NPRA United States Refining and Storage Capacity Report

Transcription

1 Refining Capacity Report January 1, 2009 NPRA United States Refining and Storage Capacity Report Published August 2009

2 Refining Capacity Report January 1, 2009 Locations of U.S. Refineries 2009 PADD V PADD IV PADD II PADD I PADD III Large: Over 75,000 B/D Small: Under 75,000 B/D

3 Refining Capacity Report January 1, 2009 NPRA United States Refining and Storage Capacity Report The enclosed statistics provide U.S. refining and storage capacity data as reported by the DOE Energy Information Administration in their 2009 Petroleum Supply Annual. These data, along with other DOE statistics, are also available electronically. (See the note at the bottom of this page for details.) This report is also available on the NPRA web site ( under Publications/Statistical Reports. On January 1, 2009, there were 150 a operable refineries in the United States (excluding Puerto Rico and the Virgin islands) with total crude distillation capacity of 17.7 million barrels per calendar day (bpcd) and 18.7 million barrels per stream day. Of these, 141 refineries were operating on January 1, 2009, with operating capacity listed at 17.3 million barrels per calendar day and 18.3 million barrels per stream day. The Energy Information Administration reports that during 2008, one U.S. refinery with a capacity of 10.0 thousand barrels per stream day (downstream charge capacity) was shut down and one U.S. refinery with a capacity of 3.0 thousand barrels per calendar day was reactivated (p. 53). The following table lists the total U.S. refining capacity for the past five years: January 1 Total Capacity in Thousands of Barrels Per Calendar Day U.S. 17,125 17,339 17,444 17,594 17,672 Puerto Rico Virgin Islands This summary of petroleum refineries in the United States and U.S. territories is taken from the Department of Energy s Petroleum Supply Annual 2009, published June, Capacity data are reproduced by NPRA as a courtesy to members. The data enclosed, as well as other DOE refining statistics, are available electronically from DOE ( For information, call EIA s National Energy Information Center at , at: infoctr@eia.doe.gov a The total count of operational refineries (150) includes two chemical plants that produce gasoline blending components. (Equistar Chemicals LP, Channelview, TX and Belvieu Environmental Fuels, Mont Belvieu, TX) EIA also reclassified two existing ConocoPhillips facilities as a single facility which reduced California s count by one refinery.

4 Table of Contents NPRA United States Refining and Storage Capacity Report 1 Table 1 Number and Capacity of Operable Petroleum Refineries by PAD District and State as of January 1, Table 2 Production Capacity of Operable Petroleum Refineries by PAD District and State as of January 1, Directory of Operable Petroleum Refineries in Tables 3 and 4 5 Table 3 Capacity of Operable Petroleum Refineries by State as of January 1, Directory of Operable Petroleum Refineries in Tables 3 and 4 30 Table 4 Production Capacity of Operable Petroleum Refineries by State as of January 1, Table 5 Refiners Operable Atmospheric Crude Oil Distillation Capacity as of January 1, Companies with Capacity Over 100,000 bbl/cd 43 Companies with Capacity 30,001 to 100,000 bbl/cd 44 Companies with Capacity 10,001 to 30,000 bbl/cd 44 Companies with Capacity 10,000 bbl/cd or Less 46 Table 6 Operable Crude Oil and Downstream Charge Capacity of Petroleum Refineries, January 1, 1981 to January 1, Table 7 Operable Production Capacity of Petroleum Refineries, January 1, 1981 to January 1, Table 8 Working Storage Capacity at Operable Refineries by PAD District as of January 1, Table 9 Shell Storage Capacity at Operable Refineries by PAD District as of January 1, Table 10 Capacity and Fresh Feed Input to Selected Downstream Units at U.S. Refineries, Table 11 Refinery Receipts of Crude Oil by Method of Transportation by PAD District, Table 12a Fuel Consumed at Refineries by PAD District, Table 12b Natural Gas Used as Feedstock for Hydrogen Production by PAD District, Table 13 New, Reactivated, and Shutdown Refineries during Table 14 Refinery Sales during Table 15 Refineries Permanently Shutdown by PAD District between 1990 and 2008 Appendices 61 Appendix A - District Descriptions and Maps 64 Appendix B - Explanatory Notes Glossary 68 Definitions of Petroleum Products and Other Terms

5 Table 1. Number and Capacity of Operable Petroleum Refineries by PAD District and State as of January 1, 2009 Atmospheric Crude Oil Distillation Capacity PAD District and State Number of Operable Refineries Total Operating Idle Barrels per Barrels per Calendar Day Stream Day a Total Operating Idle b Total Operating Idle b PAD... District I... Delaware Georgia New Jersey Pennsylvania Virginia West Virginia... PAD... District II... Illinois Indiana Kansas Kentucky Michigan Minnesota North Dakota Ohio Oklahoma Tennessee Wisconsin... PAD... District III... Alabama Arkansas Louisiana Mississippi New Mexico Texas... PAD... District IV... Colorado Montana Utah Wyoming... PAD... District V... Alaska California Hawaii Nevada Washington... U.S.... Total... U.S. Total Puerto Rico Virgin Islands ,722,700 1,582, ,000 1,817,700 1,667, , , , , , , ,000 32, , , , , , , , , , , , ,500 64, ,000 68, ,000 20, ,000 22, ,671,500 3,654,000 17,500 3,953,246 3,932,946 20, , , , , , , , , , , , , , ,000 5, , ,000 6, , , , , , , , , ,000 58, ,000 60, , , , , , ,100 12, , ,846 14, , , , , ,300 34, ,000 35, ,439,502 8,356,502 83,000 8,881,962 8,796,312 85, , , , , ,500 77, ,700 79, ,992,123 2,967,123 25,000 3,127,355 3,101,705 25, , , , , , , , , ,747,179 4,689,179 58,000 4,998,300 4,938,300 60, , ,300 3, , ,700 5, , , , , , , , , , , , , , ,500 3, , ,000 5, ,215,548 3,101, ,500 3,367,700 3,247, , , ,480 48, , ,200 50, ,060,718 1,994,218 66,500 2,148,500 2,078,500 70, , , , , ,000 2, ,000 5, , , , , ,671,550 17,313, ,000 18,681,308 18,300, , ,671,550 17,313, ,000 18,681,308 18,300, , , ,900 85, , , , , , Energy Information Administration, Refinery Capacity 2009

