RX350. In accordance with the change of engine from 1MZ-FE and 3MZ-FE to 2GR-FE, the model code has been changed as follows.

Transcription

1 2 RX350 OUTLINE OF NEW FEATURES RX350 OUTLINE OF NEW FEATURES The ollowing changes are made or the new RX350.. Model Code In accordance with the change o engine rom MZ-FE and 3MZ-FE to 2GR-FE, the model code has been changed as ollows. " Model Code A Drive 2. Engine Model New Previous Engine 2GR-FE 3MZ-FE MZ-FE 4WD GSU35R-AWAGKW GSU35L-AWAGKW GSU35R-AWAGKQ GSU35L-AWAGKV MCU38R-AWAGKQ MCU38L-AWAGKV MCU35R-AWAGKW MCU35L-AWAGKW Uses o the MZ-FE and 3MZ-FE engine has been discontinued. The 2GR-FE engine is adopted. For details, see page. D The 2GR-FE is a 3.5-liter, 24-valve DOHC V6 engine. D This engine uses a Dual VVT-i (Variable Valve Timing-intelligent) system, DIS (Direct Ignition System), ACIS (Acoustic Control Induction System) and ETCS-i (Electronic Throttle Control System-intelligent). D These control unctions achieve improved engine perormance, uel economy, and cleaner emissions.

2 3. Automatic Transaxle RX350 OUTLINE OF NEW FEATURES 3 The same transaxles, with minor speciication dierences, are available in the RX350 as in the previous RX330/300. A U5F automatic transaxle is available or the RX350. The Fluid type has changed rom the ATF T-IV to TOYOTA ATF WS. D TOYOTA ATF WS is used to reduce the resistance to low o the ATF and improve uel economy by reducing its viscosity in the practical operating temperature range. At the high-temperature end o this range, the viscosity is the same as that o ATF T-IV, ensuring the durability o the automatic transmission. D There is no interchangeability between TOYOTA ATF WS and other types o ATF (ATF T-IV, D-II). Viscosity Reduced Viscosity : ATF T-IV : TOYOTA ATF WS High High Temperature 259LSK03 Speciications o the U5F automatic transaxle has been changed as ollows: " Speciications A Model New Previous Engine 2GR-FE MZ-FE, 3MZ-FE Transaxle U5F U5F st nd rd Gear Ratio* 4th th Reverse Dierential Gear Ratio Fluid Capacity* 2 liters (US qts, Imp. qts) 9.0 (9.5, 7.9) 9. (9.6, 8.0) Fluid TOYOTA ATF WS ATF T-IV Weight (Reerence)* 3 kg (lb) 06.3 (234.3) 06.6 (234.8) * : Counter Gear Ratio Included * 2 : Dierential Included * 3 : Weight shows the igure with the luid ully illed.

3 4 RX350 OUTLINE OF NEW FEATURES 4. Transer The engine type is changed rom MZ-FE and 3MZ-FE to 2GR-FE. Because o this change, an MF2AV transer is adopted. The MF2AV transer is similar to the conventional MF2A transer, however, the MF2AV transer contains a viscous coupling type LSD (Limited Slip Dierential). D The MF2AV transer uses a viscous coupling to achieve the slip limiting eect or the center dierential. Viscous Coupling LSD New (MF2AV Transer) 0270CH07Y Previous (MF2A Transer) 0270CH06Y 5. Suspension and Axle Wheel alignment speciications or the new RX350 are shown below. " Speciications A Model RX350 MacPherson Strut Tread mm (in.) 577 (62.)* 2, 578 (62.)* 3 Front Caster degrees 2 35 * 2,2 52 * 3 Suspension* Camber degrees Toe-in mm (in.) 0 King Pin Inclination degrees 0 40 * 2,0 42 * 3 Dual Link MacPherson Strut Rear Tread mm (in.) 557 (6.3)* 2, 563 (6.5)* 3 Suspension* Camber degrees * 2,-0 58 * 3 * : Unloaded Vehicle * 2 : Without Air Suspension * 3 : With Air Suspension Toe-in mm (in.) 3 (0.2)

