FULL AUTOMATIC TEMPERATURE CONTROL HEATING, VENTILATION AND AIR CONDITIONING SYSTEM

Size: px
Start display at page:

Download "FULL AUTOMATIC TEMPERATURE CONTROL HEATING, VENTILATION AND AIR CONDITIONING SYSTEM"

Transcription

1 SECTION 7D FULL AUTOMATIC TEMPERATURE CONTROL HEATING, VENTILATION AND AIR CONDITIONING SYSTEM FATC (Full Automatic Temperature Control) is full automatic heater and airconditioning system that detects incar temperature, ambient temperature, sun load and coolant temperature and controls airconditioner system blowing capacity, outlet temperature and intaking/outlet mode to maintain interior comfort. TABLE OF CONTENTS Specifications... 7D-2 Refrigerant... 7D-2 Evaporator Unit... 7D-2 Blower Unit... 7D-2 Compressor... 7D-2 Condenser... 7D-2 Receiver Drier... 7D-2 Pressure Switch... 7D-3 Air Filter... 7D-3 Heater Unit... 7D-3 Service Specifications... 7D-4 Fastener Tightening Specifications... 7D-4 Schematic and Routing Diagrams... 7D-5 Circuit Diagram... 7D-5 FATC Block Diagram... 7D-6 Component Locator... 7D-7 Ventilation System... 7D-7 Function Description... 7D-8 Diagnosis... 7D-9 Diagnosis Test... 7D-9 Maintenance and Repair... 7D-13 FATC Control Panel... 7D-13 Air Filter... 7D-16 Troubleshooting... 7D-17

2 7D-2 FATC-HAVC SPECIFICATIONS REFRIGERANT Capacity Type Description g R134a EVAPORATOR UNIT Core Size (LxWxT) Core Type Expansion Valve Type Thermostat Resister Type Cooling Capacity Description x x 92.0 Aluminum plate Angle ON:4.5 ± 0.6 C, OFF:1.5 ± 0.6 C Aluminum plate 4,300 Kcal/h (AT 420 CMH) BLOWER UNIT Motor Type Motor Size Description Magnetic φ 70 x 145 COMPRESSOR Model Type Displacement (cc/rev.) PCD (Pulley Center Diameter) Oil Magnetic clutch output Description FK-II (DKV 14C) Vane rotary type (cc/rev) φ 143 ZXL 200 PG (PAG Oil) 45 W CONDENSER Size (WxHxT) Capacity Type Description 650 x x ,000 Kcal/h Parallel Flow RECEIVER DRIER Material Capacity Desiccant Description Aluminum 250 cc XH-9 (35 g)

3 FATC-HAVC 7D-3 Type High (OFF) Low (ON) Replacement PRESSURE SWITCH AIR FILTER HEATER UNIT Description Direct OFF : 32 ± 2 Kgf/cm 2, DIFF : 6 ± 2 Kgf/cm 2 OFF : 2.0 ± 0.2 Kgf/cm 2, ON : 2.1 ± 0.2 Kgf/cm 2 Description Every 12,000 km (replace earlier if air pollution is heavy) Heater Core Type Heating Capacity Heater Core Size (L x W x T) Description 2-ROW 4,600 Kcal/h (AT 300 CMH) x x 52

4 7D-4 FATC-HAVC Incar Sensor Ambient Sensor Coolant Temperature Sensor SERVICE SPECIFICATIONS Input Section Resistance (25 C) Voltage Rating Current Rating Resistance (25 C) Voltage Rating Current Rating Resistance (25 C) Voltage Rating Current Rating Evaporator Unit Description kω ± 0.07 kω 5 V 3 ma 1.0 kω ± 0.03 kω 5 V 3 ma 0.55 kω ± 0.02 kω 5 V 3 ma Intake Actuator Mode Actuator Mix Actuator Power TR Blower Motor Power Consumption Description Current Rating (at 12 V) 70 ± 30 ma LOCK Current Less than 500 ma Current Rating (at 12 V) 100 ± 40 ma LOCK Current Less than 500 ma Current Rating (at 12 V) 100 ± 40 ma LOCK Current Less than 500 ma Ic 30 A Pc 200 W 220 W FASTENER TIGHTENING SPECIFICATIONS N m Lb-Ft Lb-In Condenser Bolt Condenser Fan Nut Condenser Bolt Receiver Drier Pipe Bolt Receiver Drier Pipe Bolt (Condenser) Pressure Pipe Bolt Pressure Mounting Bolt

5 SCHEMATIC AND ROUTING DIAGRAMS FATC-HAVC 7D-5 CIRCUIT DIAGRAM KAA7D010

6 7D-6 FATC-HAVC FATC BLOCK DIAGRAM INCAR SENSOR VFD AMBIENT SENSOR MAX HI RELAY WATER TEMPERATURE SENSOR SUN LOAD SENSOR POWER T/R BLOWER MOTOR TEMPERATURE SWITCH BLOWER SWITCH MODE SWITCH DEFROSTER SWITCH C O N T R O L ECU MIX ACTUATOR COMPRESSOR MIX DOOR INTAKE SWITCH AUTO SWITCH A/CON SWITCH U N I T INTAKE ACTUATOR Airconditioner output INTAKE DOOR OFF SWITCH MODE ACTUATOR MODE DOOR TEMP DOOR POSITION FEEDBACK VOLTAGE POWER TRANSISTOR COLLECTOR VOLTAGE

7 FATC-HAVC 7D-7 COMPONENT LOCATOR VENTILATION SYSTEM KAA7D020

8 7D-8 FATC-HAVC FUNCTION DESCRIPTION 1. AUTO switch By pressing the AUTO switch, set temperature, AUTO, fan speed, air source, air flow mode will be appeared on the VFD display. Following items will be controlled automatically according to set temperature. - Mode and intake door - Temperature door - Blower fan speed - Compressor ON/OFF control When AUTO switch is released, other functions will be controlled automatically except for manually selected switches. 2. MODE switch By pressing the MODE switch while the AUTO switch is turned ON, AUTO indicator light will go off and air flow mode will be controlled manually in the order of VENT B/L FLR MIX VENT. 3. OFF switch Press this switch and the airconditioner system will be turned OFF. 4. Temperature UP/DOWN switch This switch is a switch increasing or decreasing set temperature and position of the temperature door will be automatically controlled according to set temperature and outlet temperature will be controlled by adjusting blending ratio of cold and hot air. By operating the switch, set temperature will be increased/decreased by 0.5 C. Set temperature range is C. Max. cold function will be performed at set temperature of 17 C and max. hot function will be performed at set temperature of 32 C. When pressed more than 1 second, it will be automatically UP/DOWN by interval of 0.28 sec. after 1 second. When it changed 17.5 C 17 C, 31.5 C 32 C and DOWN switch is pressed after 17 C or UP switch is pressed after 32 C, there will be operating sounds 3 times during 0.1 sec. 5. DEFROST switch By pressing this switch, DEF will turn on and mode door will be fixed at DEF. Recirculation/fresh air switch will be fixed as FRESH. When airconditioner is turned ON and ambient temperature is less than 1.5 C, the airconditioner will be turned off. Selection of airconditioner OFF is possible by manual. 6. A/C switch The airconditioner system will be turned ON or OFF by pressing this switch. 7. Recirculation fresh air switch Air intake will be automatically switched to recirculation or fresh air (REC FRE) by pressing this switch. 8. Blower switch (UP/DOWN) Blower speed can be controlled by manual and if fan UP/DOWN switch is pressed when AUTO mode is selected, fan speed will UP/DOWN based on current fan level. When 6 segments are turned on, it is max. HI operation. When pressed more than 1 second, it will be automatically UP/DOWN by interval of 0.28 sec. after 1 second. When segment is changed stage 2 stage 1 (LO), stage 5 stage 6 (HI) and HI switch is pressed in HI status or DOWN switch is pressed in LO status, there will be operating sounds 3 times during 0.1 sec. When switch is operated in OFF status, it will be operated as stage 1 (1 segment display).

