Integrated Valve with Presetting for Manifolds in Two-Pipe Heating Systems

Size: px
Start display at page:

Download "Integrated Valve with Presetting for Manifolds in Two-Pipe Heating Systems"

Transcription

1 Data Sheet Integrated Valve with Presetting for Manifolds in Two-Pipe Heating Systems The integrated valve is designed for manifold applications in combination with a system connection piece. Valve and connection piece are fitted to top and bottom of manifolds with ½ connections. Product The valve has RA 2000 connection for Danfoss sensors and TWA thermal actuators. The valve features an integrated presetting of max. flow, which allows each heating circuit to be balanced independantly. Flow capacity is designed for conventional twopipe heating systems. The valve is mounted in the return flow. Application Floor heating manifold with integrated valve 013G0376 and TWA thermal actuator in return flow. Code Nos. and Technical Data Part Integrated valve with RA 2000 connection Spare part: Gland seal, 10 pcs/pack Connection thread G½A Danfoss Heating Solutions Max. water temp. C 120 VDTVV202 Code no. 013G G0290 Differential pressure 1) Test press. Work. press. Code no. Rec. Tech bar bar bar bar G0376 Danfoss 03/2011 1

2 Presetting k v -value 2) 3) k N N vs 1) The technical differential pressure indicates the upper limit for a proper valve function. In most twopipe systems the recommended differential pressure is sufficient. In order to achieve a noiseless function we recommend in smaller systems to apply automatic bypass valves or automatic balancing valves. If pump differential pressure exceeds the recommended max. valve differential pressure it is recommended that an automatic balancing valve type ASV-P/PV is added to the system. 2) The k v -values indicate the flow volume (Q) in m³/h at a pressure loss ( p) across the valve of 1 bar;. At setting N, the k v -value in accordance with EN 215 can be stated as X p = 2 K. At lower preset values, X p will be reduced until approximately X p 0.5 at presetting 1. The table shows the average measured values for integrated valves with radiator. The k vs -values indicate the valve capacity, when the valve is fully open. Design and Dimensions Integrated valve 013G VDTVV202 Danfoss 03/2011 Danfoss Heating Solutions

3 Manifold design and tolerances Presetting Presetting range 2. Factory setting and one-pipe system 3. Reference mark The presetting values of the integrated valves can be adjusted easily and accurately without the use of tools (factory setting: N ): Remove the protective cap or the thermostatic sensor Find the reference mark Turn the setting ring until the desired presetting number aligns with the reference mark. Presetting can be selected within the range of 1 to 7. At setting N the valve is fully open. Setting in the shaded areas of the drawing should be avoided. Setting N is used when flushing the system. When the sensor or the actuator is fitted, the presetting is hidden and thus protected against unintended alteration. Danfoss Heating Solutions VDTVV202 Danfoss 03/2011 3

4 Materials in Contact with Water Valve body Ms 58 Valve seat Ms 58 Throttle nozzle PPS Setting ring PBT O-rings NBR / EPDM Valve spindle PPS Valve cone NBR Pressure pin and valve spring Chrome steel To avoid calcification and corrosion, it is important for the composition of the circulating water to comply with the VDI 2035 guidelines. Capacities without Manifold 013G0376 Capacities at X p = 2K measured without radiator and connection fittings. 4 VDTVV202 Danfoss 03/2011 Danfoss Heating Solutions

5 Mounting Thread G ½ A 2. Protection cap thread 3. Setting ring Fit valve in manifold and tighten by hand. Tighten to 30 Nm using a 12-edge ring spanner, KW 21. Danfoss Heating Solutions VDTVV202 Danfoss 03/2011 5

6 6 VDTVV202 Danfoss 03/2011 Danfoss Heating Solutions

7 Danfoss Heating Solutions VDTVV202 Danfoss 03/2011 7

8 Danfoss A/S Heating Solutions Haarupvaenget Silkeborg Denmark Phone: Fax: Danfoss can accept no responsibility for possible errors in catalogues, brochures and other printed material. Danfoss reserves the right to alter its products without notice. This also applies to products already on order provided that such alterations can be made without subsequential changes being necessary in specifications already agreed. All trademarks in this material are property of the respective companies. Danfoss and the Danfoss logotype are trademarks of Danfoss A/S. All rights reserved. 8 VDTVV202 Danfoss 03/2011 Danfoss Heating Solutions

Integrated Presetting Valves for Normal (013G0380) and Small (013G0381) Volume Flows

Integrated Presetting Valves for Normal (013G0380) and Small (013G0381) Volume Flows Integrated Presetting Valves for Normal (013G0380) and Small (013G0381) Volume Flows Application Integrated valves, type RA-N (013G0380) and RA- U (013G0381), with built-in presetting are designed for

More information

Integrated Presetting Valves - for Normal Volume Flows RA-N and for Small Volume Flows RA-U

