SAG Cover.qxd 6/14/05 2:30 AM Page 1 SP0375
|
|
- Gavin Henderson
- 5 years ago
- Views:
Transcription
1 SP0375
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Œ &RS\ULJKW 9ROYR &DUV RI 1RUWK $PHULFD //&
3 Contents Engine Detail...3 Engine Air Intake...4 Exhaust-Driven Turbocharger...5 Exhaust System...6 Engine Cooling and Cabin Heating...7 Air Conditioning...8 Leakage Detection System... 9 Automatic Transmission Drive Train Drive Train - All Wheel Drive Power Steering Braking System ABS & Stability Traction Control (STC) Dynamic Stability Traction Control (DSTC) Front Suspension Rear Suspension Wheel Alignment and Tire Wear Supplemental Restraint System Starting and Charging Index of 22
4 Valve and Lifter Engine Detail Exhaust-Driven Turbocharger Upper Engine Mount Piston Head Gasket Manifold Gasket Oil Filter Timing Belt Dual Camshafts Water Pump 3 of 22
5 Engine Air Intake Air to Turbochargers Air Hoses to Turbochargers Intercooler Air Intake Engine Air Filter Housing Mass Airflow Sensor (MAF) 4 of 22
6 Exhaust-Driven Turbocharger Heated Oxygen Sensors Turbocharger Catalytic Converters Turbocharger 5 of 22
7 Exhaust System Resonator Heated Oxygen Sensor Muffler Catalytic Converter 6 of 22
8 Engine Cooling and Cabin Heating Coolant Expansion Tank and Filling Point Cabin Heater Core Radiator 7 of 22
9 Air Conditioning Expansion Valve Climate Controls Service Valve Pressure Sensor Compressor In-Car Temperature Sensor Evaporator Receiver Condenser 8 of 22
10 Leakage Detection System Purge Valve Evaporative Vent Container-Close Valve Oil Trap Pressure Sensor Evaporative Fuel Canister 9 of 22
11 Automatic Transmission Transmission Position Sensor Pressure Control Solenoid Shift Solenoids 10 of 22
12 Drive Train Drive Axle CV Joints and Boots Automatic Transmission Shifter Assembly Differential Transmission Oil Cooler Automatic Transmission 11 of 22
13 Drive Train - All Wheel Drive Drive Shaft AWD Differential AWD Angle Gear Drive Shaft AWD Coupling CV Joints and Boots Automatic Transmission Shifter Assembly Automatic Transmission 12 of 22
14 Power Steering Power Steering Pump Fluid Reservoir Pinion Boot Tie-Rod End Ball Joint Rack 13 of 22
15 Parking Brake Lever and Cables Braking System Hydraulic Brake Line Fluid Reservoir Booster Master Cylinder ABS Control Module/ Brake Control Module Disc (Rotor) Caliper Anti-Rattle Spring Pads 14 of 22
16 ABS & Stability Traction Control (STC) Engine Control Module ABS Control Module 15 of 22
17 Dynamic Stability Traction Control (DSTC) Engine Control Module DSTC Brake Booster Yaw Sensor Lateral Acceleration Sensor Yaw Sensor Brake Pressure Sensors DSTC Control Module Brake Pedal Position Sensor Steering Angle Sensor (SAS) SAS Control Module 16 of 22
18 Front Suspension Spring Strut/Shock Absorber Anti-Sway Bar and Upper End Link Wheel Hub and Bearing Assembly Lower Ball Joint Engine Subframe Lower Control Arm 17 of 22
19 Rear Suspension Upper Control Arm Shock Absorber Knuckle Coil Spring Lower Control Arm Wheel Hub and Bearing Assembly Trailing Arm Bushing Trailing Arm 18 of 22
20 Wheel Alignment and Tire Wear Wear Bars Overinflation Underinflation Negative Caster Positive Caster Excess Toe In or Out Toe Out Toe In Over or Under Cambered Negative Camber Positive Camber of of 22 22
21 Supplemental Restraint System Convertible ROPS Rollover Protection Control Module Seat Belt Tensioner Inflatable Curtain Rollover Protection Cassette Side Crash Sensor Passenger s Front Airbag Driver s Front Airbag Frontal Crash Sensor Seat Frame Side Airbag Side Crash Sensor 20 of 22
22 Starting and Charging Alternator Ignition Switch Instrument Panel Charging System Light Engine Control Module Battery Alternator Drive Belt Starter Motor Fuses Engine Bay Battery + Connector for Jump Starting Fuses Under Dash Fuses and Rear Electrical Module 21 of 22
23 ABS Control Module... 14, 15 Air Hoses to Turbochargers... 4 Air Intake... 4 Air to Turbochargers... 4 Alternator Drive Belt Alternator Anti-Rattle Springs Anti-Sway Bar and Upper End Link Automatic Transmission Shifter Assembly... 11, 12 Automatic Transmission... 11, 12 AWD Angle Gear AWD Coupling AWD Differential Battery Battery+ Connector for Jump Starting Booster Boot Brake Pedal Position Sensor Brake Pressure Sensor Braking System Cabin Heater Core... 7 Caliper Catalytic Converter... 5, 6 Climate Control... 8 Coil Spring Compressor... 8 Condenser... 8 Container-Close Valve... 9 Convertible ROPS Coolant Expansion Tank and Filling Point... 7 CV Joints and Boots... 11, 12 Differential Disc (Rotor) Drive Axle Drive Shaft Driver s Front Airbag DSTC Brake Booster DSTC Control Module Dual Camshafts... 3 Engine Air Filter Housing... 4 Engine Control Module... 15, 16, 21 Engine Subframe Evaporative Fuel Canister... 9 Evaporative Vent... 9 Evaporator... 8 Excess Toe In or Out Exhaust-Driven Turbocharger... 3 Index Expansion Valve... 