Bert Transmission Fluid Performance Test Bert Blue Magic vs. Competition
|
|
- April Patterson
- 6 years ago
- Views:
Transcription
1 Bert Transmission Fluid Performance Test Bert Blue Magic vs. Competition Aeromotive Research and Development Group / SynMax University Presentation for: Bert Blue Magic Products
2
3 Product Evaluation Test was performed on a standard Bert 2 speed Transmission 2009 Race Season Competition Races Transmission (A) Bert Blue Magic 2 Speed Fluid Transmission (B) National Brand: Royal Purple ATF
4 Left - Bert Blue Magic Center - New Bert Clutches Right Royal Purple ATF Observation: Bert Blue Magic OEM Fluid Clutch & Pressure Plate Surfaces slight wear close to new could be re-used Royal Purple ATF Clutch & Pressure Plate Surfaces very worn, dark & burned due to slippage, friction, fretting, heat & lack of fluid grip lubrication Clutches need replacement
5
6
7
8
9
10
11 Left - Bert Blue Magic Center - New Bert Clutches Right Royal Purple ATF Observation: Bert Blue Magic OEM Fluid Clutches showed little amount of paint worn from the OEM Bert Transmission original Sonnax Clutches ( this is from premium clutch fluid bite & protection) Pressure Plate Surfaces slight to little wear close to new All components could be re-used
12
13 REASON FOR PERFORMANCE SUCCESS Observation: It was further discovered that Bert Blue Magic OEM Fluid chemical engineering ACTUALLY SOAKS INTO THE CLUTCHES This allows the clutches to continually create a natural high performance BITE within a hydrodynamic barrier WITHOUT TEARING, BURNING OR DISTROYING CLUTCH SURFACE MATERIAL OR PRESSURE PLATES
14
15 Center (Left) - New Bert Clutches Right Royal Purple ATF Observation: Royal Purple ATF Clutch & Surfaces very worn, dark & burned ( due to fluid slippage and low grip which causes clutches to break and burn causing particles to float within trans) Pressure Plate burned due to slippage, friction, fretting, heat & lack of lubrication fluid grip NEED REPLACEMENT
16
17
18 Bert Transmission 2 Speed Fluid Test Conclusion: Test results & evidence over one year of racing (as shown within the attached pictures) it is clear the Bert Blue Magic fluid product (specifically designed for the Bert 2 Speed Transmission) was successful, performed well & exceeded all factory expectations. Bert Blue Magic OEM Fluid held up & did not break down under high performance ( 9,000 RPM) & extreme duty (850 HP to 900 HP+) conditions - extending service cycles of the Bert Transmission, Clutches & Pressure Plates. Discovery was that Bert Blue Magic Special Designed 2 Speed Fluid had premium performance for stay-ability to GRIP / BITE upon the clutch / pressure plate areas without slipping (which happens with Standard / Commercial Automatic Transmission Fluids ).
19 Bert Transmission 2 Speed Fluid Test Conclusion: Clutch & Pressure Plate surfaces DID NOT experience fatigue or fretting (small pieces of surface breaking off creating pits due to heat & friction ) as compared to other product used. Bert Blue Magic Fluid with Poly-X Viscosity formulation provided consistent clutch engagement & shifting stability. Bert Blue Magic Fluid anti wear formulation kept the gears, slide areas and rear needle bearings cool, lubricated & protected. Bert Blue Magic Fluid - Clutch & Pressure Plate surface area inspections indicated wear pattern & specifications were within 80% of original factory tolerances, acceptable & safe for reuse. NOTE: testing was not against any company or product used. It just happened that the performance ATF used by Transmission (B) was the Royal Purple MAX ATF.
20 Bert Blue Magic Products are Performance Tested and OEM Approved by Bert himself
21 Bert Blue Magic Grease is personally approved by Bert..
22 Bert Transmission Fluid Performance Test PRESENTATION - END Aeromotive Research and Development Group / SynMax University Presentation for: Bert Blue Magic Products
23 For Technical, Test and Brochure information on how The Aerospace Advantage for Motorsports can work for your race team or commercial needs go to:.
