62 Deck Idler Kit High Speed
|
|
- Evan Melvyn Berry
- 5 years ago
- Views:
Transcription
1 Part No. 00 FORM NO Deck Idler Kit High Speed For Model 70 Serial No to For Model 7 Serial No to INSTALLATION INSTRUCTIONS Loose Parts Note: Use the chart below to identify parts for assembly. DESCRIPTION QTY. USE Bracket Bolt (/6 8 x / ) Flange Nut Pulley Spacer Belt Guide Plate Spring Disk Bolt (/8 6 x / ) Bolt (/8 6 x / ) Spacer Bracket Belt Guide Bolt Washer Nut Install Front Idler Pulley Bracket Install Front Idler Pulley Install Belt Guide Printed in USA The Toro Company 999 All Rights Reserved
2 Removing Drive Belt. Stop the engine, set the parking brake, remove the key and disconnect the spark plug wire(s) from the spark plug(s).. Remove the clutch retaining strap from machine frame and unplug clutch terminal from wire harness (Fig. ). Note: Leave clutch retaining strap attached to the clutch.. Remove the drive belt (Fig. ). Removing Deck. Lower the deck on to wood blocks.. Remove the four bolts at the bottom of chains that are attached to deck (Fig. ).. Remove the nuts and bolts holding pins in the push arm (Fig. ).. Remove pins (Fig. ).. Raise height of cut lever and slide deck out (Fig. ). 6 m 7. Clutch. Clutch retaining strap. Clutch Terminal Figure. Drive belt. Machine Frame. Deck. Chain. Chain Bolt. Push Arm Figure. Push Arm Bolt 6. Push Arm Nut 7. Push Arm Pin
3 Installing Front Idler Pulley Bracket. Remove existing belt guide and hardware and discard (Fig. ).. Align hole in bracket to the hole the belt guard was installed in (Fig. ).. Position belt idler bracket rear edge parallel to the rear edge of deck (Fig. ).. Install one bolt through the bracket and where the belt guide was installed in deck. Install nut and tighten (Fig. ).. Using bracket as a template, drill three /6 holes into deck (Fig. ). 6. Install bolts into bracket and securely tighten bracket to the deck with nuts (Fig. ). 6 Installing Front Idler Pulley. Install pulley onto the idler bracket mounting stud (Fig. ).. Install bolt (/8 x / ) into spring disk washer, belt guide plate and short spacer. Install into the center of mounting stud. Do not tighten (Fig. ).. Place belt into idler assembly with back side of belt toward idler pulley.. Install bolt (/8 x / ) into spring disk washer, belt guide plate, long bracket spacer and hole in idler bracket. Install nut onto bolt (Fig. ).. Tighten both bolts (Fig. ) Figure. Idler Pulley Bracket. Existing Belt Guide. Bolt Figure. Nut. Holes to Drill 6. Align Holes. Pulley. Bolt (/8 x / ). Spring Disk Washer. Belt Guide Plate. Short Spacer 6. Mounting Stud 7. Long Bracket Spacer 8. Hole in Idler Bracket 9. Bolt (/8 x / ) 0. Nut
4 Install Belt Guide. Remove existing belt guide, carriage bolt, washer, nut and discard (Fig. ). Figure 6. New Belt guide. New Bolt. Nut. Washer. Old Belt Finger Hole Figure. Existing Belt guide. Carriage Bolt. Nut. Washer Installing Deck. Remove existing carriage bolt and nut (Fig. 6). IMPORTANT: Remove only this specific bolt to install belt guide (Fig. 6).. Install removed carriage bolt and nut into where the existing belt finger was installed (Fig. 6).. Install new bolt, washer, nut and belt guide (Fig. 6).. Adjust belt guide. Refer to Adjusting Belt Guide section on page 6.. Remove push arms from machine frame.. Adjust push arms. Loosen jam nut and rotate ball joint counterclockwise, one turn at a time. Adjust each side the same amount. Adjust the length of push arms to /6 (89mm) (Fig. 0).. Reinstall push arms to machine frame.. Install pins into the deck and push arms.. Install the nut and bolt to secure pin to the push arm and deck. 6. Install the four bolts at the bottom of chains that attached to deck. 7. Grease the push arms. Mower Leveling When finished installing deck, the deck must be leveled (see Operator s Manual for instructions).
5 Installing Drive Belt. Place new drive belt over clutch, around rear idler pulley, installed into rear idler arm assembly, installed into front idler pulley assembly and onto mower top center pulley. IMPORTANT: Check the amount of twist in belt between pulleys. Make sure it is only what is specified in figure 7.. Install clutch retaining strap and plug clutch terminal into main wire harness (Fig. 7). m Center bolt, spring loaded idler Figure 8. Alignment hole. If adjustment is required, loosen the fixed idler on right support plate and move up or down in adjustment slot. To relieve belt tension lift up on spring loaded idler (Fig. 9).. Clutch. Clutch retaining strap. Clutch Terminal. Drive belt Figure 7. Machine Frame 6. / Belt Twist 7. /8 Belt Twist. Check belt tension. The center bolt of spring loaded idler must be between the two alignment holes in left support plate (Fig 8). Figure 9. Fixed Idler. Adjustment slot m 76 Note: Check position of center bolt in Low Height of Cut. The center bolt must be at or below the top alignment hole. Check position of center bolt in a High Height of Cut. The center bolt must be at or above the lower adjustment hole (Fig 8).. Check belt tension again. The center bolt of spring loaded idler must be between the two alignment holes in left support plate (Fig 8). Adjust, if necessary, and tighten all hardware securely. 6. If the fixed idler contacts the end of the adjustment slot and more belt tension is required, a small change in the length of the push arms can be made (Fig. 0).
