Air Conditioning And Heater Module Assembly Removal And Installation
|
|
|
- Dennis Dawson
- 5 years ago
- Views:
Transcription
1 Page 1 of Cadillac CTS : Heating, Ventilation, & Air Conditioning > Repair Instructions > Air Conditioning And Heater Module Assembly Removal And Installation Air Conditioning And Heater Module Assembly Removal And Installation AIR CONDITIONING AND HEATER MODULE ASSEMBLY REMOVAL AND INSTALLATION Tools Required J A (Image 1) Halogen Leak Detector J (Image 2) Hose Clamp Pliers J (Image 3) A/C Quick Joint Tool Removal Procedure 1. Recover the refrigerant. Refer to Refrigerant Recovery and Recharging. 2. Remove the battery. Refer to Battery Replacement (Refer To List 1) in Engine Electrical. 3. Drain the coolant. Refer to Cooling System Draining and Filling (Refer To List 2) in Engine Cooling. 4. Using thej (Image 2) disconnect the heater inlet hose (1).
2 Page 2 of Using the J (Image 2) disconnect the heater outlet hose (1). 6. Disconnect both A/C lines at the cowl. NOTE Important: The body of the tool should be parallel to the A/C line.
3 Page 3 of Using the J (Image 3) (1) insert the probe end into the two small openings of the plastic quick joint. 8. Remove both quick joint clamps. 9. Disconnect both A/C lines. 10. Remove the IP Carrier. Refer to Instrument Panel Carrier Replacement (Refer To List 3) in Instrument Panel, Gages, and Console.
4 Page 4 of Remove the air inlet assembly. 12. Disconnect the HVAC module electrical connector. 13. Disconnect the HVAC module drain tube (2) from the floor. 14. Press the tab and release the left rear duct from the HVAC module.
5 Page 5 of Disconnect the left rear heater duct from the HVAC module. 16. Press the tab and release the right rear duct from the HVAC module. 17. Disconnect the right rear heater ducts from the HVAC module.
6 Page 6 of Remove the lower left HVAC module mounting nut (1). 19. Remove the upper left HVAC module mounting nut (1). 20. Remove the HVAC module from the vehicle.
7 Page 7 of Remove the foam from the A/C lines. 22. Remove the foam from around the heater pipes. Installation Procedure 1. Install the thick foam packing (1) on the heater core pipes. 2. Install the thin foam packing (2) on the heater core pipes.
8 Page 8 of Install the thick foam packing (1) on the A/C lines. 4. Install the thin foam packing (2) on the A/C lines. 5. Install the HVAC module into the vehicle. NOTE Notice: Refer to Fastener Notice (Refer To List 4) in the Preface section. 6. Install the upper left HVAC module mounting nut (1). Tighten Tighten the nut to 9 N m (80 lb in).
9 Page 9 of Install the lower left HVAC module mounting nut (1). Tighten Tighten the nut to 9 N m (80 lb in). 8. Connect the rear heater ducts to the HVAC module. 9. Connect the drain tube to the bottom of the HVAC module.
10 2006 Cadillac CTS - Heating, Ventilation, & Air Conditioning > Repair Instructions >... Page 10 of Connect the drain tube (2) to the floor. 11. Connect the HVAC electrical connector. 12. Install the air inlet assembly. 13. Lubricate the O-rings of the A/C line with refrigerant oil before connecting the A/C lines. Refer to O-Ring Replacement. 14. Install the A/C line and A/C line quick connect line clamp (1) to the evaporator.
11 2006 Cadillac CTS - Heating, Ventilation, & Air Conditioning > Repair Instructions >... Page 11 of 16 NOTE Important: Press the A/C line quick connect line clamp together until you hear it engage. 15. Engage the clamp. 16. Install the A/C line and A/C line quick connect line clamp (1) to the evaporator.
12 2006 Cadillac CTS - Heating, Ventilation, & Air Conditioning > Repair Instructions >... Page 12 of 16 NOTE Important: Press the A/C line quick connect line clamp together until you hear it engage. 17. Engage the clamp. 18. Connect the heater inlet hose (1) using J (Image 2).
