Illustrated Parts List to

Transcription

1 TYPE NUMBERS 0001 through 0026, 0027 through 0049, 0059 through 0075, 0079 through 0093, 0105 through 0128, 0129 through 0169, 0171 through 0200, 0202 through 0217, 0219 through 0238, 0240 through 0256, 0258 through 0269, 0271 through 0299, 0300 through 0327, 0603 through 0616, Illustrated Parts List Model Series to TO FIND THE CORRECT NUMBER OF THE PART YOU NEED: FOLLOW THE INSTRUCTIONS BELOW FORM MS C 8/2002 REPLACES FORM MS C 4/2001 FILE IN SECT. 2 OF SERVICE MANUAL to TYPE NUMBERS 0620 through 0626, 0635 through 0660, 0670, 0671, 0679, 0700 through 0717, 0727 through 0740, 0747 through 0767, 0772 through 0791, 0814, 0815, through 1050, 1060 through 1093, 1105 through 1197, 1200 through 1299, 1301 through 1333, 1336 through A. Refer to Engine Model, Type and Code Number that is stamped on the blower housing of engine. Engine type numbers such as are listed only as 0123 in most instances. The two digits (01 or 02, etc.) to the right of the space may be required for more accurate parts identification in some instances. Select the Illustrated Parts List covering the correct Model Series and Type Number. B. Refer to the Illustrations and compare the original part with Illustration. The number next to the illustration is the Reference Number. Assemblies include all parts shown in frames. All parts shown in assembly frames having individual reference numbers can be purchased separately. C. After the Reference Number has been identified, refer to the Numerical text, where Reference and Primary Part Number are listed. THE PRIMARY PART IS USED ON ALL TYPE NUMBERS EXCEPT THOSE TYPE NUMBERS UNDER NOTE. D. If a Note appears below the Primary Part Number, it means that this part differs from the Primary Part for certain types. If your Type number is listed under Note, order the part referred to at the Note. E. If your Engine Type Number does not appear after any part number listed under Note, use the Primary Part Number. F. For Engine Type Numbers not covered by this book, check other Parts Lists having the same engine model or contact your source of supply. PRINTED IN U.S.A. COPYRIGHT by BRIGGS & STRATTON CORPORATION All rights reserved. No part of this material may be reproduced or transmitted, in any form or by any means, electronic or mechanical, including photocopying, recording or by any information storage and retrieval system, without permission in writing from Briggs & Stratton Corporation.

2 Cylinder Assembly Cylinder Assembly 0011, 0013, 0022, 0025, 0026, 0059, 0072, 0075, 0080, 0082, 0083, 0084, 0093, 0115, 0121, 0126, 0138, 0157, 0162, 0163, 0164, 0166, 0168, 0181, 0205, 0215, 0225, 0226, 0236, 0241, 0244, 0247, 0248, 0251, 0252, 0256, 0259, 0264, 0277, 0291, 0292, 0297, 0299, 0312, 0314, 0327, 0611, 0625, 0626, 0752, 0757, 0762, 0791, 1011, 1012, 1025, 1026, 1072, 1075, 1080, 1084, 1093, 1115, 1157, 1215, 1252, 1291, 1292, 1312, 1314, 1327, 1328, 1333, 1337, Assemblies include all parts shown in frames. 4C 8/2002 2

3 A A A REQUIRES SPECIAL TOOLS TO INSTALL. SEE REPAIR INSTRUCTION MANUAL LABEL KIT 1058 OWNER S MANUAL Cylinder Assembly (See previous page) Kit Bushing/Seal (Magneto Side) ) Kit Bushing/ Seal (Magneto Side) Date ) Seal Oil (Magneto Side) Head Cylinder Gasket Cylinder Head Breather Assembly Gasket Breather Screw (Breather Assembly) Tube Breather Tube Breather Tube Breather 1011, Screw (Cylinder Head) 13A Screw (Cylinder Head) Stud (Cylinder Head) Plug Oil Drain (Standard) Shield Cylinder Screw (Cylinder Shield) 308A Cover Cylinder Head (Full) Plug Spark Plug Spark (Resistor Type) Wrench Spark Plug Clamp Tube Clamp Tube 0299, 1011, Grommet (90 Degree) 529A Grommet (120 Degree) Bushing Governor Crank Boot Spark Plug Pin Locating Seat Valve (Intake) Seat Valve (Exhaust) Bushing Valve Guide (Exhaust) Bushing Valve Guide (Intake) Stopswitch Spark Plug 1011, Kit Label Owner s Manual Assemblies include all parts shown in frames. 4C 8/2002 3