6 7. To adjust push arms, remove push arms from machine frame, remove drive belt, loosen jam nut and rotate ball joint counterclockwise, one turn at a time. Adjust each side the same amount (Fig. 0). Note: Increase tension by lengthening the push arms and decrease tension by shortening push arms. Adjusting Belt Guide. Loosen belt guide (Fig. ).. Rotate the belt guide, so it is /8 / ( 7 mm) away from the vertical side of the PTO belt (Fig.). m 70 Figure. Push arm. /6 (89 mm) nominal Figure 0. Jam nut. Ball joint. Belt guide. Drive belt. /8 / ( 7 mm) 8. Install drive belt (Fig. 6). 6
7 7
8 8
Z Master. 62 Mower. for Z Master Z 255 Traction Unit. Model No & UP. Operator s Manual
FORM NO. 9 88 Z Master 6 Mower for Z Master Z 55 Traction Unit Model No. 7408 89000 & UP Operator s Manual IMPORTANT: Read this manual carefully. It contains information about your safety and the safety
More information52 inch Twin Bagger and Finishing Kit 200 Series Z Master
Form No. 9 68 inch Twin Bagger and Finishing Kit 00 Series Z Master Model No. 7898 Serial No. 000000 and Up Model No. 780 Operator s Manual English (EN) Contents Page Introduction................................
More informationWheel Horse. 36 Tiller. Model No & Up. Operator s Manual
FORM NO. 8 9 Rev. A Wheel Horse 6 Tiller for Classic Garden Tractors Model No. 7970 690000 & Up Operator s Manual IMPORTANT: Read this manual carefully. It contains information about your safety and the
More informationFour Wheel Drive Kit Groundsmaster 580D
Four Wheel Drive Kit Groundsmaster 580D FORM NO. 957 Rev B Model No. 0599 00 thru 99999 INSTALLATION INSTRUCTIONS POTENTIAL HAZARD Traction Unit rolls over. WHAT CAN HAPPEN Bodily injury could occur. 4
More information36 Tiller Wheel Horse Lawn and Garden Tractor Attachment
Form No. 9 6 Rev B 6 Tiller Wheel Horse Lawn and Garden Tractor Attachment Model No. 797 890000 and Up Operator s Manual English(En) Contents Page Introduction................................ Safety.....................................
More informationASSEMBLY INSTRUCTIONS FOR CHARGER AND THE BOSS QUICK ATTACH GRASS BAGGER
ASSEMBLY INSTRUCTIONS FOR CHARGER AND THE BOSS QUICK ATTACH GRASS BAGGER \ \ \ \ ~\ P P-12102 (7/2005) TABLE OF CONTENTS SECTION PAGE WARNING 1 BLOWER PULLEY INSTALLATION 2 ENGINE GUARD REMOVAL BOSS 3
More informationAgri-Fab OWNERS MANUAL. Model No " ROUGH CUT TRAILMOWER. CAUTION: Read Rules for Safe Operation and Instructions Carefully
Agri-Fab OWNERS MANUAL Model No. 45-03071 45-0361 CAUTION: Read Rules for Safe Operation and Instructions Carefully Safety Assembly Operation Maintenance Parts 42" ROUGH CUT TRAILMOWER the fastest way
More informationCollector Drive for 44 Mower
FORM NO. -80 Collector Drive for Mower Model No. 7955-990000 & Up Operator s Manual IMPORTANT: Read this manual, and your tractor manual, carefully. They contain information about your safety and the safety
More informationRear Discharge Completion Kit Groundsmaster 7200 Series Traction Unit with 62 in. Mower Groundsmaster 7200 Series Traction Unit with 72 in.
Rear Discharge Completion Kit Groundsmaster 700 Series Traction Unit with 6 in. Mower Groundsmaster 700 Series Traction Unit with 7 in. Mower Model No. 046 Model No. 0466 Form No. 58 58 Rev. C Installation
More informationQuiet Collector. Model No & Up
FORM NO. -8GB Rev A Quiet Collector Model No. 795-890000 & Up Operator s Manual IMPORTANT: Read this manual, and your tractor manual, carefully. They contain information about your safety and the safety
More informationQuiet Collector. Model No & Up
FORM NO. -0 Quiet Collector Model No. 79-990000 & Up Operator s Manual IMPORTANT: Read this manual, and your tractor manual, carefully. They contain information about your safety and the safety of others.