6 Table 1. Number and Capacity of Operable Petroleum Refineries by PAD District and State as of January 1, 2009 Downstream Charge Capacity (Barrels per Stream Day) PAD District and State Vacuum Distillation Thermal Cracking Catalytic Cracking Fresh Recycled Catalytic Hydro- Cracking c Catalytic Reforming Hydrotreating/ Desulfurization Fuels Solvent Deasphalting... PAD District I 715, , ,700 7,000 45, ,100 1,408,560 20,000 Delaware... Georgia... New... Jersey Pennsylvania... Virginia... West... Virginia 104,600 53,000 82,000 4,000 22,300 43, , ,000 27, , , ,500 20, , ,500 1,000 23, , , ,500 22,500 28,200 2, ,100 72, , ,400 18, PAD District II 1,592, ,590 1,296,210 13, , ,254 3,387,783 17,350 Illinois... Indiana... Kansas... Kentucky... Michigan... Minnesota... North... Dakota Ohio... Oklahoma... Tennessee... Wisconsin , , ,500 3,000 69, , , ,100 36, ,200 4, , , ,500 65, , ,000 78, , , , , ,200 12,500 55, , , , ,500 67, , ,000 70, , ,000 3, ,100 32, ,500 58, , , , , ,050 37, ,010 2,250 28, , ,133 4, , , , , , ,000 29, PAD District III 4,317,275 1,403,200 3,128,405 50, ,800 1,825,890 8,320, ,000 Alabama... Arkansas... Louisiana... Mississippi... New... Mexico Texas... 46,000 14, ,800 91, , , ,800 87,300 7,400 1,527, ,700 1,151,600 13, , ,300 2,625,550 63, , ,000 88, ,000 96, , , ,500 3, , , ,348, ,900 1,827,405 33, ,600 1,077,190 5,074, , PAD District IV 249,200 88, ,956 4,190 17, , ,960 5,600 Colorado... Montana... Utah... Wyoming... 33, , ,000 84, ,300 47,100 63, ,200 39, , ,500 8,500 57,200 2, , ,360 5,600 78,900 32,500 51, ,500 32, , PAD District V 1,667, , ,600 4, , ,900 2,454,000 96,000 Alaska... California... Hawaii... Nevada... Washington... 31, ,000 14,200 23, ,273, , ,600 1, , ,100 1,993,100 66,000 71,300 11,000 22, ,000 13,000 16, , ,500 83, ,000 3,000 61, , ,400 30, U.S. Total 8,542,281 2,639,090 6,291,871 78,740 1,743,300 3,829,338 16,130, ,950 U.S.... Total Puerto... Rico Virgin... Islands 8,542,281 2,639,090 6,291,871 78,740 1,743,300 3,829,338 16,130, ,950 31, ,000 39, , , , , ,000 0 a Refineries where distillation units were completely idle but not permanently shutdown on January 1, b Includes capacity from refineries that are either completely or partially idle. c Hydrocracking capacity declined from the prior year due to the reclassification of some hydrocracking capacity to hydrotreating capacity. Source: Energy Information Administration (EIA), Form EIA-820, "Annual Refinery Report." Energy Information Administration, Refinery Capacity

7 Table 2. Production Capacity of Operable Petroleum Refineries by PAD District and State as of January 1, 2009 (Barrels per Stream Day, Except Where Noted) Production Capacity PAD District Asphalt Marketable Sulfur and and Petroleum Hydrogen (short State Alkylates Aromatics Road Oil Isomers Lubricants Coke (MMcfd) tons/day) PAD District I 110,229 22, ,115 36,100 21,045 27, ,359 Delaware 11,729 1, , , Georgia , New Jersey 40,200 7,500 98,500 9,400 12,000 7, Pennsylvania 54,100 12,920 22,065 20,700 2, Virginia 4, , West Virginia , PAD District II 273,988 57, , ,682 9, , ,003 Illinois 83,400 13,500 70,100 14, , ,819 Indiana 37,700 17,000 66,700 28, , Kansas 30,300 2,200 4,000 27, , Kentucky 20,500 7,000 27,000 16, Michigan 5, , Minnesota 18, ,000 8, , ,230 North Dakota 4, Ohio 28,450 18,200 23,800 31, , Oklahoma 32, ,930 22,882 9,100 8, Tennessee 12, , Wisconsin 1, , PAD District III 619, , , , , , ,064 Alabama ,000 3, , Arkansas 5, ,100 6,600 5, Louisiana 211,900 39,700 44, ,820 66, , Mississippi 18,600 21,000 36,125 1,400 12,000 35, ,324 New Mexico 10, ,700 13, Texas 372, ,900 84, ,333 76, , ,540 PAD District IV 45, ,250 15, , Colorado , Montana 17, ,100 5, , Utah 17, ,300 7, , Wyoming 10, ,600 1, , PAD District V 220,826 3, , ,750 39, ,250 1,205 5,227 Alaska 0 1,500 12,000 4, California 182,026 1,500 85, ,150 39, ,600 1,051 4,442 Hawaii 5, ,100 3, Nevada 0 0 5, Washington 33, ,500 15, , U.S. Total 1,269, , , , , ,000 2,914 33,581 Puerto Rico Virgin Islands 19,000 20, , , MMcfd = Million cubic feet per day. Source: Energy Information Administration (EIA), Form EIA-820, "Annual Refinery Report." 3 Energy Information Administration, Refinery Capacity 2009