Integrated Presetting Valves - for Normal Volume Flows RA-N and for Small Volume Flows RA-U Integrated Presetting Valves - for Normal Volume Flows RA-N and for Small Volume Flows Application RA-N 013G7382 013G7387 Integrated valves, type RA-N 013G7382 and 013G7387, with built-in presetting are

More information

High Capacity Valve Body, Type RA-G

High Capacity Valve Body, Type RA-G Data Sheet The RA-G valves are fitted with a grey protective cap. This protective cap must not be used as a manual shut off device. A special manual shut off device is available (code no. 013G3300). Application

More information

Valve bodies type RA-N with integrated presetting

Valve bodies type RA-N with integrated presetting Data Sheet Application Straight version Angle version Left mounted angle version Horizontal angle version All RA-N valve bodies can be used together with all types of thermostatic elements in the RA 2000

More information

RA-N Valve Bodies with Pressfit Connection and Self-Sealing Tailpiece for Two Pipe Systems

RA-N Valve Bodies with Pressfit Connection and Self-Sealing Tailpiece for Two Pipe Systems Data Sheet RA-N Valve Bodies with Pressfit Connection and Self-Sealing Tailpiece for Two Pipe Systems Application Straight Angle The valve bodies with pressfit connection are used for heating systems with

More information

Dynamic Valve Type RA-DV Pressure Independent Radiator Valve

Dynamic Valve Type RA-DV Pressure Independent Radiator Valve Dynamic Valve Type RA-DV Pressure Independent Radiator Valve Application RA-DV straight version RA-DV angle version RA-DV angle Right & Left RA-DV UK (Axial) RA-DV is a series of pressure independent radiator

More information

Floor heating system, heating circuit with FHV-A in flow.

Floor heating system, heating circuit with FHV-A in flow. Application FHV control valves are ideally suited for controlling the temperature of individual under-floor heated rooms and for systems using floor-heating in conjunction with radiators. Danfoss offers

More information

High capacity valve body, type RA-G

High capacity valve body, type RA-G Application The RA-G valves are fitted with a grey protective cap. This protective cap must not be used as a manual shut off device. A special manual shut off device is available (code no. 013G3300). The

More information

X-tra Collection for designer radiators and bathroom towel rails

X-tra Collection for designer radiators and bathroom towel rails and bathroom towel rails Application The new X-tra Collection is a TRV specially designed for towel rails and designer radiators. Its new and innovative self-sealing ½" valve to radiator connection makes

More information

Premounted Midi Shunts

Premounted Midi Shunts Application Midi Shunt 088U0181 - with one circuit Midi Shunt 088U0182 - with two circuits Midi Shunt 088U0183 - with three circuits The Danfoss floor heating midi shunt is a series of pre-mounted shunts

More information

Integrated valves Series 3

Integrated valves Series 3 Series 3 Application For decades, Danfoss has been the world s leading manufacturer of radiator valves and radiator thermostats. Danfoss invented the radiator thermostat back in 1943 and later developed

More information

FHV control valves are flexible to use, easily installed and are available in two versions:

FHV control valves are flexible to use, easily installed and are available in two versions: FHV-A/FHV-R Application: FHV-A FHV-R The floor-heating valve (FHV) provides an economical method of incorporating a radiant floor heating system into an existing hot water or radiator system. FHV self-acting

More information

Combined automatic balancing valve AB-PM valve DN 10-32, PN 16

Combined automatic balancing valve AB-PM valve DN 10-32, PN 16 Data sheet Combined automatic balancing valve AB-PM valve DN 10-32, PN 16 Description AB-PM is a combined automatic balancing valve. It features three function in compact valve body: 1. Differential pressure

More information

SSM Floor Heating Manifold

SSM Floor Heating Manifold Application The manifold consists of a supply and return manifold. The supply manifold includes possibility for individual shut-off of each circuit on flowmeter or shut-off valve. The return manifold is

More information

Actuator type ABNM with Theft Protection, 0-10 V Proportional

Actuator type ABNM with Theft Protection, 0-10 V Proportional Actuator type ABNM with Theft Protection, 0-10 V Proportional Application The ABNM actuator is a thermoelectric actuator for opening and closing valves in the fields of heating, ventilation and air conditioning

More information

Automatic balancing valves ASV-PV DN (3rd gen.)

Automatic balancing valves ASV-PV DN (3rd gen.) Automatic balancing valves ASV-PV DN 50-100 (3rd gen.) Description / Application Partner valve ASV-PV DN 50 ASV-PV DN 65-100 MSV-F2 DN 50-100 ASV balancing valves are used for dynamic hydronic balance

More information

Flow-compensated temperature controller AVTQ DN 15

Flow-compensated temperature controller AVTQ DN 15 Data sheet Flow-compensated temperature controller AVTQ DN 15 Description AVTQ is a self-acting flow-compensated temperature controller primarily for use in district heating systems with plate heat exchangers

More information

X-tra Collection for designer radiators and bathroom towel rails

X-tra Collection for designer radiators and bathroom towel rails and bathroom towel rails Application The new X-tra Collection is a TRV specially designed for towel rails and designer radiators. Its new and innovative self-sealing ½" valve to radiator connection makes

More information

Manual presetting valve MSV-C

Manual presetting valve MSV-C Description / Application MSV-C is used for balancing the flow in cooling, heating and domestic water systems. MSV-C is a combined manual presetting valve with following features: Fixed measurement orifice.