13 2006 Cadillac CTS - Heating, Ventilation, & Air Conditioning > Repair Instructions >... Page 13 of Connect the heater outlet hose (1) using J (Image 2). 20. Install the IP carrier. Refer to Instrument Panel Carrier Replacement (Refer To List 3) in Instrument Panel, Gages, and Console. 21. Install the battery. Refer to Battery Replacement (Refer To List 1) in Engine Electrical. 22. Fill the coolant. Refer to Cooling System Draining and Filling (Refer To List 2) in Engine Cooling. 23. Evacuate and recharge the AC system. Refer to Refrigerant Recovery and Recharging. 24. Leak test the fittings of the component using J A (Image 1). REFERED IMAGES LIST: REFER TO LIST:
14 2006 Cadillac CTS - Heating, Ventilation, & Air Conditioning > Repair Instructions >... Page 14 of 16 (Image 1) J A REFER TO LIST: (Image 2) J REFER TO LIST:
15 2006 Cadillac CTS - Heating, Ventilation, & Air Conditioning > Repair Instructions >... Page 15 of 16 (Image 3) J List 1 List 2 List 3 List 4 Engine / Engine Electrical / Repair Instructions / Battery Replacement (RHD) Engine / Engine Electrical / Repair Instructions / Battery Replacement (LHD) Engine / Engine Cooling / Repair Instructions / Cooling System Draining And Filling (LY7) Engine / Engine Cooling / Repair Instructions / Cooling System Draining And Filling (Ls6) Engine / Engine Cooling / Repair Instructions / Cooling System Draining And Filling (LP1, LY7 Static Fill) Engine / Engine Cooling / Repair Instructions / Cooling System Draining And Filling (LS2 Static Fill) Engine / Engine Cooling / Repair Instructions / Cooling System Draining And Filling (Ge 47716) Engine / Engine Cooling / Repair Instructions / Cooling System Draining And Filling (LA3, LY9) Body / Instrument Panel, Gages, And Console / Repair Instructions / Instrument Panel Carrier Replacement Body And Accessories / Instrument Panel, Gages, And Console / Repair Instructions / Instrument Panel Carrier Replacement Body And Accessories / Keyless Entry / Repair Instructions / Instrument Panel Carrier Replacement Preface / Cautions And Notices / Introduction / Fastener Notice
16 2006 Cadillac CTS - Heating, Ventilation, & Air Conditioning > Repair Instructions >... Page 16 of 16 Unsorted / Fastener Notice
HVAC HOUSING - REMOVAL AND INSTALLATION
2005 Jeep Truck Grand Cherokee 4WD V8-4.7L VIN N Vehicle > Heating and Air Conditioning > Housing Assembly HVAC > Service and Repair > Removal and Replacement HVAC HOUSING - REMOVAL AND INSTALLATION REMOVAL
Intake Manifold Replacement
Page 1 of 13 Your Current Vehicle: 2008 Cadillac STS Intake Manifold Replacement Intake Manifold Replacement Removal Procedure 1. Turn the ignition OFF. 2. Remove the fuel injector sight shield. Refer
2014 Buick Encore. Fig. 2: Replacing Measured Compressor Oil Courtesy of GENERAL MOTORS COMPANY
Fig. 2: Replacing Measured Compressor Oil Courtesy of GENERAL MOTORS COMPANY 2. Add back the same quantity of polyalkylene glycol (PAG) oil as drained from the removed air conditioning compressor. Refer
DIM Heating and Air Conditioning
2014 NATEF JOB TASKS COMPLETION REQUIREMENT: P1-95% P2-70% P3-25% Student Name: DETAILED COURSE CONTENT VI. HEATING, VENTILATION, & AIR CONDITIONING A. HVAC SYSTEMS -- The student will be able to: P1 P2
Program IV: ProStar TM. Performance A/C International. Series. Study Guide Performance A/C Program IV: International ProStar Series TMT
Performance A/C International A N AV I S TA R C O M PA N Y Program IV: ProStar TM Study Guide TMT-160701 Series Study Guide Performance A/C Program IV: International ProStar Series TMT-160701 2007 International
Page 1 of 7 2003 Chevrolet SILVERADO 1500 Submodel: Engine Type: V8 Liters: 5.3 Fuel Delivery: FI Fuel: GAS Instrument Panel Carrier Replacement Removal Procedure Warning! Refer to Battery Disconnect Caution
1 of 12 10/5/2015 8:11 AM
1 of 12 10/5/2015 8:11 AM REMOVAL 1. Perform the fuel pressure release procedure See: Fuel Pressure Release > Procedures > Fuel System Pressure Release Procedure. 2. Recover the refrigerant from the refrigerant
VENTILATION SYSTEM SECTION VTL CONTENTS VENTILATION, HEATER & AIR CONDITIONER VTL-1 PRECAUTION... 2 PREPARATION... 4 FUNCTION DIAGNOSIS...
