Lubricants & Fluids LUBRICANTS AND FLUIDS

Transcription

1 Lubricants & Fluids Technical Lubricants Data & Fluids LUBRICANTS AND FLUIDS Recommendations for all climates and conditions. Note: Recommended oils are complete in themselves and additives should not be used. Note: It is essential to change oil much more frequently if the vehicle is operated under severe conditions, especially if deep wading is carried out. Engine oil - V8 vehicles Use only oils Certified for Gasoline Engines by the American Petroleum Institute (API). To protect your engine s warranty, use an SAE 5W/30 oil meeting specification WSS-M2C205-A (GF3). Engine oil - V6 vehicles Use only oils Certified for Gasoline Engines by the American Petroleum Institute (API). To protect your engine s warranty, use an SAE 5W/30 oil meeting specification WSS-M2C929-A (GF4). Main gearbox All vehicles: Shell ATF M Transfer gearbox All vehicles: Shell TF Front differential: All vehicles: SAF XO. Rear differential: Non-locking: SAF XO. Locking: SAFXJ Power steering Texaco Cold Climate PAS fluid Brake reservoir Use Shell DOT4 ESL or a low viscosity DOT4 brake fluid that meets ISO 4925 class 6 and Land Rover LRES22BF03 requirements. Windshield washers Screen washer fluid. Engine cooling system Texaco XLC, with one part antifreeze to one part water for protection down to -33 F (-36 C). 311

2 Lubricants & Fluids Caution: Be aware that different types of antifreeze are VERY different from each other; even different types from the same manufacturer. The use of non-approved antifreeze will have an adverse effect on the engine cooling system and therefore engine durability. Inertia reel seat belts DO NOT LUBRICATE. These components are lubricated for life during manufacture. LAND ROVER RECOMMENDS 312

3 Capacities Capacities CAPACITIES The following capacities are approximate and provided as a guide only. All oil levels must be checked using the dipstick or level plugs as applicable. Fuel tank 86 litres gallons Engine oil (dry fill): - V8 Petrol vehicles 8.6 litres Pints - V6 Petrol vehicles 6,3 litres pints Engine oil refill and filter change: - V8 Petrol vehicles 7,7 litres 13.5 pints - V6 Petrol vehicles 5,7 litres pints Engine oil minimum to maximum on dipstick: - V8 Petrol vehicles 1.5 litres 3.17 pints - V6 Petrol vehicles 1.4 litres 2.6 pints Automatic gearbox Fill for life. Fill for life. Transfer box 1.5 litres 3.17 pints Front differential 0,69 litres 1.46 pints Rear differential - non-locking 1,16 litres 2.45 pints Rear differential - electronic locking 1,61 litres 3.4 pints Washer reservoir 5,0 litres pints Cooling system (fill from dry): - V8 Petrol vehicles 15 litres 31.7 pints - V6 Petrol vehicles 12 litres pints Cooling system (refill): - V8 Petrol vehicles 9,5 litres 20 pints - V6 Petrol vehicles 8,5 litres 17.9 pints 313

4 Engines ENGINES V8 V6 Engines Fuel Premium Unleaded fuel with an octane rating of 91 or higher Displacement 4394 cm 3 Firing order Idle speed rev/min Bore 88,0 mm Stroke 90,3 mm Number of cylinders 8 Compression ratio 10.75:1 Spark plugs NGK IFR5N10 Spark plug gap 1,5 mm (0.060 in.) Fuel Premium Unleaded fuel with an octane rating of 90 or higher Displacement 4009 cm 3 Firing order Idle speed rev/min Bore 100,4 mm Stroke 84,4 mm Number of cylinders 6 Compression ratio 9.7:1 Spark plugs Motorcraft AGSF 24 PM Spark plug gap 1,5 mm (0.060 in.) 314

5 Electrical System Electrical System ELECTRICAL SYSTEM Battery type: All vehicles Battery rating: All vehicles Voltage and polarity Charging circuit Group 95R, sealed for life 75 amp/hr 12 V, negative (-) earth Alternator 315