8 Directory of Operable Petroleum Refineries on Tables 3 and 4 Refiner State(s) a Refiner State(s) a... Age Refining Inc... TX... Marathon Petroleum Co LLC Alon Refining Krotz Springs Inc... LA... Montana Refining Co Alon USA Energy Inc... TX... Motiva Enterprises LLC American Refining Group Inc... PA... Murphy Oil USA Inc BP Exploration Alaska Inc... AK... NCRA BP Products North America Inc... IN, TX... Navajo Refining Co BP West Coast Products LLC... CA, WA... Northcut Refining LLC BP-Husky Refining LLC... OH... Nustar Asphalt Refining LLC Belvieu Environmental Fuels... TX... PDV Midwest Refining LLC Big West Of California... CA... Paramount Petroleum Corporation Big West Oil Co... UT... Pasadena Refining Systems Inc Calcasieu Refining Co... LA... Pelican Refining Company LLC Calumet Lubricants Co LP... LA... Petro Star Inc Calumet Shreveport LLC... LA... Placid Refining Co Cenex Harvest States Coop... MT... Premcor Refining Group Inc Chalmette Refining LLC... LA... San Joaquin Refining Co Inc Chevron USA Inc... CA, HI, MS, NJ, UT... Shell Chem Yabucoa Inc Citgo Petroleum Corp... LA... Shell Chemical LP Citgo Refining & Chemical Inc... TX... Shell Oil Products US Coffeyville Resources Rfg & Mktg LLC... KS... Silver Eagle Refining ConocoPhillips Alaska Inc... AK... Sinclair Tulsa Refining Co ConocoPhillips Company... CA, LA, MT, NJ, OK, PA, TX, WA... Sinclair Wyoming Refining Co Countrymark Cooperative Inc... IN... Somerset Energy Refining LLC Cross Oil Refining & Marketing Inc... AR... South Hampton Resources Inc Deer Park Refining LTD Partnership... TX... Suncor Energy (USA) Inc Delek Refining LTD... TX... Sunoco Inc Edgington Oil Co Inc... CA... Sunoco Inc (R&M) Equistar Chemicals LP... TX... Tenby Inc Ergon Refining Inc... MS... Tesoro Alaska Petroleum Co Ergon West Virginia Inc... WV... Tesoro Hawaii Corp Excel Paralubes... LA... Tesoro Refining & Marketing Co ExxonMobil Refining & Supply Co... CA, IL, LA, MT, TX... Tesoro West Coast Flint Hills Resources Alaska LLC... AK... Total Petrochemicals Inc Flint Hills Resources LP... MN, TX... Trigeant LTD Foreland Refining Corp... NV... US Oil & Refining Co Frontier El Dorado Refining Co... KS... Ultramar Inc Frontier Refining Inc... WY... United Refining Co Goodway Refining LLC... AL... Valero Energy Corporation Greka Energy... CA... Valero Refining Co California Hess Corporation... NJ... Valero Refining Co New Jersey Holly Corp Refining & Marketing... UT... Valero Refining Co Oklahoma Houston Refining LP... TX... Valero Refining Co Texas LP Hovensa LLC... VI... Valero Refining New Orleans LLC Hunt Refining Co... AL... Ventura Refining & Transmission LLC Hunt Southland Refining Co... MS... WRB Refining LLC Kern Oil & Refining Co... CA... Western Refining Company LP Lima Refining Company... OH... Western Refining Southwest Inc Lion Oil Co... AR... Western Refining Yorktown Inc Little America Refining Co... WY... Wynnewood Refining Co Lunday Thagard Co... CA... Wyoming Refining Co... IL, KY, LA, MI, MN, OH, TX MT LA, TX LA, WI KS NM WY GA, NJ IL CA TX LA AK LA DE, TN, TX CA PR AL, LA CA, WA UT, WY OK WY KY TX CO NJ, OH, OK, PA PA CA AK HI CA ND, UT, WA TX TX WA CA PA TX CA NJ OK TX LA OK IL, TX TX NM VA OK WY a Includes Puerto Rico (PR) and Virgin Islands (VI). Energy Information Administration, Refinery Capacity

9 Table 3. Capacity of Operable Petroleum Refineries by State as of January 1, 2009 (Barrels per Stream Day, Except Where Noted) State/Refiner/Location Atmospheric Crude Oil Distillation Capacity Barrels per Barrels per Calendar Day Stream Day Operating Idle Operating Idle Downstream Charge Capacity Thermal Cracking Vacuum Delayed Other/Gas Distillation Coking Fluid Coking Visbreaking Oil Alabama , , ,000 14, Goodway Refining LLC Atmore... Hunt Refining Co Tuscaloosa... Shell Chemical LP Saraland... 4, , , , ,000 14, , , , Alaska ,480 48, ,200 50,000 31, BP Exploration Alaska Inc Prudhoe... Bay ConocoPhillips Alaska Inc Prudhoe... Bay Flint Hills Resources Alaska LLC North... Pole Petro Star Inc North... Pole Valdez... Tesoro Alaska Petroleum Co Kenai... 12, , , , , , , , , , , , , , Arkansas... 77, , , Cross Oil Refining & Marketing Inc Smackover... Lion Oil Co El... Dorado 7, , , , , , California... 1,994,218 66,500 2,078,500 70,000 1,273, ,000 52,000 5,000 0 Big West Of California Bakersfield... BP West Coast Products LLC Los... Angeles Chevron USA Inc El... Segundo Richmond... ConocoPhillips Company a Rodeo... Wilmington... Edgington Oil Co Inc Long... Beach ExxonMobil Refining & Supply Co Torrance... Greka Energy Santa... Maria Kern Oil & Refining Co Bakersfield... 66, , ,000 22, , , ,000 67, , , ,000 83, , , , , , ,200 50, , , ,000 53, ,000 13,500 20,000 15,000 25, , , ,300 54, , , , , , Energy Information Administration, Refinery Capacity 2009