VENTILATION, HEATER & AIR CONDITIONER SECTION VTL A VENTILATION SYSTEM B C D CONTENTS E PRECAUTION... 2 PRECAUTIONS... 2 Precaution for Supplemental Restraint System (SRS) "AIR BAG" and "SEAT BELT PRE-TEN-
1988 Chrysler LEBARON
1988 Chrysler LEBARON Submodel: Engine Type: L4 Liters: 2.5 Fuel Delivery: FI Fuel: GAS CAUTION When draining the coolant, keep in mind that cats and dogs are attracted by the ethylene glycol antifreeze,
BMW X-5 Evaporator Removal
BMW X-5 Evaporator Removal Intro: The following instructions will help you in replacing the Air Conditioning Evaporator in a BMW X-5. Following these instructions is at your own risk and the author assumes
1 of 8 12/12/2012 6:08 PM 1999 Chevrolet Express - 2WD Express, Savana VIN G Service Manual Engine Engine Mechanical - 6.5L Repair Instructions Engine Replacement Removal Procedure Tools Required J 36857
Volkswagen Golf > VW Rabbit GTI 2006-> (A5)
Volkswagen Golf 5 2004-> VW Rabbit GTI 2006-> (A5) A/C Refrigerant System General information Note: General A/C refrigerant system servicing procedures (e.g., component/system descriptions, extracting
2001 Lincoln LS Workshop Manual
Page 1 of 10 SECTION 303-01B: Engine 3.9L 2001 Lincoln LS Workshop Manual IN-VEHICLE REPAIR Procedure revision date: 05/16/2000 Intake Manifold Removal 1. Disconnect the battery ground cable. For additional
MANUAL CONTROL / SEMIAUTO TEMPERATURE CONTROL HEATING, VENTILATION AND AIR CONDITIONING SYSTEM
SECTION 7C MANUAL CONTROL / SEMIAUTO TEMPERATURE CONTROL HEATING, VENTILATION AND AIR CONDITIONING SYSTEM CAUTION: Disconnect the negative battery cable before removing or installing any electrical unit
2008 Saturn Aura V6-3.6L
1 of 14 7/17/2016 7:26 PM 2008 Saturn Aura V6-3.6L Vehicle» Engine, Cooling and Exhaust» Cooling System» Radiator» Service and Repair» Radiator Replacement Radiator Replacement (LY7 - Gas, 6 Cyl, 3.6L,
CHAPTER 21 ENVIRONMENT CONTROL. Section Title Page
CHAPTER 21 ENVIRONMENT CONTROL Section Title Page 21-00 Description........................................ 21.1 21-10 Ventilation........................................ 21.3 21-11 Nose Vent................................
Body Control Module Replacement
Page 1 of 9 2004 Pontiac Grand Prix Grand Prix (VIN W) Service Manual Body Lighting Systems Schematic and Routing Diagrams Body Control Module Replacement Removal Procedure Notice: Electrostatic discharge
Zoom and Print Options
Vehicle» Engine, Cooling and Exhaust» Engine» Service and Repair» Removal and Replacement» Engine Replacement Engine Replacement ^ Tools Required - J 38185 Hose Clamp Pliers Removal Procedure 1. Remove
HVAC Compressor Clutch Does Not Engage
Page 1 of 6 2004 Pontiac GTO GTO (VIN V) Service Manual HVAC HVAC Systems - Manual Diagnostic Information and Procedures Document ID: 1378425 HVAC Compressor Clutch Does Not Engage Test Description The
REMOVAL AND INSTALLATION
501-12-1 Instrument Panel and Console 501-12-1 REMOVAL AND INSTALLATION Instrument Panel Removal CAUTION: Electronic modules are sensitive to static electrical charges. If exposed to these charges, damage
11. Installation Instruction
11. Installation Instruction 11.1 Select The Best Location If an awning is built over the unit to prevent direct sunlight or rain, be careful that heat radiation from the condenser is not obstructed. There
HEATER, AIR CONDITIONER AND VENTILATION
55-1 HEATER, AIR CONDITIONER AND VENTILATION CONTENTS HEATER AND MANUAL AIR CONDITIONER...................... 3 GENERAL............................... 3 Outline of Change......................... 3 SERVICE
PERFECT FIT IN-DASH HEAT/ COOL/ DEFROST FORD FAIRLANE & CROWN VICTORIA
PERFECT FIT IN-DASH HEAT/ COOL/ DEFROST 1955-56 FORD FAIRLANE & CROWN VICTORIA CONTROL & OPERATING INSTRUCTIONS The controls on your new Perfect Fit system, offer complete comfort capabilities in virtually
TSI : Crankcase Oil Separator Housing Replacement. Study Guide TMT Course Code: 8443
TSI 13-12-04: Crankcase Oil Separator Housing Replacement Study Guide TMT121379 Course Code: 8443 1 TSI-13-12-04: Crankcase Oil Separator Housing Replacement Study Guide 2013 Navistar, Inc. 2701 Navistar
1. Disconnect the battery. This is important! This will prevent air bag deployment.
PARTS PACKING LIST Evaporator assembly Drain tube Plastic air plug Hardware package 11040 3601 W. Clarendon Phoenix, Arizona 85019 (602) 233-0090 800-648-4475 www.ackits.com 2003-4 Jeep Wrangler EVAPORATOR
Clutch, Pressure Plate, And Pilot Bearing Replacement
Page 1 of 6 2008 Chevrolet Aveo : Transmissions > Clutch > Repair Instructions > Clutch, Pressure Plate, And Pilot Bearing Replacement Clutch, Pressure Plate, And Pilot Bearing Replacement CLUTCH, PRESSURE
Intake Manifold Replacement
Page 1 of 14 2004 Chevrolet TrailBlazer - 4WD Bravada, Envoy, Rainier, TrailBlazer (VIN S/T) Service Manual Engine Engine Mechanical - 4.8L, 5.3L, and 6.0L Repair Instructions - On Vehicle Document ID:
AIR CONDITIONER SECTION AC CONTENTS AUTO
AIR CONDITIONER SECTION AC CONTENTS AUTO PRECAUTIONS AND PREPARATION SRS Airbag Pretensioner Seatbelt... 4 A/C Refrigerant HFC134a Handling... 4 Compressor Oil... 4 Tube Connection... 4 O-Ring Part Number...
