Technical Service BULLETIN
|
|
- Stanley Phillips
- 5 years ago
- Views:
Transcription
1 Technical Service BULLETIN July 4, 2007 Title: Models: 07 Avalon, Camry (NAP), Camry HV (NAP), & Solara EG ENGINE TSB REVISION NOTICE: August 22, 2007: Two parts have been added to the Parts Information table for Camry (PZEV) and Camry HV (P/N and ). Previous versions of this TSB should be discarded. TSB UPDATE NOTICE: The information contained in this TSB supercedes TSB No. EG TSB No. EG is now obsolete and should be discarded. Introduction Some 2007 model year Avalon, Camry, Camry HV, and Solara vehicles may exhibit one of the following conditions: Intermittent stalling at idle when at operating temperature. Intermittent rough idle when at operating temperature. M.I.L. ON with at least one of the following DTCs stored: P044 (Evaporative Emission Control System Incorrect Purge Flow) P043E (Evaporative Emission System Reference Orifice Clog Up) P043F (Evaporative Emission System Reference Orifice High Flow) P240 (Evaporative Emission System Leak Detection Pump Control Circuit Low) P2402 (Evaporative Emission System Leak Detection Pump Control Circuit High) P249 (Evaporative Emission System Switching Valve Control Circuit Low) Follow the repair procedure below to address customer concerns. Applicable Vehicles 2007 model year Avalon vehicles produced BEFORE the Production Change Effective VIN shown in this TSB model year Camry (North American produced) vehicles produced at TMMK and SIA BEFORE the Production Change Effective VINs shown in this TSB model year Camry HV (North American produced) vehicles produced at TMMK BEFORE the Production Change Effective VINs shown in this TSB model year Solara vehicles produced BEFORE the Production Change Effective VINs shown in this TSB. NOTE: This condition is a production caused issue and will be present from the first fill of the fuel tank. Vehicles with more than 0,000 miles of use with NO prior complaints about this condition should NOT need this repair. Refer to the Repair Manual to diagnose this issue on vehicles with greater than 0,000 miles and NO prior complaints. Toyota Supports ASE Certification Page of 6
2 Warranty Information OP CODE DESCRIPTION MODEL TIME OFP T T2 Avalon R & R Charcoal Canister Camry and dfuel ltank Camry HV Solara Applicable Warranty*: This repair is covered under the Toyota Federal Emissions Warranty. This warranty is in effect for 36 months or 36,000 miles, whichever occurs first, from the vehicle s in-service date. For California specification vehicles sold, registered, and operated in California, Maine, Massachusetts, and Vermont, this repair is covered under the California Emission Warranty, which is in effect for 84 months or 70,000 miles, whichever occurs first, from the vehicle s in service date. For California specification Camry HV and 4 cylinder Camry PZEV vehicles sold, registered, and operated in California, Connecticut, Maine, Massachusetts, New Hampshire, New Jersey, New York, Rhode Island, and Vermont, this repair is covered under the California Emission Warranty, which is in effect for 80 months or 50,000 miles, whichever occurs first, from the vehicle s in service date. * Warranty application is limited to correction of a problem based upon a customer s specific complaint. Production Change Information MODEL ENGINE PLANT PRODUCTION CHANGE EFFECTIVE VIN Avalon 2GR FE TMMK 4TBK36B*7U SIA 4T4BE46K*7R AZ FE Line 4TBE46K*7U50555 Camry Line 2 4TBE46K*7U TMMK Line 4TBK46K*7U GR FE Line 2 4TBK46K*7U54747 Camry HV 2AZ FE 4TBB46K*7U08802 Solara 2AZ FE TMMK 4TCE3#P*7U GR FE 4T*A3#P*7U30607 NOTE: Camry vehicles produced at SIA can be identified with an R as the th digit in the VIN. For example: 4T4BE46K*7R######. Camry vehicles produced at TMMK Line can be identified with a 0,, 2, 3, or 4 as the 2th digit in the VIN. For Example: 4TB*46K*7U0#####. Camry vehicles produced at TMMK Line 2 can be identified with a 5, 6, 7, 8, or 9 as the 2th digit in the VIN. For example: 4TB*46K*7U5#####. Page 2 of 6
3 Parts Information MODEL Camry Camry (4 Cylinder PZEV) Camry HV PREVIOUS PART NUMBER CURRENT PART NUMBER PART NAME Fuel Tank Assembly (Federal Specification Emission System) Same Charcoal Canister Assembly Avalon Solara Avalon Solara Fuel Tank Assembly (California Emission [PZEV] System) Same Charcoal Canister Assembly N/A Canister Assembly, Trap w/outlet Valve N/A Fuel Tank Assembly N/A Charcoal Canister Assembly N/A Valve Assembly, Fuel Tank Solenoid Main Fuel Tank Assembly Same Charcoal Canister Assembly QTY Required Tools & Material REQUIRED EQUIPMENT SUPPLIER PART NUMBER QTY TIS Techstream* NOTE: Software version or later is required. * Essential SSTs. ADE TSUNT NOTE: Additional Techstream units may be ordered by calling Approved Dealer Equipment (ADE) at The Toyota Diagnostic Tester and CAN Interface Module may also be used to perform the service procedures listed in this bulletin. Page 3 of 6