More informationAgri-Fab OWNERS MANUAL. Model No " ROUGH CUT TRAILMOWER. CAUTION: Read Rules for Safe Operation and Instructions Carefully
Agri-Fab OWNERS MANUAL Model No. 45-0362 CAUTION: Read Rules for Safe Operation and Instructions Carefully Safety Assembly Operation Maintenance Parts 42" ROUGH CUT TRAILMOWER NOTE: Your mower deck will
More informationG3 UHT TRANSMISSION. G3 UHT Transmission Replacement. G3 UHT Transmission Removal
G3 UHT Transmission Replacement The following procedures cover replacing the left hand UHT Transmission. The same procedures can be followed to remove the right hand UHT Transmission. 5. Raise the seat
More information44 and 52 Twin Bagger 100 Series Z Master
Form No. 7 87 and 5 Twin Bagger 00 Series Z Master Model No. 7855 Serial No. 000000 and Up Operator s Manual English (CE) Contents Page Introduction................................ Safety.....................................
More informationCollector Drive for 60 Mower
FORM NO. -66 Collector Drive for 60 Mower Model No. 7965-990000 & Up Operator s Manual IMPORTANT: Read this manual, and your tractor manual, carefully. They contain information about your safety and the
More information36 Tiller Wheel Horse Classic Garden Tractor Attachment
Form No. 6 97 6 Tiller Wheel Horse Classic Garden Tractor Attachment Model No. 7970 Serial No. 000000 and Up Operator s Manual Domestic English (EN) Contents Page Introduction................................
More information48in Snow Blade TimeCutter Z Riding Mower Attachment
Form No. 9-8 8in Snow Blade TimeCutter Z Riding Mower Attachment Model No. 796 Serial No. 000000 and Up Operator s Manual Register your product at www.toro.com Original Instructions (EN, GB) Contents Page
More informationInstruction Sheet IS Date: 8/6/2013
Instruction Sheet Date: 8/6/2013 Bulletin #: Subject: 072709/072710/072711/072811, Belt Keeper Update Kit Purpose: To instruct Lastec personnel Model Numbers: 3300, 3600, 3380, 3680, 4520 Serial Numbers:
More informationBrand Model Number Serial Number Range Description Ferris , , , , , , ,
RIGGS & STRTTON POWR PROUTS GROUP, LL S #: 108 RNS: T: PRIL 2011 TO: LL UTHORIZ RRIS LRS SUJT: UPTS TO IS2500Z ZRO-TURN RIING MOWRS MOLS: S LIST LOW rand Model Number Serial Number Range escription erris
More informationHAND THROTTLE KIT For Workman 3000 Series
FORM NO. 7 6 MODEL NO. 0746 INSTALLATION INSTRUCTIONS HAND THROTTLE KIT For Workman 000 Series. Position vehicle on a clean, level surface, stop engine, engage parking brake and remove key from ignition
More informationAssembly Instructions. General Information. Installation Instructions. 12, 15 and 20 Series Drill Small Seeds Option. Used with:
Installation Instructions! Used with: 1200, 1210 and 1220 Drills 1500, 1510 and 1520 Drills 2000, 2010 and 2020 Drills 12, 15 and 20 Series Drill Small Seeds Option When you see this symbol, the subsequent
More informationDFS Vac Collection System 400 Series Z Master
Form No. 0 DFS Vac Collection System 00 Series Z Master Model No. 780 Serial No. 000000 and Up Operator s Manual Register your product at www.toro.com Original Instructions (EN/GB) Contents Page Introduction................................