8 Fluid Reservoir... 13, 14 Front Suspension Lower Ball Joint Front Susupension Lower Control Arm Frontal Crash Sensor Fuses and Rear Electrical Module Fuses Engine Bay Fuses Under Dash Head Gasket... 3 Heated Oxygen Sensor... 5, 6 Hydraulic Brake Line Ignition Switch In-Car Temperature Sensor... 8 Inflatable Curtain Instrument Panel Charging System Light Intercooler... 4 Knuckle Lateral Acceleration Sensor Manifold Gasket... 3 Mass Airflow Sensor (MAF)... 4 Master Cylinder Muffler... 6 Negative Camber Negative Caster Oil Filter... 3 Oil Trap... 9 Over Inflation Over or Under Cambered Pads Parking Brake Lever and Cable Passenger s Front Airbag Pinion Piston... 3 Positive Camber Positive Caster Power Steering Pump Pressure Control Solenoids Pressure Sensor... 8, 9 Purge Valve... 9 Rack Radiator... 7 Rear Suspension Lower Control Arm Rear Suspension Upper Control Arm Receiver... 8 Resonator... 6 Rollover Protection Cassette Rollover Protection Control Module SAS Control Module Seat Belt Tensioner Seat Frame Service Valve... 8 Shift Solenoids Shock Absorber Side Airbag Side Crash Sensor Spring Strut/Shock Absorber Starter Motor Steering Angle Sensor (SAS) Tie-Rod End Ball Joint Timing Belt... 3 Toe In Toe Out Trailing Arm Bushing Trailing Arm Transmission Oil Cooler Transmission Position Sensor Turbocharger... 5 Under Inflation Upper Engine Mount... 3 Valve and Lifter... 3 Water Pump... 3 Wear Bars Wheel Alignment and Tire Wear Wheel Hub and Bearing Assembly... 17, 18 Yaw Sensor of 22
Drawing Page Drawing Page
Contents Drawing Page Drawing Page L4 Engine...1 L4 Engine - Exploded View...2 V6 Engine...3 V6 Engine - Exploded View... 4 Oil Filter...5 VTEC (Variable Timing Electronic Control) System... 6 Fuel and
More informationAcura Plus Comprehensive & Major Component Coverage
Acura Plus Comprehensive & Major Component Coverage ENGINE Cylinder block and all internal parts Cylinder heads and all internal parts Engine mounts Engine seals and gaskets Flywheel Intake and exhaust
More informationSOUL GDI REPAIR AND MAINTENANCE
SOUL 2013-1.6 GDI REPAIR AND MAINTENANCE (First Numbers are page number within section - Numbers in parenthesis are overall document page) GENERAL INFORMATION (23 PAGES) 01-07 (01-07): Identification Number
More informationLINCOLN. Continental 1
3154_U01.qxd 8/1/03 7:28 AM Page 1 Continental 1 BRAKES...1-27 DRIVE TRAIN...1-21 ENGINE REPAIR...1-7 FUEL SYSTEM...1-20 PRECAUTIONS...1-7 SPECIFICATION CHARTS...1-2 STEERING AND SUSPENSION...1-22 A Air
More informationTorque Specifications for 2003 Hyundai Tiburon (GK) 2.7L DOHC
Torque Specifications for 2003 Hyundai Tiburon (GK) 2.7L DOHC Engine Mechanical System Camshaft sprocket bolt 90 ~ 110 900 ~ 1,100 65 ~ 80 Cylinder head cover bolt 8 ~ 10 80 ~ 100 5.8 ~ 7.2 Main bearing
More informationWE JUST MADE YOUR DRIVE A LITTLE MORE RELAXING. THE ENHANCED COVERAGE FOR YOUR BMW CPO VEHICLE.
WE JUST MADE YOUR DRIVE A LITTLE MORE RELAXING. Introducing THE CERTIFIED PRE-OWNED (CPO) WRAP, THE ENHANCED COVERAGE FOR YOUR BMW CPO VEHICLE. When you purchase a Certified Pre-Owned BMW, you look forward
More informationPART - RETAIL SHOP C900 DAVID'S [78-94] 9000 PRICE [84-98] LIST NG900 [94-98] OG9-3 [99-03] 9-3SS [03-11] A/C Compressor
PART - RETAIL SHOP C900 DAVID'S [78-94] 9000 PRICE [84-98] LIST NG900 [94-98] OG9-3 [99-03] 9-3SS [03-11] A/C Compressor 150-250 150-250 150-250 150-250 150-250 A/C Condensor A/C Miscellaneous Parts A/C
More informationLEXUS EXTRA CARE GOLD. VEHICLE SERVICE AGREEMENT offered by LEXUS FINANCIAL SERVICES
LEXUS EXTRA CARE GOLD VEHICLE SERVICE AGREEMENT offered by LEXUS FINANCIAL SERVICES DRIVE WITH CONFIDENCE KNOWING YOU ARE PROTECTED BY LEXUS EXTRA CARE. Lexus Extra Care, designed with you in mind. Let
More information1 of 15 C:\Users\sny\Downloads\2019 Used Parts Price List.ods
PART - RETAIL SHOP C900 DAVID'S [78-94] 9000 PRICE [84-98] LIST NG900 [94-98] OG9-3 [99-03] 9-3SS [03-11] A/C Compressor 150-250 150-250 150-250 150-250 150-250 A/C Condensor A/C Miscellaneous Parts A/C
More informationAPPRENTICE TECHNICIAN PROGRESS LOG
APPRENTICE TECHNICIAN PROGRESS LOG APPRENTICE INRUCTIONS: At the end of each day track your progress on the attached log by including work order number and date next to each new skill you perform. Have
More informationSupercharged MK1 MR2 Part Diagrams
Supercharged MK1 MR2 Part Diagrams Created by: Charles K. (ckowalc) 1 Table of Contents PART DIAGRAM PAGE ACCELERATOR LINK 9 AIR CLEANER 10 AIR CLEANER 4AGZE 11 ALTERNATOR 4AGZE 12 ANTENNA 13 ARMREST &
More informationU.S. COMMUNITIES DISCOUNT SCHEDULE EFFECTIVE THROUGH
BATTERIES BATTERIES BATTERY ACCESSORIES CHARGERS, TERMINALS, CABLES -33% BATTERIES AUTOMOTIVE BATTERIES PREMIUM (PLATINUM) -33% BATTERIES AUTOMOTIVE BATTERIES BEST (GOLD) -33% BATTERIES AUTOMOTIVE BATTERIES
More informationWildcat X. U2013WSW1POSX - International SHARE OUR PASSION.