4 Piston Assembly (Standard) ) Piston Assembly (Standard) Date ) Piston Assembly (.010 Oversize) ) Piston Assembly (.010 Oversize) Date ) Piston Assembly (.020 Oversize) ) Piston Assembly (.020 Oversize) Date ) Piston Assembly (.030 Oversize) ) Piston Assembly (.030 Oversize) Date ) Ring Set (Standard) ) Ring Set (Standard) Date ) Ring Set (.010 Oversize) ) Ring Set (.010 Oversize) Date ) Ring Set (.020 Oversize) ) Ring Set (.020 Oversize) Date ) Ring Set (.030 Oversize) ) Ring Set (.030 Oversize) Date ) Lock Piston Pin Pin Piston (Standard) Pin Piston (.005 Oversize) Rod Connecting Rod Connecting (.020 Undersize) Dipper Connecting Rod Screw (Connecting Rod) Assemblies include all parts shown in frames. 4C 8/2002 4

5 B Valve Exhaust Valve Intake Spring Valve (Intake) Spring Valve (Exhaust) Retainer Valve 40B Retainer Valve (Exhaust) Tappet Valve Assemblies include all parts shown in frames. 4C 8/2002 5

6 A Crankshaft Crankshaft 0049, 0107, 0155, 0215, 0243, 0277, 0649, 1049, Crankshaft 0020, 0117, 0132, 0258, 0620, 0728, 0759, 1299, 1020, 1128, 1231, 1258, Crankshaft 0026, 0115, 0129, 0151, 0160, 0162, 0163, 0164, 0166, 0199, 0211, 0244, 0252, 0292, 0297, 0327, 0626, 0729, 0752, 1327, 1026, 1115, 1129, 1160, 1252, 1292, Crankshaft 1080, Crankshaft 0080, Crankshaft 0038, 0059, 0072, 0075, 0082, 0083, 0093, 0126, 0228, 0241, 0251, 0291, 0311, 0312, 0638, 0791, 1038, 1072, 1075, 1093, 1291, Crankshaft 0035, 0084, 0131, 0247, 0301, 0326, 0635, 1035, 1084, 1301, 1326, 1328, Crankshaft 0009, 0018, 0019, 0027, 0029, 0036, 0073, 0106, 0116, 0125, 0128, 0131, 0133, 0134, 0139, 0143, 0161, 0165, 0168, 0176, 0179, 0181, 0186, 0192, 0200, 0208, 0212, 0217, 0227, 0230, 0249, 0250, 0256, 0264, 0268, 0283, 0288, 0299, 0303, 0317, 0318, 0636, 0700, 0717, 0730, 0762, 0779, 0788, 1009, 1012, 1019, 1027, 1029, 1036, 1050, 1073, 1106, 1139, 1143, 1161, 1179, 1186, 1200, 1217, 1250, 1268, 1283, 1288, 1317, Crankshaft 0003, 0007, 0060, 0144, 0146, 0148, 0152, 0167, 0171, 0177, 0178, 0183, 0188, 0189, 0190, 0191, 0196, 0197, 0213, 0240, 0255, 0272, 0273, 0289, 0300, 0305, 0603, 0607, 0660, 0767, 0790, 0815, 1003, 1007, 1060, 1146, 1167, 1171, 1190, 1197, 1289, Crankshaft 0079, 0140, 0223, 0263, 0294, 0298, 0302, 0307, 0308, 0679, 0702, 0913, 1008, 1079, 1140, 1223, 1263, 1308, Crankshaft 0014, Crankshaft 0740, 0814, Bearing Ball Key Flywheel Key Timing (Used with Timing Gear ) Key Timing (Used with Timing Gear ) Key Drive Pulley 357A Key Drive Pulley (Woodruff) Gear Timing (Uses Woodruff Key) Gear Timing (Uses Locating Pin) Assemblies include all parts shown in frames. 4C 8/2002 6

7 to Cover Crankcase (Gear Reduction) Cover Crankcase (Auxillary PTO) Cover Crankcase (Plain Bearing) Cover Crankcase (Ball Bearing) Assemblies include all parts shown in frames. 4C 8/2002 7