4 Repair Procedure. Duplicate customer complaint (stalling or rough idle) or confirm if EVAP system DTCs are stored using TIS Techstream. 2. Confirm if the condition (stalling or rough idle) occurs when Purge VSV is turned ON with engine running at idle. A. Connect the Techstream unit to the vehicle. B. Enter the following menus: Powertrain / Engine / Active Test / VSV for EVAP Control C. Select Activate the VSV for Evap Control. D. Use the toggle buttons to turn Active Test ON or OFF and confirm if the vehicle stalls or runs rough when Active Test is ON. If the vehicle stalls or runs rough when Active Test is ON, go to step 3. If NOT, this TSB does NOT apply. Continue diagnostics per the Repair Manual. 3. Check for fuel in the EVAP system by disconnecting the vent line from the charcoal canister at the trap filter. Is liquid fuel present in the EVAP system? If YES Go to step 4. If NO This TSB does NOT apply. Continue diagnostics per the Repair Manual. 4. Remove the fuel tank assembly and the charcoal canister assembly. Refer to the Technical Information System (TIS), applicable model and model year Repair Manual: 2007 model year Avalon Repair Manual: Engine/Hybrid System Fuel System 2GR FE Fuel: Fuel Tank: Removal Engine/Hybrid System Emission Control 2GR FE Emission Control: Canister: Removal 2007 model year Camry Repair Manual: Engine/Hybrid System Fuel System 2AZ FE / 2GR FE Fuel: Fuel Tank: Removal Engine/Hybrid System Emission Control 2AZ FE / 2GR FE Emission Control: Canister: Removal 2007 model year Camry HV Repair Manual: Engine/Hybrid System Fuel System 2AZ FXE Fuel: Fuel Tank: Removal Engine/Hybrid System Emission Control 2AZ FXE Emission Control: Canister: Removal 2007 model year Solara Repair Manual: Engine/Hybrid System Fuel System 2AZ FE / 3MZ FE Fuel: Fuel Tank: Removal Engine/Hybrid System Emission Control 2AZ FE / 3MZ FE Emission Control: Canister: Removal Page 4 of 6
5 Repair Procedure (Continued) 5. Drain all remaining fuel in the EVAP system lines (including the trap filter assembly). Air Cleaner Case Throttle Valve Intake Air Intake Manifold Charcoal Filter Air Cleaner Filter When EVAP VSV is Opened, Partial Vacuum is Created Purge Line Leak Detection Area ECM EVAP VSV (Purge Valve) Fuel Tank Cap Vapor Pressure Sensor EVAP Line* Diaphragm (Atmospheric Pressure) Restrictor Passage EVAP Service Port Fuel Tank Purge Line* Charcoal Canister When CCV is Opened, Air is Drawn or Released Charcoal Canister Filter* (Trap Filter) CCV Air Inlet Line* * Check These Lines for Liquid Fuel Page 5 of 6
6 Repair Procedure (Continued) 6. Install the NEW fuel tank assembly and the NEW charcoal canister assembly. Refer to TIS, applicable model and model year Repair Manual: 2007 model year Avalon Repair Manual: Engine/Hybrid System Emission Control 2GR FE Emission Control: Canister: Installation Engine/Hybrid System Fuel System 2GR FE Fuel: 2007 model year Camry Repair Manual: Engine/Hybrid System Emission Control 2AZ FE / 2GR FE Emission Control: Canister: Installation Engine/Hybrid System Fuel System 2AZ FE / 2GR FE Fuel: 2007 model year Camry HV Repair Manual: Engine/Hybrid System Emission Control 2AZ FXE Emission Control: Canister: Installation Engine/Hybrid System Fuel System 2AZ FXE Fuel: 2007 model year Solara Repair Manual: Engine/Hybrid System Emission Control 2AZ FE / 3MZ FE Emission Control: Canister: Installation Engine/Hybrid System Fuel System 2AZ FE / 3MZ FE Fuel: 7. Clear all stored DTCs. Page 6 of 6
M.I.L. "ON" DTC P2237, P2238, P2240, or P2241
T-SB-0278-08 September 5, 2008 Service Category Engine/Hybrid System Section Engine Control Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2008 Avalon 2008 2009 Camry Introduction Some
More informationYEAR(S) MODEL(S) ADDITIONAL INFORMATION Camry Engine(s): 2AZ Transmission(s): 5AT VDS(s): BE46K
T-SB-0212-09 July 15, 2009 Service Category Engine/Hybrid System Section Engine Control Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2007 2009 Camry Engine(s): 2AZ Transmission(s):
