VAC.LINE TO HEATER-A/C CONTROLS (BLUE) HOSE (700) CABLE TO INTAKE MANIFOLD VALVE VAC. LINE (GREEN) HOSE (1200)

Transcription

1 WG NO SHEET HSSIS RELESE REV TE WG NO WORKHORSE GS ENGINE FOR F P-SERIES FREIGHTLINER R-SERIES FREIGHTLINER 9-0, J-SERIES FREIGHTLINER 9-0, WORKHORSE IESEL ENGINE (0) (00) V.LINE TO HETER-/ ONTROLS (LUE) LE () REV ZONE REVISION REOR TE FTR-ORIG WORKHORSE GS ENGINE E-SERIES(UP TO 0-0-0) -SERIES(UP TO 0-0-0) J-SERIES(UP TO 0--0) V.LINE (GREEN) SS VLVE-WTER, PORT TO RITOR TO INTKE MNIFOL (0) VLVE TEE F () W RITOR ETIL LMP (0) (0) V. LINE (GREEN) (00) LMP () ) F W (0) ELETRIL PLUGS TO MOTOR I (SEE MOTOR I INSTL) / ONENSOR (SUPPLIE W/HSSIS F FROM V.RESERVOIR TO ENGINE V. SOURE (LK) TEMP W TO INTKE MINFOL VIEW - LOW PRESSURE SWITH WORKHORSE SUPPLIE TO / ONENSOR RYER SM EVP/RYER NON-HRGE TO OMPRESSER KIT #0 SMEVP/RYER NON-HRGE V. RESERVOIR PTER GROMMET SELER (0) (00) FROM V. RESERVOIR TO HETER ONTROLS (LK) HETER-/ ONTROL OPYRIGHT 009 WINNEGO R INUSTRIES, IN. FROM WORKHORSE WIRE HRNESS FTR ORIG. TE. TORQUE TO - LS.. TORQUE TO 0 IN/LS. HKR P.E. M.E. LL IMENSIONS RE IN MILLIMETERS FIRST USE. TORQUE TO - FT/LS. THRU FIREWLL.. FROM HETER-/ HRNESS. USE (0).. USE NTI-FEEZE P/N (/R). WORKHORSE HSSIS WITHOUT ELETRI RITOR OOLINF FN,EVUTE OMPLETE SYSTEM TO 0 MIRONS N HEK FOR LEKS, HRGE SYSTEM WITH OZ. OZ OF P/N R FREON. W WTR HTR-GL/ELE/LP/MOTORI WTR HTR-0GL/OUTPUT/MTRI SNR UNSPEIFIE TOLERNES RE: WHOLE IM (X) ONE-PLE (X.X). TWO-PLE (X.XX) 0.0 MTERIL: 0 WORKHORSE NOTES:. ONNET WIRE NER RITOR ON WORKHORSE HSSIS TO / THERMOSTT.. TORQUE TO - FT/LS.. WORKHORSE REQUIRES PROUTION TO INSTLL N TORQUE TO -0 IN/LS, THE WORKHORSE SUPPLIE LOW PRESSURE SWITH IN #0 KIT N PLUG IN WIRE. 0. WORKHORSE HSSIS WITH ELETRI RITOR OOLING FN, EVUTE OMPLETE SYSTEM TO 0 MIRONS N HEK FOR LEKS, HRGE SYSTEM WITH OZ. OZ OF P/N R FREON. 9. LURITE LL O-RINGS WITH REFRIGERNT OIL.. LEVE PS ON S UNTIL FINL ONNETIONS IS ME. L ONLY WTR HTR-0GL/ELE/LP/MTRI WTR HTR-UX UTO/MOTORI F HETER-UXILIRY UTOMOTIVE HETER-UXILIRY UTO W/O NGLE THIR NGLE PROJETION TITLE: O NOT SLE RWING HETER-/ INSTL,HSSIS PRT NO SHEET OF 9 REV REF: //009

