Models Fitted with the MK Motor

Size: px

Start display at page:

Download "Models Fitted with the MK Motor"

Patrick Samuel Golden
6 years ago
Views:

1 OWNER SMANUAL MINI50 GP MINISP70 GP Models Fitted with the MK Motor

2 WARNING THIS VEHICLE IS DESIGNED AND MANUFACTURED FOR COMPETITION USE ONLY. IT DOES NOT CONFORM TO THE SAFETY MEASURES OF A HOMOLOGATED VEHICLE FOR PUBLIC ROADS. ITS USE ON STREETS, ROADS OR HIGHWAYS IS ILLEGAL. THE LAW PROHIBITS THE OPERATION OF THIS VEHICLE EXCEPT IN CLOSE CIRCUITS OR IN ORGANIZED COMPETITIVE EVENTS. THIS MOTORCYCLE IS SOLD WITHOUT WARRANTY. ANY DEFECT DETECTED AFTER PURCHASE THE BUYER ASSUMES ALONE THE ENTIRE COST OF REPAIR AS WELL AS NECESSARY MATERIAL. MAINTAINANCE WHEN RIDING THE NEW MACHINE IT IS NECESSARY TO DO A RUNNING BELOW RPM DURING ONE HOUR. A 30 MINUTES RUNNING SHOULD BE DONE WHEN THE THERMODYNAMIC GROUP IS NEW. TIGHTEN THE AXLES AND THE FRAME SCREWS AFTER EVERY TIME YOU USE THE VEHICLE. THE CYLINDER SHOULD BE DISASSEMBLED TO CHECK THE NEEDLE BEARINGS, PIN, RING, SPARKING PLUG AND TO REPLACE GASKETS EVERY.000 KMS OF FUNCTIONING. THE VEHICLE HAS STANDARD CARBURETTOR ADJUSTMENTS. IT SHOULD BE ADJUSTED TO WEATHER CONDITIONS, TEMPERATURE AND ATMOSPHERE PRESSURE. THE FUNCTIONING AND ANCHORAGE OF THE FRONT AND REAR BRAKES SHOULD BE CHECKED BEFORE GOING OUT TO THE TRACK. IF THE BRAKE LEVER S TACT IS SPONGY YOU SHOULD DRAIN THE SYSTEM. CHECK REGULARLY THE BRAKE PADS WEARING AWAY. THE CHAIN S TIGHTEN IS MEASURE IN THE FOOTREST ZONE A SEPARATION OF 20 MM +/- 5 MM SHOULD BE LEFT BETWEEN THE CHAIN AND THE SWING ARM. DUE TO THE MATERIAL WITH WHICH THE FUEL TANK IS DONE, IT SHOULD BE CHECKED REGULARLY TO CLEAN SMALL FIBRE PARTS THAT COULD LOOSEN AS WELL AS CHECKING THE FUEL VALVE AND CLEARING THE FILTER. VERIFY THE DRIVE CAP S PLAY. IN CASE THERE IS PLAY, IT SHOULD BE RETIGHTEN ( KG.). IN CASE OF REPLACING THE OIL OF THE FORK THE QUANTITY IS OF 80 ML (0.048 G) SAE 5 CHECK OFTEN THE FIBRE S FASTENINGS. THE HANDLEBARS TIGHTEN SHOULD BE CHECKED PERIODICALLY.

3 TORQUE WRENCH SETTING GENERAL SCREW NUT M M6 0.8 M7.7.3 M M ENGINE THREAD WRENCH KG SEALING HEAD NUT 7X00.7 CYLINDER STUD TO CRANKBASE 7X00 2. BLUE CYLINDER HEAD STUD 7X00.8 BLUE CYLINDER BASE NUT 7X00.7 IGNITION NUT 2X PRIMARY NUT 2X BLUE BALANCE SHAFT NUT 0X GREEN CLUTCH BELL NUT 5X50 6 BLUE CLUTCH SPRINGS SCREWS 5X0.8 BY TOUCH SPARK 4X PRIMARY COVER SCREWS 6X CRANKCASE SCREWS 6X00.0 SELECTOR SCREWS 6X BLUE SELECTOR FIXING SHIFT SCREW 6X BLUE IGNITION BRACKET SCREWS 5X0.8 BY TOUCH BLUE NOTE: APPLY GENERAL RULES TO ANY SCREW OR NUT NOT SPECIFIED, IF DOUBTS CONTACT US