EXTERNAL CONTROL VALVE (ECV) EQUIPPED VARIABLE A/C COMPRESSOR DIAGNOSIS PROCEDURE
Technical Service Bulletin GROUP DATE HVAC JUNE, 2017 NUMBER MODEL(S) 17-HA-002 Multiple Models EXTERNAL CONTROL VALVE (ECV) EQUIPPED VARIABLE A/C COMPRESSOR DIAGNOSIS PROCEDURE This bulletin supersedes
2013 Kia Optima L4-2.0L Turbo
1 of 13 5/29/2016 11:34 AM 2013 Kia Optima L4-2.0L Turbo Vehicle» Engine, Cooling and Exhaust» Engine» Service and Repair» Removal and Replacement Removal CAUTION: Use fender covers to avoid damaging painted
Condensation monitor
QXA2101 QXA2100 Condensation monitor QXA2100 QXA2101 Monitor to prevent damage caused by condensation on chilled ceilings and HVAC plants with AC/DC 24 V power. Can also be used with extension module AQX2000
Jeep Wrangler TJ 4.0 LITER Installation instructions
www.jeepair.com 2002-2004 Jeep Wrangler TJ 4.0 LITER Installation instructions Kit Information These directions are for 2002-2006 model Jeep Wranglers. After 1994 every vehicle was designed for R134a refrigerant.
2. Remove the intake manifold cover. Refer to Intake Manifold Cover Replacement.
VALVE COVER GASKET Valve Rocker Arm Cover Replacement - Left Side Removal Procedure 1. Partially drain the cooling system. Refer to Cooling System Draining and Filling (LZE, LZ4, LZG, 9C1, 9C3, GE47716
CO01 Radiator Assembly
Uniform Procedures For Collision Repair CO01 Radiator Assembly 1. Description This procedure describes methods for the removal and installation of a radiator assembly. Inspection and evaluation requirements
TITAN AND ARMADA DRIVER SIDE AIR MIX DOOR MOTOR REPLACEMENT
Classification: Reference: Date: HA11-004 NTB11-048 May 5, 2011 2004 2011 TITAN AND ARMADA DRIVER SIDE AIR MIX DOOR MOTOR REPLACEMENT APPLIED VEHICLE: 2004 2011 Titan (A60) 2004 2011 Armada (TA60) IF YOU
2000 Chevrolet Blazer
HEATER CORE Removal Procedure 1. Remove the heater/vent module. Refer to HEATER/VENT MODULE. 2. Remove the heater core access cover screws. Fig. 14: Identifying Heater Core Access Cover & Screws 3. Remove
Brake Pressure Modulator Valve Assembly Replacement (LHD)
Page 1 of 6 2007 Chevrolet Lumina VE Document ID: 1974792 Brake Pressure Modulator Valve Assembly Replacement (LHD) Removal Procedure Caution: Refer to Brake Fluid Caution in the Preface section. Caution:
2014 Dodge Challenger R/T. The water pump (1) is mounted directly to the timing chain cover and is equipped with a non serviceable integral pulley.
Fig. 73: Water Pump A centrifugal water pump (2) circulates coolant through the water jackets, passages, intake manifold, radiator core, cooling system hoses and heater core. The pump is driven from the
2003 Explorer Sport/Sport-Trac Workshop Manual. 7. Disconnect the vacuum harness connector. Remove the nut.
7. Disconnect the vacuum harness connector. Remove the nut. 8. Remove two nuts, one bolt, and the A/C evaporator housing (19850). Remove the nut located at the bottom of the A/C evaporator housing first.
Remove Air Cleaner Cover and. Filter
Remove Air Cleaner Cover and Inspect paper filter for tears Foam pre-cleaner is washable if equipped Replace if necessary Filter Remove Trim Panel Pull throttle lever knob off Remove 3, 8mm screws Remove
HEATING & AIR CONDITIONING
VA HEATING & AIR CONDITIONING 24-1 HEATING & AIR CONDITIONING TABLE OF CONTENTS page HEATING & AIR CONDITIONING DESCRIPTION...1 OPERATION...2 DIAGNOSIS AND TESTING A/C PERFORMANCE...3 HEATER PERFORMANCE
Warning Do not attempt to install A/C units unless you are experienced with servicing A/C systems!