2 WG NO SHEET HSSIS RELESE REV TE WG NO WORKHORSE (GS) REV ZONE REVISION REOR TE FTR-ORIG 9-0 FOR F (GS) M/P-SERIES FREIGHTLINER (IESEL) R/S-SERIES FREIGHTLINER (IESEL) (0) 9-0, J/K-SERIES FREIGHTLINER (IESEL) 9-0, WORKHORSE (IESEL) LMP () ELETRONI WTER VLVE (0) (0) TO RITOR (RETURN) (000) RITOR ETIL 0--0 (00) TO INTKE MNIFOL (SUPPLY) VLVE-WTER, PORT (INSTLL WITH RROW POINTING TO HETER ORE) G9-0-U () TO RITOR (RETURN) (00) TEE F W () LMP () 0--0 ( GS) 0--0 F (0 IESEL) W (0) 9 TO MOTOR I (SEE MOTOR I INSTL) (SUPPLY) (RETURN) V.LINE (LUE) TO IR REIRULTION OOR VUUM MOTOR FROM HETER / ONTROL PNEL / ONENSOR (SUPPLIE W/HSSIS GROMMET SELER TEMP (000) ( GS) 0--0 (00 IESEL) (0) F W 9 RESERVOIR-VUUM TO INTKE MINFOL (SUPPLY) TO / ONENSOR RYER SM EVP/RYER NON-HRGE ( GS) 0--0 (0 IESEL) TO ENGINE VUUM SOURE ON RER OF INTKE MNIFOL. TO OMPRESSER KIT #0 SM EVP/OMP NON-HRGE PIN HOUSING FROM HETER / ONTROL PNEL FROM V. RESERVOIR TO HETER ONTROLS (LK) HETER-/ ONTROL 0USE UT OFF HSSIS. 9. L ONLY. VIEW - LOW PRESSURE SWITH WORKHORSE SUPPLIE FROM V.RESERVOIR TO ENGINE V. SOURE (LK) R OPYRIGHT 00 WINNEGO INUSTRIES, IN. NOTES:. LUE WIRE FROM HETER-/ HRNESS.. WHEN MOTORI TUE ONTTS NY HSSIS OMPONENT THE SHLL E POTETE Y ONUIT USE NTIFREEZE (/R). EVUTE OMPLETE SYSTEM TO 0 MIRONS N HRGE SYSTEM WITH R REFRIGERNT P/N SEE ENGINEERING SPEIFITION ES00 FOR REFRIGERNT HRGE N REFRIGERNT LINE TORQUE VLUES.. LURITE LL O-RINGS WITH REFRIGERNT OIL.. LEVE PS ON S UNTIL FINL ONNETION IS ME. PPLY GIMP OVER LL SHRP EGES THT MY ROSS S.. WORKHORSE REQUIRES PROUTION TO INSTLL N TORQUE TO -0 IN/LS, THE WORKHORSE SUPPLIE LOW PRESSURE SWITH IN #0 KIT N PLUG IN WIRE. WORKHORSE GS ENGINE E-SERIES(FTER 0--0) -SERIES(FTER 0-0-0) J-SERIES(FTER 0--0) EVNS W F WTR HTR-GL/ELE/LP/MOTORI WTR HTR-0GL/OUTPUT/MTRI WTR HTR-0GL/ELE/LP/MTRI WTR HTR-UX UTO/MOTORI HETER-UXILIRY UTOMOTIVE HETER-UXILIRY UTO W/O FTR HKR P.E. M.E. SNR UNSPEIFIE TOLERNES RE: WHOLE IM (X) ONE-PLE (X.X) TWO-PLE (X.XX) NGLE THIR NGLE PROJETION O NOT SLE RWING TITLE: SHEETOF. 0.0 PRT NO MTERIL: ORIG. TE LL IMENSIONS RE IN MILLIMETERS FIRST USE 0 WORKHORSE REFER TO ES00 FOR FSTENER TIGHTENING GUIELINES HETER-/ INSTL,HSSIS 9 REV REF: /0/00

3 //009 LT. LUE ELETRIL PLUGS V.LINE TO HETER-/ ONTROLS (LUE) FOR F GS ENGINE -SERIES(UP TO 0-0-0) E-SERIES(UP TO 0-0-0) J-SERIES(UP TO 0--0) () V.LINE (GREEN) SS LE VLVE-WTER, PORT FU OR PN (0) IFU OR IPN F TEE () W LOW PRESURE SWITH (000) F TO / ONENSOR SM (00) W VIEW - IFU OR IPN TO OMPRESSER SM SM / ONENSOR (SUPPLIE W/HSSIS TO MOTOR I (SEE MOTOR I INSTL) TEMP (0) VLVE-WTER, PORT PIPE LMP () (0) FROM V.RESERVOIR TO ENGINE V. SOURE (LK) ETIL V. RESERVOIR (0) LMP () TO INTKE MNIFOL PTER V.LINE (GREEN) (00) TO WTER PUMP GROMMET SELER (00) (00) ETIL V.LINE (YELLOW) HETER-/ ONTROLS HETER-/ ONTROL. TORQUE TO 0 IN/LS.0. USE UT OFF HSSIS.. ONNETS TO SUTION PIPE SUPPLIE ON HSSIS. 0. USE NTI-FREEZE (/R) 9. LURITE LL O-RINGS WITH REFRIGERNT OIL. V.LINE (RE) FROM V. RESERVOIR TO HETER ONTROLS (LK). LEVE PS ON S UNTIL FINL ONNETIONS IS ME.. EVUTE OMPLETE SYSTEM TO 0 MIRONS N HEK FOR LEKS. HRGE SYSTEM WITH OZ. OZ OF R FREON.. FOR SUPPLIE W WTR HTR-GL/ELE/LP/MOTORI WTR HTR-0GL/OUTPUT/MTRI. TORQUE TO - FT/LS WTR HTR-0GL/ELE/LP/MTRI. TORQUE TO - FT/LS. THROUGH FIREWLL. FROM HETER-/ HRNESS. FROM WIRE SM-IP. MIN NOTES: L ONLY. 00 FOR.. PRIOR TO 00 FOR. VIEW - V.LINE (WHITE) WTR HTR-UX UTO/MOTORI F HETER-UXILIRY UTOMOTIVE HETER-UXILIRY UTO W/O HETER-/ INSTL,HSSIS 9

4 WG NO (0) (0) LMP- WORMGER () ELETRONI WTER VLVE VLVE-WTER, PORT (INSTLL WITH RROW POINTING TO HETER ORE) G9-0-U () (00) ETIL (000) LMP- WORMGER () (00) (000) TEE F () W F ETIL TO WTER PUMP (RETURN) 0--0 (000) (0) W 9 TO INTKE MNIFOL (SUPPLY) / ONENSOR (SUPPLIE W/HSSIS TO MOTOR I (SEE MOTOR I INSTL) V.LINE TO HETER-/ ONTROLS (LUE) GROMMET SELER TO WTER PUMP (RETURN) TEMP (0) LMP () FROM V. RESERVOIR TO HETER ONTROLS (LK) TO INTKE MNIFOL (SUPPLY) TO / ONENSER SM V. RESERVOIR HETER-/ ONTROL TO OMPRESSER SM PTER VLVE-WTER, PORT ELETRONI LOW PRESURE SWITH -PIN HOUSING FROM HETER / HRNESS FROM V.RESERVOIR TO ENGINE V. SOURE (LK) VIEW - 0USE UT OFF HSSIS. NOTES: 9. L ONLY.. LUE WIRE FROM HETER-/ HRNESS.. WHEN MOTORI TUE ONTTS NY HSSIS OMPONENT THE SHLL E POTETE Y ONUIT USE NTIFREEZE (/R). EVUTE OMPLETE SYSTEM TO 0 MIRONS N HRGE SYSTEM WITH R REFRIGERNT P/N SEE ENGINEERING SPEIFITION ES00 FOR REFRIGERNT HRGE N REFRIGERNT LINE TORQUE VLUES.. LURITE LL O-RINGS WITH REFRIGERNT OIL.. LEVE PS ON S UNTIL FINL ONNETION IS ME. PPLY GIMP OVER LL SHRP EGES THT MY ROSS S.. FROM WIRE SM-IP,MIN FOR F GS ENGINE E-SERIES(FTER 0--0) -SERIES(FTER 0-0-0) J-SERIES(FTER 0--0) EVNS WTR HTR-GL/ELE/LP/MOTORI W WTR HTR-0GL/OUTPUT/MTRI WTR HTR-0GL/ELE/LP/MTRI WTR HTR-UX UTO/MOTORI F HETER-UXILIRY UTOMOTIVE HETER-UXILIRY UTO W/O FIRST USE TITLE: 0 FOR F O NOT SLE RWING HETER-/ INSTL,HSSIS SHEET PRT NO 9 REV /0/00