4 TORQUE WRENCH SETTING STEERING THREAD WRENCH KG SEALING UPPER TRIPLE CLAMP 8X25.5 LOWER TRIPLE CLAMP 8X25.2 CONIC BERARING NUT 0.25 UPPER TRIPLE CLAMP SCREW 2.5 BLUE HANDLEBAR CLAMP 6X00 HANDLE BAR TUBE 6X FORK TOP 8X FRONT AXLE NUT 2X BRAKE DISC 8X25. BRAKE CALLIPER 0X BLUE STEERING SHOCK 8X BLUE NOTE: APPLY GENERAL RULES TO ANY SCREW OR NUT NOT SPECIFIED, IF DOUBTS CONTACT US

5 TORQUE WRENCH SETTING FRAME THREAD WRENCH KG. SEALING FRONT STAND 6X00 0,8 SIDES FRAME 0X25 3 BLUE ENGINE FASTENER BRACKET 8X FRAME ENGINE PLATES 8X ENGINE PLATES SCREW 8X SWING ARM AXLE 2X SHOCK UPPER SCREW 0X SHOCK LOWER SCREW 0X50 3 SEAT SCREWS 6X00 FOOTREST BRACKETS 8X BLUE FOOTREST 8X BLUE REAR MASTER CYLINDER 6X REAR BRAKE CALLIPER 6X STAND BRACKET 8X25.5 REAR BRAKE DISC 6X REAR SPROCKET 8X REAR WHEEL AXLE 4X NOTE: APPLY GENERAL RULES TO ANY SCREW OR NUT NOT SPECIFIED, IF DOUBTS CONTACT US

TECHNICAL ENGINE SPECS ENGINE SINGLE CYLINDER 2 STROKE MEASURES 39,84 X 40MM (50) / 44,50 X 44,90 MM (70) CYLINDER CAPACITY 49.86CC (50) / 69.

6 TECHNICAL ENGINE SPECS ENGINE SINGLE CYLINDER 2 STROKE MEASURES 39,84 X 40MM (50) / 44,50 X 44,90 MM (70) CYLINDER CAPACITY 49.86CC (50) / CC (70) GEARS 6 GEAR RATIO 3/37 2 5/32 3 8/3 4 2/3 5 23/ /27 PRIMARY 20/62 CLUTCH Hydraulic with automatic adjustment COMPOSITION 5 Clutch discs 4.5mm plates.2mm plate

C GRO EXTREM 75 IGNITION DIGITAL SETTING 2.

7 TECHNICAL ENGINE SPECS CLUTCH ROD SHOVE SETTING BALANCE SHAFT LUBRICATION RECOMMENDED MIX AT 3% GRO RACING- GEARBOX OIL CAPACITY 450 C.C GRO EXTREM 75 IGNITION DIGITAL SETTING 2.6 BTDC (50) 3,3 BTDC (70) PLUG NGK - 50 BR-9EIX - 70 BR-0EIX PLUG GAP 0.65 MM. NOTE: APPLY GENERAL RULES TO ANY SCREW OR NUT NOT SPECIFIED, IF DOUBTS CONTACT US

8 CUADRO - FRAME - CADRE DIAGRAM 80K K077 80K K K K K K K K0702 CHASIS TUBULAR TUBULAR FRAME CADRE TUBULAIRE SUBCHASIS TRASERO SEAT RAIL CADRE ARRIERE CARTELAS LATERALES ALUMINIO SIDE ALUMINIUM FRAME PLETINE ALUMINIUM RODAMIENTOS DIRECCIÓN STEERING BEARING ROULEMENTS DIRECTION CTO. EJE SOPORTE SUP. AMORTIGUADOR SHOCK PIN ASSY ENSEMBLE AXE SUPÉRIEUR AMORTISSEUR TORNILLERÍA CHASIS FRAME BOLT KIT ENSEMBLE VIS CADRE TOPES DE DIRECCIÓN NYLON NYLON STEERING STOP BUTOIR DE DIRECTION NYLON TORNILLERÍA COLÍN SEAT BOLT KIT ENSEMBLE VIS SIÈGE CARTELA LATERAL IZQUIERDA LEFT SIDE FRAME PLETINE GAUCHE CARTELA LATERAL DERECHA RIGHT SIDE FRAME PLETINE DROITE

9 HORQUILLA - FORK - FOURCHE DIAGRAM 2 80K K K005 HORQUILLA COMPLETA INFANTIL CHILD COMPLETE FORK FOURCHE TELESCOPIQUE ENFANT 2006 CONJUNTO PLETINA DIRECCIÓN STEM ASSEMBLY LOWER PLATE ENSEMBLE PLATINES DIRECTION RETEN HORQUILLA FORK OIL SEAL JOINT SPY FOURCHE

