ SUPPORT ~ BOLT (M6X20) ~ NUT (M6) ~ SPRING WASHER (M6) ~ BRACKET ~ BOLT (M12X35) ~ SPRING WASHER (M12) ~ PLANE WASHER (M12) ~ BOLT (M6X20) ~ NUT (M6) ~ SPRING WASHER (M6) ~ PLANE WASHER (M6) ~ 1-9

15 FIG.121 FUEL TANK AND FUEL PIPING

16 FIG.121 INDEX PART NO. DESCRIPTION Q TY SERIAL NO FUEL TANK ASS Y ~ FUEL TANK ~ STRAINER ~ CAP (WITH KEY) ~ KEY ~ OIL LEVEL GAUGE TUBE ~ CLAMP (JUBILEE 000) ~ DRAIN BOLT ~ O-RING (P18) ~ FUEL LEVEL SENSOR ~ SCREW (4X10) ~ SPRING WASHER (M4) ~ PLANE WASHER (M4) ~ COVER ~ BOLT (M6X10) ~ SPRING WASHER (M6) ~ PLANE WASHER (M6) ~ SEMS BOLT (M10X20) ~ SEMS BOLT (M10X25) ~ FUEL SUPPLY HOSE ~ FUEL SUPPLY HOSE ~ FUEL RETURN HOSE ~ ELBOW ~ JOINT ~ CLAMP (JUBILEE 000) ~ BOLT (M10X30) ~ SPRING WASHER (M10) ~ PLANE WASHER (M10) ~ SPIRAL TUBE AR ~ STRAP BAND AR ~ STRAP BAND AR ~ 1-11

17 FIG.201 FRAME RELATED PARTS (1/4) (RADIATOR COVER AND FRONT GRILLE) 24 2S2? a m a Deta11 A PV

18 FIG.201 INDEX PART NO. DESCRIPTION Q'TY SERIAL NO MAIN FRAME ~ RADIATOR COVER ~ BOLT (M10X25) ~ SPRING WASHER (M10) ~ PLANE WASHER (M10) ~ FRONT GRILLE ~ BOLT (M10X30) ~ SPRING WASHER (M10) ~ PLANE WASHER (M10) ~ LEFT SIDE COVER ~ RIGHT SIDE COVER ~ BOLT (M10X20) ~ SPRING WASHER (M10) ~ PLANE WASHER (M10) ~ FRONT BUMPER ~ BOLT (M12X25) ~ SPRING WASHER (M12) ~ PLANE WASHER (M12) ~ COVER ~ BOLT (M12X20) ~ SPRING WASHER (M12) ~ PLANE WASHER (M12) ~ HEAD LAMP BRACKET ~ BOLT (M8X20) ~ SPRING WASHER (M8) ~ 1-13

19 FIG.202 FRAME RELATED PARTS (2/4) (UNDER COVER AND STEP )

20 FIG.202 INDEX PART NO. DESCRIPTION Q'TY SERIAL NO UNDER COVER ~ BOLT (M10X20) ~ SPRING WASHER (M10) ~ PLANE WASHER (M10) ~ STEP ~ BOLT (M12X25) ~ SPRING WASHER (M12) ~ STEP ~ BOLT (M12X25) ~ SPRING WASHER (M12) ~ STEP ~ BOLT (M12X25) ~ SPRING WASHER (M12) ~ CAP ~ BOLT (M6X16) ~ SPRING WASHER (M6) ~ PLANE WASHER (M6) ~ SAFETY BAR ~ CUSHION ~ PIN ~ NUT (M16) ~ SPRING WASHER (M16) ~ PLANE WASHER (M16) ~ CUSHION BLOCK ~ BOLT (M10X110) ~ 1-15

21 FIG.203 FRAME RELATED PARTS (3/4) (ENGINE BONNET)

22 FIG.203 INDEX PART NO. DESCRIPTION Q TY SERIAL NO REAR SUPPORT ~ BOLT (M12X30) ~ SPRING WASHER (M12) ~ PLANE WASHER (M12) ~ SUPPORT ~ BOLT (M12X35) ~ NUT (M12) ~ SPRING WASHER (M12) ~ PLANE WASHER (M12) ~ LEFT SIDE BRACKET ~ RIGHT SIDE BRACKET ~ BOLT (M12X25) ~ SPRING WASHER (M12) ~ PLANE WASHER (M12) ~ BONNET ASS Y ~ BONNET ~ BRACKET ~ BOLT (M10X25) ~ SPRING WASHER (M10) ~ COVER ~ HINGE ~ BOLT (M5X16) ~ NUT (M5) ~ SPRING WASHER (M5) ~ CATCHER ~ BOLT (M6X16) ~ NUT (M6) ~ SPRING WASHER (M6) ~ HANDLE ~ BOLT (M6X10) ~ SPRING WASHER (M6) ~ DAMPER ~ BRACKET ~ BOLT (M6X12) ~ SPRING WASHER (M6) ~ BRACKET ~ BOLT (M6X16) ~ NUT (M6) ~ SPRING WASHER (M6) ~ BOLT ~ 1-17

23 FIG.203 FRAME RELATED PARTS (3/4) (ENGINE BONNET)

24 FIG.203 INDEX PART NO. DESCRIPTION Q TY SERIAL NO NUT (M8) ~ SPRING WASHER (M8) ~ PLANE WASHER (M8) ~ INSPECTION COVER ~ BOLT (M10X25) ~ SPRING WASHER (M10) ~ PLANE WASHER (M10) ~ MUFFLER SUPPORT ~ BOLT (M10X20) ~ SPRING WASHER (M10) ~ PLANE WASHER (M10) ~ 1-18