More information

Pressure relief controller AVA (PN 25)

Pressure relief controller AVA (PN 25) Data sheet Pressure relief controller AVA (PN 25) Description AVA is a self-acting pressure relief controller primarily for use in district heating systems. The controller is normally closed and opens

More information

Pressure relief controller AFA / VFG 2(1) (PN 16, 25, 40)

Pressure relief controller AFA / VFG 2(1) (PN 16, 25, 40) Data sheet Pressure relief controller AFA / VFG 2(1) (PN 16, 25, 40) Description The controller is a self-acting pressure relief controller primarily for use in district heating systems. The controller

More information

The valves can be controlled electronically by thermal actuators or act as self-acting units by means of remote temperature adjusters.

The valves can be controlled electronically by thermal actuators or act as self-acting units by means of remote temperature adjusters. Floor Heating Manifold FHF Application The Manifold FHF is used for controlling water flow in under floor heating systems. Each tube of the floor heating system is connected to the manifold, thus making

More information

Manual presetting valves LENO MSV-BD

Manual presetting valves LENO MSV-BD Manual presetting valves LENO MSV-BD Description LENO MSV-BD is a range of manual valves for balancing flow in heating, cooling and domestic hot water systems. LENO MSV-BD is a combined presetting and

More information

Horizontal Distribution Units - HDU Multi-port

Horizontal Distribution Units - HDU Multi-port Application Danfoss pre-fabricated HDU distribution units are made for distribution and measuring of waterbased heating in 2-pipe horizontal systems. A HDU is easily mounted on the apartment wall and connected

More information

Temperature controller AVT with safety temperature monitor STM/VG(F) (PN25)

Temperature controller AVT with safety temperature monitor STM/VG(F) (PN25) Data sheet Temperature controller AVT with safety temperature monitor STM/VG(F) (PN25) Description Controller closes on rising temperature. TR1240 The controllers are: Type-tested acc. to EN 14597 and

More information

Changing pistons APP 21-43

Changing pistons APP 21-43 MAKING MODERN LIVING POSSIBLE Instruction Changing pistons APP 21-43 ro-solutions.com Contents 1. Disassembling...3 2. Assembling...6 3. When should the pistons be replaced....8 4. Parts list for APP 21-38....9

More information

Valve bodies with pressfit connection and self-sealing tailpiece. Type RA-N for two pipe systems

Valve bodies with pressfit connection and self-sealing tailpiece. Type RA-N for two pipe systems Valve bodies with pressfit connection and self-sealing tailpiece. Type RA-N for two pipe systems EN 215 Application Straight Angle Horizontal angle The valve bodies with pressfit connection are used for

More information

Two- and three way valves VFG.. / VFGS 2 / VFU.. for self-acting thermostats and electrical actuators

Two- and three way valves VFG.. / VFGS 2 / VFU.. for self-acting thermostats and electrical actuators for self-acting thermostats and electrical actuators Description VFG 2 VFG 21 (see pages 2, 3, 4) Valves for heating, district heating and cooling systems. The valves can be used with following actuators:

More information

Pressure independent control valve with integrated flow limiter AVQM (PN 16) - return and flow mounting

Pressure independent control valve with integrated flow limiter AVQM (PN 16) - return and flow mounting Data sheet Pressure independent control valve with integrated flow limiter AVQM (PN 16) - return and flow mounting Description Controllers are used together with Danfoss electrical actuators: AMV 0 1)

More information

Changing pistons APP and APP 16-22

Changing pistons APP and APP 16-22 MAKING MODERN LIVING POSSIBLE Instruction Changing pistons APP 11-13 and APP 16-22 ro-solutions.com Contents 1. Disassembling...3 2. Assembling...5 3. When should the pistons be replaced?....7 This document

More information

Manual Presetting Valves LENO MSV-B

Manual Presetting Valves LENO MSV-B Data Sheet Description LENO MSV-B is a new generation of manual valves for balancing flow in heating, cooling and domestic hot water systems. LENO MSV-B is a combined presetting and shut off valve with

More information

Flow controller with integrated control valve (PN 16) AHQM - return and flow mounting

Flow controller with integrated control valve (PN 16) AHQM - return and flow mounting Flow controller with integrated control valve (PN 16) AHQM - return and flow mounting Description Controllers are used together with Danfoss electrical actuators: DN 15-32 with - AMV(E) 10 - AMV(E) 13