10 BASCULANTE - SWING ARM - BRAS OSCILLANT DIAGRAM K K0 80K K K K K K0708 BASCULANTE COMPLETO COMPLETE SWING ARM ENSEMBLE BRAS OSCILLANT PROTECTOR BASCULANTE SLIDER CHAIN PROTECTEUR BRAS OSCILLANT PROTECTOR PASO CADENA CHAIN GUARD GUIDE DE CHAÎNE CONJUNTO EJE BASC. MOTOR METRAKIT SWING ARM AXLE ASSY METRAKIT ENGINE ENSEMBLE AXE BRAS OSC.MOTEURR METRAKIT TENSOR CADENA COMPLETO COMPLETE CHAIN TIGHTNER TENDEUR DE ROUE AMORTIGUADOR ADULTO STANDARD ADULT STANDARD SHOCK ABSORBER AMORTISSEUR ADULTE STANDARD AMORTIGUADOR MULTIREGULABLE MULTIADJUSTABLE SHOCK ABSORBER AMORTISSEUR MULTIREGLABLE CASQUILLO NYLON CABALLETE STANDARD NYLON ABSORBER ENTRETOISE NYLON BEQUILLE RODAMIENTOS BASCULANTE SWING ARM BEARINGS JEUX ROULEMENTS BRAS OSCILLANT

11 CARENADO - FAIRING - CARENAGE DIAGRAM 4 80K K3 3 80K K K K K8 8 80K K K060 80K6 COLÍN 2006 SEAT 2006 SIÈGE 2006 ESPUMA COLIN SEAT RUBBERS CAOUTCHOUCS SIÈGE CARENADO SUPERIOR 2006 UPPER FAIRING 2006 CARÉNAGE SUPERIEUR 2006 CARENADO INFERIOR 2006 LOWER FAIRING 2006 CARÉNAGE INFERIEUR 2006 FIJACIONES LATERALES CARENADO FAIRINGS SIDE FASTENERS FIXATIONS LATERALES CARÉNAGE CIERRE RÁPIDO CARENADO FAIRINGS FAST BOLTS FERMETURE RAPIDE PANTALLA + REMACHES 2006 SCREEN + RIVET 2006 ÉCRAN + RIVETS 2006 GUARDABARROS TRASERO REAR MUDGUARD GARDE-BOUE ARRIERE GUARDABARROS DELANTERO 2006 FRONT MUDGUARD 2006 GARDE-BOUE AVANT 2006 DEPÓSITO DE GASOLINA 2004 FUEL TANK 2004 RÉSERVOIR D'ESSENCE 2004 TAPA DEPÓSITO 2006 FUEL TANK COVER 2006 COUVER RESERVOIR 2006

12 CARENADO - FAIRING - CARENAGE DIAGRAM K060 80K K K064 80K09 GOMAS SOPORTE DEPÓSITO GASOLINA FUEL TANK RUBBERS MOUNT GOMMES SUPPORT RÉSERVOIR D'ESSENCE GRIFO DE GASOLINA FUEL VALVE ROBINET D'ESSENCE MANGUITO DESPAVORIZADOR GASOLINA FUEL TANK TUBE TUBE AÉRATION D'ESSENCE TAPÓN DEPÓSITO GASOLINA 2004 FUEL TANK CAP 2004 BOUCHON RÉSERVIOR D'ESSENCE 2004 TORNILLERIA CARENADO FAIRING SCREWS ENSEMBLE VIS CARÉNAGE

13 MANILLAR Y MANDOS - HANDLEBAR AND CONTROLS - GUIDON ET COMMANDES DIAGRAM K020 80K02 80K002 80K004 80K024 80K K K K0204 SEMIMANILAR DERECHO RIGHT HANDLEBAR BRACELET DROIT SEMIMANILLAR IZQUIERDO LEFT HANDLEBAR BRACELET GAUCHE CONJUNTO PUÑO GAS THROTTLE GRIP ASSEMBLY POIGNEE DE GAZ COMPLETE CONJUNTO CABLE GAS 50cc. CABLE THROTTLE ASSEMBLY 50cc. GAINE ET CABLE DE GAZ 50cc. CONJUNTO CABLE GAS 70cc.SP CABLE THROTTLE ASSEMBLY 70cc.SP GAINE ET CABLE DE GAZ 70cc.SP BOMBA FRENO DELANTERA FRONT BRAKE PUMP RÉSERVOIR LIQUIDE DE FREIN AVANT PINZA DE FRENO DELANTERA FRONT BRAKE CALIPER ETRIER DE FREIN MANETA LEVER MANETE EMBRAGUE HIDRAULICO HYDRAULIC CLUTCH LEVER EMBRAYAGE HIDRAULIQUE BOMBA EMBRAGUE HIDRAULICO CLUTCH MASTER CYLINDER MAITRE CILINDRE EMBRAYAGE HIDRAULIQUE PASTILLAS FRENO BRAKE PADS PLAQUETTE DE FREIN