More informationYEAR(S) MODEL(S) ADDITIONAL INFORMATION Camry Engine(s): 2AZ VDS(s): BE30K, BE32K Solara Engine(s): 2AZ VDS(s): CE30P, CE38P
T-SB-0242-09 July 31, 2009 Service Category Engine/Hybrid System Section Engine Control Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2005 2006 Camry Engine(s): 2AZ VDS(s): BE30K, BE32K
More informationVibration Between MPH
T-SB-0069-08 Rev1 May 21, 2008 Service Category Engine/Hybrid System Section Engine Control Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2007 2009 Camry Engine(s): 2AZ Transmission(s):
More informationMIL "ON" P043E, P043F, P2401, P2402, & P2419 Due to Water Intrusion into Charcoal Canister
T-SB-0200- December 6, 20 MIL "ON" P043E, P043F, P240, P2402, & P249 Due to Water Intrusion into Service Category Engine/Hybrid System Section Emission Control Market USA Applicability YEAR(S) MODEL(S)
More informationMIL "ON" DTC P0A0F, P3190, P3191, P0171 Due to Purge VSV Vacuum Line Separation
T-SB-0041-15 June 30, 2015 MIL "ON" DTC P0A0F, P3190, P3191, P0171 Due to Purge VSV Vacuum Line Service Category Engine/Hybrid System Section Engine Control Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL
More informationSmart Key Intermittent No Crank / No Start
T-SB-0003-09 Rev1 January 7, 2009 Service Category Vehicle Interior Section Theft Deterrent/Keyless Entry Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2005 2008 Avalon 2007 2008 Camry,
More informationMIL "ON" DTC P0A80 due to Dust or Debris in HV Battery Cooling Fan
T-SB-0098-12 July 13, 2012 MIL "ON" DTC P0A80 due to Dust or Debris in HV Battery Cooling Fan Service Category Engine/Hybrid System Section Hybrid/Battery Control System Market USA Applicability YEAR(S)
More informationECM/TCM Calibration: Shift Feeling Enhancement
T-SB-0287-10 October 13, 2010 Service Category Engine/Hybrid System Section Engine Control Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2010 2011 Camry Engine(s): 2AR Transmission(s):
More information2009 Corolla, Matrix Drive Type(s): 2WD Engine(s): 2ZR VDS(s): BL40E, BU40E, KU40E
T-SB-0175-09 Rev1 June 11, 2009 Service Category Engine/Hybrid System Section Engine Control Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2009 Corolla, Drive Type(s): 2WD Engine(s):
More informationSecondary Air Injection System - Water Intrusion: MIL "ON" DTC P0418, P0419, and/or P244#
T-SB-060- October 7, 20 Secondary Air Injection System - Water Intrusion: MIL "ON" DTC P048, P049, Service Category Engine/Hybrid System Section Engine Control Market USA Applicability YEAR(S) MODEL(S)
More informationTSB REVISION NOTICE: October 16, 2003: The Parts Information table has been changed. The previous version on this TSB should be discarded.
Technical ervice BULLETIN eptember 29, 2003 Title: M.I.L. ON DTC P0440, P044 OR P0446 Models: 00-03 Avalon, Camry & olara, 0-03 ienna EG03-03 ENGINE TB REVIION NOTICE: October 6, 2003: The Parts table
More informationTitle: TCM CALIBRATION UPDATE: M.I.L. ON DTC P2716 Models: 07 Camry (2GR -FE, 6 -Speed A/T)
Technical Service BULLETIN December 12, 2006 Title: TCM CALIBRATION UPDATE: M.I.L. ON DTC P2716 Models: 07 Camry (2GR -FE, 6 -Speed A/T) TSB REVISION NOTICE: S January 12, 2007: Production Change has been
More informationMIL "ON" DTC P0A0F, P3190, P3191, P0171 Due to Purge VSV Vacuum Line Separation
L-SB-0019-15 June 26, 2015 MIL "ON" DTC P0A0F, P3190, P3191, P0171 Due to Purge VSV Vacuum Line Service Category Engine/Hybrid System Section Engine Control Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL
More informationMarket USA. The information contained in this bulletin supersedes SB No. EG
T-SB-0231-12 November 29, 2012 Service Category Engine/Hybrid System Section Cooling Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2004 2007 Prius SUPERSESSION NOTICE The information
More informationTechnical Service BULLETIN
Technical Service BULLETIN July 1, 2004 Title: Models: 02 04 Camry (2AZ FE) (Non PZEV) EG024-04 ENGINE TSB REVISION NOTICE: April 3, 2007: A new step 3 and Figure 2 have been added to the (regarding removal
More informationTechnical Service BULLETIN
Technical Service BULLETIN Introduction November 28, 2007 Title: Models: 07 Tundra Some customers may complain about a M.I.L. ON condition with DTC P2714 (Pressure Control Solenoid D Performance Shift
More informationTechnical Service BULLETIN
Technical Service BULLETIN February 8, 2005 Title: Models: 04 05 Camry (V6) EG009-05 ENGINE Introduction Under certain driving conditions, some 2004 and 2005 model year Camry vehicles may exhibit a M.I.L.