4 RX350 OUTLINE OF NEW FEATURES 5 6. Brake D The brake system speciications or the new RX350 are shown below. Model RX350 Front Brake Ventilated Disc Rotor Size For 7 in. wheel Rear Brake Solid Disc Rotor Size For 5 in. wheel Brake Control System ABS with EBD, Brake Assist, TRC and VSC Standard Brake Control Valve EBD Parking Brake Pedal " Speciications A Model RX350 Master Cylinder Tandem Cylinder Diameter mm (in.) (0.87) Brake Booster Single Size in. 0.5 Caliper AX63 Front Brake Caliper Bore Diameter mm (in.) 63.5 (2.5) Rotor Size (D T)* mm (in.) (2.56.0) Pad Material T446 Caliper AX4 Rear Brake Caliper Bore Diameter mm (in.) 4.3 (.63) Rotor Size (D T)* mm (in.) ( ) Pad Material PS506H Parking Brake Drum (Duo-servo) Drum Inner Diameter mm (in.) 90.0 (7.48) Brake Actuator ADVICS *: (Diameter Thickness)

5 6 RX350 OUTLINE OF NEW FEATURES D As a result o the adoption o the CAN (Controller Area Network) or communication between the Skid Control ECU and Engine ECU, the diagram o the brake control system (ABS with EBD, Brake Assist, TRC and VSC) is changed as ollows: " System Diagram A Brake Actuator Speed Sensors Brake Pedal Load Sensing Switch Solenoid Relay Master Cylinder Cut Solenoid Valve (2) Solenoid Valve (8) Master Cylinder Pressure Sensor Stop Light Switch Skid Control ECU Pump Motor Motor Relay Parking Brake Switch Motor Cut Relay From Battery VSC Warning Buzzer DLC3 CAN Yaw Rate & Deceleration Sensor Combination Meter BEAN Gateway ECU Steering Angle Sensor ABS Warning Light Brake System Warning Light Crankshat Position Sensor Slip Indicator Light VSC Warning Light Accelerator Pedal Position Sensor Throttle Body Speedometer Intake Air Temp. Sensor Engine ECU Throttle Position Sensor Throttle Control Motor Neutral Start Switch 0280CH0C

6 RX350 OUTLINE OF NEW FEATURES 7 7. Steering Steering speciications or the new RX350 are shown below. " Speciication A Model RX350 Power Steering Engine Revolution Sensing type Hydraulic Power Steering Steering Gear Rack and Pinion Gear Ratio (Overall) 6.0 No. o Turns Lock to Lock 3.0 Rack Stroke mm (in.) 45.0 (5.7) Vane Pump Pressure Return Fluid ATF DEXRON RII or III 8. Multiplex Communication System The CAN (Controller Area Network) has been connected to the Gateway ECU. For details, see the Multiplex Communication System on page Combination Meter The combination meter circuits have been partially changed. For details, see the Meter on page 86.

7 8 RX350 OUTLINE OF NEW FEATURES 0. Lighting System and Wiper System The designs o the light control switch and wiper switch are changed. Without rear og light " New A " Previous A 0270BE0C With rear og light " New A " Previous A 0280BE07C