More information

Pressure reduction controllers (PN 25) AVDS - for steam AVD - for water

Pressure reduction controllers (PN 25) AVDS - for steam AVD - for water Data sheet Pressure reduction controllers (PN 25) - for steam AVD - for water Description Main data AVD: DN 15-50 k VS 0,4-25 m 3 /h PN 25 Setting range: 1-5 bar / 3-12 bar Temperature: - Circulation water/glycolic

More information

Combined automatic balancing valve AB-PM valve DN 15-25, PN 16

Combined automatic balancing valve AB-PM valve DN 15-25, PN 16 Data sheet Combined automatic balancing valve AB-PM valve DN 15-25, PN 16 Description AB-PM is a combined automatic balancing valve. It features three function in compact valve body: 1. Differential pressure

More information

Pre-Fabricated Flushing Bypass Assembly for Plant Applications Hero Plant DN15-150

Pre-Fabricated Flushing Bypass Assembly for Plant Applications Hero Plant DN15-150 Pre-Fabricated Flushing Bypass Assembly for Plant Applications Description Hero Plant is a pre-fabricated, flushing bypass arrangement for balance, control, isolation, and operation of plant devices. Flow

More information

Disassembling and assembling isave 21

Disassembling and assembling isave 21 MAKING MODERN LIVING POSSIBLE Service instruction Disassembling and assembling isave 21 isave.danfoss.com Table of Contents 1. General introduction....2 2. Disassembling the isave....3 3. Disassembling

More information

Servo-operated 2/2-way solenoid valves with isolating diaphragm Type EV222B

Servo-operated 2/2-way solenoid valves with isolating diaphragm Type EV222B Data sheet Servo-operated 2/2-way solenoid valves with isolating diaphragm Type EV222B EV222B is an indirect servo-operated solenoid valve programme for use in connection with contaminated or aggressive

More information

Duct System for Danfoss Air Units

Duct System for Danfoss Air Units MAKING MODERN LIVING POSSIBLE Installation Guide for Danfoss Air Units www.heating.danfoss.com Danfoss A/S is not liable or bound by warranty if these instructions are not adhered to during installation

More information

Premounted Midi Shunts

Premounted Midi Shunts Application Midi Shunt 088U0181 - with one circuit Midi Shunt 088U0182 - with two circuits Midi Shunt 088U0183 - with three circuits The Danfoss floor heating midi shunt is a series of pre-mounted shunts

More information

Disassembling and assembling PAH , PAHT and PAHT G

Disassembling and assembling PAH , PAHT and PAHT G MAKING MODERN LIVING POSSIBLE Instruction Disassembling and assembling PAH 10-12.5, PAHT 10-12.5 and PAHT G 10-12.5 danfoss.high-pressurepumps.com Table of Contents 1. Disassembling...3 2. Inspection...7

More information

Butterfly valve with electrical actuator VFY-WA

Butterfly valve with electrical actuator VFY-WA Butterfly valve with electrical actuator Description Position indicator Torque limiter Complete installation from factory - ready for installation Features: Spline driven one piece shaft connected to spherically

More information

Butterfly valve with electrical actuator VFY-WA

Butterfly valve with electrical actuator VFY-WA Butterfly valve with electrical actuator Description Position indicator Torque limiter Complete installation from factory - ready for installation Features: Spline driven one piece shaft connected to spherically

More information

Extensions to a comprehensive product range

Extensions to a comprehensive product range Extensions to a comprehensive product range As part of our range of motorized control valves you can also find ON/OFF butterfly valves and zone valves applicable for use within heating, ventilation and

More information

Flow controller (PN 25) AVQ - return and flow mounting

Flow controller (PN 25) AVQ - return and flow mounting Data sheet Flow controller (PN 5) - return and flow mounting Description is a self-acting flow controller primarily for use in district heating systems. The controller closes when set max. flow is exceeded.

More information

SonoSensor 30 Ultrasonic flow sensor

SonoSensor 30 Ultrasonic flow sensor Data Sheet SonoSensor 30 Ultrasonic flow sensor Description MID examination certificate no.: LT-1621- MI004-030 SonoSensor 30 is an ultrasonic flow sensor especially designed for heating, cooling or combined

More information

ChangeOver6 and NovoCon ChangeOver6 - Motorized 6-port Ball Valves

ChangeOver6 and NovoCon ChangeOver6 - Motorized 6-port Ball Valves - Motorized 6-port Ball Valves Description NovoCon The and NovoCon are 6-port motorized ball valves that performs a diverting function between two water circuits in 4-pipe changeover system. This diverting

More information

ON/OFF zone valves AMZ 112, AMZ 113

ON/OFF zone valves AMZ 112, AMZ 113 Data sheet ON/OFF zone valves AMZ 112, AMZ 113 Description The ON/OFF zone valves type AMZ 112 and AMZ 113 are typical used in connection with: Domestic and commercial central heating applications Domestic

More information

INSTRUCTIONS Servicing PAH

INSTRUCTIONS Servicing PAH INSTRUCTIONS Servicing PAH 10-12.5 180R9095 Note: Dismantling: If the pump is dismantled during the warranty period, the pump is no longer under warranty. 180R9095 1. Tools required for dismantling the

More information

Control Card VLT FC Series

Control Card VLT FC Series These instructions describe the replacement of the control card in: VLT HVAC Drive FC 102. VLT Refrigeration Drive FC 103. VLT AQUA Drive FC 202. VLT AutomationDrive FC 301/FC 302. VLT Lift Drive LD 302.