9 FATC-HAVC 7D-9 DIAGNOSIS DIAGNOSIS TEST FATC airconditioner system has self-diagnosis function. Turn the ignition switch ON and press intake switch more than 4 times within 2 seconds while the AUTO switch is pressed, then it will diagnose incar sensor, ambient sensor, water temperature sensor and temperature actuator for open/short and will display numerical fault code on the set temperature display of VFD. KAA7D030 1 AUTO Switch 2 Fresh/Recirculation Switch 3 OFF Switch 4 Airconditioner Switch 5 VFD (Vaccum Fluorescent Display)

10 7D-10 FATC-HAVC Self-diagnosis Method Ignition switch ON Press the intake switch more than 4 times within 2 seconds while pressing the AUTO switch Self-diagnosis will start after turning off all displays on VFD for 2.5 seconds Press AUTO Self-diagnosis items check (continuous action) Press OFF Press AUTO Self-diagnosis items check (step action) Press OFF Airconditioner control Diagnosis Item and Fault Code 00 : normal 11 : incar Sensor Open 12 : incar Sensor Short 13 : ambient Sensor Open 14 : ambient Sensor Short 15 : coolant Sensor Open 16 : coolant Sensor Short 17 : temperature Actuator Open/Short 18 : temperature Actuator Drive Fault

11 FATC-HAVC 7D-11 Self-diagnosis Display 1. Data will be displayed at the set temperature display as 2-digit number during self-diagnosis function and other set temperature displays will be OFF. 2. Display of self-diagnosis fault code will be blinking fault code number in the intervals of 0.5 sec. 3. Following fault code number will be displayed at the set temperature display during self-diagnosis function. 4. If no defective, normal display number (00) will blink. Display during continuous action A. Normal or 1 fault (00 or 11) B. Multiple faults (11, 13, 15...) Display during step action A. Normal or 1 fault : the same as continuous action B. Multiple faults

12 7D-12 FATC-HAVC Fault Safety Function FATC airconditioner system not only performs selfdiagnosis but also has safety function against faults if there is open or short in the incar sensor, ambient sensor, water temperature sensor and temperature door potentiometer. NO. Item Defects Fault safety function Incar sensor Ambient sensor Water temperature sensor Temperature door potentiometer Open or short Open or short Open or short Open or short Control When substituted 25 C Control When substituted 20 C Perform heating maneuver control function under refrigeration maneuver control entering conditions and release after 10 minutes. Set temperature C : max. COLD position Set temperature C : max. HOT position

13 FATC-HAVC 7D-13 MAINTENANCE AND REPAIR FATC CONTROL PANEL KAA7D070 1 AUTO Switch 2 MODE Switch 3 OFF Switch 4 Temperature UP/DOWN Switch 5 Defrost Switch 6 Airconditioner Switch 7 Fresh/Recirculation Switch 8 Blower Switch (UP/DOWN) 9 VFD (Vacuum Fluorescent Display)

14 7D-14 FATC-HAVC Pin Number and Connection Circuit KAA7D080 Connector A Connector B Pin No Connection circuit Rheostat Tail lamp Battery (+) Power TR (B) Power TR (C) Temperature actuator (CCW) IG2 Ground Airconditioner switch ground HI speed relay Photo sensor (+) Photo sensor (-) Temperature actuator F/B Temperature actuator (CW) IG2 Ground Pin No Connection circuit Incar sensor (+) Ambient sensor (+) Coolant sensor (+) Sensor voltage 5V Sensor ground Intake (ambient) Intake (incar) VENT B/L FLR MIX DEF

15 E F FATC-HAVC 7D-15 Removal & Installation Procedure 1. Turn the ignition switch to OFF position. 2. Remove two screws on the cover of shift lever box. KAA7D Unscrew the screw from the center panel, pull out each switches and remove the center panel KAA7D Unscrew the 6 screws and remove the audio control panel assembly. KAA7D Unscrew the 4 screws and remove the airconditioner control panel assembly. 6. Installation should follow the removal procedure in the reverse order. KAA7D120

16 7D-16 FATC-HAVC AIR FILTER Removal and Installation Procedures Replacement Interval Every 10,000 km Notice: Replace earlier if air pollution is heavy. 1. Open the glove box and pull it inward to release the upper left and right locking portion. Notice: Remove the glove box by unscrewing lower 2 screws, if necessary. KAA7D Press the 2 filter cover holds and remove the air filter cover. 3. Remove the 2 air filters. Notice: For installation, remember the installed direction of the air filter before removal. KAA7D140

17 TROUBLESHOOTING Check and Service FATC-HAVC 7D-17 Incar sensor is a sensor that detects interior air temperature and a thermistor that decreases its resistance when temperature up and increases when temperature down. 1. Check that there are incar sensor fault code (11,12) by using self-diagnosis function. KAA7D Disconnect incar sensor 2-pin connector that installed on inner lower instrument panel cover of driver s side and remove the sensor. KAA7D Check that measured resistance value among incar sensor terminals is as shown in the right side graph. Notice: Measure resistance value by soaking the sensor in the ice water and check changes in resistance values after soaking it in the very hot water. 4. If resistance value is out of specification, replace the incar sensor. KAA7D Install the sensor and turn the ignition switch to ON position and check that voltage between No. 12A terminal of incar sensor and body (-) is 5V. 6. Check current between the No. 12B and 12A connector terminals of the incar sensor and the No. 1 and 5 connector terminals of the airconditioner control unit and repair the wire if defective. KAA7D180

18 7D-18 FATC-HAVC Ambient Sensor Ambient sensor is a sensor that detects ambient temperature and a thermistor that decreases its resistance when temperature up and increases when temperature down. 1. Check that there are ambient sensor fault code (13,14) by using self-diagnosis function. KAA7D Disconnect ambient sensor 2-pin connector that installed on front right side of the frame and remove the sensor. KAA7D Check that measured resistance value among ambient sensor terminals is as shown in the right side graph. Notice: Measure resistance value by soaking the sensor in the ice water and check changes in resistance values after soaking it in the very hot water. 4. If resistance value is out of specification, replace the ambient sensor. KAA7D Install the sensor and turn the ignition switch to ON position and check that voltage between No. 10 terminal of the ambient sensor and body (-) is 5V. 6. Check current between the No. 10 and 9 connector terminals of the ambient sensor and the No. 2 and 5 connector terminals of the airconditioner control unit and repair the wire if defective. KAA7D220