5 //009 SSEMLY SUTION LINE- TXV TO OMPRESSOR (REF) () (90) LMP () OMPRESSOR ONNETIONS VLVE-WTER -PORT RETURN LINE (FROM WTER PUMP) GREEN VUUM LINE WORKHORSE IESEL ENGINE -SERIES(UP TO 0-0-0) E-SERIES(UP TO 0-0-0) SSEMLY HOT GS LINE- OMPRESSOR TO ONENSER TOP ONNETION (REF) ETIL H SUPPLY LINE (FROM TOP OF ENGINE) SS H H TXV ONNETIONS RETURN LINE (TO TOP OF ENGINE) SSEMLY LIQUI LINE-RIER TO TXV (REF) TO VUUM RESERVOIR VUUM PUMP ROUTE / & HETER LINES OVER HSSIS OMPONENTS LIQUI LINE RIER ONNETIONS H REQUIRE/MNTORY - REFILLING OOLNT SYSTEM PROESS UING OOLNT REFILL TOOL (IUVU000INT) H EVUTE OMPLETE / SYSTEM TO 0 MIRONS N HEK FOR LEKS. HRGE SYSTEM WITH OUNE OF -00-R FREON. 0 WHEN MOTORI TUE ONTTS NY HSSIS OMPONENT THE TUE SHLL E PROTETE Y ONUIT PPLY GIMP OVER LL SHRP EGES THT MY ROSS S.. SEE MOTORI INSTL FOR ITIONL INFORMTION.. USE NTIFREEZE (/R).. LURITE LL O-RINGS WITH REFRIGERNT OIL.. SUPPLIE WITH /-HETER.. LEVE PS ON S UNTIL FINL ONNETION IS ME. SSEMLY LIQUI LINE-ONENSER LOWER ONNETION TO TXV (REF) HSSIS WTER LINES, UT LOOP N ONNET SUPPLY LINE TO WTER VLVE S SHOWN N ONNET RETURN LINE TO ENGINE SUPPLY LINE (FROM WTER PUMP). TORQUE TO 0.0 IN/LS.. TORQUE TO - FT/LS. LIQUI LINE RIER MOUNTE TO PNEL UNER EVPORTOR OIL. (SUPPLIE WITH HSSIS) VIEW H-H WTR HTR-0GL/ELE/LP/MTRI. TORQUE TO - FT/LS. NOTES: VIEW H LL WTR HTR-UX UTO/MOTORI FRTL (FRE),000#-. TIRES HETER- INSTL,HSSIS 9

6 WG NO 9 SSEMLY SUTION LINE- TXV TO OMPRESSOR (REF) () (90) LMP () OMPRESSOR ONNETIONS VLVE-WTER -PORT RETURN LINE (FROM WTER PUMP) GREEN VUUM LINE WORKHORSE IESEL ENGINE SSEMLY HOT GS LINE- OMPRESSOR TO ONENSER TOP ONNETION (REF) ETIL H SUPPLY LINE (FROM TOP OF ENGINE) -SERIES(FTER 0-0-0) E-SERIES(FTER 0--0) EVNS H SSEMLY LIQUI LINE-RIER TO TXV (REF) H TXV ONNETIONS TO VUUM RESERVOIR VUUM PUMP RETURN LINE (TO TOP OF ENGINE) ROUTE / & HETER LINES OVER HSSIS OMPONENTS LIQUI LINE RIER ONNETIONS H REQUIRE/MNTORY - REFILLING OOLNT SYSTEM PROESS UING OOLNT REFILL TOOL (IUVU000INT) H EVUTE OMPLETE / SYSTEM TO 0 MIRONS N HEK FOR LEKS. HRGE SYSTEM WITH OUNE OF -00-R FREON. 0 WHEN MOTORI TUE ONTTS NY HSSIS OMPONENT THE TUE SHLL E PROTETE Y ONUIT PPLY GIMP OVER LL SHRP EGES THT MY ROSS S.. SEE MOTORI INSTL FOR ITIONL INFORMTION. SUPPLY LINE (FROM WTER PUMP). USE NTIFREEZE (/R).. LURITE LL O-RINGS WITH REFRIGERNT OIL.. SUPPLIE WITH /-HETER.. LEVE PS ON S UNTIL FINL ONNETION IS ME. SSEMLY LIQUI LINE-ONENSER LOWER ONNETION TO TXV (REF) HSSIS WTER LINES, UT LOOP N ONNET SUPPLY LINE TO WTER VLVE S SHOWN N ONNET RETURN LINE TO ENGINE. TORQUE TO 0.0 IN/LS.. TORQUE TO - FT/LS. LIQUI LINE RIER MOUNTE TO PNEL UNER EVPORTOR OIL. (SUPPLIE WITH HSSIS) VIEW H-H WTR HTR-0GL/ELE/LP/MTRI FIRST USE 0 /E-SERIES WH O NOT SLE RWING. TORQUE TO - FT/LS. NOTES: VIEW H LL WTR HTR-UX UTO/MOTORI FRTL (FRE),000#-. TIRES TITLE: HETER- INSTL,HSSIS SHEET PRT NO 9 REV /0/00