2013 Wildcat X Model Model Model Model Number Number Number Number U2013WSW1PUSE U2013WSW1POSE - International U2013WSW1PUSX U2013WSW1POSX - International SHARE OUR PASSION. TM TABLE OF CONTENTS (Model
More informationILLUSTRATED PARTS MANUAL
ILLUSTRATED PARTS MANUAL Wildcat X LTD Model Number U2014WTW1PUSE Model Number U2014WTW1PUSJ Model Number U2014WTW1POSE - International Model Number U2014WTW1POSJ - International TM SHARE OUR PASSION.
More information2012 NATEFAutomobile Accreditation. Maintenance & Light Repair Task List
2012 NATEFAutomobile Accreditation Maintenance & Light Repair Task List 2012 ENGINE REPAIR 2012 NATEF Automobile Accreditation Maintenance and Light Repair Task List General 1. Research applicable vehicle
More informationRevised April Unit/Standard Number. Proficiency Level Achieved: (X) Indicates Competency Achieved to Industry Proficiency Level
Secondary Task List 100 ORIENTATION 101 Explain and follow all lab rules. 102 Participate in basic shop management. 103 Participate in parts ordering. 104 Demonstrate auto shop safety and hygiene. 105
More informationAudi > B4 > Liter V6 2V Engine Mechanical, Engine Code(s): AAH, AFC 10 Engine Assembly
Audi > B4 > 1993 1995 2.8 Liter V6 2V Engine Mechanical, Engine Code(s): AAH, AFC 10 Engine Assembly Removing The engine is removed from above, after being separated from the transmission. Note: All tie
More informationProwler XTX SHARE OUR PASSION ṬM
SHARE OUR PASSION ṬM Prowler XTX Model Number U2009P3T4EUSV (Steel Blue) Model Number U2009P3T4EOSV (Steel Blue) International Model Number U2009P3T4EUSC (M4 Camo) Model Number U2009P3T4EUSQ (Black - LE)
More informationPRICE LIST ITEM PRICE $ CORE
A/C Clutch $20.00 A/C Compressor $35.00 $10.00 A/C Condenser $25.00 $5.00 A/C Evaporator $15.00 A/C Hose(S) $15.00 Accelerator Cable $10.00 Air Bag $30.00 Air Bag Sensor $10.00 Air Cleaner $15.00 Air Filter
More informationFORD, LINCOLN AND MERCURY
25813_U01.qxd 3/31/05 2:19 PM Page 1 DISC BRAKES...1-153 DRIVE TRAIN...1-89 DRUM BRAKES...1-168 ENGINE REPAIR...1-19 FRONT SUSPENSION...1-125 FUEL SYSTEM...1-79 REAR SUSPENSION...1-145 SPECIFICATIONS AND
More informationA 1 SERVICE SPECIFICATIONS
A1 A2 Clutch CLUTCH Specifications Pedal height (from asphalt sheet) Release point (from pedal stroke end position) Push rod play at pedal top Pedal freeplay Disc rivet head depth Disc runout Diaphragm
More informationDRIVE-CONTROL COMPONENTS
3-1 DRIVE-CONTROL COMPONENTS CONTENTS FRONT SUSPENSION................... 2 Lower Arms............................... 5 Strut Assemblies........................... 6 REAR SUSPENSION.....................
More informationVW/AUDI/SKODA PARTS CATALOG
PASACO INTERNATIONAL GROUP LIMITED Add: 2-1-701,WANGHUJIAYUAN,ANYANG,RUIAN,ZHEJIANG,CHINA Email: jackychzh@163.com / jackychzh@yahoo.com / pasaco@chinapasaco.com MSN: jackychzh@hotmail.com SKYPE: PASACOGROUP
More informationAutomobile/Automotive Mechanics Technology/Technician CIP Task Grid
1 100 ORIENTATION 101 Explain and follow all lab rules. 1 1 10 Participate in basic shop management. 1 1 103 Participate in parts ordering. 1 1 104 Demonstrate auto shop safety and hygiene. 1 1 105 Demonstrate
More informationAutomobile/Automotive Mechanics Technology/Technician CIP Task Grid
Secondary Task List 100 ORIENTATION 101 Explain and follow all lab rules. 102 Participate in basic shop management. 103 Participate in parts ordering. 104 Demonstrate auto shop safety and hygiene. 105
More informationProwler XTZ Model Number U2013P4W1PUSU Model Number U2013P4W1POSU - International SHARE OUR PASSION.