14 MANILLAR Y MANDOS - HANDLEBAR AND CONTROLS - GUIDON ET COMMANDES DIAGRAM K K006 BOTON DE PARO SWITCH ENGINE STOP INTERRUPTEUR STOP TOPE MANILLAR HANDLEBAR CAP BRACELET RESSORT

15 RUEDA DELANTERA - FRONT WHEEL - ROUE AVANT DIAGRAM 6 Nº QTY COD. DESCRIPCIÓN - NAME - DESIGNATION LLANTA DELANTERA 80K0300 FRONT RIM JANTE AVANT RODAMIENTOS LLANTA DELANTERA K030 FRONT WHEEL BEARING ROULEMENTS JANTE AVANT DISCO DELANTERO MKRD F000 MKRD0 FRONT BRAKE DISQUE FREIN AVANT CONJUNTO EJE RUEDA DELANTERA 4 80K FRONT WHEEL AXLE ASSEMBLY ESEMBLE AXE DE ROUE AVANT 5 80K5 NEUMÁTICO DELANTERO DUNLOP TT92GP FRONT TYRE DUNLOP TT92GP PNEUMATIQUE AVANT DUNLOP TT92GP TORNILLO DISCO FRENO SCREW BRAKE DISC VIS DISQUE FREIN

16 RUEDA TRASERA - REAR WHEEL - ROUE ARRIERE DIAGRAM K K K K K035 80K036 80K037 80K038 80K039 80K040 80K04 LLANTA TRASERA 2" 2" REAR WHEEL JANTE ARRIERE 2" RODAMIENTOS LLANTA TRASERA REAR WHEEL BEARINGS ROULEMENTS JANTE ARRIERE DISCO TRASERO CON TORNILLOS REAR DISC WITH SCREWS DISQUE FREIN ARRIERE AVEC VIS CONJUNTO EJE RUEDA TRASERA REAR WHEEL AXLE ASSEMBLY ENSEMBLE AXE ARRIERE CORONA Z 35 SPROCKET Z 35 COURONNE ARRIERE Z=35 CORONA Z 36 SPROCKET Z 36 COURONNE ARRIERE Z=36 CORONA Z 37 SPROCKET Z 37 COURONNE ARRIERE Z=37 CORONA Z 38 SPROCKET Z 38 COURONNE ARRIERE Z=38 CORONA Z 39 SPROCKET Z 39 COURONNE ARRIERE Z=39 CORONA Z 40 SPROCKET Z 40 COURONNE ARRIERE Z=40 CORONA Z 4 SPROCKET Z 4 COURONNE ARRIERE Z=4

17 RUEDA TRASERA - REAR WHEEL - ROUE ARRIERE DIAGRAM 7 Nº QTY COD. DESCRIPCIÓN - NAME - DESIGNATION 5 80K042 CORONA Z 42 SPROCKET Z 42 COURONNE ARRIERE Z=42 80K043 CORONA Z 43 SPROCKET Z 43 COURONNE ARRIERE Z=43 80K044 CORONA Z 44 SPROCKET Z K000 COURONNE ARRIERE Z=44 CADENA CHAIN CHAINE TRANSMISION 7 80K53 NEUMÁTICO TRASERO DUNLOP TT92GP REAR TYRE DUNLOP TT92GP PNEUMATIQUE ARRIERE DUNLOP TT92GP ESPARRAGOS LLANTA TRASERA REAR WHEEL STUDS TIGES JANTE ARRIERE

18 FRENO TRASERO - REAR BRAKE - FREIN ARRIERE DIAGRAM 8 Nº QTY COD. DESCRIPCIÓN - NAME - DESIGNATION 80K K K K K K K K K K K K5892 PALANCA DE FRENO BRAKE PEDAL PEDALE DE FREIN ARRIERE SOPORTE PINZA DE FRENO TRASERO REAR CALIPER BRACKET SUPPORT ETRIER FREIN ARRIERE TIRANTE DE FRENO TRASERO REAR CALIPER FASTENER TENDEUR DE FREIN ARRIERE BOMBA DE FRENO TRASERA REAR BRAKE PUMP COMMANDE FREIN ARRIERE PINZA DE FRENO TRASERO REAR BRAKE CALIPER ETRIER FREIN ARRIERE PASTILLAS DE FRENO TRASERO REAR BRAKE PADS PLAQUETTE DE FREIN ARRIERE ESTRIBO FOOTREST REPOSE PIED SOPORTE ESTRIBERA DERECHA RIGHT FOOTREST BRACKET SUPPORT REPOSE PIED DROIT ROTULA BOMBA DE FRENO BRAKE PUMP KNEECAP GENOUILLERE FREIN ARRIERE TAPÓN ESTRIBO PLASTIC FOOTREST CAPS BOUCHON REPOSE-PIEDS TORNILLO ESTRIBO SCREW FOOTREST VIS RESPOSE PIED PUNTERA PALANCA RUBBER PEDAL CAOUTCHOUC PEDALE