10 Table 3. Capacity of Operable Petroleum Refineries by State as of January 1, 2009 (Barrels per Stream Day, Except Where Noted) Downstream Charge Capacity Catalytic Cracking Catalytic Hydrocracking a Catalytic Reforming State/Refiner/Location Fresh Recycled Distillate Gas Oil Residual Low Pressure High Pressure Fuels Solvent Deasphalting Alabama ,800 22,000 0 Goodway Refining LLC Atmore Hunt Refining Co Tuscaloosa , Shell Chemical LP Saraland ,000 0 Alaska , , BP Exploration Alaska Inc Prudhoe... Bay ConocoPhillips Alaska Inc Prudhoe... Bay Flint Hills Resources Alaska LLC North... Pole Petro Star Inc North... Pole Valdez Tesoro Alaska Petroleum Co Kenai , , Arkansas... 19, , ,400 Cross Oil Refining & Marketing Inc Smackover Lion Oil Co El... Dorado 19, , ,400 California ,600 1, , ,900 65, , ,000 66,000 Big West Of California Bakersfield , , BP West Coast Products LLC Los... Angeles 102, , ,000 43,000 0 Chevron USA Inc El... Segundo 82, , , Richmond... 90, ,400 65,000 71, ,000 ConocoPhillips Company a Rodeo , ,000 0 Wilmington... 51, , ,000 0 Edgington Oil Co Inc Long... Beach ExxonMobil Refining & Supply Co Torrance , , ,000 0 Greka Energy Santa... Maria Kern Oil & Refining Co Bakersfield ,500 3,300 0 Energy Information Administration, Refinery Capacity

11 Table 3. Capacity of Operable Petroleum Refineries by State as of January 1, 2009 (Barrels per Stream Day, Except Where Noted) Downstream Charge Capacity Desulfurization (incl. Catalytic Hydrotreating) State/Refiner/Location Naphtha/ Reformer Feed Gasoline Kerosene/ Jet Fuel Diesel Fuel Other Distillate Residual Heavy Gas Oil Other Alabama... 32, ,500 8,000 16, ,500 0 Goodway Refining LLC Atmore Hunt Refining Co Tuscaloosa... 10, , , ,500 0 Shell Chemical LP Saraland... 22, , ,000 0 Alaska... 13, , BP Exploration Alaska Inc Prudhoe... Bay ConocoPhillips Alaska Inc Prudhoe... Bay Flint Hills Resources Alaska LLC North... Pole Petro Star Inc North... Pole Valdez Tesoro Alaska Petroleum Co Kenai... 13, , Arkansas... 20,000 6, , ,000 11,800 Cross Oil Refining & Marketing Inc Smackover ,000 Lion Oil Co El... Dorado 20,000 6, , ,000 6,800 California , , , , , , ,000 Big West Of California Bakersfield... 13, ,000 0 BP West Coast Products LLC Los... Angeles 45,000 10,000 10,000 21, ,000 0 Chevron USA Inc El... Segundo 59, ,500 40,000 14, ,000 0 Richmond... 57, ,000 64, ,800 ConocoPhillips Company a Rodeo... 27, , Wilmington... 50, ,900 32, ,000 0 Edgington Oil Co Inc Long... Beach ExxonMobil Refining & Supply Co Torrance... 24, , ,500 0 Greka Energy Santa... Maria Kern Oil & Refining Co Bakersfield... 5, , Energy Information Administration, Refinery Capacity 2009

12 Table 3. Capacity of Operable Petroleum Refineries by State as of January 1, 2009 (Barrels per Stream Day, Except Where Noted) State/Refiner/Location Atmospheric Crude Oil Distillation Capacity Barrels per Barrels per Calendar Day Stream Day Operating Idle Operating Idle Downstream Charge Capacity Thermal Cracking Vacuum Delayed Other/Gas Distillation Coking Fluid Coking Visbreaking Oil California... 1,994,218 66,500 2,078,500 70,000 1,273, ,000 52,000 5,000 0 Lunday Thagard Co South... Gate Paramount Petroleum Corporation Paramount... San Joaquin Refining Co Inc Bakersfield... Shell Oil Products US Martinez... Tenby Inc Oxnard... Tesoro Refining & Marketing Co Martinez... Wilmington... Ultramar Inc Wilmington... Valero Refining Co California Benicia... Wilmington... 8, , , , ,000 30, , , , , , , ,000 25,000 22, , , , , ,000 50, , , ,000 42, , , ,000 29, , , , , , , , Colorado , , , Suncor Energy (USA) Inc Commerce... City East Commerce... City West 35, , , , , , Delaware , , , , Premcor Refining Group Inc Delaware... City 182, , , , Georgia , , Nustar Asphalt Refining LLC (Formerly Citgo Asphalt Refining Co) Savannah , , Hawaii , , , ,000 0 Chevron USA Inc Honolulu... Tesoro Hawaii Corp Ewa... Beach 54, , , , , , ,000 0 Illinois , , , , ExxonMobil Refining & Supply Co Joliet... Marathon Petroleum Co LLC Robinson... PDV Midwest Refining LLC Lemont... WRB Refining LLC Wood... River 238, , ,700 59, , , ,500 29, , , ,000 46, , , ,200 18, Energy Information Administration, Refinery Capacity

13 Table 3. Capacity of Operable Petroleum Refineries by State as of January 1, 2009 (Barrels per Stream Day, Except Where Noted) Downstream Charge Capacity Catalytic Cracking Catalytic Hydrocracking a Catalytic Reforming State/Refiner/Location Fresh Recycled Distillate Gas Oil Residual Low Pressure High Pressure Fuels Solvent Deasphalting California ,600 1, , ,900 65, , ,000 66,000 Lunday Thagard Co South... Gate Paramount Petroleum Corporation Paramount ,000 0 San Joaquin Refining Co Inc Bakersfield Shell Oil Products US Martinez... 72, , , Tenby Inc Oxnard Tesoro Refining & Marketing Co Martinez... 72,000 1, , ,000 20,000 0 Wilmington... 35, ,000 22, ,500 0 Ultramar Inc Wilmington... 55, , Valero Refining Co California Benicia... 75, , ,200 0 Wilmington Colorado... 30, , Suncor Energy (USA) Inc Commerce... City East 9, , Commerce... City West 20, , Delaware... 82,000 4, , , Premcor Refining Group Inc Delaware... City 82,000 4, , , Georgia Nustar Asphalt Refining LLC (Formerly Citgo Asphalt Refining Co) Savannah Hawaii... 22, , , Chevron USA Inc Honolulu... 22, Tesoro Hawaii Corp Ewa... Beach , , Illinois ,500 3, , ,400 49,900 0 ExxonMobil Refining & Supply Co Joliet... 98, , Marathon Petroleum Co LLC Robinson... 50, , , PDV Midwest Refining LLC Lemont... 69,000 3, ,200 0 WRB Refining LLC Wood... River 101, , ,800 17, Energy Information Administration, Refinery Capacity 2009