7 //009 SSEMLY SUTION LINE- TXV TO OMPRESSOR SSEMLY HOT GS LINE- OMPRESSOR TO ONENSER TOP ONNETION SSEMLY LIQUI LINE-RIER TO TXV LIQUI LINE RIER MOUNTE TO PNEL UNER EVPORTOR OIL. (SUPPLIE WITH HSSIS) SSEMLY LIQUI LINE-ONENSER LOWER ONNETION TO TXV OMPRESSOR ONNETION KIT WORKHORSE IESEL ENGINE -SERIES(UP TO 0-0-0) E-SERIES(UP TO 0-0-0) HETER- INSTL,HSSIS 9

8 WG NO 9 SSEMLY SUTION LINE- TXV TO OMPRESSOR SSEMLY LIQUI LINE-RIER TO TXV SSEMLY HOT GS LINE- OMPRESSOR TO ONENSER TOP ONNETION LIQUI LINE RIER MOUNTE TO PNEL UNER EVPORTOR OIL. (SUPPLIE WITH HSSIS) SSEMLY LIQUI LINE-ONENSER LOWER ONNETION TO TXV OMPRESSOR ONNETION KIT WORKHORSE IESEL ENGINE -SERIES(FTER 0-0-0) E-SERIES(FTER 0--0) EVNS FIRST USE 0 /E-SERIES WH O NOT SLE RWING TITLE: HETER- INSTL,HSSIS SHEET 9 PRT NO 9 REV /0/00

9 WG NO PPLITION -SERIES E-SERIES SHEET RE -0-HT () G-0- () NUT () RELESE REV ZONE REV TE REVISION REOR WG NO 9 TE FTR-ORIG 9-0 J/K-SERIES 9-0 M/P-SERIES 9-0 R-SERIES VENT 0-0-HT () G-0-0T () (VENT TO SH) VENT-EFROSTER -0-HT () GSKET () (INSTLL GSKET WITH WIE EN TOWR ENTER) G-0-U () ( THRU GSKET) PLENUM-EFROSTER G9-0-0 () ( PLES) G-0- () (TRNSITION TO EVP,HETER SM) PLENUM-TRNSITION (00) G-0-0T () G-0- () (TRNSITION TO ONTROL/PLENUM SET) (0) G-0-0T () (0) G-0-0T () EVP,HETER SM OVER SM-HETER 9-0-XXX OUTLET-EFROSTER -0-HT G9-0-U () SETION - -SERIES UP TO SS (90) G-0-0T () PLENUM-EFROSTER (REF) 9. SH SUPPORT TUE (REF) (0) G-0-0T () RKET -0-HT G-0- () OUTLET-EFROSTER,W/SWIVEL -0-HT G-0-0T () ONTROL/PLENUM SET ONTROL/PLENUM SET (REF) SETION - SETION - 9. ROUTE ONENSTE TUE TO LEFT HSSIS RIL & SEURE WITH LMP , LIP OR TIE EVERY 00M TO PREVENT TRPING OF ONENSTE WTER.. USE ON -SERIES (VERTIL SH ONTROL) (00) G-0-0T () (00) G-0-0T () R OPYRIGHT 009 WINNEGO INUSTRIES, IN.. USE ON E-SERIES (HORIZONTL SH ONTROL).. PPLY SEL-TRIM OVER LL SHRP EGES THT S MUST ROSS.. HERE TO SH PNEL.. MOUNTS IN SH FE.. MOUNTS IN SH PO.. MOUNTS IN EXTRUSION ON SH SM.. MOUNT TO LOSEOUT PNEL (00) RKET -0-HT G-0- () OUTLET-EFROSTER,W/SWIVEL -0-HT G-0-0T () FTR P.E. SNR UNSPEIFIE TOLERNES RE: PRT NO NOTES: SHEET OF G-0-0T () 9 FRONT EN SM (REF) HKR M.E. WHOLE IM (X) ONE-PLE (X.X) TWO-PLE (X.XX) NGLE THIR NGLE PROJETION TITLE:. 0.0 MTERIL: ORIG. TE LL IMENSIONS RE IN MILLIMETERS FIRST USE 0 -SERIES O NOT SLE RWING HETER-/ INSTL,SH REV REF: 0//009

