INSTALLATION INSTRUCTIONS

Size: px

Start display at page:

Download "INSTALLATION INSTRUCTIONS"

Simon McBride
5 years ago
Views:

1 INSTALLATION INSTRUCTIONS Accessory Application Publications No. All CIVIC AM/FM CD TUNER 2 and 4 DOOR (DX) Issue Date SEP 2005 PARTS LIST Pocket Attachment Kit P/N 08B60-SCV-100 AM/FM CD Tuner P/N 08A02-4E1-100 AM/FM CD tuner Pocket 2 Self-tapping screws, 4 x 12 mm Owner s Manual Antenna Sub Harness Kit P/N 08B01-SNA-100 Antenna sub harness 2 Wire ties Cushion tape 4 Washer-screws, 5 x 8 mm TOOLS REQUIRED Phillips screwdriver Flat-tip screwdriver 10 mm combination wrench Shop towel Scissors INSTALLATION Customer Information: The information in this installation instruction is intended for use only by skilled technicians who have the proper tools, equipment, and training to correctly and safely add equipment to your vehicle. These procedures should not be attempted by do-it-yourselfers. 1. Disconnect the negative cable from the battery American Honda Motor Co., Inc - All Rights Reserved. AII (0509) 08B01-SNA of 6

2 2. Remove the driver s dashboard lower cover (eight clips). 4. Lower the steering wheel lever and pull the steering toward you. COMBINATION SWITCH SHOP TOWEL SHIFT LEVER STEERING WHEEL DRIVER S DASHBOARD LOWER COVER CLIPS (8) T SHOP TOWEL 3. Remove the inside cover from the front console pocket (two tabs). TILT LEVER FRONT CONSOLE 5. To protect the dashboard area, place a shop towel over the steering wheel and shift lever H TABS (2) INSIDE COVER T 2 of 6 AII (0509) 2005 American Honda Motor Co., Inc - All Rights Reserved.

3 6. Remove the instrument panel with the center panel (one screw, two bolts, nineteen retaining clips and unplug the vehicle connectors). 8. Remove the audio cover from the center panel. AUDIO COVER CLIPS (19) INSTRUMENT PANEL H SCREW BOLT 7. Remove the center panel from the instrument panel by releasing the four clips H 9. Remove the three screws and remove the air duct from the center panel. 10. Loosen the four bolts on the right and left audio brackets. SCREW (3) INSTRUMENT PANEL AIR DUCT BOLT (Loosen.) CLIPS (4) H H 2005 American Honda Motor Co., Inc - All Rights Reserved. AII (0509) 3 of 6

4 Installing the Pocket 11. Using scissors, cut the cushion tape in half. 14. Unlock the terminal lock on the vehicle 20-pin connector. TERMINAL LOCK (Be careful not to break the terminal lock) APPROPRIATE SLOT CUSHION TAPE (Cut in half.) <Harness Side Viewed > SUB HARNESS TERMINAL (YELLOW/GREEN) (Bend up the tab.) H 12 Plug the antenna connector into the vehicle connector, then wrap the piece of cushion tape around the antenna connectors. 13. Secure the antenna sub harness to the vehicle harness on the steering hanger beam with a wire tie. S 20-PIN H ABOUT 30 mm 15. Carefully push the wire terminal (yellow/green) of the antenna sub harness into the appropriate slot of the vehicle 20-pin connector. Reattach the terminal lock. HARNESS WIRE TIE WIRE TERMINAL (YELLOW/ GREEN) JACK STEERING HANGER BEAM H 4 of 6 AII (0509) 2005 American Honda Motor Co., Inc - All Rights Reserved.

5 When you install the IN DASH/CASSETTE/ MULTI MEDIA player, go to Installing the Player in the installation instructions 08B06-SNA Position the pocket into the center panel and install the two 4 x 12 mm self-tapping screws. 20. Plug the vehicle 20-pin connector and antenna jack into the rear of the AM/FM CD tuner. AM/FM CD TUNER JACK 20-PIN H SELF-TAPPING SCREWS (2) Use the upper hole. 21. Connect the vehicle connectors to the center panel, and reinstall the center panel. (4) Insert the tab from the pocket in these holes H 17. Fasten the two bolts on the left audio bracket you loosened in step Position the AM/FM CD tuner on the pocket and install the four 5 x 8 mm washer bolts. AM/FM CD TUNER BOLT (Reused) H WASHER BOLTS (4) H 19. Fasten the two bolts on the right audio bracket you loosened in step 10, and reinstall the air duct American Honda Motor Co., Inc - All Rights Reserved. AII (0509) 5 of 6

6 22. Check that all wire harnesses are routed properly and all connectors are plugged in. 23. Reconnect the negative cable to the battery. 24. Reset the clock. 25. Check the operation of the AM/FM CD tuner as described in the Owner s Manual supplied. 26. Reinstall all removed parts. 27. Put the AM/FM CD tuner Owner s Manual in the glove box for your customer. 28. Do the ECU idle learn procedure: Make sure all electrical items are turned off. Start the engine. Hold the engine speed at 3,000 rpm with no load (in Park or neutral) until the radiator fan comes on. Let the engine idle for about 5 minutes with the throttle fully closed and with all electrical items off. NOTE: If the radiator fan comes on during this step, the time when it is operating must not be included in the 5 minutes. NOTE: When the battery is disconnected, the driver s window AUTO function is disabled. Start the engine. Push down on the driver s window switch until the window is fully open. Pull up on the driver s window switch to close the window completely, then hold the switch for 2 seconds or more. Lower and raise the driver s window to check operation of the driver s window AUTO function. 6 of 6 AII (0509) 2005 American Honda Motor Co., Inc - All Rights Reserved.

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS Accessory Application Publications No. IN DASH/CASSETTE/ MULTI MEDIA ATTACHMENT KIT 2007 CIVIC 2- and 4-DOOR (DX) AII 33543 Issue Date AUG 2006 NOTE: The vehicle must be equipped