More information

APP S pumps APP S / APP S / APP S 21-38

APP S pumps APP S / APP S / APP S 21-38 MAKING MODERN LIVING POSSIBLE Instruction APP S 2.0-3.5 / APP S 5.1-9.0 / APP S 21-38 ro-solutions.com Instruction Table of Contents 1. Identification...2 2. System design...3 2.1 Open system design...3

More information

Lockshield valves with Pressfit connection Type RLV with isulation and regulation

Lockshield valves with Pressfit connection Type RLV with isulation and regulation Data sheet Lockshield valves with Pressfit connection Type RLV with isulation and regulation Application RLV Straight pattern RLV Angle pattern Drain-cock The valve bodies with pressfit connection are

More information

3 & 4-Way Rotary Valves

3 & 4-Way Rotary Valves Applications: 3-way Valve 4-way Valve The ESBE 3 and 4-Way rotary valves type F are designed for mixing or diverting applications on heating and cooling systems. The valves are capable of controlling and

More information

MAKING MODERN LIVING POSSIBLE. Product overview. . Energy efficient. Reliable. Very long service intervals HIGH-PRESSURE SYSTEMS

MAKING MODERN LIVING POSSIBLE. Product overview. . Energy efficient. Reliable. Very long service intervals HIGH-PRESSURE SYSTEMS MAKING MODERN LIVING POSSIBLE Product overview. Energy efficient. Reliable. Very long service intervals HIGH-PRESSURE SYSTEMS Application examples: Fire fighting: Using high-pressure water mist for fire

More information

R134a R134a R13. 4a R134a R134a R134

R134a R134a R13. 4a R134a R134a R134 Product Information Compressors for Refrigerant R134a 12-24 olt Direct Current Compressors a R R134a R 34a R134a R1 R134a R134a R13 4a R134a R134a R134 R134a R134a R134a R134a 34a R134a R134a R134a R134a

More information

TDU.3 floor distribution unit SK

TDU.3 floor distribution unit SK SK General description and application The is intended for two pipe horizontal heating systems and includes connecting, measuring, regulating and distribution functions. The TDU.3 is easily installed on

More information

Oil pump type RSA. Catalogue 1. Burner Components

Oil pump type RSA. Catalogue 1. Burner Components Burner Components Catalogue 1 Contents Application... page 2 Construction... page 3 Function... page 4 Technical data... page 6 Capacity and operating torque RSA 28... page 7 Capacity and operating torque

More information

CI-tronic Soft starters for Danfoss commercial compressor applications Type MCI 15C, MCI 25C, MCI 50CM-3 I-O

CI-tronic Soft starters for Danfoss commercial compressor applications Type MCI 15C, MCI 25C, MCI 50CM-3 I-O Data sheet CI-tronic Soft starters for Danfoss commercial compressor applications Type, MCI 25C, MCI 50CM-3 I-O The MCI compressor soft starters are designed for soft starting of 3 phase compressors. During

More information

Assisted lift operated 2/2-way solenoid valves Type EV251B

Assisted lift operated 2/2-way solenoid valves Type EV251B Data sheet Assisted lift operated 2/2-way solenoid valves Type EV251B EV251B with assisted lift is especially suitable for applications such as closed systems with low and fluctuating pressure conditions

More information

Installation Guide. DEVIreg 527. Electronic Time Regulator.

Installation Guide. DEVIreg 527. Electronic Time Regulator. DEVIreg 527 Electronic Time Regulator www.devi.com Table of Contents DEVIreg 527 1 Introduction..................... 2 1.1 Technical Specifications........... 3 1.2 Safety Instructions............... 4

More information

Actuator ABNM A V Proportional For Use with RA2000 Valves

Actuator ABNM A V Proportional For Use with RA2000 Valves Actuator ABNM A5 0-10 V Proportional For Use with RA2000 Valves Application First-Open function (NC versions) Compact size, small dimensions 24V AC power source Position indicator Noiseless and maintenance-free

More information

Reliable season change

Reliable season change New perspectives with Danfoss Saginomiya 4 - Way Reversing Valves Reliable season change, VHV 4-way reversing valves Wide application range - complete capacity range - available for all common refrigerants

More information

SonoSelect and SonoSafe energy meters

SonoSelect and SonoSafe energy meters energy meters 01/2016 Danfoss VUIGB202 1 2 Danfoss Energy Meters 2016.01 VUIGB202 Contents 1. Inside the box... 4 2. Installation..............................................................................