25 FIG.204 FRAME RELATED PARTS (4/4) (BATTERY BOX)

26 FIG.204 INDEX PART NO. DESCRIPTION Q TY SERIAL NO BATTERY BOX ASS'Y ~ BATTERY BOX ~ BATTERY BOX COVER ~ HINGE ~ BOLT (M5X16) ~ NUT (M5) ~ SPRING WASHER (M5) ~ CATCHER ~ BOLT (M5X16) ~ NUT (M5) ~ SPRING WASHER (M5) ~ HANDLE ~ BOLT (M6X10) ~ SPRING WASHER (M6) ~ DAMPER ~ BRACKET ~ BOLT (M6X12) ~ SPRING WASHER (M6) ~ BRACKET ~ BOLT (M6X16) ~ NUT (M6) ~ SPRING WASHER (M6) ~ BOLT ~ NUT (M8) ~ SPRING WASHER (M8) ~ PLANE WASHER (M8) ~ SEMS BOLT (M10X25) ~ SEMS BOLT (M10X20) ~ MIRROR STAY ~ U-NUT ~ REAR VIEW MIRROR ~ 1-21

27 FIG.211 CAB MOUNTING PARTS 1-22

28 FIG.211 INDEX PART NO. DESCRIPTION Q TY SERIAL NO CUSHION ~ PLATE ~ BOLT (M16X130) ~ NUT (M16) ~ RUBBER SHEET ~ 1-23

29 FIG.221 CAB (1/3) Г 6 3 ^ 7 1 ^ 72 f 12 lr Ш Section A-A ffi Section B-B f t Ш Section C-C D i n Detail D PV

30 FIG.221 INDEX PART NO. DESCRIPTION Q TY SERIAL NO. 1 MA CAB FRAME ~ 4 MA BRACKET ~ 5 MAH BOLT (M8X16) ~ 10 MA FRONT UPPER GLASS ~ 11 MA FRONT LOWER GLASS ~ 12 MA RUBBER DAM ~ 43 MA RUBBER ~ 59 MA MIRROR ASS Y ~ 62 MA COVER ~ 64 MAH BOLT (M8X16) ~ 67 MA CUP HOLDER ~ 68 MAA SCREW (M6X12) ~ 71 MA ASHTRAY ~ 72 MAA SCREW (M5X12) ~ 1-25

31 FIG.222 CAB (2/3) 34 ffi 35 Section B-B PV

32 FIG.222 INDEX PART NO. DESCRIPTION Q'TY SERIAL NO. 15 MA LEFT SIDE GLASS ~ 16 MA RUBBER ~ 17 MA RING ~ 20 MA RIGHT SIDE GLASS ~ 21 MA RUBBER ~ 24 MA SASH ASS Y ~ 25 MA RUBBER ~ 28 MA CUSHION ~ 29 MA CUSHION ~ 33 MA CUSHION ~ 34 MA CUSHION ~ 35 MA CUSHION ~ 36 MA CUSHION ~ 48 MA FRONT INNER ROOF ~ 49 MA REAR INNER ROOF ~ 50 MA CUP ~ 53 MA CAB DOOR ASS Y ~ 56 MA REAR WINDOW ASS Y ~ 63 MA RUBBER ~ 75 MA COVER ~ 76 MAH BOLT (M8X16) ~ 79 MA COVER ~ 81 MAH BOLT (M8X16) ~ 85 MA GROMMET ~ 87 MA GROMMET ~ 1-27

33 FIG.223 CAB (3/3) z Ш View Z S Section A-A Ш Section B-B PV

34 FIG.223 INDEX PART NO. DESCRIPTION Q TY SERIAL NO. 41 MA CUSHION ~ 44 MA RUBBER ~ 45 MA RUBBER ~ 80 MA TRIM ~ 84 MA COVER ~ 88 MA GROMMET ~ 93 MAH BOLT (M8X16) ~ 1-29

35 FIG.225 OPERATOR S SEAT AND FLOOR ASS Y PV

36 FIG.225 INDEX PART NO. DESCRIPTION Q'TY SERIAL NO. 1 MA FLOOR ~ 2 MAH SEMS BOLT (M12X30) ~ 6 MA OPERATOR S SEAT ASS Y ~ 7 MA BRACKET ~ 8 MAH SEMS BOLT (M8X20) ~ 9 MAH SEMS BOLT (M10X20) ~ LEFT SIDE FOOT RAST ~ 29 MAH SEMS BOLT (M10X30) ~ RIGHT SIDE FOOT RAST ~ 34 MAH SEMS BOLT (M10X30) ~ FLOOR MAT ~ 1-31

37 PV93230

38 FIG.231 INDEX PART NO. DESCRIPTION Q'TY SERIAL NO. 1 MA WIPER MOTOR ~ 2 MAF NUT (M6) ~ 3 MA WIPER ARM ~ 4 MA WIPER BLADE ~ 5 MA COVER ~ 6 MA CUP ~ 7 MA LEAD WIRE ~ 8 MAHA BOLT ~ 9 MA BAND ~ 10 MA DUCT ~ 15 MA NOZZLE ASS Y ~ 16 MA TUBE ~ 17 MA VALVE ASS Y ~ 18 MA TUBE ~ 39 MA DC CONVERTOR ASS Y ~ 40 MAF NUT (M6) ~ 49 MAF NUT (M6) ~ 50 MAHA BOLT ~ 52 MA WIRE BAND ~ 53 MA BAND ~ 60 MA LEAD WIRE ~ 63 MA PLATE ~ 64 MAHA BOLT ~ 65 MAH BOLT ~ SLOPE ALARM UNIT ~ 69 MAF NUT ~ 70 MA CLAMP ~ 71 MA WIRE BAND ~ 1-33