10 WG NO PPLITION SHEET 9-0 -SERIES 9-0 E-SERIES 9-0 J/K-SERIES 9-0 M/P-SERIES 9-0 R-SERIES RKET-IR OX 0-0-HT 000G9-0-0 () NUT () 000G9-0-0 () VENT 0-0-HT () 000G-0-0T () (VENT TO SH) RE -0-HT () 000G-0- () NUT () RELESE REV ZONE REV TE REVISION REOR WG NO 9 TE FTR-ORIG PLENUM-EFROSTER (REF) 9. VENT-EFROSTER -0-HT () GSKET () (INSTLL GSKET WITH WIE EN TOWR ENTER) 000G-0-U () ( THRU GSKET) PLENUM-EFROSTER G9-0-0 () ( PLES) -FLEXILE " LMP HT () 000G9-0-0 () () 000G-0-0T () ORE-EVPORTOR/HETER OVER SM-HETER 09-0-XXX 000G9-0-U (). 0. SH SUPPORT TUE (REF) (0) 000G-0-0T () () 000G-0-0T () SETION - PLENUM SM-TRNSITION 00-0-XXX SETION - RKET-IR OX 0-0-HT 000G9-0-0 () NUT () 0 VUUM HRNESS HOOKUP: # LUE; IR REIRULTION OOR # GREEN; HET/EFROST ENTER PORT # LK; VUUM SOURE # YELLOW; I-LEVEL MOTOR ENTER PORT # RE; HET/EFROST EN PORT # WHITE; I-LEVEL MOTOR EN PORT 9. ROUTE ONENSTE TUE TO LEFT HSSIS RIL & SEURE WITH LMP , LIP OR TIE EVERY 00MM TO PREVENT TRPING OF ONENSTE WTER () 000G-0-0T () PLENUM-IR ISTRIUTION PNEL-ONTROL,VERTIL NUT () (0) 000G-0-0T () -SERIES FTER EVNS RKET -0-HT G-0- () OUTLET-EFROSTER,W/SWIVEL -0-HT G-0-0T () SETION - -SERIES OPYRIGHT 00. USE ON -SERIES (VERTIL SH ONTROL).. USE ON E-SERIES (HORIZONTL SH ONTROL).. PPLY SEL-TRIM OVER LL SHRP EGES THT S MUST ROSS.. HERE TO SH PNEL.. MOUNTS IN SH FE.. MOUNTS IN SH PO.. MOUNTS IN EXTRUSION ON SH SM.. MOUNT TO LOSEOUT PNEL. RKET-IR OX 0-0-HT 000G9-0-0 () NUT () 000G9-0-0 () () 000G-0-0T () FRONT EN SM (REF) FTR HKR P.E. M.E. SNR UNSPEIFIE TOLERNES RE: WHOLE IM (X) ONE-PLE (X.X) TWO-PLE (X.XX) NGLE THIR NGLE PROJETION TITLE:. 0.0 R MTERIL: ORIG. TE WINNEGO INUSTRIES, IN. LL IMENSIONS RE IN MILLIMETERS FIRST USE 0 -SERIES O NOT SLE RWING HETER-/ INSTL,SH PRT NO NOTES: SHEETOF 9 REV REF: /9/00

11 KEY PRT NUMER U/M ESRIPTION VENOR NO E SM # ONENSER/OMP E O RING # KEY PRT NUMER U/M ESRIPTION VENOR NO E SWITH-INRY W/PKR ONN E SM. - # RIER/EVP E SWITH-PRESSURE/ON. FN E O RING # KEY PRT NUMER U/M ESRIPTION VENOR NO E - # RIER/EVPORTOR E SWITH-PRESSURE/ON. FN E SWITH-INRY-HI/LOW UTOUT E FITTING-QUIK ONNET E O RING # E O RING # 0-09 OPYRIGHT 009 WINNEGO INUSTRIES IN.

12 KEY PRT NUMER U/M ESRIPTION VENOR NO E O RING F/LOW PRESSURE SWITH E SSEMLY # E O RING # KEY PRT NUMER U/M ESRIPTION VENOR NO E O RING # E - #0 EVP/OMP - ' KEY PRT NUMER U/M ESRIPTION VENOR NO E O RING # E O RING F/LOW PRESSURE SWITH E - #0 EVP/OMP -.' KEY PRT NUMER U/M ESRIPTION VENOR NO E - #-EVP/RIER -.' E O RING, # KEY PRT NUMER U/M ESRIPTION VENOR NO E PLENUM - TOP E OOR - EFROSTER-/ E RO - OOR - /HET E MOTOR-VUUM SERVO, / E PLTE - OOR - / E PLENUM - OTTOM E MOTOR - VUUM, STGE E RO - OOR - /EFROST E SPRING E RELY-OSH W/RESISTER E NISTER-VUUM E VUUM HRNESS E HRNESS - WIRE E HRNESS - WIRE W/ULS E ONTROL PNEL-REESSE FE E ONTROL PNEL SM. - RIVER E SWITH - LOWER E POTENTIOMETER E SWITH - VUUM E EL ONTROL PNEL-N/REESS E KNO - LOWER - NONREESSE E LIGHT ULS ONTT WINNEGO PRT SLES FOR UNLISTE OMPONENT(S) 0 OPYRIGHT 009 WINNEGO INUSTRIES IN.

13 KEY PRT NUMER U/M ESRIPTION VENOR NO E O RING # E - # EVP/OMP -.' KEY PRT NUMER U/M ESRIPTION VENOR NO E SE - FRONT E PLTE - MOTOR MOUNT E OOR - LEN IR E USHING/RIVE (LEN OOR) E ORE - HETER - W/GSKET E OUPLING - LEN OOR SHFT E VLVE-EXPNSION-LOK, TON E ORE-EVPORTOR E SE-RER E RKET-VUUM MOTOR E RO-OOR-REIRULTING E OOR - REIRULTION E RESISTOR-FUSE, / TERM E THERMOSTT E MOTOR-VUUM SERVO, / E MOTOR - SERVO E HOUSING-LOWER E MOTOR - LOWER W/O PIGTIL E WHEEL-LOWER, LOKWISE E LIP-MOTOR SHFT E OVER - SERVO E O RING # E O RING # E ORE-HETER E -VENT F/LOWER MOTOR 0-00 ONTT WINNEGO PRT SLES FOR UNLISTE OMPONENT(S) KEY PRT NUMER U/M ESRIPTION VENOR NO E O RING # E - /-#EVP/OMP E O RING, # 0-0 OPYRIGHT 009 WINNEGO INUSTRIES IN.