More informationInstruction Sheet Kit Number:
Instruction Sheet Kit Number: 72101800 TRACK CONVERSION KIT For All Wheel-Drive 921000 Models WARNING: FAILURE TO FOLLOW INSTRUCTIONS could result in personal injury and/or damage to unit. Read, understand,
More informationRear Roller Brush Kit Greensmaster 3150 & 3250
Rear Roller Brush Kit Greensmaster 50 & 50 Model No. 04640 Model No. 0464 Form No. 8 808 Rev. B Installation Instructions Note: The Rear Roller Brush Kit can only be installed on cutting unit models 0460
More information365L (2001) Page 1 of 36 54" Deck Assembly
365L (2001) Page 1 of 36 54" Deck Assembly 365L (2001) Page 2 of 36 54" Deck Assembly 1 720-0241 1 S Wing Nut Knob 2 703-2817 1 Belt Cover LH 3 703-2816 1 Belt Cover RH 4 747-3306 1 Idler Spring Mounting
More informationAir Commander Part No
EASYSTEET Air Commander Part No. 26903 www.airliftcompany.com MN-510 (06506) EC 5206 Please read these instructions completely before proceeding with installation The oil level in the compressor must be
More informationFIELD & BRUSH MOWER SERIES 0
Parts Manual for SERIES 0 MODEL FB13250BS FB13250BV FB15250KW McDonough, GA, 30253 U.S.A. COPYRIGHT 2005 SNAPPER PRODUCTS, INC. ALL RIGHTS RESERVED. Revision 1, 8/30/2005 Table Of Contents PAGE GROUP
More information3 Dualsport rear suspension ram truck 2500 AIR RIDE. AEV30262AA Last Updated: 07/11/17 INSTALLATION GUIDE
3 Dualsport rear suspension ram truck 2500 AIR RIDE AEV30262AA Last Updated: 07/11/17 INSTALLATION GUIDE PLEASE READ BEFORE YOU START TO GUARANTEE A QUALITY INSTALLATION, WE RECOMMEND READING THESE INSTRUCTIONS
More informationProLine. 44 Mower. for 120 Traction Unit. Model No & Up. Operator s Manual
FORM NO. 9 ProLine Mower for 0 Traction Unit Model No. 05 99000 & Up Operator s Manual IMPORTANT: Read this manual carefully. It contains information about your safety and the safety of others. Also become
More information42in GT Classic Single Stage Snowthrower Conversion Kit XT Series Garden Tractor
Form No. 5 70 in GT Classic Single Stage Snowthrower Conversion Kit XT Series Garden Tractor Part No. 06 858 Installation Instructions Original Instructions (EN) This kit is for installing an existing
More informationParts Manual. Field and Brush Mower. 16HP Tractors. 13.5HP Tractors. 13HP Tractors. 15HP Tractors
Parts Manual Field and Brush Mower.5HP Tractors Mfg. No. Description 20.5HP, Walk-Behind Brush Mower (Simplicity) 25.5HP, Walk-Behind Brush Mower (Ferris GM25H) 25.5HP, Walk-Behind Brush Mower (Giant-Vac
More informationInstruction Sheet Kit Number:
Instruction Sheet Kit Number: 7914400 POWERED DECK LIFT KIT WARNING: FAILURE TO FOLLOW INSTRUCTIONS could result in personal injury and/or damage to unit. Read, understand and follow all safety practices
More informationFIELD & BRUSH MOWER SERIES 0
Parts Manual for SERIES 0 MODEL FB13250BS (7085922) GM2513BS (3070980) GM2513H (3070101) GM2513H (7085924) GM2515KAW (3070103) GM2515KAW (7085923) GM2516BVG (3800017) COPYRIGHT 2009 GIANT-VAC ALL RIGHTS
More information160S Rewind Option Kit Installation Instructions
Installation Instructions GENERAL This kit includes the parts and documentation necessary to install the Media Rewind Option into the Zebra 160S printer. Read these instructions thoroughly before attempting
More informationReproduction. Not for. Installation Instructions. Gearbox Replacement Kit. Part No WARNING REMOVING THE GEARBOX. Fits IS2600Z Models A B
Installation Instructions Kit ontents Part No. Qty. escription Part No. Qty. escription 5025394 5 Nut, 3/8-16 ex Nylock lange 5104533 1 earbox, Right ngle 5025396 4 Nut, 1/2-13 ex Nylock lange Part No.
More informationCollection System. Please read the operator s manual carefully and make sure you understand the instructions before using the machine.
Collection System 967004601 Please read the operator s manual carefully and make sure you understand the instructions before using the machine. 2012 All rights reserved. Swainsboro, GA. Printed in U.S.A.
More informationParts Manual PZ Please read the operator manual carefully and make sure you understand the instructions before using the machine.
Parts Manual PZ 60 967 045601-00 Please read the operator manual carefully and make sure you understand the instructions before using the machine. When you need spare parts or support in service questions,
More informationInstruction Sheet. Kit Numbers: , , & CRANK PULLEY KIT DISASSEMBLY. Package Contents
Instruction Sheet Kit Numbers: 5600, 5700, 5800 & 5300 CRANK PULLEY KIT WARNING: FAILURE TO FOLLOW INSTRUCTIONS could result in personal injury and/or damage to unit. Read, understand, and follow all safety
More informationMOWER HOUSING SUSPENSION
MODEL 000xA MOWER HOUSING SUSPENSION 0 0 0 0 F 00L MODEL 000xA MOWER HOUSING SUSPENSION Knob 00 Washer 0x Pad, Friction 0 Pin, Hanger 0 Link, Lift 00E00 Nut, Flange 0x Bolt, Shoulder 00x Bracket, Rear
More informationAir Commander Late Model Ford F-150
EASYSTREET Air Commander Late Model Ford F-150 www.airliftcompany.com MN-544 (02506) ECR 5206 Please read these instructions completely before proceeding with installation The oil level in the compressor
More informationPacer Series Transaxle Drive Walk-Behind Mower
Parts Manual Pacer Series Transaxle Drive Walk-Behind Mower 15HP Product Mfg. No. Description 1694895 Pacer, 15HP B&S Walk-Behind 2690447 Pacer, 15HP B&S w/34" Deck 17HP Product Mfg. No. Description 5900630
More informationENCORE 52" X-TREME. 2-BAG GRASS CATCHER for units w/ S/N and above ASSEMBLY AND PARTS DIAGRAMS
ENCORE 52" X-TREME 2-BAG GRASS CATCHER for units w/ S/N 53138 and above ASSEMBLY AND PARTS DIAGRAMS Notes: ASSEMBLY INSTRUCTION Figure 1 Using 1/2" wrench, remove the discharge cover and the RH deck belt
More informationSafety First. Please remember to always use SAFE shop practices when performing all service procedures.