39 FIG.232 CAB ELECTRICAL SYSTEM (2/2) Detail В ffi Section C-C 1-34

40 FIG.232 INDEX PART NO. DESCRIPTION Q'TY SERIAL NO. 13 MA WINDOW WASHER PUMP ~ 14 MAF NUT (M6) ~ 19 MA GROMMET ~ 20 MA COVER ~ 21 MA COVER ~ 22 MAF NUT (M8) ~ 24 MA PANEL ~ 25 MAI WIPER SWITCH ~ 26 MA MARK ~ 27 MAI NUT ~ 28 MA SCREW ~ 31 MA ROOM LAMP ASS Y ~ 32 MAH SCREW (M5X12) ~ 33 MAF NUT (M5) ~ 34 MA LEAD WIRE ~ 35 MA CLAMP ~ 36 MA WIRE BAND ~ 48 MA WIRING HARNESS (C) ~ 51 MA RELAY ~ 52 MA WIRE BAND ~ 53 MA BAND ~ 54 MA WIRE BAND ~ 55 MA RUBBER ~ 56 MA CLAMP ~ 1-35

41 FIG.235 PANEL ASS Y IN CAB (1/2) PV

42 FIG.235 INDEX PART NO. DESCRIPTION Q TY SERIAL NO. 1 MA PANEL ASS'Y ~ 2 MAF NUT (M8) ~ 3 MA COVER ~ 4 MAH BOLT (M6X12) ~ 1-37

43 FIG.236 PANEL ASS Y IN CAB (2/2) o o \ Detail Panel Box 34 9 Section A-A 18 9 Section B-B 10 j L J d Detail Starter Switch PV

44 FIG.236 INDEX PART NO. DESCRIPTION Q TY SERIAL NO. 1 MA PANEL ~ 2 MA COVER ~ 3 MAA SCREW (M6X12) ~ 4 MA COVER ~ STARTING SWITCH ASS'Y ~ STARTING KEY ~ 10 MA LEAD WIRE ~ 13 MA THROTTLE DIAL ~ 16 MA PARKING BRAKE SWITCH ~ 18 MA H-L SPEED SELECTOR SWITCH ~ 19 MA LINER ~ 20 MA BOOT ~ 22 MA COMBINATION SWITCH ~ 25 MA FLASHER UNIT ~ 28 MAH BOLT (M6X16) ~ 30 MA RELAY ~ 31 MAH BOLT (M6X16) ~ 33 SD DISPLAY ASS Y ~ 34 MA SCREW ~ 37 MA LAMP (RED) ~ 38 MA LAMP (ORANGE) ~ 39 MA LAMP (GREEN) ~ 40 MA LAMP (BLUE) ~ 42 MA HOURMETER ~ 46 MA SIDE PANEL LABEL ~ 47 MA STARTING SWITCH LABEL ~ 51 MA BUZZER ~ 52 MAH BOLT (M8X16) ~ 54 MA BUZZER ~ 55 MAF NUT (M4) ~ 56 MAH SCREW (M4X16) ~ 58 MA WIRING HARNESS (P) ~ 59 MA CLAMP ~ 60 MA WIRE BAND ~ 61 MAH BOLT (M8X16) ~ 62 MAA SCREW (M6X12) ~ 1-39

45 FIG.237 FUSE BOX AND FUSE To A /c c o n tro l panel,w iper sw itch and etc, a t upper surface in cab. ч PV

46 FIG.237 INDEX PART NO. DESCRIPTION Q'TY SERIAL NO. MA MA WIRING HARNESS (P) (SEE FIG ) WIRING HARNESS (WITH FUSE BOX) ~ ~ 2 MA COVER ~ 3 MA FUSE PULLER ~ MINI-FUSE (5A) ~ MINI-FUSE (10A) ~ MINI-FUSE (15A) ~ 5 MA FUSE LABEL ~ 6 MAA SCREW (M6X12) ~ MA MA WIRING HARNESS (C) (SEE FIG ) WIRING HARNESS (WITH FUSE BOX) ~ ~ 8 MA COVER ~ 9 MA FUSE PULLER ~ MINI-FUSE (10A) ~ MINI-FUSE (15A) ~ 11 MA FUSE LABEL ~ 12 MAF NUT (M6) ~ 1-41

47 FIG.241 CAB AUDIO ASS Y Z ffl View Z x t r - a * M e Detail Speaker X t I^B M S Detail Stereo PV

48 FIG.241 INDEX PART NO. DESCRIPTION Q TY SERIAL NO. 1 MA BRACKET ~ 2 MAH BOLT (M8X20) ~ 3 MA CD STEREO UNIT ~ 4 MA LEAD WIRE ~ 5 MA CLAMP ~ 6 MA WIRE BAND ~ 10 MA SPEAKER UNIT ~ 11 MA NUT ~ 12 MA SCREW ~ 13 MA SPEAKER UNIT ~ 14 MA NUT ~ 15 MA SCREW ~ 18 MA ANTENNA ASS Y ~ 19 MAF SCREW (M5X16) ~ 20 MA WIRE BAND ~ 1-43