More informationYEAR(S) MODEL(S) ADDITIONAL INFORMATION. The Warranty Information and Parts Information sections have been updated.
T-SB-0044-14 Rev1 July 7, 2014 Service Category Engine/Hybrid System Section Engine Control Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2012 2014 Tacoma REVISION NOTICE October 14,
More informationTechnical Service BULLETIN July 1, 2004
2004 Camry (L4 2AZFE) Technical Service BULLETIN July 1, 2004 Title: M.I.L. "ON" DTC P0420 Models: 02 04 Camry (2AZ FE) (Non PZEV) Report a problem with this article TSB REVISION NOTICE: April 3, 2007:
More informationMIL "ON" DTC P2195, P0138, and/or P0031
T-SB-0065-10 February 5, 2010 Service Category Engine/Hybrid System Section Engine Control Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2009 Corolla Engine(s): 2ZR Transmission(s):
More informationTechnical Service BULLETIN
Technical Service BULLETIN February 16, 2006 Title: Models: 03 06 Camry, 04 05 Highlander, & 04 06 Solara, ST001-06 STEERING TSB REVISION NOTICE: July 20, 2006: 2004 2005 model year Highlander vehicles
More informationMIL "ON" DTC P2195, P0138, and/or P0031
T-SB-0066-10 February 5, 2010 Service Category Engine/Hybrid System Section Engine Control Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2010 Corolla Engine(s): 2ZR Transmission(s):
More informationTechnical Service BULLETIN
Technical Service BULLETIN November 23, 2005 Title: Models: 03 & EG062-05 ENGINE Introduction Under certain driving conditions, some 2003 model year and vehicles equipped with a 2AZ FE engine may exhibit
More information2GR-FE Engine Ticking Noise and/or MIL "ON" P0014, P0015, P0024, P0025, P0017, or P0018
T-SB-0094-09 Rev1 March 19, 2009 2GR-FE Engine Ticking Noise and/or MIL "ON" P0014, P0015, P0024, P0025, Service Category Engine/Hybrid System Section Engine Mechanical Market USA Applicability YEAR(S)
More informationYEAR(S) MODEL(S) ADDITIONAL INFORMATION. The information contained in this TSB supersedes TSB No. T-SB
T-SB-0163-11 October 20, 2011 Service Category Vehicle Interior Section Heating/Air Conditioning Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2006 2011 Avalon 2007 2011 Camry, Camry
More information2AZ-FE Engine Oil Consumption
T-SB-0094-11 August 11, 2011 Service Category Engine/Hybrid System Section Lubrication Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2007 2011 Camry HV Engine(s): 2AZ VDS(s): BB3EK,
More informationTechnical Service BULLETIN
Technical Service BULLETIN April 6, 2007 Title: Models: 04 & EG07-07 ENGINE Introduction Under certain driving conditions, some 2004 model year and vehicles may exhibit a M.I.L. ON condition with DTC P033
More informationMIL "ON" - DTC P0087/P Fuel Rail / System Pressure Too Low
L-SB-0050-5 September 9, 205 MIL "ON" - DTC P0087/P008700 - Fuel Rail / System Pressure Too Low Service Category Engine/Hybrid System Section Fuel System Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL
More informationHesitation on Acceleration
L-SB-0033-08 Rev2 June 6, 2008 Service Category Engine/Hybrid System Section Engine Control Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2007 2012 LS460 2008 2012 LS600H REVISION NOTICE
More informationTitle: M.I.L. ON DTC P3191, P3190, AND/OR P0A0F Models:
Technical Service BULLETIN October 18, 2004 Title: M.I.L. ON DTC P3191, P3190, AND/OR P0A0F Models: 04-05 Prius EG047-04 ENGINE TSB REVISION NOTICE: S February 22, 2005: Applicable Vehicles has been updated
More informationM.I.L. "ON" DTC P0101, P0121, P0171, P0172, P035#, P223#
T-SB-0379-08 November 26, 2008 M.I.L. "ON" DTC P0101, P0121, P0171, P0172, P035#, P223# Service Category Engine/Hybrid System Section Engine Control Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL
More informationTechnical Service BULLETIN
Technical Service BULLETIN July 2, 2004 Title: Models: 03 04 Matrix (ZZ FE) EG026-04 ENGINE TSB REVISION NOTICE: October 8, 2004: Part number for replacement (PCM) in Figure 2 on page 5 has been updated;
More informationOil Filter Cap Assembly Precautions
T-SB-0104-09 Rev1 April 10, 2009 Service Category Engine/Hybrid System Section Lubrication Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2010 2011 4Runner, Camry, FJ Cruiser, Prius 2009
More information2AZ Engine Oil Consumption Inspection Procedure