Safety First Please remember to always use SAFE shop practices when performing all service procedures. 2006 Update Manual January 2006 Country Clipper 2006 Update Manual Index Joystick Kill Switch Oil
More informationWheel Horse. 44 Snowthrower. for 5xi Lawn and Garden Tractors. Model No & Up. Operator s Manual
FORM NO. 8 Rev A Wheel Horse Snowthrower for 5xi Lawn and Garden Tractors Model No. 7966 890050 & Up Operator s Manual IMPORTANT: Read this manual, and your tractor manual, carefully. They contain information
More informationGM 6-Cylinder Cam Tool Set 3.0L and 3.2L Operating Instructions
GM 6-Cylinder Cam Tool Set 3.0L and 3.2L Operating Instructions Set Includes: Locking Tool... 536594 Locking Tool... 536595 Crankshaft Holding Tool... 536596 Alignment Gauge... 536608 Belt Installation
More information5 Large spring 1. Key Start Kit Workman MDX Utility Vehicle. Preparing the Machine. Loose Parts. No Parts Required. Procedure
Key Start Kit Workman MDX Utility Vehicle Model No. 119-9534 Form No. 3366-100 Rev B Installation Instructions Note: Determine the left and right sides of the machine from the normal operating position.
More informationHydrostatic Zero-Turn Commercial Riding Mower
Hydrostatic Zero-Turn Commercial Riding Mower Professional Turf Equipment 54" Fabricated Deck ILLUSTRATED PARTS LIST TABLE OF CONTENTS Frame Assembly.................................. 3 54" Fabricated
More information36 Tiller XT Series Garden Tractor Attachment
Form No. 9 6 6 Tiller XT Series Garden Tractor Attachment Model No. 79484 000000 and Up Operator s Manual English(En) Contents Page Introduction................................ Safety.....................................
More informationInstruction Sheet IS D Gearbox Drive Update Kit Installation To instruct dealers in installation. Model Numbers: IS-0129
Instruction Sheet Date: Bulletin #: Subject: Purpose: Model Numbers: Serial Numbers: Recipients: 16 October 425D Gearbox Drive Update Kit Installation To instruct dealers in installation 425D All serial
More informationAdjustments manual for: Gear Drive, ETS Gear Drive, Walk Hydro, ETS Walk Hydro, Mini Rider, Large Rider Gen 2
For Husqvarna Parts Call 66-678-96 or 66-56-98 Adjustments manual for: Gear Drive, ETS Gear Drive, Walk Hydro, ETS Walk Hydro, Mini Rider, Large Rider Gen MANUAL NO. 5957 REV. (//) For Husqvarna Parts
More informationHydro Cut Series Walk-Behind Mowers
Parts Manual HP Product Mfg. No. Description 92 Hydro Cut, HP Kawasaki, 2 inch (CE) Hydro Cut Series Walk-Behind Mowers Rev. 0/200 Table Of Contents PRODUCT COMPONENTS PAGES Engine Deck & Handle Bars
More informationWheel Horse. 48 Snow Blade. Model No & Up. Operator s Manual
FORM NO. 8 8 Wheel Horse 8 Snow Blade for Classic Graden Tractors Model No. 7950 890000 & Up Operator s Manual IMPORTANT: Read this manual carefully. It contains information about your safety and the safety
More informationSymptom Possible Cause Corrective Action. * Make sure brake isn t stuck in on position. Remove brake parts as necessary to test.
Troubleshooting Chart for the Hydro-Gear Transaxle Symptom Possible Cause Corrective Action Operates in one direction Inspect control linkage Inspect drive belt and pulleys Unit is Noisy Check oil level
More informationWheel Horse. 42 Mower. for Lawn and Garden Tractors. Model No & Up. Operator s Manual
FORM NO. 9 559 Rev A Wheel Horse 4 Mower for Lawn and Garden Tractors Model No. 78 890000 & Up Operator s Manual IMPORTANT: Read this manual carefully. It contains information about your safety and the
More informationSET-UP INSTRUCTION & PRE-OPERATION CHECKLIST SNAPPER 21" STEEL DECK COMMERCIAL WALK BEHIND MOWERS
SET-UP INSTRUCTION & PRE-OPERATION CHECKLIST SNAPPER 21" STEEL DECK COMMERCIAL WALK BEHIND MOWERS INTRODUCTION: The SNAPPER Walk Behind Mowers are shipped almost fully assembled and require minimal set-up.
