DTC P1515 Control Module Throttle Actuator Position Performance

Size: px
Start display at page:

Download "DTC P1515 Control Module Throttle Actuator Position Performance"

Transcription

1 Page 1 of 6 <- Back Forward -> Document ID# Chevrolet/Geo Corvette Print DTC P1515 Control Module Throttle Actuator Position Performance Refer to Cell 20: TP and APP Sensors for complete circuit details. Circuit Description The commanded throttle position (based on accelerator pedal position and possibly other limiting factors) is compared to the Actual throttle position. The 2 values should be within a calibrated range of each other. Both the PCM and the TAC module redundantly monitor the Commanded and Actual throttle position. This DTC sets if the PCM detects the problem. Conditions for Running the DTC DTCs P0601, P0602, P0604, P0606, P1516, P1517, P1518, are not set. DTCs P1120, P1220 and P1221 are not set at the same time or DTCs P1120 and P1220 are not set at the same time. The ignition switch is in the crank or run position. The ignition voltage is greater than 8.5 volts. The TAC system is not in the battery saver mode. Conditions for Setting the DTC The PCM detects that the commanded and actual throttle positions are not within a calibrated range of each other. All above conditions met for less than 1 second. Action Taken When the DTC Sets The PCM will illuminate the Malfunction Indicator Light (MIL) when this diagnostic runs and fails. The Reduced Engine Power message displays on the driver's information center. The PCM records the operating conditions at the time during which the diagnostic fails. The PCM stores this information in the Freeze Frame and/or Failure Records. If no other TAC System DTCs are set, the TAC System will operate in Reduced Engine Power mode. If certain TAC System DTCs are set at the same time, the TAC System either defaults to a more tightly restricted mode of operation if the TAC determines that limited safe operation is possible, or the TAC commands the engine to shut down. Conditions for Clearing the MIL/DTC The PCM turns OFF the MIL after three consecutive drive trips during which the diagnostic runs and does not fail. A last test failed (Current DTC) will clear when the diagnostic runs and does not fail.

2 Page 2 of 6 A History DTC clears after forty consecutive warm-up cycles, if this or any other emission related diagnostic does not report any failures. The PCM battery voltage is interrupted. Clear the MIL/DTC information using a scan tool. Diagnostic Aids Important Remove any debris from the PCM\TAC module connector surfaces before servicing the PCM\TAC module. Inspect the PCM\TAC module connector gaskets when diagnosing/replacing the modules. Ensure that the gaskets are installed correctly. The gaskets prevent contaminate intrusion into the PCM\TAC modules. For any test that requires probing the PCM or a component harness connector, use the Connector Test Adapter Kit J A. Using this kit prevents damage to the harness/component terminals. Refer to Using Connector Test Adapters in Wiring Systems. If you do not find any trouble, inspect for mechanical problems or binding that may be temperature related. Components may not move freely in extreme heat or cold due to the presence of contaminants or ice formation. The following may cause an intermittent: Poor connections; Refer to Intermittents and Poor Connections Diagnosis in Wiring Systems. Corrosion A mis-routed harness A rubbed through wire insulation Broken wire inside of the insulation Inspect the TAC module connectors for signs of water intrusion. When this occurs, multiple DTCs should be set and no circuit or component problems can be located. When the TAC module detects a problem within the TAC System, more than one TAC System related DTC may set. This is due to the many redundant tests run continuously on this system. Locating and repairing one individual problem may correct more than one DTC. Keep this in mind when reviewing captured DTC info. For an intermittent condition, refer to Symptoms. Test Description The numbers below refer to the step numbers on the diagnostic table. 5. If the TP Indicated Angle does not follow the movement of the throttle blade, and no TP Sensor DTCs are set, there is a mechanical condition with the throttle shaft or the TP Sensor. Re-install the air inlet duct after you complete the repairs. 20. When a condition is detected within the TAC System, more than one TAC System related DTC may set. This is due to the many redundant tests run continuously on this system. It is possible that locating and repairing one individual condition may correct more than one DTC. Keep this in mind when reviewing captured DTC info. DTC P Requested/Actual Throttle Position Performance (TAC) Value

3 Page 3 of 6 Step Action (s) Yes No Did you perform the Powertrain On-Board Diagnostic (OBD) System Check? Is DTC P1518 and P1221 also set? Is DTC P1221 set? 1. Turn OFF the ignition for 15 seconds. 2. Turn ON the ignition leaving the engine OFF. 3. Monitor the TP sensor 1 and 2 angle in the TAC data list using the scan tool. 4. Slowly depress the accelerator pedal to Wide Open Throttle (WOT) and then slowly return it to closed throttle. Go to Step 2 Go to Powertrain On Board Diagnostic (OBD) System Check Go to DTC P1518 Throttle Actuator Control (TAC) Module Serial Data Circuit Go to Step 3 Go to DTC P1221 Throttle Position (TP) Sensor 1-2 Correlation DTC P1221 Go to Step 4 Does the TP sensor 1 and 2 Angle increase as the pedal is depressed and then decrease as the pedal is released? 1. Turn OFF the ignition. 2. Remove the duct from the Throttle Body Assembly. Go to Diagnostic Aids Go to Step 5 5 Important Disconnecting the Throttle Actuator Control motor connector will cause additional DTCs to set. 3. Disconnect the Throttle Actuator Control motor harness connector. 4. Turn ON the ignition leaving the engine OFF. 5. Open the throttle blade to Wide Open Throttle (WOT) by hand and then close the throttle blade while observing the TP sensor 1 and 2 Angle on the scan tool. Does the TP sensor 1 and 2 Angle increase as the throttle blade is opened and decrease as the