Power Steering Fluid Presentation. How aerospace formulation does makes a difference
Power Steering Fluid Presentation How aerospace formulation does makes a difference Increase Power Steering Performance Power Steering Unit is a small size basic hydraulic system PUMP (which creates the
More informationAerospace Advantages for. Advanced Engine Preparation Techniques. Presentation
Aerospace Advantages for Advanced Engine Preparation Techniques Presentation Aeromotive Research and Development Group through its chemical & mechanical engineering partners is becoming one the national
More informationPERFORMANCE MARKET PRESENTATION. SynMax University -
PERFORMANCE MARKET PRESENTATION SynMax University - www.synmaxperformancelubricants.com SynMax Water Kooler: Products & Packaging Available in: 16oz Concentrate ( 6X Mini Case ) 100% PREMIX Gallon ( 3X
More informationQ & A TECHNICAL BULLETIN STREET MOTOR OIL & GENERAL INFORMATION
Q: Is SynMax Superior to other motor oils? A: SynMax outperforms other synthetic and conventional oils primarily due to its proprietary Diamond Like Additive (DLA) & SynMax aerospace anti-wear technology
More informationHORSTMAN GREASED LIGHTNING CLUTCH
HORSTMAN GREASED LIGHTNING CLUTCH Horstman s Greased Lightning (GL) clutch is designed for ultra high performance, and requires expert setup and a serious commitment to maintenance. Warning!!! 1. Clutch
More information26000 Pump Series Technical Guide
The Original Engine Cooling Pump Since 1921 www.sherwoodpumps.com 26000 Pump Series Technical Guide Identification G2601-01, G2603-01 Note: G2603-01 has an integrated cam. (There is no cam screw as the
More informationDaytona Prototype - Chevy Race Engine Ford GT Supercharger Coolant System Performance & Protection Presentation
Daytona Prototype - Chevy Race Engine Ford GT Supercharger Coolant System Performance & Protection Presentation SynMax University www.synmaxperformancelubricants.com The following presentation is to provide
More informationUSER S GUIDE Manual Revision:
REKLUSE MOTOR SPORTS The Rekluse Core EXP Clutch USER S GUIDE 193-297 Manual Revision: 051509 2009 Rekluse Motor Sports Rekluse Motor Sports, Inc. 110 E. 43rd Street Boise, Idaho 83714 208-426-0659 support@rekluse.com
More informationBearing Fundamentals. Timken Training
Bearing Fundamentals Timken Training AGENDA Basic Bearing Design Ball Bearings Cylindrical Roller Bearings (CRB) Spherical Roller Bearings (SRB) Tapered Roller Bearings (TRB) 2 BASIC BEARING DESIGN Anti-Friction
More informationINSTALLATION GUIDE. Doc ID: C Doc Rev:
REKLUSE MOTOR SPORTS The Rekluse Core EXP Kit INSTALLATION GUIDE Doc ID: 191-7700C Doc Rev: 012213 2012 Rekluse Motor Sports Rekluse Motor Sports, Inc. 12000 W Franklin Rd Boise, Idaho 83709 208-426-0659
More informationATASA 5 th Study Guide. Be Certain to Read the Summary Chapter 42 Pages Automatic Transmissions & Transaxle Service 31 Points
ATASA 5 th Study Guide Be Certain to Read the Summary Chapter 42 Pages 1245 1270 Automatic Transmissions & Transaxle Service 31 Points 1. Prior to beginning any service work on a transmission, it correctly
More informationBMW BRAKE APPLICATIONS
BMW BRAKE APPLICATIONS FAST ROAD & TRACK DAY BRAKE UPGRADES BIG BRAKE KITS - RACE DISCS AND PADS PADS APPLICATION MODEL YEAR FRONT REAR 1 Series E87 118, 120 2004-0558.11-3 Series E21 320, 323 1975-82
More information18000 Pump Series Technical Guide
The Original Engine Cooling Pump Since 1921 www.sherwoodpumps.com 18000 Pump Series Technical Guide Identification G1801 and G1805 G1807 and G18071-01 G1804, G1806 and G18061-01 G1808, G18081-01, G18082-01
More informationEngine Bearings. Above: Plain Bearings Bushings and Split Insert.
Engine Bearings Engine bearings are known by a number of terms. Precision inserts, plain bearings, tri-metal bearings etc.. Bearings used around the crankshaft are split type insert bearings because the
More informationSLP PART# ATTENTION DEALER
*015-09866* Setting the World s Performance Standards 743 East Iona Road, Idaho Falls, ID 83401, (208) 529-0244 Fax (208) 529-9000 PART# 09-866 ATTENTION DEALER PLEASE PROVIDE YOUR CUSTOMER WITH THE INSTALLATION
More informationIntroduction. Lubrication Related Failures. Gear Couplings. Failure Analysis All Types (Page 1 of 7)
All Types (Page 1 of 7) Introduction A gear coupling serves as a mechanical device which connects shafts of two separate machines and accommodates small amounts of shaft misalignment. Commercial gear couplings
More information18000 Pump Series Technical Guide
The Original Engine Cooling Pump Since 1921 www.sherwoodpumps.com 18000 Pump Series Technical Guide Identification G1801 and G1805 G1807 and G18071-01 G1804, G1806 and G18061-01 G1811-01 G1808, G18081-01,
More informationOrdinary lubricants are manufactured from paraffinic base oils that use low grade crudes and undergo a 3-step refining process.