8 REQUIRES SPECIAL TOOLS 1194 TO INSTALL. SEE REPAIR INSTRUCTION MANUAL Gasket Crankcase (Standard) Gasket Crankcase (.005 Thick) Gasket Crankcase (.009 Thick) 18 Cover Crankcase (See Previous Page) Kit Bushing/Seal (PTO Side) Seal Oil (PTO Side) Seal Oil (PTO Side) 0001, 0003, 0004, 0005, 0015, 0016, 0020, 0025, 0105, 0114, 0117, 0118, 0119, 0127, 0132, 0136, 0142, 0145, 0150, 0153, 0156, 0157, 0159, 0171, 0175, 0178, 0182, 0183, 0185, 0193, 0194, 0195, 0209, 0210, 0214, 0222, 0237, 0238, 0245, 0253, 0254, 0258, 0260, 0262, 0263, 0265, 0269, 0271, 0274, 0276, 0281, 0284, 0285, 0289, 0293, 0295, 0304, 0306, 0309, 0310, 0315, 0316, 0320, 0324, 0603, 0611, 0615, 0616, 0620, 0625, 0670, 0671, 0704, 0706, 0727, 0728, 0757, 0758, 0759, 0780, 0784, 1003, 1004, 1005, 1011, 1016, 1020, 1025, 1070, 1071, 1105, 1119, 1127, 1128, 1142, 1153, 1154, 1157, 1158, 1159, 1169, 1171, 1180, 1194, 1231, 1232, 1238, 1245, 1258, 1259, 1260, 1261, 1263, 1271, 1276, 1281, 1284, 1289, 1299, 1304, 1310, 1315, 1320, 1324, 1329, 1336, 1337, Seal Oil (PTO Side) 0011, 0070, 0071, 0108, 0120, 0121, 0124, 0141, 0154, 0157, 0158, 0169, 0173, 0174, 0180, 0182, 0194, 0198, 0202, 0203, 0204, 0205, 0206, 0207, 0209, 0214, 0216, 0232, 0236, 0254, 0260, 0265, 0269, 0295, 0309, 0310, 0320, 0324, 0611, 0670, 0671, 0728, 0757, 0758, 0780, 1011, 1070, 1071, 1128, 1154, 1157, 1158, 1169, 1173, 1180, 1194, 1232, 1260, 1261, 1265, 1309, 1310, 1320, 1324, 1336, 1337, 1338, Seal Oil (PTO Side) 0026, 0115, 0129, 0151, 0160, 0162, 0163, 0164, 0166, 0199, 0211, 0244, 0252, 0292, 0327, 0626, 0752, 1026, 1115, 1129, 1160, 1252, 1292, Cap Oil Fill Screw (Crankcase Cover) Stud (Crankcase Cover, Install In #1 and/or #2 Positions) Plug (Crankcase Cover) Seal O Ring (Plug) Assemblies include all parts shown in frames. 4C 8/2002 8

9 Camshaft ) Camshaft ). 0173, 0214, 0309, 0611, 0670, 0671, 0728, 0757, 0758, 0780, 1011, 1070, 1071, 1128, 1154, 1157, 1158, 1169, 1180, 1194, 1232, 1261, 1265, 1309, 1310, 1320, 1324, 1336, 1337, 1338, Camshaft Date ). 0070, 0071, 0108, 0120, 0121, 0124, 0141, 0154, 0157, 0158, 0169, 0174, 0180, 0182, 0194, 0198, 0202, 0203, 0204, 0205, 0206, 0207, 0209, 0216, 0232, 0236, 0254, 0260, 0265, 0269, 0295, 0309, 0310, 0320, 0322, 0324, 0611, 0670, 0671, 0757, 0758, Camshaft Date ). 0173, Gear Governor Gear Governor Date ) Washer (Governor Gear) Assemblies include all parts shown in frames. 4C 8/2002 9