2013 Prowler XTZ Model Number U2013P4W1PUSU Model Number U2013P4W1POSU - International TM SHARE OUR PASSION. TABLE OF CONTENTS 2013 Prowler XTZ (Model No. U2013P4W1PUSU) (Model No. U2013P4W1POSU - International)
More information10/20/ Ford E 250 Engine Mechanical > Engine, 4.6L and 5.4L > IN VEHICLE REPAIR > Intake Manifold 5.4L
2005 Ford E 250 : Engine Mechanical > Engine, 4.6L and 5.4L > IN VEHICLE REPAIR > Intake Manifold 5.4L Intake Manifold 5.4L Listen SECTION 303 01A: Engine 4.6L and 5.4L 2005 E Series Workshop Manual IN
More informationILLUSTRATED PARTS MANUAL
ILLUSTRATED PARTS MANUAL Wildcat Trail Model Number U2014W5T2PUSG Model Number U2014W5T2PUSR Model Number U2014W5T2PUSZ Model Number U2014W5T2POSG - International Model Number U2014W5T2POSR - International
More informationVolvo S60 (-2009) Catalog
Catalog Contents Filters Air filter 8 Oil filter 9 Filter, Interior air 10 Fuel filter 11 Brakes Disc Brake Brake disc 13 Brake pad set 19 Splash panel, Brake disc 22 Accessory kit, Brake pads 22 Handbrake
More information2013 Kia Optima L4-2.0L Turbo
1 of 13 5/29/2016 11:34 AM 2013 Kia Optima L4-2.0L Turbo Vehicle» Engine, Cooling and Exhaust» Engine» Service and Repair» Removal and Replacement Removal CAUTION: Use fender covers to avoid damaging painted
More informationABS Components Air Compressors Air Dryers & Cartridges Air Tanks. Air Disc Brakes Bearings Brake Pads Brake Rotors Brake Shoes & Kits Camshafts & Kits
Air Brake Systems ABS Components Air Compressors Air Dryers & Cartridges Air Tanks Air Valves Brass Fittings Composite Fittings Coiled Air Hoses Glad Hands Nylon Tubing Rubber Hoses Tire Valves Brake &
More informationPhone: Fax: Mobile: Unit 3, 51 Berriman Drive Wangara WA 6065 CMM Automotive ABN:
Phone: 9309 2424 Fax: 9309 6309 Mobile: 0409 420 348 Unit 3, 51 Berriman Drive Wangara WA 6065 CMM Automotive ABN: 59 032 664 268 W.A 0409420348 08 93092424 Web: www.cmmautomotive.com THE ONUS OF THE VEHICLES
More information7. Remove the starter motor. Refer to Starter Motor Replacement (2.2L) or Starter Motor Replacement (4.3L).
1 of 9 1/5/2013 6:40 PM Removal Procedure 1. Disconnect the battery negative cable. Refer to Battery Replacement. 2. Remove the hood. Refer to Hood Replacement. 3. If the vehicle is equipped with a manual
More informationX4 (GREEN) (A2000ATF2AUSG) Page 1 of 80 AIR INTAKE ASSEMBLY
2000 300 2X4 (GREEN) (A2000ATF2AUSG) Page 1 of 80 AIR INTAKE ASSEMBLY 2000 300 2X4 (GREEN) (A2000ATF2AUSG) Page 2 of 80 AIR INTAKE ASSEMBLY Ref # Part Number Qty S/P/F Description 1 3570-001 1 /P Intake,
More informationFRONT RACK, BODY PANEL, AND HEADLIGHT ASSEMBLIES
FRONT RACK, BODY PANEL, AND HEADLIGHT ASSEMBLIES 0747-506 1 2506-107 1 Rack, Front - Assembly (inc. 2) 2 0411-576 1 Decal, Warning - Load 3 0441-592 4 Bushing 4 8410-835 4 Screw, Cap 5 0423-669 4 Spacer
More informationTriumph Tiger 800. Torque settings. Torque (Nm) Camshaft cover to cylinder head 10 Camshaft drive chain tensioner to head 9
Triumph Tiger 800 Torque settings Cylinder Head Camshaft cover to cylinder head 10 Camshaft drive chain tensioner to head 9 Camshaft bearing ladder to head Camshaft sprocket to camshaft 10 Camshaft drive
More informationABS Components Air Compressors Air Dryers & Cartridges Air Tanks. Air Disc Brakes Bearings Brake Pads Brake Rotors Brake Shoes & Kits Camshafts & Kits
Air Brake Systems ABS Components Air Compressors Air Dryers & Cartridges Air Tanks Air Valves Brass Fittings Composite Fittings Coiled Air Hoses Glad Hands Nylon Tubing Rubber Hose Tire Valves Brake &
More informationENGINE ASSEMBLY. COMPONENTS (Part 1)
1 of 32 ENGINE ASSEMBLY COMPONENTS (Part 1) 2 of 32 COMPONENTS (Part 2) 3 of 32 COMPONENTS (Part 3) 4 of 32 COMPONENTS (Part 4) 5 of 32 COMPONENTS (Part 5) 6 of 32 COMPONENTS (Part 6) 7 of 32 COMPONENTS
More informationDODGE RAM TRUCK - COMPLETE SERVICE_REPAIR_WORKSHOP MANUAL - PDF DOWNLOAD PAGES_BEST_!! - PDF Service Manual
1999 2000 2001 DODGE RAM 1500 2500 3500 TRUCK - COMPLETE SERVICE_REPAIR_WORKSHOP MANUAL - PDF DOWNLOAD 2800 + PAGES_BEST_!! - PDF Service Manual DOWNLOAD HERE "1999 2000 2001 DODGE RAM 1500 2500 3500 TRUCK
More information2. MEASURE VEHICLE HEIGHT. (b) Measure the vehicle height. Measurement points: C: Ground clearance of front wheel center
ADJUSTMENT If the wheel alignment has been adjusted, and if suspension or underbody components have been removed/installed or replaced, be sure to perform the following initialization procedure in order
More informationService Schedule Chevrolet Utility
1. This Service Schedule will have preference over the Owner's Manual and Warranty & Service Guide 2. Refer to the Warranty and Service Guide for Severe Driving Conditions. 3. Consult the Owner/Customer
More informationAdded Care & Added Care Plus
Added Care & Added Care Plus For Pre-Owned Vehicles passion. performance. protection. PRODUCT DESCRIPTION ADDED CARE AND ADDED CARE PLUS CONFIDENCE ASSURED For over three decades, Mopar Vehicle Protection
More informationO U R V A L U E D C U S T O M E R
O U R V A L U E D C U S T O M E R Cori Nastro Service Consultant E. Ruiz Certified Technician Y O U R V E H I C L E Year 2000 Make Chevrolet Model Corvette Engine Type 5.7L V8 G OHV (MFI) Odometer 58,837
More information400 4x4 Euro MODEL NUMBER A2008IDG4BEUR (RED) MODEL NUMBER A2008IDG4BEUG (GREEN) MODEL NUMBER A2008IDG4BEUZ (CAT GREEN) MORE TO GO ON.