Ordinary lubricants are manufactured from paraffinic base oils that use low grade crudes and undergo a 3-step refining process. NAPHTHENE PARAFFIN Oberon sets the standards in lubrication engineering with
More information27000 Pump Series Technical Guide
The Original Engine Cooling Pump Since 1921 www.sherwoodpumps.com 27000 Pump Series Technical Guide Identification P2701-01, P2704-01, P2708-01 P2703-01, P2705-01, P2709-01 P2701X, P2702-01, P2706-01,
More informationTransmission Input Bearing Retainer
34 Transmission Input Bearing Retainer Clutch Cover / Intermediate Plate Fig 11 Failure - Damaged Sleeve Bushing Failure to center the input shaft with the sleeve of the release bearing assembly, when
More informationHeavy-Duty Off-Road. AMSOIL synthetic lubricants provide maximum protection and performance in all types of heavyduty off-road equipment.
Heavy-Duty Off-Road SYNTHETIC DIESEL OILS SYNTHETIC HYDRAULIC FLUIDS FUEL ADDITIVES AMSOIL synthetic lubricants provide maximum protection and performance in all types of heavyduty off-road equipment.
More informationFrequently Asked Questions for 3M ESPE Pentamix Systems. 1Q. What causes a non-homogeneous mixing of the material?
Technical Update Frequently Asked Questions for 3M ESPE Pentamix Systems 1Q. What causes a non-homogeneous mixing of the material? 1A. There are two potential causes. The 3M ESPE Penta Mix Tip may not
More informationMM Caster/Camber Plates, (MMCC7989)
3430 Sacramento Dr., Unit D San Luis Obispo, CA 93401 Telephone: 805/544-8748 Fax: 805/544-8645 www.maximummotorsports.com MM Caster/Camber Plates, 1979-89 (MMCC7989) IMPORTANT: The bearing used in our
More informationCROWERGLIDE AUTOMATIC CLUTCH Instruction Manual
CROWERGLIDE AUTOMATIC CLUTCH Instruction Manual Crower Cams & Equipment Co., Inc 6180 Business Center Court San Diego, CA. 92154 Phone: 619.661.6477 ext. 148 Fax: 619.690.7846 www.crower.com TABLE OF CONTENTS
More informationFAST ROAD & TRACK DAY BIG BRAKE KIT UPGRADES
FAST ROAD & TRACK DAY BIG BRAKE KIT UPGRADES PADS APPLICATION MODEL YEAR FRONT REAR 1 Series E87 118, 120 2004-0558.11-3 Series E21 320, 323 1975-82 0174.10 - E30 316, 318, 320, 323, 324, 325 1982-91 0278.06.17.44
More informationA Division of Thiessen Products, Inc.
JIMS PERFORMANCE BILLET CLUTCH KIT Important Note: Before installing this new clutch thoroughly read complete instructions. Recommended tools for Big Twin clutch and primary work: JIMS No. 971 Clutch basket
More informationMustang 7.5 Limited Slip Differential (28 Spline) V8; V6:
Mustang 7.5 Limited Slip Differential (28 Spline) 79-85 V8; 86-10 V6: Required Tools: Ratchet Wrench Torque Wrench 1/2", 5/16, 3/4", 12mm and 15mm Sockets Lug nut Wrench Dial Indicator Digital Measuring
More informationOILS & LUBRICANTS EFFECTIVE SEP 2O13 NO MATTER WHAT BRAND OF TRUCK OR 4WD, WE VE GOT IT COVERED.
OILS & LUBRICANTS EFFECTIVE SEP 2O13 NO MATTER WHAT BRAND OF TRUCK OR 4WD, WE VE GOT IT COVERED. ENGINE OIL DIESEL GOLD ENGINE OIL A high performance diesel engine lubricant designed to meet the requirements
More information2006 Hyundai Tiburon GT
Fig. 5: Identifying Clutch Cover & Disc Component With Torque Specifications REMOVAL 1. Drain the clutch fluid and transaxle gear oil. 2. Remove the transaxle assembly. 3. Insert the special tool (09411-25000)
More information2. Remove front wheels.
Read all instructions before beginning work. Following instructions in the proper sequence will ensure the best and easiest installation. Thank you for purchasing Maximum Motorsports Caster/Camber Plates.
More informationHeavy-Duty Off-Road. AMSOIL synthetic lubricants provide maximum protection and performance in all types of heavyduty off-road equipment.