49 FIG.251 AIR CONDITIONER SYSTEM (1/2) a m a Detail A z Ш View Z y m View Y PV

50 FIG.251 INDEX PART NO. DESCRIPTION Q'TY SERIAL NO. 1 MA AIR CONDITIONER UNIT ~ 2 MAH BOLT (M6X25) ~ 3 MA WASHER (M6) ~ 4 MAF BOLT (M6X30) ~ 8 MA BRACKET ~ 9 MAH BOLT (M8X20) ~ 28 MA WIRE ~ 29 MA WIRE ~ 30 MA RING ~ 31 MA CLAMP ~ 32 MA SCREW (M4X12) ~ 37 MA WATER VALVE ~ 38 MA PLATE ~ 39 MA SCREW (M4X12) ~ 40 MAH BOLT (M6X16) ~ 41 MA WIRE ~ 42 MA WIRECLAMP ~ 43 MAH SCREW (M4X16) ~ 44 MAF NUT (M4) ~ 52 MA WATER HOSE ~ 53 MA WATER HOSE ~ 54 MA HOSE CLAMP ~ 58 MA WATER HOSE ~ 59 MA WATER HOSE ~ 60 MA JOINT ~ 61 MA HOSE CLAMP ~ 66 MA WIRE BAND ~ 70 MA DRAIN HOSE ~ 71 MA DRAIN HOSE ~ 72 MA T-JOINT ~ 73 MA CLAMP ~ 79 MA PACKING ~ 101 MA FILTER ~ 102 MA CUP ~ 1-45

51 FIG.252 AIR CONDITIONER SYSTEM (2/2) Ш Section B-B S Section C-C 19 S Section D-D S Section A-A 10 ш г Section E-E Section F-F PV

52 FIG.252 INDEX PART NO. DESCRIPTION Q TY SERIAL NO. 9 MAH BOLT (M8X20) ~ 10 MA CUSHION RUBBER ~ 13 MA DUCT ~ 14 MA CUSHION ~ 15 MAH BOLT (M6X16) ~ 19 MA CUSHION ~ 23 MA CONTROL ASS Y ~ 24 MA BRACKET ~ 25 MAH BOLT (M6X16) ~ 26 MAHA SCREW ~ 27 MAF NUT (M4) ~ 33 MA WIRE BAND ~ 45 MA WIRE BAND ~ 52 MA WATER HOSE ~ 53 MA WATER HOSE ~ 65 MA BAND ~ 66 MA WIRE BAND ~ 70 MA DRAIN HOSE ~ 73 MA CLAMP ~ 74 MA GROMMET ~ 78 MA LP HOSE ~ 83 MA LQ HOSE ~ 90 MA GRILLE ASS Y ~ 91 MAA SCREW (M4X12) ~ 92 MAF NUT (M4) ~ 93 MA SEAL ~ 1-47

53 FIG.253 AIR CONDITIONER RELATED PARTS (AIR COMPRESSOR AND MOUNTING) 1

54 FIG.253 INDEX PART NO. DESCRIPTION Q'TY SERIAL NO. 1 MA AIR COMPRESSOR ASS'Y ~ BRACKET ~ BOLT (M10X30) ~ SPRING WASHER (M10) ~ PLANE WASHER (M10) ~ BOLT (M10X35) ~ 7 MA BUSHING ~ BOLT (M10X35) ~ SPRING WASHER (M10) ~ PLANE WASHER (M10) ~ 11 MA TENSION PULLEY ASS'Y ~ 12 MA ADJUSTING BOLT ~ 13 MA V-BELT ~ 1-49

55 FIG.254 AIR CONDITIONER RELATED PARTS (A/С CONDENSER AND MOUNTING)

56 FIG.254 INDEX PART NO. DESCRIPTION Q'TY SERIAL NO. 1 MA CONDENSER ASS Y ~ 2 MA LEFT SIDE BRACKET ~ 3 MA RIGHT SIDE BRACKET ~ 4 MAH BOLT ~ 5 MA GROMMET ~ 6 MA BUSHING ~ 7 MA WASHER ~ 8 MAH BOLT ~ SPRING WASHER (M10) ~ 10 MA RECEIVER ~ 11 MA HOLDER ~ 12 MAH BOLT ~ 1-51

57 FIG.255 AIR CONDITIONER RELATED PARTS (AIR CONDITIONER PIPING) 6 7 PV

58 FIG.255 INDEX PART NO. DESCRIPTION Q'TY SERIAL NO. 1 MA DISCHARGE HOSE ASS'Y ~ 2 MA SUCTION HOSE ASS Y ~ 3 MA LIQUID PAPE ~ 4 MA LIQUID HOSE ASS Y ~ 5 MAH BOLT ~ CORRUGATE TUBE AR ~ CORRUGATE TUBE AR ~ CORRUGATE TUBE AR ~ STRAP BAND AR ~ STRAP BAND AR ~ 1-53

59 FIG.256 AIR CONDITIONER RELATED PARTS (HEATER PIPING) 1-54

60 FIG.256 INDEX PART NO. DESCRIPTION Q TY SERIAL NO RETURN HOSE ~ SUPPLY HOSE ~ NIPPLE ~ VALVE ~ ADAPTER ~ JOINT ~ CLAMP ~ CORRUGATE TUBE AR ~ CORRUGATE TUBE AR ~ CORRUGATE TUBE AR ~ STRAP BAND AR ~ STRAP BAND AR ~ 1-55