19 CAMBIO - GEAR - SELECTEUR DIAGRAM 9 Nº QTY COD. DESCRIPCIÓN - NAME - DESIGNATION K K K K K K0906 PALANCA CAMBIO GEARSHIFT PEDAL PEDALE DE SELECTEUR REENVÍO CAMBIO GEAR RETURN LEVIER DE SELECTEUR ESTRIBO FOOTREST RESPOSE PIED SOPORTE ESTRIBERA IZQUIERDA LEFT FOOTREST BRACKET SUPPORT REPOSE PIED DROIT TAPÓN ESTRIBO PLASTIC FOOTREST CAPS BOUCHON REPOSE-PIEDS PUNTERA PALANCA RUBBER PEDAL CAOUTCHOUC PEDALE TORNILLO ESTRIBO SCREW FOOTREST VIS RESPOSE PIED

20 MOTOR - ENGINE - MOTEUR DIAGRAM K562 80K563 80K564 80K565 80K K402 MOTOR COMPLETO METRAKIT 50cc. COMPLETE METRAKIT ENGINE 50cc. MOTEUR COMPLETE METRAKIT 85cc. MOTOR COMPLETO METRAKIT 70cc. COMPLETE METRAKIT ENGINE 70cc. MOTEUR COMPLETE METRAKIT 70c. ENCENDIDO COMPLETO 50cc. ASSY IGNITION 50cc. GROUPE ALLUMAGE 50cc. ENCENDIDO COMPLETO 70cc ASSY IGNITION 70cc GROUPE ALLUMAGE 70cc CONJUNTO PLETINAS FIJACION MOTOR BRACKETS SET ENGINE SUP. AVANT MOTEUR PIÑÓN SALIDA MOTOR Z 2 DRIVE SPROCKET Z 2 PIGNON SORTIE MOTEUR Z 2 PIÑÓN SALIDA MOTOR Z 3 DRIVE SPROCKET Z 3 PIGNON SORTIE MOTEUR Z 3 PIÑÓN SALIDA MOTOR Z 4 DRIVE SPROCKET Z 4 PIGNON SORTIE MOTEUR Z 4 PIÑÓN SALIDA MOTOR Z 5 DRIVE SPROCKET Z 5 PIGNON SORTIE MOTEUR Z 5 PIÑÓN SALIDA MOTOR Z 6 DRIVE SPROCKET Z 6 PIGNON SORTIE MOTEUR Z 6 PIPA BUJÍA SPARK PLUG CAP ANTIPARASITE

21 MOTOR - ENGINE - MOTEUR DIAGRAM K BUJIA BR 0 EIX SPARK PLUG BR 0 EIX BUJIE BR 0 EIX CONJUNTO ROTOR-STATOR ASSY ROTOR-STATOR GROUPE ROTOR-STATOR BOBINA COIL BOBINE UNIDAD CDI 50cc. CDI UNIT 50cc. CDI 50cc. UNIDAD CDI 70cc. CDI UNIT 70cc. CDI 70cc. CABLEADO ENCENDIDO IGNITION CABLES CABLAGE ALLUMAGE

22 CARTERES - CRANKCASE - GROUPE CARTERS DIAGRAM CONJUNTO CARTERES CRANKCASE ASSY GROUPE CARTERS JUNTA CENTRAL CARTER INNER CRANKCASE GASKET JOINT INTERIEUR CARTER TAPA ENCENDIDO IGNITION COVER COUVERCLE ALLUMAGE JUNTA TAPA TRASMISION PRIMARIA TRANSMISSION PRIMARY COVER GASKET JOINT COUVERCLE TRANSMISSION PRIMAIRE TAPA TRANSMISION PRIMARIA TRANSMISSION PRIMARY COVER COUVERCLE TRANSMISSION PRIMAIRE JUNTA TAPA EMBRAGUE CLUTCH COVER GASKET JOINT COUVERCLE EMBRAYAGE TAPA EMBRAGUE CLUTCH COVER COUVERCLE EMBRAYAGE JUNTA TAPA BOMBA AGUA WATER PUMP GASKET JOINT POMPE A EAU TAPA BOMBA AGUA WATER PUMP COVER COUVERCLE POMPE A EAU CAJA DE LAMINAS REED BLOCK BOITE A CLAPETS JUNTA CAJA LAMINAS REED BLOCK GASKET JOINT BOITE A CLAPETS