2008 400 4x4 Euro Illustrated Parts Manual MODEL NUMBER A2008IDG4BEUR (RED) MODEL NUMBER A2008IDG4BEUG (GREEN) MODEL NUMBER A2008IDG4BEUZ (CAT GREEN) MORE TO GO ON. TM TABLE OF CONTENTS 2008 ATV 400 4x4
More information2017 NATEF Automobile - Maintenance and Light Repair Tasks - Auto Upkeep Correlation
2017 NATEF Automobile - Maintenance and Light Repair Tasks - Auto Upkeep Correlation Please Note: Much of the content and hands-on activities in the Auto Upkeep curriculum correlate to 2017 NATEF Automobile
More informationA SYSTEMATIC SEQUENCE FOR PM INSPECTIONS
A SYSTEMATIC SEQUENCE FOR PM INSPECTIONS TYPE OF INSPECTION UNDER THE HOOD GASOLINE AND DIESEL 1 Fuel, oil, exhaust leaks - inspect 2 Oil and fuel lines inspect for kinks and wear 3 Automatic transmission
More informationATV I l. l u. r a. Parts Manual ARCTIC CAT. 250 cc/300 cc
2000 I l l u st ATV 250 cc/300 cc Model No. A2000ATE2AUSG (250 - Green) Model No. A2000ATE2AUSR (250 - Red) Model No. A2000ATF2AUSG (300 2x4 - Green) Model No. A2000ATF2AUSR (300 2x4 - Red) Model No. A2000ATF4AUSG
More informationSUSPENSION - FRONT Toyota Celica DESCRIPTION ADJUSTMENTS & INSPECTION WHEEL ALIGNMENT SPECIFICATIONS & PROCEDURES WHEEL BEARING
SUSPENSION - FRONT 1988 Toyota Celica FRONT SUSPENSION Toyota DESCRIPTION Vehicles are equipped with front wheel drive and independent MacPherson strut front suspension. Suspension consists of vertically
More informationRobert A. Reck II 3411 Saddle Drive Hayward, CA Phone
Robert A. Reck II 3411 Saddle Drive Hayward, CA. 94541 Phone 510-7279424 Chevrolet Blazer C/K ½ Ton - 4 Wheel Drive Utility 5.7/Liter Vin # 1GNEK18K7 PJ342553 New w/700 miles 05/15/93 13,500-10/01/93 air
More informationTransmission, removing and
Page 1 of 20 34-18 Transmission, removing and installing Removing Special tools and equipment 3282 transmission support 3282/10 adjustment plate 3337 ring spanner 7-piece set VAG1383A engine/transmission
More informationIllustrated Parts Manual
Illustrated Parts Manual Model 544C-10 S/N 0255001 P/N - 91164001 Revised February 23, 2007 INTRODUCTION Table of Contents Original Issue 11-96 Revised 1-6-98 SECTION 1 INTRODUCTION Table of Contents...
More informationAutomobile/Automotive Mechanics Technology/Technician CIP Task Grid
1 100 ORIENTATION 101 Explain and follow all lab rules. 102 Participate in basic shop management. 103 Participate in parts ordering. 104 Demonstrate auto shop safety and hygiene. 105 Demonstrate the use
More informationVolvo S40 (-2004) V40
Catalog Contents Filters Air filter 8 Oil filter 9 Filter, Interior air 11 Fuel filter 12 Brakes Disc Brake Brake disc 14 Brake pad set 17 Splash panel, Brake disc 19 Handbrake Cable, Park brake 20 Brake
More informationPLAN VEHICLE THE COST OF UNEXPECTED REPAIRS FREQUENTLY ASKED QUESTIONS PACKAGE PROTECTION
Administered by GWC Warranty Corporation Showroom Level, 40 Coal Street Wilkes-Barre, PA 18702 1.800.482.7357 www.gwcwarranty.com This plan is backed by American Bankers Insurance Company of Florida (in
More informationDisconnect negative battery cable and remove coolant bottle cap.