61 FIG.301 UNDER CARRIAGE RELATED PARTS (TRAVEL MOTOR AND IDLER ) A S M 5 Detail A PV921oo 1-56

62 FIG.301 INDEX PART NO. DESCRIPTION Q TY SERIAL NO TRACK RUBBER ~ TRAVEL MOTOR ASS Y (BMV75) ~ BOLT (M16X55) ~ SPRING WASHER (M16) ~ SPROCKET ~ BOLT (M20X50) ~ HARD WASHER (M20) ~ IDLER ASS Y ~ IDLER ~ SHAFT ~ O-RING (G50) ~ ROLLER BEARING ~ SNAP RING ~ FLOATING SEAL ASS Y ~ CAP ~ SLIDE HOLDER ~ LOCK PLATE ~ BOLT (M12X25) ~ SPRING WASHER (M12) ~ NUT (M30) ~ SPRING WASHER (M30) ~ RECOIL SPRING ~ CYLINDER ~ TRACK ADJUSTMENT VALVE ~ 1-57

63 FIG.311 UNDER CARRIAGE RELATED PARTS (CARRIER ROLLER ) a m ж Detail A PV

64 FIG.311 INDEX PART NO. DESCRIPTION Q TY SERIAL NO CARRIER ROLLER ASS Y ~ CARRIER ROLLER ~ SHAFT ~ BALL BEARING ~ SNAP RING ~ FLOATING SEAL ASS'Y ~ CAP ~ SCREW (M6X30) ~ PLATE ~ O-RING (G35) ~ BOLT (M10X25) ~ SPRING WASHER (M10) ~ BOLT (M8X16) ~ SPRING WASHER (M8) ~ BOLT (M12X25) ~ SPRING WASHER (M12) ~ 1-59

65 FIG.321 UNDER CARRIAGE RELATED PARTS (TRACK ROLLER ) Л 4 P V

66 FIG.321 INDEX PART NO. DESCRIPTION Q TY SERIAL NO PIVOT SHAFT ~ BUSHING ~ TRACK ROLLER ASS Y ~ TRACK ROLLER ~ SHAFT ~ BALL BEARING ~ SNAP RING ~ FLOATING SEAL ASS Y ~ CAP ~ SCREW (M8X30) ~ O-RING (G45) ~ PLATE ~ NUT (M30) ~ SPRING WASHER (M30) ~ GREASE NIPPLE ~ 1-61

67 FIG.401 STEERING CONTROL SYSTEM PV

68 FIG.401 INDEX PART NO. DESCRIPTION Q TY SERIAL NO LEVER STAND ~ BOLT (M10X20) ~ SPRING WASHER (M10) ~ PLANE WASHER (M10) ~ TRAVEL CONTROL LEVER ASS'Y ~ GRIP ~ SCREW (M6X100) ~ PLANE WASHER (M6) ~ RUBBER SHEET ~ SCREW (M5X20) ~ CABLE FOR FRONT MAIN PUMP (L=4600) CABLE FOR REAR MAIN PUMP (L=4300) ~ ~ BALL JOINT ASS Y ~ BALL JOINT STUD ~ COLLAR (Ф 10x30) ~ FRONT SIDE MAIN PUMP LEVER ~ BALL JOINT ASS'Y ~ REAR SIDE MAIN PUMP LEVER ~ FRONT SIDE MAIN PUMP BRACKET ~ REAR SIDE MAIN PUMP BRACKET ~ SOCKET HEAD BOLT (UNC1/2X25) ~ SPRING WASHER (M14) ~ BACK-UP BUZZER SWITCH BRACKET ~ BOLT (M6X20) ~ SPRING WASHER (M6) ~ PLANE WASHER (M6) ~ BRACKET ~ COVER ~ BOLT (M10X25) ~ BOLT (M10X20) ~ SPRING WASHER (M10) ~ PLANE WASHER (M10) ~ 1-63

69 FIG.421 DUMP CONTROL SYSTEM

70 FIG.421 INDEX PART NO. DESCRIPTION Q TY SERIAL NO DUMP CONTROL LEVER ASS'Y ~ BRACKET ASS Y ~ LEVER ASS Y ~ KNOB ~ NUT (M10) ~ E-RING ~ LOCK ASS Y ~ BOLT (M6X10) ~ SPRING WASHER (M6) ~ PLANE WASHER (M6) ~ BOLT (M6X30) ~ NUT (M6) ~ TERMINAL ~ CLAMP ~ BOLT (M6X30) ~ NUT (M6) ~ PLANE WASHER (M6) ~ BOLT (M8X25) ~ PLANE WASHER (M8) ~ CABLE (L=2500) ~ JOINT ~ NUT (M8) ~ PIN (Ф 8X25) ~ COTTER PIN (Ф 1.0X15) ~ 1-65

71 FIG.501 HYDRAULIC PIPING (CONTROL VALVE AND DUMP CYLINDER LINE) Л -f К IJ Hydraul Hydraul ic Pirro 1-66

72 FIG.501 INDEX PART NO. DESCRIPTION Q'TY SERIAL NO HOSE (1 " X I500) ~ NIPPLE (PT1XSLEEVE) ~ CLAMP (ABA32-44) ~ ELBOW (PT1XPT1) ~ NIPPLE (PT1) ~ ELBOW (PT1XPT1) ~ FLANGE ~ O-RING (G35) ~ SOCKET HEAD BOLT (M10X25) ~ HOSE (3 /4"X600) ~ ELBOW (PT1/2XPF3/4) ~ FLANGE ~ O-RING (G30) ~ SOCKET HEAD BOLT (M8X25) ~ ELBOW (UNF1-3/16XPF3/4) ~ O-RING (914) ~ DUMP CONTROL VALVE ASS Y ~ BOLT (M12X30) ~ SPRING WASHER (M12) ~ PLANE WASHER (M12) ~ HOSE (1/2"X550) ~ HOSE (1/2"X650) ~ ELBOW (UNF1-3/16XPF1/2) ~ O-RING (914) ~ ELBOW (UNF1-3/16XPF1/2) ~ O-RING (914) ~ TEE (PT1/2XPF1/2XPF1/2) ~ HOSE (1/2"X700) ~ NIPPLE (PT1/2XPF1/2) ~ 1-67