4 Page 4 of 6 6 throttle is closed? Go to Step 6 Go to Step Turn OFF the ignition. 2. Leave the Throttle Actuator Control motor disconnected. 3. Disconnect the TAC module 16-way connector containing the Throttle Actuator control motor circuits. Refer to PCM/TAC Module Replacement. 4. Turn ON the ignition leaving the engine OFF. 5. Measure the voltage from each of the Throttle Actuator Control motor harness connector to the battery ground. Test both Throttle Actuator Control motor circuits using the DMM J Is any voltage present? Test the continuity of each of the Throttle Actuator Control motor circuit between the Throttle Actuator Control motor and the TAC module 16-way connector using the DMM J Does the DMM indicated continuity within the specified range on both circuits? Test the continuity of each Throttle Actuator Control motor circuit to battery ground using the DMM J Does the DMM indicate continuity? Test the continuity of each Throttle Actuator Control motor circuit at the TAC module harness connector and all other circuits in both TAC module connectors using the DMM J Does the DMM indicate continuity? 1. Turn OFF the ignition. 2. Reconnect the TAC Module. 3. Connect the test lamp J B between the two terminals of the Throttle Actuator Control motor harness connector. 4. Observe the test lamp as the ignition switch is turned ON. Does the test lamp illuminate briefly when the ignition is turned ON? 0-5ohms Go to Step 11 Go to Step 7 Go to Step 8 Go to Step 12 Go to Step 13 Go to Step 9 Go to Step 14 Go to Step 10 Go to Step 15 Go to Step 17

5 Page 5 of 6 11 Repair the short to voltage on the affected Throttle Actuator Control motor circuit. Refer to Wiring Repairs in Wiring Systems. Go to Step Repair the open/high resistance on the affected Throttle Actuator Control motor circuit. Refer to Wiring Repairs in Wiring Systems. Go to Step Repair the short to ground on the affected Throttle Actuator Control motor circuit. Refer to Wiring Repairs in Wiring Systems. Go to Step Repair the circuits that are shorted together. Refer to Wiring Repairs in Wiring Systems. Go to Step Inspect for poor connection at the Throttle Actuator Control motor harness connector. Refer to Intermittents and Poor Connections Diagnosis in Wiring Systems. 2. If you find a poor connection, repair the condition as necessary. Refer to Repairing Connector Terminals in Wiring Systems. Did you find and correct the condition? Go to Step 19 Go to Step Replace the throttle body assembly. Go to Step Inspect for poor connections at the TAC Module harness connectors. Refer to Intermittents and Poor Connections Diagnosis in Wiring Systems. 2. If you find a poor connection, repair the condition as necessary. Refer to Repairing Connector Terminals in Wiring Systems. Did you find and correct the condition? Go to Step 19 Go to Step Replace the TAC module. Refer to PCM/TAC Module Replacement. Go to Step 19

6 Page 6 of Select the Diagnostic Trouble Code (DTC) option and the Clear DTC Information option using the scan tool. 2. Idle the engine at the normal operating temperature. 3. Select the Diagnostic Trouble Code (DTC) option and the Specific DTC option, then enter the DTC number using the scan tool. 4. Operate the vehicle within the Conditions for Running the DTC as specified in the supporting text, if applicable. Does the scan tool indicate that this diagnostic ran and passed? Go to Step 20 Go to Step 2 20 Select the Capture Info option and the Review Info option using the scan tool. Does the scan tool display any DTCs that you have not diagnosed? Go to the applicable DTC table System OK <- Back Forward -> Document ID# Chevrolet/Geo Corvette Print

Repair content for 2005 GMC W4500 Forward

Repair content for 2005 GMC W4500 Forward Page 1 of 7 Your Current Vehicle: 2005 GMC W4500 Forward DTC P2101 DTC P2101 Circuit Description The commanded throttle position (TP), based on accelerator pedal position (APP) and possibly other limiting

More information

DTC P1518 Throttle Actuator Control (TAC) Module Serial Data Circuit

DTC P1518 Throttle Actuator Control (TAC) Module Serial Data Circuit Page 1 of 6 DTC P1518 Throttle Actuator Control (TAC) Module Serial Data Circuit Circuit Description The throttle acuator control (TAC) module and the powertrain control module (PCM) communicate via a

More information

DTC P0118 Engine Coolant Temperature (ECT) Sensor Circuit High Voltage

DTC P0118 Engine Coolant Temperature (ECT) Sensor Circuit High Voltage Document ID# 546741 2000 Chevrolet Chevy K Silverado - 4WD Print DTC P0118 Engine Coolant Temperature (ECT) Sensor Circuit High Voltage Circuit Description The engine coolant temperature

More information

Repair content for 2005 GMC W4500 Forward

Repair content for 2005 GMC W4500 Forward Page 1 of 8 Your Current Vehicle: 2005 GMC W4500 Forward DTC P2135 DTC P2135 Circuit Description The throttle position (TP) sensor incorporates two ratiometric TP sensors into one housing. TP sensor 1

More information

Document ID# Chevrolet Corvette

Document ID# Chevrolet Corvette Page 1 of 6 Document ID# 610892 2000 Chevrolet Corvette Feedback Print D T C P 0 4 6 2 F u e l L e v e l S e n s o r C i r c u i t L o w V o l t a g e C i r c u i t D e s c r i p t i

More information

DTC P1431 Fuel Level Sensor 2 Performance

DTC P1431 Fuel Level Sensor 2 Performance Page 1 of 8 Document ID# 610929 2000 Chevrolet Corvette Feedback Print DTC P1431 Fuel Level Sensor 2 Performance Circuit Description The right fuel level sensor 2, mounted in the rear

More information

DTC P Shift Solenoid Circuit Electrical

DTC P Shift Solenoid Circuit Electrical 1998 Pontiac Grand Prix DTC P0753 1-2 Shift Solenoid Circuit Electrical Circuit Description The 1-2 Shift Solenoid Valve Assembly (1-2 SS Valve Assy.) controls the transmission fluid pressure on the 1-2

More information

DTC P Shift Solenoid Circuit Electrical

DTC P Shift Solenoid Circuit Electrical 1998 Pontiac Grand Prix DTC P0753 1-2 Shift Solenoid Circuit Electrical Circuit Description The 1-2 Shift Solenoid Valve (1-2 SS Valve) controls the fluid flow acting on the 1-2 and 3-4 shift valve. The

More information

DTC P1223, P1226, P1229, P1232, P1235, P1238, P1241, or P1244

DTC P1223, P1226, P1229, P1232, P1235, P1238, P1241, or P1244 Page 1 of 5 005 Chevrolet Kodiak C-Series (Conventional) C/C5 Kodiak, TopKick C-Series Service Manual Document ID: 16600 DTC P13, P16, P1, P13, P135, P138, P11, or P1 Circuit Description The engine control

More information

DTC P0216 Injection Timing Control Circuit

DTC P0216 Injection Timing Control Circuit Page 1 of 5 1998 Chevrolet Chevy K Pickup - 4WD Chevy Pickup, GMC Pickup, Suburban, Tahoe, Yukon (VIN C/K) Service Manual Document ID: 177428 DTC P0216 Injection Timing Control Circuit Circuit Description