10 NOTE: SEE NEXT PAGE FOR ADDITIONAL CARBURETOR PARTS Carburetor Carburetor 0185, Carburetor Carburetor 0309, 0603, 0607, 0611, 0615, 0616, 0620, 0623, 0625, 0626, 0635, 0636, 0638, 0649, 0660, 0670, 0671, 0679, 0700, 0702, 0704, 0717, 0706, 0727, 0728, 0729, 0730, 0740, 0747, 0752, 0757, 0758, 0759, 0762, 0767, 0772, 0779, 0780, 0784, 0788, 0790, 0814, 0815, 0913, 1003, 1004, 1005, 1007, 1008, 1009, 1011, 1019, 1020, 1023, 1025, 1027, 1029, 1035, 1036, 1049, 1050, 1060, 1070, 1071, 1073, 1079, 1080, 1084, 1105, 1106, 1119, 1127, 1128, 1129, 1139, 1140, 1142, 1143, 1146, 1147, 1153, 1154, 1157, 1158, 1159, 1161, 1167, 1169, 1171, 1173, 1179, 1180, 1190, 1194, 1196, 1197, 1200, 1215, 1216, 1217, 1219, 1223, 1231, 1232, 1238, 1242, 1245, 1246, , 1259, 1261, 1268, 1271, 1276, 1281, 1283, 1284, , 1289, 1299, 1301, 1304, 1308, 1310, 1313, 1314, 1315, 1317, 1318, 1320, 1324, 1326, 1328, 1329, 1330, 1333, 1336, 1337,1338, 1340, 1342, 1343, Jet Pilot (Standard) 0309, 0603, 0607, 0611, 0615, 0616, 0620, 0623, 0625, 0626, 0635, 0636, 0638, 0649, 0660, 0670, 0671, 0679, 0700, 0702, 0704, 0717, 0706, 0727, 0728, 0729, 0730, 0740, 0747, 0752, 0757, 0758, 0759, 0762, 0767, 0772, 0779, 0780, 0784, 0788, 0790, 0814, 0815, 0913, 1003, 1004, 1005, 1007, 1008, 1009, 1011, 1019, 1020, 1023, 1025, 1027, 1029, 1035, 1036, 1049, 1050, 1060, 1070, 1071, 1073, 1079, 1080, 1084, 1105, 1106, 1119, 1127, 1128, 1129, 1139, 1140, 1142, 1143, 1146, 1147, 1153, 1154, 1157, 1158, 1159, 1161, 1167, 1169, 1171, 1173, 1179, 1180, 1190, 1194, 1196, 1197, 1200, 1215, 1216, 1217, 1219, 1223, 1231, 1232, 1238, 1242, 1245, 1246, , 1259, 1261, 1268, 1271, 1276, 1281, 1283, 1284, , 1289, 1299, 1301, 1304, 1308, 1313, 1314, 1315, 1317, 1318, 1320, 1324, 1326, 1328, 1329, 1330, 1333, 1336, 1337, 1338, 1340, 1342, Jet Pilot (High Altitude) Assemblies include all parts shown in frames. 4C 8/

11 A A A A A Gasket Intake 90 Carburetor (See Previous Page) Screw (Throttle Valve) Shaft Throttle Washer (Choke Shaft) (Felt) 110A Washer (Choke Shaft) (Brass) Plug Welch 127A Plug Welch Valve Throttle Kit Choke Shaft ) Kit Choke Shaft Date ) Spring Needle Valve Valve Idle Mixture (Idle) Gasket Fuel Tank Crank Bell (Standard, Nylon) Screw (Bell Crank) Link Throttle Screw (Carburetor) Spring Pump Diaphragm Screen Carburetor Diaphragm Carburetor Cap Spring Cover Diaphragm Screw (Diaphragm Cover) Pipe Fuel Tube Pick Up (Uses Clip Spring) Tube Pick Up (Uses Spiral Pin) Spring Friction (Idle Screw) Spring Detent (Used On Part Carburetor) 718A Pin Locating (Pump Cover) Seal Throttle Shaft (Foam) Screw (Throttle Shaft) (Idle Speed Adjusting Only) Assemblies include all parts shown in frames. 4C 8/