TOOLS REQUIRED: INSTALLATION INSTRUCTIONS PT-A-406 Rear HVAC System for 2014-2018 RAM PROMASTER without OEM rear AC/Heat Prep Package Fittings ***This system can also be used for a Promaster van with the
FACTORY AIR CONVERSION HEAT/ COOL/ DEFROST CHEVROLET CHEVELLE
specializing in AIR CONDITIONING, PARTS AND SYSTEMS for your classic vehicle FACTORY AIR CONVERSION HEAT/ COOL/ DEFROST 1970-72 CHEVROLET CHEVELLE CONTROL & OPERATING INSTRUCTIONS The controls on your
2002 Chevrolet Blazer
The blower motor will operate in any switch position, as long as the ignition switch is in the RUN position and the mode switch is in any position other than OFF. When the ignition switch is on, power
Power Steering Pump. GM Century/Lumina/Grand Prix/Intrigue REMOVAL & INSTALLATION BLEEDING
1 of 9 GM Century/Lumina/Grand Prix/Intrigue 1997-2000 Power Steering Pump REMOVAL & INSTALLATION BLEEDING When servicing the power steering pump, inspect the power steering fluid. Look for foaming, milky
2005 Chevrolet Equinox LS ENGINE Engine Cooling - Equinox
2005 ENGINE Engine Cooling - Equinox SPECIFICATIONS FASTENER TIGHTENING SPECIFICATIONS Fastener Tightening Specifications Specification Application Metric English Coolant Heater 50 N.m 37 lb ft Heater
PERFECT FIT SERIES IN-DASH HEAT/ COOL/ DEFROST 1969 CHEVROLET CAMARO/ FIREBIRD NOTE: INSTRUCTIONS DEPICT CAMARO
specializing in AIR CONDITIONING, PARTS AND SYSTEMS for your classic vehicle PERFECT FIT SERIES IN-DASH HEAT/ COOL/ DEFROST 1969 CHEVROLET CAMARO/ FIREBIRD NOTE: INSTRUCTIONS DEPICT CAMARO CONTROL & OPERATING
Rzr Heater System Part #
Rzr Heater System Part # 2878135 NOTE: This heater unit installs below the center of the dash. If you have a radio mount kit (Polaris Part # 2876897) you may need to cut the top front corner off the mount
NCF fans 50 Hz. Protection class IP 55
The Nederman NCF Fans have direct drive motors which means a safe and cost effective operation. Installing an energy efficient NCF fan with our other Nederman products saves time and reduces energy costs.
2015 F-250, 350, 450, 550 Super Duty DESCRIPTION AND OPERATION Procedure revision date: 04/28/2016. Climate Control System
Page 1 of 9 412-00 Climate Control System General Information and Diagnostics Climate Control System 2015 F-250, 350, 450, 550 Super Duty DESCRIPTION AND OPERATION Procedure revision date: 04/28/2016 WARNING:
Refrigerant Oil Calculation during Compressor Replacement
Refrigerant Oil Calculation during Compressor Replacement Study Guide TMT: 100820 Dealer Education 2008 Navistar, Inc. 4201 Winfield Road, Warrenville, IL 60555. All rights reserved. No part of this publication
Volkswagen > Golf, Jetta, GTI, Cabrio > Heating Air Conditioning 87 - A/C controls and mechanical components, servicing
x-ebahn:///c:/program%20files/ebahn/data/vw-a-a3-h28ebn/vw/a/a3/repair%20ma Page 1 of 13 Volkswagen > Golf, Jetta, GTI, Cabrio > 1993-2002 Heating Air Conditioning 87 - A/C controls and mechanical components,
Mustang/Capri Fox Body 5.0 Engine Compartment Upgrade Kit - Standard (22-132)
Classic Auto Air Mfg. 4901A W. Rio Vista Ave, Tampa, FL 33634 Toll free - 866-352-4678 9:30am 6pm M-F EST ClassicAutoAir.Com Mustang/Capri Fox Body 5.0 Engine Compartment Upgrade Kit - Standard (22-132)
SERVICE & OWNER S MANUAL
1 of 10 SERVICE & OWNER S MANUAL Product Specifications 25 x 36 x 7 Weight: 47 lbs. Air Flow: 260 CFM Air Conditioner p/n: 1ACUNIT-G1 Fits with Curtis Roof Kit: Contact Curtis for Details. Fits with Curtis
Water Pump Replacement L61
2002 Saturn VUE - AWD Water Pump Replacement L61 Tools Required J 43651 Water Pump Holding Tool Removal Procedure 1. Drain the coolant. Refer to Draining and Filling Cooling System. 2. Remove the thermostat
Drained coolant must be stored in a clean container for disposal or reuse.