More information

DTC P0102 Mass Air Flow (MAF) Sensor Circuit Low Frequency

DTC P0102 Mass Air Flow (MAF) Sensor Circuit Low Frequency Seite 1 von 5 Document ID# 187823 1998 Chevrolet/Geo Tahoe - 2WD Print DTC P0102 Mass Air Flow (MAF) Sensor Circuit Low Frequency Circuit Description The mass air flow (MAF) sensor is

More information

DTC P1351 Ignition Coil Control Circuit High Voltage

DTC P1351 Ignition Coil Control Circuit High Voltage Page 1 of 5 1996 Chevrolet Chevy K Pickup - 4WD Chevy Pickup, GMC Pickup, Suburban, Tahoe, Yukon (VIN C/K) Service Manual Document ID: 34079 DTC P1351 Ignition Coil Control Circuit High Voltage Circuit

More information

DTC P0341 Camshaft Position (CMP) Sensor Performance

DTC P0341 Camshaft Position (CMP) Sensor Performance Page 1 of 5 1999 Buick Century Century, Regal VIN W Service Manual Document ID: 345654 DTC P0341 Camshaft Position (CMP) Sensor Performance Circuit Description During cranking, the Ignition Control Module

More information

DTC P0135, P0141, P0155, or P0161 (w/lr4 and LM7 w/ Delphi HO2S)

DTC P0135, P0141, P0155, or P0161 (w/lr4 and LM7 w/ Delphi HO2S) Page 1 of 5 2001 GMC Truck GMC K Sierra - 4WD Sierra, Silverado, Suburban, Tahoe, Yukon (VIN C/K) Service Manual DTC P0135, P0141, P0155, or P0161 (w/lr4 and LM7 w/ Delphi HO2S) Circuit Description This

More information

DTC P0102 Mass Air Flow (MAF) Sensor Circuit Low Frequency

DTC P0102 Mass Air Flow (MAF) Sensor Circuit Low Frequency Page 1 of 5 1997 Pontiac Grand Prix Grand Prix (VIN W) Service Manual Engine Engine Controls - 3.8L Diagnostic Information and Procedures Document ID: 106986 DTC P0102 Mass Air Flow (MAF) Sensor Circuit

More information

DTC P1415 Secondary Air Injection (AIR) System Bank 1

DTC P1415 Secondary Air Injection (AIR) System Bank 1 Page 1 of 5 2000 GMC Truck GMC K Sierra - 4WD Sierra, Silverado, Suburban, Tahoe, Yukon (VIN C/K) Service Manual Document ID: 546887 DTC P1415 Secondary Air Injection (AIR) System Bank 1 Circuit Description

More information

DTC P0201, P0202, P0203, P0204, P0205, P0206, P0207, or P0208

DTC P0201, P0202, P0203, P0204, P0205, P0206, P0207, or P0208 Page 1 of 9 2004 Chevrolet Chevy K Silverado - 4WD Sierra, Silverado (VIN C/K) Service Manual Document ID: 850614 DTC P0201, P0202, P0203, P0204, P0205, P0206, P0207, or P0208 Circuit Description The fuel

More information

1 of 6 3/7/2013 9:56 AM 2002 Chevrolet TrailBlazer - 4WD Bravada, Envoy, TrailBlazer VIN S/T Service Manual DTC P1481 Circuit Description The powertrain control module (PCM) uses the cooling fan speed

More information

DTC P0336 Crankshaft Position (CKP) Sensor Performance

DTC P0336 Crankshaft Position (CKP) Sensor Performance Page 1 of 5 1998 Chevrolet Chevy K Pickup - 4WD Chevy Pickup, GMC Pickup, Suburban, Tahoe, Yukon (VIN C/K) Service Manual Document ID: 188141 DTC P0336 Crankshaft Position (CKP) Sensor Performance Circuit

More information

DTC P0502 Vehicle Speed Sensor (VSS) Circuit Low Input (3.1L VIN M)

DTC P0502 Vehicle Speed Sensor (VSS) Circuit Low Input (3.1L VIN M) Page 1 of 5 1996 Pontiac Grand Am Achieva, Grand Am, Skylark (VIN N) Service Manual Document ID: 49145 DTC P0502 Vehicle Speed Sensor (VSS) Circuit Low Input (3.1L VIN M) Circuit Description The Vehicle

More information

2002 Buick Rendezvous - AWD

2002 Buick Rendezvous - AWD 2002 Buick Rendezvous - AWD DTC P0410 Description The control module activates the secondary air injection (AIR) system by grounding both the pump relay and the vacuum control solenoid control circuits.

More information

DTC P1406 Exhaust Gas Recirculation (EGR) Position Sensor Performance

DTC P1406 Exhaust Gas Recirculation (EGR) Position Sensor Performance 1996 Chevrolet Blazer - 4WD DTC P1406 Exhaust Gas Recirculation (EGR) Position Sensor Performance Circuit Description The VCM constantly monitors the linear EGR valve pintle position sensor in order to

More information

2002 Chevrolet Silverado 1500

2002 Chevrolet Silverado 1500 For the specific DTCs required for each system, see table. Systems such as fuel delivery, misfire, and comprehensive components may not be listed in a system status list. These tests run continuously on

More information

Document ID: General Motors Corporation. All rights reserved.

Document ID: General Motors Corporation. All rights reserved. Page 1 of 6 2005 Chevrolet TrailBlazer - 4WD Envoy, Rainier, TrailBlazer, Ascender (VIN S/T) Service Manual Document ID: 1489377 DTC P0053 or P0054 Circuit Description The heated oxygen sensor (HO2S) must

More information

Fuel Pump Electrical Circuit Diagnosis

Fuel Pump Electrical Circuit Diagnosis Page 1 of 6 Document ID# 599891 2000 Chevrolet Camaro Feedback Print Fuel Pump Electrical Circuit Diagnosis Circuit Description When the ignition switch is ON, the powertrain control

More information

DTC P1336 Crankshaft Position (CKP) System Variation Not Learned

DTC P1336 Crankshaft Position (CKP) System Variation Not Learned Page 1 of 5 Document ID# 243256 1998 Chevrolet/Geo Express Print DTC P1336 Crankshaft Position (CKP) System Variation Not Learned Circuit Description The crankshaft position (CKP) sensor

More information

DTC P0172 Fuel Trim System Rich

DTC P0172 Fuel Trim System Rich Page 1 of 6 1997 Chevrolet Cavalier Cavalier, Sunfire (VIN J) Service Manual Document ID: 47788 DTC P0172 Fuel Trim System Rich System Description A Closed Loop air/fuel metering system is used to provide

More information

No signal from the CMP sensor for 3 seconds with the PCM receiving an engine start signal.

