SEATING CAPACITY: 45 + DRIVER

Transcription

1 KNEE SEATING CAPACITY: 45 + DRIVER EMERGENCY EXIT A.C. ELECTRICAL BOX NO UNDERBODY BOXES ALLOWED LEFT BARRIER FRONT MOUNTING HOLE TO FIRST SEAT FRONT MOUNTING HOLE = 8.0 RIGHT BARRIER FRONT MOUNTING HOLE TO FIRST SEAT FRONT MOUNTING HOLE = 7.2 D XXX 3.2" REAR CLEARANCE ON 32" SEATS AND GREATER A/C DUCT MOUNTED IN REAR 3.5" CLEARANCE NEEDED FOR 41" SEATS 4.0" CLEARANCE NEEDED FOR 45" SEATS CLR OPG. IW-10 EVAPORATOR 10.8 HTR 84K PUMP HEATER NOT ALLOWED IN AREA FUEL FILL C L 77.1 BRAUN LIFT B B UND FLR HTR MAXIMUM HEIGHT (SEE NOTE 6) NOMINAL HEIGHT (SEE NOTE 5) Thomas NOT AVAILABLE ACROSS FROM 39" SEAT NOTES: UNIT EQUIPPED WITH OVERHEAD TRACK REINFORCEMENT UNIT IS CONFIGURED WITH A FLAT FLOOR EMERGENCY EXIT D3023xx_AG2 Model: Saf-T-Liner C2 Units Ordered: 1 Order Number: N/A Quote Number: Locality: PA Build Date: N/A GENERAL NOTES 1. SOME ITEMS, SUCH AS CV MIRRORS, ROOF LUGGAGE RACKS, AND OTHER ITEMS, ARE SHOWN IN ONE VIEW ONLY FOR CLARITY. 2. THIS DRAWING IS A REPRESENTATION ONLY AND MAY NOT HAVE ALL ITEMS REQUIRED. PLEASE REFER TO ORDER!!! 3. THE CLEARANCE BETWEEN BOTTOM OF BUS OR BOTTOM OF UNDERBODY COMPARTMENTS AND GROUND WILL VARY ACCORDING TO TIRE SIZE, BUS LOAD, AND SUSPENSION TYPE. 4. THE MAXIMUM WIDTH AT BELT LINE OVER GUARD RAILS IS 96". 5. THE NOMINAL BUS HEIGHT IS BASED ON A STANDARD BODY AND LARGEST SIZE TIRES. 6. THE MAXIMUM BUS HEIGHT IS BASED ON BDOY WITH OPTIONS SUCH AS A/C UNITS, STROBE LIGHT, LARGEST SUSPENSION ETC. 7. "OVER BUMPER" DIMENSION DOES NOT TAKE INTO ACCOUNT OPTIONS THAT MAY ADD TO THE TOTAL LENGHT OF THE BUS, SUCH AS MIRRORS, LIGHTS AND CROSSING ARMES. STEP WELL HTR SIDE ROW SPACING ROOM LEFT RIGHT THIS DRAWING AND ALL INFORMATION PROVIDED WITH IT ARE THE PROPERTY OF THOMAS BUILT BUSES, INC. ANY REPRODUCTION OR DISTRIBUTION OF THIS MATERIAL OR ANY PART WITHOUT WRITTEN PERMISSION OF THOMAS BUILT BUSES, INC. IS STRICTLY PROHIBITED. COPYRIGHT 2004 THOMAS BUILT BUSES, INC. THOMAS BUILT BUSES,INC HIGH POINT,NC TITLE PLAN AND ELEVATION BODY 221TS DRN: BY: Mike Easter SIZE DWG. NO. SCALE 3/8"=12" S Program Version:

2 LEFT SIDE RAFTER HOLES HOLE DIM "A" TYPE R SL R SL SL R SL R SL R SL R SL R SL R SL DP R1 LEFT SIDE SEAT HOLES HOLE DIM "B" RIGHT SIDE RAFTER HOLES HOLE DIM "A" TYPE R DP SL R SL R SL R SL R SL R SL R R SL DP R1 RIGHT SIDE SEAT HOLES HOLE DIM "B" RAW PART # FINISHED PART #N/A-L01 A A Hole Hole 2 1 FRONT OF BUS LEFT SIDE PARTS DATUM REFERENCE LEFT SIDE RAFTER (A - A) Hole 1 LEFT SIDE SEAT RAIL (B - B) CENTER LINE FIRST RAFTER FRONT OF BUS RIGHT SIDE PARTS CENTER LINE FIRST RAFTER RIGHT SIDE SEAT RAIL (C - C) RAW PART # FINISHED PART #N/A-R02 RAW PART # FINISHED PART #N/A-R01 RIGHT SIDE RAFTER (D - D) DO NOT MAKE MANUAL CHANGES TO DRAWING Model: Saf-T-Liner C2 Units Ordered: 1 Order Number: N/A Quote Number: Locality: PA Build Date: N/A GENERAL NOTES THIS DRAWING AND ALL INFORMATION PROVIDED WITH IT ARE THE PROPERTY OF THOMAS BUILT BUSES, INC. ANY REPRODUCTION OR DISTRIBUTION OF THIS MATERIAL OR ANY PART WITHOUT WRITTEN PERMISSION OF THOMAS BUILT BUSES, INC. IS STRICTLY PROHIBITED. COPYRIGHT 2004 THOMAS BUILT BUSES, INC. THOMAS BUILT BUSES,INC HIGH POINT,NC WOODSTOCK,CANADA SEAT RAIL - C2 1. SOME ITEMS, SUCH AS CV MIRRORS, ROOF LUGGAGE RACKS, AND OTHER ITEMS, ARE SHOWN IN ONE VIEW ONLY FOR TITLE CLARITY. 2. THIS DRAWING IS A REPRESENTATION ONLY AND MAY NOT HAVE ALL ITEMS REQUIRED. PLEASE REFER TO ORDER!!! 3. THE CLEARANCE BETWEEN BOTTOM OF BUS OR BOTTOM OF BODY 221TS UNDERBODY COMPARTMENTS AND GROUND WILL VARY ACCORDING TO TIRE SIZE, BUS LOAD, AND SUSPENSION DRN: BY: Mike Easter SIZE DWG. NO. TYPE. 4. THE MAXIMUM WIDTH AT BELT LINE OVER GUARD RAILS IS 96". SCALE 3/8"=12" S DO NOT MAKE MANUAL CHANGES TO DRAWING Program Version:

3 RAW PART CUSTOM PART QTY FRONT OF BUS Model: Saf-T-Liner C2 Units Ordered: 1 Order Number: N/A Quote Number: Locality: PA Build Date: N/A GENERAL NOTES 1. SOME ITEMS, SUCH AS CV MIRRORS, ROOF LUGGAGE RACKS, AND OTHER ITEMS, ARE SHOWN IN ONE VIEW ONLY FOR CLARITY. 2. THIS DRAWING IS A REPRESENTATION ONLY AND MAY NOT HAVE ALL ITEMS REQUIRED. PLEASE REFER TO ORDER!!! 3. THE CLEARANCE BETWEEN BOTTOM OF BUS OR BOTTOM OF UNDERBODY COMPARTMENTS AND GROUND WILL VARY ACCORDING TO TIRE SIZE, BUS LOAD, AND SUSPENSION TYPE. 4. THE MAXIMUM WIDTH AT BELT LINE OVER GUARD RAILS IS 96". 5. THE NOMINAL BUS HEIGHT IS BASED ON A STANDARD BODY AND LARGEST SIZE TIRES. 6. THE MAXIMUM BUS HEIGHT IS BASED ON BDOY WITH OPTIONS SUCH AS A/C UNITS, STROBE LIGHT, LARGEST SUSPENSION ETC. 7. "OVER BUMPER" DIMENSION DOES NOT TAKE INTO ACCOUNT OPTIONS THAT MAY ADD TO THE TOTAL LENGHT OF THE BUS, SUCH AS MIRRORS, LIGHTS AND CROSSING ARMES. THIS DRAWING AND ALL INFORMATION PROVIDED WITH IT ARE THE PROPERTY OF THOMAS BUILT BUSES, INC. ANY REPRODUCTION OR DISTRIBUTION OF THIS MATERIAL OR ANY PART WITHOUT WRITTEN PERMISSION OF THOMAS BUILT BUSES, INC. IS STRICTLY PROHIBITED. COPYRIGHT 2004 THOMAS BUILT BUSES, INC. THOMAS BUILT BUSES,INC HIGH POINT,NC TITLE PLYWOOD FLOOR BODY 221TS DRN: BY: Mike Easter SIZE DWG. NO. SCALE 3/8"=12" S Program Version:

4 * * * WEIGHT DISTRIBUTION REPORT * * * ***** WEIGHT O.K. ***** SEATINGPLAN: ORDER NO: YARD NO: BODY MODEL: 221TS CHASSIS MAKE: FLNER WHEELBASE: DATE: TIME: 15:47:41 Weight Summary Front %Front Rear %Rear Total Total Weight % % Allowables Unladen % % Base Body Body Options Base Chassis Chassis Options Passenger State Special NOTES: **************************************************************** * THE WEIGHT AND AXLE RATINGS IN THIS REPORT APPLY ONLY TO * * ORDER NO AND REFERENCE SEATING PLAN * * ANY OPTIONS EXCEEDING 20 LBS. OR SEATING PLAN CHANGES NOT ON * * THIS REPORT OR MADE AFTER THE SUBMISSION DATE AND TIME WILL * * NULLIFY RESPONSIBILITY OF THOMAS BUILT BUSES ENGINEERING * * DEPARTMENT OF THE SAFE OPERATION OF THE VEHICLE * **************************************************************** * THIS SHEET MUST ACCOMPANY ORIGINAL ORDER. SIGNATURE OF ENGINEERING APPROVAL: Diann Overcash ******************* BODY OPTIONS ******************* Option Description Front Rear Total B BELT-ELR SHOULDER/PUSH BUT LAP B " BARR-VERT,WALL MT 45"H RS RIGHT SIDE B "8DEG BARR-REV. WALL-MT 45"H LEFT SIDE B " FMVSS HIGH BACK RESTR SEAT LEFT SIDE B " FMVSS HIGH BACK RESTR SEAT LEFT SIDE B " FMVSS HIGH BACK RESTR SEAT LEFT SIDE B " FMVSS HIGH BACK RESTR SEAT LEFT SIDE B " FMVSS HIGH BACK RESTR SEAT LEFT SIDE B " FMVSS HIGH BACK RESTR SEAT LEFT SIDE B " FMVSS HIGH BACK RESTR SEAT LEFT SIDE B " FMVSS HIGH BACK RESTR SEAT LEFT SIDE B " FMVSS HIGH BACK RESTR SEAT LEFT SIDE B " FMVSS HIGH BACK RESTR SEAT RIGHT SIDE B " FMVSS HIGH BACK RESTR SEAT RIGHT SIDE B " FMVSS HIGH BACK RESTR SEAT RIGHT SIDE B " FMVSS HIGH BACK RESTR SEAT RIGHT SIDE B " FMVSS HIGH BACK RESTR SEAT RIGHT SIDE B " FMVSS HIGH BACK RESTR SEAT RIGHT SIDE D FAN-CIRC DRV S WDO HDR BLACK D RADIO-AM/FM W/CD & PAGE D HATCH-RF ESC SPEC PROLO ENG(1) D FLAPS-MUD, REAR 22.5"W D FLAPS-MUD, FRONT 16"W X 12"H Page 1