More information

Starting Torque Limiter Type TCI (Soft Start)

Starting Torque Limiter Type TCI (Soft Start) Data sheet Starting Torque Limiter Type TCI (Soft Start) Starting Torque Limiters are designed for the soft starting of single and tree phase AC motors. The controller allows smooth starting of all AC

More information

When ordering, please state type and code number. Suitable sensor length. Max. Cap. range. tube adjust- see also Accessories. sensor. temp.

When ordering, please state type and code number. Suitable sensor length. Max. Cap. range. tube adjust- see also Accessories. sensor. temp. Thermostats Description KPS thermostats are temperature-controlled switches. The position of the contacts depends on the temperature of the sensor and the set value. In this series, special attention has

More information

SonoSensor 30 Ultrasonic flow meter for heating and cooling applications

SonoSensor 30 Ultrasonic flow meter for heating and cooling applications Installation & User Guide SonoSensor 30 Ultrasonic flow meter for heating and cooling applications 03/2017 Danfoss VDIGK202 www.heating.danfoss.com 1 Note! To ensure latest version of declaration, please

More information

Crankcase pressure regulator Type KVL

Crankcase pressure regulator Type KVL Data sheet Crankcase pressure regulator KVL Crankcase pressure regulator type KVL is fitted in the suction line ahead of the compressor. KVL protects the compressor motor against overload during start-up

More information

Installation Guide. VLT Real-time Clock MCB 117 VLT HVAC Drive FC 102, VLT Refrigeration Drive FC 103, VLT AQUA Drive FC 202, VLT AutomationDrive

Installation Guide. VLT Real-time Clock MCB 117 VLT HVAC Drive FC 102, VLT Refrigeration Drive FC 103, VLT AQUA Drive FC 202, VLT AutomationDrive Installation Guide VLT Real-time Clock MCB 117 VLT HVAC Drive FC 102, VLT Refrigeration Drive FC 103, VLT AQUA Drive FC 202, VLT AutomationDrive FC 301/FC 302 Installation Guide VLT Real-time Clock MCB

More information

50% Raise your efficiency to a higher level. Equipped for silence and top performance. Optyma Plus TM New Generation

50% Raise your efficiency to a higher level. Equipped for silence and top performance.  Optyma Plus TM New Generation Optyma Plus TM New Generation Raise your efficiency to a higher level. Equipped for silence and top performance. Range extension for a complete offer: 0.6-16.5 kw for MBP refrigeration 0.7-9.6 kw for LBP

More information

3/2-Way Zone-Drain-Valves VDHT 2E, VDHT 15E and VDHT 15EC

3/2-Way Zone-Drain-Valves VDHT 2E, VDHT 15E and VDHT 15EC Lenntech info@lenntech.com Tel. +31-152-610-900 www.lenntech.com Fax. +31-152-616-289 3/2-Way Zone-Drain-Valves VDHT 2E, VDHT 15E and VDHT 15EC danfoss.high-pressurepumps.com General information The 3/2

More information

FHF Floor Heating Manifold

FHF Floor Heating Manifold Data Sheet Application Manifold with flowmeter Manifold without flowmeter The Manifold FHF is used for controlling water flow in under floor heating systems. Each tube of the floor heating system is connected

More information

SonoSelect and SonoSafe energy meters

SonoSelect and SonoSafe energy meters energy meters 03/2017 Danfoss VUIGB602 www.heating.danfoss.com 1 Note! To ensure latest version of declaration, please visit danfoss.com. 2 Danfoss Energy Meters 2017.03 VUIGB702 Contents 1. Inside the

More information

RADIATOR VALVE ACCESSORIES

RADIATOR VALVE ACCESSORIES RADIATOR VALVES ACCESSORIES RADIATOR VALVES CONTENTS Accessories and spare parts: Presetting tools Radiator connections Other connections (FPL, FPL-PX, KOMBI - see each catalogue leaflet) Radiator unions

More information

Solenoid valve VDHT Standard BSP (British Standard Pipe)

Solenoid valve VDHT Standard BSP (British Standard Pipe) MAKING MODERN LIVING POSSIBLE Data sheet Standard BSP (British Standard Pipe) high-pressurepumps.danfoss.com Contents 1. Picture overview...3 2. Introduction...4 3. VDHT valve selection overview...4 4.