Heavy-Duty Off-Road SYNTHETIC DIESEL OILS SYNTHETIC HYDRAULIC FLUIDS FUEL ADDITIVES AMSOIL synthetic lubricants provide maximum protection and performance in all types of heavyduty off-road equipment.
More informationPRO-CLUTCH TM PC-1100-CA Evo Big-Twin. chain drive primary PC-1200-CA Evo Big-Twin. chain drive primary PC-1298-CA
HOME OF PRIMO BELT DRIVES PRO-CLUTCH TM PC-1100-CA / PC-1200-CA / PC-1298-CA / 1056-0020 INSTALLATION INSTRUCTIONS PC-1100-CA 1986-1989 Evo Big-Twin chain drive primary Pro-Clutch TM Stock Clutch PC-1200-CA
More informationFailures of Rolling Bearings in Bar and Rod Mill
Case Study Failures of Rolling Bearings in Bar and Rod Mill by Christo Iliev University of Zimbabwe, Dept. of Mechanical Engineering Harare, Zimbabwe INTRODUCTION Bar and rod mills can usually be found
More informationWhere Industrial productivity Begins. How You Can Improve Productivity with Mobil SHC Series of High Performance of Lubricating Oils
Where Industrial productivity Begins How You Can Improve Productivity with Mobil SHC Series of High Performance of Lubricating Oils Introduction: We understand that you are interested in discussing how
More informationYour (Electric) Mileage May Vary. Feasibility Report- Plug in Cars
Your (Electric) Mileage May Vary Feasibility Report- Plug in Cars 3 TABLE OF CONTENTS INTRODUCTION... 1 METHODS... 2 PRICE... 3 MILEAGE... 4 CHARGING... 5 SEATING... 6 CONCLUSION... 7 RECOMMENDATION:...
More informationAUTOMATIC TRANSMISSIONS Mitsubishi F3A20 Series TRANSMISSION APPLICATION TABLE
Article Text ARTICLE BEGINNING AUTOMATIC TRANSMISSIONS Mitsubishi F3A20 Series APPLICATION TRANSMISSION APPLICATION TABLE Vehicle Application Transmission Model Colt 3-Speed (1990-94)... F3A21 Colt Vista
More informationSingle Pipe for Ski-Doo REV H.O. (For use with ported engines only) #09-870
the World s Performance Standards Single Pipe for 200-2006 Ski-Doo REV H.O. (For use with ported engines only) #09-870 Important: Read instructions carefully before installation. 1. Remove stock pipe and
More informationCATALOG AUTOMOTIVE BRAKE PRODUCTS
2017 CATALOG AUTOMOTIVE BRAKE PRODUCTS BENDIX PREMIUM COPPER-FREE* BRAKE PADS Comprehensive Coverage for Late Model Vehicles 100% Copper-free* Vehicle-Specific Friction Formulas Includes Hardware (Where
More informationLubricant ageing in wet clutch applications
Lubricant ageing in wet clutch applications Kim Berglund Supervisors: Pär Marklund Roland Larsson Industry partners: BorgWarner Statoil Lubricants Wet clutch - Engaged Input shaft Output shaft 1 Wet clutch
More informationINSTALLATION GUIDE CRF150R Manual Revision:
REKLUSE MOTOR SPORTS The z-start Pro Clutch INSTALLATION GUIDE CRF150R 191-810 Manual Revision: 032508 2002 Rekluse Motor Sports Rekluse Motor Sports, Inc. 110 E. 43rd Street Boise, Idaho 83714 208-426-0659
More informationDRUM BRAKE RIMS Periodic inspection of drum brake rims is necessary to determine indications of uneven or excessive wear. In general, brake rim failures other that regular wear are caused by brake linings
More informationINSTALLATION & USER S GUIDE
REKLUSE MOTOR SPORTS The Rekluse Core EXP Kit with Adjustable Slave Cylinder INSTALLATION & USER S GUIDE Doc ID: 191-7704A Doc Rev: 102915 OVERVIEW This kit replaces the OEM core clutch components including
More informationSAGINAW P-SERIES PUMP INSTALLATION
SAGINAW P-SERIES PUMP INSTALLATION WARNING Failure to read and follow these instructions will void any warranty, can cause severe damage to power steering components and premature failure. Pump internals
More informationPASSENGER CAR MOTOR OILS