5 * * * WEIGHT DISTRIBUTION REPORT * * * D HOOKS-TOW, REAR BOLTED (2) D CONDENSER- CM D LIFT-WCH BRAUN NL919IB-2(U.S.) D BOLTED ALUM TRACK-CONT (4) PER LOC D BAR-PRY 3/4"DIA X 24"L D TRIANGLES-REFL. 3 W/BOX D DOOR-STORAGE BOX W/O GLASS D ANTENNA - RADIO SWIVEL BASE D WHEELHOUSES-REAR L&R OMIT D DOOR-ACC WITH WINDOW D PULL-ENTRANCE DOOR, EXT. ALUM D DOOR-SI LIFT RS RR 50" OPG D LPS-DOME OVER DRIVER D LPS-WARNING HALOGEN (8) D SIGN-STOP, AIR FRT #2500-1C D FENDERETTE-STL FLAT FLR 21" D VENT-STATIC PRESENT D FLR-PLYWD MARINE GRADE 221T D6047FG2SP HOSE-HTR SGL PLY NO W/H POS D HEATER-ENTRANCE DOOR STEPWELL D RAIL-ASSIST FRT ENT DR 39"W D RAIL-ASSIST FRT ENT DR RS 1"OD D HTR-RS 84,000 BTU RR FLR D ELEC-HTR U/ SEAT POS D HOLDER-STORAGE, CLIP BOARD D BACK-NATIONAL DRV S SEAT STD0TACBOX STD C2 AC ELECTRICAL BOX STDTACDUCT A/C DUCT FOR C ** STDTACIW10 C2 IW-10 EVAP. REAR MOUNT Body Option Total ******************* CHASSIS OPTIONS ******************* Option Description Front Rear Total FL AIR BRAKE PACKAGE FL-093-0BN FRT MICH XZE 255/70R22.5,16PLY FL-094-0BM RR MICH XD2 255/70R22.5,16PLY FL-101-2N2 CUM ISB 2300 RPM FL ALLI FUEL/WATER SEP HTD W/LT FL-124-1B6 LN 12V 270 AMP 4944A ALTERNATR FL SINGLE TM21 A/C COMPRESSOR FL PHILLIPS 750W/115V BLOCK HEATR FL ENG HEAT RECPT MTD BMP LH SIDE FL WEBASTO 17K BTU COOLANT HEATER FL DELCO 12V 29MT STARTER WITH M FL ,6K BTU STPWL HEAT,RH FT ENT FL GAL/227 LIT STEL TANK, BTR FL-23U GALLON DEF TANK FL-266-1AH 750 SQUARE INCH DOWN FLOW RADI FL (2)ALLIA 1131 GP31 12V 1900CCA FL-31X-021 FT BUMPER MT CROSSING ARM-AIR FL-342-1MJ ALLISON 2500 PTS AUTO TRANS FL DRIVELINE GUARD FL-400-1A5 DA-F K 71.5 KPI/3.74 AX FL MERITOR 15X5Q+ CAM FRT BRK ROC FL CONMET CAST IRON FRT BRK DRUMS ** FL-420-1C6 DA-RS K R-SRS SGL AX FL HALDEX,L-STROK, AXLE SPR CHAMB ** FL CONMET CAST IRON RR BRAKE DRUM ** FL BENDIX AD-9 AIR DRYER W/HEATER FL FRONT AC 22.5X HP,5-HAND FL REAR AC 22.5X HP,5-HAND FL ADJUSTABLE STEERING COLUMN FL TRW THP-60 POWER STEERING FL MM (199") WHEELBASE FL MM (114")RR FRAME OVERHANG ** FL-556-1C1 ONE-PIECE 14" PTD STEEL BUMPER FL FRT FRAME MOUNTED TOW HOOKS FL ,000 LB.TAPERLEAF FRT SUSPENS FL AIRLINER 23K REAR SUSPENSION FL CAB MOUNTING HOOD/COWL CHASSIS ** FL CUSTOMER FURNISHED RADIO FL AMMETER Chassis Option Total Page 2

6 * * * WEIGHT DISTRIBUTION REPORT * * * ******************* PASSENGER WEIGHTS ******************* # Option Description Side Front Rear Total 1 D BACK-NATIONAL DRV S SEAT SIDE B " FMVSS HIGH BACK RESTR SEAT L LEFT SIDE B " FMVSS HIGH BACK RESTR SEAT L LEFT SIDE B " FMVSS HIGH BACK RESTR SEAT L LEFT SIDE B " FMVSS HIGH BACK RESTR SEAT L LEFT SIDE B " FMVSS HIGH BACK RESTR SEAT L LEFT SIDE B " FMVSS HIGH BACK RESTR SEAT L LEFT SIDE B " FMVSS HIGH BACK RESTR SEAT L LEFT SIDE B " FMVSS HIGH BACK RESTR SEAT L LEFT SIDE B " FMVSS HIGH BACK RESTR SEAT L LEFT SIDE B " FMVSS HIGH BACK RESTR SEAT R RIGHT SIDE B " FMVSS HIGH BACK RESTR SEAT R RIGHT SIDE B " FMVSS HIGH BACK RESTR SEAT R RIGHT SIDE B " FMVSS HIGH BACK RESTR SEAT R RIGHT SIDE B " FMVSS HIGH BACK RESTR SEAT R RIGHT SIDE B " FMVSS HIGH BACK RESTR SEAT R RIGHT SIDE Passenger Totals Page 3