12 90A A 987A 987B 232A 130A A 141A A A 205C 392A 127B 680A A A A Gasket Intake 0299, 1101, 1012, A Carburetor 1011, Carburetor Carburetor Screw (Throttle Valve) 97A Shaft Throttle 0299, 1101, 1012, Washer (Choke Shaft) (Felt) 110A Washer (Choke Shaft) (Brass) Screw (Choke Lever) Seat Needle Valve 127B Plug Welch 130A Valve Throttle 141A Kit Choke Shaft Spring Needle Valve 173A Valve Idle Mixture (Main) 203A Crank Bell (Steel, Long) 205C Screw (Bell Crank) 212A Link Throttle 0299, 1101, 1012, A Spring Governor Link 0299, 1101, 1012, Washer Sealing Washer (High Speed Valve) 392A Spring Pump Diaphragm 0299, 1101, 1012, Screen Carburetor Diaphragm Carburetor (Pump) Cap Spring Cover Diaphragm Screw (Diaphragm Cover) Pipe Fuel Tube Pick Up (Uses Clip Spring) 612A Tube Pick Up (Uses Spiral Pin) Washer (Choke Lever) (Spring) 680A Washer (Choke Lever) (Flat) Spring Friction (6 Coil, Closed Ends, Idle Screw) 718A Pin Locating (Pump Cover) Seal O Ring (High Speed Valve) Nut Needle Valve Connector Vacuum Tube Lever Choke 987A Seal Throttle Shaft (Felt) Seal Throttle Shaft (Felt) B Seal Throttle Shaft (Lip Seal) Screw (Throttle Shaft) (Idle Speed Adjusting Only) Valve High Speed Assemblies include all parts shown in frames. 4C 8/

13 A 485A A A A Link Choke (Manual) 222A Bracket Control (Gear and Rack) Rod Hand Choke (Kit) 226A Rod Hand Choke (Rod Assembly) Lever Governor Control Lever Governor Control 0299, 1011, Screw (Wire Clip) Washer (Governor Crank) Knob Control (Slide) 485A Knob Control Nut (Governor Control Lever) Bolt (Governor Control Lever) (Round) Pin Cotter Retainer E Ring Crank Governor Bracket Control (Panel) Switch Stop Cap Friction 689A Spring Friction (Conical Spring, Hand Choke Control) 729A Clip Wire (Clamp, Steel) Screw (Hand Choke Rod) Assemblies include all parts shown in frames. 4C 8/

14 A B B 206A A A A A A 203A A Kit Collar/Screw Link Mechanical Governor Link Mechanical Governor 0299, 1011, A Crank Bell (Steel) 205A Screw (Bell Crank) Nut Governor Adjusting (Governor Idle) 206A Nut Governor Adjusting (Fixed Speed) Rod Governor Control (Non Threaded) 208A Rod Governor Control (Threaded) (Governor Idle Speed) 208B Rod Governor Control (Fixed Speed) 216A Link Choke (Choke A Matic) Spring Choke Return Washer (Choke Link) Screw (Collar/Screw Kit) Spring Governor Link Clamp Casing Control Throttle (Remote/Governor Idle) 266A Control Throttle (Kit with Spring) Screw (Casing Clamp) Casing Control Wire (Cut To Required Length) Wire Control (Cut To Required Length) Nut (Control Wire Casing) Lever Control Screw (Throttle Control) 275A Screw (Throttle Control) Bracket Rod Screw (Cable Clamp) Screw (Wire Clip) Link Control Washer (Bell Crank) Screw (Link Bracket) Clamp Cable Spring Throttle Return 689B Spring Friction (4 Coil, Closed Ends) Shield Heat (Fuel Tank) 729A Clip Wire (Steel) Link Bell Crank Anchor Spring (Throttle Control) 780A Anchor Spring (Governor Idle) Screw (Spring Anchor) Lever Choke (Choke A Matic) Bracket Link Retainer Link Support Control Assemblies include all parts shown in frames. 4C 8/

15 A A 356B 356D 356E Key Flywheel Armature Magneto Screw (Magneto Armature) 334A Screw (Magneto Armature) Switch Rocker Wire Stop 356A Wire Stop 356B Wire Stop 356D Wire Stop 356E Wire Stop Washer (Ground Terminal) Nut (Ground Terminal) Alternator (Magneto Armature) Insulator Terminal Ground Wire Assembly Bracket Stopswitch Spacer Clip Wire (Snap In, Nylon) Terminal Spark Plug Switch Key Solenoid Starter Key Set Tie Cable Screw (Alternator) Assemblies include all parts shown in frames. 4C 8/