PASSENGER CAR MOTOR OILS FULL SYNTHETIC / EURO / Full Synthetic SAE 0W-20 dexos1 TM Gen 2 A, C, F, G, H Full Synthetic SAE 5W-20 A, C, F, G, H Full Synthetic SAE 5W-30 dexos1 TM Gen 2 A, B, C, F, G, H
More informationRevision 4 May 23, 2018
Kalsi Seals Handbook Chapter C16 Plastic lined Kalsi Seals Revision 4 May 23, 2018 Individual chapters of the Kalsi Seals Handbook are periodically updated. To determine if a newer revision of this chapter
More informationMercedes Manual Transmission Fluid Change How Often Do You
Mercedes Manual Transmission Fluid Change How Often Do You Transmission repair costs are expensive, whether it's to rebuild or replace one. If you notice fluid under your car, you should have the transmission
More informationVibrating Mechanism Bearings
Vibrating Mechanism Bearings Vibrating equipment represents some of the most demanding applications for anti-friction roller bearings. This type of equipment includes screens, vibrating finishing mills,
More informationAST Suspension Product Line-up
2000 AST 2000 series With the 2000 series AST wants to offer a product for a new type of customer. This series is specially setup for tuners and show cars. The performance is up to the AST specifications
More informationOWNER S MANUAL. Part# Revision
REKLUSE MOTOR SPORTS Pro Start Clutch Harley-Davidson OWNER S MANUAL Part# 191-681 Revision 020807 2002 Rekluse Motor Sports Rekluse Motor Sports, Inc. 110 E. 43 rd Street Boise, Idaho 83714 208-426-0659
More informationG Series Technical Guide 9959 Impeller
The Original Engine Cooling Pump Since 1921 www.sherwoodpumps.com G Series Technical Guide 9959 Impeller Identification G30-2 & G30-2B G21 G9901 & G9903* K75 & K75B J70 G15 *(G9901-6 1 /2 pulley; G9903-4
More informationCargo Control. Tie Down Straps & Transport Chain
Cargo Control Tie Down Straps & Transport Chain CARGO CONTROL WARNINGS & INFORMATION Quality assurance and general information: We at Super Slings Inc. offer a full line of ratchet straps, tie downs, e-track
More informationPONTIAC Late Model (with 11 Bolt Water Pump)
1969-79 PONTIAC Late Model (with 11 Bolt Water Pump) S-Drive Pulley Kit INSTALLATION INSTRUCTIONS Before beginning the installation, please note: Please read all of the instructions thoroughly before beginning
More informationMotor Homes. Power Protection Fuel Economy ACCESSORY PRODUCTS SYNTHETIC MOTOR OILS
Motor Homes SYNTHETIC MOTOR OILS ACCESSORY PRODUCTS Power Protection Fuel Economy When you put the best into your motor home, you can expect the best from it. AMSOIL-engineered lubricants help protect
More informationFitting-removal and maintenance
Fitting-removal and maintenance Fitting of bearings 136 General rules 136 Fitting principles 136 Hot fitting 137 Press fitting (or with anti-rebound hammer) 138 Adapter sleeves 139 Removal of bearings
More informationStellar 4 Clutch Manual
INSTRUCTIONS Stellar 4 Clutch Manual Thank you for choosing Tomar products; we are proud to be your manufacturer of choice. Please read this instruction sheet carefully before beginning installation, and
More information1998 F-150/250 Workshop Manual
Page 1 of 8 SECTION 205-02B: Rear Drive Axle/Differential Ford 9.75-Inch Ring Gear DISASSEMBLY AND ASSEMBLY Procedure revision date: 03/07/2000 Differential Case and Ring Gear Traction-Lok Special Tool(s)
More informationHigher performance. through longer life of gear units
Higher performance through longer life of gear units High-performance gear oils that extend gear life and increase productivity Castrol offers you a complete range of world-class gear oils and product
More informationDurapower. II Raw Edge FHP Belt Light Duty Fractional Horsepower Belt.