T-SB-0158-14 Rev2 December 12, 2014 Service Category Engine/Hybrid System Section Lubrication Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2007 2011 Camry HV Engine(s): 2AZ VDS(s):
More information1st to 2nd Gear Upshift Shudder
T-SB-0089-2 June 5, 202 Service Category Drivetrain Section Automatic Transmission/Transaxle Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 200 202 Drive Type(s):, Engine(s): GR Transmission(s):
More informationM.I.L. "ON" DTC B2799 "No Start" Due to Harness Water Intrusion
T-SB-0220-08 Rev1 August 11, 2008 M.I.L. "ON" DTC B2799 "No Start" Due to Harness Water Intrusion Service Category Vehicle Interior Section Theft Deterrent/Keyless Entry Market USA Applicability YEAR(S)
More information2GR-FE Engine Ticking Noise and / or MIL ON P0014, P0015, P0024, P0025, P0017, or P0018
T-SB-0094-09 March 19, 2009 2GR-FE Engine Ticking Noise and / or MIL ON P0014, P0015, P0024, P0025, Service Category Engine/Hybrid System Section Engine Mechanical Market USA Applicability YEAR(S) MODEL(S)
More informationAB60 Transmission C1 Clutch Damage
T-SB-0170-09 June 4, Service Category Drivetrain Section Automatic Transmission/Transaxle Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2008 Sequoia Drive Type(s):, 2WD Engine(s): 3UR
More informationRear HVAC Vents Blow Hot Air with A/C "ON"
T-SB-0143-08 July 30, 2008 Service Category Vehicle Interior Section Heating/Air Conditioning Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2005 2007 Avalon TSB SUPERSESSION NOTICE The
More information4/24/2017 A L L Diagnostic Trouble Codes ( DTC ) Testing and Inspection, P Code Charts: P0441
Vehicle» A L L Diagnostic Trouble Codes ( DTC )» Testing and Inspection» P Code Charts» P0441 DTC P0441 Evaporative Emission Control System Incorrect Purge Flow CIRCUIT DESCRIPTION http://repair.alldata.com/alldata/article/display.action?componentid=3926&itypeid=423&nonstandardid=2379425&vehicleid=38048&windowname=mainadonlin
More informationAbnormal Noise when Brake Pedal Released
T-SB-0363-10 December 22, 2010 Service Category Brake Section Brake Control/Dynamic Control System Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2010 2011 Prius Introduction Some 2010
More information2AZ-FE Engine Oil Consumption
T-SB-0094-11 Rev2 August 11, 2011 Service Category Engine/Hybrid System Section Engine Mechanical Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2007 2011 Camry HV Engine(s): 2AZ VDS(s):
More informationMIL "ON" DTC P030# and/or Intermittently Runs Rough
L-SB-0029-10 May 12, 2010 Service Category Engine/Hybrid System Section Engine Control Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2006 2010 IS250 Introduction Some 2006 2010 model
More informationDocument ID: General Motors Corporation. All rights reserved.
Page 1 of 7 Document ID: 1274962 #02-06-01-016A: (MIL) Service Engine Soon Telltale Illuminated With DTCs P0171 and/or P0174 (Retorque Intake Manifold Vacuum Chamber Bolts, Install Vacuum Chamber Springs)
More informationECM Calibration: Shift Feeling Enhancements
T-SB-0077-16 July 14, 2016 Service Category Drivetrain Section Automatic Transmission/Transaxle Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2016 Tacoma VDS(s): AZ5CN, BZ5DN, CZ5AN,
More informationMIL "ON" DTC P0012 and/or P0022
T-SB-0019-10 January 0, 010 Service Category Engine/Hybrid System Section Engine Control Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 010 Sequoia, Tundra Engine(s): 1UR, 3UR Introduction
More informationTechnical Service Information Bulletin
Technical Service Information Bulletin August 4, 2003 Title: Models: 02 03 ES 300 & 04 05 ES 330 REVISION NOTICE: April 1, 2005: 2004 2005 model year ES 330 vehicles have been added to Applicable Vehicles.
More informationTransaxle Whine Noise
T-SB-030-2 August 8, 202 Service Category Drivetrain Section Automatic Transmission/Transaxle Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2006 202 RAV4 Drive Type(s): 4WD, 2WD Engine(s):
More informationYEAR(S) MODEL(S) ADDITIONAL INFORMATION
T-SB-0007-11 January 7, 2011 Service Category Drivetrain Section Automatic Transmission/Transaxle Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2009 2011 RAV4 Drive Type(s):, Engine(s):
More informationYEAR(S) MODEL(S) ADDITIONAL INFORMATION. 1. Review DTC P0705 Freeze Frame Data to determine if this TSB may be applicable.