1 of 16 3/25/2012 10:18 AM ools Required SA9105E 3-Bar Engine Support Fixture SA9412G Constant Force Clamp Pliers SA9127E Gage Bar Set Powertrain Assembly Removal Caution: Do not allow smoking or the use
More informationFord Privilege Parts Purchase Scheme
001 BRAKE DRUMS 40% 044 NEW EXCH.TURBOCHARGERS 35% 002 BRAKE DISCS 50% 045 NEW EXCH. INJ.PUMPS-DIESEL 35% 003 CALIPER COMPONENTS 30% 046 MC REMAN INJ PUMPS-DIESEL 35% 004 CABLES PARKING BRAKE 50% 047 LENSES
More informationBUZZERS, RELAYS & TIMERS
ELECTRICAL COMPONENT LOCATOR 1994 ELECTRICAL COMPONENT LOCATION Mazda Electrical s BUZZERS, RELAYS & TIMERS BUZZERS, RELAYS & TIMERS LOCATION ABS s Motor Relay On top of ABS pump, on right rear corner
More informationVolvo S40 (2004-) V50
Pricelist Contents Filters Air filter 7 Oil filter 9 Filter, Interior air 12 Fuel filter 12 Filter, crankcase breather 14 Brakes Disc Brake Brake disc 15 Brake pad set 18 Handbrake Cable, Park brake 20
More informationCOMPONENT LOCATIONS GROUP CONTENTS FUSIBLE LINK, FUSE AND IOD OR STORAGE CONNECTOR RELAY OTHER DEVICES...
70-1 GROUP 70 COMPONENT LOCTIONS CONTENTS RELY........................ 70-2 OTHER DEVICES............... 70-3 CONTROL UNIT................. 70-4 INSPECTION TERMINL......... 70-7 SENSOR.......................
More informationLower Intake Manifold Replacement
Lower Intake Manifold Replacement Removal Procedure 1. Turn OFF all the lamps and the accessories. 2. Ensure the ignition switch is in the OFF position. 3. Disconnect the negative battery cable from the
More informationINSTALLATION INSTRUCTION Rev A
INSTALLATION INSTRUCTION 88587 Rev A FOR RANCHO SUSPENSION SYSTEM RS6587B: 2009 DODGE RAM 1500 READ ALL INSTRUCTIONS THOROUGHLY FROM START TO FINISH BEFORE BEGINNING INSTALLATION IMPORTANT NOTES! WARNING:
More informationPARTIAL ENGINE ASSY COMPONENTS. Clip. Radiator Grille. Clip. Front Bumper Cover. Engine Under Cover LH. N m (kgf cm, ft lbf) : Specified torque
ENGINE MECHANICAL 1417 COMPONENTS 141FP01 Radiator Grille Front Bumper Cover Engine Under Cover RH Engine Under Cover LH A79361 962 1418 ENGINE MECHANICAL Heater Outlet Water Hose 7.0 (71, 62 in. lbf)
More informationMotorcycle parts compatibility on ebay.co.uk
Motorcycle parts compatibility on ebay.co.uk Review the full list of categories and subcategories in which you can list motorcycle and scooter parts. Last updated: 10 August 2016 Motorcycle Parts (10063)
More informationINSTALLATION INSTRUCTION 88581
INSTALLATION INSTRUCTION 88581 FOR RANCHO SUSPENSION SYSTEM RS6581B: DODGE RAM READ ALL INSTRUCTIONS THOROUGHLY FROM START TO FINISH BEFORE BEGINNING INSTALLATION Rev C IMPORTANT NOTES! WARNING: This suspension
More informationIllustrated Parts Manual
1 10 Illustrated Parts Manual 2 425 CR EFT Model Number A2011IRK4CETR (Red) S H A R E O U R PA S S IO N. TM TABLE OF CONTENTS 2011 ATV 425 CR EFT Red (A2011IRK4CETR) FRONT RACK, BODY PANEL, AND HEADLIGHT
More informationTime of Sale. Peace of mind. Extended Protection B (01/16)
Time of Sale Extended Protection 8-1400B (01/16) Peace of mind. Canada & United States Coverage FCPP covers your vehicle anywhere in Can ada and the continental United States. Direct Response FCPP will
More informationXC 450 EFT Model Number A2013KCK4CETT SHARE OUR PASSION.