Durapower II Raw Edge FHP Belt 178 1 2 Energy efficient Reduces maintenance and downtime Assures smoother, quieter operation with less vibration Lengthens belt life and improves system-wide performance
More informationInstallation Instructions for TCI Turbo 700R TCI Turbo 700R
Installation Instructions for TCI 378805 Turbo 700R4 1982-1984 TCI 378905 Turbo 700R4 1985-1993 KIT INTRODUCTION Read all instructions first to familiarize yourself with the parts and procedures. Work
More informationCHAPTER 5 FAILURE ANALYSIS OF MAIN BEARING
93 CHAPTER 5 FAILURE ANALYSIS OF MAIN BEARING 5. 1 BEARING LAYOUT The two main bearings are used in the crankshaft assembly, one bearing is at the drive end side of the crankshaft and another bearing is
More informationINSTALLATION & USER S GUIDE
REKLUSE MOTOR SPORTS The Rekluse Auto-Clutch Kit for BMW F650, F700, F800 Parallel Twins INSTALLATION & USER S GUIDE Doc ID: 191-6305A Doc Rev: 082517 OVERVIEW This kit replaces the OEM clutch pack with
More informationRetro it Steering Column
Retro it Steering Column INSTALLATION INSTRUCTIONS for 1976-86 CJ5 & CJ7 FOR PART NUMBER S: 1520800010, 1520800020, 1520800051, 1526800010, 1526800020, 1526800051 S I NCE 1986 Instruction # 8000000010
More informationGM 4L80-E, 4L85-E SURE CURE KIT
GM 4L80-E, 4L85-E SURE CURE KIT PART NUMBER SC-4L80E INSTALLATION GUIDE Parts are labeled here in order of installation. See page 2 for details on Sure Cure kit contents. See Sure Cure instruction booklet
More informationIRS Racing Brake Kit (MMBAK-15, -16)
3430 Sacramento Dr., Unit D San Luis Obispo, CA 93401 Telephone: 805/544-8748 Fax: 805/544-8645 www.maximummotorsports.com IRS Racing Brake Kit (MMBAK-15, -16) Floating rotors (MMBAK-16 ONLY) can move
More informationDriver Driven. InputSpeed. Gears
Gears Gears are toothed wheels designed to transmit rotary motion and power from one part of a mechanism to another. They are fitted to shafts with special devices called keys (or splines) that ensure
More informationGM 4L80-E, 4L85-E SURE CURE KIT
GM 4L80-E, 4L85-E SURE CURE KIT PART NUMBER SC-4L80E INSTRUCTION BOOKLET Parts are labeled here in order of installation. See page 2 for details on Sure Cure kit contents. See Sure Cure instruction booklet
More informationAdvanced Auto Tech. ASE A 1 Test Preparation Engine Upper End Theory & Service
Advanced Auto Tech ASE A 1 Test Preparation Engine Upper End Theory & Service Torque to yield bolts stretch to their yield point when tightened and should not be reused. True or False The sealing lip &
More informationIRP Auto Clutch Manual
IRP Auto Clutch Manual KTM 65 SX 2009-2013 P/N 920400 10-12 Forward This manual provides instructions for installing the IRP Auto Clutch into the 2009-2013 KTM 65 SX Engineered for MX racing as well as
More informationFocus on Training Section: Unit 3
All Pump Types Page 1 1. Title Page Unit learning objectives Understand the properties of common types of fuels Understand the principals of filtration Be able to make recommendations regarding fuel storage
More informationSLP PART # ATTENTION DEALER
PART #09-8000 ATTENTION DEALER PLEASE PROVIDE YOUR CUSTOMER WITH THE INSTALLATION AND INSTRUCTION DATA THAT IS SUPPLIED IN THIS PACKET FOR THIS PRODUCT. Before you begin, please read the following: The
More informationDiesel Power. Advanced synthetic technology to protect today s most demanding diesels. SYNTHETIC DIESEL OILS. FuEL.
Diesel Power SYNTHETIC DIESEL OILS DrIvETraIN FLuIDS FuEL additives Advanced synthetic technology to protect today s most demanding diesels. Synthetic Diesel Oils AMSOIL introduced the world s first synthetic
More informationElectronic Cautions. Resetting Shift Adapts. Post-Adapt Road Test. Solenoids. 5th Off Off ON ON ON ON
Toyota u5e-u250e zip Kit PaRT NUMBER u5e-u250e-zip Installation & TESTING BOOKLET Torque Specifications Pan Filter to Valve Body 8 ft-lb Oil Pan to Transaxle 9 in-lb Component Pack Clearance Forward (C)
More informationDESIGN. I. Loading and Speed
DESIGN D.Wren designs Solid Rubber & Duramatic Tyres as per customer s requirements at its computer aided design facility based on the following data. Selection of Solid Tyres by the users should be based
More informationINSTALLATION & USER S GUIDE
REKLUSE MOTOR SPORTS TorqDrive Manual Clutch Kit for Harley-Davidson Big Twin Motorcycles INSTALLATION & USER S GUIDE Doc ID: 191-2841A Doc Rev: 082417 OVERVIEW This kit is compatible ONLY with the OEM
More informationAn alternative approach to Synthetic Wind Turbine Gear Oil formulation. Phil Hutchinson. Evonik Oil Additives, Singapore.