14 Table 3. Capacity of Operable Petroleum Refineries by State as of January 1, 2009 (Barrels per Stream Day, Except Where Noted) Downstream Charge Capacity Desulfurization (incl. Catalytic Hydrotreating) State/Refiner/Location Naphtha/ Reformer Feed Gasoline Kerosene/ Jet Fuel Diesel Fuel Other Distillate Residual Heavy Gas Oil Other California , , , , , , ,000 Lunday Thagard Co South... Gate Paramount Petroleum Corporation Paramount... 15, , San Joaquin Refining Co Inc Bakersfield , Shell Oil Products US Martinez... 27,000 50, , ,500 0 Tenby Inc Oxnard Tesoro Refining & Marketing Co Martinez... 27,000 38, ,000 17, ,500 5,500 Wilmington... 33, ,000 10,000 22, ,000 0 Ultramar Inc Wilmington... 32, , ,000 0 Valero Refining Co California Benicia... 30,000 43,200 15,400 15,000 5, ,000 21,700 Wilmington Colorado... 21, ,100 21, ,000 0 Suncor Energy (USA) Inc Commerce... City East 10, Commerce... City West 10, ,100 21, ,000 0 Delaware... 50,000 26,000 16,500 16,000 43, Premcor Refining Group Inc Delaware... City 50,000 26,000 16,500 16,000 43, Georgia Nustar Asphalt Refining LLC (Formerly Citgo Asphalt Refining Co) Savannah Hawaii... 13, ,500 Chevron USA Inc Honolulu ,500 Tesoro Hawaii Corp Ewa... Beach 13, Illinois , ,000 68, , ,300 ExxonMobil Refining & Supply Co Joliet , , ,300 Marathon Petroleum Co LLC Robinson... 66,500 39, , PDV Midwest Refining LLC Lemont... 95, ,000 35, WRB Refining LLC Wood... River 69,300 80,000 53,250 46, Energy Information Administration, Refinery Capacity

15 Table 3. Capacity of Operable Petroleum Refineries by State as of January 1, 2009 (Barrels per Stream Day, Except Where Noted) State/Refiner/Location Atmospheric Crude Oil Distillation Capacity Barrels per Barrels per Calendar Day Stream Day Operating Idle Operating Idle Downstream Charge Capacity Thermal Cracking Vacuum Delayed Other/Gas Distillation Coking Fluid Coking Visbreaking Oil Indiana , , ,100 36, BP Products North America Inc Whiting... Countrymark Cooperative Inc Mount... Vernon 405, , ,000 36, , , , Kansas , , ,500 65, Coffeyville Resources Rfg & Mktg LLC Coffeyville... Frontier El Dorado Refining Co El... Dorado NCRA McPherson , , ,000 24, , , ,000 19, , , ,500 22, Kentucky ,000 5, ,000 6, , Marathon Petroleum Co LLC Catlettsburg... Somerset Energy Refining LLC (Formerly Somerset Refinery Inc) Somerset , , , , , Louisiana... 2,967,123 25,000 3,101,705 25,650 1,527, , ,600 Alon Refining Krotz Springs Inc (Formerly Valero Refining Co Louisiana) Krotz... Springs Calcasieu Refining Co Lake... Charles Calumet Lubricants Co LP Cotton... Valley Princeton... Calumet Shreveport LLC Shreveport... Chalmette Refining LLC Chalmette... Citgo Petroleum Corp Lake... Charles ConocoPhillips Company Belle... Chasse Westlake... Excel Paralubes Westlake... ExxonMobil Refining & Supply Co Baton... Rouge Marathon Petroleum Co LLC Garyville... Motiva Enterprises LLC Convent... Norco... 80, , , ,000 25,000 54,350 25,650 30, , , , , , , , , , , ,700 40, , , ,000 99, , , ,000 27, , , ,000 64, , , , , , , , ,000 40, , , , , , ,000 27, Energy Information Administration, Refinery Capacity 2009

16 Table 3. Capacity of Operable Petroleum Refineries by State as of January 1, 2009 (Barrels per Stream Day, Except Where Noted) Downstream Charge Capacity Catalytic Cracking Catalytic Hydrocracking a Catalytic Reforming State/Refiner/Location Fresh Recycled Distillate Gas Oil Residual Low Pressure High Pressure Fuels Solvent Deasphalting Indiana ,200 4, ,500 71,500 0 BP Products North America Inc Whiting ,000 4, ,500 0 Countrymark Cooperative Inc Mount... Vernon 8, , Kansas , , ,000 22,500 0 Coffeyville Resources Rfg & Mktg LLC Coffeyville... 36, , Frontier El Dorado Refining Co El... Dorado 40, ,500 22,500 0 NCRA McPherson... 24, , , Kentucky , ,000 32,000 12,500 Marathon Petroleum Co LLC Catlettsburg , ,000 31,000 12,500 Somerset Energy Refining LLC (Formerly Somerset Refinery Inc) Somerset ,000 0 Louisiana... 1,151,600 13,500 49, ,000 52, , ,800 63,000 Alon Refining Krotz Springs Inc (Formerly Valero Refining Co Louisiana) Krotz... Springs 34, ,000 0 Calcasieu Refining Co Lake... Charles Calumet Lubricants Co LP Cotton... Valley Princeton Calumet Shreveport LLC Shreveport , Chalmette Refining LLC Chalmette... 71, , ,000 29,400 0 Citgo Petroleum Corp Lake... Charles 147,000 3, , ,000 52,800 0 ConocoPhillips Company Belle... Chasse 102,000 2, ,600 0 Westlake... 50, , Excel Paralubes Westlake , ExxonMobil Refining & Supply Co Baton... Rouge 242, , , Marathon Petroleum Co LLC Garyville , , ,000 Motiva Enterprises LLC Convent... 92, , ,000 0 Norco , , ,000 22,000 0 Energy Information Administration, Refinery Capacity