More information

Installation Instructions In-back/Out-back Cooling Kit for D5h/D6h and D7h/D8h Enclosures VLT Series FC 102, FC 202, and FC 302

Installation Instructions In-back/Out-back Cooling Kit for D5h/D6h and D7h/D8h Enclosures VLT Series FC 102, FC 202, and FC 302 In-back/Out-back Cooling Kit for D5h/D6h and D7h/D8h Enclosures VLT Series FC 102, FC 202, 1.1 Description Base plate assembly The back-channel cooling (in-back/out-back) kit is designed for the D5h/D6h

More information

Steel butterfly valves SBFV (PN 16/25)

Steel butterfly valves SBFV (PN 16/25) ata sheet Steel butterfly valves SBFV (PN 16/25) escription anfoss SBFV are high performance steel butterfly valves that together with anfoss JIP ball valves complete the family of shut off valves designed

More information

Crankcase pressure regulator Type KVL

Crankcase pressure regulator Type KVL Data sheet Crankcase KVL KVL crankcase are used to protect the compressor motor against overload experienced during startup after long off periods or just after defrost periods. They are installed in the

More information

Infocal 9 Energy calculator for heating and cooling applications

Infocal 9 Energy calculator for heating and cooling applications Installation & User Guide Infocal 9 Energy calculator for heating and cooling applications www.danfoss.com 2 Danfoss Energy Meters 2017.03 VUIGN102 1. Installation 1.1. Preparation Only qualified personnel

More information

Installation Instructions 500 A Current Sensor Kit for F1 F4/F8 F13 Enclosure Sizes VLT Series FC 102, FC 202, and FC 302

Installation Instructions 500 A Current Sensor Kit for F1 F4/F8 F13 Enclosure Sizes VLT Series FC 102, FC 202, and FC 302 1.1 Description The 500 A current sensor kit is designed for F1 F4 and F8 F13 enclosure sizes in the power ranges shown in Table 1.1. To identify the power rating, see Illustration 1.1. Product group and

More information

APP pump instruction APP 21-43

APP pump instruction APP 21-43 MAKING MODERN LIVING POSSIBLE Instruction APP pump instruction APP 21-43 ro-solutions.com Table of Contents 1. Identification...2 2. System design...3 2.1 Open-ended systems with direct water supply....3

More information

Reliable season change

Reliable season change ew perspectives with anfoss Saginomiya 4 - Way Reversing Valves Reliable season change ST, VHV 4-way reversing valves Wide application range - complete capacity range - available for all common refrigerants

More information

Nessie 3/2-Way Zone-Drain-Valves types VDM 2E, VDHT 15E, VDHT 15EC and VDH 30EC "Soft-Charge"

Nessie 3/2-Way Zone-Drain-Valves types VDM 2E, VDHT 15E, VDHT 15EC and VDH 30EC Soft-Charge Nessie 3/2-Way Zone-Drain-Valves types VDM 2E, VDHT 15E, VDHT 15EC and VDH 30EC "Soft-Charge" Generally The Nessie 3/2 way valves have in particular been designed for applications in high-pressure humidification

More information

Steering Priority Valve OLS 160

Steering Priority Valve OLS 160 MAKING MODERN LIVING POSSIBLE Service Manual Steering Priority Valve OLS 160 powersolutions.danfoss.com Revision History Table of Revisions Date Changed Rev Mar 2014 Converted to Danfoss layout - DITA

More information

The precise step to take

The precise step to take New perspectives with Danfoss Saginomiya Electronic Expansion Valves The precise step to take Type KV Electronic Expansion Valves Energy efficiency Precision flow control with high resolution Compact and

More information

MAKING MODERN LIVING POSSIBLE. Data sheet. Data sheet APP ro-solutions.com

MAKING MODERN LIVING POSSIBLE. Data sheet. Data sheet APP ro-solutions.com MAKING MODERN LIVING POSSIBLE Data sheet Data sheet APP 11-13 ro-solutions.com Table of Contents 1. Introduction...3 2. Benefits...3 3. Technical data...4 4. Variants...4 5. Flow at different rpm....5

More information

ELIMINATOR Hermetic filter drier Types DML and DCL

ELIMINATOR Hermetic filter drier Types DML and DCL Data sheet ELIMINATOR Hermetic filter drier s DML and DCL All ELIMINATOR driers have a solid core with binding material held to an absolute minimum. There are two types of ELIMINATOR cores. DML driers

More information

Capacity regulators (hot gas bypass) PMC and CVC

Capacity regulators (hot gas bypass) PMC and CVC MAKING MODERN LIVING POSSIBLE Technical brochure Capacity regulators (hot gas bypass) PMC and CVC The PMC and CVC is used for capacity regulation in refrigeration, freezing and air conditioning plant for

More information

ATEX instruction for APP / PAH PAHT G 2-90 / PAH Tech

ATEX instruction for APP / PAH PAHT G 2-90 / PAH Tech MAKING MODERN LIVING POSSIBLE Instruction ATEX instruction for APP 0.6-10.2 / PAH 2-100 PAHT G 2-90 / PAH 25-80 Tech danfoss.high-pressurepumps.com Table of Contents 1. Common demands for Category 2 and

More information

Data sheet APP

Data sheet APP MAKING MODERN LIVING POSSIBLE Data sheet Data sheet APP 0.6-1.0 ro-solutions.com Table of Contents 1. General information....2 2. Benefits...3 3. Technical data...3 4. Flow at different rpm....4 5. Flushing