An alternative approach to Synthetic Wind Turbine Gear Oil formulation. Phil Hutchinson. Evonik Oil Additives, Singapore. 1 Synthetic Industrial Gear-Oils / Wind Turbine Gear-oils (WTGO) MT Synthetics
More informationINSTALLATION & USER S GUIDE
REKLUSE MOTOR SPORTS The Rekluse Core EXP Kit for Kawasaki KX80/85/100 OVERVIEW INSTALLATION & USER S GUIDE Doc ID: 191-7742A Doc Rev: 073015 This kit replaces the OEM core clutch components including
More informationRETRACTABLE RAIL CLAMPS BROCHURE
RETRACTABLE RAIL CLAMPS BROCHURE 2015 RRC Brochure Page 1 RELIABILITY THROUGH QUALITY AND INNOVATION WHERE TO USE (APPLICATIONS) Storm Brakes are parking and safety devices which provide friction forces
More informationHEADCASE PROJECT MIATA THE NASA RULEBOOK ON SPEC MIATA CYLINDER HEAD MODIFICATIONS IS CLEAR AND CONCISE. HERE S WHAT THE RULES LOOK LIKE IN THE METAL.
PROJECT MIATA Story and Photos by Brett Becker HEADCASE 44 THE NASA RULEBOOK ON SPEC MIATA CYLINDER HEAD MODIFICATIONS IS CLEAR AND CONCISE. HERE S WHAT THE RULES LOOK LIKE IN THE METAL. Here s the reality
More informationINSTALLATION GUIDE. Clutch Cable Actuated Models Manual Revision:
REKLUSE MOTOR SPORTS The z-start Pro Clutch INSTALLATION GUIDE Clutch Cable Actuated Models 191-800 Manual Revision: 061810 2002 Rekluse Motor Sports Rekluse Motor Sports, Inc. 110 E. 43rd Street Boise,
More informationLIMITED SLIP DIFFERENTIAL INSTALLATION
Installation of the limited slip gear can be done with axle out of car or with car lifted to gain access from underneath. Refer to repair manual for proper lifting instructions if car is to be lifted.
More informationGM ALLISON 6 SPEED LCT-1000/2000/2400 CO-PILOT Parts list
2006-10 GM ALLISON 6 SPEED LCT-1000/2000/2400 CO-PILOT Parts list Co-Pilot Computer (1) 601-800-4308 Solenoid Block (1) 601-109-4308 External Wiring Harness (1) 601-011-4308 Internal Wiring Harness (1)
More informationCVT VALVE BODY COMMON WARRANTY COMPLAINTS AND TIPS
CVT VALVE BODY COMMON WARRANTY COMPLAINTS AND TIPS Disclaimer: Please consult with a qualified auto technician before attempting to perform any diagnosis, repairs, or modifications based on this guide.
More information5.7L & 6.4L Chrysler Hemi Phaser Limiter Kit #5761. Limiter 1 Tool 1 Screw 1. Tools Required T-25 Torx bit 3/16" Allen
1 INSTRUCTIONS 5.7L & 6.4L Chrysler Hemi Phaser Limiter Kit #5761 Thank you for choosing products; we are proud to be your manufacturer of choice. Please read this instruction sheet carefully before beginning
More informationRektol Classic Product Line
Rektol Classic Product Line Engine Oils SAE API Epoch* Application Rektol Running-In Oil 30 SA/SB universal Rektol Running-In Oil, formulated for use during the running in period for re-built or overhauled
More informationHPI Tutorial - How to improve the lifetime of your Savage Spur Gear
HPI Tutorial - How to improve the lifetime of your Savage Spur Gear Related Parts - 76937 - SPUR GEAR 47 TOOTH (1M) 76939 - SPUR GEAR 49 TOOTH (1M) 76942 - SPUR GEAR 52 TOOTH (1M) Savage spur gears are
More informationPRESEASON CHASSIS SETUP TIPS
PRESEASON CHASSIS SETUP TIPS A Setup To-Do List to Get You Started By Bob Bolles, Circle Track Magazine When we recently set up our Project Modified for our first race, we followed a simple list of to-do
More informationTBR TYRE 2018/19 QINGDAO HANS TYRE CO.,LTD
TBR TYRE C A T A L O G U E QINGDAO HANS TYRE CO.,LTD No.72-1, Songling Rd., Laoshan Dist., Qingdao 266101, China Tel: +86-532-81927691 Email: info@hanstyre.com Web: www.hanstyre.com 2018/19 ABOUT US COMPANY
More informationAUTOMOTIVE IGNITION SYSTEMS
AUTOMOTIVE IGNITION SYSTEMS ABSTRACT This report describes the differences and similarities between a 1964 Mustang traditional ignition system and that of my 2014 Jeep. To help you understand the process
More informationRekluse Motor Sports. The z-start Clutch CRF 250X. Installation Guide Copyright 2002 Rekluse Motor Sports z-start Revision RMS116 CRF 250X
Rekluse Motor Sports The z-start Clutch CRF 250X Installation Guide Copyright 2002 Rekluse Motor Sports z-start Revision 3.000 RMS116 CRF 250X 191-216 Manual Revision: 103105 Rekluse Motor Sports, inc.