16 C Spring Governor (Rich Red) Spring Governor (Black) 0004, 0016, 0020, 0027, 0029, 0119, 0124, 0127, 0141, 0142, 0143, 0176, 0177, 0185, 0189, 0195, 0203, 0209, 0217, 0232, 0240, 0242, 0254, 0260, 0262, 0263, 0265, 0268, 0276, 0281, 0309, 0315, 0324, 1003, 1035, 1080, 1084, 1155, 1171, , 1326, 1328, Spring Governor (Blue) 0018, 0215, 0225, 0248, 0603, 0607, 0611, 0615, 0623, 0625, 0635, 0636, 0649, 0660, 0670, 0671, 0679, 0700, 0702, 0704, 0717, 0730, 0740, 0747, 0759, 0762, 0767, 0779, 0780, 0784, 0788, 0790, 0814, 0815, 0913, 1005, 1007, 1008, 1009, 1011, 1019, 1023, 1025, 1036, 1049, 1050, 1060, 1070, 1071, 1073, 1079, 1105, 1106, 1139, 1140, 1143, 1146, 1147, 1153, 1154, 1157, 1158, 1159, 1161, 1167, 1169, 1173, 1179, 1180, 1186, 1190, 1194, 1196, 1197, 1200, 1216, 1219, 1223, 1231, 1238, 1245, 1250, 1258, 1259, 1271, 1284, 1288, 1289, 1296, 1299, 1301, 1304, 1308, 1310, 1313, 1314, 1317, 1318, 1320, 1329, Spring Governor (Green) 0026, 0038, 0082, 0115, 0129, 0151, 0160, 0162, 0164, 0166, 0199, 0211, 0241, 0244, 0252, 0311, 0327, 0626, 0638, 0729, 0752, 0791, 1026, 1038, 1115, 1129, 1160, 1252, 1291, 1327, Spring Governor (Yellow) 0059, 0072, 0075, 0083, 0093, 0126, 0163, 0228, 0251, 0292, 0297, 0312, 1072, 1093, 1292, 1312, Spring Governor (Silver) 0616, 0620, 0706, 0727, 0728, 1004, 1016, 1020, 1027, 1029, 1119, 1127, 1128, 1142, 1217, 1232, 1242, 1260, 1261, 1263, 1265, 1268, 1276, 1281, 1309, 1315, 1324, 1343, Spring Governor (Bright Orange) C Spring Governor (Green) 0299, 1011, Spring Governed Idle Assemblies include all parts shown in frames. 4C 8/

17 191B 180B A A 180C A B NOTE: ALL FUN KART APPLICATIONS USING MODEL SERIES ENGINES MUST USE FUEL TANK. 180B 180C Tank Fuel (Metal Tank) (Uses Plastic Locking- Cap) Tank Fuel (Metal Tank) (Uses Plastic Locking- Cap) Tank Fuel (Metal Tank) (Uses Vented Metal Screw Cap) 0299, 1011, 1012, Cap Fuel Tank (Metal) (Threaded, Vented) Cap Fuel Tank (Metal) (Threaded, Non Vented) Screw (Fuel Tank) 190A Screw (Fuel Tank) 190B Screw (Fuel Tank) Gasket Fuel Tank 191A Gasket Fuel Tank 191B Gasket Fuel Tank 0299, 1011, Switch Stop Rack Governor Gear (Black) Rack Governor Gear (Natural) 0016, 0019, 0071, 0147, 0148, 0185, 0195, 0200, 0213, 0214, 0216, 0232, 0260, 0263, 0306, 0310, 1016, 1071, 1147, 1200, 1232, 1260, 1263, Cap Fuel Tank (Plastic) Assemblies include all parts shown in frames. 4C 8/

18 A A A B 536A 968A 967A Base Air Cleaner (Round) 161A Base Air Cleaner (Rectangular) Air Cleaner Gasket (Standard, Oval) 163A Air Cleaner Gasket (1 5/8 O.D. Round) 163B Air Cleaner Gasket (1 15/16 O.D. Round) Screw (Air Cleaner Cover) Filter Air Cleaner Cartridge (Canister) 445A Filter Air Cleaner Cartridge (Rectangular) Knob Air Cleaner Cleaner Air (Rectangular) 536A Cleaner Air (Canister) Stud (Air Cleaner Cover, 1/4 Diameter) Stud (Air Cleaner Cover, 1/2 Diameter) 0185, 0263, Adapter Air Cleaner Filter Pre Cleaner (Rectangular) 967A Filter Pre Cleaner (Round) Cover Air Cleaner (Rectangular) 968A Cover Air Cleaner (Canister) Screw (Air Cleaner Base) Assemblies include all parts shown in frames. 4C 8/