14 KEY PRT NUMER U/M ESRIPTION VENOR NO E RELY-OSH W/RESISTER E MOTOR-VUUM SERVO, / E NISTER-VUUM E MOTOR - VUUM, STGE E VUUM HRNESS E HRNESS - WIRE W/ULS E SWITH - LOWER E POTENTIOMETER E SWITH - VUUM E EL ONTROL PNEL-N/REESS E PLENUM - TOP SE E PLENUM - LOWER SE E OOR - HET/VENT E RO - EF/HET OOR E OOR - EF/HET E HOUSING ONLY - ONTROL PNEL E KNO - ONTROL E ONTROL PNEL W/SWITHES KEY PRT NUMER U/M ESRIPTION VENOR NO E PLENUM - TOP E OOR - EFROSTER-/ E RO - OOR - /HET E MOTOR-VUUM SERVO, / E PLTE - OOR - / E PLENUM - OTTOM E MOTOR - VUUM, STGE E RO - OOR - /EFROST E SPRING E RELY-OSH W/RESISTER E NISTER-VUUM E VUUM HRNESS E SWITH - LOWER E POTENTIOMETER E SWITH - VUUM E EL ONTROL PNEL-N/REESS E KNO - LOWER - NONREESSE 0-00 ONTT WINNEGO PRT SLES FOR UNLISTE OMPONENT(S) 0 OPYRIGHT 009 WINNEGO INUSTRIES IN.

15 KEY PRT NUMER U/M ESRIPTION VENOR NO E O RING # E - #0 EVP/OMP KEY PRT NUMER U/M ESRIPTION VENOR NO E PLENUM - TOP E OOR/IVERTOR - EFROSTER E RO - EFROSTER IVERTOR R E RKET-VUUM MOTOR E MOTOR - VUUM, STGE E MOTOR-VUUM SERVO, / E OOR/IVERTOR - /-HET E RO - /-HET OOR E PLENUM - OTTOM E RELY-OSH W/RESISTER E NISTER-VUUM E VUUM HRNESS E HRNESS - WIRE W/ULS E SWITH - LOWER E POTENTIOMETER E SWITH - VUUM E EL ONTROL PNEL-N/REESS E KNO - ONTROL OPYRIGHT 009 WINNEGO INUSTRIES IN.

16 UT-" (0) LMP-" () REGISTER-" 90-0-HT G-0-P () NGLE-FORME --HT () --HT () FURNE-0,000 TU OOR SM -0-HT 0G0--0() ONNETOR EXTR OTTOM UT KIT G-0- (0) GSKET PLYWOO -- X 0 RELESE REV ZONE REV TE REVISION REOR WG NO TE FTR-ORIG REGISTER-HET 9-0-HT () G-0-G () REGISTER-HET 9-0-HT G-0-0G () R OPYRIGHT 009 WINNEGO INUSTRIES, IN. FTR ORIG. TE. IN FLOOR UTS. GRILL-RETURN IR 9--HT G-0-U () HKR P.E. M.E. SNR UNSPEIFIE TOLERNES RE: WHOLE IM (X) MTERIL: LL IMENSIONS RE IN MILLIMETERS FIRST USE 09 J WRP FURNE UT WITH INSULTION SEURE SEMS WITH TPE PNEL SM-FURNE 0-0-HT ONE-PLE (X.X) TWO-PLE (X.XX) NGLE. 0.0 THIR NGLE PROJETION. LL EXPOSE EGES MUST E OVERE WITH TPE 0-0-HT.. FURNE TO E INSTLLE TO VENORS SPEIFITION. TITLE: O NOT SLE RWING HETING SYSTEM INSTL PRT NO NOTES: SHEET OF REV REF:

17 OPYRIGHT 009 WINNEGO INUSTRIES IN.

18 (ONTINUE) KEY PRT NUMER U/M ESRIPTION VENOR NO E INET - FRONT 090 SEE VOLT WIRING RES FOR ORRET THERMOSTT E INET E OLLR - UT E MNIFOL SSEMLY E ORFIE - MIN URNER E GSKET - URNER ESS OVER E PLTE - SEONRY IR/TOP K E PLTE - SEONRY IR/TOP FRT E PLTE - SEONRY IR/OTTOM E ELETROE E URNER SSEMLY, SF-F E VLVE-GS SF S.N E PIPE SSEMLY (GS INLET) E TUE SSEMLY, EXHUST W/P E OX SM (OM. IR INTKE) 00K E GSKET (OM. IR HOUSING) E WHEEL (OMUSTION IR) E HOUSING (OMUSTION IR) 90K 9-0- E GSKET-FIREWLL/OM. IR E MOTOR SSEMLY E GSKET-MIROSWITH E SWITH-MIRO-W/O FLG /" -0- E LOWER SSEMLY(ROOM IR) 90K -0- E WHEEL - ROOM IR E SWITH - ON/OFF E PNEL SSEMLY-MOULE E INSULTOR - MOULE E MOULE W/RELY TIME ELY E P/INSULTOR-MOULE E USHING - UNIVERSL E USHING - STRIN RELIEF E GSKET-FIREWLL,HMER SIE E SWITH - LIMIT E TUE SSEMLY, INTKE E GSKET - MOTOR E HMER SM. - FINL 0K ONTT WINNEGO PRT SLES FOR UNLISTE OMPONENT(S) OPYRIGHT 009 WINNEGO INUSTRIES IN.