73 FIG.502 HYDRAULIC PIPING (MAIN PUMP CHARGE LINE) PV

74 FIG.502 INDEX PART NO. DESCRIPTION Q TY SERIAL NO HOSE (3/4"X970) ~ ELBOW (UNF1-5/16XPF3/4) ~ O-RING (916) ~ ELBOW (PT1XPF3/4) ~ 4 ( ) OIL FILTER ASS Y ~ ADAPTER (PT1XPF3/4) ~ ELBOW (PT3/4XPT3/4) ~ ADAPTER (PT3/4XPF1/4) ~ HOSE (3 /4"X700) ~ HOSE (3 /4"X650) ~ TEE (PT3/4XPF3/4XPF3/4) ~ ELBOW (UNF1-3/16XPF3/4) ~ O-RING (910) ~ NIPPLE (PT1/2XPT1/2) ~ ELBOW (PT1/2XPT1/2) ~ 1-69

75 FIG.503 HYDRAULIC PIPING (HST MAIN LINE) AT fn'jvlky? H ydrauliс Рите A f KD'J #? -? *! Hydraul ic Motor R. H. A-f Hydraul ic Motor L. H. PV

76 FIG.503 INDEX PART NO. DESCRIPTION Q TY SERIAL NO HOSE (1 "X2350, 210 DEG.) ~ HOSE (1"X2200, 0 DEG.) ~ HOSE (1 "X1950, 0 DEG.) ~ HOSE (1 "X DEG.) ~ O-RING ~ SPLIT FLANGE ~ SOCKET HEAD BOLT (UNC7/16X25) ~ CLAMP ~ NUT (M12) ~ SPRING WASHER (M12) ~ PLANE WASHER (M12) ~ RUBBER SHEET AR ~ RUBBER SHEET AR ~ STRAP BAND AR ~ STRAP BAND AR ~ 1-71

77 FIG.504 HYDRAULIC PIPING (PARKING BRAKE AND H-L SPEED VALVE LINE) / ' U PV

78 FIG.504 INDEX PART NO. DESCRIPTION Q TY SERIAL NO SOLENOID VALVE ASS'Y (FOR PARKING BRAKE AND H /L SPEED) ~ BOLT (M8X16) ~ SPRING WASHER (M8) ~ SUPPLY HOSE (1/4"X950) ~ PARKING BRAKE HOSE (1/4"X1550) ~ PARKING BRAKE HOSE (1/4"X710) ~ PARKING BRAKE HOSE (1/4"X950) ~ H /L SPEED HOSE (1/4"X1500) ~ H /L SPEED HOSE (1/4"X980) ~ H /L SPEED HOSE (1/4"X1170) ~ RETURN HOSE (1/4"X1800) ~ ELBOW (PT1/4XPF1/4) ~ ELBOW (PF1/4XPF1/4) ~ O-RING (P11) ~ TEE (PF1/4XPF1/4XPF1/4) ~ ELBOW (UNF9/16XPF1/4) ~ O-RING (906) ~ NIPPLE (PF1/4XPF1/4) ~ O-RING (P11) ~ ELBOW (PT1/4XPF1/4) ~ 1-73

79 FIG.505 HYDRAULIC PIPING (OIL COOLER AND DRAIN LINE) JW H ydraulic Tank ) H f D ЧуОХуУ H ydraulic pump t'f 11,9-7 O il coole r JW Hydraul ic Motor R. H. rto 'D 'J Hydraul ic Motor L. H. / у PV

80 FIG.505 INDEX PART NO. DESCRIPTION Q'TY SERIAL NO MAIN PUMP RETURN HOSE (3/4"X450) ~ RETURN HOSE (3/4"X1400) ~ TRAVEL MOTOR RETURN HOSE HOSE (3/4"X780) TRAVEL MOTOR RETURN HOSE (3/4"X560) OIL COOLER INLET HOSE (3/4"X1500) ~ ~ ~ ADAPTER (UNF1 1 /1 6XPT3/4) ~ O-RING (912) ~ TEE (PT3/4XPF3/4XPF3/4) ~ ELBOW (PT3/4XPF3/4) ~ CROSS (PF3/4XPF3/4) ~ ELBOW (UNF1-1/16XPT3/4) ~ O-RING (912) ~ ELBOW (PT1XPF3/4) ~ OIL COOLER OUTLET HOSE (ГХ2250) ~ ELBOW (PT1XPF1) ~ TEE (PT1XPT1XPT3/4) ~ NIPPLE (PT1XPT1) ~ NIPPLE (PT3/4XPF3/4) ~ CHECK VALVE ASS Y ~ HOSE (3/4"X300) ~ NIPPLE (PT3/4XPF3/4) ~ CLAMP (ABA22-32) ~ ELBOW (PT1XPF1) ~ ELBOW (PT1XPT1) ~ NIPPLE (PT1) ~ 1-75