19 300A 613D 725A 300B A A 300C B D C Lock Muffler Screw Locknut Muffler/Elbow 300A Muffler (Super Lo Tone) 300B Muffler (Heat Shield Supplied By Equipment Manufacturer) C Muffler (Lo Tone) Muffler (Lo Tone) 0072, 0075, 0142, 0143, 0193, 0195, 0198, 0208, 0244, 0315, 0316, 1072, 1075, 1127, 1142, 1143, D Muffler (Round Lo Tone) 0138, 0165, 0227, Elbow Exhaust Screw (Muffler) 613A Screw (Muffler) 613B Screw (Muffler) 613C Screw (Muffler) 613D Screw (Muffler) 613E Screw (Muffler) Deflector Muffler (Side Out) (Deep) Deflector Muffler (Side Out) (Shallow) 0029, 0167, 0190, 0225, 0248, 0276, 0767, 1029, 1276, 1167, A Deflector Muffler (Direct Out) Screw (Muffler Deflector) 725A Shield Heat (Muffler) Gasket Exhaust Brace Muffler Assemblies include all parts shown in frames. 4C 8/

20 A 725A 832A C 836C B A A 836B B 836D Screw (Spark Arrestor) Screw (Muffler Guard Bracket) Bracket Muffler Guard Deflector Muffler (Side Out) (Deep) Deflector Muffler (Side Out) (Shallow) 0029, 0167, 0190, 0225, 0248, 0276, 0767, 1029, 1276, 1167, A Deflector Muffler (Direct Out) 676B Deflector Muffler (Louvered) Screw (Muffler Deflector) 725A Shield Heat (Fuel Tank) 832A Guard Muffler (Super Lo Tone) 832B Guard Muffler (Lo Tone) 832C Guard Muffler (Round Lo Tone) Screw (Muffler Guard) 836A Screw (Muffler Guard) 836B Screw (Muffler Guard) 836C Screw (Muffler Guard) 836D Screw (Muffler Guard) 994A Arrestor Spark Assemblies include all parts shown in frames. 4C 8/

21 A 73A to A Flywheel (Rewind Start) 23A Flywheel (With Ring Gear) Screen Rotating Date ). 73A Screen Rotating ) Screen Rotating Date ) Washer (Flywheel) Screen/Cup Assembly ) Nut (Flywheel) Flywheel Puller Cup Flywheel (Straight Side Cup) Date ). 455A Cup Flywheel (Straight Side Cup With Rotating Screen Ring) Gear Ring (Includes Mounting Hardware) Assemblies include all parts shown in frames. 4C 8/

22 A EMISSIONS LABEL Guard Flywheel Screw (Flywheel Guard) Guide Air (Rewind Start) Guide Air (Electric Start) Housing Blower (Rewind Start) Housing Blower (Electric Start) 0011, 0013, 0022, 0025, 0121, 0138, 0157, 0205, 0225, 0236, 0248, 0264, 0299, 0611, 0625, 0757, 0762, Screw (Blower Housing) Screw (Wire Clip) Cover Starter Drive 729A Clip Wire (Steel) Screw (Starter Drive Cover) Label Emission ) Label Emission Date and After Code Date ) Label Emission Date and After Code Date ) Label Emission Date ) Assemblies include all parts shown in frames. 4C 8/

23 to A Housing Rewind Starter Rope Starter (Cut To Required Length) Insert Grip Grip Starter Rope (1 Piece) 60A Grip Starter Rope (2 Piece) Screw (Rewind Starter) Plate Pawl Friction Pawl Rachet Nut (Rewind Starter) Screw (Pawl Friction Plate) Starter Rewind 689C Spring Friction (Rachet Pawl) Pulley/Spring Assembly (Pulley) Pulley/Spring Assembly (Spring) Assemblies include all parts shown in frames. 4C 8/

24 608A A 57A A 689D A A 60A 59 58A 55A Housing Rewind Starter (For Complete Rewind Starter Housing Service, See Ref 608, Previous Page) 57A Rewind Starter Spring 58A Starter Rope (Cut To Length) Insert Grip 60A 65A Grip Starter Rope Screw (Rewind Starter) Shaft Pin Starter Pulley 276A Sealing Washer 456A Plate Pawl Friction 459A Pawl Rachet Nut (Rewind Starter) 608A Starter Rewind (For Complete Rewind Starter Service, See Ref 608, Previous Page) Rewind Spacer 689D Friction Spring Washer (Pawl Friction Plate) Assemblies include all parts shown in frames. 4C 8/