19 RELESE REV TE WG NO REV ZONE REVISION REOR TE FTR-ORIG 9 INSULTION-RINGE OMPT TPE () LMP-LOSE () G-0- () REGISTER 9-0-HT () G-0-0U () TUE-MOTOR I --000() 9. PPLY TO TOP OF RINGE TNK. GROMMET (). TORQUE TO 0 IN-LS. OPYRIGHT 009 WINNEGO. WHERE THE MOTORI TUE OMES IN ONTT WITH NY HSSIS OMPONENT OTHER THN THE FRME RILS, IT SHLL E PROTETE Y ONVOLUTE ONUIT FTR R ORIG. TE INUSTRIES, IN.. NTIFREEZE - OOLNT (LL-GREEN OLOR, EXEPT HEVY ORNGE) (HEVY-ORNGE OLOR) 0-0 MIXTURE NTIFREEZE & LEN WTER. HKR P.E. M.E. SNR LL IMENSIONS RE IN MILLIMETERS FIRST USE 09 J. SEE HETER & / INSTL TO ONNET S FROM ENGINE.. SEURE UTS T LL JOINTS WITH T LEST TWO WRPS OF TPE N TIGHTEN WITH LMP. UNSPEIFIE TOLERNES RE: WHOLE IM (X) ONE-PLE (X.X). TWO-PLE (X.XX) 0.0 MTERIL:. SLIP JOINTS TO HVE N OVERLP OF mm MINIMUM. NGLE THIR NGLE PROJETION. SPLIE TUES FOR MOTOR I USING UNION S REQUIRE.. EXTERIOR OPENINGS ROUN PIPE TO E SELE WITH TITLE: O NOT SLE RWING MOTOR I INSTL NOTES: SHEET OF PRT NO REV REF:

20 WG NO -HETER ( mm) LMP () -HETER (0 mm) LMP () UT-FLEXILE () (0 mm) ONNETOR () LMP () WTER HETER HETER SM-RER,UT SETION - PLTFORM SM-MOTORI 9-0-XXX -HETER (0 mm) LMP () SETION - FIRST USE 09 J O NOT SLE RWING TITLE: MOTOR I INSTL SHEET PRT NO REV

21 KEY PRT NUMER U/M ESRIPTION VENOR NO E ORE-HETER FT E FN HV E MOTOR SSEMLY, VOLT RV00 OPYRIGHT 009 WINNEGO INUSTRIES IN.

22 9 IR ONITIONER -0-0 (WHT) (UP TO 0-0-0) -0-0 (WHT) (FTER 0--0) -0-0 (LK) (UP TO 0--0) -0-0 (LK) (FTER 0--0) IR ONITIONER -0-0 (WHT) (UP TO 0-0-0) -0-0 (WHT) (FTER 0-0-0) -0-0 (LK) (UP TO 0-0-0) -0-0 (LK) (FTER 0--0) Q -0-0 (WHT) (UP TO 0--0) -0-0 (WHT) (FTER 0--0) -0-0 (LK) (UP TO 0--0) -0-0 (LK) (FTER 0--0) 9R -0-0 (WHT) (UP TO 0-0-0) -0-0 (WHT) (FTER 0--0) -0-0 (LK) (UP TO 0--0) -0-0 (LK) (FTER 0--0) -0-0 (WHT) (UP TO 0--0) -0-0 (WHT) (FTER 0-0-0) -0-0 (LK) (UP TO 0-0-0) -0-0 (LK) (FTER 0--0) 9J -0-0 (WHT) (UP TO 0--0) -0-0 (WHT) (FTER 0--0) -0-0 (LK) (UP TO 0--0) -0-0 (LK) (FTER 0--0) 9R 9-0 -SERIES E-SERIES OR-IVIER R EILING SM -0-0 EILING SM R OR-IVIER -0-0 Q 9J 9R EILING SM -0-0 Q EILING SM J 9R 9R HET PUMP- HI EFFIIENY 9J HET PUMP- / ROOF-HI EFF () W/EMS Q / ROOF IR (),00 TU OES/STNRS-S/MVSS OES/STNRS US 0 MOTORHOMES FOR ELETRIL TORQUE SPEIFITIONS SEE WG NO WIRING INSTL-ROOF / 9 /0/00

23 KEY PRT NUMER U/M ESRIPTION VENOR NO E PLUG SSEMLY E TERMINL OR E ISOLTOR - LNK E OR - P E FILTER E GRILLE /X / RETURN E OIL SENSOR E JUNTION OX SSEMLY E SMLL PRTS PKG E NUT/WING 00-0 ONTT WINNEGO PRT SLES FOR UNLISTE OMPONENT(S) OPYRIGHT 009 WINNEGO INUSTRIES IN.

24 KEY PRT NUMER U/M ESRIPTION VENOR NO E OX - JUNTION E PLUG SSEMLY E OR - TERMINL E ISOLTOR - LNK E OR - P E FILTER E GRILLE /X / RETURN E JUNTION OX SM.(HET PUMP) E OIL SENSOR E NUT/WING E SMLL PRTS PKG 0-9 ONTT WINNEGO PRT SLES FOR UNLISTE OMPONENT(S) OPYRIGHT 009 WINNEGO INUSTRIES IN.

25 KEY PRT NUMER U/M ESRIPTION VENOR NO E SHROU-ROOF IR/ PIEE-WHT E OIL-ONENSER E SHROU FN/INNER-LESS LOGO E LE-FN-ONENSER E OMPRESSOR RKT-00-Y E OVERLO PROTETOR MR# E MOUNTING PKG.,OMP., PER E MOTOR - V, 0 HURTZ E LOWER WHEEL PKGE E PITOR - RUN E PITOR-FN (INOOR MOTOR) E PTR (STRT EVIE) - W/P E EVPORTOR OIL E GSKET PKGE E MOTOR MOUNT & SEL KIT E LINE - SUTION E SHROU RKET ONTT WINNEGO PRT SLES FOR UNLISTE OMPONENT 0 OPYRIGHT 009 WINNEGO INUSTRIES IN.