Cooling System, Draining and Filling Special tools, testers and auxiliary items required Adapter (V.A.G 1274/8) Adapter V.A.G 1274 tester (V.A.G 1274/10) Hose clamp pliers (V.A.G 1921) Cooling system charge
Z1 Motorsports 300zx 2.5 Upgraded piping & BA SMIC Install Guide
Z1 Motorsports 300zx 2.5 Upgraded piping & BA SMIC Install Guide Congratulations on your new upgraded piping and intercooler kit, this kit has proven to provide the lowest intake air temps to date on our
Intake Manifold Replacement
ALLDATA Online - 2001 Cadillac DeVille V8-4.6L VIN 9 - Intake Manifold Replacement Page 1 of 15 Home Account Contact ALLDATA Log Out Help DAN GRIMWOOD DAN GRIMWOOD00002 Select Vehicle New TSBs Technician's
Technical Service Bulletin
INTRODUCTION: Technical Service Bulletin March 3, 2009 Title: DECREASED AIR VOLUME FROM HVAC VENTS Models: 07-09 Tacoma Some customers may experience decreased air volume from the HVAC vents when the temperature
IN-VEHICLE SERVICING > VALVE COVER - RH
Page 1 of 20 Service Manual: ENGINE - 5.4L (3V)- F-150 & MARK LT IN-VEHICLE SERVICING > VALVE COVER - RH 2008 Ford Pickup 5.4L Eng F150 Material Item Specification Motorcraft Metal Surface Prep ZC-31 PAG
9.1 Assembled Planetary Gearbox
SEC. 9 GEARBOX 9.1 Assembled Planetary Gearbox SEC. 9 GEARBOX Page 1 9.1 Assembley Gearbox Drawing 9.1.1. Drawing #11236 - Gearbox, Planetary SEC. 9 GEARBOX Page 2 9.2. Assembly Lower Output Shaft and
Oil Pan Replacement Buick Regal
2000 Buick Regal Oil Pan Replacement Removal Procedure Tools Required J 28467-90A Engine Support Adapters J 28467-B Universal Engine Support Fixture J 36462-A Engine Support Adapter Leg Set 1. Disconnect
A/C - Retrofitting R-12 to R-134a File In Section: 1 - HVAC
1984 Cadillac Full Size Cad RWD V8-252 4.1L Page 1 Technical Service Bulletin # 431207E Date: 970101 A/C - Retrofitting R-12 to R-134a File In Section: 1 - HVAC Bulletin No.: 43-12-07E Date: January, 1997
Turbocharger system. Note: Observe rules of cleanliness Page Charge air pressure control connection diagram Page 21-2.
Page 1 of 50 21-1 Turbocharger system Note: Observe rules of cleanliness Page 21-22. Charge air pressure control connection diagram Page 21-2. All hose connections are secured with hose clamps: parts catalog.
A/C-HEATER SYSTEM - AUTOMATIC
A/C-HEATER SYSTEM - AUTOMATIC 1988 Toyota Celica 1988 Automatic A/C-Heater Systems Celica * PLEASE READ THIS FIRST * CAUTION: When discharging air conditioning system, use only approved refrigerant recovery/recycling
Draining and Filling Cooling System
1998 Chevrolet/Geo Cavalier Draining and Filling Cooling System Glycol Usage Before you drain and refill the cooling system, inspect the system. Perform any service needed to ensure that the system is
Boss/Coyote 5.0 Compressor without Power Steering Serpentine Drive System
an ISO 900:205 Registered Company Boss/Coyote 5.0 Compressor without Power Steering Serpentine Drive System 74007 8865 Goll St. San Antonio, TX 78266 Phone: 800-862-6658 Sales: sales@vintageair.com Tech
Draining and Filling Cooling System
1996 Chevrolet/Geo Monte Carlo Draining and Filling Cooling System Correct Fill Ratios 1. Ethylene glycol/water fill ratios have been established to ensure a minimum of 50 percent ethylene glycol in the
SOUL GDI REPAIR AND MAINTENANCE
SOUL 2013-1.6 GDI REPAIR AND MAINTENANCE (First Numbers are page number within section - Numbers in parenthesis are overall document page) GENERAL INFORMATION (23 PAGES) 01-07 (01-07): Identification Number
ERV ENERGY RECOVERY VENTILATOR 60 HZ. Indoor / Outdoor 500 to 10,000 cfm Capacity ERV I - D - D - P - 1 MODEL NUMBER IDENTIFICATION
P R O D U C T S P E C I F I C AT I O N S I N D O O R A I R Q U A L I T Y ERV ENERGY RECOVERY VENTILATOR 60 HZ Bulletin No. 20245 March 200 Supersedes April 2009 Indoor / Outdoor 500 to 0,000 cfm Capacity
This information covers the proper service procedures for the replacement of the radiator on a chassis with the Volvo D16F engine.