19 Water Sensor FATC-HAVC 7D-19 Water sensor is a thermistor that detects engine coolant temperature to operate the blower speed to LO when water temperature is less than Check that there are water sensor fault code (15,16) by using self-diagnosis function. KAA7D Disconnect water sensor 2-pin connector that installed on the heater unit of inner instrument panel and remove the water sensor. KAA7D Check that measured resistance value among water sensor terminals is as shown in the right side graph. Notice: Measure resistance value by soaking the sensor in the ice water and check changes in resistance values after soaking it in the very hot water. 4. If resistance value is out of specification, replace the water sensor. KAA7D Install the sensor and turn the ignition switch to ON position and check that voltage between No. 7a terminal of the water sensor and body (-) is 5V. 6. Check current between the No. 7a and 7b connector terminals of the water sensor and the No. 3 and 5 connector terminals of the airconditioner control unit and repair the wire if defective. KAA7D260

20 7D-20 FATC-HAVC Sun load Sensor Sun load sensor is a photo diode that detects lights. Resistance of diode can be measured as current by using multimeter according to increasing sun loads. 1. Check current on the circuits between the sun load sensor and the airconditioner control unit. KAA7D Turn the ignition switch to ON position and check that voltage between No. 13a terminal of the sun load sensor and vehicle ground is 5V. KAA7D Measure current between No. 13a terminal of the sun load sensor and No. 11 terminal of the control unit and check it is as shown in the below graph. 4. If current value is out of specification, replace the sun load sensor. KAA7D290 KAA7D300

21 FATC-HAVC 7D-21 Fault : intake (recirculation/fresh air) door inoperative Remove the glove box. Disconnect 3-pin connector of the intake mode actuator and turn the ignition switch to ON position. KAA7D310 Measure voltage between 6c terminal positive pole (+) and body (-). Wiring side connector Measured voltage is 12V. Yes Turn the ignitin switch OFF and disconnect harness of the intake actuator. No Check No. 24 fuse (15A) in the box. Check that it operates toward each direction after connecting the battery to the 6C terminal of intake actuator and ground 6A & 6B to the body. Intake actuator is normal. Yes Disconnect 20-pin connector from the airconditioner control unit. No Repair and replace the intake actuator. Check intake actuator linkage and door for proper operation and repair if necessary. Check current between the intake actuator (6A, 6B) and the airconditioner control unit (6,7). Is there current? Yes No Repair open wire between the intake actuator and the control unit. Replace the good control unit and re-check. If no fault, replace the control panel.

22 7D-22 FATC-HAVC Fault : air flow does not change toward panel side. Remove the center panel of the instrument panel. Disconnect 8-pin connector of the mode actuator and turn the ignition switch to ON position. KAA7D350 Measure voltage between 8I terminal positive pole (+) and body (-). Measured voltage is 12V. Yes Turn the ignition switch OFF and disconnect harness of the mode actuator. No Check No. 24 fuse (15A) in the fuse box. Check that it operates toward each directions when ground is connected to terminal (8J, 8H, 8F, 8D, 8B) of the mode actuator alternatively. Mode actuator is normal. Yes Disconnect 20-pin connector from the airconditioner control unit. No Repair and replace the mode actuator. Check the intake actuator linkage and door for proper operation and repair if necessary. Check current between the mode actuator (8J, 8H, 8F, 8D, 8B) and the airconditioner control unit (11, 12, 13, 14, 15). Is there current? Yes No Repair open wire between the mode actuator and the control unit. Replace the good control unit and re-check. If no fault, replace the control panel.

MANUAL CONTROL / SEMIAUTO TEMPERATURE CONTROL HEATING, VENTILATION AND AIR CONDITIONING SYSTEM

MANUAL CONTROL / SEMIAUTO TEMPERATURE CONTROL HEATING, VENTILATION AND AIR CONDITIONING SYSTEM SECTION 7C MANUAL CONTROL / SEMIAUTO TEMPERATURE CONTROL HEATING, VENTILATION AND AIR CONDITIONING SYSTEM CAUTION: Disconnect the negative battery cable before removing or installing any electrical unit

More information

1. SPECIFICATIONS 01-2

1. SPECIFICATIONS 01-2 01-2 1. SPECIFICATIONS Description Specification Heater Core size (mm²) 200 x 165.5 x 25 Capacity (kcal/h) 4,700 Evaporator Core size (mm²) 254.8 x 196.7 x 60 Capacity (kcal/h) 4,700 Blower Supplied power

More information

37. FATC (FULL AUTO TEMP. CONTROL) CIRCUIT 6810

37. FATC (FULL AUTO TEMP. CONTROL) CIRCUIT 6810 5156 6810 37. FATC (FULL AUTO TEMP. CONTROL) CIRCUIT 6810 1) CONDENSOR FAN, AIR MIX MOTOR, SUN SENSOR, WATER TEMP SENSOR A. CONNECTOR INFORMATION 6810 5157 Connector Number (Pin Number, Color) Connecting

More information

Pagina 1 di 1 INSPECTION In-car air sensor is located at crash pad. It is installed with humidity sensor. It will detect interior, which will be used for discharge control, sensor failsafe, door control,

More information

AIR CONDITIONER 1. SYSTEM LAYOUT AND COMPONENTS Air Conditioner Controller FATC. Manual air conditioner

AIR CONDITIONER 1. SYSTEM LAYOUT AND COMPONENTS Air Conditioner Controller FATC. Manual air conditioner 06-2 6810-01 1. SYSTEM LAYOUT AND COMPONENTS Type Air Conditioner Controller FATC Manual air conditioner Sun Sensor - Instrument Panel Upper Left It changes sun load coming through front windshield into

More information

5. SELF DIAGNOSIS (ONLY FOR FATC AIR CONDITIONER)

5. SELF DIAGNOSIS (ONLY FOR FATC AIR CONDITIONER) 18 6810 5. SELF DIAGNOSIS (LY FOR FATC AIR CDITIER) Self Diagnosis 1. Starting Self Diagnosis Turn the ignition switch to OFF position and press OFF switch for more than 5 seconds within 10 seconds. 1.

More information

1. DO NOT HANDLE REFRIGERANT IN AN ENCLOSED AREA OR NEAR AN OPEN FLAME

1. DO NOT HANDLE REFRIGERANT IN AN ENCLOSED AREA OR NEAR AN OPEN FLAME 2006 Toyota 4Runner 4.0L Eng Limited 1Search AIR CONDITIONER REQUESTED INFORMATION PRECAUTION 1. DO NOT HANDLE REFRIGERANT IN AN ENCLOSED AREA OR NEAR AN OPEN FLAME 2. ALWAYS WEAR EYE PROTECTION Fig 1:

More information

A/C-HEATER SYSTEM - AUTOMATIC

A/C-HEATER SYSTEM - AUTOMATIC A/C-HEATER SYSTEM - AUTOMATIC 1996 Subaru SVX 1995-96 AUTOMATIC A/C-HEATER SYSTEMS Subaru SVX * PLEASE READ THIS FIRST * WARNING: To avoid injury from accidental air bag deployment, read and carefully

More information

3.10 Air Conditioning (A/C) Contents

3.10 Air Conditioning (A/C) Contents 3.10 Air Conditioning (A/C) Contents 3.10 Model 208 as of M.Y. 1998 Diagnosis Page Function Test................................... 11/1 Reading Actual Values............................ 12/1 Version Code...................................