6 Steering Steering STEERING Steering wheel turns lock to lock 3.3 Turning circle curb to curb 11,45 metres (37.56 ft) Camber angle -0.5 Castor angle 4.4 King pin inclination 13.9 Front wheel toe-out included angle

7 Wheels & Tires Wheels & Tires WHEELS & TIRES WARNING ALWAYS use radial-ply tyres front and back. DO NOT use cross-ply tyres, or interchange tyres from front to back For optimum performance and handling ALWAYS replace tyres with the same make and type as those fitted from new at the factory. If these tyres are not available, consult your Dealer/Authorised Repairer for advice on Land Rover approved alternatives. Failure to do so may adversely affect vehicle handling. NEVER drive your vehicle if the tyres are badly worn, cut or damaged, or if the pressures are incorrect. Incorrectly inflated tyres wear rapidly and can seriously affect the vehicle s safety and road handling characteristics. Your vehicle is fitted with tubeless road wheels that will NOT accept inner tubes. DO NOT fit a tubed tyre. ONLY Land Rover approved wheel and tyre combinations should be fitted to the vehicle. Wheel size and type Type Size Alloy wheels 7J x 17 8J x 18 8J x 19 Compact spare wheel - steel 5.5J x 19 Road wheel nut torque to hub 140 Nm (+/- 10 Nm) Tire specification Wheel size Tire Load Index Snow Chain Fitment Front Rear 7J x 17 (alloy wheel) 235/70 R17 H - All terrain tire 111 Y N 8J x 18 (alloy wheel) 255/60 R18 H or V - All terrain tire 112 Y N 8J x 19 (alloy wheel) 255/55 R19 H or V - All terrain tire 111 Y N Note: For further information on Snow Chains, see SNOW CHAINS,

8 Wheels & Tires TIRE PRESSURES Tire inflation pressures Note: The pressure for your spare tire should be set to the highest value given for your vehicle s wheel/tire size combination and adjusted after fitment. Note: When towing a heavily laden trailer, tire pressures should be increased to the maximum specified in the handbook, and road speeds limited to 100 km/h (60 mph). This excludes the compact spare wheel* which has a maximum permitted speed of 80 km/h (50 mph) with tire pressures maintained at those shown in the above table. Accessory wheels - insert details kpa bar lbf/in 2 Normal operating conditions Front Rear Loaded to Maximum GVW Front Rear Compact spare tire (All operating conditions) Wheel size Tire Snow Chain Fitment Front Rear Accessory wheel tire pressures - insert details Loading condition kpa bar lbf/in 2 Normal operating conditions Front Rear Vehicle loaded to maximum gross vehicle weight Front Rear 318

9 Vehicle Weights Vehicle Weights VEHICLE WEIGHTS DEFINITIONS Curb Weight Minimum unladen vehicle weight plus a full fuel tank. Gross Vehicle Weight Maximum permissible weight of vehicle with driver, passengers, payload, equipment and towing attachment load (where applicable). Approximate curb weights (full fuel tank) V kg lb. V kg lb. Maximum gross vehicle weight (GVW) V kg lb. V kg 7121 lb. Maximum front axle load All vehicles 1450 kg 3197 lb. Maximum rear axle load See vehicle VIN plate kg lb. Gross train Weight (GVW + Max Trailer Weight) See vehicle VIN plate kg lb. Note: Axle weights are non-additive. The individual maximum axle weights and gross vehicle weight must not be exceeded. 319

10 Dimensions Dimensions DIMENSIONS B H5737G G A C D E F H A Overall width 2191 mm in. Overall width (mirrors folded) 2009 mm in. B Overall height (standard ride height) - Fixed roof - Sunroof open - With roof side rails - With roof antenna module C Approach angle (curb weight and off-road height) D Breakover angle (curb weight and off-road height) 1887 mm 1920 mm 1891 mm 1940 mm 37.2 o o 74.3 in in in in. E Wheelbase 2885 mm in. F Overall length 4848 mm in. Overall length (including tow hitch - to centre of tow ball) 4913 mm in. G Track: - Front 1605 mm 63.2 in. - Rear 1612 mm 63.5 in. H Departure angle without tow hitch (curb weight and off-road height) 30 o Departure angle with tow hitch (at curb weight): - Standard ride height - Off -road ride height Wading depth - Standard height - Off-road height 15.7 o 18.5 o 600 mm 700 mm in in. Minimum ground clearance (off-road height) 240 mm 9.45 in. Maximum gradient, nose up/down - Continuous operation - Drive-through 35 o 45 o 320