8 RX350 OUTLINE OF NEW FEATURES 9. Air Conditioner Item A/C Compressor Outline Europe/Australia Models The compressor has been changed rom 0S7 type to the 6SBU6 type. G.C.C. Countries Models The compressor has been changed rom 0S7 type to the 7SBH7 type. The solenoid valve and internal valving have been integrated to control the discharge capacity and to improve the compressor durability. For details, see page Multi Display The multi display unctions are changed. For details, see the Multi Display on page Back Guide Monitor System (Except G.C.C. Countries) D The Television Camera ECU is connected to the CAN. Because o this change, the rear view monitor system circuit has been partially changed. D The mounting location o the Television Camera ECU has been changed. For details, see the Back Guide Monitor System on page Rear View Monitor System (G.C.C. Countries) The Television Camera ECU has been abolished. The rear view monitor system circuits have been changed. For details, see the Rear View Monitor System on page Cruise Control System D The Engine ECU is connected to the CAN. Because o this change, the cruise control system circuit has been partially changed. For details, see the Cruise Control System on page 04. D Low speed limit and RES switch controls have been changed. Control Low Speed Limit RES Switch Model New Previous Even i vehicle speed goes lower than the I vehicle speed goes lower than the low low speed limit, the set vehicle speed speed limit, the set vehicle speed is cleared. remains. Even i the vehicle speed decreases to the low speed limit or less, resume can be perormed when the vehicle speed increases to the low speed limit or more. I the vehicle speed decreases to the low speed or less even once, resume cannot be perormed.

9 0 RX350 MODEL CODE & MODEL LINE-UP MODEL CODE GSU35 L AWAGKW BASIC MODEL CODE GSU35: 2GR-FE 4WD 5 GEAR SHIFT TYPE A: 5-Speed Automatic, Floor STEERING WHEEL POSITION 2 L : Let-Hand Drive R : Right-Hand Drive 6 GRADE G: 3 MODEL NAME A: RX350 7 ENGINE SPECIFICATION K: Compact DOHC and EFI 4 BODY TYPE W: Wagon DESTINATION 8 W : Europe Q : Australia V : G.C.C. Countries MODEL LINE-UP DESTINATION Europe Australia G.C.C. Countries DRIVE ENGINE BODY GRADE TYPE TYPE 4WD 2GR-FE Wagon TRANSAXLE 5-Speed Automatic U5F GSU35R-AWAGKW GSU35L-AWAGKW GSU35R-AWAGKQ GSU35L-AWAGKV

10 RX350 NEW FEATURES NEW FEATURES J2GR-FE ENGINE. Description The 2GR-FE engine is a 3.5-liter, 24-valve DOHC V6 engine. This engine uses a Dual VVT-i (Variable Valve Timing-intelligent) system, DIS (Direct Ignition System), ACIS (Acoustic Control Induction System) and ETCS-i (Electronic Throttle Control System-intelligent). These control unctions achieve improved engine perormance, uel economy, and clean emissions. 285EG0 0270EG26C

11 2 RX350 NEW FEATURES " Engine Speciications A Engine No. o Cyls. & Arrangement Valve Mechanism Combustion Chamber Flow o Intake and Exhaust Gasses Fuel System Ignition System 2GR-FE 6-Cylinder, V 24-Valve DOHC, Chain Drive (with Dual VVT-i) Pentroo Cross-Flow Displacement cm 3 (cu. in.) 3456 (20.9) Bore Stroke mm (in.) ( ) Compression Ratio 0.8 : Max. Output (SAE-NET) Max. Torque (SAE-NET) Oil Capacity Destination Destination Without ih Oil Cooler With ihoil Cooler Europe/Australia G.C.C. Countries Europe/Australia G.C.C. Countries Dry With Oil Filter Without Oil Filter Dry With Oil Filter Without Oil Filter EFI DIS rpm rpm 342 N 4700 rpm 34 N 4700 rpm 6.5 liters (6.9 US qts, 5.7 Imp. qts) 6. liters (6.4 US qts, 5.4 Imp. qts) 5.7 liters (6.0 US qts, 5.0 Imp. qts) 6.8 liters (7.2 US qts, 6.0 Imp. qts) 6. liters (6.4 US qts, 5.4 Imp. qts) 5.7 liters (6.0 US qts, 5.0 Imp. qts) 20W-50 and 5W-40 API grade SL or SM multigrade engine oil 0W-30 and 5W-30 API grade SL Oil Grade Energy-Conserving, Energy-Conserving SM or ILSAC multigrade engine oil TOYOTA Genuine Super Long Lie Coolant or the ollowing* Engine Coolant Without Oil Cooler 9.0 liters (9.5 US qts, 7.9 Imp. qts) Capacity With Oil Cooler 9.2 liters (9.7 US qts, 8.mp. qts) DENSO FK20HR (Iridium) Spark Plug Plug Gap mm (in.).0 -. ( ) Firing Order Research Octane Europe/Australia 95 or higher Destination No. G.C.C. Countries 96 or higher Tailpipe Emission Regulation EURO IV Without Oil Cooler 73 kg (38 lb) Engine Service Mass* 2 (Reerence) With Oil Cooler 76.5 kg (389 lb) * : Similar high quality ethylene glycol based non-silicate, non-amine, non-nitrite, and non-borate coolant with long-lie hybrid organic acid technology. (Coolant with hybrid organic acid technology consists o a combination o low phosphates and organic acids.) * 2 : The igure shown is the weight with the oil and coolant ully illed.