More information

RETRIEVING DIAGNOSTIC TROUBLE CODES

RETRIEVING DIAGNOSTIC TROUBLE CODES Page 1 of 13 SELF-DIAGNOSTICS A/C-heater control assembly monitors system circuits and stores a code in memory if a problem is detected. All codes are stored in memory except Code 2 Malfunction is current

More information

AIR CONDITIONER SECTION AC CONTENTS AUTO

AIR CONDITIONER SECTION AC CONTENTS AUTO AIR CONDITIONER SECTION AC CONTENTS AUTO PRECAUTIONS AND PREPARATION SRS Airbag Pretensioner Seatbelt... 4 A/C Refrigerant HFC134a Handling... 4 Compressor Oil... 4 Tube Connection... 4 O-Ring Part Number...

More information

Module 4: Climate Control

Module 4: Climate Control ÂÂ ÂÂ Air-Conditioning Electronic Control Unit (ECU) Â Controlling Cabin Air Temperature Servo Motors Electric Servo Motors ÂÂ Air-Conditioning Electronic Control Unit (ECU) Automatic Climate Control Sensors

More information

3.5 Air Conditioning (A/C) Contents

3.5 Air Conditioning (A/C) Contents 3.5 Air Conditioning (A/C) Contents 3.5 Model 210 Diagnosis Page Function Test................................... 11/1 Reading Actual Values............................ 12/1 Individual Flap Test...............................

More information

FULL AUTO TEMPERATURE CONTROL GENERAL 1. SPECIFICATIONS FULL AUTO TEMPERTURE CONTROL REXTON

FULL AUTO TEMPERATURE CONTROL GENERAL 1. SPECIFICATIONS FULL AUTO TEMPERTURE CONTROL REXTON 02-3 FULL AUTO TEMPERATURE CONTROL GENERAL 1. SPECIFICATIONS 02-4 OVERVIEW AND OPERATION PROCESS 1. FATC SYSTEM LAYOUT Configuration and Characteristic of A/C Controller 02-5 A/C System Related Devices

More information

DIAGNOSIS AND TESTING

DIAGNOSIS AND TESTING 412-00-1 Climate Control System - General Information 412-00-1 DIAGNOSIS AND TESTING Climate Control System Refer to Wiring Diagrams Cell 54, Air Conditioning/Heater for schematic and connector information.

More information

A/C-HEATER SYSTEM - AUTOMATIC

A/C-HEATER SYSTEM - AUTOMATIC A/C-HEATER SYSTEM - AUTOMATIC 1988 Toyota Celica 1988 Automatic A/C-Heater Systems Celica * PLEASE READ THIS FIRST * CAUTION: When discharging air conditioning system, use only approved refrigerant recovery/recycling

More information

DIAGNOSIS AND TESTING

DIAGNOSIS AND TESTING 412-00-1 Climate Control System - General Information 412-00-1 DIAGNOSIS AND TESTING Climate Control System Refer to Wiring Diagrams Cell 54, Air Conditioner/Heater for schematic and connector information.

More information

This vehicle uses HFC 134a (R 134a) refrigerant, which does not contain chlorofluorocarbons. Pay attention to the following service items:

This vehicle uses HFC 134a (R 134a) refrigerant, which does not contain chlorofluorocarbons. Pay attention to the following service items: HEATING AND A/C SYSTEM DESCRI... 2007 CIVIC Heating and A/C System Description The air conditioning (A/C) system removes heat from the passenger compartment by transferring heat from the ambient air to

More information

SECTION Climate Control System - General Information

SECTION Climate Control System - General Information 412-00-i Climate Control System - General Information 412-00-i SECTION 412-00 Climate Control System - General Information CONTENTS PAGE DIAGNOSIS AND TESTING Climate Control System... 412-00-2 Inspection

More information

A/C SYSTEM SPECIFICATIONS

A/C SYSTEM SPECIFICATIONS A/C SYSTEM SPECIFICATIONS SPECIFICATIONS Application Specification Compressor Type Matsushita Matsushita Rotary Sanden Sanden Scroll Compressor Belt Deflection (1) Used 5/16-7/16" (8-9.5 mm) New 9/32-5/16"

More information

2001 Dodge Caravan Sport MANUAL A/C-HEATER SYSTEMS Caravan, Town & Country, & Voyager

2001 Dodge Caravan Sport MANUAL A/C-HEATER SYSTEMS Caravan, Town & Country, & Voyager SPECIFICATIONS NOTE: Information for Caravan includes the Grand Caravan. SPECIFICATIONS Application Specification Compressor Type Nippondenso 10S20H Compressor Belt Tension (1) System Oil Capacity (2)

More information

HEATER, AIR CONDITIONER AND VENTILATION

HEATER, AIR CONDITIONER AND VENTILATION 55-1 HEATER, AIR CONDITIONER AND VENTILATION CONTENTS HEATER AND MANUAL AIR CONDITIONER...................... 3 GENERAL............................... 3 Outline of Change......................... 3 SERVICE

More information

3.6 Air Conditioning (A/C) Contents

3.6 Air Conditioning (A/C) Contents 3.6 Air Conditioning (A/C) Contents 3.6 Model 140 as of MY 1996 Page Diagnosis Function Test.................................. 11/1 Reading Sensor Values........................... 12/1 Individual Flap

More information

211 Climate Control 219 PP HVAC (TWK)

211 Climate Control 219 PP HVAC (TWK) 211 Climate Control 219 PP HVAC (TWK) 8-30-02 1 These technical training materials are current as of the date noted on the materials, and may be revised or updated without notice. Always check for revised

More information

Page 1 of 50 Section 412-00: Climate Control System General Information DIAGSIS AND TESTING 1997 Mark VIII Workshop Manual Climate Control System Special Service Tool(s) 73 Digital Multimeter 105-R0051

More information

Position of Parts in Engine Compartment

Position of Parts in Engine Compartment ELECTRICAL WIRING ROUTING [3S GTE] Position of Parts in Engine Compartment A 1 A/C Ambient Temp. Sensor D 1 Date Link Connector 1 (Check Connector) A 2 A/C Condenser Fan Motor D 2 Distributor A 4 A/C Magnetic

More information

A/C-HEATER SYSTEM - AUTOMATIC

A/C-HEATER SYSTEM - AUTOMATIC A/C-HEATER SYSTEM - AUTOMATIC 1993 Toyota Celica 1993 Automatic A/C-Heater Systems Celica SPECIFICATIONS SPECIFICATIONS TABLE Application Specification Compressor Type 1.6L... Nippondenso 10PA15C 10-Cyl.