Volvo Trucks North America Greensboro, NC USA This Service Bulletin replaces SB 260-32, Cooling System Service, dated (1.2007), publication no. PV776-20177193. Radiator, Replacement DService Bulletin Trucks
1. SPECIFICATIONS 01-2
01-2 1. SPECIFICATIONS Description Specification Heater Core size (mm²) 200 x 165.5 x 25 Capacity (kcal/h) 4,700 Evaporator Core size (mm²) 254.8 x 196.7 x 60 Capacity (kcal/h) 4,700 Blower Supplied power
PERFECT FIT SERIES IN-DASH HEAT/ COOL/ DEFROST MUSTANG
specializing in AIR CONDITIONING, PARTS AND SYSTEMS for your classic vehicle PERFECT FIT SERIES IN-DASH HEAT/ COOL/ DEFROST 1969-70 MUSTANG CONTROL & OPERATING INSTRUCTIONS The controls on your new Perfect
Water Pump Replacement (L4)
2011 Chevrolet Equinox Equinox, Terrain VIN L Service Manual Water Pump Replacement (L4) Special Tools EN-43651 Water Pump Holding Tool For equivalent regional tools, refer to Special Tools. Removal Procedure
INSTALLATION INSTRUCTIONS FOR COZY CAB A-1 AIR CONDITIONING KIT
INSTALLATION INSTRUCTIONS FOR COZY CAB A-1 AIR CONDITIONING KIT 05-11 INSTALLATION INSTRUCTIONS A-12235 Air Conditioner Kit Cab set up instructions; This air conditioning kit is designed to be used with
Jeep Wrangler TJ 4.0 LITER Installation instructions
www.jeepair.com 2000-2001 Jeep Wrangler TJ 4.0 LITER Installation instructions Important information about your system, and warranty DO NOT ADD ANY OIL TO ANY PART OF THE SYSTEM. DO NOT USE THE SIGHT GLASS
Electronic Refrigerator Diagnostics
Electronic Refrigerator Diagnostics IMPORTANT SAFETY NOTICE The information in this presentation is intended for use by individuals possessing adequate backgrounds of electrical, electronic, & mechanical
1964 Chevrolet Impala Condenser Kit with Drier (021063)
an ISO 900:2008 Registered Company 964 Chevrolet Impala Condenser Kit with Drier (02063) 8865 Goll St. San Antonio, TX 78266 Phone: 20-654-77 Fax: 20-654-33 www.vintageair.com 9036 REV B 03/0/6, PG OF
Engine Removal and Installation
Page 1 of 5 Home Account Contact ALLDATA Log Out Help TINO TORRES Select Vehicle New TSBs Technician's Reference Component Search: OK 2005 Chrysler Sebring Sedan V6-2.7L VIN R Conversion Calculator Vehicle
RADIATOR CLEANING OF RADIATOR
CO20 COOLING SYSTEM RADIATOR CLEANING OF RADIATOR Using water or a steam cleaner, remove any mud and dirt from the radiator core. CAUTION: If using a high pressure type cleaner, be careful not to deform
Weistec True Downpipes
Weistec True Downpipes Installation Guide, W212, W218, AWD 2014+ E63 2014+ CLS63 WARNING! IF YOU ARE NOT EXPERIENCED IN THE AREA OF AUTOMOTIVE MECHANICS, WE STRONGLY URGE THAT YOU REFER THIS INSTALLATION
ARTICLE BEGINNING * PLEASE READ THIS FIRST * DESCRIPTION OPERATION ATC COMPUTER BLEND-AIR DOOR ACTUATOR CONTROL PANEL
A/C-HEATER SYSTEM - AUTOMATIC Article Text 1989 Chrysler LeBaron Sedan For m m m m m Copyright 1998 Mitchell Repair Information Company, LLC Thursday, July 03, 2003 10:15AM ARTICLE BEGINNING 1989 AUTOMATIC
& 76 CHEVROLET NOVA HEATER ONLY
specializing in AIR CONDITIONING, PARTS AND SYSTEMS for your classic hi l PERFECT FIT IN-DASH HEAT/ COOL/ DEFROST 1969-74 & 76 CHEVROLET NOVA HEATER ONLY CONTROL & OPERATING INSTRUCTIONS The controls on
CHAPTER 12 SERVICING. Section Title Page
CHAPTER 12 SERVICING Section Title Page 12-10 Main Rotor Gearbox.................................. 12.1 12-11 Servicing................................. 12.1 12-12 Filter Replacement...........................
OVERVIEW: This bulletin involves correcting a sealant void between the cowl plenum lower panel and dash crossmember.