81 FIG.506 HYDRAULIC PIPING (MAIN PUMP DRAIN LINE) iw tnvvvfy? H ydraulic tank Л4 К 0 'Ь? ;Ю 7 H ydraulic Pimp PV

82 FIG.506 INDEX PART NO. DESCRIPTION Q'TY SERIAL NO RETURN HOSE (1/2"X400) ~ RETURN HOSE (1/2"X800) ~ ADAPTER (UNF1-1/16XPT3/4) ~ O-RING (912) ~ ADAPTER (PT3/4XPT1/2) ~ TEE (PT3/4XPF3/4XPF3/4) ~ ELBOW (UNF1-1/16XPF1/2) ~ O-RING (912) ~ ELBOW (PT3/8XPF1/2) ~ THROTTLE CHECK VALVE ASS Y ~ ELBOW (PT3/8XPF3/8) ~ 1-77

83 FIG.551 HYDRAULIC OIL TANK

84 FIG.551 INDEX PART NO. DESCRIPTION Q'TY SERIAL NO HYDRAULIC OIL TANK ASS Y ~ HYDRAULIC OIL TANK ~ SUCTION FILTER ~ COVER ~ O-RING ~ BOLT (M8X16) ~ SPRING WASHER (M8) ~ BREATHER ~ GASKET ~ BOLT ~ STRAINER ~ CAP ~ OIL LEVEL GAUGE ASS Y ~ OIL LEVEL GAUGE ~ BOLT ~ GASKET ~ DRAIN PLUG (PT1) ~ PLUG (PT3/8) ~ BOLT (M10X20) ~ SPRING WASHER (M10) ~ PLANE WASHER (M10) ~ NUT (M10) ~ 1-79

85 FIG.555 HYDRAULIC OIL FILTER A I I fffl Detail A PV

86 F1G.555 INDEX PART NO. DESCRIPTION Q'TY SERIAL NO OIL FILTER ASS Y ~ HEAD ASS Y ~ ELEMENT ASS Y ~ BRACKET ~ BOLT (M10X20) ~ SPRING WASHER (M10) ~ PLANE WASHER (M10) ~ BOLT (M10X25) ~ SPRING WASHER (M10) ~ 1-81

87 FIG.561 OIL COOLER AND RERATED PARTS a 6 PV

88 FIG.561 INDEX PART NO. DESCRIPTION Q TY SERIAL NO OIL COOLER ASS Y ~ LEFT SIDE BRACKET ~ RIGHT SIDE BRACKET ~ UPPER SIDE BRACKET ~ LOWER SIDE BRACKET ~ BOLT (M8X30) ~ PLANE WASHER (M8) ~ NUT (M8) ~ SPRING WASHER (M8) ~ BOLT (M8X20) ~ SPRING WASHER (M8) ~ PLANE WASHER (M8) ~ BOLT (M10X30) ~ PLANE WASHER (M10) ~ NUT (M10) ~ SPRING WASHER (M10) ~ LEFT SIDE BRACKET FOR A/C CONDENSOR MOUNTING RIGHT SIDE BRACKET FOR A /C CONDENSOR MOUNTING RIGHT LOWER SIDE BRACKET FOR A/С CONDENSOR MOUNTING ~ ~ ~ BOLT (M8X20) ~ PLANE WASHER (M8) ~ NUT (M8) ~ SPRING WASHER (M8) ~ 1-83

89 FIG.601DUMP BODY RELATED PARTS ( 3-WAY OPENABLE TYPE) А В M DetalI A PV

90 FIG.601 INDEX PART NO. DESCRIPTION Q TY SERIAL NO DUMP BODY ~ HINGE PIN BRACKET (WELDED) ~ L.H. SIDE DOOR ~ R.H. SIDE DOOR ~ REAR SIDE DOOR ~ REFLECTOR ~ PIN ~ GREASE NIPPLE ~ SPRING PIN (Ф 6x40) ~ LEVER ~ NUT (M14) ~ PLANE WASHER (M14) ~ HINGE PIN ~ BUSHING ~ GREASE NIPPLE ~ BOLT (M12X100) ~ NUT (M12) ~ SPRING WASHER (M12) ~ L.H. SIDE CUSHION ASS'Y ~ R.H. SIDE CUSHION ASS Y ~ SPRING CASE ASS Y ~ HOOK ~ L.H. SIDE ARM ASS Y ~ R.H. SIDE ARM ASS Y ~ PIN ASS Y ~ SPRING ~ DUMP CYLINDER ASS Y ~ CYLINDER PIN ~ WASHER ~ COTTER PIN (0 5.9x71) ~ 1-85

91 FIG.611 DUMP BODY RELATED PARTS (EARTH-MOVING TYPE) A i f Sffl DetaiI A PV

92 FIG.611 INDEX PART NO. DESCRIPTION Q TY SERIAL NO DUMP BODY ~ HINGE PIN BRACKET (WELDED) ~ REAR SIDE DOOR ~ REFLECTOR ~ PIN ~ GREASE NIPPLE ~ SPRING PIN (Ф 6x40) ~ HINGE PIN ~ BUSHING ~ GREASE NIPPLE ~ BOLT (M12X100) ~ NUT (M12) ~ SPRING WASHER (M12) ~ L.H. SIDE CUSHION ASS Y ~ R.H. SIDE CUSHION ASS Y ~ SPRING CASE ASS Y ~ HOOK ~ L.H. SIDE ARM ASS Y ~ R.H. SIDE ARM ASS Y ~ PIN ASS'Y ~ SPRING ~ DUMP CYLINDER ASS Y ~ CYLINDER PIN ~ WASHER ~ COTTER PIN (Ф 5.9x71) ~ 1-87