More information

A/C SYSTEM SPECIFICATIONS

A/C SYSTEM SPECIFICATIONS A/C SYSTEM SPECIFICATIONS A/C-HEATER SYSTEM - MANUAL 1997 Manual A/C-Heater System WARNING: To avoid injury from accidental air bag deployment, read and follow all SERVICE PRECAUTIONS and DISABLING & ACTIVATING

More information

2002 Taurus/Sable Workshop Manual

2002 Taurus/Sable Workshop Manual Page 1 of 69 SECTION 412-00: Climate Control System - General Information 2002 Taurus/Sable Workshop Manual DIAGNOSIS AND TESTING Procedure revision date: 02/05/2005 Climate Control System Refer to Wiring

More information

A/C-HEATER SYSTEM - AUTOMATIC

A/C-HEATER SYSTEM - AUTOMATIC A/C-HEATER SYSTEM - AUTOMATIC 1994 Volvo 960 1994 Auto. A/C-Heater System Volvo 960 A/C SYSTEM SPECIFICATIONS AUTOMATIC A/C SYSTEM SPECIFICATIONS TABLE Application Specification Compressor Type... Sanden

More information

Volkswagen Golf > VW Rabbit GTI 2006-> (A5)

Volkswagen Golf > VW Rabbit GTI 2006-> (A5) Volkswagen Golf 5 2004-> VW Rabbit GTI 2006-> (A5) A/C Refrigerant System General information Note: General A/C refrigerant system servicing procedures (e.g., component/system descriptions, extracting

More information

Page 1 of 54 412-00 Climate Control System General Information and Diagnostics 2006 Crown Victoria/Grand Marquis DIAGNOSIS AND TESTING Procedure revision date: 12/23/2008 Climate Control System Printable

More information

A/C SYSTEM GENERAL DIAGNOSTIC PROCEDURES

A/C SYSTEM GENERAL DIAGNOSTIC PROCEDURES Article Text ARTICLE BEGINNING 1993 AIR CONDITIONING & HEAT A/C General Diagnostic Procedures Diagnosis is an important first step in A/C system servicing. To save time and effort, systems should be carefully

More information

DESCRIPTION AND OPERATION

DESCRIPTION AND OPERATION Your Current Vehicle: 1998 Ford Explorer Top / Heating, Ventilation, & Air Conditioning / Control Components / DESCRIPTION AND OPERATION DESCRIPTION AND OPERATION SECTION 412-04: Control Components 1998

More information

HEATER & AIR CONDITIONING CONTROL SYSTEM

HEATER & AIR CONDITIONING CONTROL SYSTEM VENTILATION, HEATER & AIR CONDITIONER SECTION HAC A HEATER & AIR CONDITIONING CONTROL SYSTEM B C D CONTENTS E WITH COLOR DISPLAY BASIC INSPECTION... 5 INSPECTION AND ADJUSTMENT... 5 Operational Check (Front)...5

More information

HEATER, AIR CONDITIONING AND VENTILATION

HEATER, AIR CONDITIONING AND VENTILATION 55-1 GROUP 55 HEATER, AIR CONDITIONING AND VENTILATION CONTENTS GENERAL INFORMATION 55-3 FASTENER TIGHTENING SPECIFICATIONS 55-5 GENERAL SPECIFICATIONS 55-5 SERVICE SPECIFICATIONS 55-5 LUBRICANTS 55-5

More information

TSB #: 53 Date: 2/11/2011 HOLDEN (DELPHI) VARIABLE STROKE COMPRESSOR DIAGNOSIS STEP ACTION RESULT YES NO

TSB #: 53 Date: 2/11/2011 HOLDEN (DELPHI) VARIABLE STROKE COMPRESSOR DIAGNOSIS STEP ACTION RESULT YES NO HOLDEN (DELPHI) VARIABLE STROKE COMPRESSOR DIAGSIS TSB #: 53 Date: 2/11/2011 Initial Once Read: Even though the Holden variable stroke compressor manufactured by Delphi has been in the Australian market

More information

Different oils are used in automotive A/C systems, based on the type of refrigerant. Polyalkylene Glycol (PAG) oil is used for R-134a refrigerant.

Different oils are used in automotive A/C systems, based on the type of refrigerant. Polyalkylene Glycol (PAG) oil is used for R-134a refrigerant. Lubricants Automotive air conditioning lubricants are specially formulated because of how and where they operate. Air conditioning oils must be dry (having little or no water content) and mix with the

More information

DESCRIPTION AND OPERATION

DESCRIPTION AND OPERATION Page 1 of 10 DESCRIPTION AND OPERATION AIR DELIVERY DESCRIPTION AND OPERATION The air delivery description and operation is divided into five areas: HVAC Control Components Air Speed Air Delivery Recirculation

More information

Jeep Wrangler TJ 4.0 LITER Installation instructions

Jeep Wrangler TJ 4.0 LITER Installation instructions www.jeepair.com 2000-2001 Jeep Wrangler TJ 4.0 LITER Installation instructions Important information about your system, and warranty DO NOT ADD ANY OIL TO ANY PART OF THE SYSTEM. DO NOT USE THE SIGHT GLASS

More information

RADIATOR FAN AND AIR CONDITIONER

RADIATOR FAN AND AIR CONDITIONER RADIATOR FAN AND AIR CONDITIONER E 7 AM ACC IG ST L I9 IGNITION S EA 6 I H D 7 A C E 5A ECU IG INTEGRATION RELAY 9 9 E 0A GAUGE 5 5 M 0A CDS A A/C CONDENSER FAN MOTOR ENGINE MAIN RELAY 6 D F 5 C D D M

More information

HEATER, AIR CONDITIONING AND VENTILATION

HEATER, AIR CONDITIONING AND VENTILATION 55-1 GROUP 55 HEATER, AIR CONDITIONING AND VENTILATION CONTENTS GENERAL INFORMATION 55-3 FASTENER TIGHTENING SPECIFICATIONS 55-5 GENERAL SPECIFICATIONS 55-5 SERVICE SPECIFICATIONS 55-5 LUBRICANTS 55-5

More information

PERFECT FIT SERIES IN-DASH HEAT/ COOL/ DEFROST 1969 CHEVROLET CAMARO/ FIREBIRD NOTE: INSTRUCTIONS DEPICT CAMARO

PERFECT FIT SERIES IN-DASH HEAT/ COOL/ DEFROST 1969 CHEVROLET CAMARO/ FIREBIRD NOTE: INSTRUCTIONS DEPICT CAMARO specializing in AIR CONDITIONING, PARTS AND SYSTEMS for your classic vehicle PERFECT FIT SERIES IN-DASH HEAT/ COOL/ DEFROST 1969 CHEVROLET CAMARO/ FIREBIRD NOTE: INSTRUCTIONS DEPICT CAMARO CONTROL & OPERATING

More information

Jeep Wrangler 4.0 Liter TJ Jeep Wrangler 2.5 Liter TJ Installation instructions

Jeep Wrangler 4.0 Liter TJ Jeep Wrangler 2.5 Liter TJ Installation instructions TM www.jeepair.com 1999 Jeep Wrangler 4.0 Liter TJ 1999-2001 Jeep Wrangler 2.5 Liter TJ Installation instructions Kit Information After 1994 every vehicle was designed for R134a refrigerant. The Jeep kit

More information

G ELECTRICAL WIRING ROUTING [5VZ FE] TOYOTA TACOMA (EWD517U) Position of Parts in Engine Compartment

G ELECTRICAL WIRING ROUTING [5VZ FE] TOYOTA TACOMA (EWD517U) Position of Parts in Engine Compartment G ELECTRICAL WIRING ROUTING [5VZ FE] Position of Parts in Engine Compartment A 5 A/C Magnetic Clutch A 7 A/T Oil Temp. Sensor A22 ABS Actuator with ECU A23 Air Fuel Ratio Sensor (Bank 1 Sensor 1) A24 ADD

More information

SECTION 9A BODY WIRING SYSTEM

SECTION 9A BODY WIRING SYSTEM SECTION 9A BODY WIRING SYSTEM Caution: Disconnect the negative battery cable before removing or installing any electrical unit or when a tool or equipment could easily come in contact with exposed electrical