No signal from the CMP sensor for 3 seconds with the PCM receiving an engine start signal. DTC P0340 Circuit Description The DTC P0340 Camshaft Position (CMP) Sensor Circuit diagnostic monitors the output of the CMP sensor. The CMP sensor is located in the distributor and consists of a signal

More information

DTC P1404 Exhaust Gas Recirculation (EGR) Closed Position Performance

DTC P1404 Exhaust Gas Recirculation (EGR) Closed Position Performance Page 1 of 5 DTC P1404 Exhaust Gas Recirculation (EGR) Closed Position Performance Circuit Description The PCM monirs the EGR valve pintle position input ensure that the valve responds properly commands

More information

DTC P0341 Camshaft Position (CMP) Sensor Performance

DTC P0341 Camshaft Position (CMP) Sensor Performance Page 1 of 7 1997 Buick Riviera Aurora, Riviera (VIN G) Service Manual Document ID: 53298 DTC P0341 Camshaft Position (CMP) Sensor Performance Circuit Description The camshaft position PCM input is produced

More information

DTC P1655 Evaporative Emission (EVAP) Purge Solenoid Control Circuit

DTC P1655 Evaporative Emission (EVAP) Purge Solenoid Control Circuit Page 1 of 5 1997 Pontiac Grand Am Achieva, Grand Am, Skylark (VIN N) Service Manual Document ID: 58460 DTC P55 Evaporative Emission (EVAP) Purge Solenoid Control Circuit Circuit Description Output Driver

More information

DTC P1811 Maximum Adapt and Long Shift

DTC P1811 Maximum Adapt and Long Shift 2000 Buick Century DTC P1811 Maximum Adapt and Long Shift Circuit Description The transmission pressure is modified by an adaptive modifier which controls the shift execution time. This test checks the

More information

The engine is running. DTC P0351, P0352, P0353, and P0354 run continuously once the above condition has been met.

The engine is running. DTC P0351, P0352, P0353, and P0354 run continuously once the above condition has been met. Page 1 of 6 DTC P0351-P0354 Circuit Description DTCs P0351 through P0354 Ignition Coil Primary/Secondary Feedback Circuit diagnostic monitors the primary circuitry of individual ignition coils for the

More information

DTC P0341 Camshaft Position (CMP) Sensor Performance

DTC P0341 Camshaft Position (CMP) Sensor Performance Page 1 of 5 1998 Chevrolet Cavalier : Diagnostics > Diagnostic Routines > Powertrain > Engine Controls - 2.2L > DTC P0341 Camshaft Position (CMP) Sensor Performance DTC P0341 Camshaft Position (CMP) Sensor

More information

Idle Air Control (IAC) System Diagnosis

Idle Air Control (IAC) System Diagnosis Page 1 of 6 2002 Chevrolet Tahoe - 4WD Avalanche, Escalade, Suburban, Tahoe, Yukon VIN C/K Service Manual Engine Engine Controls - 4.8L, 5.3L, and 6.0L Diagnostic Information and Procedures Document ID:

More information

1999 Chevrolet Tahoe - 4WD. DTC P1345 Crankshaft Position (CKP)-Camshaft Position (CMP) Correlation

1999 Chevrolet Tahoe - 4WD. DTC P1345 Crankshaft Position (CKP)-Camshaft Position (CMP) Correlation 1999 Chevrolet Tahoe - 4WD DTC P1345 Crankshaft Position (CKP)-Camshaft Position (CMP) Correlation Circuit Description This diagnostic trouble code (DTC) monitors the crankshaft position (CKP) and the

More information

If the PCM detects a counter value of two during one trip, then DTC P1811 sets. DTC P1811 is a type C DTC.

If the PCM detects a counter value of two during one trip, then DTC P1811 sets. DTC P1811 is a type C DTC. Page 1 of 6 2001 Pontiac Montana Montana, Silhoutte, Venture (VIN U) Service Manual Document ID: 654706 DTC P1811 Circuit Description The transmission pressure is modified by an adaptive modifier which

More information

# : SMU - Revised DTC P0201-P (Sep 16, 2002)

# : SMU - Revised DTC P0201-P (Sep 16, 2002) Page 1 of 8 2001 Chevrolet Chevy K Silverado - 4WD Sierra, Silverado, Suburban, Tahoe, Yukon (VIN C/K) Service Manual #02-06-04-049: SMU - Revised DTC P0201-P0208 - (Sep 16, 2002) Subject: Revised DTC

More information

Distributor Ignition DI System Diagnosis

Distributor Ignition DI System Diagnosis Page 1 of 8 2004 Chevrolet K Silverado - 4WD Sierra, Silverado VIN C/K Service Manual Engine Engine Controls - 4.3L Diagnostic Information and Procedures Document ID: 848577 Distributor Ignition DI System

More information

DTC P0743 sets when the TCM detects an open circuit, a short to power, or a short to ground in the TCC PWM solenoid circuit for 1.5 seconds.

DTC P0743 sets when the TCM detects an open circuit, a short to power, or a short to ground in the TCC PWM solenoid circuit for 1.5 seconds. Page 1 of 5 2005 GMC Truck GMC K Sierra - 4WD Sierra, Silverado VIN C/K Service Manual Document ID: 1492351 DTC P0743 Circuit Description The torque converter clutch (TCC) solenoid is a pulse width modulated

More information

Idle Air Control (IAC) System Diagnosis

Idle Air Control (IAC) System Diagnosis 2001 Oldsmobile Alero Idle Air Control (IAC) System Diagnosis Circuit Description The idle air control (IAC) valve is located in the throttle body. It consists of a movable pintle, driven by a gear attached

More information

Cruise Control Diagnosis

Cruise Control Diagnosis 1999 Pontiac Firebird Cruise Control Diagnosis Circuit Description The Cruise Control system is a speed control system that maintains a desired vehicle speed under normal driving conditions. The cruise