25 A Motor Starter Bolt (Starter Motor) Set Brush Drive Starter Clutch Drive Armature Starter Washer (Brush Retainer) Screw (Drive Cap) 697A Screw (Drive Cap) (Starter Drive Cover) Gear Pinion Nut (Brush Retainer) Cap Drive Cap End Housing Starter Ring Retaining Retainer Brush Washer (Drive Cap) Assemblies include all parts shown in frames. 4C 8/

26 79 20A 80 82A A 15A Plug Oil Drain Plug (Flush) 20A Seal Oil (PTO Side) ( 53/64 I.D. Without Spring) Case Gear Reduction Gasket Gear Case Screw (Gear Reduction Case) 82A Screw (Gear Reduction Case) Shaft Auxiliary Drive Plug Breather Screw (Gear Cover To Gear Reduction) Cover Gear Seal Gear Reduction Gasket Gear Reduction Cover Hood Snow Screw (Snow Hood) Assemblies include all parts shown in frames. 4C 8/

27 A 523A 842A 525A A 847B C 523B A Screw (Dipstick Tube) 287A Screw (Dipstick Tube) Gasket Dipstick Nut (OIL GARD Kit) Bracket Oil Fill Dipstick (8 7/16 Flat Wire) ). 523A Dipstick (7 11/16 Spring) Date ). 523B Dipstick (4 13/16 Round Bar) Dipstick (8 11/16 Spring) 0255, 0273, 0294, 0307, 0308, 1008, Seal Dipstick Tube Tube Dipstick (31/32 ID Top) ). 525A Tube Dipstick (1 1/64 ID Top) Date ). 525C Tube Dipstick (Oil Filler Pipe Adapter) (3 1/8 Long) Screw (OIL GARD Light Bracket) Harness Wiring Seal O Ring (Dipstick Tube) ). 842A Seal O Ring (Dipstick Tube) Date ) Dipstick/Tube Assembly (Without Bracket) ). 847A Dipstick/Tube Assembly (With Bracket) Date ). 847B Dipstick/Tube Assembly (Uses Dipstick Tube) Washer (OIL GARD Kit) Gasket OIL GARD Cover OIL GARD Kit OIL GARD Screw (OIL GARD Cover) 982A Screw (OIL GARD Cover) Light Indicator Bracket OIL GARD Light Assemblies include all parts shown in frames. 4C 8/

28 358A ENGINE GASKET SET A 51 51A A A 191B Seal Oil (Magneto Side) Gasket Cylinder Head Gasket Breather Gasket Crankcase (Standard) Gasket Crankcase (.005 Thick) Gasket Crankcase (.009 Thick) Seal Oil (PTO Side) Gasket Intake 0299, 1101, 1012, A Gasket Intake Gasket Air Cleaner (Standard, Oval) Gasket Fuel Tank 191A Gasket Fuel Tank 191B Gasket Fuel Tank 0299, 1011, A Gasket Set Engine Seal Dipstick Tube Seal O Ring (Dipstick Tube) ). 842A Seal O Ring (Dipstick Tube) Date ) Gasket Exhaust Gasket OIL GARD Seal O Ring (Plug) 20A Seal Oil (PTO Side) Assemblies include all parts shown in frames. 4C 8/

29 121 CARBURETOR OVERHAUL KIT 51 51A 163A A B A Gasket Intake 0299, 1101, 1012, A Gasket Intake Seat Needle Valve Kit Carburetor Overhaul Spring Needle Valve Gasket Air Cleaner (Standard, Oval) 163A Gasket Air Cleaner (1 5/8 O.D. Round) Valve Idle Mixture (Idle) 173A Valve Idle Mixture (Main) Gasket Fuel Tank 191A Gasket Fuel Tank 191B Gasket Fuel Tank 0299, 1011, Washer Sealing Washer (High Speed Valve) Diaphragm Carburetor (Pump) Seal O Ring (High Speed Valve) Nut Needle Valve Valve High Speed Assemblies include all parts shown in frames. 4C 8/

30 1095 VALVE GASKET SET A Gasket Cylinder Head Gasket Breather 51A Gasket Intake Gasket Air Cleaner (Standard, Oval) Gasket Set Valve Assemblies include all parts shown in frames. 4C 8/