More information

VALEO HEVAC (P38 NRR) - System Overview

VALEO HEVAC (P38 NRR) - System Overview VALEO HEVAC (P38 NRR) - System Overview Custom Manufactured by Valeo for the P38 Range Rover as an Air condition control module option on everything except the very base model, which has only 3 rotary

More information

DESCRIPTION & OPERATION

DESCRIPTION & OPERATION DESCRIPTION & OPERATION HEATER SYSTEM 1997 Heater System WARNING: To avoid injury from accidental air bag deployment, read and follow all SERVICE PRECAUTIONS and DISABLING & ACTIVATING AIR BAG SYSTEM procedures

More information

Electric Rotary Knob BILLET CONTROLS INSTALLATION INSTRUCTIONS

Electric Rotary Knob BILLET CONTROLS INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS THESE ARE THE PARTS YOU WILL FIND IN YOUR BILLET CONTROL BOX You will use these parts and hardware during the next series of installation steps. Pressure Switch (engine compartment)

More information

3.1 Air Conditioning (A/C) Contents

3.1 Air Conditioning (A/C) Contents 3.1 Air Conditioning (A/C) Contents 3.1 Model 129 up to M.Y. 1997 Diagnosis Page Diagnostic Trouble Code (DTC) Memory................ 11/1 Complaint Related Diagnostic Chart................... 12/1 Electrical

More information

HEATER, AIR CONDITIONING AND VENTILATION

HEATER, AIR CONDITIONING AND VENTILATION - GROUP HEATER, AIR CONDITIONING AND VENTILATION CONTENTS GENERAL DESCRIPTION......... -3 SERVICE PRECAUTIONS......... - CAUTION LABELS................... -........ - INTRODUCTION TO HEATER, AIR CONDITIONING

More information

HEATING AND AIR CONDITIONING

HEATING AND AIR CONDITIONING 55-1 GROUP 55 HEATING AND AIR CONDITIONING CONTENTS GENERAL INFORMATION........ 55-3 MANUAL A/C DIAGNOSIS........ 55-4 INTRODUCTION TO HEATER, AIR CONDITIONING AND VENTILATION DIAGNOSIS........ 55-4 HEATER,

More information

EXTERNAL CONTROL VALVE (ECV) EQUIPPED VARIABLE A/C COMPRESSOR DIAGNOSIS PROCEDURE

EXTERNAL CONTROL VALVE (ECV) EQUIPPED VARIABLE A/C COMPRESSOR DIAGNOSIS PROCEDURE Technical Service Bulletin GROUP DATE HVAC JUNE, 2017 NUMBER MODEL(S) 17-HA-002 Multiple Models EXTERNAL CONTROL VALVE (ECV) EQUIPPED VARIABLE A/C COMPRESSOR DIAGNOSIS PROCEDURE This bulletin supersedes

More information

PERFECT FIT IN-DASH HEAT/ COOL/ DEFROST FORD FAIRLANE & CROWN VICTORIA

PERFECT FIT IN-DASH HEAT/ COOL/ DEFROST FORD FAIRLANE & CROWN VICTORIA PERFECT FIT IN-DASH HEAT/ COOL/ DEFROST 1955-56 FORD FAIRLANE & CROWN VICTORIA CONTROL & OPERATING INSTRUCTIONS The controls on your new Perfect Fit system, offer complete comfort capabilities in virtually

More information

1996 AUTOMATIC A/C-HEATER SYSTEMS Acura Automatic A/C Systems

1996 AUTOMATIC A/C-HEATER SYSTEMS Acura Automatic A/C Systems Article Text Saturday, January 23, 1999 06:32PM ARTICLE BEGINNING 1996 AUTOMATIC A/C-HEATER SYSTEMS Acura Automatic A/C Systems A4 * PLEASE READ THIS FIRST * WARNING: To avoid injury from accidental air

More information

G ELECTRICAL WIRING ROUTING [1MZ-FE] Position of Parts in Engine Compartment

G ELECTRICAL WIRING ROUTING [1MZ-FE] Position of Parts in Engine Compartment G ELECTRICAL WIRING ROUTING [1MZ-FE] Position of Parts in Engine Compartment A 1 A/C Ambient Temp. Sensor A 2 A/C Condenser Fan Motor A 3 A/C Magnetic Clutch and Lock Sensor A 4 A/C Triple Pressure SW

More information

Program IV: ProStar TM. Performance A/C International. Series. Study Guide Performance A/C Program IV: International ProStar Series TMT

Program IV: ProStar TM. Performance A/C International. Series. Study Guide Performance A/C Program IV: International ProStar Series TMT Performance A/C International A N AV I S TA R C O M PA N Y Program IV: ProStar TM Study Guide TMT-160701 Series Study Guide Performance A/C Program IV: International ProStar Series TMT-160701 2007 International

More information

TROUBLE DIAGNOSIS. Press (DEF) switch a third time. Temperature detected by intake sensor is indicated on the display ( F for

TROUBLE DIAGNOSIS. Press (DEF) switch a third time. Temperature detected by intake sensor is indicated on the display ( F for 8. SELF-DIAGNOSIS STEP 5: TEMPERATURE OF EACH SENSOR IS CHECKED 1. Rotate the temperature control dial clockwise (driver) to STEP 5. 2. Code No. 51 appears on the display. >> GO TO 9. 9. CHECK AMBIENT

More information

ARTICLE BEGINNING * PLEASE READ THIS FIRST * DESCRIPTION OPERATION ATC COMPUTER BLEND-AIR DOOR ACTUATOR CONTROL PANEL

ARTICLE BEGINNING * PLEASE READ THIS FIRST * DESCRIPTION OPERATION ATC COMPUTER BLEND-AIR DOOR ACTUATOR CONTROL PANEL A/C-HEATER SYSTEM - AUTOMATIC Article Text 1989 Chrysler LeBaron Sedan For m m m m m Copyright 1998 Mitchell Repair Information Company, LLC Thursday, July 03, 2003 10:15AM ARTICLE BEGINNING 1989 AUTOMATIC

More information

Jeep Wrangler TJ. Complete Air Conditioning System. Slide Control Head. Installation instructions

Jeep Wrangler TJ. Complete Air Conditioning System. Slide Control Head. Installation instructions WWW.JEEPAIR.COM 1996-1998 Jeep Wrangler TJ Complete Air Conditioning System Slide Control Head Installation instructions Kit Information After 1994 every vehicle was designed for R134a refrigerant. The

More information

3.3 Air Conditioning (A/C) Model 202

3.3 Air Conditioning (A/C) Model 202 Notes for Diagnosis The A/C pushbutton control module (N22) has DTC memory and data output.the diagnostic trouble codes and data are displayed via the temperature display window (arrow). The stored DTC

More information

SOUL GDI REPAIR AND MAINTENANCE

SOUL GDI REPAIR AND MAINTENANCE SOUL 2013-1.6 GDI REPAIR AND MAINTENANCE (First Numbers are page number within section - Numbers in parenthesis are overall document page) GENERAL INFORMATION (23 PAGES) 01-07 (01-07): Identification Number

More information

Position of Parts in Engine Compartment

Position of Parts in Engine Compartment ELECTRICAL WIRING ROUTING [5S FE] Position of Parts in Engine Compartment A 1 A/C Ambient Temp. Sensor D 1 Distributor A 2 A/C Condenser Fan Motor A 3 A/C Idle Up VSV E 1 ECT Solenoid A 4 A/C Magnet Clutch