More information

1 of 14 9/4/2016 4:05 PM

1 of 14 9/4/2016 4:05 PM 1 of 14 9/4/2016 4:05 PM P0068-MANIFOLD PRESSURE/THROTTLE POSITION CORRELATION P0068-Manifold Pressure/Throttle Position Correlation Theory of Operation This DTC sets when an unexpected high intake manifold

More information

Symptom: P0068-MANIFOLD PRESSURE/THROTTLE POSITION CORRELA- TION - VACUUM LEAK DETECTED

Symptom: P0068-MANIFOLD PRESSURE/THROTTLE POSITION CORRELA- TION - VACUUM LEAK DETECTED Symptom: P0068-MANIFOLD PRESSURE/THROTTLE POSITION CORRELA- TION - VACUUM LEAK DETECTED When Monitored and Set Condition: VAC- UUM LEAK DETECTED When Monitored: During all drive modes. Set Condition: If

More information

SCHEMATIC AND ROUTING DIAGRAMS

SCHEMATIC AND ROUTING DIAGRAMS 2004 ACCESSORIES & EQUIPMENT Cruise Control - Corvette SCHEMATIC AND ROUTING DIAGRAMS CRUISE CONTROL SCHEMATICS Fig. 1: Cruise Control Switch, Throttle Actuator Control Motor And Cruise Control Release

More information

Engine Cranks But Does Not Run

Engine Cranks But Does Not Run Page 1 of 5 2000 GMC Truck GMC K Sierra - 4WD Sierra, Silverado, Suburban, Tahoe, Yukon (VIN C/K) Service Manual Engine Engine Controls - 4.8L, 5.3L, and 6.0L Diagnostic Information and Procedures Engine

More information

P0222-THROTTLE POSITION SENSOR 2 CIRCUIT LOW

P0222-THROTTLE POSITION SENSOR 2 CIRCUIT LOW - RT - DODGE CARAVAN -.L V V.V.T. P- POSITION SENSOR CIRCUIT LOW 5 VOLT SUPPLY CONTROL 5 VOLT SUPPLY 5 VOLT SUPPLY APPS SENSOR APPS APPS SENSOR APPS SENSOR- ACCELERATOR PEDAL POSITION 9 C 5 K855 K85 K7

More information

DTC P0420. Circuit Description. Conditions for Running the DTC.

DTC P0420. Circuit Description. Conditions for Running the DTC. Page 1 of 5 DTC P0420 2003 Buick LeSabre LeSabre (VIN H) Service Manual Document ID: 792202 Circuit Description In order to control emissions of hydrocarbons (HC), carbon monoxide (CO), and oxides of nitrogen

More information

2007 Hummer H TRANSMISSION Manual Transmission - Aisin AR5 - H3. Fastener Tightening Specifications Specification Application

2007 Hummer H TRANSMISSION Manual Transmission - Aisin AR5 - H3. Fastener Tightening Specifications Specification Application 2007 TRANSMISSION Manual Transmission - Aisin AR5 - H3 SPECIFICATIONS FASTENER TIGHTENING SPECIFICATIONS Fastener Tightening Specifications Specification Application Metric English Backup Lamp Switch 44

More information

Scan Tool Does Not Communicate with Class 2 Device (W/O Immobilizer)

Scan Tool Does Not Communicate with Class 2 Device (W/O Immobilizer) Page 1 of 5 2002 GMC Truck Envoy - 4WD Bravada, Envoy, TrailBlazer (VIN S/T) Service Manual Body and Accessories Data Link Communications Diagnostic Information and Procedures Document ID: 754548 Scan

More information

Enhanced Ignition System Diagnosis

Enhanced Ignition System Diagnosis Page 1 of 7 1998 Chevrolet Chevy K Pickup - 4WD Chevy Pickup, GMC Pickup, Suburban, Tahoe, Yukon (VIN C/K) Service Manual Engine Engine Controls - 5.0L and 5.7L Diagnostic Information and Procedures Enhanced

More information

2003 Chevrolet S10 - Engine Performance & Emission Controls > Engine Controls - 4.3L > Diagn...

2003 Chevrolet S10 - Engine Performance & Emission Controls > Engine Controls - 4.3L > Diagn... Page 1 of 7 2003 Chevrolet S10 : Engine Performance & Emission Controls > Engine Controls -4.3L > Diagnostic Information And Procedures > DTC P0442 DTC P0442 DTC P0442 System Description This diagnostic

More information

Control Module Command EVAP Canister Purge Valve EVAP Canister Vent Valve ON Open Closed OFF Closed Open

Control Module Command EVAP Canister Purge Valve EVAP Canister Vent Valve ON Open Closed OFF Closed Open DTC P0440 System Description The control module tests the evaporative emission (EVAP) system for a large leak. The control module monitors the fuel tank pressure (FTP) sensor signal to determine the EVAP

More information

Fuel Pump Electrical Circuit Diagnosis

Fuel Pump Electrical Circuit Diagnosis 1999 Chevrolet/Geo Tahoe - 4WD Fuel Pump Electrical Circuit Diagnosis Refer to Fuel Controls. Circuit Description When the ignition switch is turned ON, the VCM energizes the fuel pump relay which powers

More information

DTC P0420 or P0430. Circuit Description. DTC Descriptors. Conditions for Running the DTC

DTC P0420 or P0430. Circuit Description. DTC Descriptors. Conditions for Running the DTC Page 1 of 5 2005 Cadillac STS STS (VIN D) Service Manual Engine Engine Controls - 4.6L (LH2) Diagnostic Information and Procedures DTC P0420 or P0430 Circuit Description A three-way catalytic converter

More information

Idle Air Control (IAC) System Diagnosis

Idle Air Control (IAC) System Diagnosis 2000 GMC Truck GMC K Sierra - 4WD Idle Air Control (IAC) System Diagnosis Circuit Description The vehicle control module (VCM) controls idle RPM with the idle air control (IAC) valve. To increase idle

More information

The engine control module (ECM) uses the following information to calculate an expected airflow rate.