More informationPRODUCTS. Snowmobiles. AMSOIL synthetic lubricants provide maximum performance and protection for all makes of snowmobiles.
Snowmobiles SYNTHETIC 2-STROKE OILS SYNTHETIC 4-STROKE OILS ACCESSORY PRODUCTS AMSOIL synthetic lubricants provide maximum performance and protection for all makes of snowmobiles. Snowmobiles are meant
More informationHAMMER ABUSE/NEGLECT CAUSE AND EFFECT. Piston impacting catch cap Critical safety feature! Shut down hammer and inspect if struck (See below)
HAMMER ABUSE/NEGLECT CAUSE AND EFFECT Below are some of the most common types of hammer abuse/neglect and the typical causes and evidence of damages that occur from them. Piston impacting catch cap Critical
More informationFOR COMMERCIAL ON-HIGHWAY HEAVY-DUTY PROTECTION CHOOSE DELO
FOR COMMERCIAL ON-HIGHWAY HEAVY-DUTY PROTECTION CHOOSE DELO DELO DELIVERS CONFIDENCE TABLE OF CONTENTS Introduction 3 Engine Oils 4-5 Transmission Fluids 6 Gear Lubricants 7 Greases 8 Coolant/Antifreeze
More informationCOMER SW80 TECHNICAL SPECIFICATIONS
VERSION 3 / 2013 UPDATED AUGUST 20 th, 2013 DOCUMENT UPDATE SCHEDULE It is certified that the updates listed below have been approved by the Australian Karting Association and have been incorporated into
More informationSLP Single Pipe for Polaris 600 H.O. Fusion/RMK/Switchback/Shift (Carb Models)
SLP Single Pipe for 2006-09 Polaris 600 H.O. Fusion/RMK/Switchback/Shift (Carb Models) Part # 09-634 Kit Contents: 2-7 Insulated Heat Tape 1-1/8 Pipe Adjustment Washer 4-30 Reflective Heat Tape 1 - Wire
More informationSTARTER - HITACHI Isuzu Trooper II DESCRIPTION TESTING STARTER PERFORMANCE TESTS Starters HITACHI. Isuzu
STARTER - HITACHI 1986 Trooper II 1984 Starters HITACHI DESCRIPTION Starter is a conventional 12-volt, 4-pole brush-type motor, with direct or reduction gear drive. The starter-mounted solenoid shifts
More informationPRESSURE TEST. Checks for leaks at fuel line, inlet needle, & fuel pump body Hook tester up to tank inlet line. Pump tester up to 10psi (.
PRESSURE TEST #91024 Pressure/Vacuum Tester Pressure Setting Checks for leaks at fuel line, inlet needle, & fuel pump body Hook tester up to tank inlet line. Pump tester up to 10psi (.7 bar) ALL tests
More informationTUBE SADDLE Tech Tips
TUBE SADDLE Tech Tips Flat Tire Forensics 101: Part 2 Tech Tips is a free publication intended to provide useful information to all riders and racers. We encourage you to pass it along to all your riding
More informationCaterpillar Lube Oil. DEO Diesel Engine Oil. FDAO Final Drive/ Axle Oil. HYDO Hydraulic Oil. GO Gear Oil. NGEO Natural Gas Engine Oil
Cat Fluids 1 Caterpillar Lube Oil DEO Diesel Engine Oil HYDO Hydraulic Oil NGEO Natural Gas Engine Oil TDTO Transmission and Drive Train Oil FDAO Final Drive/ Axle Oil GO Gear Oil MTO Multipurpose Tractor
More informationCLUTCH CONTENTS SERVICE DIAGNOSIS. (a) Worn or damaged disc assembly. (b) Grease or oil on disc facings. (c) Improperly adjusted cover assembly.
CLUTCH CONTENTS -GROUP 6 Page CLUTCH HOUSING ALIGNMENT... 6 CLUTCH PEDAL FREE PLAY 1 CLUTCH RELEASE BEARING 5 CLUTCH RELEASE FORK... 5 CLUTCH SERVICING 2 PILOT BUSHING CRANKSHAFT TO TRANSMISSION DRIVE
More informationINSTALLATION GUIDE. Doc ID Revision
REKLUSE MOTOR SPORTS INSTALLATION GUIDE OVERVIEW Doc ID 191-6300 Revision 013017 Read the separate included Safety Information document before operating the vehicle with the product installed. If you are
More information