17 Table 3. Capacity of Operable Petroleum Refineries by State as of January 1, 2009 (Barrels per Stream Day, Except Where Noted) Downstream Charge Capacity Desulfurization (incl. Catalytic Hydrotreating) State/Refiner/Location Naphtha/ Reformer Feed Gasoline Kerosene/ Jet Fuel Diesel Fuel Other Distillate Residual Heavy Gas Oil Other Indiana... 81,500 26,000 2, , ,000 0 BP Products North America Inc Whiting... 71,500 26,000 2, , ,000 0 Countrymark Cooperative Inc Mount... Vernon 10, , Kansas , , ,700 27, ,000 0 Coffeyville Resources Rfg & Mktg LLC Coffeyville... 36, ,000 30,000 27, Frontier El Dorado Refining Co El... Dorado 42, ,000 51, ,000 0 NCRA McPherson... 36, , Kentucky... 53, ,000 77, ,500 22,400 Marathon Petroleum Co LLC Catlettsburg... 52, ,000 77, ,500 22,400 Somerset Energy Refining LLC (Formerly Somerset Refinery Inc) Somerset... 1, Louisiana , , , , ,500 12, , ,500 Alon Refining Krotz Springs Inc (Formerly Valero Refining Co Louisiana) Krotz... Springs 14,000 18, Calcasieu Refining Co Lake... Charles Calumet Lubricants Co LP Cotton... Valley 4, Princeton , Calumet Shreveport LLC Shreveport... 16, , ,100 1,200 Chalmette Refining LLC Chalmette... 40,000 45, , ,500 0 Citgo Petroleum Corp Lake... Charles 123,000 77,000 29, , ConocoPhillips Company Belle... Chasse 48,300 53, , Westlake... 50,000 38,500 24,000 55, ,500 49,000 0 Excel Paralubes Westlake ExxonMobil Refining & Supply Co Baton... Rouge 78, , , ,300 Marathon Petroleum Co LLC Garyville... 49,500 89, , ,000 0 Motiva Enterprises LLC Convent... 98, ,800 70, ,000 0 Norco... 38,500 75, , Energy Information Administration, Refinery Capacity 2009

18 Table 3. Capacity of Operable Petroleum Refineries by State as of January 1, 2009 (Barrels per Stream Day, Except Where Noted) State/Refiner/Location Atmospheric Crude Oil Distillation Capacity Barrels per Barrels per Calendar Day Stream Day Operating Idle Operating Idle Downstream Charge Capacity Thermal Cracking Vacuum Delayed Other/Gas Distillation Coking Fluid Coking Visbreaking Oil Louisiana... 2,967,123 25,000 3,101,705 25,650 1,527, , ,600 Murphy Oil USA Inc Meraux... Pelican Refining Company LLC Lake... Charles Placid Refining Co Port... Allen Shell Chemical LP Saint... Rose Valero Refining New Orleans LLC Norco , , , , , , , , , , , , ,000 71, Michigan , , , Marathon Petroleum Co LLC Detroit , , , Minnesota , , ,500 67, Flint Hills Resources LP Saint... Paul Marathon Petroleum Co LLC Saint... Paul 280, , ,000 67, , , , Mississippi , , , , Chevron USA Inc Pascagoula... Ergon Refining Inc Vicksburg... Hunt Southland Refining Co Sandersville , , , , , , , , , , Montana , , ,300 36,700 10, Cenex Harvest States Coop Laurel... ConocoPhillips Company Billings... ExxonMobil Refining & Supply Co Billings... Montana Refining Co Great... Falls 59, , ,000 15, , , ,400 21, , , , , , , , Nevada... 2, , , Foreland Refining Corp Ely... 2, , , New... Jersey 543, , , , ,000 27, Chevron USA Inc Perth... Amboy ConocoPhillips Company Linden... Hess Corporation Port... Reading 0 80, ,000 47, , , , Energy Information Administration, Refinery Capacity

19 Table 3. Capacity of Operable Petroleum Refineries by State as of January 1, 2009 (Barrels per Stream Day, Except Where Noted) Downstream Charge Capacity Catalytic Cracking Catalytic Hydrocracking a Catalytic Reforming State/Refiner/Location Fresh Recycled Distillate Gas Oil Residual Low Pressure High Pressure Fuels Solvent Deasphalting Louisiana... 1,151,600 13,500 49, ,000 52, , ,800 63,000 Murphy Oil USA Inc Meraux... 37, , , ,000 Pelican Refining Company LLC Lake... Charles Placid Refining Co Port... Allen 25, , ,000 Shell Chemical LP Saint... Rose Valero Refining New Orleans LLC Norco ,000 8, , Michigan... 32, , Marathon Petroleum Co LLC Detroit... 32, , Minnesota , , ,500 33,300 0 Flint Hills Resources LP Saint... Paul 86, , ,500 13,800 0 Marathon Petroleum Co LLC Saint... Paul 28, ,500 0 Mississippi... 88, , ,000 34,000 0 Chevron USA Inc Pascagoula... 88, , ,000 34,000 0 Ergon Refining Inc Vicksburg Hunt Southland Refining Co Sandersville Montana... 63, , ,000 27,080 0 Cenex Harvest States Coop Laurel... 15, , ConocoPhillips Company Billings... 21, ,550 0 ExxonMobil Refining & Supply Co Billings... 23, , ,500 0 Montana Refining Co Great... Falls 3, ,030 0 Nevada Foreland Refining Corp Ely New... Jersey 327, , ,000 Chevron USA Inc Perth... Amboy ConocoPhillips Company Linden , , ,000 Hess Corporation Port... Reading 70, Energy Information Administration, Refinery Capacity 2009