26 -0-0 KEY PRT NUMER U/M ESRIPTION VENOR NO E SHROU-ROOF IR/ PIEE-LK E OIL-ONENSER E SHROU FN/INNER-LESS LOGO E LE-FN-ONENSER E OMPRESSOR RKT-00-Y E OVERLO PROTETOR MR# E MOTOR - V, 0 HURTZ E LOWER WHEEL PKGE E PITOR - RUN E PITOR-FN (INOOR MOTOR) E PTR (STRT EVIE) - W/P E EVPORTOR OIL E GSKET PKGE E MOTOR MOUNT & SEL KIT E LINE - SUTION E SHROU RKET ONTT WINNEGO PRT SLES FOR UNLISTE OMPONENT OPYRIGHT 009 WINNEGO INUSTRIES IN.

27 KEY PRT NUMER U/M ESRIPTION VENOR NO E SHROU-ROOF IR/ PIEE-WHT E ONENSER OIL E SHROU FN/INNER-LESS LOGO E LE-FN-ONENSER E OMPRESSOR RKT-00-Y E MOUNTING PKG.,OMP., PER E MOTOR - V, 0 HURTZ E LOWER WHEEL PKGE E RESTRITOR - Y FLOW E PITOR - RUN E PITOR-FN (INOOR MOTOR) E PTR (STRT EVIE) - W/P E EVPORTOR OIL E GSKET PKGE E MOTOR MOUNT & SEL KIT E OIL - SOLENOI E SWITH - FREEZE E LIQUI LINE E SHROU RKET ONTT WINNEGO PRT SLES FOR UNLISTE OMPONENT OPYRIGHT 009 WINNEGO INUSTRIES IN.

28 -0-0 KEY PRT NUMER U/M ESRIPTION VENOR NO E SHROU-ROOF IR/ PIEE-LK E ONENSER OIL E SHROU FN/INNER-LESS LOGO E LE-FN-ONENSER E OMPRESSOR RKT-00-Y E MOUNTING PKG.,OMP., PER E MOTOR - V, 0 HURTZ E LOWER WHEEL PKGE E RESTRITOR - Y FLOW E PITOR - RUN E PITOR-FN (INOOR MOTOR) E EVPORTOR OIL E GSKET PKGE E MOTOR MOUNT & SEL KIT E OIL - SOLENOI E SWITH - FREEZE E LIQUI LINE E SHROU RKET ONTT WINNEGO PRT SLES FOR UNLISTE OMPONENT OPYRIGHT 009 WINNEGO INUSTRIES IN.

29 KEY PRT NUMER U/M ESRIPTION VENOR NO E SHROU-ROOF IR/ PIEE-WHT E OIL-ONENSER E SHROU FN/INNER-LESS LOGO E LE-FN-ONENSER E OMPRESSOR (TEUMSEH) E MOUNTING PKG.,OMP., PER E MOTOR (V, 0HZ) E LOWER WHEEL PKGE E PITOR - RUN E PITOR-FN (I/O MOTOR) E PTR (STRT EVIE) - W/P E EVPORTOR OIL E GSKET PKGE E MOTOR MOUNT & SEL KIT E PROTETOR-OVERLO, RH & LH E SHROU RKET ONTT WINNEGO PRT SLES FOR UNLISTE OMPONENT(S) OPYRIGHT 009 WINNEGO INUSTRIES IN.

30 -0-0 KEY PRT NUMER U/M ESRIPTION VENOR NO E SHROU-ROOF IR/ PIEE-LK E OIL-ONENSER E SHROU FN/INNER-LESS LOGO E LE-FN-ONENSER E OMPRESSOR (TEUMSEH) E MOUNTING PKG.,OMP., PER E MOTOR (V, 0HZ) E LOWER WHEEL PKGE E PITOR - RUN E PITOR-FN (I/O MOTOR) E PTR (STRT EVIE) - W/P E EVPORTOR OIL E GSKET PKGE E MOTOR MOUNT & SEL KIT E PROTETOR-OVERLO, RH & LH E SHROU RKET ONTT WINNEGO PRT SLES FOR UNLISTE OMPONENT(S) OPYRIGHT 009 WINNEGO INUSTRIES IN.

31 KEY PRT NUMER U/M ESRIPTION VENOR NO E SHROU-ROOF IR/ PIEE-WHT E ONENSER OIL E SHROU FN/INNER-LESS LOGO E LE-FN-ONENSER E OMPRESSOR (TEUMSEH) E MOUNTING PKG.,OMP., PER E MOTOR (V, 0HZ) E LOWER WHEEL PKGE E OMPRESSOR RUN PITOR E PITOR-FN (I/O MOTOR) E PTR (STRT EVIE) - W/P E EVPORTOR OIL E GSKET PKGE E MOTOR MOUNT & SEL KIT E OIL - SOLENOI E SWITH - FREEZE E LIQUI LINE E PROTETOR-OVERLO, RH & LH E SHROU RKET ONTT WINNEGO PRT SLES FOR UNLISTE OMPONENT(S) OPYRIGHT 009 WINNEGO INUSTRIES IN.

32 -0-0 KEY PRT NUMER U/M ESRIPTION VENOR NO E SHROU-ROOF IR/ PIEE-LK E ONENSER OIL E SHROU FN/INNER-LESS LOGO E LE-FN-ONENSER E OMPRESSOR (TEUMSEH) E MOUNTING PKG.,OMP., PER E MOTOR (V, 0HZ) E LOWER WHEEL PKGE E OMPRESSOR RUN PITOR E PITOR-FN (I/O MOTOR) E PTR (STRT EVIE) - W/P E EVPORTOR OIL E GSKET PKGE E MOTOR MOUNT & SEL KIT E OIL - SOLENOI E SWITH - FREEZE E LIQUI LINE E PROTETOR-OVERLO, RH & LH E SHROU RKET ONTT WINNEGO PRT SLES FOR UNLISTE OMPONENT(S) OPYRIGHT 009 WINNEGO INUSTRIES IN.