23 CARTERES - CRANKCASE - GROUPE CARTERS DIAGRAM 2 92D BOQUILLA ADMISION MINI GP 50 MANIFOLD MINI GP 50 PIPE D' ADMISSION MINI GP 50 BOQUILLA ADMISION MINI GP 70 MANIFOLD MINI GP 70 PIPE D' ADMISSION MINI GP D60 LAMINAS FIBRA CARBONO CARBON REEDS SET LAMELLES DE CARBONE JUEGO JUNTAS MOTOR ENGINE GASKET SET POCHETE DE JOINTS MOTEUR

24 EQUIPO MOTOR - CYLINDER KIT - HAUT MOTEUR DIAGRAM 2 NUT FOR CRANKSHAFT (Left & Right) Part No: 8008F D EQUIPO MOTOR 50cc. CYLINDER KIT 50cc. HAUT MOTEUR 80cc. CULATA HEAD COVER COUVERCLE CULASSE SEGMENTO RING SEGMENT PISTON D.39,84 A PISTON D.39,84 A PISTON D.39,84 A PISTON D.39,84 B PISTON D.39,84 B PISTON D.39,84 B PISTON D.39,84 C PISTON D.39,84 C PISTON D.39,84 C PISTON D.39,84 D PISTON D.39,84 D PISTON D.39,84 D JUEGO JUNTAS GASKET SET POCHETE DE JOINTS JAULA 2x7x4,4 BEARING 2x7x4,4 CAGE AIGUILLE 2x7x4,4 BIELA CON ROD BIELLE CIGÜEÑAL CRANKSHAFT VILOBREQUIN KIT COJINETES Y RETENES BEARINGS-SEAL KIT KIT ROULEMENT JOINT SPI VILO

25 EQUIPO MOTOR - CYLINDER KIT - HAUT MOTEUR DIAGRAM 2 NUT FOR CRANKSHAFT (Left & Right) Part No: 8008F D EQUIPO MOTOR 70cc. CYLINDER KIT 70 cc. HAUT MOTEUR 70cc. TAPA CULATA HEAD COVER COUVERCLE CULASSE CULATIN HEAD CULASSE SEGMENTO 44,50x,00 CR RING 44,50x,00 CR SEGMENT 44,50x,00 CR PISTON D.44,50 A PISTON D.44,50 A PISTON D.44,50 A PISTON D.44,50 B PISTON D.44,50 B PISTON D.44,50 B PISTON D.44,50 C PISTON D.44,50 C PISTON D.44,50 C PISTON D.44,50 D PISTON D.44,50 D PISTON D.44,50 D JUEGO JUNTAS GASKET SET POCHETE DE JOINTS JAULA 2x7x4,4 BEARING 2x7x4,4 CAGE AIGUILLE 2x7x4,4 BIELA CON ROD BIELLE CIGÜEÑAL CRANKSHAFT VILOBREQUIN KIT COJINETES Y RETENES BEARINGS-SEAL KIT KIT ROULEMENT JOINT SPI VILO

26 EMBRAGUE - CLUTCH - EMBRAYAGE DIAGRAM TORNILLO+TOPE MUELLE EMBRAGUE SCREW + CLUTCH SPRING STOP VIS+COUVERCLE RESSORT JUEGO MUELLES EMBRAGUE CLUTCH SPRINGS SET GROUPE RESSORTS EMBRAYAGE TAPA CIERRE EMBRAGUE CLUTCH LOCK COVER PLAQUE PRESSION EMBRAYAGE CONJUNTO RODAMIENTO AXIAL AXIAL BEARINGS SET ENSEMBLE ROULEMENT AXIAL CASQUILLO EMPUJE EMBRAGUE CLUTCH BUSHING ENTRETOISE EMBRAYAGE TUERCA EMBRAGUE CLUTCH NUT ECROU EMBRAYAGE ARANDELA PRECINTO EMBRAGUE CLUTCH WASHER SEAL RONDELLE EMBRAYAGE JUEGO DISCOS EMBRAGUE CLUTCH DISC SET ENSEMBLE DISQUES EMBRAYAGE CAMPANA CONDUCIDA BELL CLOCHE INTERNE ARANDELA 7x30x WASHER 7x30x RONDELLE 7x30x CAMPANA EMBRAGUE CLUTCH BELL CLOCHE EMBRAYAGE