20 Table 3. Capacity of Operable Petroleum Refineries by State as of January 1, 2009 (Barrels per Stream Day, Except Where Noted) Downstream Charge Capacity Desulfurization (incl. Catalytic Hydrotreating) State/Refiner/Location Naphtha/ Reformer Feed Gasoline Kerosene/ Jet Fuel Diesel Fuel Other Distillate Residual Heavy Gas Oil Other Louisiana , , , , ,500 12, , ,500 Murphy Oil USA Inc Meraux... 35, ,000 34, ,000 0 Pelican Refining Company LLC Lake... Charles Placid Refining Co Port... Allen 11,000 20, , Shell Chemical LP Saint... Rose Valero Refining New Orleans LLC Norco... 35,000 60,000 11, , Michigan... 29, ,000 30, ,000 0 Marathon Petroleum Co LLC Detroit... 29, ,000 30, ,000 0 Minnesota... 73,000 52,500 49,000 81,500 7, ,500 0 Flint Hills Resources LP Saint... Paul 52,500 52,500 41,500 60,000 7, ,000 0 Marathon Petroleum Co LLC Saint... Paul 20, ,500 21, ,500 0 Mississippi... 57, ,000 35, ,000 62,000 Chevron USA Inc Pascagoula... 57, ,000 35, ,000 50,000 Ergon Refining Inc Vicksburg ,000 Hunt Southland Refining Co Sandersville Montana... 44,050 24,900 19,300 42,400 24, ,400 7,900 Cenex Harvest States Coop Laurel... 15, , ,000 0 ConocoPhillips Company Billings... 13,550 6,000 4,400 30, ,400 0 ExxonMobil Refining & Supply Co Billings... 13,900 18,900 13,900 10, ,900 Montana Refining Co Great... Falls 1, ,000 2, ,000 0 Nevada Foreland Refining Corp Ely New... Jersey 159, ,000 28, , ,000 Chevron USA Inc Perth... Amboy ConocoPhillips Company Linden... 97, , Hess Corporation Port... Reading 0 27, ,000 Energy Information Administration, Refinery Capacity

21 Table 3. Capacity of Operable Petroleum Refineries by State as of January 1, 2009 (Barrels per Stream Day, Except Where Noted) State/Refiner/Location Atmospheric Crude Oil Distillation Capacity Barrels per Barrels per Calendar Day Stream Day Operating Idle Operating Idle Downstream Charge Capacity Thermal Cracking Vacuum Delayed Other/Gas Distillation Coking Fluid Coking Visbreaking Oil New... Jersey 543, , , , ,000 27, Nustar Asphalt Refining LLC (Formerly Citgo Asphalt Refining Co) Paulsboro... Sunoco Inc Westville... Valero Refining Co New Jersey Paulsboro , ,000 40, , , , , , ,000 27, New... Mexico 132, , , Navajo Refining Co Artesia... Western Refining Southwest Inc Bloomfield... Gallup... 95, , , , , , , North... Dakota 58, , Tesoro West Coast Mandan... 58, , Ohio , , ,500 58, BP-Husky Refining LLC (Formerly BP Products North America LLC) Toledo... Lima Refining Company Lima... Marathon Petroleum Co LLC Canton... Sunoco Inc Toledo , , ,500 35, , , ,000 23, , , , , , Oklahoma ,100 12, ,846 14, ,050 37, ConocoPhillips Company Ponca... City Sinclair Tulsa Refining Co (Formerly Sinclair Oil Corp) Tulsa... Sunoco Inc Tulsa... Valero Refining Co Oklahoma Ardmore... Ventura Refining & Transmission LLC Thomas... Wynnewood Refining Co Wynnewood , , ,050 26, , , , , , ,000 11, , , , , , , , , Pennsylvania , , , American Refining Group Inc Bradford... ConocoPhillips Company Trainer... 10, , , , , Energy Information Administration, Refinery Capacity 2009

22 Table 3. Capacity of Operable Petroleum Refineries by State as of January 1, 2009 (Barrels per Stream Day, Except Where Noted) Downstream Charge Capacity Catalytic Cracking Catalytic Hydrocracking a Catalytic Reforming State/Refiner/Location Fresh Recycled Distillate Gas Oil Residual Low Pressure High Pressure Fuels Solvent Deasphalting New... Jersey 327, , ,000 Nustar Asphalt Refining LLC (Formerly Citgo Asphalt Refining Co) Paulsboro Sunoco Inc Westville... 57, , Valero Refining Co New Jersey Paulsboro... 55, , New... Mexico 41,500 3, ,000 11,800 0 Navajo Refining Co Artesia... 27, , Western Refining Southwest Inc Bloomfield... 6, ,000 0 Gallup... 8,500 3, ,800 0 North... Dakota 27,000 3, ,100 0 Tesoro West Coast Mandan... 27,000 3, ,100 0 Ohio , , , ,000 0 BP-Husky Refining LLC (Formerly BP Products North America LLC) Toledo... 55, , ,000 0 Lima Refining Company Lima... 40, , ,000 0 Marathon Petroleum Co LLC Canton... 26, , Sunoco Inc Toledo... 79, , ,000 0 Oklahoma ,010 2,250 28, ,850 98,704 4,850 ConocoPhillips Company Ponca... City 69, ,704 0 Sinclair Tulsa Refining Co (Formerly Sinclair Oil Corp) Tulsa... 24,209 2, ,000 0 Sunoco Inc Tulsa ,000 0 Valero Refining Co Oklahoma Ardmore... 30, , , Ventura Refining & Transmission LLC Thomas Wynnewood Refining Co Wynnewood... 21, , , ,850 Pennsylvania ,500 1, ,000 50, ,800 0 American Refining Group Inc Bradford ,800 0 ConocoPhillips Company Trainer... 53, ,000 50, Energy Information Administration, Refinery Capacity