NUMBER: 23-029-15 GROUP: Body DATE: July 21, 2015 This bulletin is supplied as technical information only and is not an authorization for repair. No part of this publication may be reproduced, stored in
1 AIR HANDLING UNIT TYPE AIR ACCESS 75
SUPPLY 1 AIR HANDLING UNIT TYPE AIR ACCESS 75 Location : EXTERNAL Position : SIDE BY SIDE SLIDING PANELS for COMPLETE ACCESSIBILITY MULTI SERVICE BULKHEAD for HYDRAULIC AND ELECTRICAL CONNECTIONS Self-supporting
COMPONENTS ILLUSTRATION
COMPONENTS ILLUSTRATION ILLUSTRATION ILLUSTRATION REMOVAL 1. REMOVE WINDSHIELD WIPER MOTOR AND LINK ASSEMBLY (a) Remove the windshield wiper motor and link assembly. 2. REMOVE COWL BODY MOUNTING REINFORCEMENT
Front Bumper Fascia Replacement
Page 1 of 10 2008 Pontiac G8 G8 Service Manual Body Repair Bumpers and Fascias Repair Instructions Document ID: 2044380 Front Bumper Fascia Replacement Removal Procedure Caution: Refer to Safety Glasses
Cooling system components, removing and installing
Page 1 of 40 19-1 Cooling system components, removing and installing WARNING! The cooling system is pressurized when the engine is warm. When opening the expansion tank, wear gloves and other appropriate
2002 Jeep Grand Cherokee Laredo
Removal WARNING: DO NOT REMOVE THE CYLINDER BLOCK DRAIN PLUGS OR LOOSEN THE RADIATOR DRAINCOCK WITH THE SYSTEM HOT AND UNDER PRESSURE. SERIOUS BURNS FROM COOLANT CAN OCCUR. REFER TO COOLING SYSTEM DRAINING.
IAG Street Series Air / Oil Separator (AOS) For 2017 WRX
P IAG Street Series Air / Oil Separator (AOS) For 2017 WRX Part# IAG-ENG-7152 Tools Required: Ratchet, torque wrench, extensions, needle nose pliers, hose cutter, snips/scissors, flathead screwdriver,
Automotive Air Conditioning Manifold Gauge Sets
Automotive Air Conditioning Manifold Gauge Sets 1 Caution: These instructions are not for use with Hybrid Vehicles. For instructions for servicing Hybrid Vehicles use Hybrid Vehicle manufacturer s service
MIXING DIFFERENT APPROVED BRANDS OF TYPE II IS AUTHORIZED. REFER TO THE GENERAL ELECTRIC SERVICE MANUAL BEFORE MIXING OIL BRANDS.
OIL SYSTEM REPLENISHING 1. General Refer to Figure 1. Each engine is equipped with an oil tank. The filler cap is accessible through the upper core cowl 412 AT on left engine or 422 AT on right engine
TSB #: 53 Date: 2/11/2011 HOLDEN (DELPHI) VARIABLE STROKE COMPRESSOR DIAGNOSIS STEP ACTION RESULT YES NO
HOLDEN (DELPHI) VARIABLE STROKE COMPRESSOR DIAGSIS TSB #: 53 Date: 2/11/2011 Initial Once Read: Even though the Holden variable stroke compressor manufactured by Delphi has been in the Australian market
Chevrolet Truck Install Instructions. This kit is designed for the Chevrolet or GMC trucks without factory air conditioning.
1967-1972 Chevrolet Truck Install Instructions This kit is designed for the 1967-1972 Chevrolet or GMC trucks without factory air conditioning. Glove box Heater box Heater box firewall cover Controls and
Jeep Wrangler 4.0 Liter TJ Jeep Wrangler 2.5 Liter TJ Installation instructions
TM www.jeepair.com 1999 Jeep Wrangler 4.0 Liter TJ 1999-2001 Jeep Wrangler 2.5 Liter TJ Installation instructions Kit Information After 1994 every vehicle was designed for R134a refrigerant. The Jeep kit
RetroAir JAGUAR XKE S1-3.8 LHD FULL KIT CONTENTS:
RetroAir JAGUAR XKE S1-3.8 LHD FULL KIT 2-12-2011 CONTENTS: 1- Custom Design Evaporator Case &Core Assembly 1- Universal Bracket (installed) Evaporator Pak includes: 2-Custom Brackets; 2-1-¼ Grommets;
2005 Ford Pickup F250 Super Duty. SPECIAL TOOLS Release Tool, Injector Connector
FUEL INJECTORS SPECIAL TOOLS Release Tool, Injector Connector 303-1115 MATERIAL Item Specification SAE 15W-40 Super Duty Motor Oil XO-15W40-QSD or equivalent WSS-M2C171-D Metal Brake Parts Cleaner PM-4
SBH / SBV Sales Guide BLOWER-COILS HORIZONTAL AND VERTICAL
SO TOUGH, WE GUARANTEE IT. SBH / SBV Sales Guide BLOWER-COILS HORIZONTAL AND VERTICAL SBH SBV www.superiorrex.com SO TOUGH, WE GUARANTEE IT! www.superiorrex.com SBH / SBV Series: CONSTRUCTION FEATURES
2001 Dodge Caravan Sport MANUAL A/C-HEATER SYSTEMS Caravan, Town & Country, & Voyager
SPECIFICATIONS NOTE: Information for Caravan includes the Grand Caravan. SPECIFICATIONS Application Specification Compressor Type Nippondenso 10S20H Compressor Belt Tension (1) System Oil Capacity (2)