27 EMBRAGUE - CLUTCH - EMBRAYAGE DIAGRAM JUNTA PLANA 2x25x6 EMBRAGUE CLUTCH FLAT GASKET JOINT EMBRAYAGE CORONA EMBRAGUE CLUTCH SPROCKET COURONE EMBRAYAGE PLACA SOPORTE JUNTAS EMBRAGUE CLUTCH BRACKET PLATE GASKETS PLAQUE SUPORT TORNILLO ALLEN M6x2 ALLEN SCREW M6x2 VIS ALLEN M6x2 CONJUNTO RODAMIENTO PRIMARIO PRIMARY BEARINGS SET ENSEMBLE ROULEMENT PRIMAIRE VARILLA EMPUJE EMBRAGUE CLUTCH ROD SHOVE TIGE POUSSE EMBRAYAGE BOLA RODAMIENTO BEARING BALL BOULE ROULEMENT

28 BOMBA DE AGUA - WATER PUMP - POMPE A EAU EJE DE BALANCE - BALANCE SHAFT - BALANCIER DIAGRAM COJINETE 2x32x0 EJE BALANCE BALANCE SHAFT BEARINGS 2x32x0 ROULEMENT 2x32x0 BALANCIER EJE DE BALANCE BALANCE SHAFT BALANCIER COJINETE+RETEN 2x32x2,5 BEARINGS + SEAL 2x32x2,5 ROULEMENT + JOINT SPY 2x32x2,5 CHAVETA EJE BALANCE BALANCE SHAFT COTTER PIN VIS BALANCIER PIÑON EJE BALANCE BALANCE SHAFT SPROCKET PIGNON BALANCIER TUERCA M0x25 DIN 439 M0x25 DIN 439 NUT ECROU M0x25 DIN 439 PIÑON BOMBA AGUA WATER PUMP SPROCKET PIGNON POMPE A EAU CIRCLIP PIÑON BOMBA AGUA WATER PUMP SPROCKET CIRCLIP CIRCLIP PIGNON POMPE A EAU COJINETE 8x22x7 BEARINGS 8x22x7 ROULEMENT 8x22x7 RETEN BOMBA AGUA WATER PUMP SEAL JOINT SPI POMPE A EAU EJE BOMBA AGUA WATER PUMP SHAFT AXE POMPE A EAU

29 BOMBA DE AGUA - WATER PUMP - POMPE A EAU EJE DE BALANCE - BALANCE SHAFT - BALANCIER DIAGRAM TURBINA BOMBA AGUA WATER PUMP TURBINE TURBINE POMPE A EAU COJINETE 2x9x2 BEARINGS 2x9x2 ROULEMENT 2x9x2 PIÑON CIGUEÑAL CRANKSHAFT SPROCKET PIGNON VILO PIÑON INTERMEDIO EJE BALANCE BALANCE SHAFT MIDDLE SPROCKET PIGNON INTERMEDIAIRE BALANCIER CORONA EMBRAGUE CLUTCH SPROCKET COURONE EMBRAYAGE PLACA RECUPERADOR SELECTOR SELECTOR PLATE PLAQUE SELECTEUR EJE SELECTOR CAMBIO GEAR SELECTOR SHAFT AXE SELECTEUR CASQUILLO DISTANCIADOR SPACING BUSH ENTRETOISE RODAMIENTO AGUJAS 2x6x0 NEEDLE BEARINGS 2x6x0 CAGE AIGULLES 2x6x0 RETEN 2x20x7 SEAL 2x20x7 JOINT SPY 2x20x7 COJINETE 25x37x7 BEARINGS 25x37x7 ROULEMENT 25x37x7

30 BOMBA DE AGUA - WATER PUMP - POMPE A EAU EJE DE BALANCE - BALANCE SHAFT - BALANCIER DIAGRAM ARANDELA 25x35x0,5 WASHER 25x35x0,5 RONDELE 25x35x0,5 TAMBOR DESMODRONICO SHIFT CAM BARRILET VITESSE CABEZA TAMBOR DESMODRONICO HEAD SHIFT CAM TETE BARRILET SOPORTE FIJACIÓN SELECTOR SELECTOR FIXING BRACKET SUPORT SELECTEUR MUELLE RETORNO RETURN SPRING RESSORT CHAVETA CIGUEÑAL-TRANSMISION CRANKSHAFT-TRANSMISSION COTTER PIN VIS VILO-TRANSMISSION