23 Table 3. Capacity of Operable Petroleum Refineries by State as of January 1, 2009 (Barrels per Stream Day, Except Where Noted) Downstream Charge Capacity Desulfurization (incl. Catalytic Hydrotreating) State/Refiner/Location Naphtha/ Reformer Feed Gasoline Kerosene/ Jet Fuel Diesel Fuel Other Distillate Residual Heavy Gas Oil Other New... Jersey 159, ,000 28, , ,000 Nustar Asphalt Refining LLC (Formerly Citgo Asphalt Refining Co) Paulsboro Sunoco Inc Westville... 30,000 65, , Valero Refining Co New Jersey Paulsboro... 32,000 35,000 28,500 46, New... Mexico 47, ,000 47, ,000 0 Navajo Refining Co Artesia... 36, ,000 41, ,000 0 Western Refining Southwest Inc Bloomfield... 5, , Gallup... 6, , North... Dakota 13,600 4, , Tesoro West Coast Mandan... 13,600 4, , Ohio , ,000 30,000 60, ,000 0 BP-Husky Refining LLC (Formerly BP Products North America LLC) Toledo... 40, , ,000 0 Lima Refining Company Lima... 63,000 35, , Marathon Petroleum Co LLC Canton... 25, , ,000 0 Sunoco Inc Toledo... 39,500 65,000 30, Oklahoma ,507 69,282 18, ,981 31, ,338 34,354 ConocoPhillips Company Ponca... City 49,007 47,282 18,500 31,981 31, ,888 12,754 Sinclair Tulsa Refining Co (Formerly Sinclair Oil Corp) Tulsa... 20,000 22, , Sunoco Inc Tulsa... 28, ,600 Valero Refining Co Oklahoma Ardmore... 26, , ,450 0 Ventura Refining & Transmission LLC Thomas Wynnewood Refining Co Wynnewood... 13, , Pennsylvania , ,500 27,800 44, , ,000 0 American Refining Group Inc Bradford... 3, ConocoPhillips Company Trainer... 77, ,300 27,300 4, , Energy Information Administration, Refinery Capacity 2009

24 Table 3. Capacity of Operable Petroleum Refineries by State as of January 1, 2009 (Barrels per Stream Day, Except Where Noted) State/Refiner/Location Atmospheric Crude Oil Distillation Capacity Barrels per Barrels per Calendar Day Stream Day Operating Idle Operating Idle Downstream Charge Capacity Thermal Cracking Vacuum Delayed Other/Gas Distillation Coking Fluid Coking Visbreaking Oil Pennsylvania , , , Sunoco Inc Marcus... Hook Sunoco Inc (R&M) Philadelphia... United Refining Co Warren , , , , , , , , Tennessee , , Premcor Refining Group Inc Memphis , , Texas... 4,689,179 58,000 4,938,300 60,000 2,348, ,400 42, Age Refining Inc San... Antonio Alon USA Energy Inc Big... Spring Belvieu Environmental Fuels Mont... Belvieu BP Products North America Inc Texas... City Citgo Refining & Chemical Inc Corpus... Christi ConocoPhillips Company Sweeny... Deer Park Refining LTD Partnership Deer... Park Delek Refining LTD Tyler... Equistar Chemicals LP Channelview... ExxonMobil Refining & Supply Co Baytown... Beaumont... Flint Hills Resources LP Corpus... Christi Houston Refining LP Houston... Marathon Petroleum Co LLC Texas... City Motiva Enterprises LLC Port... Arthur Pasadena Refining Systems Inc Pasadena... Premcor Refining Group Inc Port... Arthur South Hampton Resources Inc Silsbee... Total Petrochemicals Inc Port... Arthur Trigeant LTD Corpus... Christi 14, , , , , , , ,000 33, , , ,000 45, , , ,100 78, , , ,000 88, , ,000 15,000 6, , , ,600 51,400 42, , , ,800 48, , , ,500 14, , , , , , , , , ,000 57, , , ,000 12, , , ,000 99, , , , , Energy Information Administration, Refinery Capacity

25 Table 3. Capacity of Operable Petroleum Refineries by State as of January 1, 2009 (Barrels per Stream Day, Except Where Noted) Downstream Charge Capacity Catalytic Cracking Catalytic Hydrocracking a Catalytic Reforming State/Refiner/Location Fresh Recycled Distillate Gas Oil Residual Low Pressure High Pressure Fuels Solvent Deasphalting Pennsylvania ,500 1, ,000 50, ,800 0 Sunoco Inc Marcus... Hook 108, ,000 0 Sunoco Inc (R&M) Philadelphia , ,000 0 United Refining Co Warren... 25,000 1, ,000 0 Tennessee... 70, , Premcor Refining Group Inc Memphis... 70, , Texas... 1,827,405 33, , , , , ,600 Age Refining Inc San... Antonio Alon USA Energy Inc Big... Spring 25, , ,000 Belvieu Environmental Fuels Mont... Belvieu BP Products North America Inc Texas... City 175,000 8,000 60, ,000 75,000 17,000 Citgo Refining & Chemical Inc Corpus... Christi 82, , ConocoPhillips Company Sweeny ,700 12, , Deer Park Refining LTD Partnership Deer... Park 70,000 5, , ,000 25,000 0 Delek Refining LTD Tyler... 20, ,000 4,500 0 Equistar Chemicals LP Channelview ExxonMobil Refining & Supply Co Baytown ,500 8,000 28, , ,000 Beaumont , , , Flint Hills Resources LP Corpus... Christi 106, , ,500 18,000 0 Houston Refining LP Houston , Marathon Petroleum Co LLC Texas... City 58, ,500 0 Motiva Enterprises LLC Port... Arthur 90, , Pasadena Refining Systems Inc Pasadena... 56, , Premcor Refining Group Inc Port... Arthur 78, , , South Hampton Resources Inc Silsbee , Total Petrochemicals Inc Port... Arthur 80, , ,500 Trigeant LTD Corpus... Christi Energy Information Administration, Refinery Capacity 2009