More informationGROUNDSMASTER. 52 Recycler. for 120 Traction Unit. Model No & UP. Operator s Manual
FORM NO. 8-980 Rev A GROUNDSMASTER 5 Recycler for 0 Traction Unit Model No. 077 79000 & UP Operator s Manual IMPORTANT: Read this manual carefully. It contains information about your safety and the safety
More informationParts Manual. ProCut 20 Series 3-Wheel Riding Mower Serial No & Above. Models: H2220K R52 R61
Parts Manual ProCut 20 Series 3-Wheel Riding Mower Serial No. 7671 & Above Models: H2220K R52 R61 Ferris Industries 5375 North Main Street Munnsville, NY 13409 USA 800-933-6175 5022204 Revision 07 Rev.
More informationSETUP, PARTS & MAINTENANCE MANUAL 2 BAG CATCHER
SETUP, PARTS & MAINTENANCE MANUAL 2 BAG CATCHER MODELS: 970338 2 BAG CATCHER, 36 970339 2 BAG CATCHER, 42 970340 2 BAG CATCHER, 48 970341 2 BAG CATCHER, 52 WARNING: If incorrectly used this machine can
More informationReproduction. Not for. Installation Instructions. IS2600Z Gearbox Replacement. Replacing the Gearbox and Mount Bracket WARNING. Removing the Gearbox
Installation Instructions WRNIN Remove the ignition key prior to performing maintenance on the unit. IS2600Z earbox Replacement its erris IS2600Z omestic Models allout Part escription Qty Number 5413882
More information42in GT Classic Single Stage Snowthrower Conversion Kit XT Series Garden Tractor
Form No. 9 66 in GT Classic Single Stage Snowthrower Conversion Kit XT Series Garden Tractor Part No. 06 88 Installation Instructions English (EN) This kit is for installing an existing 00 Series Classic
More informationCut off saw - Starter assy and engine
Cut off saw - Starter assy and engine Copyright Comet USA, Inc. 1/9/2015 1-13 Cut off saw - Starter assy and engine Ref.Nu Qty Part number Description Validity from Validity till Notes Bulletin 1 4 097000092AR
More informationParts Manual Rev. A
115 96 28-27 Rev. A Parts Manual Z 242F / 967 271802-00 Please read the operator manual carefully and make sure you understand the instructions before using the machine. Gasoline containing a maximum of
More informationHydrostatic Zero-Turn Commercial Riding Mower
Hydrostatic Zero-Turn Commercial Riding Mower Professional Turf Equipment 0" Fabricated Deck ILLUSTRATED PARTS LIST TABLE OF CONTENTS Frame Assembly.................................. 3 0" Fabricated Cutter
More informationRiding Mowers. Z44 and Z52 Accu-Z Razor (S/N and above) SM Service Manual Printed 9/24/09
Riding Mowers Z44 and Z52 Accu-Z Razor (S/N 472620 and above) 23802 357-044SM Service Manual 2006 Printed 9/24/09 Copyright 2006 All rights Reserved Land Pride provides this publication as is without warranty
More informationGrass Catcher. Instructional / Parts Manual Part Number: January ( & ) & Drive Kits ( , , )
Grass Catcher Instructional / Parts Manual Part Number: January 200 5020 ( 507 & 5026 ) & Drive Kits ( 52030, 5203, 52032) Table of Contents Z RIDER GRASS CATCHER TWO PACKAGED ITEMS LIST 507 BLOWER ASSEMBLY
More information42 Mower Wheel Horse Classic Garden Tractor Attachment
Form No. 6 9 Mower Wheel Horse Classic Garden Tractor Attachment Model No. 78 000000 and Up Operator s Manual Domestic English (EN) Contents Page Introduction................................ Slope Chart..............................
More information48 Mower Wheel Horse Classic Garden Tractor Attachment
Form No. 6 96 Rev B 8 Mower Wheel Horse Classic Garden Tractor Attachment Model No. 786 000000 and Up Operator s Manual Domestic English (EN) Contents Page Introduction.................................
More informationService Kit A
Service Kit 753-05894A Date: Subject: Models Affected: June 28, 2010 Service Replacement for the 618-04360 and 618-04360A Tiller Transmissions N/A Read through and understand these instructions completely
More informationRIGHT HYDRAULIC PUMP. Right Hydraulic Pump Replacement. Right Hydraulic Pump Removal. 5. Remove the pump belt from around the pump pulleys (Fig. 002).
Right Hydraulic Pump Replacement Note: Cleanliness is a key factor in a successful repair of any hydraulic system. Thoroughly clean all exposed surfaces prior to any type of maintenance. Cleaning all parts
More informationWorldlawn Power Equipment, Inc. Industrial Park 2415 Ashland Ave. Beatrice, NE Toll Free Number:
Parts Catalog R WYRZ46S/50U/60U Residential Zero Turn Mower Worldlawn Power Equipment, Inc. Industrial Park 2415 Ashland Ave. Beatrice, NE 68310 Toll Free Number: 1-800-267-4255 Table of Contents Table
More informationSERVICE BULLETIN SB.DSL rev02
DSL 505 Rear Delt / Pec Fly Cable Repair Applies to DSL 505 Rear Delt / Pec Fly built prior to 5/16/2017 Issue/Symptoms On some machines using the 1/8 diameter lift cables, the cam cables may twist and
More informationInstallation Instructions
Equipment Required: Fastener Kit: F Wrenches: 3/4, 15/16 Drill Bits: 1/4 Other Tools: Drill Installation Instructions Short & Long Bed All Megacabs 9464/9474 HIDE-A-GOOSE HITCH INSTALLATION WARNING: Under
More informationParts List. Model Revision 00 TP LT-R
Parts List Model 7800276 Revision 00 Rev. Date 03/2008 Table Of Contents PRODUCT COMPONENTS PAGES Steering... 4 Engine Mount... 6 Motion Drive... 8 Electrical System... 12 Chassis & Hood... 14 Decals...