More information

Maneurop reciprocating compressors MT - MTZ - NTZ

Maneurop reciprocating compressors MT - MTZ - NTZ MAKING MODERN LIVING POSSIBLE Quick reference Maneurop reciprocating compressors MT - MTZ - NTZ 60 Hz - R404A - R507A - R407C - R134a - R22 - R417A www.cc.danfoss.com Quick reference Dimensions Ø D ø

More information

Parallel coupled APP pumps

Parallel coupled APP pumps Design Guide Parallel coupled APP pumps Parallel coupled APP pumps and energy energy recovery devices recovery devices hpp.danfoss.com Table of Contents Table of Contents 1. Introduction...3 2. Preferred

More information

Danfoss Saginomiya 4 - Way Reversing Valves

Danfoss Saginomiya 4 - Way Reversing Valves New perspectives with anfoss Saginomiya - Way Reversing Valves Reliable season change ST, VHV -way reversing valves Wide application range - complete capacity range - available for all common refrigerants

More information

Data sheet. Thermostatically operated cooling water valves Type FJVA. January 2000 DKACV.PD.500.B B0033

Data sheet. Thermostatically operated cooling water valves Type FJVA. January 2000 DKACV.PD.500.B B0033 Data sheet Thermostatically operated cooling water valves January 2000 DKACV.PD.500.B1.02 520B0033 General data on thermostatically operated cooling water valves Introduction Thermostatically operated

More information

Danfoss VDHT Solenoid Valves WATER SOLUTIONS

Danfoss VDHT Solenoid Valves WATER SOLUTIONS Danfoss VDHT Solenoid Valves danfoss HIGH-PRESSURE WATER SOLUTIONS What is a Danfoss VDHT valve? Facts and benefits The VDHT solenoid valve programme consists of both single valves and manifold block solutions

More information

MAKING MODERN LIVING POSSIBLE. Data sheet. Data sheet APP ro-solutions.com

MAKING MODERN LIVING POSSIBLE. Data sheet. Data sheet APP ro-solutions.com MAKING MODERN LIVING POSSIBLE ro-solutions.com Table of Contents 1. General information..................................................................... Benefits................................................................................

More information

Installation Instructions In-bottom/Out-back Cooling Kit for E4h Drives VLT FC Series FC 102, FC 103, FC 202, and FC 302

Installation Instructions In-bottom/Out-back Cooling Kit for E4h Drives VLT FC Series FC 102, FC 103, FC 202, and FC 302 1.1 Description The in-bottom/out-back cooling kit fits the following E4h drives. It is compatible with drives mounted in Rittal TS8 800 mm (32 in) cabinets. VLT HVAC Drive FC 102 VLT Refrigeration Drive

More information

V2880, Therafix Design Thera Design Edition - H-Block with TRV Insert WITH HIGH QUALITY SURFACE FOR DESIGN RADIATORS

V2880, Therafix Design Thera Design Edition - H-Block with TRV Insert WITH HIGH QUALITY SURFACE FOR DESIGN RADIATORS W GE R MAN Y W GE R MAN Y V2880, Therafix Design Thera Design Edition - H-Block with TRV Insert WITH HIGH QUALITY SURFACE FOR DESIGN RADIATORS Design Angle left Straight W GE R MAN Y Angle right The Therafix

More information

Installation Instructions Bus Bar Kit for 6-pulse, 4-drive System VLT Series FC 102, FC 202, and FC 302. Description. Kit Part Number.

Installation Instructions Bus Bar Kit for 6-pulse, 4-drive System VLT Series FC 102, FC 202, and FC 302. Description. Kit Part Number. Description The bus bar kit is designed for the specific VLT HVAC Drive FC 102, VLT AQUA Drive FC 202, and VLT AutomationDrive FC 302 D4h-size VLT Parallel Drive Modules mounted in a Rittal TS8 enclosure.

More information

ATEX instruction APP S 674 pumps APP S , APP S and APP S

ATEX instruction APP S 674 pumps APP S , APP S and APP S MAKING MODERN LIVING POSSIBLE Instruction APP S 674 2.0-3.5, APP S 674 5.1-9.0 and APP S 674 21-38 ro-solutions.com Table of Contents 1. General information....2 2. Common demands for Category 2 and 3

More information

PAH / PAHT / PAHT G pumps

PAH / PAHT / PAHT G pumps Lenntech info@lenntech.com Tel. +31-152-610-900 www.lenntech.com Fax. +31-152-616-289 Instruction PAH / PAHT / PAHT G 10-12.5 pumps Instruction Pump instruction PAH / PAHT / PAHT G 10-12.5 Table of Contents

More information

APP pump instruction APP and APP 16-22

APP pump instruction APP and APP 16-22 MAKING MODERN LIVING POSSIBLE Instruction APP pump instruction APP 11-13 and APP 16-22 www.ro-solutions.com Table of Contents 1. Identification...2 2. System design...3 2.1 Open-ended systems with direct

More information