12 RX350 NEW FEATURES 3 " Valve Timing A Intake VVT-i Operation Range 37_ Exhaust VVT-i Operation Range TDC 3_ 4_ 39_ : Intake Valve Opening Angle : Exhaust Valve Opening Angle Intake Exhaust Open Close Open Close -3 to 37 BTDC 7 to 3 ABDC 60 to 25 BBDC 4 to 39 ATDC 7_ 60_ Intake VVT-i Operation Range 3_ 25_ Exhaust VVT-i Operation Range BDC 285EG03 " Perormance Curve A Output (kw) 220 Output (kw) Torque (N m) Torque (N m) Engine Speed (rpm) 0280EG09C Engine Speed (rpm) 0280EG0C Models or Europe and Australia Models or G.C.C. Countries

13 4 RX350 NEW FEATURES 2. Features o 2GR-FE Engine The 2GR-FE engine has achieved the ollowing perormance through the use o the items listed below. () High perormance and reliability (2) Low noise and vibration (3) Lightweight and compact design (4) Good serviceability (5) Clean emission and uel economy Item () (2) (3) (4) (5) A steel laminate type cylinder head gasket is used. A taper squish shape is used or combustion chamber. Engine Proper A cylinder block made o aluminum alloy is used. The skirt portion o each piston has a resin coating applied to reduce riction. An oil pan No. made o aluminum alloy is used. A Dual VVT-i (Variable Valve Timing-intelligent) system is used. Valve Mechanism Hydraulic lash adjusters are used. A timing chain and chain tensioner are used. Roller rocker arms are used. Lubrication System An oil ilter with a replaceable element is used. Cooling System The engine coolant is used the TOYOTA Genuine SLLC (Super Long Lie Coolant). A cable-less type throttle body is used. A intake air chamber made o plastic is used. Intake and Exhaust System A stainless steel exhaust maniold is used. An ultra thin-wall, high-cell density ceramic type TWC (Three-Way Catalytic converter) is used. A uel delivery pipe made o plastic is used. A compact 2-hole type injector is used. Fuel System A multi-layer plastic uel tank is used. Quick connectors are used to connect the uel hose with the uel pipe. The DIS (Direct Ignition System) makes ignition timing Ignition System adjustment unnecessary. Long-reach type iridium-tipped spark plugs are used. Charging System A segment conductor type alternator is used. An alternator pulley with a one way clutch is used. Starting System A PS (Planetary reduction-segment conductor motor) type starter is used. (Continued)

14 RX350 NEW FEATURES 5 Item () (2) (3) (4) (5) Engine Mount An active control engine mount is used. Serpentine Belt Drive System Engine Control System A serpentine belt drive system is used. MRE (Magnetic Resistance Element) type VVT sensors are used. The ETCS-i (Electronic Throttle Control System-intelligent) is used. An ACIS (Acoustic Control Induction System) is used. An air intake control system is used.