More informationTO THE OWNER ASSEMBLY
TO THE OWNER This is an operational and general maintenance manual only and does not cover repair. All repair work must be performed by an authorized BOLENS DEALER or the factory warranty is void. Bolens
More informationDewEze I N S T A L L A T I O N I N S T R U C T I O N S. Clutch Pump Kit # Ford 6.8L Van with A/C AA mount Disconnect the battery.
DewEze Clutch Pump Kit #700442 Ford 6.8L Van with A/C AA mount 2 0 0 6 + I N S T A L L A T I O N I N S T R U C T I O N S 1. Disconnect the battery. 2. Remove the OEM belt. Remove the fan shroud and fan.
More informationParts Manual Rev. A
115 97 25-27 Rev. A Parts Manual Z 242F / 967 844702-00 Please read the operator manual carefully and make sure you understand the instructions before using the machine. Gasoline containing a maximum of
More informationHustler X-ONE i Parts Manual
Hustler X-ONE i Parts Manual 00 South Ridge Road Hesston, Kansas 6706 Table of Contents General Information Service Literature...................................... - Options Available From Your Dealer........................
More informationCREATIVE EQUIPMENT CC 18 Main Road, Fishers Hill, Germiston, 1401 Tel: Fax:
FRAME & DRIVE IDLER ASSEMBLY REF # PART # DESCRIPTION 1 MTD603-04680A FRAME ASSY 2 MTD703-05829 DRIVE IDLER ARM 3 MTD710-0520 HEX SCREW, 3/8-16 x 1.5 4 MTD710-3005 HEX SCREW, 3/8-16 x 1.25 5 MTD712-04065
More information36 Rear Discharge Mower
FORM NO. 8 95 Rev. A Wheel Horse 6 Rear Discharge Mower for Classic Garden Tractor Model No. 7805 790000 & Up Operator s Manual IMPORTANT: Read this manual carefully. It contains information about your
More informationService Manual. Bolens 683 Series Box Frame Tractor IMPORTANT: READ SAFETY RULES AND INSTRUCTIONS CAREFULLY
Service Manual Bolens 683 Series Box Frame Tractor IMPORTANT: READ SAFETY RULES AND INSTRUCTIONS CAREFULLY This Service Manual is not a substitute for the Operator s Manual. You must read, understand and
More information25 Horsepower Hydrostatic Zero-Turn Commercial Riding Mower
MMZ 2, 260 2 Horsepower Hydrostatic Zero-Turn Commercial Riding Mower ILLUSTRATED PARTS LIST " Float Cutter Deck - Figure 1 3 1 27 32 17 6 1 11 31 36 3 19 7 23 1 33 38 18 37 22 3 20 2 10 2 12 21 30 39
More informationParts Manual Zero Turn Mower / Z
Parts Manual Zero Turn Mower / Z 246 967271501-00 Please read the operator manual carefully and make sure you understand the instructions before using the machine. When you need spare parts or support
More informationWorldlawn Power Equipment, Inc. Industrial Park 2415 Ashland Ave. Beatrice, NE Toll Free Number:
Parts Catalog R WYRZ46S/50U/60U Residential Zero Turn Mower Worldlawn Power Equipment, Inc. Industrial Park 2415 Ashland Ave. Beatrice, NE 68310 Toll Free Number: 1-800-267-4255 Table of Contents Table
More informationInstallation Instructions
Equipment Required: Fastener Kit: F Wrenches: 15/16, 10 mm Drill Bits: 1/4 Other Tools: Drill, Reciprocating Saw 9464/9474 HIDE-A-GOOSE HITCH All Fasteners Typical, Both Sides WARNING: Under no circumstances
More informationMODEL NO & UP MODEL NO & UP MODEL NO & UP MODEL NO & UP MODEL NO.