More information

TA V TA V

TA V TA V TA-3030 12V TA-3031 24V High Cooling Capacity Low Power Consumption Small Dimensions Low Weight Parallel Flow Condenser Aluminum Body ABS Acrylic Cover TA-3030 12V p.n. 4500-030 TA-3031 24V p.n. 4500-031

More information

HEATING AND AIR CONDITIONING

HEATING AND AIR CONDITIONING 55-1 GROUP 55 HEATING AND AIR CONDITIONING CONTENTS GENERAL INFORMATION........ 55-3 MANUAL A/C DIAGNOSIS........ 55-4 INTRODUCTION TO MANUAL A/C DIAGNOSIS........................ 55-4 MANUAL A/C DIAGNOSTIC

More information

Chevrolet Camaro Control Panel Kit

Chevrolet Camaro Control Panel Kit an ISO 900:2008 Registered Company 970-8 Chevrolet Camaro Panel Kit 47307 8865 Goll St. San Antonio, TX 78266 Phone: 20-654-77 Fax: 20-654-33 90307 REV C 0/3/7, PG OF 9 Table of Contents Thank you for

More information

Lotus Service Notes Section EMD

Lotus Service Notes Section EMD ENGINE MANAGEMENT SECTION EMD Lotus Techcentre Sub-Section Page Diagnostic Trouble Code List EMD.1 3 Component Function EMD.2 8 Component Location EMD.3 10 Diagnostic Guide EMD.4 11 CAN Bus Diagnostics;

More information

SERVICE & OWNER S MANUAL

SERVICE & OWNER S MANUAL 1 of 10 SERVICE & OWNER S MANUAL Product Specifications 25 x 36 x 7 Weight: 47 lbs. Air Flow: 260 CFM Air Conditioner p/n: 1ACUNIT-G1 Fits with Curtis Roof Kit: Contact Curtis for Details. Fits with Curtis

More information

TABLE OF CONTENTS Subject Page

TABLE OF CONTENTS Subject Page TABLE OF CONTENTS Subject Page Control Panel................................................2 Control Module..............................................6 Substitute Value Operation......................................7

More information

3.2 Air Conditioning (A/C) Model 140 up to M.Y. 1995

3.2 Air Conditioning (A/C) Model 140 up to M.Y. 1995 Diagnosis Memory P83-3271-13B Notes for Diagnosis The A/C pushbutton control module (N22) has DTC memory and the capability to display the codes via the temperature display windows (arrows) on the A/C

More information

Position of Parts in Engine Compartment

Position of Parts in Engine Compartment [1UZ FE] Position of Parts in Engine Compartment A 1 A/C Ambient Temp. Sensor E 4 Engine Coolant Temp. Sensor (Water Temp. Sensor A 2 A/C Dual Pressure SW and A/C High Pressure SW (for Cooling Fan)) A

More information

CHAPTER 21 ENVIRONMENT CONTROL. Section Title Page

CHAPTER 21 ENVIRONMENT CONTROL. Section Title Page CHAPTER 21 ENVIRONMENT CONTROL Section Title Page 21-00 Description........................................ 21.1 21-10 Ventilation........................................ 21.3 21-11 Nose Vent................................

More information

2001 IMPREZA SERVICE MANUAL QUICK REFERENCE INDEX

2001 IMPREZA SERVICE MANUAL QUICK REFERENCE INDEX 00 IMPREZA SERVICE MANUAL QUICK REFERENCE INDEX BODY SECTION HVAC SYSTEM (HEATER, VENTILATOR AND A/C) HVAC SYSTEM (AUTO A/C) (DIAGNOSTICS) AIRBAG SYSTEM AC AC AB This service manual has been prepared to

More information

Position of Parts in Engine Compartment

Position of Parts in Engine Compartment ELECTRICAL WIRING ROUTING [5S FE] Position of Parts in Engine Compartment A 1 A/C Condenser Fan Motor E 4 Engine Coolant Temp. Sensor (EFI Water Temp. A 2 A/C Magnetic Clutch and Lock Sensor Sensor) A

More information

Jeep Wrangler TJ 4.0 LITER Installation instructions

Jeep Wrangler TJ 4.0 LITER Installation instructions www.jeepair.com 2002-2004 Jeep Wrangler TJ 4.0 LITER Installation instructions Kit Information These directions are for 2002-2006 model Jeep Wranglers. After 1994 every vehicle was designed for R134a refrigerant.

More information

LIST OF OPERATION METHODS

LIST OF OPERATION METHODS 0.5 Seconds 0.5 Seconds AT0716 DI1747 DIB6T02 PRECHECK 1. Warning for A/C compressor lock If compressor lock occurs during A/C operation, the A/C switch indicator on the A/C control assembly starts blinking.

More information

POWER SOURCE (Current Flow Chart)

POWER SOURCE (Current Flow Chart) The chart below shows the route by which current flows from the battery to each electrical source (Fusible Link, Circuit Breaker, Fuse, etc.) and other parts. The next page and following pages show the

More information

How to Retrieve a DTC (Without HDS)

How to Retrieve a DTC (Without HDS) How to Retrieve a DTC (Without HDS) The climate control unit has a self-diagnostic function. To run the self-diagnostic function, do the following: NOTE: Before troubleshooting the climate control system,

More information

& 76 CHEVROLET NOVA HEATER ONLY

& 76 CHEVROLET NOVA HEATER ONLY specializing in AIR CONDITIONING, PARTS AND SYSTEMS for your classic hi l PERFECT FIT IN-DASH HEAT/ COOL/ DEFROST 1969-74 & 76 CHEVROLET NOVA HEATER ONLY CONTROL & OPERATING INSTRUCTIONS The controls on

More information

CAMARO. w/ & w/o AC CONTROL PANEL CONVERSION KIT an ISO 9001:2008 Registered Company

CAMARO. w/ & w/o AC CONTROL PANEL CONVERSION KIT an ISO 9001:2008 Registered Company an ISO 9001:2008 Registered Company 1970-81 CAMARO w/ & w/o AC CONTROL PANEL CONVERSION KIT 473071 903071 REV B 9/18/14, INST. GEN IV 1970-81 CAMARO w/ & w/o AC CNTRL PNL PG 1 OF 9 Table of Contents PAGES

More information

COMPONENT LOCATIONS GROUP 70 CONTENTS INSPECTION CONNECTOR AND SPARE CONNECTOR SENSOR DIODE SOLENOID VALVE...

COMPONENT LOCATIONS GROUP 70 CONTENTS INSPECTION CONNECTOR AND SPARE CONNECTOR SENSOR DIODE SOLENOID VALVE... GROUP 70 COMPONENT LOCTIONS CONTENTS SENSOR....................... 70-2 DIODE........................ 70-8 ECU.......................... 70-9 FUSIBLE LINK ND FUSE........ 70-11 RELY........................