11 Towing Towing TOWING WEIGHTS Maximum permissible towed weights On-road Off-road Unbraked trailers 750 kg (1654 lb.) 750 kg (1654 lb.) Trailers with overrun brakes 3500 kg (7716 lb.) 1000 kg (2205 lb.) Roof rack load (including the mass of roof rack) 75 kg (165 lb.) 50 kg (110 lb.) Maximum permissible tongue weight 250 kg (550 lb.) 250 kg (550 lb.) 321

12 322

13 Index A Accessories Adaptive Frontlighting System Aerial Air conditioning Air vents Air vents (rear) Airbag occupancy detection Airbag SRS cleaning disposal location operation servicing Airbags side Alarm indicator light partial arming perimetric Tilt sensor Anti-freeze Anti-lock braking (ABS) Anti-theft alarm Audible warnings Audio system remote controls Auto safety hotline Automatic control lamps Auxiliary equipment (use of) Auxiliary power socket Axle loads B Battery disconnection disposal jump starting maintenance reconnection removal and replacement replacement safety specification Battery disconnection - effects Booster starting starting your vehicle Brake fluid fluid check & top-up replacement specification Brakes anti-lock brakes (ABS) brake pads cornering control dynamic control electronic brake force distribution (EBD) foot brake handbrake servo assistance warning indicator (ABS) Breakdown recovery Breaking-in , 163 Bulb replacement door lamp front fog lamps headlamps high beam loadbay lamp map lamp mirror downlighter number plate lamps puddle lights tailgate lamp vanity mirror lamp

14 Index C California Proposition 65 Warning Capacities Carpets (cleaning) Catalytic converter Check control Child restraints for larger children for small children and babies LATCH Child safety locks Child seats Chocks Cigar lighter Cleaning (exterior) Cleaning (interior) Clock setting the time Cold climate starting Controls instrument panel Convenience seats Cool box Coolant check & top-up replacement specification Cooling system Cornering brake control Courtesy lamps operation Cruise control Cubby box Cup holders D Data recording Dimensions Direction indicators operation Door mirrors Door/puddle lamps bulb replacement Driving , 165 Dynamic brake control Dynamic Stability Control E Electric windows Electronic Traction Control Emergency starting Emergency towing Emission control system , 237 Engine Breaking-in breaking-in data warming-up , 221 Engine compartment V V Engine immobilisation Engine oil check & top-up disposal (used oil) specification Engine starting Exterior mirrors F Face level vents Fluid specifications Fog lamps (front) bulb replacement Folding armrest Fuel economy , 223 empty tank filler filling safety specification tank capacity Fuel cut-off system Fuel gauge Fuse box main (passenger compartment)

15 Index Fuses main fuse box G Gas station safety Gauge fuel Gauges speedometer tachometer temperature Gear selector position display Gearbox Automatic default mode electronic modes emergency park release kick down manual mode selector positions sport mode Gearbox (automatic) starting Gearbox (transfer box) General data Gross weights Ground clearance H Halogen bulbs Handbrake Handset battery disposal battery replacement buttons customer programmable button Headlamp Courtesy Delay Land Rover button , 35 operation Panic alarm Remote suspension operation replacement Handset compliance Headlamp courtesy delay Headlamps AFS bulb replacement washers Headlamps high beam bulb replacement Heated seats front rear Height (of vehicle) Hill Descent Control (HDC) operation warning HomeLink accessories compliance erasing channels operation precautions programming rolling codes Hood opening Horn I Ignition switch Information labels Instrument pack instruments warning indicators Instrument panel cleaning Interior (cleaning) Interior lamps operation Interior locking switch J Jack (wheel changing) Jacking the vehicle Jump starting starting your vehicle