The engine control module (ECM) uses the following information to calculate an expected airflow rate. DTC Descriptors DTC Mass Air Flow (MAF) sensor performance Circuit/System Description The engine control module (ECM) uses the following information to calculate an expected airflow rate. The throttle

More information

# : Revised Engine Cranks But Does Not Run Diagnostic - (Sep 26, 2003)

# : Revised Engine Cranks But Does Not Run Diagnostic - (Sep 26, 2003) #03-06-04-046: Revised Engine Cranks But Does Not Run - (Sep 26, 2003) Subject: Revised Engine Cranks But Does Not Run Models: 2001-2004 Chevrolet Silverado 2003-2004 Chevrolet Kodiak 2001-2004 GMC Sierra

More information

# : SMU - Revised DTC P0341 Camshaft Position (CMP) Sensor Performance - (Feb 20, 2002)

# : SMU - Revised DTC P0341 Camshaft Position (CMP) Sensor Performance - (Feb 20, 2002) Page 1 of 7 2002 Buick Regal Century, Regal (VIN W) Service Manual Engine Document ID: 861441 #02-06-04-008: SMU - Revised DTC P0341 Camshaft Position (CMP) Sensor Performance - (Feb 20, 2002) Subject:

More information

DTC P0657 Actuator Supply Voltage Circuit / Open

DTC P0657 Actuator Supply Voltage Circuit / Open 1GR-FE EINE CONTROL SYSTEM SFI SYSTEM 277 DTC P0657 Actuator Supply Voltage Circuit / Open MONITOR DCRIPTION The ECM monitors the output voltage to the throttle actuator. This self-check ensures that the

More information

2007 Chevrolet Corvette STEERING Steering Wheel and Column - Corvette. Steering Wheel and Column - Corvette

2007 Chevrolet Corvette STEERING Steering Wheel and Column - Corvette. Steering Wheel and Column - Corvette 2007 STEERING Steering Wheel and Column - Corvette SPECIFICATIONS FASTENER TIGHTENING SPECIFICATIONS Fastener Tightening Specifications Specification Application Metric English Actuator Retaining Screws

More information

Alternative Fuel Engine Control Unit

Alternative Fuel Engine Control Unit 1999 Chevrolet/Geo Cavalier (CNG) Alternative Fuel Engine Control Unit Table 1: AF ECU Function Parameters The (AF ECU) controls alternative fuel engine operation. The control unit monitors various engine

More information

CONDITIONS FOR RUNNING THE DTC

CONDITIONS FOR RUNNING THE DTC SYSTEM DESCRIPTION The powertrain control module (PCM) uses information from the crankshaft position (CKP) sensor and the camshaft position (CMP) sensor in order to determine when an engine misfire is

More information

DTC P0174 Fuel Trim System Lean Bank 2

DTC P0174 Fuel Trim System Lean Bank 2 2000 Chevrolet/Geo S10 Pickup - 4WD DTC P0174 Fuel Trim System Lean Bank 2 Circuit Description In order to provide the best possible combination of driveability, fuel economy, and emission control, the

More information

DRIVEABILITY - GAS. All symptoms listed above are diagnosed using the same tests. The title for the tests will be P0300-MULTIPLE CYLINDER MIS-FIRE.

DRIVEABILITY - GAS. All symptoms listed above are diagnosed using the same tests. The title for the tests will be P0300-MULTIPLE CYLINDER MIS-FIRE. Symptom List: P0300-MULTIPLE CYLINDER MIS-FIRE P0301-CYLINDER #1 MISFIRE P0302-CYLINDER #2 MISFIRE P0303-CYLINDER #3 MISFIRE P0304-CYLINDER #4 MISFIRE P0305-CYLINDER #5 MISFIRE P0306-CYLINDER #6 MISFIRE

More information

Active Grille Air Shutter 1 Malfunction

Active Grille Air Shutter 1 Malfunction Page 1 of 5 Active Grille Air Shutter 1 Malfunction 2015 Cadillac ATS 2.0L Eng Premium Print Date: Diagnostic Instructions Perform the Diagnostic System Check - Vehicle prior to using this diagnostic procedure.

More information

Fuel System Diagnosis

Fuel System Diagnosis Page 1 of 6 2001 Chevrolet Malibu Malibu (VIN N) Service Manual Engine Engine Controls - 3.1L (LG8) Diagnostic Information and Procedures Document ID: 704675 Fuel System Diagnosis System Description When

More information

Cruise Control Inoperative/Malfunctioning (WO/ETC)

Cruise Control Inoperative/Malfunctioning (WO/ETC) Cruise Control Inoperative/Malfunctioning (WO/ETC) Diagnostic Aids Important: Perform the following in order to avoid misdiagnosis. Inspect for proper operation of brake lamps and clutch switch, if equipped.

More information

System Description. Diagnostic Aids. Enhanced Ignition System Diagnosis

System Description. Diagnostic Aids. Enhanced Ignition System Diagnosis Enhanced Ignition System Diagnosis System Description This system includes the distributor, the CAM position sensor ignition coil with the ignition coil driver, the secondary wires, spark plugs, the knock

More information

P0123-THROTTLE POSITION SENSOR 1 CIRCUIT HIGH

P0123-THROTTLE POSITION SENSOR 1 CIRCUIT HIGH - DS - RAM PICKUP -.7L MAGNUM V8 8 - DTC-Based Diagnostics/MODULE, Powertrain Control (PCM), NGC/Diagnosis and Testing P- POSITION SENSOR CIRCUIT HIGH VOLT SUPPLY MODULE- POWERTRAIN CONTROL 9 C F8 PK/YL

More information

Dtc P128E. Print Chevrolet Silverado 6.6L Eng 2500 Hd. 1Search P128E REQUESTED INFORMATION. Diagnostic Instructions

Dtc P128E. Print Chevrolet Silverado 6.6L Eng 2500 Hd. 1Search P128E REQUESTED INFORMATION. Diagnostic Instructions Print 1Search REQUESTED INFORMATION Dtc Diagnostic Instructions 2012 Chevrolet Silverado 6.6L Eng 2500 Hd Perform the Diagnostic System Check - Vehicle prior to using this diagnostic procedure. Review

More information

D2 - RAM 3500 PICKUP - 6.7L CUMMINS TURBO DIESEL

D2 - RAM 3500 PICKUP - 6.7L CUMMINS TURBO DIESEL 0 - D - RAM 00 PICKUP -.7L CUMMINS TURBO DIESEL PB-O SENSOR / CELL CIRCUIT OPEN BATT A0 B(+) ELECTRONICS TOTALLY INTEGRATED POWER FUSED IGNITION SWITCH OUTPUT (RUN-START) PORT LOW PORT HIGH POWER 7 C 7

