Heritage (Model 8091) Pellet Stove

Transcription

1 Heritage (Model 8091) Pellet Stove Illustrated Parts List Production Dates: March 21, Serial Number: Please refer to the owner s manual before and after servicing this pellet fuel burning room heater. To reduce the risk of fire, follow all instructions. Failure to follow these instructions could result in property damage, bodily injury, or even death. R: 2-10/15/2012 Hearthstone Quality Home Heating Products, Inc. inquiry@hearthstonestoves.com

2 Heritage Exploded View

3 ILLUSTRATED PARTS LIST 1 Assm. H HOPPER DOOR ASSM. 2 Assm. G GRILL ASSM TOP 4 Assm. I SIDE STONE ASSM SAFETY/RATING LABEL REAR PANEL (SHROUD) HOPPER EXTENSION SECONDARY HOPPER DOOR HINGE PIN: SECONDARY HOPPER DOOR REAR TOP SUPPORT SENSOR: HOPPER SAFETY HOPPER CABLE CHANNEL PANEL GROMMET RIGHT HINGE: HOPPER DOOR 15 Assm. B ENGINE ASSM AIR WASH SIDE LEG BOTTOM REAR PANEL LEFT HINGE: HOPPER DOOR A DOOR LATCH CATCH FRONT TOP SUPPORT GASKET TAPE, 3/4"x1/16" FRONT DOOR FRAME 25 Assm. J FRONT STONE ASSM. 26 Assm. M FRONT DOOR ASSM. 27 Assm. F BOTTOM CAST ASSM ROD: HEAT EXCHANGER CLEANING

4 Figure 1 - Engine Assembly : Major Components Assembly A ENGINE ASSEMBLY, INCLD. ALL OF THE PARTS BELOW A1 Assm. B ENGINE SUB ASSEMBLY A REAR PANEL: BOTTOM A3 Assm. N ROOM BLOWER ASSEMBLY A4 Assm. K ASH BOX ASSEMBLY

5 Assembly B B CONTROL BOARD ASSM. WITH BRACKET B MOTHERBOARD B TEMPERATURE SAFETY LIMIT SWITCH B4 NA FUSE HOLDER (PART OF HARNESS ) B EXHAUST FAN MOTOR B HOSE CLAMP: 12MMWX70-90DIA B EXHAUST GAS PIPE B EXHAUST FAN HOUSING B9 Assm. C AUGER ASSM. B10 Assm. L HOPPER ASSM. B SENSOR WIRE CONDUIT B COMBUSTION CHAMBER B PRESSURE PLATE B HEAT EXCHANGER HEAT SHIELD B SENSOR: FLAME THERMOCOUPLE B16a PLENUM: LEFT CONVECTION AIR B16b PLENUM: RIGHT CONVECTION AIR B GASKET: 3/8"X 1/8"FLAT, KNIT BLK, 1/4"AD SP B SIDE COMBUSTION COVER B KNURLED THUMB SCREW B AIR FLOW SENSOR B AIR INLET PIPE B IGNITER FERRULE B BURN POT B24 Assm. E LOWER BAFFLE ASSM. B25 Assm. D UPPER BAFFLE ASSM. B HOPPER BULB CLIP B IGNITER ELEMENT (with spade terminals installed ) B INLET TUBE GASKET NA WIRING HARNESS - (Not Shown)

6 Figure 2 - Heritage 8091 Engine Assembly

7 Figure 3 - Heritage 8091 Auger Assembly Assembly C C AUGER HOUSING C SINTERED BEARING C AUGER SCREW / SHAFT C AUGER FEED UNIT LID C AUGER ACCESS WASHER C SINTERED BEARING C AUGER MOTOR BRACKET C AUGER SHAFT CLAMP RING C WTR/AIR HOSE C AUGER MOTOR SUPPORT C AUGER MOTOR

8 Figure 4 - Heritage 8091 Upper Baffle Assembly Assembly D D LEFT BAFFLE MOUNT BRACKET D RIGHT BAFFLE MOUNT BRACKET D UPPER BAFFLE INSULATION GUARD D UPPER BAFFLE CERAMIC HEATSHIELD D UPPER BAFFLE

9 Figure 5 - Heritage 8091 Lower Baffle Assembly Assembly E E LEFT BAFFLE MOUNT BRACKET E RIGHT BAFFLE MOUNT BRACKET E LOWER BAFFLE INSULATION GUARD E LOWER BAFFLE CERAMIC HEATSHIELD E LOWER BAFFLE

10 Figure 6 - Heritage 8091 Bottom Assembly Assembly F F BOTTOM: MATTE F FOOT: MATTE

11 Figure 7 - Heritage 8091 Grill Assembly Assembly G G TOP GRILL, MATTE G OUTLET GRILL SCREEN G AIR CIRCULATION LOUVER

12 Figure 8 - Heritage 8091 Hopper Door Assembly Assembly H H LOAD DOOR HANDLE H HOPPER DOOR STONE, SAHARA H HOPPER DOOR STONE, POL H HOPPER DOOR H MAGNET

13 Figure 9 - Heritage 8091 Side Stone Assembly Assembly I I OUTER SIDE STONE FRAME I SIDE STONE, SAHARA I SIDE STONE, POL I INNER SIDE STONE FRAME

14 Figure 10 - Heritage 8091 Front Stone Assembly Assembly J J FRONT STONE FRAME J FRONT HORIZONTAL STONE, SAHARA J FRONT HORIZONTAL STONE, POL J FRONT VERTICAL STONE, SAHARA J FRONT VERTICAL STONE, POL J FRONT INNER STONE RETAINER J FRONT OUTER STONE RETAINER

15 Figure 11 - Heritage 8091 Ash Drawer Assembly Assembly K K ASH PAN CATCH SPRING K OUTER ASH BOX FRAME K ASH PAN CATCH KNOB K ASH PAN K ASH DOOR: MATTE K GASKET: ROPE, 3/8", AD, NON-CORE, 2.4'

16 Figure 12 - Heritage 8091 Hopper Assembly Assembly L L HOPPER: DISPLAY BASE L HOPPER: REAR PANEL BRACKET,FRNT/LT,PEL L HOPPER: LEFT L HOPPER: BACK L HOPPER: RIGHT L HOPPER: REAR PANEL BRACKET,FRNT/RT,PEL L HOPPER: REAR PANEL BRACKET,FRNT/RT,PEL L HOPPER HEAT SHIELD

17 Figure 13 - Heritage 8091 Front Door Assembly Assembly M M GLASS CLIP M GLASS CLIP GASKET: BLACK M GLASS M GASKET: ROPE,1/4" M GASKET: ROPE,3/8" M FRONT DOOR HINGE M FRONT DOOR: MATTE M FRONT DOOR LATCH M FRONT DOOR LATCH HOLDER M FRONT DOOR HANDLE: MATTE M WOODEN HANDLE

18 Figure 14 - Heritage 8091 Room Fan Assembly Assembly N N SCREEN; CONVECTION FAN N FAN: BLOWER, ASSY, CONVECTION N HOUSING: CONVECTION FAN N GROMMET: SIL.45" PANEL x.25" ID, M-633 N SLEEVE:.25"OD x.183"id x.375", M-632