More information

G ELECTRICAL WIRING ROUTING

G ELECTRICAL WIRING ROUTING 2 6 G ELECTRICAL WIRING ROUTING [2JZ-GTE] Position of Parts in Engine Compartment A 1 A/C Ambient Temp Sensor A 2 A/C Condensor Fan Motor A 3 A/C Triple Pressure SW (A/C Dual and Single Pressure SW) A

More information

2015 F-250, 350, 450, 550 Super Duty DESCRIPTION AND OPERATION Procedure revision date: 04/28/2016. Climate Control System

2015 F-250, 350, 450, 550 Super Duty DESCRIPTION AND OPERATION Procedure revision date: 04/28/2016. Climate Control System Page 1 of 9 412-00 Climate Control System General Information and Diagnostics Climate Control System 2015 F-250, 350, 450, 550 Super Duty DESCRIPTION AND OPERATION Procedure revision date: 04/28/2016 WARNING:

More information

HEATER & AIR CONDITIONER SECTIONHA CONTENTS IDX

HEATER & AIR CONDITIONER SECTIONHA CONTENTS IDX HEATER & AIR CONDITIONER SECTIONHA GI MA EM LC EC CONTENTS FE PRECAUTIONS...2 Supplemental Restraint System (SRS) AIR BAG and SEAT BELT PRE-TENSIONER...2 Precautions for Working with HFC-134a (R-134a)...2

More information

HVAC System: Engine Cooling, Controls and Communication

HVAC System: Engine Cooling, Controls and Communication Course #S-AC07-04.01VCT HVAC System: Engine Cooling, Controls and Communication Participant Guide Revised: 01/24/11 Copyright 2011, General Motors Company, All Rights Reserved Caution Danger: In order

More information

5/12/2018 Climate Control - Control Components - Description and Operation 2009 Ford F-150 MotoLogic

5/12/2018 Climate Control - Control Components - Description and Operation 2009 Ford F-150 MotoLogic 2009 F-150 Subarticles Report a problem with this article Electronic Manual Temperature Control (EMTC) Dual-Zone Electronic Automatic Temperature Control (EATC) SECTION 412-01: Climate Control 2009 F-150

More information

13A-1 FUEL CONTENTS MULTIPOINT FUEL INJECTION (MPI) FUEL SUPPLY... 13B

13A-1 FUEL CONTENTS MULTIPOINT FUEL INJECTION (MPI) FUEL SUPPLY... 13B 13A-1 FUEL CONTENTS MULTIPOINT FUEL INJECTION (MPI)... 13A FUEL SUPPLY... 13B 13A-2 MULTIPOINT FUEL INJECTION (MPI) CONTENTS GENERAL INFORMATION... 3 SERVICE SPECIFICATIONS... 6 SEALANT... 6 SPECIAL TOOLS...

More information

Technical Services Information

Technical Services Information Technical Services Information Keywords: Dash Air Conditioning, Air Conditioning, Automotive, Automotive Air Conditioner, Air Conditioner, AC, *.* Topic: Denso Dash Air Conditioner, Component Testing Issue

More information

ELECTRICAL COMPONENT LOCATOR

ELECTRICAL COMPONENT LOCATOR ELECTRICAL COMPONENT LOCATOR 1988 Toyota Celica 1988 TOYOTA Celica Electrical Components ---------------------------------------------------------------------- BUZZERS, RELAYS & TIMERS ----------------------------------------------------------------------

More information

Chevrolet Camaro without Factory Air Evaporator Kit (561180)

Chevrolet Camaro without Factory Air Evaporator Kit (561180) an ISO 9001:2008 Registered Company 1979-81 Chevrolet Camaro without Factory Air Evaporator Kit (561180) 18865 Goll St. San Antonio, TX 78266 Phone: 210-654-7171 Fax: 210-654-3113 901186 REV D 01/13/17,

More information

CONFIGURATION DIAGRAMS

CONFIGURATION DIAGRAMS GROUP 80 CONFIGURATION DIAGRAMS CONTENTS OVERALL CONFIGURATION DIAGRAM...................... 80-2......... 80-3 .. 80-3 .. 80-5 ...... 80-7 INSTRUMENT PANEL............ 80-9 FLOOR

More information

POWER SOURCE (Current Flow Chart)

POWER SOURCE (Current Flow Chart) POWER SOURCE (Current Flow Chart) The chart below shows the route by which current flows from the battery to each electrical source (Fusible Link, Circuit Breaker, Fuse, etc.) and other parts. The next

More information

an ISO 9001: 2008 Registered Company CHEVELLE without FACTORY AIR REV C 8/27/14, CHEVELLE wo AC EVAP INSTR PG 1 OF 29

an ISO 9001: 2008 Registered Company CHEVELLE without FACTORY AIR REV C 8/27/14, CHEVELLE wo AC EVAP INSTR PG 1 OF 29 an ISO 9001: 2008 Registered Company 1966-67 CHEVELLE without FACTORY AIR 561066 SS 901162 REV C 8/27/14, 1966-67 CHEVELLE wo AC EVAP INSTR PG 1 OF 29 PAGES Table of Contents 1. COVER 2. TABLE OF CONTENTS

More information

G ELECTRICAL WIRING ROUTING

G ELECTRICAL WIRING ROUTING G ELECTRICAL WIRING ROUTING Position of Parts in Engine Compartment A 1 A/C Ambient Temp. Sensor A 2 A/C Condenser Fan Motor A 3 A/C Magnetic Clutch and Lock Sensor A 4 A/C Triple Pressure SW (A/C Dual

More information

Cutlass with Factory Air

Cutlass with Factory Air an ISO 9001: 2008 Registered Company 1968-69 Cutlass with Factory Air 564069 18865 Goll St. San Antonio, TX 78266 ph: 210-654-7171 fax: 210-654-3113 904057 REV B 10/2/12, INST 1968-69 CUTLASS w/ AC EVAP

More information

1969 CAMARO VCZ-A

1969 CAMARO VCZ-A 969 CAMARO w/o FACTORY AIR 55070-VCZ-A 8865 GOLL ST. - SAN ANTONIO, TX. - 78266 ph.20-654-77 - fax 20-654-33 905070-VCZ-A /22/05, 69 CAMARO w/o FAC. AIR INSTRUCTIONS PG OF 20 969 CAMARO w/o FACTORY AIR

More information

Fault Codes. J control

Fault Codes. J control J control Timer Temp Fault Codes 12 11 10 9 8 7 6 5 4 3 2 1 30 29 28 27 26 25 24 23 22 21 20 Enter unit inspection mode by pushing the UP and DOWN buttons simultaneously for two seconds. Ensure that the

More information

1012-Electrical Diagrams

1012-Electrical Diagrams Term Absolute Pressure 1012-Electrical Diagrams Definition Total or true pressure. Gauge pressure plus atmospheric pressure. Absolute that includes the atmospheric pressure in its reading. This sensor

More information

MULTIPOINT FUEL INJECTION (MPI) <4G9>

MULTIPOINT FUEL INJECTION (MPI) <4G9> MULTIPOINT FUEL INJECTION (MPI) 13C-1 MULTIPOINT FUEL INJECTION (MPI) CONTENTS GENERAL................................. 2 Outline of Changes............................ 2 GENERAL INFORMATION...................

More information

Cutlass without Factory Air

Cutlass without Factory Air an ISO 9001: 2008 Registered Company 1970-72 Cutlass without Factory Air 561076 18865 Goll St. San Antonio, TX 78266 ph: 210-654-7171 fax: 210-654-3113 901076 REV A 9/17/12, INST 1970-72 CUTLASS wo AC

More information