More information

P0340-CAMSHAFT POSITION SENSOR CIRCUIT - BANK 1 SENSOR 1

P0340-CAMSHAFT POSITION SENSOR CIRCUIT - BANK 1 SENSOR 1 11 - RT - CHRYSLER TOWN AND COUNTRY - 3.6L V6 V.V.T. P0340-CAMSHAFT POSITION SENSOR CIRCUIT - BANK 1 SENSOR 1 S109 K856 BR/YL K856 BR/YL 2 SENSOR CAMSHAFT POSITION 2 SENSOR CAMSHAFT POSITION 2 1 4 3 3

More information

DTC B0228, B0413, B0423, Or B3779

DTC B0228, B0413, B0423, Or B3779 2007 Chevrolet Silverado 1500 : Heating, Ventilation, & Air Conditioning > HVAC Systems - Manual > Diagnostic Information And Procedures > DTC B0228, B0413, B0423, Or B3779 DTC B0228, B0413, B0423, Or

More information

SCHEMATIC AND ROUTING DIAGRAMS

SCHEMATIC AND ROUTING DIAGRAMS 2004 ACCESSORIES & EQUIPMENT Theft Deterrent - Corvette SCHEMATIC AND ROUTING DIAGRAMS THEFT DETERRENT SYSTEM SCHEMATICS Fig. 1: Theft Deterrent Relay, Security Indicator, Lighting and Horn References

More information

P0441-EVAP PURGE SYSTEM PERFO... P0441-EVAP PURGE SYSTEM PERFORMANCE

P0441-EVAP PURGE SYSTEM PERFO... P0441-EVAP PURGE SYSTEM PERFORMANCE P0441-EVAP PURGE SYSTEM PERFO... P0441-EVAP PURGE SYSTEM PERFORMANCE For a complete wiring diagram, refer to the Wiring Information. Theory of Operation EVAP SYSTEM COMPONENTS CALLOUT DESCRIPTION 1 Filter

More information

DJ - RAM 2500 PICKUP - 6.7L I6 CUMMINS TURBO DIESEL

DJ - RAM 2500 PICKUP - 6.7L I6 CUMMINS TURBO DIESEL 2013 - DJ - RAM 2500 PICKUP - 6.7L I6 CUMMINS TURBO DIESEL 1 P202E-(DIESEL EXHAUST FLUID) REDUCTANT PERFORMANCE MODULE- POWERTRAIN CONTROL SIGNAL 77 K428 DB RETURN 53 C2 K426 DB/LG 1 SIGNAL 2 RETURN -

More information

U010C-LOST COMMUNICATION WITH TURBOCHARGER/ SUPERCHARGER CONTROL MODULE

U010C-LOST COMMUNICATION WITH TURBOCHARGER/ SUPERCHARGER CONTROL MODULE 2014 - D2 - RAM 3500 PICKUP - 6.7L I6 CUMMINS TURBO DIESEL U010C-LOST COMMUNICATION WITH TURBOCHARGER/ SUPERCHARGER CONTROL MODULE For a complete wiring diagram, refer to the Wiring Information. IGN RELAY-

More information

DTC P2118 THROTTLE ACTUATOR CONTROL MOTOR CURRENT RANGE/PERFORMANCE

DTC P2118 THROTTLE ACTUATOR CONTROL MOTOR CURRENT RANGE/PERFORMANCE 0560 05NY0 DTC P8 THROTTLE ACTUATOR CONTROL MOTOR CURRENT RANGE/PERFORMANCE CIRCUIT DESCRIPTION The Electronic Throttle Control System (ETCS) has a dedicated power supply circuit. The voltage () is monitored

More information

DTC P3401, P3425, P3441, or P3449

DTC P3401, P3425, P3441, or P3449 Page 1 of 5 2008 Chevrolet Avalanche - 4WD Avalanche, Escalade, Suburban, Tahoe, Yukon VIN C/K Service Manual Document ID: 1914310 DTC,,, or Diagnostic Instructions Perform the Diagnostic System Check

More information

2001 Chevrolet Corvette ACCESSORIES & EQUIPMENT Cruise Control Systems - Corvette

2001 Chevrolet Corvette ACCESSORIES & EQUIPMENT Cruise Control Systems - Corvette 2001 ACCESSORIES & EQUIPMENT Cruise Control Systems - Corvette DESCRIPTION Cruise control is a speed control system that maintains a desired vehicle speed under normal driving conditions. Steep grades

More information

1GR-FE ENGINE CONTROL SYSTEM SFI SYSTEM

1GR-FE ENGINE CONTROL SYSTEM SFI SYSTEM 1GR-FE ENGINE CONTROL SYSTEM SFI SYSTEM 299 P2120 Throttle / Pedal Position Sensor / Switch "D" Circuit P2122 Throttle / Pedal Position Sensor / Switch "D" Circuit Low Input P2123 Throttle / Pedal Position

More information

DTC P0300-P0308. Diagnostic Instructions. DTC Descriptors. Circuit/System Description. Conditions for Running the DTC

DTC P0300-P0308. Diagnostic Instructions. DTC Descriptors. Circuit/System Description. Conditions for Running the DTC Page 1 of 5 2009 GMC Truck Sierra - 2WD Sierra, Silverado (VIN C/K) Service Manual Engine Engine Mechanical - 4.8L, 5.3L, 6.0L, 6.2L, or 7.0L Description and Operation DTC P0300-P0308 Diagnostic Instructions

More information

DTC P0171, P0172, P0174, or P0175

DTC P0171, P0172, P0174, or P0175 Page 1 of 6 2009 Pontiac G8 G8 Service Manual Document ID: 2076050 DTC P0171, P0172, P0174, or P0175 Diagnostic Instructions Perform the Diagnostic System Check - Vehicle prior to using this diagnostic

More information

P0401-EGR SYSTEM PERFORMANCE

P0401-EGR SYSTEM PERFORMANCE P0401-EGR SYSTEM PERFORMANCE P0401-EGR SYSTEM PERFORMANCE http://dh.identifix.com/searchfixes/index?roid=176514061&vid=2189101&vsm=2&locationid=2#kw=p0401&soption=1&vetid=8&stmode=1&p 1/6 For a complete

More information

Fuel System Diagnosis

Fuel System Diagnosis 2000 Chevrolet Corvette Corvette (VIN Y) Service Manual Document ID: 609667 Page 1 of 7 Fuel Diagnosis (1) Fuel Feed Pipe (2) Auxiliary Fuel Feed Rear Pipe (left tank to jet pump) (3) Auxiliary Fuel Return