16 Index K Key/handset numbers Keys L Labels Lamps automatic control front fog hazard warning headlamp courtesy delay headlamp flash high beam rear fog reversing side Lamps (exterior) direction indicators Lamps (interior) courtesy loadspace LATCH child restraints Lights rear Load carrying roof rack Load limit procedure Loadbay lamp bulb replacement Loadspace access hatch Loadspace cover Loadspace lamp operation Locking Locking wheel nuts Locking/Unlocking Single point entry Locking/unlocking emergency interior switch speed-related Lower tailgate opening Lubricant specifications Luggage anchor points M Main fuse box Main message center Maintenance , 235 Manual seats Map lamp bulb replacement Message center critical warnings information warning messages Mirror downlighter bulb replacement Mirrors electric operation Mirrors (exterior) adjustment cleaning folding N Number plate lamps bulb replacement O Odometer (distance recorder) Off-road driving Oil (engine) check & top-up disposal specification Owner maintenance P Parkbrake Parts & accessories Personal settings Poisonous fluids Polishing (the bodywork) Power socket Power steering emergency operation fluid check & top-up

17 Index Pre-tensioners servicing Procedure - correct load limit Production option weights Punctured tires R Radio aerial Radio/cassette player aerial remote controls Rear window wash/wipe Recommended tire pressures Recovery (of vehicle) Remote controls audio system Remote handset battery Reporting safety defects Road testing on dynamometers Roof rack S Safety in the garage Screen wash Seat belt adjustment cleaning operation pre-tensioners safety testing Seat belt pre-tensioners servicing Seat belts caring for fastening locking mechanism pregnant women Seat heaters front rear Seats access position child seats correct position folding armrest front front (manual) front (power-operated) loadspace position lumbar support adjustment manual adjustment seat memory facility second row (5-seat vehicle) second row (7-seat vehicle) table-fold position third row Self-levelling suspension operation Service interval indicator Service portfolio book , 235 Servo assistance (brakes) Side airbags Side lamps Side marker lamp bulb replacement Snow chains Spare wheel (removing) Speedometer Speed-related locking Starter switch Starting automatic models catalyst (precautions) emergency warming-up the engine , 221 Steering column lock Steering data Steering wheel adjustment Storage bins Sun visor

18 Index Sunroof electric operation roller blind System check control T Tachometer Tailgate opening Tailgate emergency unlock Tailgate lamp bulb replacement Technical data Temperature gauge Terrain Response Tether anchorages Tilt sensor Tire pressures punctures replacement specification wear indicators Tire care Tire glossary , 265 Tire information labels Tire pressures Tires pressure labels , 261 pressure monitoring Tool kit Tow bars Towing Towing eyes Towing for recovery Towing weights Trailer socket Transfer gearbox Transmission Automatic default mode electronic modes emergency park release kick down manual mode selector positions sport mode Transmitter - HomeLink Transporter or trailer lashing Transporting your vehicle Trip computer Settings option Trip recorder Trip recorder reset button U Underbody maintenance Under-hood covers refitting removal Uniform tire quality grading V Vanity mirror (illumination) Vanity mirror lamp bulb replacement Vehicle height Vehicle identification number Vehicle recovery Vehicle weights Ventilation Voice Recognition Activating the system Voice recognition help commands notepad steering wheel control W Wading Warming-up (the engine) ,

19 Index Warning indicators airbag SRS anti-lock braking (ABS) battery charging brake system , 103 check engine cruise control active direction indicators door open Dynamic Stability Control HDC fault Hill Descent Control low coolant low oil pressure parkbrake system rear fog guard lamps , 102, 103 seat belt , 101 tire pressure monitoring transmission fault , 104 Warning labels Warning lights headlamp high beam low oil pressure low washer Warranty information Washers (windshield fluid top-up Washers (windshield) jets operation Washing (the bodywork) Weights (vehicle) Wheel size & type spare (removal) Wheel changing changing the wheel jacking the vehicle locking wheel nuts spare wheel tool kit Wheel chocks Wheels locking wheel nuts Windows Windscreen wipers variable delay Windshield washers fluid top-up operation Windshield wipers blade replacement intermittent wipe operation roadspeed sensor variable delay Wiper blade replacement front rear X Xenon light units