31 CAMBIO DE MARCHAS - GEAR BOX - BOÎTE A VITESSE DIAGRAM 5 CAMBIO DE MARCHAS GEAR BOX BOITE A VITESSE CONJUNTO PIÑON ª VELOCIDAD st GEAR SPROCKET SET ENSEMBLE PIGNON er VISTESSE CONJUNTO PIÑON 2ª VELOCIDAD 2 nd GEAR SPROCKET SET ENSEMBLE PIGNON 2 eme VISTESSE CONJUNTO PIÑON 3ª-4ª VELOCIDAD 3 rd - 4 th GEAR SPROCKET SET ENSEMBLE PIGNON 3 eme - 4 eme VISTESSE CONJUNTO PIÑON 5ª VELOCIDAD n th GEAR SPROCKET SET ENSEMBLE PIGNON 5 eme VISTESSE CONJUNTO PIÑON 6ª VELOCIDAD 6 th GEAR SPROCKET SET ENSEMBLE PIGNON 6 eme VISTESSE EJE SECUNDARIO CAMBIO GEAR SECONDARY AXLE AXE SCONDAIRE BOITE HORQUILLA CAMBIO 3ª-4ª VELOCIDAD GEAR FORK 3 rd - 4 th SPEED FOURCHETTE 3 eme - 4 eme VISTESSE HORQUILLA CAMBIO 6ª VELOCIDAD GEAR FORK 6 th SPEED FOURCHETTE 6 eme VISTESSE HORQUILLA CAMBIO 5ª VELOCIDAD GEAR FORK 5 th SPEED FOURCHETTE 5 eme VISTESSE EJE HORQUILLA SECUNDARIO SECONDARY FORK AXLE AXE FOURCHETTE SECONDAIRE

32 CAMBIO DE MARCHAS - GEAR BOX - BOÎTE A VITESSE DIAGRAM EJE HORQUILLA PRIMARIO PRIMARY FORK AXLE AXE FOURCHETTE PRIMAIRE RODAMIENTO AGUJAS 2x9x2 NEEDLE BEARINGS 2x9x2 CAGE AIGULLES 2x9x2 COJINETE 7x40x2 BEARINGS 7x40x2 ROULEMENT 7x40x2 COJINETE 7x47x4 BEARINGS 7x47x4 ROULEMENT 7x47x4 COJINETE 2x28x8 BEARINGS 2x28x8 ROULEMENT 2x28x8 RETEN 20x40x7 SEAL 20x40x7 JOINT SPY 20x40x7 KIT ARANDELAS + CLIPS CAMBIO WASHERS KIT + GEAR CLIPS KIT RONDELE + CLIPS BOITE

33 CARBURADOR - CARBURETTOR - CARBURATEUR ESCAPE Y SILENCIOSO - EXHAUST PIPE AND SILENCER DIAGRAM 6 Nº QTY COD. DESCRIPCIÓN - NAME - DESIGNATION K20 CARBURADOR 9 MINI GP 50 CARBURETTOR 9 MINI GP 50 CARBURATEUR 9 MINI GP 50 CARBURADOR 28 MINI GP 70 CARBURETTOR 28 MINI GP 70 CARBURATEUR 28 MINI GP 70 TUBO DE ESCAPE MINI GP 50 EXHAUST PIPE MINI GP 50 TUBE D'ECHAPPEMENT MINI GP 50 TUBO DE ESCAPE MINI GP 70 EXHAUST PIPE MINI GP 70 TUBE D'ECHAPPEMENT MINI GP 70 SILENCIOSO KEVLAR KEVLAR SILENCER SILENCIEUX D'ECHAPPEMENT CABALLETE TRASERO REAR STAND BEQUILLE ARRIERE

34 TACOMETRO - SPEEDOMETER - TABLEAU DE BORD RADIADOR - RADIATOR - RADIATEUR DIAGRAM 7 Nº QTY COD. DESCRIPCIÓN - NAME - DESIGNATION 80K K D K K5808 RADIADOR RADIADOR RADIATEUR MANGUITOS RADIADOR MOTOR RADIATOR HOSES ENGINE DURITE RADIATEUR MOTEUR GOMAS SOPORTE RADIADOR RUBBERS RADIATOR STAND GOMMES SUPPORT RADIATEUR TACÓMETRO MULTIFUNCIÓN DIGITAL TACHOMETER DIGITAL TCOMPTE TOURS SOPORTE CARENADO Y RELOJES FAIRING BRACKET AND CONTROLS SUPPORT CARÉNAGE ET MONTRES TOPE NYLON NYLON CAP COUVERCLE NYLON TAPON RADIADOR RADIATOR CAP BOUCHON RADIATEUR

No. Part No. Descripcion Description Cant./Qty Culata suelta Cylinder head Esparrago culata Stud Guia

No. Part No. Descripcion Description Cant./Qty Culata suelta Cylinder head Esparrago culata Stud Guia 1 12008027600 Culata suelta Cylinder head 1 2 38018009300 Esparrago culata Stud 2 3 38060011700 Guia ocation pin 2 4 12015007000 Junta culata Gasket for cylinder head 1 5 38018009800 Esparrago Stud 2 6