93 FIG.711 ELECTRICAL SYSTEM (1/4) (CHASSIS WIRING HARNESS AND LAMPS) 1-88

94 FIG. 711 INDEX PART NO. DESCRIPTION Q TY SERIAL NO L.H. SIDE HALOGEN HEAD LAMP ASS Y ~ OUTER HALOGEN HEAD LAMP ~ OUTER HALOGEN BULB (75/70W) ~ INNER HALOGEN HEAD LAMP ~ INNER HALOGEN BULB (70W) ~ R.H. SIDE HALOGEN HEAD LAMP ASS Y ~ OUTER HALOGEN HEAD LAMP ~ OUTER HALOGEN BULB (75/70W) ~ INNER HALOGEN HEAD LAMP ~ INNER HALOGEN BULB (70W) ~ TURN SIGNAL LAMP ASS Y ~ HORN ~ FLANGE NUT (M8) ~ NUT (M8) ~ 15 C HEATER RELAY ~ BRACKET ~ FLANGE NUT (M6) ~ BACK-UP BUZZER SWITCH ~ PLATE ~ BOLT (M4X30) ~ NUT (M4) ~ PLANE WASHER (M4) ~ BACK-UP BUZZER ~ SCREW (M6X20) ~ FLANGE NUT (M6) ~ WIRING HARNESS ~ GROUND CONNECTION WIRE (D409R038) ~ NUT (M10) ~ SPRING WASHER (M10) ~ PLANE WASHER (M10) ~ HST OIL PRESSURE SENSOR (SD ) HST OIL TEMPERATURE SENSOR (SD ) ~ ~ FUEL LEVEL SENSOR ~ 34 C RADIATOR WATER LEVEL SENSOR ~ CLIP (LARGE) AR ~ CLIP (SMALL) AR ~ 1-89

95 FIG.711 ELECTRICAL SYSTEM (1/4) (CHASSIS WIRING HARNESS AND LAMPS) 1-88

96 FIG.711 INDEX PART NO. DESCRIPTION Q TY SERIAL NO NUT (M6) AR ~ SPRING WASHER (M6) AR ~ STRAP BAND AR ~ STRAP BAND AR ~ 1-90

97 FIG.712 ELECTRICAL SYSTEM (2/4) (CHASSIS WIRING DIAGRAM)

98 FIG.712 INDEX PART NO. DESCRIPTION Q'TY SERIAL NO MAIN WIRING HARNESS (D209R036) ~ WIRING HARNESS (D409R037) ~ BACK-UP BUZZER WIRING HARNESS ~ GROUND CONNECTION WIRE (D409R038) ~ WIRING HARNESS (D309R045) ~ WIRING HARNESS (D409R044) ~ WIRING HARNESS (D409R042) ~ L.H. SIDE HALOGEN HEAD LAMP ASS Y R.H. SIDE HALOGEN HEAD LAMP ASS Y ~ ~ TURN SIGNAL LAMP ASS Y ~ HORN ~ 12 C RADIATOR WATER LEVEL SENSOR ~ 13 C HEATER RELAY ~ SOLENOID VALVE ASS'Y (FOR PARKING BRAKE AND H /L SPEED) ~ BACK-UP BUZZER SWITCH ~ BACK-UP BUZZER ~ HST OIL TEMPERATURE SENSOR (SD ) HST OIL PRESSURE SENSOR (SD ) ~ ~ FUEL LEVEL SENSOR ~ 20 MA A/С WIRING HARNESS ~ 1-93

99 FIG.715 ELECTRICAL SYSTEM (3/4) (BATTERY AND BATTERY RELAY ) 1-94

100 FIG.715 INDEX PART NO. DESCRIPTION Q TY SERIAL NO BATTERY (130F51) (12V.120AH) ~ TERMINAL (+) ~ TERMINAL (-) ~ BOARD ~ HOLDER ~ ROD ~ PLANE WASHER (M10) ~ NUT (M10) ~ SPRING WASHER (M10) ~ BRACKET ~ BOLT (M10X30) ~ PLANE WASHER (M10) ~ NUT (M10) ~ SPRING WASHER (M10) ~ BATTERY RELAY ~ BOLT (M8X20) ~ SPRING WASHER (M8) ~ PLANE WASHER (M8) ~ 19 C STARTER RELAY ~ SPACER (L=5) ~ BOLT (M6X15) ~ SPRING WASHER (M6) ~ PLANE WASHER (M6) ~ 24 C BREAKER (80A) ~ N1010 SCREW (UNF-NO.10X10) ~ PLANE WASHER (M6) ~ FLANGE NUT (M10) ~ MINI BLADE FUSE (20A) ~ SLOW BLOW FUSE (65A) ~ SLOW BLOW FUSE (75A) ~ 1-95

101 FIG.716 ELECTRICAL SYSTEM (4/4) (BATTERY WIRING DIAGRAM) To s ta r te r and a lte rn a to r 2 PV

102 FIG.716 INDEX PART NO. DESCRIPTION Q TY SERIAL NO BATTERY CABLE (D409R039) ~ BATTERY CABLE (D409R038) ~ BATTERY CABLE (D409R040) ~ WIRING HARNESS (D409R043) ~ WIRING HARNESS (D409R041) ~ WIRING HARNESS (D309R045) ~ WIRING HARNESS (D410R193) ~ MAIN WIRING HARNESS (D209R036) ~ MINI BLADE FUSE (20A) ~ SLOW BLOW FUSE (65A) ~ SLOW BLOW FUSE (75A) ~ DIODE ~ BATTERY (130F51) (12V.120AH) ~ BATTERY RELAY ~ 15 C STARTER RELAY ~ 16 C BREAKER (80A) ~ 1-97