T-SB-0277-09 August 18, 2009 Service Category Drivetrain Section Automatic Transmission/Transaxle Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2005 2009 Tacoma Introduction Some 2005
More informationNoise from Auxiliary Port with External Device
T-SB-0067-08 May 2, 2008 Service Category Audio/Visual/Telematics Section Audio/Video Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2006 2008 4Runner, Prius, RAV4 2007 Camry, Camry HV,
More informationVibration Between MPH
L-SB-0013-12 March 14, 2012 Service Category Drivetrain Section Automatic Transmission/Transaxle Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2009 2012 LS460 Drive Type(s): 4WD VDS(s):
More informationTechnical Service BULLETIN
Technical Service BULLETIN December 15, 2007 Title: Models: 04 07 Sienna EL011-07 ELECTRICAL Introduction Some customers may experience difficulty when using the power close feature of the power back door
More informationTechnical Service BULLETIN
Technical Service BULLETIN August 0, 2007 Title: Models: 06 07 4Runner, Prius, & RAV4 & 07 Camry,, FJ Cruiser, Solara, & Yaris AU004-07 AUDIO Introduction Some customers may notice noise in the auxiliary
More informationTorque Converter Flex Lock-up Shudder
T-SB-0023-5 Rev May 2, 205 Service Category Drivetrain Section Automatic Transmission/Transaxle Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 203 205 RAV4 REVISION NOTICE August 3, 207
More information2ZR-FXE Engine Oil Consumption Inspection Procedure
T-SB-0168-16 November 16, 2016 Service Category Engine/Hybrid System Section Engine Mechanical Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2010, 2012-2014 Prius PHV 2012-2014 Prius
More informationTechnical Service Information Bulletin
Technical Service Information Bulletin August 2, 2006 Title: Models: 07 ES 350 TSIB REVISION NOTICE: August 7, 2006: The OFP has been updated in Warranty Information. Applicable Warranty has been changed
More informationIntermittent MIL"ON" DTC P0335
T-SB-0192-12 October 15, 2012 Service Category Vehicle Interior Section Meter/Gauge/Display Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2007 2011 Camry HV Engine(s): 2AZ VDS(s): BB3EK,
More information13. Evaporative Emission Control System
85 13. Evaporative Emission Control System General The evaporative emission control system prevents the fuel vapors that are created in the fuel tank from being released directly into the atmosphere. The
More informationTechnical Service BULLETIN
Technical Service BULLETIN May 28, 2004 Title: Models: 03 04 Corolla EG016-04 ENGINE Introduction Some customers may complain of excessive sulfur dioxide odor on 2003 2004 model year Corolla vehicles under
More informationIntermittent Battery Discharge
L-SB-0035-16 July 8, 2016 Service Category Power Source/Network Section Battery/Charging Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2013-2014 ES350, GS350 2014-2015 IS250, IS350 Introduction
More informationFederal and California Emissions Warranties Parts List
Emissions warranties are state specific. Refer to the years/miles 1 columns below as follows: A Minimum coverage for all vehicles in all states. B Vehicles registered and normally operated in California,
More informationEntune Audio Head Unit Software Update (Pioneer)
T-SB-0047-14 July 23, 2014 Service Category Audio/Visual/Telematics Section Audio/Video Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2014 4Runner, Camry, Camry HV, Highlander, Highlander
More informationSRS Airbag Light "ON" - B0111/B0116 Open Side Squib Circuit
T-SB-0069-12 May 1, 2012 SRS Airbag Light "ON" - B0111/B0116 Open Side Squib Circuit Service Category Vehicle Interior Section Supplemental Restraint Systems Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL
More information7. Evaporative Emission Control System
W1860BE.book Page 10 Tuesday, January 28, 2003 11:01 PM 7. Evaporative Emission Control System A: GENERAL The evaporative emission control system prevents fuel vapors from escaping into atmosphere. This
More informationSide Window Glass Noise During Operation
T-SB-0077-12 May 21, 2012 Service Category Vehicle Exterior Section Window/Glass Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2012 Camry, Camry HV Introduction Some 2012 Camry and Camry
More informationEvaporative Emission Control System Operation Description (Enhanced)
Page 1 of 7 1999 Chevrolet Chevy Suburban - 2WD Escalade, Pickup (Classic), Suburban, Tahoe, Yukon (VIN C/K) Service Manual Document ID: 222842 Evaporative Emission Control System Operation Description
More informationMoon Roof Assembly Structure Noise
T-SB-05-3 Rev2 October 2, 203 Service Category Vehicle Exterior Section Exterior Panels/Trim Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 203 205 Avalon, Avalon HV WMI(s): 4T 202 206
More informationATF Leak from Transfer Case
T-SB-0335-08 November 3, 2008 Service Category Drivetrain Section Transfer/4wd/Awd Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2008 Highlander Drive Type(s): 4WD Engine(s): 2GR Transmission(s):
More informationTech-Note. The following GM Service Bulletin pertains to possible intake manifold leaks affecting Saturn VUE 3.0L.