9-0688 MODEL NO. 00-800 & UP MODEL NO. 0-800 & UP MODEL NO. 5-800 & UP MODEL NO. -800 & UP MODEL NO. 0-800 & UP SKID SPRAYER with the Centrifugal Pump FORM NO. 95-9095 SET-UP AND PARTS CATALOG SAFETY AND
More informationWHEEL HORSE LAWN TRACTOR
FORM NO. 897 WHEEL HORSE LAWN TRACTOR FOR AND 8 MOWERS SET-UP INSTRUCTIONS Loose Parts Note: Use the chart below to verify all parts have been shipped. DESCRIPTION QTY. USE Front Wheel Shim Washer (as
More informationMfg. No: P216020KWV, 21" 6 TP Steel Deck Series
Parts Manual Mfg. No: 7800557 P216020KWV, 21" 6 TP Steel Deck Series Copyright Briggs and Stratton. All Rights reserved 28-Sep-2018 Model Components Table Of Contents Page Accessory Recycling Kits..............................................................................
More informationLEFT HYDRAULIC PUMP. Left Hydraulic Pump Replacement. Left Hydraulic Pump Removal. 5. Remove the pump belt from around the pump pulleys (Fig. 002).
Left Hydraulic Pump Replacement Note: Cleanliness is a key factor in a successful repair of any hydraulic system. Thoroughly clean all exposed surfaces prior to any type of maintenance. Cleaning all parts
More informationSpare parts list Trowel STG244 F TP
Spare parts list Trowel STG244 F TP Valid from serial number Valid to serial number BGF111601- www.cp.com STG244 F TP Spare parts list General information This spare parts list applies to the following:
More information74901, Z Master G3 Riding Mower, with 48in TURBO FORCE Side Discharge Mower, 2011 (SN ) : BRAKE HANDLE ASSEMBLY NO.
74901, Z Master G3 Riding Mower, with 48in TURBO FORCE Side Discharge Mower, 2011 (SN 311000001-311999999) : BRAKE HANDLE ASSEMBLY NO. 1 Page 1 of 52 74901, Z Master G3 Riding Mower, with 48in TURBO FORCE
More informationTABLE OF CONTENTS PAGE NO. DESCRIPTION
P-11549 (3-9-07) TABLE OF CONTENTS DESCRIPTION PAGE 36" DECK AND RELATED PARTS 1 48" DECK AND RELATED PARTS CASTER WHEEL ASSEMBLY 3 DECK SPINDLE ASSEMBLY 4 DECK IDLERS AND RELATED PARTS 5 DRIVE LINE PARTS
More informationWheel Horse. 52 Mowers. Model No & Up Model No & Up. Operator s Manual
FORM NO. 9-567 Wheel Horse 5 Mowers for Lawn & Garden Tractors Model No. 7880 890000 & Up Model No. 7885 890000 & Up Operator s Manual IMPORTANT: Read this manual carefully. It contains information about
More informationParts Manual EZF 3417/ Please read the operator s manual carefully and make sure you understand the instructions before using the machine.
Parts Manual EZF 3417/ 96579301 Please read the operator s manual carefully and make sure you understand the instructions before using the machine. English 200 HTC. All Rights Reserved. Beatrice, NE. Printed
More informationFORM NO REV B. Carefree Electric. 120 Volt Mower. Model No & Up. Parts Catalog
FORM NO. 3317 878 REV B Carefree Electric 120 Volt Mower Model No.20645 6900001 & Up Parts Catalog 3317 878B ORDERING REPLACEMENT PARTS To order replacement parts, please supply: the part number, the quantity,
More informationCommercial Walk-Behind Mower Fixed Deck, Pistol Grip, Gear Drive with 32in Cutting Unit
Form No. 3391-559 Rev A Commercial Walk-Behind Mower Fixed Deck, Pistol Grip, Gear Drive with 32in Cutting Unit Model No. 30632 Serial No. 315000001 and Up Register at www.toro.com. Original Instructions
More informationPage 1 of HP B&S Vanguard Engine
1405 Page 1 of 41 14 HP B&S Vanguard Engine 1405 Page 2 of 41 14 HP B&S Vanguard Engine Ref # Part Number Qty S/P/F Description BS-28Q777-0647-E1 1 14 HP B&S Vanguard Engine 1 BS-496412 1 Cylinder Assembly
More informationHANDLEBAR AND CONSOLE ASSEMBLY
Section 6 Parts List HANDLEBAR AND CONSOLE ASSEMBLY 4 33 47 4 49 7 3 78 4 97 46 44 37 38 37 48 39 35 36 34 7 3 4 5 45 4 3 4 0 33 9 96 80 6 300 84 9 5 30 4 9 30 4 3 43 97 0 43 3 68 9 9 Models 753B, F753B
More informationMZ 52LE. Parts Manual. Zero Turn Mower /
Parts Manual MZ 52LE Zero Turn Mower / 9677406-00 Please read the operator manual carefully and make sure you understand the instructions before using the machine. When you need spare parts or support
More informationParts Manual MZ5225 /
Gasoline containing up to 10% ethanol (E10) is acceptable for use in this machine. The use of any gasoline exceeding 10% ethanol (E10) will void the product warranty. Parts Manual MZ5225 / 966690502 Please
More information48 Side Discharge Mower
FORM NO. 9 650 Rev A Wheel Horse 8 Side Discharge Mower for Classic Garden Tractor Model No. 786 890000 & Up Operator s Manual IMPORTANT: Read this manual carefully. It contains information about your
More information