2013 XC 450 EFT Model Number A2013KCK4CETT TM SHARE OUR PASSION. TABLE OF CONTENTS 2013 XC 450 EFT Green (Model No. A2013KCK4CETT) FRONT BODY ASSEMBLY... 1 REAR BODY AND TAILLIGHT ASSEMBLY... 2 BUMPER,
More informationFederal and California Emissions Warranties Parts List
Emissions warranties are state specific. Refer to the years/miles 1 columns below as follows: A Minimum coverage for all vehicles in all states. B Vehicles registered and normally operated in California,
More informationREMOVAL AND INSTALLATION
204-00-1 Suspension System 204-00-1 REMOVAL AND INSTALLATION Wheel Bearing, Hub, Knuckle, Upper Arm and Lower Arm Rear Special Tool(s) 3. Remove the parts in the order indicated in the following illustrations
More informationPigtail - Carline Matrix Ford Vehicle Application
Part Nr. 736 4107 001 00 TYCO 1-1670917-1 TO SENSOR PARKING AID REAR RIGHT OUTER 736 4107 002 00 Tyco 1438153-5 TO F MAF SENSOR TO SENSOR - MASS AIR FLOW AND INTAKE AIR TEMPERATURE TO MASS AIR FLOW SENSOR
More information5/16/2017 ALLDATA Repair - Vehicle Information Volvo V L5-2.4L VIN 61 B5244S
1/1 Battery 2/16 Relay, Intermittent Rear Window Wiping On/Off 2/17 Horn Relay 2/22 AC Relay 2/23 Fuel Pump Relay 2/29 Relay, Extended D1 Feed 2/30 X Feed Overload Relay 2/31 15-Feed Overload Relay 2/32
More information10th letter in VIN: J
08 0th letter in VIN: J Headlight G Br Speedometer Headlight Light Switch B Br Ignition Switch R B Y/R Brake Light Switch B G/Y Starter Relay Fuse A + G Starter Motor Rear Brake Light G/Y Br G Speed Sensor
More informationreplacement rates WHAT ARE REPLACEMENT RATES? HOW REPLACEMENT RATES CAN BE USED: UNIT MARKET SIZE ESTIMATES
2018 REPLACEMENT RATES OF U.S. AUTOMOTIVE PARTS AUTOMOTIVE AFTERMARKET SUPPLIERS ASSOCIATION AASA, The Voice for the Automotive Aftermarket Supplier Industry 2018 replacement rates of u.s. REPLACEMENT
More informationCONFIGURATION DIAGRAMS
80A-1 GROUP 80A CONFIGURATION DIAGRAMS CONTENTS OVERALL CONFIGURATION DIAGRAM...................... 80A-2 HOW TO READ CONFIGURATION DIAGRAMS.................... 80A-3 ENGINE COMPARTMENT......... 80A-4
More information303-01C Engine 3.5L 2010 Fusion, Milan, MKZ, Fusion Hybrid, Milan Hybrid. REMOVAL Procedure revision date: 10/19/2012. Engine
2010 MKZ Report a problem with this article 303-01C Engine 3.5L 2010 Fusion, Milan, MKZ, Fusion Hybrid, Milan Hybrid REMOVAL Procedure revision date: 10/19/2012 Engine Special Tool(s) 2,200# Floor Crane,
More informationPage 1 of 10 43: Transmission, automatic, B5254T2, AW50/51 AWD V70 XC (01-) / XC70 (-07), 2004, B5254T2, AW50/51 AWD, L.H.D, YV1SZ59H241147306, 147306 15/10/2011 PRINT 43: Transmission, automatic, B5254T2,
More informationPLAN VEHICLE THE COST OF UNEXPECTED REPAIRS FREQUENTLY ASKED QUESTIONS PACKAGE PROTECTION
Administered by GWC Warranty Corporation Showroom Level, 40 Coal Street Wilkes-Barre, PA 18702 1.800.482.7357 www.gwcwarranty.com This plan is backed by American Bankers Insurance Company of Florida, an
More informationDIAMO Discovery ATV PARTS CATALOG - CHASSIS First Edition April 2008
DIAMO Discovery ATV PARTS CATALOG - CHASSIS First Edition April 2008 Copyright 2004-2008 LS MotorSports, LLC. Reproduction without written permission is completely forbidden. The information and diagrams
More informationWHY FORD PROTECT? GO FURTHER WITH PREMIUMCARE PLUS! PremiumCARE Plus! NEW VEHICLE PLANS. The numbers speak for themselves:
VEHICLE PLANS AND SELECTION 2, km 15, km 12, km 1, km 1,+ vehicle components, plus all required scheduled investment with our most The only plan 1% backed by Covers the parts and labour on over 1,+ vehicle
More informationCustomer/Dealer name VIN. Inspection Area Check Point Measurements / Comments Description Repair Est.
Customer/Dealer name Date Gold VIN License/Stock # Year/Make/Model Mileage In/Out / Road Test Starts, idles Check Engine light Instrument panel lights Instrument panel gauges Speedometer, odometer Tachometer
More information2013 NATEF Task Area A-4 Suspension, Steering, Alignment7-2013
2013 NATEF Task Area A-4 Suspension, Steering, Alignment7-2013 A. Steering System Diagnosis & Repair B. Suspension System Diagnosis & Repair C. Wheel Alignment Diagnosis & Adjustment D. Wheel & Tire Diagnosis
More informationAST Test - 80 Questions
AST Test - 80 Questions 1. One rear taillight does not work and a test light is being used to check for voltage at a taillight socket. Technician A says that the alligator clip on the test light should
More informationAER Automotive Steering and Suspension
2013 NATEF JOB TASKS COMPLETION REQUIREMENT: P1-95% P2-80% P3-50% Student Name: DETAILED COURSE CONTENT AUTOMOTIVE SUSPENSION AND STEERING TECHNICIAN DEMONSTRATE PROFICIENCY IN SUSPENSION AND STEERING
More informationLIFETIME WRAP. 5 Star Wrap Vehicle Service Contract
LIFETIME WRAP 5 Star Wrap Vehicle Service Contract We go the extra mile so you can enjoy the drive The 5 Star Wrap Vehicle Service Contract provides additional protection to your dealer s Limited Lifetime
More informationA proportioning valve is used to regulate brake pressure between front and rear brakes. Rear brakes on all models are self-adjusting.
Page 1 of 21 ARTICLE BEGINNING DESCRIPTION & OPERATION WARNING: For warnings and procedures regarding vehicles equipped with Anti- Lock Brake Systems (ABS), see ANTI-LOCK BRAKE SYSTEM article in the BRAKES
More informationIllustrated Parts Manual
Illustrated Parts Manual Models 534D-6 534D-6 Turbo S/N 0588001 P/N - 9133-4006 Revised July 6, 2007 SECTION 1 INTRODUCTION INTRODUCTION Table of Contents 534D-6 Starting Serial No. 0588001 534 D6-TURBO
More informationMaintenance. Lubricants and Fluids Maintenance Minder General Information... Maintenance Main Items... Maintenance Sub Items...