More information

P245C REQUESTED INFORMATION P245C EGR COOLER BYPASS CONTROL CIRCUIT LOW RAM Pickup 6.7L Eng /12/2014 Printer Friendly View

P245C REQUESTED INFORMATION P245C EGR COOLER BYPASS CONTROL CIRCUIT LOW RAM Pickup 6.7L Eng /12/2014 Printer Friendly View P245C 2012 RAM Pickup 6.7L Eng 2500 REQUESTED INFORMATION P245C EGR COOLER BYPASS CONTROL CIRCUIT LOW http://www1.prodemand.com/print/index?content=tabs&module=true&tab=true&terms=true&ymms=false&classname=

More information

Component Tests P2106. Component Tests Mazda RX 8 1.3L Eng. 1Search

Component Tests P2106. Component Tests Mazda RX 8 1.3L Eng. 1Search 1Search 2004 Mazda RX 8 1.3L Eng Component Tests P2106 P2106 indicates throttle actuator Control system malfunction (forced limited power). PCM monitors throttle actuator Control current when ignition

More information

Page 1 of 5 1Search Print Date: P0179 DTC P0179: Fuel Composition Sensor Circuit High Frequency Diagnostic Instructions Perform the Diagnostic System Check - Vehicle prior to using this diagnostic procedure.

More information

1998 ENGINE PERFORMANCE. General Motors Corp. - Basic Diagnostic Procedures - 5.7L

1998 ENGINE PERFORMANCE. General Motors Corp. - Basic Diagnostic Procedures - 5.7L INTRODUCTION 1998 ENGINE PERFORMANCE General Motors Corp. - Basic Diagnostic Procedures - 5.7L The following diagnostic steps will help prevent overlooking a simple problem. This is also where to begin

More information

1 of 8 9/11/2015 3:59 PM

1 of 8 9/11/2015 3:59 PM 1 of 8 9/11/2015 3:59 PM P013C-O2 SENSOR 2/2 SLOW RESPONSE - RICH TO LEAN For complete wiring diagrams refer to Diagrams/Electrical. - When Monitored: With the engine running, vehicle speed between 32

More information

POWERTRAIN CONTROL MODULE (PCM) - NGC

POWERTRAIN CONTROL MODULE (PCM) - NGC 2011 Dodge or Ram Truck Grand Caravan V6-3.6L Vehicle > ALL Diagnostic Trouble Codes ( DTC ) > Testing and Inspection > P Code Charts > P0128 POWERTRAIN CONTROL MODULE (PCM) - NGC P0128-THERMOSTAT RATIONALITY

More information

P0365-CAMSHAFT POSITION SENSOR CIRCUIT - BANK 1 SENSOR 2

P0365-CAMSHAFT POSITION SENSOR CIRCUIT - BANK 1 SENSOR 2 3 - JC - DODGE JOURNEY - 2.4L 4 CYL DOHC 6V DUAL V.V.T. P0365-CAMSHAFT POSITION CIRCUIT - BANK 2 MODULE- CMP /2 CMP / CKP CKP CMP / CMP /2 POWERTRAIN 85 C2 22 C 67 C2 87 C2 62 C2 66 C2 88 C2 86 C2 67 C2

More information

P0688-AUTO SHUTDOWN SENSE CIRCUIT LOW

P0688-AUTO SHUTDOWN SENSE CIRCUIT LOW - DS - RAM 5 PICKUP - 5.7L V HEMI MDS V.V.T. (EZH) P6- SHUTDOWN SENSE CIRCUIT LOW BATT A B(+) ELECTRONICS TOTALLY INTEGRATED POWER 5 SHUT DOWN 6 FUSE M 5A C C5 K5 C C K5 S4 C 4.7L/ C C C.7L 5.7L S S4 BLACK/BLACK

More information

2008 Hummer H2 - Engine Performance & Emission Controls > Engine Controls - 4.8L, 5.3L,

2008 Hummer H2 - Engine Performance & Emission Controls > Engine Controls - 4.8L, 5.3L, Page 1 of 7 2008 Hummer H2 : Engine Performance & Emission Controls > Engine Controls - 4.8L, 5.3L, 6.0L, 6.2L, Or 7.0L > Diagnostic Information And Procedures > DTC P0011 DTC P0011 DTC P0011 Diagnostic

More information

Inspection/Maintenance Evaporative Emission System Set

Inspection/Maintenance Evaporative Emission System Set Page 1 of 5 2001 Chevrolet S10 Pickup - 2WD Blazer, Bravada, Envoy, Jimmy, S10 Pickup, Sonoma VIN S/T Service Manual Engine Engine Controls - 2.2L L43 Diagnostic Information and Procedures Document ID:

More information

DESCRIPTION & OPERATION

DESCRIPTION & OPERATION DESCRIPTION & OPERATION ANTI-LOCK BRAKING 1998-99 BRAKES Anti-Lock/TCS - Corvette The Anti-Lock Brake System (ABS) and Traction Control System (TCS) increases vehicle control during severe deceleration

More information

#97-T-20A: MIL (Service Engine Soon Telltale Lamp) On and EGR DTCs P0401, P0404, P0405, P1404 and/or P1406 in PCM Memory - (Jan 6, 2003)

#97-T-20A: MIL (Service Engine Soon Telltale Lamp) On and EGR DTCs P0401, P0404, P0405, P1404 and/or P1406 in PCM Memory - (Jan 6, 2003) #97-T-20A: MIL (Service Engine Soon Telltale Lamp) On and EGR DTCs P0401, P0404, P0405, P1404 and/or P1406 in PCM Memory - (Jan 6, 2003) Subject: Malfunction Indicator Lamp (SERVICE ENGINE SOON Telltale

More information

Page 1 of 11 2009 Hummer H2 6.2L Eng 1Search Print Date: SHIFT LOCK CONTROL SYSTEM Repair Instructions Automatic Transmission Shift Lock Control Actuator Replacement Removal Procedure NOTE: After assembling

More information

SECTION 5 DIAGNOSTIC TROUBLE CODES (DTC)

SECTION 5 DIAGNOSTIC TROUBLE CODES (DTC) 5 1. DTC MEMORY SECTION 5 Diagnostic Trouble Codes (DTCs) are logged in a list in TCM memory. The DTCs contained in the list have information recorded as shown in Table 5 1 (DTC example). The TCM is capable

More information