Tech-Note The following GM Service Bulletin pertains to possible intake manifold leaks affecting 2002-2003 Saturn VUE 3.0L. Even the smallest vacuum leak is capable of causing false catalytic converter
More informationTechnical Service BULLETIN
Technical Service BULLETIN November 10, 2005 Title: Models: 05 Tacoma SU002-05 SUSPENSION TSB REVISION NOTICE: November 11, 2005: Production Change Production Change Effective VINs have been updated. Warranty
More informationUpper/Lower Windshield/Rear Glass Tick Noise
T-SB-0142-08 Rev1 July 29, 2008 Service Category Vehicle Exterior Section Window/Glass Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2003 2009 4Runner, Avalon, Camry, Camry HV, Celica,
More information1998 Toyota Camry CE Sedan L4-2164cc 2.2L DOHC MFI BO026- BR Brakes - Pad Clicking Noise ST004- EG009- BO001-
[object] Page 1 of 2 1998 Toyota Camry CE Sedan L4-2164cc 2.2L DOHC MFI Top - Vehicle.. Technical Service Bulletins EG013-020712 Emissions System - MIL ON/DTC's. Customer Interest 02 P0440/P0441/P0446
More information1 CONFIRM DTC 2 PERFORM EVAP SYSTEM CHECK 3 CHECK OPERATION FOR PRESSURE SWITCHING VALVE INSPECTION PROCEDURE ES 240
240 1NZ-FXE EINE CONTROL SYSTEM SFI SYSTEM INSPECTION PROCEDURE 1 CONFIRM DTC Turn the power switch OFF and wait for 10 seconds. Turn the power switch ON (IG). (c) Turn the power switch OFF and wait for
More informationMIL "ON" DTC P030#, Intermittently Runs Rough, and/or Engine Oil Consumption
L-SB-0068-11 Rev1 August 11, 2011 MIL "ON" DTC P030#, Intermittently Runs Rough, and/or Engine Oil Consumption Service Category Engine/Hybrid System Section Engine Control Market USA Applicability YEAR(S)
More informationTechnical Service BULLETIN
Technical Service BULLETIN November 20, 2002 Title: Models: 01 02 Prius EG021-02 ENGINE Introduction Under certain driving conditions, some Prius vehicles may exhibit a Master, Hybrid and M.I.L. Warning
More informationTechnical Service BULLETIN
Technical Service BULLETIN March 31, 2006 Title: Models: 03 05 Sequoia BR006-06 BRAKES TSB REVISION NOTICE: August 3, 2007: Step 1A of the has been updated. Previous versions of this TSB should be discarded.
More informationSmart Key Intermittent No Crank/No Start
L-SB-0161-08 Rev1 November 11, 2008 Service Category Vehicle Interior Section Theft Deterrent/Keyless Entry Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2007 2008 ES350, GS350, GS450H,
More informationTechstream ECU Flash Reprogramming Procedure
L-SB-0001-18 January 22, 2018 Service Category Engine/Hybrid System Section Emission Control Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2001-2018 CT200H, ES300H, ES330, ES350, GS
More informationMIL "ON" DTC P030#, Intermittently Runs Rough, and/or Engine Oil Consumption
L-SB-0124-12 November 30, 2012 MIL "ON" DTC P030#, Intermittently Runs Rough, and/or Engine Oil Consumption Service Category Engine/Hybrid System Section Engine Control Market USA Applicability YEAR(S)
More informationDIAGNOSTIC TROUBLE CODE CHART HINT:
DIAGNOSTICS DIAGNOSTIC TROUBLE CODE CHART HINT: SFI SYSTEM (1MZFE) 05241 Parameters listed in the chart may not be exactly the same as your reading due to the type of instrument or other factors. If a
More informationModel(s) Year Eng. Code Trans. Code VIN Range From VIN Range To. Passat Wagon 2007 BPY (2.0L) All 3C_7E C_7E051587
Model(s) Year Eng. Code Trans. Code VIN Range From VIN Range To Passat 2006 BPY (2.0L) All All All Passat 2007 BPY (2.0L) All 3C_7E000001 3C_7P000001 3C_7E051587 3C_7P045144 Passat Wagon 2007 BPY (2.0L)
More informationHYBRID SYSTEMS - HV AND AUXILIARY BATTERY MAINTENANCE
2009 Toyota Camry L4-2.4L (2AZ-FXE) Hybrid Vehicle > Hybrid Drive Systems > Battery System, Hybrid Drive > Technical Service Bulletins HYBRID SYSTEMS - HV AND AUXILIARY BATTERY MAINTENANCE T-SB-0007-08
More informationTechnical Service BULLETIN
Technical Service BULLETIN December 4, 2003 Title: Models: 03 4Runner BR005-03 BRAKES Introduction Some 2003 model year 4Runner vehicles may experience a VSC light ON condition and DTC C1203 in the Skid