Maintenance Lubricants and Fluids... 3-2 Maintenance Minder General Information.... 3-4 Maintenance Main Items.... 3-7 Maintenance Sub Items.... 3-8 Lubricants and Fluids For details of the lubrication
More information03 1 SERVICE SPECIFICATIONS
SERVICE SPECIFICATIONS STANDARD BOLT STANDARD BOLT HOW TO DETERMINE BOLT STRENGTH 031 0307K02 Bolt Type Hexagon Head Bolt Normal Recess Bolt Deep Recess Bolt Stud Bolt Weld Bolt Class 4 4T No Mark No Mark
More informationARTICLE BEGINNING INTRODUCTION IGNITION SYSTEM CAMSHAFT POSITION (CMP) SENSOR DISTRIBUTOR
Article Text Thursday, August 19, 1999 11:40PM ARTICLE BEGINNING 1996 ENGINE PERFORMANCE Volkswagen Removal, Overhaul & Installation - Gasoline Cabrio, Golf III, GTI, Jetta III, Passat CAUTION: When battery
More informationINSTALLATION INSTRUCTION 89400
INSTALLATION INSTRUCTION 89400 FOR RANCHO SUSPENSION SYSTEM RS66400B: 2012 RAM 1500 4WD. READ ALL INSTRUCTIONS THOROUGHLY FROM START TO FINISH BEFORE BEGINNING INSTALLATION Rev B IMPORTANT NOTES! WARNING:
More informationHenry's Auto Parts, LLC
Item Name Price ABS Unit $33.99 AC Compressor $34.99 AC Compressor Clutch $29.99 AC Condensor $19.99 AC Evaporator $16.99 AC Evaporator Housing $16.99 AC Receiver Drier $12.99 Air Cleaner $12.99 Air Conditioner
More informationCLUTCH Toyota Celica DESCRIPTION ADJUSTMENTS CLUTCH PEDAL HEIGHT Clutch. Celica
CLUTCH 1993 Toyota Celica 1993 Clutch Celica DESCRIPTION The single, dry disc type clutch uses a hydraulically operated master cylinder and a release cylinder mounted on clutch housing. Clutch release
More informationA4 AVANT TECHNICAL SPECIFICATIONS
A4 AVANT TECHNICAL SPECIFICATIONS - Engine Arrangement Bore Stroke Displacement Compression ratio Fuel requirements Horsepower Max. Torque Engine Design Inline 4-cylinder with exhaust gas turbocharger
More informationFRONT & REAR SUSPENSION SECTIONSU CONTENTS IDX. FRONT SUSPENSION...2 Precautions...2. REAR SUSPENSION...14 Precautions...14
FRONT & REAR SUSPENSION SECTIONSU GI MA EM LC EC CONTENTS FE FRONT SUSPENSION...2 Precautions...2 PRECAUTIONS...2 Preparation...2 SPECIAL SERVICE TOOLS...2 COMMERCIAL SERVICE TOOLS...2 Noise, Vibration
More informationREMOVAL AND INSTALLATION OF TRANSAXLE (4WD)
MT63 REMOVAL AND INSTALLATION OF TRANSAXLE (4WD) REMOVAL AND INSTALLATION OF TRANSAXLE REMOVE AND INSTALL TRANSAXLE AS SHOWN MT64 REMOVAL OF TRANSAXLE 1. DISCONNECT CABLE FROM NEGATIVE TERMINAL OF BATTERY
More informationFilters. Brakes. Suspension + Steering. Exhaust. Turbocharger. Disc Brake. Steering. Handbrake. Brake Hoses, -Pipes. Brake Master Cylinder
Catalog Contents Filters Air filter 8 Oil filter 9 Filter, Interior air 11 Fuel filter 12 Brakes Disc Brake Brake disc 14 Brake pad set 16 Accessory kit, Brake pads 17 Handbrake Brake shoe set, Park brake
More information650 H1 TRV EFT MODEL NUMBER A2008TBS4BETI (RED) MODEL NUMBER A2008TBS4BETM (GREEN) MODEL NUMBER A2008TBS4BETJ (CAT GREEN)
2008 650 H1 TRV EFT Illustrated Parts Manual MODEL NUMBER A2008TBS4BETI (RED) MODEL NUMBER A2008TBS4BETM (GREEN) MODEL NUMBER A2008TBS4BETJ (CAT GREEN) (VADA644AV80X05001 - VADA644AV80X05250) MORE TO GO
More informationPARTIAL ENGINE ASSY (2ZZ GE)
COMPONENTS 14189 140R701 7.0 (71, 62 in. lbf) Cylinder Head Cover No. 2 19 (194, 14) Radiator Support Upper 19 (194, 14) Radiator Hose Inlet Cruise Control Actuator Assy 6.0 (61, 53 in. lbf) Radiator Assy
More informationOxygen sensor control,
Page 1 of 46 24-71 Oxygen sensor control, checking Oxygen sensor and oxygen sensor control before catalytic converter, checking Special Tools and Equipment VAG1526A VAG1594A VAG1598/31 VAS5051 with VAG5051/1
More informationFORD CREDIT EXTENDED SERVICE PLAN GENUINE PARTS. For more information, please contact: Roadside Assistance
FORD CREDIT One of the many benefits of buying a Ford Certified Pre-Owned vehicle is flexible financing options from Ford Credit. Ask your Ford Dealer for the details on current offers. EXTENDED SERVICE
More information