More information1GR-FE ENGINE CONTROL SYSTEM SFI SYSTEM
1GR-FE ENGINE CTROL SYSTEM SFI SYSTEM 349 EVP System RELTED DTCS DTCs Monitoring Items See procedure P043E 0.02 inch orifice clogged (built into pump module) -212 P043F 0.02 inch orifice high-flow (built
More informationPrevious versions of this TSB should be discarded. TSB UPDATE NOTICE: The information contained in this TSB supersedes TSB No. PG
BATTERY MAINTENANCE FOR IN-STOCK VEHICLES & PRE-DELIVERY -2008... Page 1 of 31 BATTERY MAINTENANCE FOR IN-STOCK VEHICLES & PRE-DELIVERY TECHNICAL SERVICE BULLETIN Reference Number(s): PG001-06, Date of
More informationTechnical Service BULLETIN
Technical Service BULLETIN Title: Models: 01 03 Sequoia TSB UPDATE NOTICE: The information contained in this TSB supercedes TSBs AC001 01 and AC001 02. The previous TSBs, AC001 01 and AC001 02, should
More informationHigh Beam/DRL Bulb Inoperative
T-SB-0044-10 Rev2 January 27, 2010 Service Category Vehicle Exterior Section Lighting (ext) Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2008 2010 Avalon TSB REVISION NOTICE October
More information2ZR-FXE Engine Oil Consumption Repair Procedure
T-SB-0169-16 November 16, 2016 Service Category Engine/Hybrid System Section Engine Mechanical Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2010, 2012-2014 Prius PHV 2012-2014 Prius
More informationP0441-EVAP PURGE SYSTEM PERFO... P0441-EVAP PURGE SYSTEM PERFORMANCE
P0441-EVAP PURGE SYSTEM PERFO... P0441-EVAP PURGE SYSTEM PERFORMANCE For a complete wiring diagram, refer to the Wiring Information. Theory of Operation EVAP SYSTEM COMPONENTS CALLOUT DESCRIPTION 1 Filter
More informationTechnical Service BULLETIN
Technical Service BULLETIN Introduction November 28, 2005 Title: Models: 04 06 Sequoia Some 2004 2006 model year Sequoia vehicles may display one of the following conditions from corrosion inside of the
More informationFront Seat Squeak Noise
T-SB-0288-08 Rev1 September 8, 2008 Service Category Vehicle Interior Section Seat Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2004 2010 4Runner, Avalon, Camry, Corolla, Echo, FJ Cruiser,
More informationTechnical Service BULLETIN
Technical Service BULLETIN March 9, 004 Title: Models: 03 04 4Runner BO005-04 BODY TSB REVISION NOTICE: April 8, 004: A note has been added to step 4 on page 3 to clarify the removal of the roof rack.
More informationDIAGNOSTIC TROUBLE CODE CHART
DIAGNOSTIC TROUBLE CODE CHART 05 35 HINT: As for the vehicle for MEXICO, refer to Repair Manual 2003 COROLLA MATRIX (Pub. No. RM940U). Parameters listed in the chart may not be exactly the same as your
More informationCharging System Inoperative
T-SB-0055-12 March 13, 2012 Service Category Power Source/Network Section Battery/Charging Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2011 Avalon, RAV4, Venza 2011 2012 Camry, Highlander,
More informationFront Seat Squeak Noise
T-SB-0288-08 September 8, 2008 Service Category Vehicle Interior Section Seat Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2004 2009 4Runner, Avalon, Camry, Camry HV, Celica, Corolla,
More information2UZ-FE ENGINE CONTROL SYSTEM SFI SYSTEM. DTC No. Monitoring Items See procedure
428 2UZ-FE ENGINE CTROL SYSTEM SFI SYSTEM EVP System RELTED DTCS DTC No. Monitoring Items See procedure P043E P043F P0441 P0450 P0451 P0452 P0453 P0455 P0456 P2401 P2402 P2419 Reference orifice clogged
More informationDTC P0440 Evaporative Emission Control System Malfunction
DIAGNOSTICS EINE DI81 DI1JZ07 DTC P0440 Evaporative Emission Control System Malfunction CIRCUIT DESCRIPTION The vapor pressure sensor, VSV for canister closed valve (CCV) and VSV for pressure switching
More informationTechnical Service BULLETIN
Technical Service BULLETIN September 12, 2002 Title: Models: 00 05 Tundra BR004-02 BRAKES TSB REVISION NOTICE: April 4, 2005: Applicable Vehicles has been updated to include 2003 2005 model years. The
More information